NEC NP-ME402X Installation guide

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

1 of 10

For customer care call 1-800-865-2112

Installation and Assembly Manual:

Custom Ceiling Mount for NEC M260X, M260W, M271X, M300X,

M300W M300XS, M300WS, M311X, M311W, P350X, P350W, P420X

Projectors

Model: MP300CM

Features:

• ImageLock

alignmentpreventspicturesagordrift

• Wrenchaccessslotforeasierushmountinstallations

• Exclusivealuminumtrackquickrelease

NECDisplaySolutionsofAmerica,Inc.

Max UL Load Capacity:50lb(22.7kg)

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

2 of 10

For customer care call 1-800-865-2112

Table of Contents

PartsList.................................................................................................................................................................................3

InstallationtoExtensionColumns/CeilingPlate...................................................................................................................4

InstallationtoWoodJoistCeilings..........................................................................................................................................5

InstallationtoConcreteCeilings.............................................................................................................................................6

InstallationtoThreadedRods.................................................................................................................................................7

AttachingAdapterPlatetoProjector.......................................................................................................................................8

AttachingAdapterPlatetoProjectorMount............................................................................................................................9

ProjectorAlignment..............................................................................................................................................................10

Tools Needed for Assembly

• studnder("edgetoedge"studnderisrecommended)

• phillipsscrewdriver

• drill

• 5/16"bitforconcretesurface

• 5/32"bitforwoodstuds

• level

NOTE:Readentireinstructionsheetbeforeyoustartinstallationandassembly.

• DonotbegintoinstallyourPeerlessproductuntilyouhavereadandunderstoodtheinstructionsandwarnings

containedinthisInstallationSheet.Ifyouhaveanyquestionsregardinganyoftheinstructionsorwarnings,please

callPeerlesscustomercareat1-800-865-2112.

• Thisproductshouldonlybeinstalledbysomeoneofgoodmechanicalaptitude,hasexperiencewithbasicbuilding

construction,andfullyunderstandstheseinstructions.

• Makesurethatthesupportingsurfacewillsafelysupportthecombinedloadoftheequipmentandallattached

hardwareandcomponents.

• NeverexceedtheMaximumULLoadCapacity.Seepage1.

• Ifmountingtowoodjoistceilings,makesurethatmountingscrewsareanchoredintothecenterofthejoist.Useof

an"edgetoedge"studnderishighlyrecommended.

• Alwaysuseanassistantormechanicalliftingequipmenttosafelyliftandpositionequipment.

• Tightenscrewsrmly,butdonotovertighten.Overtighteningcandamagetheitems,greatlyreducingtheirholding

power.

• Thisproductisintendedforindooruseonly.Useofthisproductoutdoorscouldleadtoproductfailureandpersonal

injury.

• Thisproductwasdesignedandintendedtobemountedtothefollowingsupportingsurfacescheckedbelowwith

thehardwareincludedinthisproductasspeciedintheinstallationsheet.Tomountthisproducttoanalternative

supportingsurface,contactPeerlesscustomercareat1-800-865-2112.

• Thisproductwasdesignedtobeinstalledonthefollowingceilingconstructiononly;

 CEILING CONSTRUCTION ADDITIONAL HARDWARE REQUIRED

x WoodStud   None

 x WoodJoist   None

 x SolidConcrete   None

  CinderBlock   ContactCustomerService

  Brick    ContactCustomerService

  Otherorunsure?  ContactCustomerService

WARNING

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

3 of 10

For customer care call 1-800-865-2112

Description Qty. Part #

projectormountassembly 1

054-2171

4mmsecurityallenwrench 1

560-9646

#10-32x3/8"serratedwasherheadsocketpinscrew 2

520-2151

#10-32x1/4"socketpinscrew 1

520-2196

flatwasher

2 540-1078

#14x2.5phillipshexheadwoodscrew 2

5S1-015-C04

G concreteanchor 2 590-0320

adapterplate 1 055-2985

BB M4x16mmserratedsocketpinscrew 3 510-2087

CC retainingspacer 3 590-2009

DD 2mmallenwrench 1 560-1097

EE connectionblock 1 580-4065

Parts List

NOTE:Actualpartsmayappearslightlydifferentthanillustrated.

Beforeyoustartcheckthepartslisttoinsureallofthepartsshownareincluded.

E F

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

4 of 10

For customer care call 1-800-865-2112

Installation to Extension Column / Ceiling Plate

NOTE: Refertoaccompanyinginstructionswithceilingplates(soldseparately)forinstallingthesemodelsto

ceiling.

Screwprojectormountassembly(A)ontoextensioncolumnasshownin gure 1.1.Tightenswivelstopscrew

againstextensioncolumn,ushmounttubeorreducerusing4mmsecurityallenwrench(B)asshowningure

1.2.

NOTE: Swivelstopscrewisusedtojamagainstthreadsofextensioncolumn,ushmounttubeorreducerto

preventanyexcessmovementofprojectormountassembly(A).Donotovertightenscrew;overtighteningscrew

willdamagethreadsmakingitdifculttoseparateproducts.

Skip to step 5.

g. 1.1

g. 1.2

1-1/2"EXTENSIONCOLUMN

(SOLDSEPARATELY)

(ULLISTEDEXTORAECSERIES)

ARROWINDICATES

FRONTOFMOUNT

SWIVELSTOPSCREW

CMJ455

(SOLDSEPARATELY)

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

5 of 10

For customer care call 1-800-865-2112

Placeprojectormountassembly(A)onceilingasatemplateandmarkthecenterofthetwomountingholes.

Makesurethatthemountingholesareinthecenterofthewoodjoist.Drilltwo5/32"(4mm)dia.holestoa

minimumdepthof2.5"(64mm).Attachprojectormountassembly(A)withtwo#14x2.5"woodscrews(F)and

twoatwashers(E)asshowningure 2.1orgure 2.2dependingonjoistorientation.

NOTE: Mountingslotsonprojectormountassemblyallowfor30°(±15°)ofswiveladjustmentbeforefullysecuring

woodscrews.

Tightenwoodscrews(F)using3/8"(10mm)socketwrench,phillipsscrewdriveror10mmopenendwrenchuntil

projectormountassembly(A)isrmlyattached.

Skip to step 5.

Installation To Wood Joist Ceilings

• Installermustverifythatthesupportingsurfacewillsafelysupportthecombinedloadoftheequipmentandall

attachedhardwareandcomponents.

• Tightenwoodscrewssothatprojectormountassemblyisrmlyattached,butdonotovertighten.Overtightening

candamagethescrews,greatlyreducingtheirholdingpower.

• Nevertighteninexcessof80in.•lb(9N.M.).

• Makesurethatmountingscrewsareanchoredintothecenterofthestud.Theuseofan"edgetoedge"studnder

ishighlyrecommended.

• Hardwareprovidedisforattachmentofmountthroughstandardthicknessdrywallorplasterintowoodstuds.

Installersareresponsibletoprovidehardwareforothertypesofmountingsituations(notevaluatedbyUL).

WARNING

WOODJOIST

FRONTOF

MOUNT

WOODJOIST

ACCESSSLOTFOR

OPENENDWRENCH

ALLOWSTIGHTENING

OFWOODSCREW

g. 2.1

g. 2.2

ARROWONTOPOF

PROJECTORMOUNT

ASSEMBLYINDICATES

FRONTOFMOUNT

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

6 of 10

For customer care call 1-800-865-2112

g. 3.1

Installation to Concrete Ceilings

Placeprojectormountassembly(A)onceiling

asatemplateandmarkthecenterofthetwo

mountingholes.Drilltwo5/16"(8mm)dia.holes

toaminimumdepthof2-1/2"(64mm).Attach

projectormountassembly(A)usingtwoconcrete

anchors(G),twoatwashers(E),andtwo#14x

2-1/2"woodscrews(F)asshowningure 3.1.

NOTE: Mountingslotsonprojectormount

assemblyallowfor30°(±15°)ofswiveladjustment

beforefullysecuringwoodscrews.

Tightenwoodscrews(F)using3/8"(10mm)socket

oropenendwrenchorphillipsscrewdriveruntil

projectormountassembly(A)isrmlyattached.

• Concretemustbe2000psidensityminimum.Lighterdensityconcretemaynotholdconcreteanchor.

• Makesurethatthesupportingsurfacewillsafelysupportthecombinedloadoftheequipmentandallattached

hardwareandcomponents.

WARNING

• Alwaysattachconcreteanchorsdirectlytoload-

bearingconcrete.

• Neverattachconcreteanchorstoconcretecovered

withplaster,drywall,orothernishingmaterial.

Ifmountingtoconcretesurfacescoveredwitha

nishingsurfaceisunavoidable(notevaluatedby

UL),thenishingsurfacemustbecounterbored

asshownbelow.Besureconcreteanchorsdonot

pullawayfromconcretewhentighteningscrews.If

plaster/drywallisthickerthan5/8",customfasteners

mustbesuppliedbyinstaller(notevaluatedbyUL).

WARNING

• Tightenwoodscrewsrmly,butdonotovertighten.

Overtighteningcandamagethescrews,greatly

reducingtheirholdingpower.

• Nevertighteninexcessof80in•lb(9N.M.).

WARNING

CUTAWAY VIEW

CORRECT

plaster/

drywall

concrete

INCORRECT

plaster/

drywall

concrete

CONCRETECEILING

ARROWONTOP

OFPROJECTOR

MOUNTASSEMBLY

INDICATESFRONT

OFMOUNT

Drillholesandinsertanchors(G).

Placeplate(A)overanchors(G)andsecurewithscrews(F).

Tightenallfasteners.

F E

concrete

surface

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

7 of 10

For customer care call 1-800-865-2112

Threadtwo1/4-20hexthinnylon-insertlocknuts(notincluded)ontwo1/4-20threadedrods(notincluded)tothe

desiredheightofprojectormountassembly.Attachprojectormountassembly(A)tothetwo1/4-20threadedrods

usingtwo1/4-20hexthinnylon-insertlocknutsasshowningure 4.1orgure 4.2.

Installation to Threaded Rod

(Not evaluated by UL - Professional installation only)

1/4-20THREADEDROD

(NOTINCLUDED)

1/4-20THREADEDROD

(NOTINCLUDED)

1/4-20HEXTHIN

NYLON-INSERT

LOCKNUT

(NOTINCLUDED)

1/4-20HEXTHIN

NYLON-INSERT

LOCKNUT

(NOTINCLUDED)

1/4-20HEXTHIN

NYLON-INSERT

LOCKNUT

(NOTINCLUDED)

1/4-20HEXTHIN

NYLON-INSERT

LOCKNUT

(NOTINCLUDED)

ARROW

INDICATES

FRONTOF

MOUNT

ARROW

INDICATES

FRONTOF

MOUNT

g. 4.1

g. 4.2

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

8 of 10

For customer care call 1-800-865-2112

Alignshoulderonconnectionblock(EE)opposite

notchinadapterplate(AA).Attachadapterplate

(AA)toconnectionblock(EE)usingtwo#10-32x

3/8"serratedwasherheadsocketpinscrews(C)

asshowningure5.1.Tightenscrewsusing4mm

allenwrench(B).

NOTCHINDICATES

FRONTOFPROJECTOR

SHOULDER

Attaching Adapter Plate to Projector

g. 5.1

Flipprojectorupsidedownandattachadapterplate(AA)usingfourserratedsocketpinscrews(BB)andretaining

spacers(CC)asshownbelow.Tightenusing4mmallenwrench(B).

NOTE:Retainingspacers(CC)gobetweentheprojectorandadapterplate(AA).

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

9 of 10

For customer care call 1-800-865-2112

Slideconnectionblock(EE)withprojectorintoprojectormountassembly(A)asshown.Tightencaptivescrewto

secureprojectortoprojectormountassembly(A).

IMPORTANT:Forsecurityinstallations,insertone#10-32x1/4"socketpinscrew(D)throughprojectormount

assembly(A)andintoconnectionblock(EE)asshownindetail1.Tightenscrewusing4mmsecurityallen

wrench(B).

• Donotliftmoreweightthanyoucanhandle.Useadditionalmanpowerormechanicalliftingequipmenttosafely

handleplacementofthescreen.

WARNING

Attaching Adapter Plate to Projector Mount

DETAIL 1

FRONTOFMOUNT

CAPTIVESCREW

ARROWINDICATES

FRONTOFMOUNT

ISSUED: 10-01-10 SHEET #: 056-9034-4 07-29-11

Visit the Peerless Web Site at www.peerlessmounts.com

10 of 10

For customer care call 1-800-865-2112

SCREWFORYAW(SWIVEL)STOP

(REFERTOSTEP1,INSTALLATION

TOEXTENSIONCOLUMNS,FIG.1.2)

KNOBFORROLL

ADJUSTMENT

KNOBFORPITCH

ADJUSTMENT

BACKOFMOUNT

ARROWINDICATES

FRONTOFMOUNT

To adjust yaw (swivel) for wood stud, concrete ceiling, and threaded rod mounting applications: Loosen

woodscrews(F)ifushmountedtowoodjoists(page5)orconcreteceilings(page6),orloosenlocknutson

threadedrods(page7),untilprojectormountcanberotated.Rotatemounttodesiredpositionandretighten

screwsorlocknuts.

To adjust yaw (swivel) for extension column applications:Loosenscrewonprojectormountassembly(A)

indicatedbelowuntilprojectormountcanberotated.Rotatemounttodesiredpositionandretightenscrew.

To adjust pitch (forward and backward tilt):Turnknobonbackofmountasshownbelow.Pullknoboutand

turnbyhandforeasyadjustmentorinsert#2phillipsscrewdriverinendofknobandturn.

To adjust roll (side to side tilt):Turnknobonsideofmountasshownbelow.Pullknoboutandturnbyhandfor

easyadjustmentorinsert#2phillipsscrewdriverinendofknobandturn.

To prevent tampering with the pitch and roll adjustments: Tightenthetwotamperresistantsecurityscrews

ontheprojectormountassemblyusing4mmsecurityallenwrench(B)tolockthepitchandrolladjustmentsas

shownbelow.Note:Tightenscrewsrmly,butdonotovertighten.Overtighteningcandamagethemount.

SIDE VIEW

Projector Alignment

9-1

TOLOCKPITCH,TIGHTEN

TAMPERRESISTANT

SECURITYSCREW

Allotherbrandandproductnamesaretrademarksorregisteredtrademarksoftheirrespectiveowners.

• Donotadjustpitchorrollwhiletamperresistantsecurityscrewsarefullyengaged.

• Loosenthetwotamperresistantsecurityscrewsonecompleteturnbeforeadjustingtheprojectormountassembly

ordamagemayoccur.

CAUTION

NEC NP-ME402X Installation guide

Related papers

Other documents