Norac 7465BC-LP Installation guide







SevereTerrainOption

LowProfileBrackets

InstallationManual



ReorderP/N:7465BC‐LP‐INSTRevC(SevereTerrainOptionLowProfileBrackets)



NOTICE:NORACSystemsInternationalInc.reservestherighttoimproveproductsandtheirspecificationswithoutnoticeandwithouttherequirementtoupdate

productssoldpreviously.Everyefforthasbeenmadetoensuretheaccuracyoftheinformationcontainedinthismanual.Thetechnicalinformationinthismanual

wasreviewedatthetimeofapprovalforpublication.



WWW.NORAC.CA

PRECISIONDEFINED



Contents



Introduction..........................................................................................................................1



PartsOverview......................................................................................................................2



UltrasonicSensorInstallation................................................................................................4



ElectricalInstallation.............................................................................................................8



SoftwareSetup......................................................................................................................9



CableDrawings....................................................................................................................10





WWW.NORAC.CA

PRECISIONDEFINED





Page1

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

1 Introduction

Pleasetakethetimetoreadthismanualcompletelybeforeattemptingtoinstallthesystem.Athorough

understandingofthismanualwillensurethatyoureceivethemaximumbenefitfromthesystem.

Yourinputcanhelpmakeusbetter!Ifyoufindissuesorhavesuggestionsregardingthepartslistorthe

installationprocedure,pleasedon’thesitatetocontactus.



Everyefforthasbeenmadetoensuretheaccuracyoftheinformationcontainedinthismanual.Allparts

suppliedareselectedtospeciallyfitthesprayertofacilitateacompleteinstallation.However,NORACcannot

guaranteeallpartsfitasintendedduetothevariationsofthesprayerbythemanufacturer.

Pleasereadthismanualinitsentiretybeforeattemptinginstallation.



Donotusehighspeedpowertools/drillswheninstallinghardware.



TheuseofdielectricgreaseisnotrecommendedonanyNORACelectricalconnections.



ToensureallstainlesssteelhardwaredoesnotgallorseizeapplyalightcoatingofthesuppliedPermatex

Anti‐seizegreasetoallthreadedpartsuponinstallation.PermatexAnti‐seizelubricantispreferred,butother

similaranti‐seizeproductsmaybeused.

WWW.NORAC.CA

PRECISIONDEFINED





Page2

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

2 PartsOverview

2.1. KitOverview



Figure1:SevereTerrainParts



*SevereTerrainOptionKitsforApachesprayersincludetwospacers(B12).





WWW.NORAC.CA

PRECISIONDEFINED





Page3

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

2.2. ListofParts

ItemPartNumberNameQuantity

B0544706‐01KITCABLETIEBLACK10PCS21IN150PCS7.5IN1

B2044971SENSORMOUNTINGBRACKETLOWPROFILE16GA2

C0643210‐10CABLENETWORK18AWG10M2

E0750300MAXSENSOR2

E1043760NETWORKCOUPLER3‐WAY2

M027465BC‐LP‐INSTMANUALINSTALLATIONSEVERETERRAINOPTIONLOWPROFILE 1



2.3. AdditionalPartsforApacheSprayers

ItemPartNumberNameQuantity

B1244747SPACER2INSQUARETUBING8IN2



WWW.NORAC.CA

PRECISIONDEFINED





Page4

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

3 UltrasonicSensorInstallation

3.1. UltrasonicSensorSerialNumberArrangement

Wheninstallingtheultrasonicsensors,startwiththesmallestserialnumberontheleft‐handside,andproceed

tothelargestserialnumberontherighthandside.Eachultrasonicsensorhasaserialnumberstampedonthe

sensorhousing.

ApplyalightcoatingofthesuppliedPermatexAnti‐seizegreasetoallthreadedpartsuponinstallation.



Figure2:SensorSerialNumberArrangement

 Onlythecomponentsshowninblackareincludedinthiskit.



WWW.NORAC.CA

PRECISIONDEFINED





Page5

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

3.2. WingSensorInstallation

1. Thesensorbracketshouldbeorientedforward(aheadoftheboom).

2. Mountthesensorbracketsontotheboomhalfwaybetweenthetipandcenterofthesprayer.

3. MounttheMAXsensorintothesensorbracket.TorquetheM8nutto108in‐lb(12Nm).Runthesensor

cableeitherthroughholeinthebackorthroughthesidecut‐outandbehindthebracket.Ensurethecable

isclearofmovingpartsandwillnotbedamagedduringfolding.

  

Figure3:BracketMountingExample

4. IfinstallingtheSevereTerrainOptiononanApachesprayer,spacers(B12)mustbeusedtomountthe

bracketonthelowestpartoftheboom.Thespacermustbeplacedbetweenthelowestpartoftheboom

andthebackfaceofthebracket.Theplatewouldthenbeplacedbehindtheboom.(Figure4)

Figure4:ApacheSpacerPlacementonSevereTerrainPackage





Front

Spacer

(B12)

Front

WWW.NORAC.CA

PRECISIONDEFINED





Page6

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

3.3. UltrasonicSensorMountingGuidelines

Thefollowingguidelineswillensureoptimalsensorperformanceandpreventsensormeasurement.

1. Initslowestposition,thesensormustbe9inches(230mm)ormorefromtheground.

2. Ensurethattherearenoobstructionswithina12inch(300mm)diametercircleprojecteddirectlybelow

thecenterofthesensor.

3. Thesensorshouldbeapproximatelyverticalatnormaloperatingheights.



Figure5:SensorMountingGuidelines



Figure6:BracketMountingGuidelines





WWW.NORAC.CA

PRECISIONDEFINED





Page7

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

3.4. LowProfileBracketMountingGuidelines

1. Minimizethedistancebetweentheboltstopreventbendingthebracketandpreventthebracketfrom

looseningovertime.

2. Ensurethebracketismountedtightagainstthebottomoftheboom,minimizingthedistancebetweenthe

boomstructureandtheangledflange.



Aproblemcanariseifasensorisnotmountedcorrectly.Thismayonlybecomeapparentoncethecontrol

systemisswitchedfromsoiltocropmode.

Becarefulthatthesensorbracketdoesnotcollidewithanyotherpartoftheboomwhentheboomisfolded

totransportposition.Ifpossible,mountthesensorbracketswhiletheboomsarefoldedtoensuretheywill

notcauseinterference.



WWW.NORAC.CA

PRECISIONDEFINED





Page8

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

4 ElectricalInstallation

1. Removethe2‐waycouplerwithterminator(E20)fromtheoutersensorandinstallitattheinnersensor.

2. Installthe3‐waycoupler(E10)attheoutersensor.PlugtheexistingCANbuscable(C05)andthesensor

cableintothe3‐waycoupler.

3. ConnecttheCANbuscable(C06)betweenthe2‐waycouplerwithterminator(E20)andthe3‐waycoupler

(E10).

Onlythecomponentsshowninblackareincludedinthiskit.



Figure7:ElectricalInstallation



WWW.NORAC.CA

PRECISIONDEFINED





Page9

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

5 SoftwareSetup

1. Startupthesprayerandtestthesprayer’sfunctionality.Thecontrolpaneldoesnotneedtobepowered

onfortheoriginalswitchestofunction.



Confirmthatthecablingandhosesareagreeabletotheentirerangeofmotion.

2. Ifanyfunctionsdonotwork,reviewthismanualtocheckforproperinstallation.

3. Turnonthepowerforthecontrolpanelusingtheswitchonthesideofthechassis.

4. RefertotheSprayHeightControlOperator’sManualtorunanautomaticinstall.



WWW.NORAC.CA

PRECISIONDEFINED





Page10

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

6 CableDrawings

6.1. ITEMC06:43210‐10‐CABLENETWORK18AWG‐10M





WWW.NORAC.CA

PRECISIONDEFINED





Page11

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

 Notes



TOPCONAgricultureCanada

3702KinnearPlace

Saskatoon,SKS7P0A6

TOPCONAgricultureAmericas

W5527Hwy106

FortAtkinson,WI53538

TOPCONPrecisionAgricultureEurope

Avenidadelaindustria,

35,TresCantos,España

Spain

Support

Phone:8889799509

E‐mail:[email protected]

Web:www.norac.ca





Norac 7465BC-LP Installation guide

Related papers

Other documents