RAIS Pilar Instructions Manual

Brand: RAIS

Model: Pilar

Type: Instructions Manual

This manual is also suitable for

INSTRUCTIONSFORINSTALLATION,

USEANDMAINTENANCE

RAISQBIC&RAISQBICINSERT

IMPORTANTINFORMATION

Onfirstlightingthestoveyoumustbecarefulnottotouchthepainted

surfacesanditisMOSTIMPORTANTthatthedooriskeptslightly‘ajar’in

orderforthedoorsealandsealanttocure.

Thiswillpreventthedoorsealsticki ngtothepa intedbodyandbecoming

damaged.

INTRODUCTION ………………………………………………………….. 4

WARRANTY …………………………………………………….………….. 4

SPECIFICATIONS………………………………………………………….. 5

CONVECTION………………………………………………………………. 6

INSTALLATIONINSTRUCTIONS ………………………………….……… 7

CHIMNEY………………………………………………………….…………. 89

INSTALLATION……………………………………………………………... 10

INSTALLATIONOFQBICINSERT………………...…………………….. 1219

INSTALLATIONDISTANCETONONCOMBUSTIBLEWALL……….. 20

INSTALLATIONDISTANCETOCOMBUSTIBLEWALL……………… 20

GENERALINSTALLATION(RIGHTANGLE)SECUREBASE……….. 21

CORNERINSTALLATION45°………… ……………………………. 22

360°SWIVELBASE…………………………………………………… 22

FORTHEINSTALLER…………………………………………………….... 23

OPERATINGINSTRUCTIONS…………………………………………….. 24

FUEL…………………………………………………………………………... 24

DRYINGANDSTORAGE…………………………………………………… 25

REGULATIONOFCOMBUSTIONAIR…………………………………… 25

USINGTHEWOODBURNINGSTOVE…………………………………… 26

ADJUSTMENTOFAIRDAMPER…………………………………………. 2627

CONTROL…………………………………………………………………….. 27

FIRSTUSAGE……………………………………………………………….. 28

LIGHTINGANDFUELLING………………………………………………… 2930

CLEANINGANDCARE…………………………………………………….. 31

CLEANINGOFTHEFLUEWAYS………………………………………… 32

PROBLEMSOLVING……………………………………………………….. 33

ACCESSORIESANDSPAREPARTS……………………………………. 34

SPAREPARTDIAGRAMQBIC106……………………..………………. 3435

SPAREPARTDIAGRAMQBIC127….…………………………………… 3637

SPAREPARTDIAGRAMQBICINSERT………………………………… 3639

Revision

Date :2011

ARaiswoodburningstoveismorethanjustaheatsource:italsoshowsthatyou

careaboutdesignandqualityinyourhome.

Tomakethemostofyourwoodburningstoveitisimportantthatyoureadthemanual

thoroughlybeforeinstallingandusingit.

Inthecaseofwarrantycoverage,andforgeneralqueriesregardingyourwood

burningstove,itisimportantthatyouknowthestove’sproductionnumber.

Wethereforerecommendthatyounotedownthe numberinthetablebelow.

Theproductionnumberislocatedatthebackofthestoveatthebottom.

Warranty

YourRaiswoodburningstovecomeswitha5yearwarranty.

Thewarranty,however,doesnotcoverheati nsulatingmaterials,glassandseals.

TheseareavailabletoorderfromyourlocalRaisdealer/stockist.

Anyalterationsmadetothestovewillvoidthewarranty.

Introduction

ThankyouforpurchasingaRaiswoodbur ningstove.

TheseapplianceshavebeenapprovedbyHETASas

intermittentoperatingappliancesforburningwoodlogsonly.

RaisQBic106 RaisQBic127

Nominaloutput(kW): 4.5 4.5

Min./Max.output(kW): 26 26

Heatingarea(m

2

): Approx.80 Approx.80

Size,widt h/depth/height(mm): 4044041060 4044041270

Combustionchamberwidth/depth/height(mm). 288288500 288288500

Recommendedamountofwoodwhenfuelling(kg)

(Basedon2  3logsofwoodapprox.25cm)

1.6 1.6

Min.uptake/Min.draught(Pascal): 12 12

Weight(kg):  143 153

Smokegasmassflow(g/s): 6.3 6.3

Smokegastemperature(°C): 253 253

Intermittentoperation: Fuellingshouldbeundertaken

within3hours

RaisQBicInsert

4.5

26

Approx.80

426418850

288288500

1.6

12

140

6.3

253

Efficiency(%):  75 75 75

DustmeasuredaccordingtoDin+(mg/Nm

3

):

ParticlesafterNS3058/3059(g/kg): 3.4 3.4 3.4

PleaseNote,thisappliancehasbeentestedbythemanufacturersandworksona3mstraightflue.

Convection

Raisstovesareconvectionstoves.Thismeanst hatthestove’sbackandsidepanelsare

notoverheated.Convectionmeansthatthereisacirculationofair,whichensuresthat

theheatisdistributedmoreevenlythroughouttheentireroom.Thecoldairissuckedin

atthebaseofthestoveandupthroughtheconvectionchannel,whichrunsalongthe

stove’scombustionchamber.Theheatedai rcomesoutatthetopofthestove,which

ensuresacirculationofwarmairthroughouttheroom.

Thestovesareequippedwithcooldoorhandles  aRaisspecialfeature which

meansyoucouldalmostdoawaywithgloves.Beaware,however,thatallexterior

surfacesbecomehotduringuse  sotakeextremecare.

InstallationInstructions

Thefollowingpagesgiveinstructionsforthesafeandproperinstallationofthisheating

applianceintheUK.Theseinstructionscoverthebasicprinciplesofinstallation,

althoughsomedetailsmayneedslightmodificationtosui tparticularlocalsiteconditions.

InallcasestheinstallationmustcomplywithcurrentUKBuildingRegulations,Local

AuthorityByelawsandotherspecificationsorregulationsastheyaffecttheinstallationof

thestove.

PleasenotethatitisalegalrequirementunderEnglandandWalesBuildingRegulati ons

thattheinstallationofthestoveisei thercarriedoutunderlocalAuthorityBuilding

ControlapprovalorisinstalledbyaCompetentPersonregisteredwithaGovernment

approvedCompetentPersonsScheme.HETASoperatesuchaschemeandalistingof

theirregisteredCompetentPersonscanbefoundontheirwebsiteatwww.hetas.co.uk.

ItshouldbenotedthatthecurrentBuildingRegulationsrequirementsaregivenin

ApprovedDocumentJ.Theserequirementsmayal sobemetbyadoptingtherelevant

recommendationsgiveninBritishStandardsBS8303,BS6461andBS7566.

WARNING.HealthandSafetyAdviceNotice.

Theinstallationofthisheatingappli anceisgovernedbytheHealthandSafetyatWork

Act1974.itistheresponsibilityoftheinstall ertoensurethatallrequirementsofthisAct

aremetduringtheinstallationworks.Attentionisdrawninparticulartothefollowing:

Handling: Theapplianceisaheavyitemandadequatefacilitiesmustbeavailable

forloading,unloadingandsitehandling.

FireCement: Sometypesoffirecementarecausticandshouldnotbeallowedtocome

intocontactwiththeskin.Protectiveglovesshouldbewornw hen

handlingfirecement.Incaseofcontactwiththeskin,washimmediately

withplentyofwater.

Asbestos: Thisstovecontainsnoasbestos.Ifthereisapossibilityofdisturbingany

asbestosinthecourseoftheinstall ation,thenpleaseseekspecialist

guidanceanduseappropriateprotectiveequipment.

MetalParts: Wheninstallingorservicingthisstovecareshouldbetakentoavoidthe

possibilityofpersonalinjury.

ImportantWarning  PreparatoryWorkandsafetyChecks:

· Thisstovemustnotbeinstalledintoachimneywhichservesanyotherheating

appliance.

· Theremustnotbeanextractorfanfittedinthesameroomasthestove,asthiscan

causethestovetoemitfumesintotheroom.

· Ifthisapplianceisinstalledintoanexisti ngchimney,thechimneymustfirstbe

sweptandexaminedforsoundnessandsuitability,beforetheapplianceisinstalled

(seealsosectionheaded‘Chimney’).

Chimney

Thechimneyisthedrivingforcewhichmakesthestovefunction.Inorderforthestoveto

performsatisfactorilythechimneyheightmustbesufficienttoensurethecorrectdraught

of14to18Pa,soastocleartheproductsofcombustionandpreventprobl emsofsmoke

leakingintotheroomwhenthestoveisli t.

Note:Achimneyheightofnotlessthan4.5metres,measuredverticallyfromtheoutletof

thestovetothetopofthechimney,shouldbesatisfactory.

AlternativelythecalculationproceduregiveninBS5854:1980maybeusedasthebasis

fordecidingwhetheraparticularchimneydesignwillprovidesufficientdraught.

PleaseNote,thisappliancehasbeentestedbythemanufacturersandworksona3m

straightflue.

Theoutletfromthechimneyshouldbeabovetheroofofthebuildinginaccordancewith

theprovisionsoftheBuildingRegulati onsApprovedDocumentJ.

Iftheinstallationisintoanexistingchimney,thenitmustbesoundandhavenocracksor

otherfaultswhichmayallowfumesintothehouse.Olderproperties,especially,mayhave

chimneyfaultsorthecrosssectionmaybetool argei.e.morethan230x230mm.

Remedialactionshouldbetakenifrequire d,expertadviceshouldbesoughtwhere

required.

Ifthechimneyrequireslining,thenasuitablesolidfuelfluelinermustbeused,in

accordancewithBuildingRegulationsApprovedDocumentJ.

Anyexistingchimneymustbeclearofobstructio nandshouldhavebeensweptclea n

immediatelybeforetheinstallationofthestove.Ifthestoveisfittedinplaceofanopen

fire,thenthechimneyshouldbesweptonemonthafterinstallationtoclearanysootfalls

whichmayhaveoccurredduetothedifferenceincombustionbetweenthestovean dthe

openfire.

Ifthereisnoexistingchimneytheneitheraprefabricatedblockchimney,inaccordance

withBuildingRegulationsApprovedDocumentJoratwinwallinsul atedstainlesssteel

fluetoBS4543canbeused.Thesechimneysmustbefittedinaccordancewiththe

manufacturer’sinstructionsandtheBuildingRegulations.

Asinglewallmetalfluepipeissuitableforconnectingthestovetothechimneybutis

notsuitableforusingforthecompletechimney.Thechimneyand

connectingfluepipemusthaveaminimumdi ameterof150mmandit’s

dimensionshouldbenotlessthanthesizeoftheoutletsocketofthestovew hichis

150mm.Anybendinthechimneyorconnectingfluepipeshouldnotexceed45°.90°

bendsshouldnotbeused.

Combustiblematerialshouldnotbelocatedwheretheheatdissipatingthroughthe

wallsoffireplacesorfluescouldigniteit.Thereforewheninstallingthestoveinthe

presenceofcombustiblematerialsdueaccountmustbetake noftheguidanceonthe

separationofcombustiblematerialgiveninBuildingRegulationsApprovedDocument

Jandalsointhes estoveinstructions.

Ifitisfoundthatthereisexcessivedraughtinthechimneytheneitheranadjustable

fluedamperoralternativelyadraughtstabilisershouldbefitted.Theadjustableflue

dampershouldnotcloseofftheflueentirely,butshouldinitsclosedpositionleavea

minimumcontinuousopeningfreeareaof atleast20%ofthetotalcrosssectional

areaoftheflueorfluepipe.

Adequateprovisione.g.easilyaccessiblesootdoorordoorsmustbeprovidedfor

sweepingthechimneyandconnectingfluepipe.

Youshouldalsofamiliariseyourselfwiththedraughtconditi onsforchimneyswith2

flues.

Forstrongdraughts,thechimneyorflueshouldbefittedwithadraughtstabiliser.In

whichcase,itisimportanttoensurethatthereisafreeflowthroughareaofminimum

20cm

2

whentheregulatinggateisshut.Otherwise,thefuelenergymaynotbeused

optimally.

If,atanytime,youareunsureabouttheconditionofthechimney,youshouldcontact

achimneysweep.

Rememberthataccesstothesootdoorshouldbekeptclear.

Installation

Itisprohibitedtocarryoutunauthorisedalterationstothestove.

Theremustbeplentyoffreshairintheroomwherethestovei sbeinginstalled,inorderto

ensurepropercombustion.Notethatanymechanicalexhaustventilatione.g.an

extractionhoodmayreducetheairsupply.Anyairgrillesmustbeplacedinsucha

manner,thattheairsupplyisnotblocked.

BuildingRegulationsApprovedDocument Jgivesspecificguidanceontherequired

permanentventilationintotheroomforcombustionairofsolidfuelappliances.

Thefloorstructuremustbeabletocarrythewei ghtofthewoodburningstove,aswellas

theweightofachimney,ifnecessary.

WhenyouchoosewheretosetupyourRAISwoodburningstove,youshouldconsiderthe

heatdistributiontotheotherrooms.Thiswillenableyoutogetthebestuseoutofyour

stove.

Thestoveshouldbesetupatasafedistancefrominflammablematerials.

Seethemanufacturer'splateonthewoodburningstove.

Installationinstructions QBicInsert

Firstloosenthescrewintheupperrightcorner

andthescrewinthelowerleftcorner(both

doorside),DONOTUNSCREWENTIRELY.

Nowitispossibletoremovethestovebody

fromthecassette.

Preparationofthecassette

Removethetwoscrewskeepingthestiffening

ribinposition.

Forastudwall(panelled)installation:

Assemblethecassette,theuppercovering

plateandthestiffeningribwiththetwoscrews

Assemblethetopplatewiththeselftappingscrews.

Forasolidwallinstallation:

Theoutermostpartoftheuppercovering

shouldbebrokenoffbeforeitisassembl ed

withthetwoselftappingscrews.

Thetopplateisnotused.

N.B.

A30degreebendmustalwaysbeusedfora

brickwall.

Thelegsarefixedontotheboxandthen

theboxcanbeplacedintopositi on.

Forastudwallinstallation,allthreelegs

areused.

Forasolidwallinstallation,onlytheback

legisused.

IMPORTANT.

Usingaspiritlevelensurethatthestoveis

perfectlylevelbothhorizontallyand

vertically.

Fixingholeforsolidwallinstallation

Fixingholesfortheanglebraceforastud

wallinstallation

Liftthestovebodyontothebaseplateandplaceit

asshowninthepictureontheleft.

Note.

Thebasicsettingsontheadjustingboltsareapproximately32.5mm(betweenthebottomof

thestove’sbaseplateandthebaseplateontheinternalbox).

Pleasenote,adjustmentmayberequiredinordertoensurethatthestovebodywillbelevel.

Pushthestovebodyinuntilthefront

islevelwiththewallonbothsides.

Retightenthescrewsintheupperleftand

lowerleftcorners.

Installationdistancetononcombustiblewall

Werecommendaminimumdistancetononcombustiblematerialof50mmforcleaning

considerations.

Usinguninsulatedfluepipe,theminimumdistancetoacombustiblewallmustbe450mm

or225mmifthewallisheatshielded(seeSectionJoftheBuildingRegulations)from

thefluepipe.

Installationdistancetocombustiblewall

Tofindoutwhetherthewallnexttowherethestoveisgoingtobeinstalledisflammable,

youshouldcontactyourbuildingcontractororthelocalbuildingaut horities.

Thehearthshouldbeabletoaccommodatetheweightofthestove.Thechimneymust

beindependentlysupportedbywall bracketsoraceilingsupportplate.Theweightofthe

stoveisindicatedinthebrochure.

Thestoveshouldalwaysbeinstalledonanoncomb ustiblehearthofasizeand

constructionthatisinaccordancewiththe provisionsofthecurrentUKBuildi ng

RegulationsApprovedDocumentJ.

Ifthestoveistobeinstalledonawoodenfloor,itmustbecoveredwitha

noncombustiblematerialatleast12mmthick,inaccordancewithUKBuilding

RegulationsApprovedDocumentJ,toadistanceof300mminfrontofthestoveand

150mmtoeachsidemeasuringfromthedoorofthecombustionchamber.

Theclearancedistancestocombustiblematerialbeneath,surroundingoruponthe

hearthandwallsadjacenttothehearthshouldcomplywiththeguidanceonthe

separationofcombustiblematerialgiveninUKBuildingRegulationsApproved

DocumentJandalsointhesestoveinstructions.

Informtheuserthattheappliancehasbeencommissionedandreadytouseandgive

instructiononthesafeoperationofthestove.

TheseInstructionsmustbeleftwiththeuserandtheusershouldbeinstructedtoke ep

theminasafeplace.

Page is loading ...

RAIS Pilar Instructions Manual

Brand: RAIS

Model: Pilar

Type: Instructions Manual

This manual is also suitable for

Download PDF

report

RAIS Pilar Instructions Manual

This manual is also suitable for

RAIS Pilar Instructions Manual

Related papers

Other documents