Diebold Nixdorf CINEO T2000 Operating instructions

Installation Guide & Operating Manual

CINEO T2000 BMW

Supplement

Self-Service

Systems

Questions and suggestions

CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

Do you have ...

... any questions or suggestions

regarding this manual?

Please contact the following address

giving the order number of this manual

in your message:

Address:

WINCOR NIXDORF International GmbH

Handbuchredaktion R&D ACT 12

D - 33094 Paderborn

Germany

Fax: +49 (0) 52 51 693-62 09

E-mail: [email protected]

... any technical questions or problems?

Please conctact your local representative.

April Edition 2014

CINEO T2000 BMW

Supplement

Installation Guide & Operating Manual

CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

All rights, including rights of translation

and rights of reproduction by reprinting,

copying or similar methods, even of

parts, are reserved.

Any violations give rise to a claim for

damages.

All rights, including rights created by

patent grants or registration of a utility

model or design, are reserved. Delivery

subject to availability; right of technical

modifications reserved.

All names of hardware and software

products mentioned in this manual are

trade names and/or trademarks of their

respective manufacturers.

This manual was

produced using paper

treated with chlorine-free

bleach.

01750263559 A CINEO T2000 BMW - Installation Guide & Operating Manual I

Contents

Introduction ............................................................................................... 1

Symbols used in this manual ...................................................................... 1

Important safety precautions ...................................................................... 2

Installation note ...................................................................................... 2

General safety precautions .................................................................... 2

General power interruption ......................................................................... 5

Planning the installation .......................................................................... 7

Device dimensions ...................................................................................... 7

CINEO T2000 BMW .............................................................................. 8

Installation options ...................................................................................... 9

Installation .............................................................................................. 9

Device view ....................................................................................... 9

Necessary operation and maintenance space .......................................... 11

Installation ............................................................................................... 13

Removing the transport packing ............................................................... 13

Mounting material ..................................................................................... 14

Installing the CINEO T2000 BMW ............................................................ 15

Device overview ...................................................................................... 17

Overall view .............................................................................................. 18

Basic operation ....................................................................................... 19

Opening the device door ........................................................................... 19

Inserting IDs .............................................................................................. 19

Paper level indicator ................................................................................. 20

Appendix .................................................................................................. 21

Check list for installation preparations for self-service systems ............... 21

General information ............................................................................. 22

Preparations ........................................................................................ 22

Construction work ........................................................................... 22

Power and data cables ................................................................... 23

Organizational preparations............................................................ 23

Delivery and installation .................................................................. 24

Flooring materials on the path of transport ..................................... 24

Notes concerning installation preparation ............................................ 25

Contents

II CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

Technical Data .......................................................................................... 27

Installation specifications ................................................................ 27

Compliance with standards and certifications ........................................... 28

Standards met ...................................................................................... 28

Conformity ............................................................................................ 28

Notes concerning radio interference suppression and electrical

safety .................................................................................................... 29

Certification for data transmission ....................................................... 29

FCC rules and Canadian Standard ICES - 003 ................................... 29

Environmental protection .......................................................................... 29

Environmentally and recycling-friendly product development .............. 29

Saving energy ...................................................................................... 30

Disposing of used consumables .......................................................... 30

Labels on plastic case parts ................................................................. 30

Returning, recycling and disposing of used units and

consumables ........................................................................................ 30

01750263559 A CINEO T2000 BMW - Installation Guide & Operating Manual III

Abbreviations

C

CE Communauté Européenne

(European Community)

Declaration of Conformity

CEN Comité Européen de

Normalisation (European

Committee for

Standardization)

CIM Card Identification Module

(security module)

D

DT Data Transmission

E

EDM Encryption/Decryption

Module

EEC European Economic

Community

EMA Intruder alarm system

EMC Electromagnetic

Compatibility

EPP Encrypted PIN Pad

G

GmbH Limited liability company

M

MM Modular Marker of ID card

(evaluation by means of

security modules like MM

box or CIM 06)

R

RoHS Restriction of the use of

certain Hazardous

Substances (directive on

restricting the use of

certain harmful

substances in electrical

and electronic equipment)

S

SELV Safety Extra-Low Voltage

U

UL Underwriters Laboratories

Inc.

UPS Uninterruptible Power

Supply

Abbreviations

IV CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

01750263559 A CINEO T2000 BMW - Installation Guide & Operating Manual 1

Introduction

This supplementary operating manual contains specifications for project-

specific changes and replaces in part the CINEO T2000 operating instructions

(01750189197) and the operating instructions (01750189195).

Symbols used in this manual

 Text following this mark represents an item in a list.

" " Text in quotation marks contains references to other chapters or sections in

this document.

 Paragraphs following this symbol are actions to be performed in the order

in which they are specified.

Text following this symbol should be given special attention in order to

avoid damage and injury.

i

This symbol identifies paragraphs which contain general notes to

facilitate use of the device and help avoid operating errors.

Important safety precautions Introduction

2 CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

Important safety precautions

Please read the following notes carefully before doing any work on the

device.

Be careful not to injure your head when the customer panel or the

operating unit door are lifted up!

Installation note

 When installing the device and/or doing any work on it, make sure that it is

disconnected from power.

 Remove the shipping restraints inside the unit which secure its components

during transportation if necessary for the installation (see enclosed

information sheet).

General safety precautions

This device complies with the relevant safety regulations for information

processing equipment.

 For reasons of stability, the device must be screwed to the load-bearing

substructure of the installation site or mounted on a suitable base.

 When moving the device from a cold to a warm environment, do not

operate it for at least two hours to prevent possible damage caused by

condensation.

 Only use the original packaging material to transport the device.

 Note the warning and information labels on the device.

 Unless otherwise stated, grasp the components only by the green ledge

when handling them.

 The device is equipped with a safety-tested power cable which must be

connected only to a suitable grounded outlet.

 Always hold the plug when removing the power cable. Never pull the cable

itself.

 Install cables in such a way that they will not be stepped on or tripped over

or damaged or crushed in any way.

Introduction Important safety precautions

01750263559 A CINEO T2000 BMW - Installation Guide & Operating Manual 3

 Have damaged power cables replaced immediately.

 Make sure that there is always free access to the sockets used or to the

electrical circuit-breakers of the house installation.

 In case of an emergency (e.g. damaged cabinets, controls or power cables,

liquids or foreign objects in the device) take the following steps:

Deactivate the device immediately by:

Switching off the automatic circuit-breaker or removing the fuse inset

from the fuse holder in the distribution box of the building installation;

Disconnecting the plug connector of the power supply cable from the

grounded socket in the building installation;

Switching off the ON/OFF switch on the power distributor;

Interrupting the power connection, if there is one, between the UPS

(uninterruptible power supply) and the device (see chapter

“Introduction” section "General power interrupt" in the operating

manual);

 During a thunderstorm, data transmission lines must not be connected or

disconnected.

 Always keep the device's vents free from obstruction to ensure proper air

circulation and to prevent malfunctions resulting from overheating.

 Only use accessories and extension components that have been approved

by us. Nonobservance can result in damage to the device or violations of

regulations concerning safety, radio interference and ergonomical

requirements.

 Note that there are only safety extra-low voltage circuits (SELV circuits) if

you want to feed voltage from an external source into prepared cables to

install additional electronics (e. g. EMA connection, relay panel for external

features).

 To clean and maintain the device only use cleaning agents approved by

WINCOR NIXDORF International GmbH (see chapter "Appendix" in the

operating manual).

Important safety precautions Introduction

4 CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

Repairs

Repair work may only be carried out by authorized personnel.

Unauthorized opening of the device or repair work carried out

improperly could result in considerable danger to the user.

In case of noncompliance, WINCOR NIXDORF International GmbH

excludes all liability.

Lithium batteries

The handling and the replacement should only be performed by

authorized service personnel who were trained by the

WINCOR NIXDORF International GmbH.

There is danger of fire or explosion if the batteries are handled

improperly. It is therefore important to note the following points:

– Avoid short circuits

– Never recharge the battery

– Avoid temperatures above +100 °C (+212 °F).

– Do not try to open the battery by force

– Do not allow the battery to come in contact with water or fire

The battery should only be replaced with the same or an equivalent

type recommended by WINCOR NIXDORF International GmbH (see

chapter “Appendix,” section “Consumables”).

Dispose of used batteries in compliance with national regulations and

the manufacturer's specifications.

Start-up

i

Before operating the device, remove all parts inside of it which secure

its components during transportation or check whether they have been

removed (see info sheet supplied with the device).

Introduction General power interruption

01750263559 A CINEO T2000 BMW - Installation Guide & Operating Manual 5

General power interruption

 Shut down the device in a controlled manner and switch it off

(see operating manual "„CINEO T2000", chapter "Basic Operation", section

"Switching the device on/off").

Detach the rubber plug of the power

cable (power supply input) from the

power supply (1).

General power interruption Introduction

6 CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

01750263559 A CINEO T2000 BMW - Installation Guide & Operating Manual 7

Planning the installation

This chapter provides you with all the information you need to prepare the

installation.

Device dimensions

i

All dimensions are specified in millimeters (inches). The device views

are not drawn to scale.

i

From the time of installation up to the start-up of the device, the

climatic environmental conditions for storage must be met (see

chapter "Appendix", Section "Technical data").

Make sure that the values are neither higher nor lower

than the specified values to prevent irreparable damage to the device.

In the event of non-compliance, Wincor Nixdorf International GmbH

shall not assume liability for any damage that is caused to the device.

Device dimensions Planning the installation

8 CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

CINEO T2000 BMW

1813 (71,38")

1413 (55,63")

1208 (47,56")

8 (0,31")

50 (1,97")

700 (27,56")

650 (25,59")

498 (19,61")

800 (31,5")

700 (27,56")

Planning the installation Installation options

01750263559 A CINEO T2000 BMW - Installation Guide & Operating Manual 9

Installation options

The CINEO T2000 BMW has been designed for indoor installation and is set

up with an adapter plate on the protection bumper. It is installed without an

installation frame.

i

Note the corresponding operation and maintenance space (see

section "Space required for operation and maintenance").

Installation

Device view

Installation options Planning the installation

10 CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

2

3

1

LAN connection 1

2

LAN connection 2

3

Power plug

Planning the installation Necessary operation and maintenance space

01750263559 A CINEO T2000 BMW - Installation Guide & Operating Manual 11

Necessary operation and maintenance

space

Operation and maintenance space

4

8

3

(

1

9

,

0

2

"

)

800 (31,5")

249

(9,8")

1049 (41,3")

583 (22,96")

1183 (46,57")

Necessary operation and maintenance space Planning the installation

12 CINEO T2000 BMW - Installation Guide & Operating Manual 01750263559 A

Page is loading ...

Diebold Nixdorf CINEO T2000 Operating instructions

Diebold Nixdorf CINEO T2000 Operating instructions

Related papers

Other documents