WaterLogic WL200 Operating, Installation And Service Manual

Waterlogic Commercial Products, LLC

11710 Stonegate Circle

Omaha, NE 68164

(800) 288-1891 www.waterlogic.us

Tech Portal Website: http://techportal.waterlogic.com

WL200

OPERATING, INSTALLATION, AND SERVICE MANUAL



WL200Operating,Installation,andServiceManual Page2‐Revision:4‐13‐2016



WL200OPERATING,INSTALLATION,ANDSERVICEMANUAL



CongratulationsonyourchoiceoftheWaterlogicWL200watertreatmentsystem.TheWL200

modeldispensescoldwater.EveryWL200includes:



Bio‐CoteAnti‐MicrobialProtection



Filterconfigurationcanbeoptimizedforallwaterconditions



TheWaterlogicWL200providesexceptionalqualityandgreattastingwaterwitheveryuse.



TABLEOFCONTENTS



 FeaturesandBenefits.................................................................3

 Certifications...............................................................................4

 IntroductionandSafetyAlertSymbols.......................................5

 SafetyPrecautions......................................................................6

 ModelandPartDesignations......................................................7

 Specifications..............................................................................7

 OperatingInstructions................................................................8

 FlowDiagrams.............................................................................9

 AdjustingColdSetPoint............................................................11

 Pre‐InstallationProcedures......................................................12

 DrainingProcedures..................................................................15

 InstallationProcedures.............................................................18

 ServiceRequirements...............................................................20

 CounterTopDrawingsandPartsList……………………..................21

 TowerDrawingsandPartsLists................................................26

 ElectricalDiagrams....................................................................31

 Troubleshooting........................................................................34

 Warranty..................................................................................41

WL200Operating,Installation,andServiceManual Page3‐Revision:4‐13‐2016

WL200FEATURESANDBENEFITS



ColdWater

WaterlogicWL200comesstandardwithColdWaterSelection.



HighVolumeStorageandWaterCapacity

TowerModelhas4litersofColdWaterCapacity.CounterTophas2litersofColdWaterCapacity.



BioCote®Anti‐MicrobialProtection

Plasticsurfacessurroundingdispensingareasanddriptrayareinfusedwithan

exclusivesilveradditivecalledBioCote®.Silverisanaturalanti‐microbialthat

inhibitsthegrowthofmicroorganismsprovidingadditionalsurfaceprotection.



LargeDispenseAreawithRecessedFaucet

8.5inchdispenseheightwithBioCote®recessedfaucettoprotectfromcross‐contamination.





WL200Operating,Installation,andServiceManual Page4‐Revision:4‐13‐2016

WL200CERTIFICATIONS



Waterlogicwatertreatmentsystemshavebeentested,andcertifiedtorigorousNSFandUL

Standards.WebelievethatperformancetestingandcertificationsvalidateWaterlogicasaworld‐

leaderinwatertreatmentsystems.

WL200CertificationsInclude

UL399–CertifiedDrinkingWaterCooler

IntertekLabs(ETL)CertifiedtheWL200toANSI/UL399StandardforDrinkingWater

Coolers.



BPAFree‐WaterlogictestsforBPAanddeclaresthatallofitsproductsareBisphenol‐A

FREEandcontainnoharmfulBPAplastics.



WaterlogicmanufacturingiscertifiedtoISO9001–QualityManagement

Systems(certifiedbyMoodyInternational).ISO9001isthe

internationallyacceptedstandardforwellmanagedorganizationsthat

haveadoptedthekeyqualitymanagementprinciplestoitsoperationsto

bringconsistentqualityproductsandacultureofcontinuous

improvement.

SafeDrinkingWaterAct

WaterlogicwatertreatmentsystemsconformtotheSafeDrinkingWaterAct(SWDA)“lead‐free”

amendmenteffectiveJanuary4,2014.





WL200Operating,Installation,andServiceManual Page5‐Revision:4‐13‐2016

INTRODUCTION



CarefullyreadandfollowallinstructionstoensureproperandefficientoperationofyourWL200.

ContactWaterlogicoranAuthorizedWaterlogicDealerifyouhaveanyquestions.



WaterlogicandAuthorizedWaterlogicDealersemploytrainedservicepersonnelwhoare

experiencedintheinstallation,functionandrepairofWaterlogicequipment.Thispublicationis

writtenforusebythesequalifiedindividuals.Waterlogicencouragesuserstolearnaboutproducts,

however,webelievethatproductknowledgeandserviceisbestobtainedbyconsultingWaterlogic

oranAuthorizedWaterlogicDealer.



Waterlogicwatertreatmentsystemsshouldbecombinedwithselectedwatertreatment

componentstocreateasystemspecificallytailoredforeachapplicationbytrainedandqualified

personnel.



ProductsmanufacturedandmarketedbyWaterlogicanditsaffiliatesareprotectedbypatents

issuedorpendingintheUnitedStatesandothercountries.



Waterlogicreservestherighttochangethespecificationsreferredtointhisliteratureatanytime,

withoutpriornotice.ChangesormodificationsnotexpresslyapprovedbyWaterlogiccouldvoidthe

warrantyanduser’sauthoritytooperatetheequipment.



SAFETYALERTSYMBOLS



Readandfollowallsafetyinformationcarefully.Thesignalwordsusedinthismanualareselectedas

shownbelowandbasedonanassessmentofthedegreeofpotentialinjuryordamage(severeor

minor)andtheoccurrenceofinjury(definitelyoccursorhasthepotentialtooccur)whenthe

warningisignored:



DANGER!

Indicatesasituationwhich,whennotavoided,resultsindeathorsevereinjury.



WARNING!

Indicatesasituationwhich,whennotavoided,hasthepotentialtoresultindeathorsevere

injury;and/orseverepropertydamage.





CAUTION!

Indicatesasituationwhich,whennotavoided,resultsorhasthepotentialtoresultinminor

injury;and/orminorpropertydamage.



WL200Operating,Installation,andServiceManual Page6‐Revision:4‐13‐2016

SAFETYPRECAUTIONS



Basicsafetyprecautionsshouldbefollowed,includingthefollowing:



DANGER!Ifincorrectlyinstalled,operatedormaintained,thisproductcancausedeathor

severeinjury.Thosewhoinstall,operate,ormaintainthisproductshouldbetrainedinitsproperuse,

warnedofitsdangers,andshouldreadtheentiremanualbeforeattemptingtoinstall,operate,or

maintainthisproduct.



WARNING!Unitistobeusedforitsintendedpurposeasdescribedinthismanual,and

untrainedindividualswhousethismanualassumetheriskofanyresultingpropertydamageor

personalinjury.



DANGER!ELECTRICALSHOCKHAZARD.Alwaysunplugfrompowersupplypriortoservicing

equipmenttopreventelectricalshock.



WARNING!Thissystemtobeusedforwateronlyandisnotintendedforusewherewateris

microbiologicallyunsafeorwithwaterofunknownqualitywithoutadequatedisinfectionbeforeor

afterthesystem.Thesystemisdesignedforthesupplementalbactericidaltreatmentofeither

treatedanddisinfectedpublicdrinkingwater,orotherdrinkingwater,whichhasbeentestedand

deemedacceptableforhumanconsumptionbythestateorlocalhealthagencyhavingjurisdiction.

Thesystemisdesignedtoreducenormallyoccurringnon‐pathogenicornuisancemicroorganisms

only.Systemisnotintendedfortreatmentofcontaminatedwater.



WARNING!DispenserCouldTiporFallcausingseriousinjury.Alwaysinstallunitonafirm,flat,

andlevelsurfaceandsecuretheWL200tothebasecabinetwiththescrewprovidedtolockthe

componentstogether.Neverplaceheavyitemsontopofunitandneverclimb,stand,orhangonunit

orstoragecabinettopreventinjuryanddamage.





CAUTION!INDOORUSEONLY.Donotinstalloutdoorsorwhereunitisindirectsunlight.Donot

installwhereambienttemperaturegoesbelow50Forabove97F.Avoidhighhumidityandmoisture.

Productlifeandperformancewillbeimpactedandwarrantycouldbevoided.

 

WL200Operating,Installation,andServiceManual Page7‐Revision:4‐13‐2016

MODEL/PARTDESIGNATIONS

BRANDNAME DESCRIPTION

MODEL‐

PARTNUMBER

WL200CounterTop

WaterlogicWL200CounterTop‐ColdWater

F‐6002‐M‐C‐TT‐CS‐WLU

12‐WL200CT

WL200Tower

WaterlogicWL200Tower‐ColdWater

F‐6002‐FS‐C‐TT‐CS‐WLU

12‐WL200FS



SPECIFICATIONS

ITEM WL200CounterTop WL200Tower

WaterConnection ¼”QuickConnect

ColdWaterTemperature

ColdWaterTemperature

–

FactorySetPoint41°‐ 5°C

(Adjustable)34° - 54° F.(1.1°‐12.2°C)

RecommendedService

Pressure

40‐60psi(275‐414kPa)–UsePressureRegulator

MaximumServicePressure 100psi(689kPa)–UsePressureRegulator

RatedServiceFlow 0.5gallonsperminute(1.89Lpm)

EnvironmentalTemperature35°‐100°F(2°‐37°C)

RefrigerantGas R134a,40g,1.41ounces R134a,65g,2.29ounces

R134aPressures High(230psi),Low(90psi)



SHIPPINGSPECIFICATIONS

ITEM WL200CounterTop WL200Tower

Width/Depth/Height

13.5”x14.5”x17.75”

(34cmx37cmx

45cm)

13.5”x14.5 x40.5”(34cmx41cmx

103cm)

Weight(dry) 42pounds(19.5kg) 58pounds(26.5kg)



ELECTRICALSPECIFICATIONS

ELECTRICALSUPPLY 120V/60Hz,1PH 15AmpService

COMPONENT POWER(approximate) AMPDRAW(approximate)

Compressor 216 1.8Amps

WL200TOTAL 216 1.8Amps



#WL200CounterTopis17.75in.tallandmaynotfitbetweenCounterTopsandcabinets‐Checkinstallationtoensureadequateclearance.

WL200Operating,Installation,andServiceManual Page8‐Revision:4‐13‐2016

OPERATINGINSTRUCTIONS



TheabovepictureshowsfrontLCDdisplayandcontrolpanelfortheWaterlogicWL200.



ForColdWater: PresstheDispensingButton.





DispensingButton

WL200Operating,Installation,andServiceManual Page9‐Revision:4‐13‐2016

WL200COUNTERTO PWATERFLOWDIAGRAM



WL200Operating,Installation,andServiceManual Page10‐Revision:4‐13‐2016



WaterIn

FilterDryer



SolenoidValve

Compressor

Condenser



WaterOut



Faucet



WL200TOWERWATERFLOWDIAGRAM





WL200Operating,Installation,andServiceManual Page11‐Revision:4‐13‐2016

ADJUSTINGCOLDSETPOINT



Thecoldsetpointcanbeadjustedbyaccessingthecoldthermostat

adjustmentscrewUndertheDecalattherearoftheunit.

ThiswillNOTVoidtheWarrantyasthecurrentDecalstatesonthebackof

theunit.Thefactorysetpointis~41°Fandisindicatedbythedotonsheet

metalaroun

dtheadjustmentscrewandbehindthedecal.

Turningtheadjustmentscrewclockwiselowersthesetpointtemperature

andtherangeisapproximately20°Fthruthefullrangeofadjustment

(~7:00tothe~5:00positions).



Youshouldbeabletoturnthescrewfromthefactorysetpointof41°F

(~12:00position)about45degreesclockwise(2:30onaclock) toreduce

thesetpointtemperatureby6°Fandachievethe35‐36°Fsettingyouare

lookingfor.



Trialthisbyadjustingandthenmeasurethewatertemperature10‐15

minutesafterthecompressorshutsoff(coldestpoint)toverifytheset

pointtemperature.



Eachunitwillvaryslightly.Trynottogomuchpastthe“3:00position”to

avoidfreezingthecoldtankasshownabove.



FutureProductionchangesColdThermostatCoverLabeltoLP‐0326‐L00‐

00/WLUSAPNLP‐0326.



 

WL200Operating,Installation,andServiceManual Page12‐Revision:4‐13‐2016

PRE‐INSTALLATIONPROCEDURES



DANGER!ELECTRICALSHOCKHAZARD.

Onlyqualifiedpersonnelwhohavereadandunderstandthisentiremanualshouldattemptto

install,orservicethisunit,failuretodosocouldresultindeathorseriousinjury.DONOTplug

intoanelectricalsupplyuntilspecificallyinstructed.



WARNING!ALWAYSSANITIZEBEFOREUSE.

Sanitizebeforeusetoeliminateanypotentialmicrobiologicalcontaminates.



MaterialsNeeded:

 PersonalProtectiveEquipment.RubberorNitrileSafetyGlovesandProtectiveEyewear

 PhillipsScrewdriver

 TemperatureGage

 WaterPitcherorContainertocollectwaterfromthefaucet

 5galloncontainerordrainbasin

 Sanitizer‐HouseholdBleach(5.25%SodiumHypochlorite)orCitricAcidBasedCleaner

 ¼”PlasticTubing,atleast4feetinlength,andassorted¼”quickconnectfittings

 TDSMeterandTestStripsformeasuringchlorine‐Optional



1. UnpacktheWaterlogicWL200andcheckexteriorfordamage.





Sanitizing



SanitizeusingaHouseholdBleach(5.25%SodiumHypochloritesolution)orotherapproved

cleanerthroughoutthecoldandsparklingwatercircuits.Followallinstructionsonthesanitizer

andflushwithfreshwaterthroughthefaucetuntilodorandtasteisacceptable.



WARNING!USEPROPERPERSONALPROTECTIVEEQUIPMENT

Alwaysensureproperventilationanduseproperpersonalprotectiveequipmentsuchasgloves

andeyeprotectionwhenusingchemicals.RefertoMaterialSafetyDataSheetforspecific

requirementsofeachchemicalproduct.Takeallnecessaryprecautionstopreventsanitizerfrom

contactingeyes,clothing,andanyothersurfacesincoulddamage(carpets).



2. Put1teaspoonofsanitizerperdirectionsoruseBleachSolution(1teaspoon=1/6oz.=5ml=½

capfull)ofhouseholdbleach(SodiumHypochlorite5‐10%Concentration)intheSanitizing

Cartridge.Alwaysensuresanitizeriscompatiblewithstainlesssteelandacetylplastic.



3. Connectsanitizingcartridgetoinletwatersupplyandconnecttoinletbulkheadfittingonbackof

unit.Turnonwatersupply.



4. ConnectpowertoWL200.DONOTTURNONREDPOWERSWITCHATTHISTIME

O=OFF.



WL200Operating,Installation,andServiceManual Page13‐Revision:4‐13‐2016

FilltheColdCircuitwithSanitizer



5. Depressthemaindispensingbuttononthefrontcontrolpaneluntilcoldwater/sanitizingsolution

comesoutthefaucet.NOTE:Containeranddrainbasinwillberequiredtocatchthewaterfrom

thefaucet.



WARNING!UsePersonalProtectiveEquipment.GlovesandEyeProtectionRequired.Thefirst

2or3gallonsofwaterwillcontainconcentratedsanitizer.Useextremecare!



6. TurnoffwatersupplyandremoveSanitizingCartridgefrominletwatersupply.Reconnectwater

supplytoinletbulkheadfitting.



FlushFilters



CAUTION!FILTERFLUSHREQUIRED.



WL200’sarenotsuppliedwithfilters.Filtersshouldbeconfiguredtooptimizeyoursystem.Filters

needtobeconfiguredandspecifiedtodothejobgiventhelocalwaterconditions,usage,

maintenanceschedule,andplacementrestrictions.



Inorderforthefilterstoperformasrepresentedandtoprovidethebestqualitywaterpossible,it

isessentialthatfiltersbereplacedperiodically.Thefrequencyoffilterchangesdependsuponyour

waterqualityandyourwaterusage.Forexample,ifthereisalotofsedimentand/orparticlesin

yourwater,thenyouwillhavetochangeyourfiltersmorefrequentlythanalocationwithlittleto

nosediment.Besuretoreplaceyourfilterswheneveryounoticeadeclineintheperformance,

whetheritisadropinflowrateand/orpressureoranunusualtasteinthewater.



7. Flushthoroughlyperfiltermanufacturers’recommendationwithfreshwatertodrain.



8. Onceflushed,installthefilters.Followingtheflowdirectiononthefilter.



NOTE:



Filtersshouldnotbeflushedpriorto24hoursbeforeinstallationtolimitMicrobial

Growth.



9. ConnectWL200topower.





WL200Operating,Installation,andServiceManual Page14‐Revision:4‐13‐2016

FlushingtheSanitizerfromtheMachine



10. Placeapitcher,catchbasin,orothercontainerunderthefaucetoftheWL200.



11. FlushtheColdTank.Runseveralgallonsofwaterthroughthefaucetbydispensingcoldwaterto

diluteandremovethesanitizerfromthecoldcircuit.Youcanusechlorineteststripstoevaluate

thewater.



12. Oncethesanitizerodor/tastehasbeenflushedoutofthecoldsideofthemachineth

e

sanitizationprocessfortheColdCircuitisnowcomplete.





WL200Operating,Installation,andServiceManual Page15‐Revision:4‐13‐2016

WL200COUNTERTOPDRAININGINSTRUCTIONS



DrainingNotes



DraintheWL200fortransportation.



WARNING!STOREUNITEMPTY.ALWAYSSANITIZEBEFOREREUSE.

Theunitmustbecompletelydrainedandsealedbeforestoringtoavoidstagnationandreduce

microbialgrowth).



DisableColdTank



1. TurnofftheRedPowerSwitchtodisablecompressor.O=OFF



TurnoffWaterSupplyandBleedWaterPressure



2. Isolatetheunitfromfeedwaterbyturningoffthesupply.

3. Dispensecoldstillwatertorelieveanypressurebuiltupinthesystem.

4. Removethewatersupplylinefromtheinletlinebulkheadfittingatbackofmachine.

5. Installdustcaporplugintowatersupplylinebulkheadfitting.



DraintheColdWaterTankandCircuit



6. Removetopcover.



7. Removefrontpanel.Remove2Phillipscrews

securingfrontpanel.Unseatfaucetassembly

frompanel.UnclipwiresfromPCB.



WL200Operating,Installation,andServiceManual Page16‐Revision:4‐13‐2016

8. Disconnecttubingfrominletelbowfrom

solenoidandallowwatertodrain.



9. Reconnecttubingintoinletelbow,



10. Dryinsideofunit.



11. Replacefrontpanel.





WL200Operating,Installation,andServiceManual Page17‐Revision:4‐13‐2016

WL200TOWERDRAININGINSTRUCTIONS



DrainingNotes



DraintheWL200fortransportation.



WARNING!STOREUNITEMPTY.ALWAYSSANITIZEBEFOREREUSE.

Theunitmustbecompletelydrainedandsealedbeforestoringtoavoidstagnationandreduce

microbialgrowth).



DisableColdTanks



1. TurnofftheRedPowerSwitchtodisablethecompressor.O=OFF



TurnoffWaterSupplyandBleedWaterPressure



2. Isolatetheunitfromfeedwaterbyturningoffthesupply.

3. Dispensecoldstillwatertorelieveanypressurebuiltupinthesystem.

4. Removethewatersupplylinefromtheinletlinebulkheadfittingatbackofmachine.

5. Installdustcaporplugintowatersupplylinebulkheadfitting.



DraintheColdWaterTankandCircuit



6. Removelowerfrontpaneltoaccesstankfeedlines.



 



7. Disconnecttanklinefeedlinefromcoldinletsolenoidto

drainintobasinorcatch.



8. Reconnecttubingintoinletelbowoncedrained.



9. Dryinsideofunitifnecessary.



10. Replacelowerfrontpanel.



WL200Operating,Installation,andServiceManual Page18‐Revision:4‐13‐2016

INSTALLATIONPROCEDURES



SafetyandInstallationGuidelines

EnsureallLocal,State,andFederalLawsandCodesincludinghealthandsafetyguidelinesaremet

wheninstallingWaterlogicEquipment.Onlyqualifiedservicetechniciansshouldattempt

installationandserviceofWaterlogicEquipment.



WARNING!ELECTRICALSHOCKHAZARD.Alwaysunplug(isolatefrompowersupply)toprevent

electricalshockexceptwhereelectricaltestsarespecified.



WARNING!IMPROPERSUPPLYORCONNECTIONCANRESULTISRISKOFSHOCK.

Connecttoa15amp120V60Hzproperlygroundedoutlet(GFIisrecommended).Ensurepolarityis

correctandalwaysusea3‐prongoutlet.Consultaqualifiedelectricianifyouhaveanyquestions.



WARNING!USEONLYWaterlogicSUPPLIEDPOWERCORD.Locatesystemwithin5feetof

powersupply.Neveruseanextensioncordoradapter.Donotuseadamagedpowercordorplug.

Keeppowercordoutofheavytrafficareasandawayfromheatsources.Donot,underany

circumstances,removegroundprongoralterthepowercord.Neverpullthepowerplugfromthe

outletwithawethandorallowtheplugtogetwet.Failuretousethesuppliedpowercordwillvoid

ULCertificationandWarranty.



CAUTION!INDOORUSEONLY.Neverexposetodirectsunlight,heatsources,orambientair

temperatureabove100°F(37°C)orbelow35°F(2°C).Installindoorsandkeepunitawayfrom

excessivehumidity.Neverexposetofreezingtemperatures.Ensurethereisadequateclearance

aroundtheunittoallowrefrigerationsystemcondensertodissipateheat.Warmerenvironments

requiremoreclearancearoundtheunit.Minimumclearancearoundallsurfacesofthemachineis2‐

inches.Installswheretheambienttemperatureexceed80F,requireaminimumof4‐inchesclearance

forproperheatdissipationandefficientoperation.



CAUTION!USEAWATERPRESSUREREGULATOR.Waterlogicwillnotberesponsibleforinjuryor

damagecausedbyexcessivewaterpressure.Operatingpressuremustbe40psito60psi.Beaware

anyofpotentialpressuresurgescausedbybuilding/municipalpumpingstations.



CAUTION!USEUVSTABILIZEDSUPPLYLINES.Feedtheunitwithapotableambientorcold

watersupplyonly.Feedwaterover100°F(37°C)candamagethetreatmentcomponents.Water

blockdevicesandexternalleakdetectorsarestronglyrecommended.Locatetheunitasclosetothe

watersupplyandtheelectricalconnectionsaspossible.



WARNING!STOREANDTRANSPORTUNITEMPTY.ALWAYSSANITIZEBEFOREUSE.

Theunitmustbecompletelydrainedandsealedbeforestoringtoavoidstagnationandreduce

microbiologicalcontamination(potentialbacterialgrowth).Sanitizebeforeusetoeliminateany

potentialmicrobiologicalcontaminates



Pre‐installationandsanitizationproceduresasprescribedinthismanualmustbeperformedbefore

installingtheWL200.



AlwaysinstallindoorsandplacetheWaterlogicWL200onafirm,flatandstablesurface.



WL200Operating,Installation,andServiceManual Page19‐Revision:4‐13‐2016



1. Attachthewatersupplylinetothe1/4”feedwaterinletbulkheadfittingonthebackoftheunit.

Waterlogicrequirestheuseofawaterpressureregulator.Waterfeedpressuremustbe

between40‐60psi.Turnonthewa tersupplyandcheckforleaks. 





2. ChecktoensurethattheRedPowerSwitchisoff.O=OFF



3. ConnectthepowercordtothebackoftheWaterlogicWL200andtoa120Voltsupply.



4. FilltheColdTank.Holdacontainerunderthedispensingfaucet,pressandholdthemain

dispensingbuttonuntilacontinuousflowofwaterisobtained.Onceacontinuousflowis

obtained,releasethedispensingbutton.Coldtankisnowfull.



5. MovetheWaterlogicWL200intoitsfinaloperatingposition.Be surethataminimumof2”

clearanceismaintainedaroundboththesidesandthebackoftheunit.Thisisimportanttoallow

properairflowandheatexchangeofrefrigerationsystem.



6. Levelunitusingtheadjustablefeettolevelifnecessary.Neverinstallonincline.



7. TurntheRedPowerSwitchon.I=ON.



8. WhentheunithasreacheditsColdTempSetPointTemperature,thecompressorwillcycleoff.



9. Oncetheunitisatthetargettemperature(s),samplethewatertoensurewatermeets

expectationsandadditionalrinsingoradjustmentisnotrequired.



10. Checktheunitforanyleaks.ExternalLeakProtectionisalwaysrecommended.



WL200Operating,Installation,andServiceManual Page20‐Revision:4‐13‐2016

SERVICEREQUIREMENTS



WARNING!Readandunderstandthecontentsofthismanualbeforeattemptingtoservice

WL200.Failuretofollowtheinstructionsinthismanualcouldresultindeath,seriouspersonal

injury,orseverepropertydamage.Onlytrainedandqualifiedtechniciansshouldattemptto

install,maintain,orserviceWaterlogicEquipment.



1. Visuallyinspectallelectricalandwaterconnectionsforsignsofwearordamage.



DANGER!HIGHVOLTAGEELECTRICALHAZARD.Unplugbeforeinspectionandservice.



2. Ensurethereisadequate(minimumof2”)clearancearoundtheunitandcleanthecondensergrill

andcompressorfantoprovideefficientcoolingsystemoperation.



3. Sanitizethecoldtankperinstructionsinthepre‐installationprocedures.



4. Cleanandsanitizeexternalsurfacesoftheunit.Usesoapandwaterorchemicalsthatare

compatiblewithABSplasticandwillnotdamageordegradetheproductsurfaces.



5. RemoveandcleantheFaucet.Replaceasneeded.



WARNING!SANITIZERMAYCONTAINHAZARDOUSCHEMICALS.Useofproperpersonal

protectiveequipmentsuchasrubberglovesandeyeprotectionisrequired.





WaterLogic WL200 Operating, Installation And Service Manual

Related papers

Other documents