Norac 7470BC-01 Installation guide







MainLiftOption

44743Bracket

InstallationManual



ReorderP/N:7470BC‐01‐INSTRevB(MainLiftOption–44743Bracket)



NOTICE:TopconAgricultureCanadareservestherighttoimproveproductsandtheirspecificationswithoutnoticeandwithouttherequirementtoupdate

productssoldpreviously.Everyefforthasbeenmadetoensuretheaccuracyoftheinformationcontainedinthismanual.Thetechnicalinformationinthismanual

wasreviewedatthetimeofapprovalforpublication.



WWW.NORAC.CA

PRECISIONDEFINED



Contents



Introduction..........................................................................................................................1



MainLiftSensorInstallation..................................................................................................2



ElectricalInstallation.............................................................................................................4



SoftwareSetup......................................................................................................................5



CableDrawings......................................................................................................................6





WWW.NORAC.CA

PRECISIONDEFINED





Page1

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

1 Introduction

Pleasetakethetimetoreadthismanualcompletelybeforeattemptingtoinstallthesystem.Athorough

understandingofthismanualwillensurethatyoureceivethemaximumbenefitfromthesystem.

Yourinputcanhelpmakeusbetter!Ifyoufindissuesorhavesuggestionsregardingthepartslistorthe

installationprocedure,pleasedon’thesitatetocontactus.



1.1. ListofParts

ItemPartNumberNameQuantity

B1144743BRKT,SENSORMAINLIFTUC1

C0743220‐01CBL,NETWORK14AWG1M1

E0750300MAXSENSOR‐CLIP/FOAM1

E1243764NETWORKCOUPLER2‐WAY1

M037470BC‐01‐INSTMANUALINSTALLATIONMAINLIFTOPTION–44743BRACKET1



Everyefforthasbeenmadetoensuretheaccuracyoftheinformationcontainedinthismanual.Allparts

suppliedareselectedtospeciallyfitthesprayertofacilitateacompleteinstallation.However,Topconcannot

guaranteeallpartsfitasintendedduetothevariationsofthesprayerbythemanufacturer.

Pleasereadthismanualinitsentiretybeforeattemptinginstallation.



Donotusehighspeedpowertools/drillswheninstallinghardware.



TheuseofdielectricgreaseisnotrecommendedonanyTopconelectricalconnections.



ToensureallstainlesssteelhardwaredoesnotgallorseizeapplyalightcoatingofthesuppliedPermatex

Anti‐seizegreasetoallthreadedpartsuponinstallation.PermatexAnti‐seizelubricantispreferred,butother

similaranti‐seizeproductsmaybeused.

WWW.NORAC.CA

PRECISIONDEFINED





Page2

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

2 MainLiftSensorInstallation

1. Assemblethemainliftsensorbracket(B11)asshowninFigure1.



Figure1:MainLiftBracketAssembly

2. Thereareavarietyofwaystomountthemainliftbracketonmostsprayers.Thebracketshouldposition

thesensorapproximatelyinthecenterofthesprayer,forwardoftheboom.Anexampleofthismounting

isillustratedinFigure2.

3. Mounttheultrasonicsensortothemainliftbracket.TorquetheM8nutto108in‐lb(12Nm).Runthe

sensorcabledownthecenterofthemainliftbrackettube.

 

Figure2:ExampleMountingoftheMainLiftBracket



Avoidmountingthemainliftsensoroverornearawheel‐track.Measurementsfromthewheel‐trackdonot

provideanaccuratecropheightandwillcausemeasurementandcontrolerror.

Ensurethebracketdoesnotcollidewithanyotherpartofthesprayerthroughoutthefullrangeofmainlift

motion.

WWW.NORAC.CA

PRECISIONDEFINED





Page3

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

2.1. UltrasonicSensorMountingGuidelines

Thefollowingguidelineswillensureoptimalsensorperformanceandpreventsensormeasurementerror.

1. Initslowestposition,thesensormustbe9inches(23cm)ormorefromtheground(A).

2. Thecenterlineoftheacousticconeshouldbeapproximatelyverticalatnormaloperatingheights(A).

3. Thebottomofthesensormustbeatleast9inchesinfrontofthespraynozzlesandboomstructure(B).

(Thisdoesnotapplyforthemainliftsensor)

4. Thebottomofthesensormustbeatleast9inchesabovethespraynozzles(C).

5. Ensuretherearenootherobstructionswithina12inch(23cm)diametercircleprojecteddirectlybelow

thesensor(D).



Figure3:SensorMountingGuidelines



WWW.NORAC.CA

PRECISIONDEFINED





Page4

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

3 ElectricalInstallation

1. Connectthemainliftsensortothe8‐waycoupler(E11)usingcableC07andthe2‐waycoupler(E12).Cable

C07anditemE12maynotbeneededifthe8‐waycouplerismountedcloseenoughtothemainliftsensor.



Figure4:ElectricalConnections

Onlycomponentsshowninblackareincludedwiththiskit.

WWW.NORAC.CA

PRECISIONDEFINED





Page5

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

4 SoftwareSetup

1. Startupthesprayerandtestthesprayer’sfunctionality.Thecontrolpaneldoesnotneedtobepowered

onfortheoriginalswitchestofunction.



Confirmthatthecablingandhosesareagreeabletotheentirerangeofmotion.

2. Ifanyfunctionsdonotwork,reviewthismanualtocheckforproperinstallation.

3. Turnonthepowerforthecontrolpanelusingtheswitchonthesideofthechassis.

4. RefertotheSprayHeightControlOperator’sManualtorunanautomaticinstall.



WWW.NORAC.CA

PRECISIONDEFINED





Page6

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

5 CableDrawings

5.1. ITEMC07:43220‐01‐CBL,NETWORK14AWG1M





WWW.NORAC.CA

PRECISIONDEFINED





Page7

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

 Notes



TOPCONAgricultureCanada

3702KinnearPlace

Saskatoon,SKS7P0A6

TOPCONAgricultureAmericas

W5527Hwy106

FortAtkinson,WI53538

TOPCONPrecisionAgricultureEurope

Avenidadelaindustria,

35,TresCantos,España

Spain

Support

Phone:8889799509

E‐mail:[email protected]

Web:www.norac.ca





Norac 7470BC-01 Installation guide

Related papers

Other documents