WaterLogic BLUPURA FIZZ 80 User manual

Brand: WaterLogic

Model: BLUPURA FIZZ 80

Type: User manual

BLUPURAFizz80Manual Page4‐Revision:11‐2‐2018

SAFETYALERTSYMBOLS



Readandfollowallsafetyinformationcarefully.Thesignalwordsusedinthismanualareselectedas

shownbelowandbasedonanassessmentofthedegreeofpotentialinjuryordamage(severeor

minor)andtheoccurrenceofinjury(definitelyoccursorhasthepotentialtooccur)whenthe

warningisignored:



DANGER!

Indicatesasituationwhich,whennotavoided,resultsindeathorsevereinjury.



WARNING!

Indicatesasituationwhich,whennotavoided,hasthepotentialtoresultindeathorsevere

injury;and/orseverepropertydamage.





CAUTION!

Indicatesasituationwhich,whennotavoided,resultsorhasthepotentialtoresultinminor

injury;and/orminorpropertydamage.



SAFETYPRECAUTIONS



Basicsafetyprecautionsshouldbefollowed,includingthefollowing:

EnsureallLocal,State,andFederalLawsandCodesincludinghealthandsafetyguidelinesaremet

wheninstallingWaterlogicEquipment.Onlyqualifiedservicetechniciansshouldattempt

installationandserviceofWaterlogicEquipment.Alwaysreadtheentireoperatinginstructions

beforeusingtheapplianceandsavetheseinstructionsforfutureuse.



DANGER!Thisproductcancausedeathorsevereinjuryifincorrectlyoperated,installedor

maintained.Theinstallation,maintenance,sanitizingandanyrepairmustbeperformedby

qualifiedpersonstrainedbyWaterlogicInternationalortheirapproveddistributorsonly.Donot

removeanypanelorcovertoprotectagainstelectricalshockandexposuretoUVradiation.



DANGER!ELECTRICALSHOCKHAZARD.Alwaysuseadedicatedandproperlygroundedoutlet.

Unitshouldbeprotectedbyground‐faultcircuitinterrupter(GFCI)orresidualcurrentdevice(RCD)

havingaratedresidualoperatingcurrentnotexceeding30mA.UseonlyWaterlogicsupplied

powercord.Neveruseextensioncordsorpowerstripstoconnectunit.Donotuseifthepower

supplycordisdamaged.Alwaysunplugfrompowersupplypriortoservicing.



WARNING!AUTHORIZEDUSEONLY.Thisapplianceistobeusedforitsintendedpurposeas

describedinthismanualanduntrainedindividualswhousethismanualassumetheriskofany

resultingpropertydamageorpersonalinjury.Thisappliancecan’tbeusedbychildrenandpersons

withreducedphysical,sensoryormentalcapabilitiesorlackofexperience.



WARNING!DONOTOPERATEIFDAMAGED.Unplugandisolatewatersupplyifabnormal

conditionsexist.ContactWaterlogicorauthorizeddealerforrepair,service,andinstallationto

avoidhazards.



WARNING!CONNECTTOPOTABLEWATERSUPPLY.Thissystemistobeusedforwateronlyandis

notintendedforusewherewaterismicrobiologicallyunsafeorwithwaterofunknownquality

withoutadequatedisinfectionbeforeorafterthesystem.



BLUPURAFizz80Manual Page5‐Revision:11‐2‐2018

WARNING!TIPHAZARD.Dispensercouldtiporfallcausingseriousinjury.Alwaysinstallunitona

firm,flat,andlevelsurfaceandsecureunittocabinet,wall,orfloorifneeded.Neverplaceheavy

itemsontopofunitandneverclimb,stand,orhangonunitorstoragecabinettopreventinjury

anddamage.



WARNING!UNITISHEAVY.TWOPERSONLIFTREQUIRED.Transportunitemptyandalwaysuse

materialhandlingequipmentortwopeoplewithproperliftingtechniquetoreduceinjuryrisk.



WARNING!STOREANDTRANSPORTUNITEMPTY.ALWAYSSANITIZEBEFOREUSE.

Theunitmustbecompletelydrainedbeforestoringtoavoidstagnationandreduce

microbiologicalcontamination(potentialbacterialgrowth).Alwayssanitizebeforeuseto

eliminateanypotentialmicrobiologicalcontaminates.



CAUTION!INDOORUSEONLY.IntendedforHouseholdUse.Neverexposetodirectsunlight,

heatsources,orambientairtemperatureabove37°C(100°F)orbelow2°C(35°F).Installindoors

andkeepunitawayfromexcessivehumidity.Neverexposetofreezingtemperatures.Ensure

thereisadequateclearancearoundtheunittoallowrefrigerationsystemcondensertodissipate

heat.Warmerenvironmentsrequiremoreclearancearoundtheunit.Minimumclearancearound

allsurfacesofthemachineis2‐inches.Installswheretheambienttemperatureexceeds27°C

(80°F),requireaminimumof4‐inchesclearanceforproperheatdissipationandefficient

operation.



CAUTION!USEAWATERPRESSUREREGULATOR.Waterlogicwillnotberesponsibleforinjuryor

damagecausedbyexcessivewaterpressure.Inputorfeedpressuremustbe40psito60psi.Be

awareofanypotentialpressuresurgescausedbybuilding/municipalpumpingstations.



CAUTION!USEUVSTABILIZEDSUPPLYLINES.Feedtheunitwithapotableambientorcold

watersupplyonly.Feedwaterover37°C(100°F)candamagethetreatmentcomponents.Water

blockdevicesandexternalleakdetectorsarestronglyrecommended.Locatetheunitascloseto

thewatersupplyandtheelectricalconnectionsaspossible.Locatetheunitasclosetothewater

supplyandtheelectricalconnectionsaspossible.Immediatelyisolateorclosewatersupplyvalve

andcontactservicerepresentativeifleakisnoticed.



ContactWaterlogicforassistanceorhelpfindinganAuthorizedServiceRepresentative.



BLUPURAFizz80Manual Page6‐Revision:11‐2‐2018

BLUPURAFEATURESANDBENEFITS



ColdandColdSparklingWater

ColdandColdSparklingWatersetpointsareprogrammabletomeetawiderangeofcustomer

demandswithhighcapacityof14Liters(3.7Gallons).



HighOutputofColdandSparklingWater

HighlyinsulatedIceBankhasaCoolingcapacityof80Litersperhour(20Gallonsperhour)withan

outputofcoldandsparklingwaterof45Liters(12Gallons)ofcontinuoussupply.



DispenseFlowRate

DispenseflowrateisadjustabledirectlyontheColumnTapforcustomerease.



LargeDispenseArea

12.6inchdispenseheightwitharemovabledriptray.



StateoftheArtTechnology

The

BLUPURAFIZZ80WaterTreatmentSystem

supplyheadbringscontemporarystyleandstate‐of‐the‐

arttechnologytocommercialwaterdispenserscombiningprofessionalperformancewithamodern,

sleekdesign.



ModernDesignUsingStrongMaterials

Amoderndesignusingstrongmaterialsandafrontplexiglasspanelwithelegantlighting.



NoAccidentalWaterLeakage

TheColumnTapselfclosestoavoidaccidentalwaterleakageinadditiontoacompensatorto

regulatetheflowofeachspout.



RecyclableMaterials

The

BLUPURAFIZZ80WaterTreatmentSystem

andColumnTaparemadewithnatural

andrecyclablematerialsthroughoutunit;stainlesssteel,aluminumandglass.The

internalcomponentsaremadeentirelyofstainlesssteel.Usingrecyclablematerial

preventspotentialnegativeconsequencesfortheenvironmentandforhealth.



MaintenanceAccess

Easyopenformaintenance.





BLUPURAFizz80Manual Page7‐Revision:11‐2‐2018

MODEL/PARTDESIGNATIONS



MODEL DESCRIPTION

BLUPURAFIZZ80

900583

CarbonationChillerwithIntegratedTaps



SPECIFICATIONS

ITEM SPECIFICATION

IceBankCapacity 14Liters(3.7Gallons)

CoolingCapacity 80LitersperHour(20GallonsperHour)

ColdWaterTemperature Adjustable‐3°‐10°C(37.4° - 50° F)

WaterConnection 3/8”InletWaterPipe

RecommendedService

Pressure

14.5‐51psi(.10MPa

–

0.35MPa)

–

UsePressureRegulator

*specificationlabelonbackofmachinestates51/58psi(whichoneiscorrect?)

IncomingFlowRate

>0.8GallonsperMinute



Minimumof0.8isrecommendedtoenhancethequalityofthesparklingwater

dispensed

RatedServiceFlow >0.8GallonsperMinute

MaximumServicePressure 100psi(689kPa)–UsePressureRegulator

EnvironmentalTemperature16°C(32°F)to32°C(90°F)

RefrigerantGas R134a,150grams(5.290ounces)

R134aPressures High(341psig),Low(88psig)



 

BLUPURAFizz80Manual Page8‐Revision:11‐2‐2018

SHIPPINGSPECIFICATIONS

ITEM UNIT SHIPPINGBOX

Width/Depth/Height

360x566x570mm

14.2x22.3x22.4Inches

420x590x720mm

16.5x23.2x28.3inches

Weight(dry) 27kg(59pounds) 30kg(66pounds)



ELECTRICALSPECIFICATIONS

ELECTRICALSUPPLY 120V/60Hz,1PH 15AmpService

CertifiedtoUL‐399and

CSAStandardC22.2No.

120

POWER(approximate) AMPDRAW(approximate)

330Watts 3.20Amps



 

BLUPURAFizz80Manual Page9‐Revision:11‐2‐2018

OPERATINGINSTRUCTIONS



ForColdSparklingWater: PullTapKnobforwardtostartdispensing.

PushTabKnobbacktostopdispensing.



ForColdWater:   PullTapKnobforwardtostartdispensing.

PushTabKnobbacktostopdispensing.



Flowcanbethrottled.



ColdSparkling

Water

ColdWater

BLUPURAFizz80Manual Page10‐Revision:11‐2‐2018

DAILYMAINTENANCEREQUIREDBYCUSTOMER



KeepyourBLUPURAFIZZ80WaterTreatmentSysteminshowroomconditionanddisinfected.



1. CleanoutsideoftheBLUPURAFIZZ80WaterTreatmentSystembyhandwithadisposable

towelandarinsefreeanti‐citrusproduct.Toremovelimestains,useastainless‐steel

cleaningproductwithadisposabletowel.



*Toremovelimescale,useaslightlyacidicproduct(e.g.citricacid)thathasbeenheavily

diluted.Excessiveaciditymaydamagethesurfaceofthesteel.



2. CleanGrillandDripTraywithnon‐foamingdetergentoradilutedlimescalecleanersuchas

citricacidandaplasticbrush.*TheDripTraymaybewashedinthedishwasher.



3. Glassfacingonfrontofunitmaybecleanedusingmulti‐usecleanersordedicatedglass

cleaners.



NOTE:DONOTUSETHEFOLLOWINGPRODUCTS!Usingthefollowingproductcancause

surfacepitting,oxidizationandgivetheimpressionthatthesurfaceoftheproductisrusting.



 Fullstrengthbleach.Onlyusebleachdiluted1‐

partbleachto4partswater.

 Metalfibers(ifabrushisneeded,useplastic

brushes).

 Abrasivecleanersorabrasivepads.

 Waterjet.



4. InsideofTapDispensingSpoutssanitization.



a) Cleaninsideofspoutthoroughlyandremoveany

tracesoflimestonewithanon‐foamingdetergent.

b) Rinsethoroughlywithpotablewater.

c) Utilizingaspraybottle,prepareasolutionof

hydrogenperoxideorsodiumhypochlorite,with10%

dilution.Cleaningwithadisinfectantsolutionthatis

hydrogenperoxide‐based.Thissolutionmustbe

replacedonaweeklybasisasithasadurationof7

daystobeeffective.

d) Useacottonswabtosanitizewithsolutioninside

taps.

e) After3‐5minutesrinsewithpotablewater.



NOTE:DONOTUSEFULLSTRENGTHBLEACH!Dilute1partbleachto4partswater.





Alloutside

surfaces.

Glass

Grill

andDrip

Tray

4.

SanitizeinsideTap

Spouts

BLUPURAFizz80Manual Page11‐Revision:11‐2‐2018

WEEKLYMAINTENANCEREQUIREDBYCUSTOMER



1. Useavacuumtocleanoutallvents. 

BLUPURAFizz80Manual Page12‐Revision:11‐2‐2018

WATERLOGICMANUFACTUREDWATERTREATMENTSYSTEMLIMITEDWARRANTY

UNITEDSTATESANDCANADAONLY



Waterlogicwatertreatmentsystemsareguaranteedtotheoriginalpurchasertobefreeofdefectsin

materialsandworkmanshipforaperiodofthree(3)yearsfromthedateofpurchase,butinnoevent

longerthanforty‐eight(48)monthsfromthedateofmanufacture.WaterlogicCommercialProducts,

LLC(“Waterlogic”)basedintheU.S.A.anditsaffiliatedcompaniesarenotliableforanycostof

removal,installation,transportation,oranyotherchargeswhichmayariseinconnectionwitha

warrantyclaim.



Thiswarrantydoesnotcoverdamageorweartoproductscausedbyabnormaloperatingconditions,

accident,abuse,misuse,unauthorizedorimproperalterationorrepair,damagecausedbyor

resultingfromshippingoraccident,damagecausedbyhotwater,freezing,flood,fire,oractsofGod.

Theeffectsfromchlorinecorrosion,scalingandnormalweararespecificallyexcludedfromthis

warranty.Thiswarrantydoesnotcoverproductsusedoutsidethecountrieswheretheunitwas

purchased,anddoesnotcoverproductsthatwerenotinstalledinaccordancewithWaterlogicprinted

installationandoperatinginstructionsobtainedintrainingorfromwww.waterlogic.us.Failureto

followallinstructionsforoperationandmaintenancevoidsthewarranty.Thiswarrantyisnot

transferable.



Toobtainwarrantyrepairsorreplacement,youmustobtainaReturnAuthorizationfromWaterlogic.

ToobtainaReturnAuthorization,youmustsubmitaReturnAuthorizationformwithsupporting

documentationtoWaterlogicforevaluation.Theformisavailableatwww.waterlogic.us.Supporting

documentationmustinclude,butisnotlimitedto;proofofpurchase,installationdate,failuredate,

andsupportinginstallationandmaintenancedata.AfteryousubmitaReturnAuthorizationformand

supportingdocumentation,Waterlogicwilldeterminewhetherareasonablyapparentdefectin

materialsorworkmanshipcoveredbythislimitedwarrantyexists.IfWaterlogicdeterminesthe

claimeddefectiscoveredbythiswarranty,Waterlogicwill,atitssolediscretion,determinewhether

tocorrectthedefectorreplacetheunit,freeofchargetoyou.IfWaterlogicdeterminesthattheunit

shouldbereturnedforwarrantyservice,Waterlogicwillapproveofreturninwritingandwillissuea

ReturnAuthorizationwhichyoumustobtainpriortoshippingtheproduct.Youareresponsibleforthe

costoffreightintoWaterlogic.



Waterlogicanditsaffiliatedcompaniesherebylimitthedurationofanyandallimpliedwarrantiesto

amaximumperiodofthree(3)yearsfromthedateofpurchaseincluding,butnotlimitedto,the

impliedwarrantiesofmerchantabilityandfitnessforaparticularpurpose.Somestatesdonotallow

limitationsonhowlonganimpliedwarrantylasts,sotheabovelimitationmaynotapplytoyou.

Consequentialandincidentaldamagesarenotrecoverableunderthiswarranty.Somestatesdonot

allowtheexclusionorlimitationofincidentalorconsequentialdamages,sotheabovelimitationor

exclusionmaynotapplytoyou.



Thiswarrantygivesyouspecificlegalrightsandyoumayalsohaveotherrightswhichmayvaryfrom

statetostate.



NewWarrantyPolicyissuedbyWaterlogicCommercialProductsLLC,USA‐January10,2014



WaterlogicCommercialsProductsLLCTel:(800)288‐1891

11710StonegateCircle Website:waterlogic.us

Omaha,NE68164

WaterLogic BLUPURA FIZZ 80 User manual

WaterLogic BLUPURA FIZZ 80 User manual

WaterLogic BLUPURA FIZZ 80 User manual

Related papers

Other documents