Topcon UC7-BC-GN02 Installation guide

Brand: Topcon

Model: UC7-BC-GN02

Type: Installation guide

This manual is also suitable for

Norac UC7







GenericUnitStandardControl

UC7BoomHeightControlSystem

InstallationManual



ReorderP/N:UC7‐BC‐GN02‐INSTRevB(GenericUnitStandardControl)



NOTICE:NORACSystemsInternationalInc.reservestherighttoimproveproductsandtheirspecificationswithoutnoticeandwithouttherequirementtoupdate

productssoldpreviously.Everyefforthasbeenmadetoensuretheaccuracyoftheinformationcontainedinthismanual.Thetechnicalinformationinthismanual

wasreviewedatthetimeofapprovalforpublication.



WWW.NORAC.CA

PRECISIONDEFINED



Contents



Introduction..........................................................................................................................1



TechnicalSpecifications........................................................................................................2



PartsOverview......................................................................................................................3



Pre‐InstallationChecklist.......................................................................................................5



UltrasonicSensorInstallation................................................................................................6



ElectronicInstallation..........................................................................................................10



SoftwareSetup....................................................................................................................13



CableSchematics.................................................................................................................14





WWW.NORAC.CA

PRECISIONDEFINED





Page1

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

1 Introduction

CongratulationsonyourpurchaseoftheNORACBoomHeightControlSystem.Thissystemismanufactured

withtopqualitycomponentsandisengineeredusingthelatesttechnologytoprovideoperatingreliability

unmatchedforyearstocome.

Whenproperlyusedthesystemcanprovideprotectionfromsprayerboomdamage,improvesprayerefficiency,

andensurechemicalsareappliedcorrectly.

Pleasetakethetimetoreadthismanualcompletelybeforeattemptingtoinstallthesystem.Athorough

understandingofthismanualwillensurethatyoureceivethemaximumbenefitfromthesystem.

Yourinputcanhelpmakeusbetter!Ifyoufindissuesorhavesuggestionsregardingthepartslistorthe

installationprocedure,pleasedon’thesitatetocontactus.



Everyefforthasbeenmadetoensuretheaccuracyoftheinformationcontainedinthismanual.Allparts

suppliedareselectedtospeciallyfitthesprayertofacilitateacompleteinstallation.However,NORACcannot

guaranteeallpartsfitasintendedduetothevariationsofthesprayerbythemanufacturer.

Pleasereadthismanualinitsentiretybeforeattemptinginstallation.

WWW.NORAC.CA

PRECISIONDEFINED





Page2

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

2 TechnicalSpecifications

  

CANICES‐3(A)/NMB‐3(A)



ThisClassAdigitalapparatuscomplieswithCanadianICES‐003.

PursuanttoEMCDirective–Article9,thisproductisnotintendedforresidentialuse.

Table1:SystemSpecifications

SupplyVoltage(rated) 12VDC

SupplyCurrent(rated) 10A

HydraulicPressure(maximum) 3300psi

BaudRate 250kbps

OperatingTemperatureRange 0°Cto80°C





WWW.NORAC.CA

PRECISIONDEFINED





Page3

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

3 PartsOverview

3.1. ElectronicInstallationOverview

ThefollowingdiagramsillustratetheGN02kitspecificpartsoftheNORACUC7™system.Interfacecables,valve

cables,andpowercablesareshowninthismanualandmaynotbeincluded.Cablesareavailableseparately

fromNORAC.PleaserefertotheUC7CableOrderingGuide(P/N:UC7‐BC‐CABLE‐GUIDE)forcableordering

information(availableatwww.norac.ca).



Figure1:ElectronicInstallationOverview

Itemsshowningreenanddenotedwithanasterisk(*)arenotincludedandmustbeorderedseparately.

ItemsshowninBLUEareincludedinthedisplaypackageandmaynotbeexactlyasshown.

WWW.NORAC.CA

PRECISIONDEFINED





Page4

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

3.2. ListofParts

ItemPartNumberNameQuantity

B0544706‐01KITCABLETIEBLACK10PCS21IN150PCS7.5IN1

B1744972SENSORMOUNTINGBRACKETLOWPROFILERAINFLAP16GA2

B2044971SENSORMOUNTINGBRACKETLOWPROFILE16GA2

C0243220‐03CABLENETWORK14AWG3M1

C0543210‐20CABLENETWORK18AWG20M2

E0150000HCM1MODULE1

E0750300ULTRASONICMAXSENSOR2

E1143765NETWORKCOUPLER8‐WAY1

E2043764TNETWORKCOUPLER2‐WAYWITHTERMINATOR 2

M02UC7‐BC‐GN02‐INSTMANUALINSTALLATIONUC7GENERICSTANDARDCONTROL1

P01106705NETWORK4PINCAVITYPLUG4

P02106602NETWORK12PINPLUG(A‐KEY)DT1

P03105882NETWORK6PINPLUG5



Donotusehighspeedpowertools/drillswheninstallinghardware.



TheuseofdielectricgreaseisnotrecommendedonanyNORACelectricalconnections.



ToensureallstainlesssteelhardwaredoesnotgallorseizeapplyalightcoatingofthesuppliedPermatex

Anti‐seizegreasetoallthreadedpartsuponinstallation.PermatexAnti‐seizelubricantispreferred,butother

similaranti‐seizeproductsmaybeused.



WWW.NORAC.CA

PRECISIONDEFINED





Page5

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

4 Pre‐InstallationChecklist

Thepre‐installchecklistisnecessarytochecktheexistingsprayerfunctionalitybeforetheinstallation.

1. Unfoldthesprayeroveraflat,unobstructedarea(i.e.nopowerlines…etc.).

2. Ensureallboom‐foldoperationsarefunctional(placeacheckmarkinboxesbelow).

3. Bringenginetofield‐operationalRPMandrecordbelow.

4. Recordthetime(seconds)ittakesforafullstrokeforallboomfunctions.Toensurerepeatable

measurements,taketheaverageof3trials.

5. NotallsprayerswillhavethefunctionslistedbelowinFigure2.



Ensuretheboomhassufficienttravelsoitdoesnotcontactthegroundduringthesetests.



Figure2:Pre‐InstallBoomSpeeds





WWW.NORAC.CA

PRECISIONDEFINED





Page6

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

5 UltrasonicSensorInstallation

5.1. UltrasonicSensorSerialNumberArrangement

TheMAXSensors™(E07)aremountedintheouterwingpositionswiththelowestserialnumberontheleftside

andthehighestserialnumberontherightside.

Eachsensorhasaserialnumberstampedonthesensorhousing.

ApplyalightcoatingofthesuppliedPermatexAnti‐seizegreasetoallthreadedpartsuponinstallation.



Figure3:SensorSerialNumberArrangement



WWW.NORAC.CA

PRECISIONDEFINED





Page7

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

5.2. UltrasonicSensorMountingGuidelines

Thefollowingguidelineswillensureoptimalsensorperformanceandpreventsensormeasurement.

1. Initslowestposition,thesensormustbe9inches(230mm)ormorefromtheground.

2. Ensurethattherearenoobstructionswithina12inch(300mm)diametercircleprojecteddirectlybelow

thecenterofthesensor.

3. Thesensorshouldbeapproximatelyverticalatnormaloperatingheights.



Figure4:SensorMountingGuidelines



Figure5:BracketMountingGuidelines



5.3. LowProfileBracketMountingGuidelines

1. Minimizethedistancebetweentheboltstopreventbendingthebracketandpreventthebracketfrom

looseningovertime.

2. Ensurethebracketismountedtightagainstthebottomoftheboom,minimizingthedistancebetweenthe

boomstructureandtheangledflange.



Aproblemcanariseifasensorisnotmountedcorrectly.Thismayonlybecomeapparentoncethecontrol

systemisswitchedfromsoiltocropmode.

Becarefulthatthesensorbracketdoesnotcollidewithanyotherpartoftheboomwhentheboomisfolded

totransportposition.Ifpossible,mountthesensorbracketswhiletheboomsarefoldedtoensuretheywill

notcauseinterference.

WWW.NORAC.CA

PRECISIONDEFINED





Page8

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

5.4. RainflapInstallation



Rainflapsareonlyinstalledifthesensorfacewillbepointingupwhentheboomsarefolded.

1. Insertonesideoftherainflaprodintothepre‐benthingetabonthesensorbracket.(Figure6)



Figure6:RainflapRodinPre‐BentHingeTab

2. Aligntheothersideoftherainflaprodwiththeunbenthingetab.(Figure7)



Figure7:AlignRainflapRod

3. Bendthehingetabinwardovertherainflaproduntilthehingetabfitssecurelyinthedetentgrooveon

thebacksideofthesensorbracket.(Figure8)



Figure8:BendRainflapHingeTab

4. Ensuretherainflapactuatessmoothlywhenthebracketisturnedupsidedownandreturnstotheopen

positionwhenthesensorbracketisreturnedtoitsoperatingposition(sensorpointingdownwardstoward

theground).

WWW.NORAC.CA

PRECISIONDEFINED





Page9

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

5.5. WingSensorInstallation

1. Thesensorbracketshouldbeorientedforward(aheadoftheboom).

2. Typically,thebestmountinglocationforthewingsensorbracketswillbeneartheendoftheboomtips,

approximatelytwofeet(0.6m)fromtheend.

3. Mountthesensorintothesensorbracket.TorquetheM8nutto108in‐lb(12Nm).Runthesensorcable

throughholeandbehindthebracket.Ensurethecableisclearofmovingpartsandwillnotbedamaged

duringfolding.

  

Figure9:BracketMountingExample



Front

WWW.NORAC.CA

PRECISIONDEFINED





Page10

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

6 ElectronicInstallation

6.1. HCM1Installation

1. InstalltheHCM1(E01)ontheboomnearthevalveblockwiththelargelabelandLEDsfacingup.Secure

withcableties.



Figure10:HCM1Connections



Figure11:HCM1Label

2. Insert4‐pinplugs(P01)intoanyunusedconnectorsontheHCM1.



Theinterfacecables(C14andC15)areorderedseparatelyfromthiskit.PleaserefertotheUC7™Cable

OrderingGuide(P/N:UC7‐BC‐CABLE‐GUIDE)forcableorderinginformation(availableatwww.norac.ca).

3. Connectthe4‐pinconnectorsoncableC14totheHCM1.TeetheconnectorsoncableC14intotheleft

up,leftdown,rightup,andrightdownfunctions.

4. Connectthe4‐pinconnectorsoncableC15totheHCM1.TeetheconnectorsoncableC15intothemain

up,maindown,andbypassfunctions.



Ensurethatallunusedconnectorsarepluggedwiththeplugsprovided.



Thebatterycable(C30)isorderedseparatelyfromthiskit.PleaserefertotheUC7CableOrderingGuide(P/N:

UC7‐BC‐CABLE‐GUIDE)forcableorderinginformation(availableatwww.norac.ca).

OutputNumberNormalFunction

1,2LeftUpandDown

3,4RightUpandDown

5,6MainUpandDown

7,8RollCWandCCW

WWW.NORAC.CA

PRECISIONDEFINED





Page11

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

6.2. CablingConnections

1. Fastenthe8‐waycouplertotheboomwithcableties.ConnectcableC02betweenthe8‐waycoupler(E11)

andthe6‐pinNORACbusconnectorontheHCM1.



Figure12:NORACBusLocation

2. ConnectcableC05tothe8‐waycouplerandroutealongtheboomtotheouterwingsensors.

3. Atthesensorbrackets,attacha2‐waycouplerwithterminator(E20)tothesprayerboom.The2‐way

couplerwithterminatoristhewhite2‐waycoupler.PlugthesensorandtheCANbuscableintothe2‐way

coupler.

4. Insertthe6pinplugs(P03)intotheremainingreceptaclesofthe8‐waycoupler.



NORACBus

WWW.NORAC.CA

PRECISIONDEFINED





Page12

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.



Figure13:CablingandPartsLayout



WWW.NORAC.CA

PRECISIONDEFINED





Page13

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

7 SoftwareSetup

1. Startupthesprayerandtestthesprayer’sfunctionality.Thedisplayterminaldoesnotneedtobepowered

onfortheoriginalboomfunctionswitchestooperate.Unfoldtheboomsandraise/lowereachboomand

themainsection.



Confirmthatthecablingandhosesdonotpinch,stretchorbindovertheentirerangeofmotion.

2. Ifanyfunctionsdonotwork,reviewthehydraulicandelectricalportionsofthismanualtocheckforproper

installation.

3. Turnonthepowerforthedisplayterminalusingtheswitchontheside.

4. TheprocedurefortheinstallationoftheUC7™BoomHeightControlsystemisnowcomplete.Beginthe

AutomaticSystemSetupprocedureasdescribedintheUC7TechnicalOperationManualforStandard

Control.





WWW.NORAC.CA

PRECISIONDEFINED





Page14

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

8 CableSchematics

8.1. ItemC02:43220‐03‐CableNetwork14AWG–3m





WWW.NORAC.CA

PRECISIONDEFINED





Page15

Visitwww.solutions.norac.caformoresystem

installationandtroubleshootinginfo.

8.2. ItemC05:43210‐20‐CableNetwork18AWG–20m



TOPCONAgricultureCanada

3702KinnearPlace

Saskatoon,SKS7P0A6

TOPCONAgricultureAmericas

W5527Hwy106

FortAtkinson,WI53538

TOPCONPrecisionAgricultureEurope

Avenidadelaindustria,

35,TresCantos,España

Spain

Support

Phone:8889799509

E‐mail:[email protected]

Web:www.norac.ca





Topcon UC7-BC-GN02 Installation guide

Brand: Topcon

Model: UC7-BC-GN02

Type: Installation guide

This manual is also suitable for

Norac UC7

Download PDF

report

Topcon UC7-BC-GN02 Installation guide

This manual is also suitable for

Topcon UC7-BC-GN02 Installation guide

Related papers

Other documents