RAIS MINO II soapstone Instructions For Installation, Use And Maintenance Manual

Brand: RAIS

Model: MINO II soapstone

Category: Wood stove

Type: Instructions For Installation, Use And Maintenance Manual

This manual is also suitable for

INSTRUCTIONSFORINSTALLATION,

USEANDMAINTENANCE

RAISRONDO&RAISMINO2

IMPORTANTINFORMATION

Onfirstlightingthestoveyoumustbecarefulnottotouchthepainted

surfacesanditisMOSTIMPORTANTthatthedooriskeptslightly‘ ajar’in

orderforthedoorsealandsealanttocure.

Thiswillpreventthedoorsealsticki ngtothepa intedbodyandbecoming

damaged.

Revision

Date :2011

INTRODUCTION ………………………………………………………….. 4

WARRANTY …………………………………………………….………….. 4

SPECIFICATIONS………………………………………………………….. 5

CONVECTION………………………………………………………………. 6

INSTALLATIONINSTRUCTIONS ………………………………….……… 7

CHIMNEY………………………………………………………….…………. 89

INSTALLATION……………………………………………………………... 11

OPERATIONOFSWIVELBASE(RAISRONDO)……………………. 11

ADJUSTMENTOFCHIMNEYCONNECTION…………………………… 1213

INSTALLATIONOFSOAPSTONE(RaisMINOSOAPSTONE)……… 1417

INSTALLATIONDISTANCETOCOMBUSTIBLEWALL……………… 18

GENERALINSTALLATION(RIGHTANGLE)SECUREBASE……….. 18

CORNERINSTALLATION45°………… ……………………………. 18

360°SWIVELBASE…………………………………………………… 19

INSTALLATIONDISTANCETONONCOMBUSTIBLEWALL……….. 19

FORTHEINSTALLER…………………………………………………….... 20

OPERATINGINSTRUCTIONS…………………………………………….. 21

FUEL…………………………………………………………………………... 21

DRYINGANDSTORAGE…………………………………………………… 22

REGULATIONOFCOMBUSTIONAIR…………………………………… 22

USINGTHEWOODBURNINGSTOVE…………………………………… 23

ADJUSTMENTOFAIRDAMPER…………………………………………. 23

CONTROL…………………………………………………………………….. 23

FIRSTUSAGE……………………………………………………………….. 24

LIGHTINGANDFUELLING………………………………………………… 2627

CLEANINGANDCARE…………………………………………………….. 28

CLEANINGOFTHEFLUEWAYS………………………………………… 28

PROBLEMSOLVING……………………………………………………….. 29

ACCESSORIESANDSPAREPARTS……………………………………. 3031

SPAREPARTDIAGRAMMINOII………………………………………… 3233

SPAREPARTDIAGRAMMINOIISOAPSTONE.………………………. 3435

SPAREPARTDIAGRAMRONDO….……………..……………………… 3637

ARaiswoodburningstoveismorethanjustaheatsource:italsoshowsthatyou

careaboutdesignandqualityinyourhome.

Tomakethemostofyourwoodburningstoveitisimportantthatyoureadthemanual

thoroughlybeforeinstallingandusingit.

Inthecaseofwarrantycoverage,andforgeneralqueriesregardingyourwood

burningstove,itisimportantthatyouknowthestove’sproductionnumber.

Wethereforerecommendthatyounotedownthe numberinthetablebelow.

Theproductionnumberislocatedatthebackofthestoveatthebottom.

Warranty

YourRaiswoodburningstovecomeswitha5yearwarranty.

Thewarranty,however,doesnotcoverheati nsulatingmaterials,glassandseals.

TheseareavailabletoorderfromyourlocalRaisdealer/stockist.

Anyalterationsmadetothestovewillvoidthewarranty.

Introduction

ThankyouforpurchasingaRaiswoodbur ningstove.

TheseapplianceshavebeenapprovedbyHETASas

intermittentoperatingappliancesforburningwoodlogsonly.

TheseapplianceshavebeenapprovedforuseinSmokelessZones.

RaisMinoII RaisMinoII

Soapstone

Nominaloutput(kW): 5 5

Min./Max.output(kW): 38 38

Heatingarea(m

2

): Approx.100 Approx.100

Size,widt h/depth/height(mm): 510  460  1000 536  482  1027

Combustionchamberwidth/depth/height(mm). 336  289  345 336  289  345

Recommendedamountofwoodwhenfuelling(kg)

(Basedon2  3logsofwoodapprox.25cm)

1.5 1.5

Min.uptake/Min.draught(Pascal): 12 12

Weight(kg):  120 207

Smokegasmassflow(g/s): 4.7 4.7

Smokegastemperature(°C): 246 246

Intermittentoperation: Fuellingshouldbeundertakenwithin3hours

RaisRondo

5

38

Approx.100

490  490  1030

336  289  345

1.5

12

138

4.7

246

Efficiency(%) 80 80 80

ParticlesafterNS3058/3059(g/kg) 3.3 3.3 3.3

DustmeasuredaccordingtoDin+(mg/Nm

3

)

Convection

Raisstovesareconvectionstoves.Thismeanst hatthestove’sbackandsidepanelsare

notoverheated.Convectionmeansthatthereisacirculationofair,whichensuresthat

theheatisdistributedmoreevenlythroughouttheentireroom.Thecoldairissuckedin

atthebaseofthestoveandupthroughtheconvectionchannel,whichrunsalongthe

stove’scombustionchamber.Theheatedai rcomesoutatthetopofthestove,which

ensuresacirculationofwarmairthroughouttheroom.

Thestovesareequippedwithcooldoorhandles  aRaisspecialfeature which

meansyoucouldalmostdoawaywithgloves.Beaware,however,thatallexterior

surfacesbecomehotduringuse  sotakeextremecare.

InstallationInstructions

Thefollowingpagesgiveinstructionsforthesafeandproperinstallationofthisheating

applianceintheUK.Theseinstructionscoverthebasicprinciplesofinstallation,

althoughsomedetailsmayneedslightmodificationtosui tparticularlocalsiteconditions.

InallcasestheinstallationmustcomplywithcurrentUKBuildingRegulations,Local

AuthorityByelawsandotherspecificationsorregulationsastheyaffecttheinstallationof

thestove.

PleasenotethatitisalegalrequirementunderEnglandandWalesBuildingRegulations

thattheinstallationofthestoveisei thercarriedoutunderlocalAuthorityBuilding

ControlapprovalorisinstalledbyaCompetentPersonregisteredwithaGovernment

approvedCompetentPersonsScheme.HETASoperatesuchaschemeandalistingof

theirregisteredCompetentPersonscanbefoundontheirwebsiteatwww.hetas.co.uk.

ItshouldbenotedthatthecurrentBuildingRegulationsrequirementsaregivenin

ApprovedDocumentJ.Theserequirementsmayal sobemetbyadoptingtherelevant

recommendationsgiveninBritishStandardsBS8303,BS6461andBS7566.

WARNING.HealthandSafetyAdviceNotice.

Theinstallationofthisheatingappli anceisgovernedbytheHealthandSafetyatWork

Act1974.itistheresponsibilityoftheinstall ertoensurethatallrequirementsofthisAct

aremetduringtheinstallationworks.Attentionisdrawninparticulartothefollowing:

Handling: Theapplianceisaheavyitemandadequatefacilitiesmustbeavailable

forloading,unloadingandsitehandling.

FireCement: Sometypesoffirecementarecausticandshouldnotbeallowedtocome

intocontactwiththeskin.Protectiveglovesshouldbewornwhen

handlingfirecement.Incaseofcontactwiththeskin,washimmediately

withplentyofwater.

Asbestos: Thisstovecontainsnoasbestos.Ifthereisapossibilityofdisturbingany

asbestosinthecourseoftheinstall ation,thenpleaseseekspecialist

guidanceanduseappropriateprotectiveequipment.

MetalParts: Wheninstallingorservicingthisstovecareshouldbetakentoavoidthe

possibilityofpersonalinjury.

ImportantWarning  PreparatoryWorkandsafetyChecks:

· Thisstovemustnotbeinstalledintoachimneywhichservesa nyotherheating

appliance.

· Theremustnotbeanextractorfanfittedinthesameroomasthestove,asthiscan

causethestovetoemitfumesintotheroom.

· Ifthisapplianceisinstalledintoanexisti ngchimney,thechimneymustfirstbe

sweptandexaminedforsoundnessandsuitability,beforetheapplianceisinstalled

(seealsosectionheaded‘Chimney’).

Chimney

Thechimneyisthedrivingforcewhichmakesthestovefunction.Inorderforthestoveto

performsatisfactorilythechimneyheightmustbesufficienttoensurethecorrectdraught

of14to18Pa,soastocleartheproductsofcombustionandpreventprobl emsofsmoke

leakingintotheroomwhenthestoveisli t.

Note:Achimneyheightofnotlessthan4.5metres,measuredverticallyfromtheoutletof

thestovetothetopofthechimney,shouldbesatisfactory.

AlternativelythecalculationproceduregiveninBS5854:1980maybeusedasthebasis

fordecidingwhetheraparticularchimneydesignwillprovidesufficientdraught.

Theoutletfromthechimneyshouldbeabovetheroofofthebuildinginaccordancewith

theprovisionsoftheBuildingRegulati onsApprovedDocumentJ.

Iftheinstallationisintoanexistingchimney,thenitmustbesoundandhavenocracksor

otherfaultswhichmayallowfumesintothehouse.Olderproperties,especially,mayhave

chimneyfaultsorthecrosssectionmaybetool argei.e.morethan230x230mm.

Remedialactionshouldbetakenifrequire d,expertadviceshouldbesoughtwhere

required.

Ifthechimneyrequireslining,thenasuitablesolidfuelfluelinermustbeused,in

accordancewithBuildingRegulationsApprovedDocumentJ.

Anyexistingchimneymustbeclearofobstructio nandshouldhavebeensweptclea n

immediatelybeforetheinstallationofthestove.Ifthestoveisfittedinplaceofanopen

fire,thenthechimneyshouldbesweptonemonthafterinstallationtoclearanysootfalls

whichmayhaveoccurredduetothedifferenceincombustionbetweenthestovean dthe

openfire.

Ifthereisnoexistingchimneytheneitheraprefabricatedblockchimney,inaccordance

withBuildingRegulationsApprovedDocumentJoratwinwallinsul atedstainlesssteel

fluetoBS4543canbeused.Thesechimneysmustbefittedinaccordancewiththe

manufacturer’sinstructionsandtheBuildingRegulations.

Asinglewallmetalfluepipeissuitableforconnectingthestovetothechimneybutis

notsuitableforusingforthecompletechimney.Thechimneyand

connectingfluepipemusthaveaminimumdi ameterof150mmandit’s

dimensionshouldbenotlessthanthesizeoftheoutletsocketofthestovew hichis

150mm.Anybendinthechimneyorconnectingfluepipeshouldnotexceed45°.90°

bendsshouldnotbeused.

Combustiblematerialshouldnotbelocatedwheretheheatdissipatingthroughthe

wallsoffireplacesorfluescouldigniteit.Thereforewheninstallingthestoveinthe

presenceofcombustiblematerialsdueaccountmustbetakenoftheguidanceonthe

separationofcombustiblematerialgiveninBuildingRegulationsApprovedDocument

Jandalsointhes estoveinstructions.

Ifitisfoundthatthereisexcessivedraughtinthechimneytheneitheranadjustable

fluedamperoralternativelyadraughtstabilisershouldbefitted.Theadjustableflue

dampershouldnotcloseofftheflueentirely,butshouldinitsclosedpositionleavea

minimumcontinuousopeningfreeareaof atleast20%ofthetotalcrosssectional

areaoftheflueorfluepipe.

Adequateprovisione.g.easilyaccessiblesootdoorordoorsmustbeprovidedfor

sweepingthechimneyandconnectingfluepipe.

Youshouldalsofamiliariseyourselfwiththedraughtconditi onsforchimneyswith2

flues.

Forstrongdraughts,thechimneyorflueshouldbefittedwithadraughtstabiliser.In

whichcase,itisimportanttoensurethatthereisafreeflowthroughareaofminimum

20cm

2

whentheregulatinggateisshut.Otherwise,thefuelenergymaynotbeused

optimally.

If,atanytime,youareunsureabouttheconditionofthechimney,youshouldcontact

achimneysweep.

Rememberthataccesstothesootdoorshouldbekeptclear.

Installation

Itisprohibitedtocarryoutunauthorisedalterationstothestove.

Theremustbeplentyoffreshairintheroomwherethestoveisbeinginstalled,inorderto

ensurepropercombustion.Notethatanymechanicalexhaustventilatione.g.an

extractionhoodmayreducetheairsupply.Anyairgrillesmustbeplacedinsucha

manner,thattheairsupplyisnotblocked.

BuildingRegulationsApprovedDocument Jgivesspecificguidanceontherequired

permanentventilationintotheroomforcombustionairofsolidfuelappliances.

Thefloorstructuremustbeabletocarrythewei ghtofthewoodburningstove,aswellas

theweightofachimney,ifnecessary.

WhenyouchoosewheretosetupyourRAISwoodburningstove,youshouldconsiderthe

heatdistributiontotheotherrooms.Thiswillenableyoutogetthebestuseoutofyour

stove.

Thestoveshouldbesetupatasafedistancefrominflammablematerials.

Seethemanufacturer'splateonthewoodburningstove.

Installationwithturntable(RaisRondo)

Ifthestovehasaturntablethenpleasedothefollowing:

Liftupthepositioningboltandrotatethestoveat30°intervals.

Whenyouhavereachedthedesiredposition,releasethepositioningbolt,andturnthe

stoveslightlyuntiltheboltclicksintoplace.

Adjustmentofthechimneyconnection

Thestoveisalwaysdeliveredfortopflueconnection,butcanbechangedtorearfluecon

nectionasfollows:

Removethebaffleplate

andsmokediverter(see

cleaningandcare).

LoosenthethreeM6nutswithaspanner.

Makesurethattheflue

diverterisfastenedtothe

protectivecover.

Liftupthereflectorplate,pushoutthe‘knockout’

andputthereflectorplatebackintoplace.

Removethecasingknockout.

Removetheprotectivecover/sealandplaceoverthe

holeinthetopmakesurethatthesealispositioned

properly.TightentheassemblyusingthethreeM6nuts.

Theflueoutletspigot,whichcanbefoundinthestoveina

bag,andtheholderfortheupperfluediverterare

assembledwith3M6x20nutsandbolts.

Theupperfluediverter,baffleplateandtopplateare

assembledinreverseorder.

Installationdistancetocombustiblewall

Tofind outwhetherthewallnexttowherethestoveisgoingtobeinstalledisflammabl e,youshould

contactyourbuildingcontractororthelocalbuildingauthorities.

Theh earth shouldbeabletoaccommodatetheweightofthestove.Thechimneymustbe

independentlysupportedbywallbracketsoraceilingsupportplate.Theweightofthestoveisindicated

inthebrochure.

Thestoveshouldalwaysbeinstalledonanoncombustiblehearthofasizeandconstructionthatisin

accorda ncewiththeprovisionsofthecurrentUKBuildingRegulationsApprovedDocumentJ. 

Ifthestoveistobeinstalledonawoodenfloor,itmustbecoveredwithanoncombustible

materialatleast12mmthick,inaccordancewithUKBuildingRegulationsApprovedDocumentJ,toa

distanceof300mminfrontofthestoveand150mmtoeachsidemeasuringfromthedoorofthecom

bustionchamber.

Theclearancedistancestocombustiblematerialbeneath,surroundingoruponthehearthandwallsad

jacenttothehearthshouldcomplywiththeguidanceontheseparationofcombustiblematerialgiven in

UKBuildingRegulationsApprovedDocumentJandalsointhesestove

instruction s.

Informtheuserth attheappliancehasbeencommissionedandreadytouseandgiveinstructiononthe

safeoperation ofthestove.

These Instructionsmustbeleftwiththeuserandtheusershouldbeinstructedtokeeptheminasafe

place.

Installationdistancefornoncombustible

walls.

Werecommendaminimumdistanceto

noncombustiblematerialof50mm(F)for

cleaningconsiderations.

FortheInstaller

Finallybeforefiringthestoveforthefirsttimeac heckshouldbemadetoensurethatthe

assemblyandstoveinstallationhasbeensatisfactoryandthattherearenoleaksinany

sealsintheappl ianceandapplianceconnectionstothechimney.

Ensurethattheapplianceandchimneyfluearefunctioningcorrectlybeforefinally

handingovertotheuser.Readthelaterpartsofthismanualforguidanceoncare

requiredwhenfirstlighting.

Informtheuserthattheappliancehasbeencommissionedandreadytouseandgive

instructiononthesafeoperationofthestove.

TheseInstructionsmustbeleftwiththeuserandtheusershouldbeinstructedtoke ep

theminasafeplace.

Page is loading ...

RAIS MINO II soapstone Instructions For Installation, Use And Maintenance Manual

Brand: RAIS

Model: MINO II soapstone

Category: Wood stove

Type: Instructions For Installation, Use And Maintenance Manual

This manual is also suitable for

Download PDF

report

RAIS MINO II soapstone Instructions For Installation, Use And Maintenance Manual

This manual is also suitable for

RAIS MINO II soapstone Instructions For Installation, Use And Maintenance Manual

Related papers

Other documents