RAIS Q20 Instructions For Installation, Use And Maintenance Manual

Brand: RAIS

Model: Q20

Category: Stoves

Type: Instructions For Installation, Use And Maintenance Manual

ENGLISH RAISmanualforRaisQ20

1

INSTRUCTIONSFORINSTALLATION,

USEANDMAINTENANCE

RAISQ20

IMPORTANTINFORMATION

Onfirstlightingthestoveyoumustbecarefuln ottotoucht hepainted

surfacesanditisMOSTIMPORTANTthatthedooriskeptslightly‘ajar’in

orderforthedoorsealandsealanttocure.

Thiswillpreventthedoorsealstickingtothepaintedbo dyandbecoming

damaged.

ENGLISH RAISmanualforRaisQ20

3

Revision:

Date :2011MARCH

INTRODUCTION ……………………………………………… ………….. 4

WARRANTY ……………………………………………… …….………….. 4

SPECIFICATIONS……………………………………………… ………….. 5

INSTALLATIONINSTRUCTIONS ………………………………….……… 6

QUICKGUIDE…………………………………………………………. 7

CONVECTION…………………………………………………………. 8

CHIMNEY………………………………………………………….…… 8

FLUEOUTLETPOSITIONS…………………………………………. 10

HEARTH…………………………………… …………………………… 11

COMBUSTIONAIRSUPPLY………………………………………… 11

INSTALLATION…………………………… …………………………… 11

INSTALLATIONDISTANCETOCOMBU STIBLEWALL………… 12

COMMISSIONINGANDHANDOVER………………………………. 12

GENERALINSTALLATION(RIGHT ANGLE)SECUREBASE…. 13

CORNERINSTALLATION45°………………………………………. 14

360°SWIVELBASE…………………………………………………… 15

INSTALLATIONDISTANCETONONCO MBUSTIBLEWALL…. 16

OPERATINGINSTRUCTIONS…………………………………………….. 17

FUEL……………………………………………………………………. 17

DRYINGANDSTORAGE……………………………………………. 18

REGULATIONOFCOMBUSTIONAIR…………………………….. 18

ROOMVENTILATIONANDSTOVES………………………………. 18

COALARM………………………………… …………………………. 18

USINGTHEWOODBURNINGSTOVE……………………………. 19

FIRSTUSAGE…………………………………………………………. 19

LIGHTINGANDFUELLING…………………………………………. 21

MAINTENANCE

CLEANINGANDCARE………………… ……………………………. 22

CHIMNEYCLEANING………………………………………………… 22

CLEANINGTHEFLUEWAYS………...…………………………….. 23

PROBLEMSOLVING…………………………………………………. 24

DO’SANDDON' TS……………………………………………………. 25

ACCESSORIESANDSPAREPARTS……………………………………. 26

SPAREPARTDIAGRAMQ20………..……………………………… 2728

Q20

ENGLISH RAISmanualforRaisQ20

4

ARaiswoodburningstoveismorethanjustaheatsource:i talsoshowsthatyou

careaboutdesignandqualityinyourhome.

Tomakethemostofyourwoodburningstoveitisimportantthatyoureadthemanual

thoroughlybeforeinstallingandusingit.

Inthecaseofwarrantycoverage,andforgeneralqueriesregardingyourwood

burningstove,itisimportantthatyouknowthestove’sproductionnumber.

Wethereforerecommendthatyounotedownthenumberinthetablebelow.

Theproductionnumberislocatedatthebackofthestoveatthebottom.

Warranty

YourRaiswoodburningstovecomeswitha5yearwarranty.

Thewarranty,however,doesnotcoverheatinsulatingmaterials,glassandseals.

TheseareavailabletoorderfromyourlocalRaisdealer/stockist.

Anyalterationsmadetothestovewillvoidthewarranty.

Introduction

ThankyouforpurchasingaRaiswoodburningstove.

TheseapplianceshavebeenapprovedbyHETASas

intermittentoperatingappliancesforburningwoodlogsonl y.

ENGLISH RAISmanualforRaisQ20

5

SPECIFICATIONS

Q20

Nominaloutput(kW): 5

Min./Max.output( kW): 37

Heatingarea(m

2

): Ca.60105

Size,widt h/depth/height(mm): 426  426  1290

Combustionchamberwidth/depth/height(mm). 308  275  558

Recommendedamountofwoodwhenfuelling(kg)

(Basedon2  3logsofwoodapprox.25cm)

1.6

Min.uptake/Min.draught(Pascal): 12

Weight(kg):  115/220

Smokegasmassflow(g/s): 5.6

Smokegastemperature(°C): 249

Intermittentoperation: Fuellingshould

beundertaken

within3hours

Efficiency(%) 79

ParticlesafterNS3058/3059(g/kg) 2.9

DustmeasuredaccordingtoDin+(mg/Nm

3

) 9

PleaseNote,thisappliancehasbeentestedbythemanufacturersandworksona

3mstraightflue.

ENGLISH RAISmanualforRaisQ20

6

InstallationInstructions

Thefollowingpagesgiveinstructionsforthesafeandpro perinstall ationofthisheating

applianceintheUK.Theseinstructionscoverthebasicprinciplesofinstallation,

althoughsomedetailsmayneedslightmodificationtosuitparticularlocalsiteconditions.

InallcasestheinstallationmustcomplywithcurrentUKBuildingRegulations,Local

AuthorityByelawsandotherspecificationsorregulationsastheyaffecttheinstallationof

thestove.

PleasenotethatitisalegalrequirementunderEnglandandWalesBuildingRegulations

thattheinstallationofthestoveiseithercarriedoutunderlocalAuthorityBuilding

ControlapprovalorisinstalledbyaCompetentPersonregisteredwithaGovernment

approvedCompetentPersonsScheme.HETASoperatesuchaschemeandalistingof

theirregisteredCompetentPersonscanbefoundontheirwebsiteatwww.hetas.co.uk.

ItshouldbenotedthatthecurrentBuildingRegulationsrequirementsaregivenin

ApprovedDocumentJ.Theserequirementsmayalsobemetbyadoptingt herelevant

recommendationsgiveninBritishStandardsBS8303,BS6461andBS7566.

WARNING.HealthandSafetyAdviceNotice.

TheinstallationofthisheatingapplianceisgovernedbytheHealthandSafetyatWork

Act1974.itistheresponsibilityoftheinstallertoensurethatallrequirementsofthisAct

aremetduringtheinstallationworks.Attentionisdrawninparticulartothefollowing:

Handling: Theapplianceisaheavyitemandadequatefacilitiesmustbeavailable

forloading,unloadingandsitehandling.

FireCement: Sometypesoffirecementarecausticandshouldnotbeallowedtocome

intocontactwiththeskin.Protectiveglovesshouldbewornwhen

handlingfirecement.Incaseofcontactwiththeskin,washimmediately

withplentyofwater.

Asbestos: Thisstovecontainsnoasbestos.Ifthereisapossibilityofdisturbingany

asbestosinthecourseoftheinstallation,thenpleaseseekspecialist

guidanceanduseappropriateprotectiveequipment.

MetalParts: Wheninstallingorservicingthisstovecareshouldbetakentoavoidthe

possibilityofpersonalinjury.

ImportantWarning  PreparatoryWorkandsafetyChecks:

· Thisstovemustnotbeinstalledintoachimneywhichservesanyotherheating

appliance.

· Theremustnotbeanextractorfanfittedinthesameroomasthestove,asthiscan

causethestovetoemitfumesintotheroom.

· Ifthisapplianceisinstalledintoanexistingchimney,thechimneymustfirstbe

sweptandexaminedforsoundnessandsuitability,beforetheapplianceisinstalled

(seealsosectionheaded‘Chimney’).

ENGLISH RAISmanualforRaisQ20

8

Convection

Raisstovesareconvectionstoves.Thismeansthatthestove’sbackandsidepanelsare

notoverheated.Convectionmeansthatthereisacirculationofair,whichensuresthatthe

heatisdistributedmoreevenlythroughouttheentireroom.Thecoldairissuckedinatthe

baseofthestoveandupthroughtheconvectionchannel,whichrunsalongthestove’s

combustionchamber.Theheatedaircomesoutatthetopofthestove,whichensuresa

circulationofwarmairthroughouttheroom.

Thestovesareequippedwithcooldoorhandles  aRaisspecialfeature whichmeans

youcouldalmostdoawaywithgloves.Beaware,however,thatallexteriorsurfaces

becomehotduringuse  sotakeextremecare.

Chimney

Inorderforthestovetoperformsatisfactorilythechimneyheightmustbesufficientto

ensureanadequatedraughtofapproximately15Pasoastocleartheproductsof

combustionandpreventsmokeproblemsintotheroom.

NOTE:Achimneyheightofnotlessthan4.5metresmeasuredverticallyfromtheoutletof

thestovetothetopofthechimneyshouldbesatisfactory.Alternativelythecalculation

proceduregiveninEN133841maybeusedasthebasisfordecidingwhethera

particularchimneydesignwillprovidesufficientdraught.

PleaseNote,thisappliancehasbeentestedbythemanufacturersandworksona3m

straightflue.

Theoutletfromthechimneyshouldbeabovetheroofofthebuildinginaccordancewith

theprovisionsofBuildingRegulationsApprovedDocumentJ.

Ifinstallationisintoanexistingchimneythenitmustbesoundandhavenocracksorother

faultswhichmightallowfumesintothehouse.Olderproperties,especially,mayhave

chimneyfaultsorthecrosssectionmaybetoolargei.e.morethan230mmx230mm.

Remedialactionshouldbetaken,ifrequired,seekingexpertadvice,ifnecessary.Ifitis

foundnecessarytolinethechimneythenafluelinersuitableforsolidfuelmustbeusedin

accordancewithBuildingRegulationsApprovedDocumentJ.

Anyexistingchimneymustbeclearofobstructionandhavebeensweptclean

immediatelybeforeinstallationofthestove.Ifthestoveisfittedinplaceofanopenfire

thenthechimneyshouldbesweptonemonthafterinstallationtoclearanysootfallswhich

mayhaveoccurredduetothedifferenceincombustionbetweenthestoveandtheopen

fire.

Ifthereisnoexistingchimneythenanynewsystemmustbetothedesignation

describedaboveandinaccordancewithBuildingRegulationsApprovedDocumentJ.

Asinglewallmetalfluepipeissuitableforconnectingthestovetothechimneybutisnot

suitableforuseasthecompletechimney.Thechimneyandconnectingfluepipemust

haveaminimumdiameterof150mmanditsdimensionshouldbenotlessthanthesizeof

theoutletsocketofthestove.

ENGLISH RAISmanualforRaisQ20

9

Anybendinthechimneyorconnectingfluepipeshouldnotexceed45°.

90°bendsshouldnotbeused.

Combustiblematerialshouldnotbelocatedwheretheheatdissipatingthroughthewallsof

fireplacesorfluescouldigniteit.Thereforewheninstallingthestoveinthepresenceof

combustiblematerialsdueaccountmustbetakenoftheguidanceontheseparationof

combustiblematerialgiveninBuildingRegulationsApprovedDocumentJandalsoin

thesestoveinstructions.

Ifitisfoundthatthereisexcessivedraughtinthechimneythenadraughtstabilisershould

befitted.Fittingofadraughtstabiliserwillaffecttherequirementforthe

permanentairsupplyintotheroominwhichthestoveisfittedinaccordancewith

ApprovedDocumentJ(seealsocombustionairsupply).

Adequateprovisione.g.easilyaccessiblesootdoorordoorsmustbeprovidedforsweep

ingthechimneyandconnectingfluepipewhereitisnotintendedforthe

chimneytobesweptthroughtheappliance.

ChimneyFires

Ifthechimneyisthoroughlyandregularlyswept,chimneyfiresshouldnotoccur.

However,ifachimneyfiredoesoccurturnoffthestoveimmediatelyandisolatethemains

electricitysupply(ifapplicable),andtightlyclosethedoorsofthestove.T hisshouldcause

thechimneyfiretogoout.Ifthechimneyfiredoesnotgooutwhentheaboveactionis

takenthenthefirebrigadeshouldbecalledimmediately.Donotrelightthestoveuntilthe

chimneyandfluewayshavebeencleanedandexaminedbya

professional.

ENGLISH RAISmanualforRaisQ20

10

FlueOutletPositions

ENGLISH RAISmanualforRaisQ20

11

Hearth

Thehearthshouldbeabletoaccommodatetheweightofthestoveanditschimneyif

thechimneyisnotindependentlysupported.Theweightofthestoveisindicatedinthe

brochure.

Thestoveshouldpreferablybeinstalledonanoncombustiblehearthofasizeand

constructionthatisinaccordancewiththeprovisionsofthecurrentBuilding

RegulationsApprovedDocumentJ.

Theclearancedistancestocombustiblematerialbeneath,surroundingoruponthe

hearthandwallsadjacenttothehearthshouldcomplywiththeguidanceonthe

separationofcombustiblematerialgiveninBuildingRegulationsApprovedDocumentJ

andalsointhesestoveinstructions.

Ifthestov eistobeinstalledonacombustiblefloorsurface,i tmustbecoveredwitha

noncombustiblematerialatleast12mmthick,inaccordancewithBuildingRegulations

ApprovedDocumentJ, toadistanceof30cminfrontofthestoveand15cmtoeac h

sidemeasuringfromthedoorofthecombustionchamber.

Combustionairsupply

Inorderforthestovetoperformefficientlyandsafelytheremustbeanadequateair

supplyintotheroominwhi chthestoveisinstalledtoprovidecombustionair.The

provisionofairsupplytothestovemustbeinaccordancewithcurrentBuilding

RegulationsApprovedDocumentJ.Anopeningwindowisnotappropriateforthis

purpose.

Installation

Itisprohibitedtocarryoutunauthorisedalterationstothestove.

Theremustbeplentyoffreshairintheroomwherethestoveisbeinginstalled,inorder

toensurepropercombustion.Notethatanymechanicalexhaustventilatione.g.an

extractionhoodmayreducetheairsupply.Anyairgrillesmustbeplacedinsucha

manner,thattheairsupplyisnotblocked.

BuildingRegulationsApprovedDocumentJgivesspecificguidanceontherequired

permanentventilationintotheroomforcombustionairofsolidfuelappliances.

Thefloorstructuremustbeabletocarrytheweightofthewoodburningstove,aswell

astheweightofachimney,ifnecessary.

WhenyouchoosewheretosetupyourRAISwoodburningstove,youshouldconsider

theheatdistributiontotheotherrooms.Thiswillenableyoutogetthebestuseoutof

yourstove.

Thestoveshouldbesetupatasafedistancefrominflammablematerials.

Seethemanufacturer'splateonthewoodburningstove.

ENGLISH RAISmanualforRaisQ20

12

Installationdistanceincaseofcombustiblewall

Tofindoutwhetherthewallnexttowherethestoveisgoingtobeinstalledisflammable,

youshouldcontactyourbuildi ngcontractororthelocalbuildingauthorities.

Thehearthshouldbeabletoaccommodatetheweightofthestove.Thechimneymust

beindependentlysupportedbywallbracketsoraceilingsupportplate.Theweightofthe

stoveisindicatedinthebrochure.

Thestoveshouldalwaysbeinstalledonanoncombustiblehearthofasizeand

constructionthatisinaccordancewiththeprovisionsofthecurrentUKBuilding

RegulationsApprovedDocumentJ.

Ifthestoveistobeinstalledonawoodenfloor,itmustbecoveredwitha

noncombustiblematerialatleast12mmthick,inaccordancewithUKBuilding

RegulationsApprovedDocumentJ,toadistanceof300mminfrontofthestoveand

150mmtoeachsidemeasuringfromthedoorofthecombustionchamber.

Theclearancedistancestocombustiblematerialbeneath,surroundingoruponthe

hearthandwallsadjacenttothehearthshouldcomplywiththeguidanceonthe

separationofcombustiblematerialgiveninUKBuildingRegulationsApproved

DocumentJandalsointhesestoveinstructions.

Commissioningandhandover

Ensureallpartsarefittedinaccordancewiththeinstructions.

Oncompletionoftheinstallationallowasuitableperiodoftimeforanyfirecementand

mortartodryout,beforelightingthestove.Oncethestoveisunderfirecheckallseals

forsoundnessandcheckthattheflueisfunctioningcorrectlyandthatallproductsof

combustionareventedsafelytoatmosphereviathechimneyterminal.

Oncompletionoftheinstallationandcommissioningensurethattheoperating

instructionsforthestoveareleftwiththecustomer.Ensuretoadvisethecustomeron

thecorrectuseoftheapplianceandwarnthemtouseonlytherecommendedfuelforthe

stove.

Advisetheuserwhattodoshouldsmokeorfumesbeemittedfromthestove.The

customershouldbewarnedtouseafireguardtoBS8423:2002(ReplacesBS6539)in

thepresenceofchildren,agedand/orinfirmpersons.

COAlarm

Buildingregulationsrequirethatwheneveraneworreplacementfixedsolidfuelor

wood/biomassapplianceisinstalledinadwellingacarbonmonoxidealarmmustbe

fittedinthesameroomastheappliance.Furtherguidanceontheinstallationofthe

carbonmonoxidealarmisavailableinBSEN50292:2002andfromthealarm

manufacturer’sinstructions.

Provisionofanalarmmustnotbeconsideredasubstituteforeitherinstallingthe

appliancecorrectlyorensuri ngregularservicingandmaintenanceoftheapplianceand

chimneysystem.

ENGLISH RAISmanualforRaisQ20

16

FortheInstaller

Finallybeforefiringthestoveforthefirsttimeacheckshouldbemadetoensurethatthe

assemblyandstoveinstallationhasbeensatisfactoryandthatt herearenoleaksinany

sealsintheapplianceandapplianceconnectionstothechimney.

Ensurethattheapplianceandchimneyfluearefunctioningcorrectlybeforefinally

handingovertotheuser.Readthelaterpartsofthismanualforguidanceoncare

requiredwhenfirstlighting.

Informtheuserthattheappliancehasbeencommissionedandreadytouseandgive

instructiononthesafeoperationofthestove.

TheseInstructionsmustbeleftwiththeuserandtheusershouldbeinstructedtokeep

theminasafeplace.

Installationdistancesfornoncombustiblewall

Werecommendami nimumdistancetononcombustiblematerialof50mm(F)forcleaning

considerations.

Usinguninsulatedfluepipe,theminimumdistancetoacombustiblewallmustbe450mmor

225mmifthewallisheatshielded(seeSectionJoftheBuildingRegulations)fromtheflue

pipe.

ENGLISH RAISmanualforRaisQ20

17

ONLYUSERECOMMENDEDFUELS

Thefollowingtableshowsthecalori ficvalueofdifferenttypesofwood,whichhavebeen

storedfor2yearsandwhichhavearesidualmoistureof15 17%.

Wood Kgdrywoodprm

3

comparedtobeech/oak

Hornbeam 640 110%

Beechandoak 580 100%

Ash 570 98%

Maple 540 93%

Birch 510 88%

Mountainpine 480 83%

Fir 390 67%

Poplar 380 65%

1kgofwoodyieldsthesameheatenergyirrespectiveofwoodtype.

1kgofbeechmerelytakesuplessspacethan1kgoffi r.

Operatinginstructions

PleasenotethatHETASApplianceApprovalonlycoverstheuseofdryseasonedwood

logsonthisappliance.HETASApprovaldoesnotcovert heuseofotherfuelseither

aloneormixedwiththewoodlogs,nordoesitcoverinstructionsfortheuseofother

fuels.

Fuel

ThestoveisdesignedandapprovedinaccordancewithEN13240andNS3058for

stokingsplit,driedfirewood.Thefirewoodmusthaveawatercontentof1522%andits

max.lengthshouldbethelengthofthecombustionchamberminus5060mm.

Stokingwithwetfirewoodcausesbothsoot,environmentalpollutionandbadfuel

economy.Freshlycutwoodcontainsapprox.5070%waterandisthoroug hlyunsuitable

forstoking.Allowatleast1yearofstoragetimefornewlycutwoodbeforeusing.Wood

withadiameterofmorethan100mmshouldbesplit.Regardlessofwoodsize,itshould

alwayshaveatleastonesurfaceareafreeofbark.

Wedonotrecommendstokingwithpainted,laminatedorimpregnatedwood,woodwith

asyntheticsurface,paintedrefusewood,chipboard,pl ywood,domesticwaste,paper

briquettesandpitcoal,asthiswillproducemalodoroussmoke,whichcouldbe

poisonous.

Whenfiringwiththeabovementioneditemsandamountslargerthanthose

recommended,thestoveissubjectedtoalargeramountofheat,whi chresultsina

higherchimneytemperatureandlowerefficiency.Thiscanresultinthestoveand

chimneybecomingdamagedandwouldvoidthewarranty.

Thecalorificvalueofthefirewoodiscloselyconnectedtothemoisturelevel.

Moistfirewoodhasalowheatvalue.Themorewaterthewoodcontains,themore

energyittakesforthiswatertovaporise,resultinginthisenergybeinglost.

ENGLISH RAISmanualforRaisQ20

18

Dryingandstorage

Dryingwoodtakestime:properairdryingtakesapproximately2years.

Herearesometips:

Storethewoodsawn,splitandstackedinanairy,sunnyplace,whichisprotectedagainst

rain(thesouthsideofthehouseisparticularlysuitable).

Storethefirewoodstacksatahand'sbreadthapart,asthisensuresthattheairflowing

throughtakesthemoisturewithit.Avoidcoveringthefirewoodstackswithplastic,asthis

preventsthemoisturefromescaping.Itisagoodideatobringthefirewoodintothehouse

23daysbeforeyouneedit.

Regulatingthecombustionair

AllRAISstovesareequippedwithaonehandedoperatingleverforregulatingthedamper.

Thestovespecificregulatingmechanismscanbeseenonthediagrams.

Primaryairisthecombustionairaddedtotheprimarycombustionzone,i.e.thebedof

glowingembers.Thisair,whichiscold,isonlyusedinthelightingstage.Secondaryairis

theairwhichisaddedinthegascombustionzone,i.e.airwhichcontributestothe

combustionofthepyrolysisgasses(preheatedair,whichisusedforthecleanerglass

systemandcombustion).Thi sairissuckedthroughthedamperunderthecombustion

chamberandispreheatedthroughthesidechannelsandthenemittedashotscavenging

airontotheglass.Thehotairrinsestheglassandkeepsitsootfree.

Thetertiarychannel,whichcanbeseenatthetopofthecombustionchambertowardsthe

back,servestocombustthefinalgasresidues.

Bysettingtheintervalbetweenposition1and2,theenergycontentinthefirewoodisused

optimally,asthereisoxygenforcombustionandfortheburningofthepyrolysisgasses.

Whentheflamesareaclearyellowthedamperhasbeensetcorrectly.Findingthecorrect

positioncomeswithtimeafteryouhaveusedforstoveforawhile.

Itisnotrecommendedthatyouturnitdowncompletely.Amistakecommonlymadeis

shuttingthedampertooearlybecauseitfeelstoohot.Thisresultsi ndarksmokeemanating

fromthechimneyandinthecalori ficvalueofthefirewoodnotbeingusedtoitsfullest.

Roomventilationandstoves

Theremustnotbeanextractorfanfittedinthesameroomasthestoveasthiscancause

thestovetoemitsmokeandfumesintotheroom.

Thestoverequiresapermanentandadequateairsupplyinorderforittooperatesafelyand

efficiently.

InaccordancewithcurrentBuildingRegulationstheinstallermayhavefittedapermanentair

supplyventintotheroominwhichthestoveisinstalledtoprovidecombustionair.Thisair

ventshouldnotunderanycircumstancesbeshutofforsealed.

COAlarm

YourinstallershouldhavefittedaCOalarminthesameroomastheappliance.Ifthealarm

soundsunexpectedly,followtheinstructionsgivenunder“ImportantWarningNote”on

page24.

ENGLISH RAISmanualforRaisQ20

19

Usingthewoodburningstove

Adjustingtheairdamper.Thedamperhas3settings.

Position1

Thedamperisalmostclosedmeaning

thatthereisa

minimalairintake.

Position2

Pulltheleveruntilthefirstclick.Thispositiongivesfullsecondaryair.

Duringnormalusetheleverissetbetweenposition1and2.

Whentheflamesareclearandyellow,thedamperissetcorrectly,

i.e.resultinginaslow/optimalburning.

Position3

Pulltheleveruntilthenextclick.

Theairdamperiscompletelyopenandgivesfull

primaryandsecondaryair.Thispositionisforthelightingstageand

isnotusedundernormaloperation.

Control

Iftheashiswhiteandthewallsi nthecombustionchamberaresootfreeafterthestove

hasbeenused,theairregulationwassetcorrectlyandthewoodwassufficientlydry.

Firstusage

Acarefulstartpaysoff.Startwithasmallfire,sothatthewoodburni ngstovecanget

accustomedtothehightemperature.Thisgivesthebeststartandanydamageis

avoided.

Beawarethatastrangebutharmlessodourandsmokeconcoctionmayemanatefrom

thesurfaceofthestove,thefirsttimeyoufireup.Thisisbecausethepaintand

materialsneedtoharden.Theodourdisappearsquickly,butyoushouldcheckthe

ventilationanddraught,ifpossible.Seealso,theIMPORTANTwarningnoticebelow

aboutpersistentfumes.

Duringthisprocessyoumustbecarefulnottotouchthepaintedsurfaces,anditis

recommendedthatyouregularlyopenandclosethedoortopreventthedoorsealfrom

sticking.

Thestovemayalsoproduce"clickingnoises"duringheatingandcooling,causedbythe

largetemperaturedifferenceswhichthematerialissubjectedto.

Neveruseanytypeofliquidfuelforkindlingormaintainingthefire.Youcouldbeatrisk

ofexplosion.

ENGLISH RAISmanualforRaisQ20

20

Beforelightingthestovecheckwiththeinstallerthattheinstallationworkand

commissioningchecksdescribedabovehavebeencarriedoutcorrectlyandthatthe

chimneyhasbeensweptclean,issoundandfreefromanyobstructions.Aspartofthe

stoves’commissioningandhandovertheinstallershouldhaveshownyouhowto

operatethestovecorrectly.

IMPORTANTWarningNote!

Properlyinstalled,operatedandmaintainedthisappliancewillnotemitfumesintothe

dwelling.Occasionalfumesfromdeashingandrefuellingmayoccur.

However,persistentfumeemissionispotentiallydangerousandmustnotbetolerated.

Iffumeemissiondoespersist,thefollowingimmediateactionsshouldbetaken:

(a) Opendoorsandwindowstoventilatetheroomandthenleavethepremises.

(b) Letthefiregoout.

(c) Checkforflueorchimneyblockage,andcleanifrequired.

(d) Donotattempttorelightthefireuntilthecauseofthefumeemissionhasbeen

identifiedandcorrected.Ifnecessaryseekexpertadvice.

Themostcommoncauseofflueemissionisfl uewayorchimneyblockage.

Foryourownsafetythesemustbekeptcleanatalltimes.

IMPORTANTWarningNote!

Donotuseanaerosolsprayonornearthestovewhenitisalight.

IMPORTANTSafetyadvice!

Whenusingthestoveinsituationswherechildren,agedand/orinfirmpersonsare

presentafireguardmustbeusedtopreventaccidentalcontactwiththestove.The

fireguardshouldbemanufacturedinaccordancewithBS8423:2002(ReplacesBS

6539).

Page is loading ...

RAIS Q20 Instructions For Installation, Use And Maintenance Manual

Brand: RAIS

Model: Q20

Category: Stoves

Type: Instructions For Installation, Use And Maintenance Manual

Download PDF

report

RAIS Q20 Instructions For Installation, Use And Maintenance Manual

RAIS Q20 Instructions For Installation, Use And Maintenance Manual

Related papers

Other documents