WaterLogic WL100 Operating, Installation And Service Manual

Waterlogic Commercial Products, LLC

11710 Stonegate Circle

Omaha, NE 68164

(800) 288-1891 www.waterlogic.us

Tech Portal Website: www.techportal.waterlogic.com

WL100

OPERATING, INSTALLATION, AND SERVICE MANUAL



WL100Operating,Installation,andServiceManual Page2Revision:5‐20‐2016

WL100OPERATING,INSTALLATION,ANDSERVICEMANUAL



CongratulationsonyourchoiceoftheWaterlogicWL100WaterTreatmentSystem.TheWL100

WaterTreatmentSystemdispensescold,andhot.EveryWL100WaterTreatmentSystemincludes:



Bio‐CoteAnti‐MicrobialProtection



Filterconfigurationcanbeoptimizedforallwaterconditions



TheWaterlogicWL100WaterTreatmentSystemprovidesexceptional

qualityandgreattasting

waterwitheveryuse.



TABLEOFCONTENTS



 FeaturesandBenefits.................................................................3

 Certifications...............................................................................4

 IntroductionandSafetyAlertSymbols.......................................5

 SafetyPrecautions......................................................................6

 ModelandPartDesignations......................................................7

 Specifications..............................................................................7

 OperatingInstructions................................................................8

 HotTankPrinciplesofOperation................................................9

 FlowDiagram............................................................................10

 DisablingEnergyStarSleepMode............................................11

 ChangingHotWaterModetoAmbient....................................12

 AdjustColdSetPoint................................................................13

 Pre‐InstallationProcedures......................................................14

 DrainingProcedures..................................................................17

 InstallationProcedures.............................................................21

 ServiceRequirements...............................................................23

 ReplacementComponents.......................................................24

 HotTankDescalingInstructions...............................................25

 ResettingtheHotTankOverloadorHighLimitSafety.............27

 HeaterCircuit–HotTankWiring..............................................29

 CounterTopDrawingsandPartLists……………………..................30

 TowerDrawingsandPartsLists................................................36

 ElectricalDiagrams....................................................................42

 Troubleshooting........................................................................43

 Warranty..................................................................................65

WL100Operating,Installation,andServiceManual Page3Revision:5‐20‐2016

WL100FEATURESANDBENEFITS



Ambient,ColdandHotWater

Ambient,ColdandHotWaterSelectionstomeetawiderangeofcustomerdemands.Cold

temperatureisadjustable.



HighVolumeStorageandWaterCapacity

WL100WaterTreatmentSystemshave2Liter(0.5Gallon)Coldtanksand1.6Liter(0.4Gallon)Hot

Tanks.



BioCote®Anti‐MicrobialProtection

Plasticsurfacessurroundingdispensingareasanddriptrayareinfusedwithan

exclusivesilveradditivecalledBioCote®.Silverisanaturalanti‐microbialthat

inhibitsthegrowthofmicroorganismsprovidingadditionalsurfaceprotection.



RecessedFaucet

BioCote®Faucet(Spigot)isrecessedintounittoprotectfromcrosscontamination.



LargeDispenseArea

8.5inchdispenseheighttoaccommodatemostcupandbottlesizes.



ChildSafeguard

TheWL100WaterTreatmentSystemrequiresusertoselectandholdbothRedButtonstoprevent

accidentaldispensingofhotwater.



EnergySavingSleepMode

EnergysavingSleepModecanbeprogrammedtoturnoffheaterafter3ofinactivityandcanbeshut

off.



AuxiliaryPort

AuxiliaryPortattherearoftheCounterTopModelstofeedCoffeeMachinesorotherappliances.



StainlessSteelTanks

Peaceofminddrinkingfromhighquality,sealedstainlesssteelreservoirs.



AdvancedFiltration

TheWL100WaterTreatmentSystemTowerequippedwitheasyaccess

filtermountingtraythatallowsdealerstooptimizefilterconfigurationfor

allwaterconditions.



HighCapacityRemovableDripTray

HighCapacityRemovableDripTraywithBioCote®protection.Driptrayis

two‐pieceforeasycleaningandcomesconfiguredwithoptionaldrainport.



WL100Operating,Installation,andServiceManual Page4Revision:5‐20‐2016

WL100CERTIFICATIONS



Waterlogicwatertreatmentsystemshavebeentested,andcertifiedtorigorousNSFandUL

Standards.WebelievethatperformancetestingandcertificationsvalidateWaterlogicasaworld‐

leaderinwatertreatmentsystems.

WL100WaterTreatmentSystemCertificationsInclude

UL399–CertifiedDrinkingWaterCooler

IntertekLabs(ETL)CertifiedtheWL100WaterTreatmentSystemstoANSI/UL399

StandardforDrinkingWaterCoolers.



BPAFree‐WaterlogictestsforBPAanddeclaresthatallofitsproductsareBisphenol‐A

FREEandcontainnoharmfulBPAplastics.



NSF/ANSI‐61–CertifiedDrinkingWaterSystemComponents

TheWL100WaterTreatmentSystemhasbeentestedandcertifiedbyTheWater

QualityAssociation(WQA)toNSF/ANSI‐61,Section9.



EnergyStarCertified

TheWL100WaterTreatmentSystemhasbeentestedandcertifiedtotheEnergyStar,a

USEnvironmentalProtectionAgency(EPA)programthathelpsourcustomerssave

moneyandprotectourclimatethroughsuperiorenergyefficiency.



WaterlogicmanufacturingiscertifiedtoISO9001–QualityManagement

Systems(certifiedbyMoodyInternational).ISO9001isthe

internationallyacceptedstandardforwellmanagedorganizationsthat

haveadoptedthekeyqualitymanagementprinciplestoitsoperationsto

bringconsistentqualityproductsandacultureofcontinuous

improvement.

SafeDrinkingWaterAct

WaterlogicwatertreatmentsystemsconformtotheSafeDrinkingWaterAct(SWDA)“lead‐free”

amendmenteffectiveJanuary4,2014.

ADACompliance

Waterlogicdesignswatersystemstobeergonomicandmeetthehigheststandardsavailablewhile

consideringusebydisabledandphysicallyimpairedusers.SeeourADAPositionStatementfor

futuredetails.

WL100Operating,Installation,andServiceManual Page5Revision:5‐20‐2016

INTRODUCTION



CarefullyreadandfollowallinstructionstoensureproperandefficientoperationofyourWL100

WaterTreatmentSystem.ContactWaterlogicoranAuthorizedWaterlogicDealerifyouhaveany

questions.



WaterlogicandAuthorizedWaterlogicDealersemploytrainedservicepersonnelwhoare

experiencedintheinstallation,functionandrepairofWaterlogicequipment.Thispublicationis

writtenforusebythesequalifiedindividuals.Waterlogicencouragesuserstolearnaboutproducts,

however,webelievethatproductknowledgeandserviceisbestobtainedbyconsultingWaterlogic

oranAuthorizedWaterlogicDealer.



Waterlogicwatertreatmentsystemsshouldbecombinedwithselectedwatertreatment

componentstocreateasystemspecificallytailoredforeachapplicationbytrainedandqualified

personnel.



ProductsmanufacturedandmarketedbyWaterlogicanditsaffiliatesareprotectedbypatents

issuedorpendingintheUnitedStatesandothercountries.



Waterlogicreservestherighttochangethespecificationsreferredtointhisliteratureatanytime,

withoutpriornotice.ChangesormodificationsnotexpresslyapprovedbyWaterlogiccouldvoidthe

warrantyanduser’sauthoritytooperatetheequipment.



SAFETYALERTSYMBOLS



Readandfollowallsafetyinformationcarefully.Thesignalwordsusedinthismanualareselectedas

shownbelowandbasedonanassessmentofthedegreeofpotentialinjuryordamage(severeor

minor)andtheoccurrenceofinjury(definitelyoccursorhasthepotentialtooccur)whenthe

warning

isignored:



DANGER!

Indicatesasituationwhich,whennotavoided,resultsindeathorsevereinjury.



WARNING!

Indicatesasituationwhich,whennotavoided,hasthepotentialtoresultindeathorsevere

injury;and/orseverepropertydamage.





CAUTION!

Indicatesasituationwhich,whennotavoided,resultsorhasthepotentialtoresultinminor

injury;and/orminorpropertydamage.



WL100Operating,Installation,andServiceManual Page6Revision:5‐20‐2016

SAFETYPRECAUTIONS



Basicsafetyprecautionsshouldbefollowed,includingthefollowing:



DANGER!Ifincorrectlyinstalled,operatedormaintained,thisproductcancausedeathor

severeinjury.Thosewhoinstall,operate,ormaintainthisproductshouldbetrainedinitsproper

use,warnedofitsdangers,andshouldreadtheentiremanualbeforeattemptingtoinstall,

operate,ormaintainthisproduct.



WARNING!Unitistobeusedforitsintendedpurposeasdescribedinthismanual,and

untrainedindividualswhousethismanualassumetheriskofanyresultingpropertydamageor

personalinjury.



WARNING!HOTWATER.UnitproducesHotWaterupto87

C(189

F).Waterabove52°C

(125°F)cancausesevereburnsorscalding.Keepunauthorizedpeopleandchildrenawayfromthe

unittoavoidaccidentaldispensingofhotwater.Childrenshouldnotusewithoutsupervision.



DANGER!ELECTRICALSHOCKHAZARD.Alwaysunplugfrompowersupplypriortoservicing

equipmenttopreventelectricalshock.



WARNING!Thissystemtobeusedforwateronlyandisnotintendedforusewherewateris

microbiologicallyunsafeorwithwaterofunknownqualitywithoutadequatedisinfectionbefore

orafterthesystem.Thesystemisdesignedforthesupplementalbactericidaltreatmentofeither

treatedanddisinfectedpublicdrinkingwater,orotherdrinkingwater,whichhasbeentestedand

deemedacceptableforhumanconsumptionbythestateorlocalhealthagencyhavingjurisdiction.

Thesystemisdesignedtoreducenormallyoccurringnon‐pathogenicornuisancemicroorganisms

only.Systemisnotintendedfortreatmentofcontaminatedwater.



WARNING!DispenserCouldTiporFallcausingSeriousInjury.Alwaysinstallunitonafirm,flat,

andlevelsurfaceandsecuretheWL100WaterTreatmentSystemtothebasecabinetwiththe

screwprovidedtolockthecomponentstogether.Neverplaceheavyitemsontopofunitandnever

climb,stand,orhangonunitorstoragecabinettopreventinjuryanddamage.





CAUTION!INDOORUSEONLY.Donotinstalloutdoorsorwhereunitisindirectsunlight.Donot

installwhereambienttemperaturegoesbelow10°C(50°F)orabove36°(97°F).Avoidhigh

humidityandmoisture.Productlifeandperformancewillbeimpactedandwarrantycouldbe

voided.

 

WL100Operating,Installation,andServiceManual Page7Revision:5‐20‐2016

MODEL/PARTDESIGNATIONS



BRANDNAME DESCRIPTION

MODEL‐

PARTNUMBER

WL100CounterTop

WaterlogicWL100CounterTop‐ColdandHot 12‐CHCM

F‐100‐M‐HC‐TT‐CS‐WLU

WL100Tower

WaterlogicWL100Tower‐ColdandHot 12‐CHC

F‐100‐FS‐HC‐TT‐CS‐WLU



SPECIFICATIONS

ITEM WL100CounterTop WL100Tower

WaterConnection ¼”QuickConnect

ColdWaterTemperature

–

FactorySetPoint41°‐ 5°C

Adjustableto34° - 54° F.(1.1°‐12.2°C)

HotWaterTemperature 85°C(185°F)

HotWaterManualReset

Overload

105°C(221°F)

RecommendedService

Pressure

40‐60psi(275‐414kPa)–UsePressureRegulator

MaximumServicePressure 100psi(689kPa)–UsePressureRegulator

RatedServiceFlow 1.89Litersperminutes(0.5gallonsperminute)

EnvironmentalTemperature35°‐100°F(2°‐37°C)

Heater 500W

RefrigerantGas R134a,40g,1.41ounces R134a,45g,1.59ounces

R134aPressures High(230psi),Low(90psi)



SHIPPINGSPECIFICATIONS

ITEM WL100CounterTop WL100Tower

Width/Depth/Height

13.5”x16”x17.75”

(34cmx41cmx

45cm)

13.5”x16” x40.5”(34cmx41cmx

103cm)

Weight(dry) 40pounds(18kg) 50pounds(23kg)



ELECTRICALSPECIFICATIONS

ELECTRICALSUPPLY 120V/60Hz,1PH 15AmpService

COMPONENT POWER(approximate) AMPDRAW(approximate)

Heater 504 4.2Amps

Compressor 168 1.4Amps

WL100TOTAL 672 5.6Amps



#WL100CounterTopis17.75in.tallandmaynotfitbetweencountertopsandcabinets‐Checkinstallationtoensureadequateclearance.

WL100Operating,Installation,andServiceManual Page8Revision:5‐20‐2016

OPERATINGINSTRUCTIONS



TheabovepictureshowsfrontLCDdisplayandcontrolpanelfortheWaterlogicWL100Water

TreatmentSystem.



ForColdWater PresstheBlue‐ColdWaterSelectButton

ForHotWater

PressthetwoRed‐HotWaterSelectButtonsatthe

sametime.



ThisisaSafetyFeaturetopreventaccidentaldispensing

ofhotwater.





ColdWaterDispense

PressBothforHot

WaterDispense

WL100Operating,Installation,andServiceManual Page9Revision:5‐20‐2016

HOTTANKPRINCIPLESOFOPERATION



AllWaterlogicHotTankshaveabuiltinVentor

ExpansionChamberinthetopofthetankexceptfor

WL270(GF)units.



TheVentChamberallowsforexpansionofthewater

whenitisheated.



Thechambersareseparatedbyawelded‐intank

baffle.



Wateralwaysflowsintothebottomofthetankand

outthetoptothefaucet.



Thehottankoutlettubehasarestrictorinitsbase.

Thisensuresthereservoirisalwaysfullbyallowing

morewaterinthanout.



Thereisasmallholeinthesideofthetankoutlettube

thatallowsairandwatertopassintothevent

chamberasitisheated.



Waterintheventchamberissuctionedbackthrough

theoutlettubeventholewhenwaterisdispensed.



Expansionofwaterasitisheatedinthereservoirwill

pushthewateroutthefaucetwhentheoutlettube

ventholebecomespluggedwithdebrisorscale.



ThesmallOutletVentHoleissusceptibletoscalebuild

upandisakeyindicatorthatdescalingisrequired.



Itiscriticaltodescalethehottankthroughthevent

lineandoutletlineonaregularbasistopreventthis

problem.



Descalingthroughtheinletand/oroutletlinesonly

willnotcleantheventchamberandoutletventhole

properly.





WL100Operating,Installation,andServiceManual Page10Revision:5‐20‐2016

WL100WATERFLOWDIAGRAM



WL100Operating,Installation,andServiceManual Page11Revision:5‐20‐2016

PROGRAMMINGINSTRUCTIONS



DISABLINGENERGYSAVINGSLEEPMODE

AllWL100WaterTreatmentSystemscomefromthefactorywithEnergySavingSleepMode

engagedtomeettheEnergyStarCertificationrequirements.EnergySavingSleepModedisables

theheatercircuitiftheunithasnotbeenusedforacontinuous3hourorlongerperiod.

Selectinganybutton"wakesup"theWL100WaterTreatmentSystemandturnstheheater

circuitbackon.TheHotTankwilltypicallytakelessthan10minutestoheatthewaterfrom

ambienttothe85°C(185°F)setpoint.



UnplugPowerCordandremoveTopCovertoaccessEnergySaverPCB.



WL100WaterTreatmentSystemcomeswiththe

EnergySavingSleepMode“ON”



PCBJumperJP7inthe"ON"position(Pin1and2)



DeactivatetheEnergySavingSleepModebymoving

PCBJumperJP7tothe"OFF"position(Pins2and3).



EnergySaverPCB–P/NEN‐6131–WLCPPN20‐0075

PinNumbers

1 2 3

2

3

1

2

WL100Operating,Installation,andServiceManual Page12Revision:5‐20‐2016

PROGRAMMINGINSTRUCTIONS



CHANGINGHOTWATERMODETOAMBIENTWATER



AllWL100WaterTreatmentSystemshavefactorysettingtoHotandCold,whichcanbechanged

toAmbientandColdWatersettings.



UnplugPowerCordandremoveTopCovertoaccessEnergySaverPCB.



Onthe

EnergySaverPCB,MovetheJumperonJP9fromPins1and2toPins2and3.



TheWL100WaterTreatmentSystemcomeswith

HotandColdWaterfactorysettings.



PCBJumperJP9inpositions‐Pin1and2



ChangetoAmbientandColdbymovingPCB

JumperJP9topositions–Pin2and3



1 2

2 3

EnergySaverPCB–P/NEN‐6131–WLCPPN20‐0075

1 2 3

PinN

WL100Operating,Installation,andServiceManual Page13Revision:5‐20‐2016



ADJUSTINGCOLDSETPOINT



ThecoldsetpointcanbeadjustedbyaccessingtheColdThermostat

adjustmentscrewUndertheDecalattherearoftheunit.

ThiswillNOTVoidtheWarrantyasthecurrentDecalstatesonthebackof

theunit.Thefactorysetpointis5°C(41°F)thatisindicatedwiththedot

onsheetmetalaroundtheadjustmentscrewandbehindthedecal.

Turningtheadjustmentscrewclockwiselowersthesetpointtemperature

andtherangeisapproximately‐6.7°C(20°F)thruthefullrangeof

adjustment(~7:00tothe~5:00positions).



Youshouldbeabletoturnthescrewfromthefactorysetpoint5°C(41°F)

(~12:00position)about45degreesclockwise(2:30onaclock)toreduce

thesetpointtemperatureby‐14.4°C(6°F)andachievethe1.7–2.2°C(35‐

36°F)settingyouarelookingfor.



Trialthisbyadjustingandthenmeasurethewatertemperature10‐15

minutesafterthecompressorshutsoff(coldestpoint)toverifytheset

pointtemperature.



Eachunitwillvaryslightly.Trynottogomuchpastthe“3:00position”to

avoidfreezingthecoldtankasshownabove.



FUTUREPRODUCTIONWILLINCLUDECOLDTHERMOSTATCOVERLABEL

PartNumber:LP‐0326‐L00‐00/WLCPPNLP‐0326



WL100Operating,Installation,andServiceManual Page14Revision:5‐20‐2016

PRE‐INSTALLATIONPROCEDURES



DANGER!ELECTRICALSHOCKHAZARD.

Onlyqualifiedpersonnelwhohavereadandunderstandthisentiremanualshouldattemptto

install,orservicethisunit,failuretodosocouldresultindeathorseriousinjury.DONOTplug

intoanelectricalsupplyuntilspecificallyinstructed.



WARNING!ALWAYSSANITIZEBEFOREUSE.

Sanitizebeforeusetoeliminateanypotentialmicrobiologicalcontaminates.



MaterialsNeeded:

 PersonalProtectiveEquipment.RubberorNitrileSafetyGlovesandProtectiveEyewear

 PhillipsScrewdriver

 TemperatureGauge

 WaterPitcherorContainertocollectwaterfromthefaucet

 19Liter(5gallon)containerordrainbasin

 Sanitizer‐HouseholdBleach(5.25%SodiumHypochlorite)orCitric AcidBasedCleaner

 ¼”PlasticTubing,atleast4feetinlength,andassorted¼”quickconnectfittings

 TDSMeterandTestStripsformeasuringchlorine–Optional

 SanitizingCartridge–anemptyWaterlogicFilterwithcartridgeremoved



1. UnpacktheWaterlogicWL100WaterTreatmentSystemandcheckexteriorfordamage.





Sanitizing



SanitizeusingaHouseholdBleach(5.25%SodiumHypochloritesolution)orotherapproved

cleanerthroughoutthecoldwatercircuit.Followallinstructionsonthesanitizerandflushwith

freshwaterthroughthefaucetuntilodorandtasteisacceptable.



WARNING!USEPROPERPERSONALPROTECTIVEEQUIPMENT

Alwaysensureproperventilationanduseproperpersonalprotectiveequipmentsuchasgloves

andeyeprotectionwhenusingchemicals.RefertoMaterialSafetyDataSheetforspecific

requirementsofeachchemicalproduct.Takeallnecessaryprecautionstopreventsanitizerfrom

contactingeyes,clothing,andanyothersurfacesincoulddamage(carpets).





2. Put5Millimeter(1Teaspoon)ofsanitizerperdirectionsoruseBleachSolution(5Millimeter=1

Teaspoon=1/6ounces=½capfull)ofhouseholdbleach(SodiumHypochlorite5‐10%

Concentration)intheSanitizingCartridge.Alwaysensuresanitizeriscompatiblewithstainless

steelandacetylplastic.



3. Connectsanitizingcartridgetoinletwatersupplyandconnecttoinletbulkheadfittingonbackof

unit.Turnonwatersupply.



4. ConnectpowertotheWL100WaterTreatmentSystem.DONOTTURNONRED

HEATER–COMPRESSORSWITCHATTHISTIME. RedCompressor/HeaterSwitch

mustbeintheO=OFFposition.



WL100Operating,Installation,andServiceManual Page15Revision:5‐20‐2016



FilltheColdCircuitwithSanitizer



5. DepresstheMainDispensingButtonontheFrontControlPaneluntilcoldwater/sanitizing

solutioncomesoutthefaucet.NOTE:Containeranddrainbasinwillberequiredtocatchthe

waterfromthefaucet.



WARNING!UsePersonalProtectiveEquipment.GlovesandEyeProtectionRequired.Thefirst

8or11Liters(2or3gallons)ofwaterwillcontainconcentratedsanitizer.Useextremecare!



6. TurnoffwatersupplyandremoveSanitizingCartridgefrominletwatersupply.Reconnectwater

supplytoinletbulkheadfitting.



FlushFilters



CAUTION!FILTERFLUSHREQUIRED.



WL100WaterTreatmentSystemsarenotsuppliedwithfilters.Filtersshouldbeconfiguredto

optimizeyoursystem.Filtersneedtobeconfiguredandspecifiedtodothejobgiventhelocal

waterconditions,usage,maintenanceschedule,andplacementrestrictions.



Inorderforourfilterstoperformasrepresentedandtoprovidethebestqualitywaterpossible,it

isessentialthatfiltersbereplacedperiodically.Thefrequencyoffilterchangesdependsuponyour

waterqualityandyourwaterusage.Forexample,ifthereisalotofsedimentand/orparticlesin

yourwater,thenyouwillhavetochangeyourfiltersmorefrequentlythanalocationwithlittleto

nosediment.Besuretoreplaceyourfilterswheneveryounoticeadeclineintheperformance,

whetheritisadropinflowrateand/orpressureoranunusualtasteinthewater.



7. Flushthoroughlyperfiltermanufacturers’recommendationwithfreshwatertodrain.



8. Onceflushed,installthefilters.Followingtheflowdirectiononthefilter.



NOTE:



Filtersshouldnotbeflushedpriorto24hoursbeforeinstallationtolimitMicrobial

Growth.



9. ConnectWL100WaterTreatmentSystemtopower.



CAUTION!NEVERTURNONHEATERBEFOREFILLINGHOTTANK.



RedCompressor/HeaterSwitchmustbeintheO=OFFpositionwhiletheHot

Tankisempty.Damagecouldoccurwithinoneminuteandtheoverload(high

limit)willrequiremanualresetifHeateristurnedonwithanemptyHotTank.



WL100Operating,Installation,andServiceManual Page16Revision:5‐20‐2016



FlushingtheSanitizerfromtheMachine



10. Placeapitcher,catchbasin,orothercontainerunderthefaucetoftheWL100WaterTreatment

System.



11. FlushtheColdTank.Runseveralgallonsofwaterthroughthefaucetbydispensingcoldwaterto

diluteandremovethesanitizerfromthecoldcircuit.Chlorineteststripscanbeusedtoevaluate

thewater.



12. Oncethesanitizerodor/taste hasbeenflushedoutofthecoldsideofthemachinethe

sanitizationprocessfortheColdCircuitisnowcomplete.



FilltheHotTank



13. PresstheHotWaterSelectButton,followedbytheMainDispensingButtontofilltheHotTank.

Waterwilldispensefromthefaucetoncethehottankisfull.Flushuntilwaterisclear.



WARNING!HOTCIRCUITISNOTSANITIZED.

WaterintheHotCircuitisnotsanitaryuntilthetemperatureexceeds77°C(171°F)foratleast

5minutes.



CompressorTest



14. SwitchRedCompressor/HeatertoonI=ONposition.AlwaysensureTanksarefull

ofwaterbeforeturningontheHeaterortheOverload(HighLimit)opensand

requiremanualreset.IftheWireCondenseratbackoftheWL100Water

TreatmentSystemiswarm,therefrigerationsystemisworking.



15. Oncethemachinereachesitstargettemperature,thecompressorwillshutoff.Drawaglassof

coldwaterandverifyithaschilledtopropertemperature.



HeaterTest



16. Alwaysensuretanksarefullofwaterbeforeturningontheheaterortheoverload(highlimit)will

openandrequiremanualreset.Itwilltaketheheaterapproximately10minutestoheatthe

waterfromambient75°F(24°C)tothefactorysetpointof185°F(85°C).Dispenseacupofhot

watertoensurethetemperature/odor/tasteisacceptable.



WARNING!HOTWATER.UnitproducesHotWaterupto87

C(189

F).Waterabove52

C

(125

F)cancausesevereburnsorscalding.Hotwatershouldbedispensedcarefullyintoinsulated

containertoavoidinjury.





WL100Operating,Installation,andServiceManual Page17Revision:5‐20‐2016

WL100COUNTERTO PDRAININGINSTRUCTIONS



DrainingNotes



DraintheWL100WaterTreatmentSystemfortransportation.



WARNING!STOREUNITEMPTY.ALWAYSSANITIZEBEFOREREUSE.

Theunitmustbecompletelydrainedandsealedbeforestoringtoavoidstagnationandreduce

microbialgrowth).



PriortodrainingtheHotTank,turnofftheRedHeaterandCompressorSwitch–

O=OFF,anddispense2Liters(½Gallon)ofhotwaterfromtheWL100Water

TreatmentSystem.Ashotwaterisdispensedfromthefaucetoftheunit,colder

waterwillbeintroducedintotheHotTank.SincetheRedHeaterandCompressor

Switchisturnedoff,theHeaterwillnotenergizeandheattheincomingtapwater.

Followingthisprecautionpreventsexposingpersonnelandequipment(drains,catchbasin,etc.)

fromscaldinghotwater.



DisableColdandHotTanks



1. TurnofftheRedHeaterandCompressorSwitchtodisabletheheaterandcompressor.

RedCompressor/HeaterSwitchmustbeintheO=OFFposition



2. Dispense2liters(½Gallon)ofwaterthroughtheHotTanktocoolthewater

temperatureintheHotTankandavoidburns.



WARNING!HOTWATER.UnitproducesHotWaterupto87

o

C(189

F).Waterabove52

C

(125

F)cancausesevereburnsorscalding.Hotwatershouldbedispensedcarefullyintoinsulated

containertoavoidinjury.



TurnoffWaterSupplyandBleedWaterPressure



3. IsolateWL100WaterTreatmentSystemfromfeedwaterbyturningoffthesupply.



4. Dispensecoldstillwatertorelieveanypressurebuiltupinthesystem.



DraintheColdWaterTankandCircuit



5. RemoveTopCover.



WL100Operating,Installation,andServiceManual Page18Revision:5‐20‐2016



6. RemoveFrontPanel.Remove2Phillipscrewssecuring

FrontPanel.



7. UnseatFaucetAssemblyfromFrontPanel.



8. UncliptheWhite,RedandBlackwireconnectorsfrom

PCBtoallowFrontCovertoberemoved.



9. RemoveFrontPanel



10. Disconnecttubingtoallowwaterto

drainfromtheWL100Water

TreatmentSystem. 



Catchwaterinapitcher,catchbasin

orothercontainer.



11. Dryinside oftheWL100Water

TreatmentSystem.



12. ReplaceFrontPanel.



WL100Operating,Installation,andServiceManual Page19Revision:5‐20‐2016



WL100TOWERDRAININGINSTRUCTIONS



DrainingNotes



DraintheWL100WaterTreatmentSystemfortransportation.



WARNING!STOREUNITEMPTY.ALWAYSSANITIZEBEFOREREUSE.

Theunitmustbecompletelydrainedandsealedbeforestoringtoavoidstagnationandreduce

microbialgrowth).



Priortodrainingthehottank,turnofftheRedHeaterandCompressorSwitch(O=

OFF)anddispense2liters(½Gallon)ofhotwaterfromtheWL100Water

TreatmentSystem.Ashotwaterisdispensedfromthefaucetoftheunit,colder

waterwillbeintroducedintotheHotTank.SincetheRedHeaterandCompressor

switchisturnedoff,theHeaterwillnotenergizeandheattheincomingtapwater.

Followingthisprecautionpreventsexposingpersonnelandequipment(drains,catchbasin,etc.)

toscaldinghotwater.



RedCompressor/HeaterSwitchmustbeintheO=OFFposition.



DisableColdandHotTanks



1. EnsuretheRedHeaterandCompressorSwitchisoff(O=OFF)todisabletheheater

andcompressor.



2. Dispense2liters(½Gallon)ofwaterthroughthehottanktocoolthewater

temperatureinthehottankandavoidburns.



3. WARNING!HOTWATER.UnitproducesHotWaterupto87

C(189

F).Waterabove52°C

(125°F)cancausesevereburnsorscalding.Hotwatershouldbedispensedcarefullyintoinsulated

containertoavoidinjury.



4. Dispensecoldstillwatertorelieveanypressurebuiltupinthesystem.



DraintheColdWaterTankandCircuit



5. RemovetheLowerFrontPanelto

accesstankfeedlines.



WL100Operating,Installation,andServiceManual Page20Revision:5‐20‐2016

6. RemovetheHotandColdwatersupplylinesfromtheinletlinesolenoids.



7. DisconnecttanklineoutletlinesfromHotandColdsolenoidstodrainintobasinorbucket.



8. TurnoutletfittingsoutwardtoavoidwaterspillingontotheCompressor.



9. ReconnectTubing

intoOutletElbowsoncedrained.



10. Dryinside ofBottomTrayasnecessary.



11. ReplaceLowerFrontPanel





WaterLogic WL100 Operating, Installation And Service Manual

Related papers

Other documents