Welch Allyn SCANTEAM 3400PDF User manual

Disclaimer

Welch Allyn



reserves the right to make changes in specifications and

other information contained in this document without prior notice, and the

reader should in all cases consult Welch Allyn to determine whether any

such changes have been made. The information in this publication does

not represent a commitment on the part of Welch Allyn.

Welch Allyn shall not be liable for technical or editorial errors or

omissions contained herein; nor for incidental or consequential

damages resulting from the furnishing, performance, or use of this

material.

This document contains proprietary information which is protected by

copyright. All rights are reserved. No part of this document may be

photocopied, reproduced, or translated into another language without the

prior written consent of Welch Allyn, Incorporated.

 1998 – 1999 Welch Allyn, Inc.

SCANTEAM 3400PDF User’s Guide

This device complies with part 15 of the FCC Rules. Operation is subject to the

following two conditions: (1) this device may not cause harmful interference,

and (2) this device must accept any interference received, including

interference that may cause undesired operation.

This equipment has been tested and found to comply with the limits for a Class A

digital device, pursuant to part 15 of the FCC Rules. These limits are designed

to provide reasonable protection against harmful interference when the

equipment is operated in a commercial environment. This equipment

generates, uses, and can radiate radio frequency energy and, if not installed

and used in accordance with the instruction manual, may cause harmful

interference to radio communications. Operation of this equipment in a

residential area is likely to cause harmful interference, in which case the user

will be required to correct the interference at his own expense.

FCC Class A Compliance Statement

Caution: Any changes or modifications made to this device that are not

expressly approved by Welch Allyn, Inc. may void the user’s authority to

operate the equipment.

Note: To maintain compliance with FCC Rules and Regulations, cables

connected to this device must be

shielded

cables, in which the cable shield

wire(s) have been grounded (tied) to the connector shell.

This equipment does not exceed the Class A limits for radio noise emissions as

described in the Radio Interference Regulations of the Canadian Department of

Communications.

Canadian Notice

Le present appareil numerique n’emet pas de bruits radioelectriques depassant

les limites applicables aux appareils numeriques de la classe A prescrites dans

le Reglement sur le brouillage radioelectrique edicte par le ministere des

Communications du Canada.

SCANTEAM 3400PDF User’s Guide

Welch Allyn shall not be liable for use of our product with equipment

(i.e., power supplies, personal computers, etc.) that is not CE marked and

does not comply with the Low Voltage Directive.

The CE mark on the product indicates that the system has been tested to and

conforms with the provisions noted within the 89/336/EEC Electromagnetic

Compatibility Directive (Class A) and the 73/23/EEC Low Voltage Directive.

i

SCANTEAM 3400PDF User’s Guide

TABLE OF CONTENTS

Section 1 Introduction & Quick Start Menu

Section Page

Introduction 1–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Scanner Identification 1–2. . . . . . . . . . . . . . . . . . . . . . . . . .

Connecting the Scanner 1–3. . . . . . . . . . . . . . . . . . . . . . . .

Scan Maps 1–4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Plug and Play Selections

IBM PC Interface 1–7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

RS232 Interface 1–7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Wand Emulation Interface 1–8. . . . . . . . . . . . . . . . . . . . . . .

Terminal Interface Selections

Supported Terminals 1–9. . . . . . . . . . . . . . . . . . . . . . . . . . .

Reset Factory Settings 1–11. . . . . . . . . . . . . . . . . . . . . . . . .

Status Check 1–11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Section 2 Output Parameters Menu

Section Page

Introduction 2–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Prefix / Suffix Selections

Quick Suffix Selections 2–2. . . . . . . . . . . . . . . . . . . . . . . . .

Primary Interface Prefix Selection 2–4. . . . . . . . . . . . . . . .

Primary Interface Suffix Selection 2–4. . . . . . . . . . . . . . . .

Exit Selection for Prefix / Suffix 2–4. . . . . . . . . . . . . . . . . .

Output Selections

Beeper Volume Selection 2–8. . . . . . . . . . . . . . . . . . . . . . .

Ticking/Scanning Progress Selection 2–8. . . . . . . . . . . . .

Humming/Busy Decoder Selection 2–8. . . . . . . . . . . . . . .

Output Delays Selection 2–9. . . . . . . . . . . . . . . . . . . . . . . .

AutoTrigger Selection 2–10. . . . . . . . . . . . . . . . . . . . . . . . . .

Reread Delay Selection 2–10. . . . . . . . . . . . . . . . . . . . . . . . .

Good Read Delay Selection 2–10. . . . . . . . . . . . . . . . . . . . .

Scan Voting Selection 2–11. . . . . . . . . . . . . . . . . . . . . . . . . .

Code I.D. Transmit Selection 2–11. . . . . . . . . . . . . . . . . . . .

AIM I.D. Transmit Selection 2–11. . . . . . . . . . . . . . . . . . . . .

Function Code Transmit Selection 2–11. . . . . . . . . . . . . . . .

ii

SCANTEAM 3400PDF User’s Guide

Section 2 Output Parameters Menu,

continued

Section Page

Serial Communication Selections

CTS Check Selection 2–12. . . . . . . . . . . . . . . . . . . . . . . . . . .

Baud Rate Selection 2–12. . . . . . . . . . . . . . . . . . . . . . . . . . .

RS-232 Word Length Selection 2–13. . . . . . . . . . . . . . . . . .

Parity Selection 2–14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Protocol Selection 2–14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Data Formatter Selections

Status Check 2–17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Require Data Format 2–17. . . . . . . . . . . . . . . . . . . . . . . . . . .

Data Format Editor 2–17. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Section 3 General Operating Menu

Section Page

Introduction 3–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Wand Emulation Selections

Characters per Data Block Selection 3–2. . . . . . . . . . . . .

Delay Between Data Blocks Selection 3–2. . . . . . . . . . . .

Effective Output Scan Rate Selection 3–3. . . . . . . . . . . . .

Digital Output Signal Polarity Selection 3–3. . . . . . . . . . .

Overall Checksum Selection 3–3. . . . . . . . . . . . . . . . . . . . .

Transmission Rate Selection 3–4. . . . . . . . . . . . . . . . . . . .

Wake Up Pulse Selection 3–4. . . . . . . . . . . . . . . . . . . . . . .

Country Code Selections

Country Keyboard Selection 3–5. . . . . . . . . . . . . . . . . . . . .

Keyboard Selections

Keyboard Style Selection 3–6. . . . . . . . . . . . . . . . . . . . . . .

Keyboard Style Modifiers Selection 3–7. . . . . . . . . . . . . . .

Code Page Selections

Windows/DOS Selection 3–8. . . . . . . . . . . . . . . . . . . . . . . .

PDF Label Character Set Selection 3–8. . . . . . . . . . . . . . .

Section 4 Symbology Menu

Section Page

Introduction 4–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Industrial Symbology Selections

Codabar Selection 4–2. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Code 39 Selection 4–4. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Code 93 Selection 4–6. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Interleaved 2 of 5 Selection 4–7. . . . . . . . . . . . . . . . . . . . .

Code 2 of 5 Selection 4–8. . . . . . . . . . . . . . . . . . . . . . . . . . .

Matrix 2 of 5 Selection 4–8. . . . . . . . . . . . . . . . . . . . . . . . . .

iii

SCANTEAM 3400PDF User’s Guide

Section 4 Symbology Menu,

continued

Industrial Symbology Selections,

continued

Section Page

Code 11 Selection 4–9. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Code 128 Selection 4–9. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Code 128 Function Character Selection 4–10. . . . . . . . . . .

Retail Symbology Selections

Code 49 Selection 4–11. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Code 16K Selection 4–11. . . . . . . . . . . . . . . . . . . . . . . . . . .

EAN Selection 4–12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

UPC Selection 4–13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

EAN Addenda Selection 4–14. . . . . . . . . . . . . . . . . . . . . . . .

UPC Addenda Selection 4–14. . . . . . . . . . . . . . . . . . . . . . . .

MSI Selection 4–15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Plessey Selection 4–15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Stacked Symbology Selections

Section Page

Enable PDF Selection 4–16. . . . . . . . . . . . . . . . . . . . . . . . . .

Show GLI Blocks Selection 4–16. . . . . . . . . . . . . . . . . . . . . .

Macro PDF Selection 4–16. . . . . . . . . . . . . . . . . . . . . . . . . . .

Show Macro Control Blocks Selection 4–17. . . . . . . . . . . .

Section 5 Firmware Utility Menu

Section Page

Introduction 5–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Cloning Utility 5–2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Section 6 Supported Interface Keys

Section Page

Keyboard Function Relationships 6–1. . . . . . . . . . . . . . . .

Supported Interface Keys 6–2. . . . . . . . . . . . . . . . . . . . . . .

Section 7 Product Specifications and Pinouts

Section Page

Environmental Specifications 7–1. . . . . . . . . . . . . . . . . . . .

Electrical Specifications 7–1. . . . . . . . . . . . . . . . . . . . . . . . .

Scanner Performance 7–2. . . . . . . . . . . . . . . . . . . . . . . . . .

Standard Cable Pin Outs 7–3. . . . . . . . . . . . . . . . . . . . . . . .

iv

SCANTEAM 3400PDF User’s Guide

Section 8 Maintenance and Troubleshooting

Section Page

Maintenance 8–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Troubleshooting 8–3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Section 9 Customer Service

Section Page

Obtaining Factory Service 9–1. . . . . . . . . . . . . . . . . . . . . . .

Technical Support 9–2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Limited Warranty 9–3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Default Charts

Programming Chart (inside back cover)

Sample Bar Codes (back cover)

1–1

SCANTEAM 3400PDF User’s Guide

  +''*+ * "#!" )* (*&' .#+ (* *#'!

 ' %#'* * (+ "0 * /%% +-#, (*  .*#,0 ( ))%#,#('+

/#," #',!*, (#'! ' $0(* /!  (* /' &-%,#('

(-,)-,+ .#%%

" +''* '  )*(!*&& (* &'0 (&&-'#,#('+ )*&,*+ '

#')-,(-,)-, )*(,((%+ (&),#% ,( ," "(+, *(!*&&#'! #+ (&)%#+"

0 -+#'! ," +#'!% )*(!*&&#'! * (+ #' ,"#+ &'- + ,"#+ "),* ,(

)*(!*& 0(-* +''* ,( /(*$ /#," 0(-* ,*&#'%(&)-,*

Introduction

Section 1 Introduction & Quick Start Menu

"#+ )*(!*&&#'! +,#(' (',#'+ ," (%%(/#'!

• ,,#'! ,*, ' (*&,#('

• %-! ' %0 %,#('+

• *&#'% ',*  %,#('+

• #' '- %,#('+

" +''*+ '  )*(!*&& ,( -+,(&#1 ," +,-) )*&,*+ '

,#%(* ," , (-,)-, ,( +-#, ))%#,#(' '+

SCANTEAM 3400PDF User’s Guide

1–2

 "( %%  "  $%#%!! #%

('#%% #

   

 

$'#"

"

!( '#"





%(



*#%







DD

D

%#(&

➌➋

➌

➊

Model Number 3400HD–12

Scanner Identification

  

  # %%   )*& " "& %

('#%% #

 !

   "&'*

➊

➋

  #" "

1–3

SCANTEAM 3400PDF User’s Guide

Connecting the Scanner

"'( ( '""& - # #+" ( '($' '#+"  #+

➊ )&" # ( $#+& (# ( #'( '-'(!

➋ #""( ( "(&   (# ( '""& " (# ( (&!" #!$)(&

   



1

2

3

➌ )&" #" ( $#+& (# ( #'( '-'(!

➍ &#&! -#)& '""& (# +#& +( -#)& (&!" #& #!$)(& - '"""

( &!" ($ #' (& '" (  ) "  - #' 

 #& )' ( )$$#&( &!" '( '  (# (&!" -#)&

(&!" ' &!" 

(  ) "  - $&#&!!" -#) #""( ( '""& " '"  #"

& # " &%)& $&,' " '),' (# $&#&! ( '""& (# +#&

+(  '"( "(&

➎ # (&!"  -#)& '""& ' '( )$ #&&( - '" #" # ( '!$  &

#' #" (  #*& # (' )

     

SCANTEAM 3400PDF User’s Guide

1–4

40 mil

In.

Cm.

0

2

5.08

4

10.16

6

15.24

8

20.32

$    " %    #!

  !

Typical Depth of Field in Inches/Centimeters

7531

20 mil

13 mil

7 mil

08

07

1.5 6

3 4.5

4

In. Cm.

4

3

2

1

0

1

10.16

7.62

5.08

2.54

0

2.54

5.08

7.62

10.16

Width of Field in Inches/Centimeters

1–5

SCANTEAM 3400PDF User’s Guide

$    " %    #!

  !

13 mil

10 mil

2

5

3 4.5

In.

Cm.

0

13

5.08

5

10.16

42

2.5

In. Cm.

1.5

2.5

0

1.5

6.35

3.81

0

3.81

6.35

Width of Field in Inches/Centimeters

Typical Depth of Field in Inches/Centimeters

SCANTEAM 3400PDF User’s Guide

1–6

$    " %    #!

"     !

14 mil

In.

Cm.

0

2

5.08

4

10.16

Typical Depth of Field in Inches/Centimeters

12.3 mil

7.9 mil

.85 2.15

12

1.35 1.95

1.75

In. Cm.

1.5

1.75

1.2

1.5

0

1.2

4.45

3.81

3.05

0

3.05

3.81

4.45

Width of Field in Inches/Centimeters

1–7

SCANTEAM 3400PDF User’s Guide

✱    " #!$' & "'%

IBM PC Interface

  " #!$' & "'%

These bar codes  program a carriage return (CR) suffix.

 &#  (     ( ( 

%!"  

#%    !# &

%!"  

( "'%

%!"  

Baud Rate 9600 bits per second

Parity even

Data Format 7 data bits, parity bit, 1 stop bit

(8 Bit Data)

The bar code above  programs the following parameters:

Programmable Option Setting

RS–232 Interface

✱ Indicates default selection.

SCANTEAM 3400PDF User’s Guide

1–8

Wand Emulation Interface

     

  

      [

(Terminal ID 64)

End of “Plug and Play” programming...

[ Supports Code 39, UPC, EAN, Code 128, Interleaved 2 of 5, and

Codabar. All other linear codes output as Code 39. PDF417 is output as

Code 128.

Transmission Rate 20 inches per second

Output Polarity Black High

Programmable Option Setting

These bar codes  program the following parameters:

1–9

SCANTEAM 3400PDF User’s Guide

Supported Terminals

   

645.7   

*&7- %*2.7-  

 "*(75&   

     

 !      $ 

    

  *<       

     

  *<       

  *<      

 

 314&7.'0* &4&2  *< ! 7<0* 

  &4&2 #35/67&7.32 

 

!!  

** &7&  

  $$ *5.*6 

0.9*77.      

  !! 

!*0*;  *<         

  

!*0*;  *<         

  

!*0*;  *<         

  

#&2) 180&7.32 3)*  +351&7 

#&2) 180&7.32 &1* (3)* +351&7 

53,5&1 !*51.2&0 27*5+&(*

+ <385 7*51.2&0 .6 237 32* 3+ 7-* 08, &2) 0&< 347.326 <38 1867 453,5&1 32*

3+ 7-* 7*51.2&06 0.67*) '*03: !3 453,5&1 7-* 7*51.2&0 .27*5+&(* 6(&2 7-*

53,5&1 !*51.2&0 27*5+&(* '&5 (3)* '*03: 7-*2 6(&2 7-* &445345.&7* 7:3 ).,.7

!*51.2&0  (3)* +531 7-* 53,5&11.2, -&57 32 7-* 2*;7 4&,*

SCANTEAM 3400PDF User’s Guide

1–10































1–11

SCANTEAM 3400PDF User’s Guide

!( !%(# '$!

%!#) &% %% $

Reset Factory Settings

Status Check

   %    # ! #$%$ % $ # %! %

!#  %!#) $%% $ #   ) "#!#   $ )!& ) '



 %    # ! %! %# $% % $!%(# #'$!

' %! % !$% %#   $!%(# #'$! (  "# % !&% $

*  *$ ( '#) !#  %! % #(# 

SCANTEAM 3400PDF User’s Guide

1–12

Page is loading ...

Welch Allyn SCANTEAM 3400PDF User manual

Welch Allyn SCANTEAM 3400PDF User manual

Related papers

Other documents