Xpelair Simply Silent SSGX150R Installation And Maintenance Instructions Manual

Xpelair
Brand
Xpelair
Model
Simply Silent SSGX150R
Type
Installation And Maintenance Instructions Manual

This manual is also suitable for

SSGX150S (93195AW)
SSGX150R (93196AW)
SSGX150PS (93222AW)
SSGX150PR (93223AW)
Xpelair Simply Silent
GX150 Window Fan
™
I
nstallation and Maintenance Instructions
English
ُ
ِ
َ َ
• Doreadtheentireinstructionleaetbeforecommencinginstallation.
• Doinstalleachfanwithameansfordisconnectioninallpolesinthexedwiring.
• Domakesurethemainssupplyisswitchedobeforeattemptingtomakeelectrical
connectionsorcarryoutanymaintenanceorcleaning.
• Pleaseleavethisleaetwiththefanforthebenetoftheuser.
Standard
SSGX150S (93195AW)
SSGX150R (93196AW
PullCord
SSGX150PS (93222AW)
SSGX150PR (93223AW)
Installation and Maintenance Instructions
EnglishEnglish
Thisapplianceisintendedfor
connectiontoxedwiring.Check
thattheelectricalratingshownon
eachfanmatchesthemainssupply.
THE APPLIANCE IS DOUBLE INSULATED
AND DOES NOT REQUIRE AN EARTH
CONNECTION.
Allinstallationsmustbesupervisedbya
qualiedelectrician.Installationsandwiring
mustconformtocurrentIETRegulations
(UK),localorappropriateregulations(other
countries).
This appliance can be used
by children aged from 8 years
and above and persons with
reduced physical, sensory
capabilities or lack of
experience and knowledge
if they have been given
supervision or instruction
concerning the use of the
appliance in a safe way and
understand the hazards
involved. Children shall not
play with the appliance.
Cleaning and maintenance
of the appliance shall not be
made by children.
AllXpelairSimplySilent™GX150AC
fanshavethefollowingfeatures:
• Twospeedextraction
(Selectableatinstallation)
• Windowmountingwith
automaticshutter
SSGX150S/SSGX150R - Operatethefanusing
anon/oswitch(notsupplied).
SSGX150PS/SSGX150PR - Operatethefan
usinganintegralpull-cord.
Forinstallationintoawindowwitha184mmto
190mmdiameterhole,upto30mmthick.
Before Installation – Disconnectthetwowires
fromtheshutteractuatorterminalsonthe
controlPCB(SeeFigureE),removethethree
screwsholdingthefanintothewindowduct
(SeeFigureC).
Note – Powercablecanberoutedthroughone
oftheknockoutsinthewindowductandthen
feedthroughthecableaccessholeinthefan
forterminationintothecustomerconnection
terminalonthefancontrolboard.Ensurethe
cableaccessissealedwithasuitablesealant
tomaintainIPX4rating.
Where to locate the fan.
• Fanisdesignedfordirect
mountingintoawindowwitha
184mmto190mmhole,upto
30mmthick.
• Locateitashighaspossible.
• Asfarawayaspossiblefromandoppositeto
themainsourceofairreplacementtoensure
airowacrosstheroom(e.g.oppositethe
internaldoorway).
• Nearthesourceofsteamorodours.
•Notwhereambienttemperatures
are likely to exceed 50°C.
• Ifinstalledinakitchenfansmust
not be mounted immediately above
a cooker hob, or eye level grill.
• Ifinstallinginaroomcontainingafuel
burning device which has a non-balanced
flue, it is the installer’s responsibility to
ensure that there is enough replacement
air to prevent fumes being drawn down
the flue when the fan is operating up
to maximum extract. Refer to Building
Regulations for specific requirements.
• Exhaustairmustnotbedischargedinto
a flue used for exhausting of fumes from
appliances supplied with energy other than
electric. Requirements of all authorities
concerned must be observed for exhaust
air discharge and intake flow rates.
• Notsuitableforuseinpossiblechemical
corrosive atmospheres.
Installation
What the installer will need.
•3mmelectrician’sscrewdriver
andNo.1or2Pozidrive
screwdrivers.
Installing the isolating switch
and cables.
Ameansfordisconnectioninall
polesmustbeincorporatedinthe
xedwiringinaccordancewith
wiringregulations
English
English
Install Window Duct
BA
C D
Overall Dimensions (mm)
CLAMPSCREW
STICKDUCTTO
WINDOW,TIGHTEN
SCREWSGENTLYTOSECURE
DUCTINWINDOWHOLE.NOTE
LEVELLINEANDORIENTATION
DEPRESSCOVERLATCH
WITHTOOL&REMOVE
COVER&BAFFLECOMPLETE
Install Fan
Assemble Gasket
SECUREFAN
TOWINDOW
DUCTWITH
SCREWS
PROVIDED
REMOVEPAPER
BACKINGFROMSELF
ADHESIVEGASKET
Front cover removal
51 128
EnglishEnglish
Wiring and Setting Up
E
SEEDETAILA
CUSTOMER
CONNECTION
TERMINAL
SHUTTER
ACTUATOR
CONNECTIONS
SETJUMPERTO
REQUIREDPOSITION
FORSPEEDSETTING
LOW
SPEED
HIGH
SPEED
DETAIL A
SCALE 2.000
F
N
E
L
N
L
CUSTOMER
CONNECTION
TERMINAL
FUSE
SHUTTER
ACTUATOR
CONNECTIONS
FROMSHUTTER
ACTUATOR
SOLN
Either wire may be installed in either terminal for the shutter actuator to operate
For fixed wiring circuits the protective fuse
for the appliance must not exceed 5A.
Electrical Connections
English
English
• Ifmetalswitchboxesareused,earthing
regulations must be followed.
• Thecross-sectionalareaofthesupplycord
usedshouldberangedfrom1-1.5mm².
• SSGX150S/SSGX150R/SSGX150PS/
SSGX150PR–2core.
1. Check that the electrical rating shown
inside the back-plate matches your
mains supply.
2. Check there are no buried pipes or cables
e.g. electricity, gas, water behind the switch
location (in the wall or above the ceiling). If
in doubt, seek professional advice.
3. Isolate the mains supply.
4.Layinthecablefromtheisolatingswitchtothe
fanlocationviatheon/oswitch(ifrequired).
5.Layinthecablefromtheisolatingswitchto
thepointofconnectiontothemainssupply.
Warning: Do not make any
connections to the electrical
supply at this stage.
6.Installtheisolatingswitchandon/oswitch
(ifrequired).
7.Makeallconnectionswithintheisolating
switchandtheon/oswitch(ifrequired).
Wet Rooms: On/Off switch must
be situated so that it cannot be
touched by persons making use of
the bath or shower.
For Australia Only – SSGX150S / SSGX150R
/ SSGX150PS / SSGX150PR
Connectiontothesupplycanbemadebya
exible2-corecablecompletewith3pinplug
forinsertionintoanapproved10AGPOor
directlywiredthroughanapproved10Awall
mountedsurfaceswitchwithatleast3mm
clearancebetweencontacts.
Preparing the Fan for installation.
1. Ensureexternalwindowclampsare
retractedintowindowductbefore
installation.
2. Removeremainingbackingpaperfrom
gasket(SeeFigureA)andinstallwindow
ductintowindow,ensurelevellineis
horizontal.
3. Gentlytightenthethreeclampscrewsto
secureductintowindow.(SeeFigureB)
4. Routepowercableviacutoutintowindow
duct.Ensurepowercableremainsnear
edgeofduct.
If working above ground floor
level, safety precautions must
be observed.
Fan installation
1. Carefullyinsertthefanintothewindowduct.
2. Feedthemainscableandshutteractuator
cablethroughthecableentryholeinthe
backplatetotheterminals.(SeeFigureE)
3. Fastentheback-platetothewindowduct
usingfastenerssupplied.(SeeFigureC)
4. Donotovertightenscrews.
Electrical connections.
1. Makesurethemainssupplyisisolated.
Switchothemainselectricalsupplyand
removefuses.
2. Feedthecablestotheappropriateterminal
block.WirethefanasshowninFigureF.
3. Connectthecablefromtheisolatingswitch
totheelectricalsupplywiring.
Fan Settings
SPEED SETTING
Thefansarefactorysettolowspeed,buthave
twospeedsettingsfordierentapplications.
Selecteitherhighorlowspeedbyconnecting
thejumperbetweenthecentreandhighorlow
speedpinonthejumper(seeFigureE)
Using the fan
SSGX150S / SSGX150R Only
• Operatethefanusingtheon/oswitch(not
supplied).Repeattoswitcho.
SSGX150PS / SSGX150PR Only
• Operatethefanbypullingandreleasingthe
cord.Repeattoswitcho.
Note – Theshuttersareoperatedbyasilent
thermoactuatorwhichhasatimedelayon
opening(30-50secs)andclosing(3mins).
All Fans
Re-tthefrontgrilleassemblybyhookingin
thetoprst,andthenswingthecoverdownto
clipintoplace.
Cleaning
(recommendedonceamonth)
1.Beforecleaning,isolatethefancompletely
fromthemainssupply.
EnglishEnglish
2.Removethefrontbaeassemblyby
depressingthelatchontheundersideofthe
coverandpullingothefrontbaefromthe
bottom.
3.Tocleanthefrontbaeassembly,either
wipeitwithadamp,lintfreeclothorwashit
withwarmsoapywater.Thoroughlydrythe
frontcoverandret.
4.Donotimmersethefaninwaterorother
liquidstocleananyotherpartsofthefan.
5.Donotusestrongdetergents,solventsor
chemicalcleaners
6.Allowfantodrythoroughlybeforeuse.
7.Apartfromcleaning,noothermaintenanceis
required.
Disposal
Thisproductshouldnotbe
disposedofwithhouseholdwaste.
Pleaserecyclewherefacilitiesexist.
Checkwithyourlocalauthorityfor
recyclingadvice.
Guarantee
UK only
We,RedringXpelairGroupLimited,providea
guaranteeagainstfaultypartsandmanufacture
foraperiodof2yearsfromthedateof
purchase.Intheunlikelyeventofaproduct
breakdownduringtheguaranteeperiodthe
productshouldbereturnedtotheplaceof
purchaseortoRedringXpelairGroupLimited.
Exclusions
• Thisguaranteedoesnotcovercompensation
forthelossoftheproductorconsequential
lossofanykind.
• Damageordefectstotheproductarisingfrom
incorrectinstallationorlackofmaintenance.
• Transportationcosts.
This guarantee does not affect your
statutory rights
Technical advice
and service
Customers outside UK -
see international below.
United Kingdom
Xpelairhaveacomprehensiverangeofservices
including:
• Freetechnicaladvicehelp-deskfrom
Engineersonallaspectsofventilation.
• Freedesignservice,quotationsandsitesurveys.
• Serviceandmaintenancecontractstosuitall
requirements.
Pleaseaskfordetails:
• BytelephoneonTechline:+44(0)8443727766
• ByfaxonTechfax:+44(0)8443727767
• Attheaddressbelow
Head Office, UK Sales Office and Spares
RedringXpelairGroupLtd,Newcombe
House,NewcombeWay,OrtonSouthgate,
Peterborough,PE26SEEngland
Telephone:+44(0)8443727761
Fax:+44(0)8443727762
Sales/SparesHotline:+44(0)8443727750
Sales/SparesFaxline:+44(0)8443727760
www.xpelair.co.uk
International
• Guarantee:Contactyourlocaldistributoror
Xpelairdirectfordetails.
• TechnicalAdviceandService:Contactyour
localXpelairdistributor.
English
English
PartNo:26136AA
Head Offi ce, UK Sales Offi ce and Spares
RedringXpelairGroupLtd,
NewcombeHouse,NewcombeWay,
OrtonSouthgate,Peterborough,
PE26SEEngland
Telephone:+44(0)8443727761
www.xpelair.co.uk
www.xpelair.co.uk/international
FM02118 ISO 9001: 2000
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

Xpelair Simply Silent SSGX150R Installation And Maintenance Instructions Manual

Xpelair
Brand
Xpelair
Model
Simply Silent SSGX150R
Type
Installation And Maintenance Instructions Manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents