KC HiLiTES 9150 Installation guide

Brand
KC HiLiTES
Model
9150
Category
Motorcycle Accessories
Type
Installation guide
KC HiLiTES, Inc. 2843 W. Avenida de Luces, PO Box155, Williams, Arizona 86046-0155 * 800-528-0950 * 6-15-07www.kchilites.com
Fog Lights
Fog lights should be aimed so that the top cutoff is
below the center of the low beam.
Left Low Beam Right Low Beam
23 Year Warranty
See details on our website at
www.kchilites.com
Installation Instructions
Relay Wiring Kit for Two Lights
Thanks for choosing a KC HiLiTES product. We
take pride in building the highest quality, best
engineered systems possible. Your satisfaction
with our product is important us.
If you have any questions, please call our
customer service line at 800-528-0950.
Parts Included In Your Wiring Kit:
1 - Complete harness with Relay for 2 Lights
5 - Screws
6 - Wire ties
1 - Wire splice connector (for White wire)
1 - Switch w/ Panel (optional ½” hole mount)
Tips
* To start, determine where your Lights and Switch
will be mounted and then install the Harness.
* Mount Relay close to the Battery (terminals facing
downward). Remove Relay from Harness before
installing Power wires and then replace Relay when
completed.
* Connect the Yellow power wire to the (+) Positive
post of the battery.
* The Black wire must be connected to a (-) Battery or
Chassis ground. Ground the Brown wire to activate
Switch LED.
* The White power wire must be connected to a (+)
Positive 12v source (direct to Battery or Accessory
Fuse is ok). DO NOT SPLICE INTO YELLOW WIRE.
* Some states require Fog Lights to be switched with
Low Beams (connect White wire to Low Beam hot wire
with splice connector).
* Some states require Driving Lights to be switched
with High Beams (connect White wire to High Beam hot
wire with splice connector).
* Aim lights before they are securely tightened.
Driving Lights
Driving lights should be aimed around the same level
as your high beams.
Left High Beam Right High Beam
Load
Supply
Green
White
Black
To
Ground
Earth
Brown
Fuse
3A
+12 VDC
Battery
Yellow
Fuse
20/25A
To
Ground
LED
KC
SWITCH
RELAY
+12 VDC
8586
87
87
30
LIGHTS
Long Range Lights
Long Range off road lights are not legal for highway
use and should be mounted to see as far ahead as
possible.
Left High Beam Right High Beam
  • Page 1 1

KC HiLiTES 9150 Installation guide

Brand
KC HiLiTES
Model
9150
Category
Motorcycle Accessories
Type
Installation guide
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents