RAIS Q-TEE Instructions For Installation, Use And Maintenance Manual

ENGLISH RAISmanualforRaisQTee

1

INSTRUCTIONSFORINSTALLATION,

USEANDMAINTENANCE

RAISQTEE

IMPORTANTINFORMATION

Onfirstlightingthestove youmustbecarefulnottotouchthepainted

surfacesanditisMOSTIMPORTANTthatthedooriskeptslightly‘ajar’in

orderforthedoorseal andsealanttocure.

Thiswillpreventthedoorsealstickingtothe paintedbodyandbecoming

damaged.

ENGLISH RAISmanualforRaisQTee

3

Revision:

Date :2011

INTRODUCTION ………………………………………………………….. 4

WARRANTY …………………………………………………….………….. 4

SPECIFICATIONS………………………………………………………….. 5

CONVECTION………………………………………………………………. 6

INSTALLATIONINSTRUCTIONS ………………………………….……… 7

CHIMNEY…………………………………………………….…………. 89

HEARTH………………………………………………………………… 9

INSTALLATION………………………………………………..……... 11

COMMISSIONINGANDHANDOVER……………………………… 11

MANUFACTURERSPLATE………………………………………………. 12

CHANGINGTHECHIMNEYCONNECTION…………………………….. 13

INSTALLATIONDISTANCETOCOMBUSTIBLEWALL…………....... 1416

INSTALLATIONDISTANCETONONCOMBUSTIBLEWALL……… 17

FORTHEINSTALLER……………………………………………………… 17

OPERATINGINSTRUCTIONS…………………………………………….. 22

FUEL…………………………………………………………………………... 22

DRYINGANDSTORAGE…………………………………………………… 23

REGULATIONOFCOMBUSTIONAIR…………………………………… 23

ROOMVENTILATIONANDSTOVES…………………………………….. 23

USINGTHEWOODBURNINGSTOVE…………………………………… 24

FIRSTUSAGE………………………………………………………………… 25

LIGHTINGANDFUELLING………………………………………………… 2627

CLEANINGANDCARE…………………………………………………….. 28

CLEANINGOFTHEFLUEWAYS………………………………………… 29

PROBLEMSOLVING……………………………………………………….. 30

ACCESSORIESANDSPAREPARTS……………………………………. 31

SPAREPARTDIAGRAM…….………..……………………………………. 3233

FITTINGTHEDIRECTAIRBOX…………………………………………… 3435

LOCKBLOCKFORSTEELDOORS………………………………………. 36

QUICKGUIDE…………………………………………………………………. 37

ENGLISH RAISmanualforRaisQTee

4

ARaiswoodburningstoveismorethanjustaheatsource:italsoshowsthatyou

careaboutdesignandqualityinyourhome.

Tomakethemostofyourwoodburningstoveitisimportantthatyoureadthemanual

thoroughlybeforeinstallingandusingit.

Inthecaseofwarrantycoverage,andforgeneralqueriesregardingyourwood

burningstove,itisimportantthatyouknowthestove’sproductionnumber.

Wethereforerecommendthatyounotedownthenumberinthetablebelow.

Theproductionnumberislocatedatthebackofthestoveatthebottom.

Warranty

YourRaiswoodburningstovecomeswitha5yearwarranty.

Thewarranty,however,doesnotcoverheatinsulatingmaterials,glassandseals.

TheseareavailabletoorderfromyourlocalRaisdealer/stockist.

Anyalterationsmadetothestovewillvoidthewarranty.

Introduction

ThankyouforpurchasingaRaiswoodburningstove.

TheseapplianceshavebeenapprovedbySCA/HETASas

intermittentoperatingappliancesforburningwoodl ogsonly.

TheseapplianceshavebeenapprovedforuseinSmokelessZones

ENGLISH RAISmanualforRaisQTee

5

QTee57

Nominaloutput(kW): 4.7

Min./Max.outp ut(kW): 45

Heatingarea(m

2

): Ca.3090

Size,widt h/depth/height(mm): 425/372/570

Combustionchamberwidth/depth/height(mm). 317/270/270

Recommendedamountofwoodwhenfuelling(kg)

(Basedon2  3logsofwoodapprox.25cm)

1.5

Min.uptake/Min.draught(Pascal): 12

Weight(kg): (SteelDoo r/GlassDoor) 79/81

Smokegasmassflow(g/s): 3.7

Smokegastemperature(°C): 283

Intermittentoperation: Fuellingshould

beundertaken

within3hours

Efficiency(%) 73

ParticlesafterNS3058/3059(g/kg) 3.6

DustmeasuredaccordingtoDin+(mg/Nm

3

) 20

QTee65

4.7

45

Ca.3090

425/372/650

317/270/270

1.5

12

82/84

73

3.6

20

3.7

283

Fuellingshould

beundertaken

within3hours

QTee85

4.7

45

Ca.3090

425/372/850

317/270/270

1.5

12

94/96

73

3.6

20

3.7

283

Fuellingshould

beundertaken

within3hours

Specifications

PleaseNote,thisappliancehasbeentestedbythemanufacturersandworksona3mstraightflue.

ENGLISH RAISmanualforRaisQTee

6

Convection

Raisstovesareconvectionstoves.Thismeansthatthestove’sbackandsidepanelsare

notoverheated.Convectionmeansthatthereisacirculationofair,whichensuresthat

theheatisdistributedmoreevenlythroughouttheentireroom.Thecoldairissuckedin

atthebaseofthestoveand upthroughtheconvectionchannel,whichrunsalongthe

stove’scombustionchamber.Theheatedaircomesoutatthetopofthestove,which

ensuresacirculationofwarmairthroughouttheroom.

Thestovesareequippedwithcooldoorhandles  aRaisspecialfeature which

meansyoucouldalmostdoawaywithgloves.Beaware,however,thatallexterior

surfacesbecomehotduringuse  sotakeextremecare.

ENGLISH RAISmanualforRaisQTee

7

PleasenotethatitisalegalrequirementunderEnglandandWalesBuilding

RegulationsthattheinstallationofthestoveiseithercarriedoutunderLocal

AuthorityBuildingControlapprovalorisinstalledbyaCompetentPerson

registeredwithaGovernmentapprovedCompetentPersonsScheme.HETASLtd

operatesuchaSchemeandalistingoftheirRegisteredCompetentPersonsca n

befoundontheirwebsiteatwww.hetas.co.uk.

COAlarms:

Buildingregulationsrequirethatwheneveraneworreplacementfixedsolidfuel

orwood/biomassapplianceisinstalledinadwellingacarbonmonoxidealarm

mustbefittedinthesameroomastheappliance.Furtherguidanceonthe

installationofthecarbonmonoxidealarmisavailableinBSEN50292:2002and

fromthealarmmanufacturer’sinstructions.

Provisionofanalarmmustnotbeconsideredasubstituteforeitherinstallingthe

appliancecorrectlyorensuringregularservicingandmaintenanceoftheappli

anceandchimneysystem.

HEALTHANDSAFETYPRECAUTIONS

Specialcaremustbetakenwheninstallingthestovesuchthattherequirementsofthe

HealthandSafetyatWorkActaremet.

Handling

Adequatefacilitiesmustbeavailableforloading,unloadingandsitehandling.

FireCement

Sometypesoffirecementarecausticandshould notbeallowedtocomeintocontact

withtheskin.Incaseofcontactwashimmediatelywithplentyofwater.

Asbestos

Thisstovecontainsnoasbestos.Ifthereisapossibilityofdisturbinganyasbestosin

thecourseofinstallationthenpleaseseek specialistguidanceanduseappropriate

protectiveequipment.

MetalParts

Wheninstallingorservicingthisstovecareshouldbetakentoavoidthepossibilityof

personalinjury.

Theseinstructions togetherwiththoseintheinstructionbookletcover

thebasicprinciplestoensurethesatisfactoryinstallationofthestove,

althoughdetailmayneedslightmodificationtosuitparticularlocalsite

conditions.

InallcasestheinstallationmustcomplywithcurrentBuildingRegulations,

LocalAuthorityByelawsandotherspecificationsorregulationsastheyaffect

theinstallationofthestove.

ItshouldbenotedthattheBuildingRegulationsrequirementsmaybemetby

adoptingtherelevantrecommendationsgiveninBritishStandardsBS8303,

BSEN152871:2007asanalternativemeanstoachieveanequivalentlevelof

performancetothatobtainedfollowingtheguidancegiveninApproved

DocumentJ.

ENGLISH RAISmanualforRaisQTee

8

STOVEPERFORMANCE

IntheUKthestovehasbeenapprovedbyHETASLtdasanintermittentoperating

applianceforburningwoodlogsonl y.

PREPARATORYWORKANDSAFETYCHECKS

IMPORTANTWARNING

Thisstovemustnotbeinstalledintoachimneythatservesanyotherheatingappliance.

Theremustnotbeanextractorfanfittedinthesameroomasthestoveasthiscancause

thestovetoemitfumesintotheroom.

Chimney

Inorderforthestovetoperformsatisfactorilythechimneyheightmustbesufficientto

ensureanadequatedraughtofapproximately15Pasoastocleartheproductsof

combustionandpreventsmokeproblemsintotheroom.

NOTE:Achimneyheightofnotlessthan4.5metresmeasuredverticallyfromtheoutletof

thestovetothetopofthechimneyshouldbesatisfactory.Alternativelythecalculation

proceduregiveninEN133841maybeusedasthebasisfordecidingwhetheraparticular

chimneydesignwillprovidesufficientdraught.

PleaseNote,thisappliancehasbeentestedbythemanufacturersandworksona3m

straightflue.

Theoutletfromthechimneyshouldbeabovetheroofofthebuildinginaccordancewith

theprovisionsofBuildingRegulationsApprovedDocumentJ.

Ifinstallationisintoanexistingchimneythenitmustbesoundandhavenocracksorother

faultswhichmightallowfumesintothehouse.Olderproperties,especially,mayhave

chimneyfaultsorthecrosssectionmaybetoolargei.e.morethan230mmx230mm.

Remedialactionshouldbetaken,ifrequired,seekingexpertadvice,ifnecessary.Ifitis

foundnecessarytolinethechimneythenafluelinersuitableforsolidfuelmustbeusedin

accordancewithBuildingRegulationsApprovedDocumentJ.

Anyexistingchimneymustbeclearofobstructionandhavebeenswe ptcleanimmediately

beforeinstallationofthestove.Ifthestoveisfittedinplaceofanopenfirethenthe

chimneyshouldbesweptonemonthafterinstallationtoclearanysootfallswhichmay

haveoccurredduetothedifferenceincombustionbetweenthestoveandtheopenfire.

Ifthereisnoexistingchimneytheneitheraprefabricatedblockchimneyinaccordance

withBuildingRegulationsApprovedDocumentJoratwi nwall edinsulatedstainlesssteel

fluetoBS4543canbeused.Thesechimneysmustbefittedinaccordancewiththe

manufacturer’sinstructionsandBuildingRegulations.

ENGLISH RAISmanualforRaisQTee

9

Asinglewallmetalfluepipeissuitableforconnectingthestovetothec himneybutisnot

suitableforusingforthecompletechimney.Thechimneyandconnectingfluepipemust

haveaminimumdiameterof125mmanditsdimensionshouldbenotlessthanthesizeof

theoutletsocketofthestove.

Anybendinthechimneyorconnectingfluepipeshouldnotexceed45°.90°bendsshould

notbeused.

Combustiblematerialshouldnotbelocatedwheretheheatdissipatingthroughthewallsof

fireplacesorfluescouldigniteit.Thereforewheninstallingthestoveinthepresenceof

combustiblematerialsdueaccountmustbetakenoftheguidanceontheseparationof

combustiblematerialgiveninBuildingRegulationsApprovedDocumentJandalsoin

thesestoveinstructions.

Ifitisfoundthatthereisexcessivedraughti nthechimneythenadraughtstabilisershould

befitted.Fittingofadraughtstabiliserwillaffecttherequirementforthepermanentair

supplyintotheroominwhichthestoveisfittedinaccordancewithApprovedDocumentJ

(seealsocombustionairsupply).

Adequateprovisione.g.easilyaccessiblesootdoorordoorsmustbeprovidedfor

sweepingthechimneyandconnectingfluepipewhereitisnotintendedforthechimneyto

besweptthroughtheappliance,alsotopermitvisualchecksontheintegrityoftheflue

whentheapplianceisserviced.

Hearth

Thehearthshouldbeabletoaccommodatetheweightofthestoveanditschimneyifthe

chimneyisnotindependentlysupported.Theweightofthestoveisindicatedinthe

brochure.

Thestoveshouldalwaysbeinstalledonanoncombustiblehearthofasi zeand

constructionthatisinaccordancewiththeprovisionsofthecurrentBuildingRegulations

ApprovedDocumentJ.

Theclearancedistancestocombustiblematerialbeneath,surroundingoruponthehearth

andwallsadjacenttothehearthshouldcomplywiththeguidanceontheseparationof

combustiblematerialgiveninBuildingRegulationsApprovedDocumentJandalsoin

thesestoveinstructions.

If the stove is to be installed on a combustible floor surface, it must be covered with a

noncombustible material at l east 12mm thick, in accordance with Building Regulations

ApprovedDocumentJ,toadistanceof30cminfrontofthestoveand15cmtoeachside

measuringfromthedoorofthecombustionchamber.

ENGLISH RAISmanualforRaisQTee

10

Combustionairsupply

Inorderforthestovetoperformefficientlyandsafelythereshouldbeanadequateair

supplyintotheroominwhichthestoveisinstalledtoprovidecombustionair.Thisis

particularlynecessaryiftheroomisdoubleglazedorafluedraughtstabiliserisoperat

inginthesameroomastheappliance.Itmaybenecessarytoincrease theairventsize

inpropertywithlowairpermeability(<5.0m

3

/(h.m

2

).

Theprovisionofairsupplytothestovemustbei naccordancewithcurrentBuilding

RegulationsApprovedDocumentJ.Anopeni ngwindowisnotappropriateforthis

purpose.

IMPORTANTNOTE:Ifapplicableandtheapplianceisbeingfittedwithinanexisting

fireplacerecess,specialistadviceshouldbesoughtbeforefittingany permanent

ventilationwithinthisarea.

Connectiontochimney

Stovesmayhaveachoiceofeitherarearortopfl uegasconnectorthatallows

connectiontoeitheramasonrychimneyoraprefabricatedfactorymadeinsulatedmetal

chimneyinaccordancewiththeirinstructions.Insomecasesitmaybenecessarytofit

anadaptortoincreasethediameterofthefluetotheminimumrequired150mmsection

ofthechimneyorliner.

ElectricalServices

Theinstallationofanyelectricalservicesduringtheinstallationofthisappliancemustbe

carriedoutbyaregisteredcompetentelectricianandinaccordancewiththe

requirementsofthelatestissueofBS7671

CarbonMonoxideAlar m

AcarbonmonoxidealarmcomplyingwithBSEN50292mustbefittedinthesameroom

astheappliance.Itshouldbepositionedontheceilingatleast300mmfromanywallor,

ifitislocatedonawall,ashighupaspossible(aboveanydoorsandwindows)butnot

within150mmoftheceiling.Thealarmshouldalsobebetween1mand3mhorizontally

fromtheappliance.

ENGLISH RAISmanualforRaisQTee

11

Installation

Itisprohibitedtocarryoutunauthorisedalterationstothestove.

Theremustbeplentyoffreshairintheroomwherethestoveisbeinginstalled,i n

ordertoensurepropercombustion.Notethatanymechanicalexhaustventilation

e.g.anextractionhoodmayreducethea irsupply.Anyairgrillesmustbeplaced

insuchamanner,thattheairsupplyisnotblocked.

BuildingRegulationsApprovedDocumentJgivesspecificguidanceontherequired

permanentventilationintotheroomforcombustionai rofsolidfuelappliances.

Thefloorstructuremustbeabletocarrytheweightofthewoodburningstove,as

wellastheweightofachimney,ifnecessary.

WhenyouchoosewheretosetupyourRAISwoodburningstove,yo ushould

considertheheatdistributiontotheotherrooms.Thiswillenableyoutogetthebest

useoutofyourstove.

Thestoveshouldbesetupatasafedistancefrominflammablematerials.

Seethemanufacturer'splateonthewoodburningstove.

Commissioningandhandover

Ensureloosepartsarefittedinaccordancewitht heinstructionsgiveninthe

instructionbooklet.

Oncompletionoftheinstallationallowasuitableperiodoftimeforanyfirecement

andmortartodryout,whenasmallfiremaybelitandcheckedtoensurethe

smokeandfumesaretakenfromthestoveupt hechimneyandemittedsafelyto

atmosphere.Donotrunatfulloutputforatleast24hours.

Oncompletionoftheinstallationandcommissioningensurethattheoperating

instructionsforthestoveareleftwiththecustomer.Ens uretoadvisethecustomer

onthecorrectuseoftheappliancewithth efuelslikelytobeusedonthestoveand

warnthemtouseonlytherecommendedfuelsforthestove.

Advisetheuserwhattodoshouldsmokeorfumesbeemittedfromthestove.The

customershouldbewarnedtouseafireguardtoBS8423:2002(ReplacesBS

6539)inthepresenceofchildren,agedand/orinfirmpersons.

ENGLISH RAISmanualforRaisQTee

13

Removethecasingknockout.

Removetheprotectivecover/sealandplaceoverthe

holeinthetopmakesurethatthesealispositioned

properly.TightentheassemblyusingthethreeM6nuts.

Theflueoutletspigot,whichcanbefoundinthestoveina

bag,andtheholderfortheupperfluediverterare

assembledwith3M6x20nutsandbolts.

Theupperfluediverter,baffleplateandtopplateare

assembledinreverseorder.

Changingthechimneyconnection

ENGLISH RAISmanualforRaisQTee

14

Installationdistancetocombustiblewall

Tofindoutwhetherthewallnexttowherethestoveisgoingtobeinstalledisflammable,

youshouldcontactyourbuildingcontractororthelocalbuildingauthorities.

Thehearthshouldbeabletoaccommodatetheweightofthestove.Thechimneymustbe

independentlysupportedbywallbracketsoraceilingsupportplate.Thewei ghtofthestove

isindicatedinthebrochure.

Thestoveshouldalwaysbeinstalledonanoncombustiblehearthofasi zeandconstruction

thatisinaccordancewiththeprovisionsofthecurrentUKBuildingRegulationsApproved

DocumentJ.

Ifthestoveistobeinstalledonawoodenfloor,itmustbecoveredwithanoncombustible

materialatleast12mmthick,inaccordancewithUKBuildingRegulationsApproved

DocumentJ,toadistanceof300mminfrontoft hestoveand150mmtoeachside

measuringfromthedoorofthecombustionchamber.

Theclearancedistancestocombustiblematerialbeneath,surroundingoruponthehearth

andwallsadjacenttothehearthshouldcomplywiththeguidanceontheseparationof

combustiblematerialgiveninUKBuildingRegulationsApprovedDocumentJandalsoin

thesestoveinstructions.

Informtheuserthattheappliancehasbeencommissi onedandreadytouseandgive

instructiononthesafeoperationofthestove.

TheseInstructionsmustbeleftwiththeuserandt heusershouldbeinstructedtokeepthem

inasafeplace.

ENGLISH RAISmanualforRaisQTee

15

Normalsetupcornersetting

Uninsulatedflue Insulatedflue

A. Distancetofurniture 650mm 650mm

Distancetoflammablematerials:

B. infront(floor) 300mm 300mm

C. totheside(floor) 150mm 150mm

D. totherear(floor) 350mm 275mm

E. tothesideofthewall 275mm 225mm

ENGLISH RAISmanualforRaisQTee

16

Cornersetting45°fixedsocket

Uninsulatedflue Insulatedflue

A. Distancetofurniture 650mm 650mm

Distancetoflammablematerials:

B. infront(floor) 300mm 300mm

C. totheside(floor) 150mm 150mm

D. totherear(wall) 225mm 175mm

E. tothesideofthewall 275mm 225mm

ENGLISH RAISmanualforRaisQTee

17

Installationdistanceincaseofnoncombustiblewall

Werecommendamini mumdistancetononcombustiblematerialof50mm(F)for

cleaningconsiderations.

Usinguninsulatedfluepipe,theminimumdistancetoacombustiblewallmustbe

450mmor225mmifthewallisheatshielded(seeSectionJoftheBuildingRegu

lations)fromthefluepipe.

FortheInstaller

Finallybeforefiringthestoveforthefirsttimeacheckshouldbemadetoensurethat

theassemblyandstoveinstallationhasbeensatisfactoryandthattherearenoleaksin

anysealsintheapplianceandapplianceconnectionstot hechimney.

Ensurethattheapplianceandchimneyfluearefunctioningcorrectlybeforefinally

handingovertotheuser.Ifnecessaryreadthelaterpartsofthismanualforguidance

oncarerequiredwhenfirstlighting.

Informtheuserthattheappliancehasbeencommissi onedandreadytouseandgive

instructiononthesafeoperationofthestove.

TheseInstructionsmustbeleftwiththeuserandt heusershouldbeinstructedtokeep

theminasafeplace.

ENGLISH RAISmanualforRaisQTee

18

WARNINGNOTE

Properlyinstalled,operatedandmaintainedthi sstovewillnotemitfumesintothe

dwelling.Occasionalfumesfromde‑ashingandre‑fuellingmayoccur.However,

persistentfumeemissionispotentiallydangerousandmustnotbetolerated.Inthe

eventoffumeemissionfromtheappliance,thenthefollowingimmediateaction

shouldbetaken:‑

(a) Opendoorsandwindowstoventilateroomandthenleavethepremises

(b) Letthefiregoout

(c) Whensafetodoso,checkforflueorchimneyblockageandcleanifrequi red

(d) Donotattempttorelightthefireuntilthecauseofthefumeemissionhasbeen

identifiedandcorrected.Ifnecessaryseekexpertadvice.

Themostcommoncauseoffumeemissionisfluewayorchimneyblockage.For

yourownsafetythesemustbekeptcleanatall times.

IMPORTANTNOTES

General

Beforelightingthestovecheckwiththeinstallerthattheinstallationworkandcom

missioningchecksdescribedintheinstallationinstructionshavebeencarriedout

correctlyandthatthechimneyhasbeensweptclean,issounda ndfreefromany

obstructions.Aspartofthestoves’commissioningandhandovertheinstaller

shouldhaveshownyouhowtooperatethestovecorrectly.

COAlarm

YourinstallershouldhavefittedaCOalarminthesameroomastheappliance.If

thealarmsoundsunexpectedly,followtheinstructionsgivenunder“WarningNote”

above.

Useoffireguard

Whenusingthestoveinsituationswherechildren,agedand/orinfirmpersonsare

presentafireguardmustbeusedtopreventaccidentalcontactwiththestove.

ThefireguardshouldbemanufacturedinaccordancewithBS8423:2002

(ReplacesBS6539).

IfthefireisleftunattendedasparkguardtoBS3248,specificati onforspark

guardsforusewithsolidfuelappliancesshouldbeused.

Chimneycleaning

Thechimneyshouldbesweptatleasttwiceayear.Itisimportantthatthefluecon

nectionandchimneyaresweptpriortolightingupafteraprolongedshutdownpe

riod.

ENGLISH RAISmanualforRaisQTee

19

Ifthestoveisfittedinplaceofanopenfirethenthechimneywillrequiresweepi ng

afteramonthofcontinuousoperation.Thisi saprecautiontoensurethatany

“softer”depositsleftfromtheopenfireusagehavenotbeenloosenedbythehigher

fluetemperaturesgeneratedbytheclosedstove.

Insituationswhereitisnotpossibletosweepthroughthestovetheinstallerwill

haveprovidedalternativemeans,suchasasootdoor.Aftersweepingthechim

neythestoveflueoutletandthefluepipeconnectingthestovetothechimney

mustbecleanedwithafluebrush.

SpecialNotesforuseinaSmokeControlArea(RaisQTee):

Refuellingontoalowfirebed

Ifthereisinsufficientburningmaterialinthefirebedtolightanewfuelcharge,ex

cessivesmokeemissioncanoccur.Refuellingmustbecarriedoutontoasufficient

quantityofglowingembersandashthatthenewfuelchargewilligniteinareason

ableperiod.Iftherearetoofewembersinthefirebed,addsuitableki ndlingtopre

ventexcessivesmoke

Fueloverloading

Themaximumamountoffuelspecifiedinthismanualshouldnotbeexceeded,

overloadingcancauseexcesssmoke.

Operationwithdoorleftopen

Operationwiththedooropencancauseexcesssmoke.Theappliancemustnot

beoperatedwiththeappliancedoorleftopenexceptasdirectedintheinstruc

tions.

Dampersleftopen

Operationwiththeaircontrolsordampersopenca ncauseexcesssmoke.Theap

pliancemustnotbeoperatedwithaircontrolsordampersdoorleftopenexceptas

directedintheinstructions.

PeriodsofProlongedNonUse

Ifthestoveistobeleftunusedforaprolongedperiodoftimethenitshouldbe

givenathoroughcleantoremoveashand unburnedfuelresidues.Toenablea

goodflowofairthroughtheappliancetoreducecondensationandsubsequent

damage,leavetheaircontrolsfullyopen.

Extractorfan

Theremustnotbeanextractorfanfittedinthesameroomasthestoveasthiscan

causethestovetoemitsmokeandfumesintot heroom.

Aerosolsprays

Donotuseanaerosolsprayonornearthestovewhenitisalight.

Useofoperatingtools

Alwaysusetheoperatingtoolsprovidedwhenhandlingpartslikelytobehotwhen

thestoveisinuse.

ENGLISH RAISmanualforRaisQTee

20

ChimneyFires

Ifthechimneyisthoroughlyandregularlyswept,chimneyfiresshouldnotoccur.

However,ifachimneyfiredoesoccurturnoffthestoveimmediatelyandisolate

themainselectricitysupply(ifapplicable),andtightlyclosethedoorsofthestove.

Thisshouldcausethechimneyfiretogoout.Ifthechimneyfiredoesnotgoout

whentheaboveactionistakenthenthefirebrigadeshouldbecalledimmediately.

Donotrelightthestoveuntilthechimneyandfluewayshavebeencleanedandex

aminedbyaprofessional.

Permanentairvent

Thestoverequiresapermanentandadeq uateairsupplyinorderforittooperate

safelyandefficiently.

InaccordancewithcurrentBuildingRegulationstheinstallermayhavefittedaper

manentairsupplyventintotheroominwhichthestoveisinstalledtoprovidecom

bustionair.Thisairventshouldnotunderanycircumstancesbeshutofforsealed.

USEROPERATINGINSTRUCTIONSWOOD

Pleasereadtheimportantnoticesgivenabovebeforereferringtothemaininstruc

tionbookfordetailedoperatinginstructions.

HETASLtdApproval

HETASapprovalmaybelimitedtospecificfueltypesasdetailedinthemainin

structionmanuals.Approvaldoesnotcoverthe useofotherfuelseitheraloneor

mixedwiththerecommendedfuel,nordoesitcoverinstructionsfortheuseof

otherfuels.

Recommendedfuels

Stovesmaybedesignedtoburndryseasonedwoodlogsand/orsolidmineralfuel

asindicatedinthemainstovemanuals.

Dooroperation

Thedoorhandlemaybecomehotduringoperation,usethetooltoopenandclosethe

doors,ifappropriate.

Lightingoffire

Placesomefirelightersorpaperanddrykindlingwoodo nthegrateandcoverwith

asmallamountoffuel.Setaircontrolstomaximumandsetlighttofirelightersor

paper.Closethedoorsandallowfiretoburnuntilfueliswellalightthenloadwith

morefuelandadjustaircontrolstotherequiredlevelofheatoutput.

Beforerelightingthefirecleanthefirebedofashandclinkerandemptythe

ashpan.

RAIS Q-TEE Instructions For Installation, Use And Maintenance Manual

Related papers

Other documents