Premier UC1-HC Installation, Operation and Maintenance Manual

Brand: Premier

Model: UC1-HC

Category: Water dispensers

Type: Installation, Operation and Maintenance Manual

Premier, Inc. 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381

Phone: 800-752-5582 www.PremierH2o.com Fax: 623-866-5666

Manual #: 299112 Manual Date: 09/25/2013

INSTALLATION, OPERATION AND MAINTENANCE MANUAL

Save manual for future reference

Warning

Please read carefully before proceeding with installation. Your failure to follow any attached instructions

or operating parameters may lead to the product’s failure.

Model: UC1-HC

Thank you for your purchase of a state of the art Premier Water Treatment system.

UC1-HC Water Treatment System:

Premier UC1-HC water treatment system contains a heavy duty sediment, cyst and chlorine

reducing lter block. The UC1-HC water ltration helps protect small appliances and provides

clean, clear, great tasting water with a higher ow and gallon rating than other similar systems.

System Maintenance

Just because you can not taste it, does not mean that it is not there. Many contaminants in the

drinking water are undetectable to the taste. Additionally, over time if you do not replace the

lter elements, other bad tastes and odors will be apparent in your drinking water. This is why

it is important to change your lters at the recommended intervals as indicated in this system

manual.

When replacing any of the lter elements, pay special attention to any cleaning instructions. Should

you have any further questions please refer to our web site at www.PremierH2o.com or call our

customer service department at 1-800-752-5582.

Service Record

Model Number: _____________

Serial Number: _____________

Date of Purchase: _____________

Date of Install: _____________

Installed by: _____________

Table of Contents

Service Record ...................................................................................................................................... 3

Operational Parameters ........................................................................................................................ 4

Contents of Under Counter System....................................................................................................... 4

Tools Recommended For Installation .................................................................................................... 4

Part Number List / Flow Diagram .......................................................................................................... 4

Blue Tube Connection to Cold Water Angle Stop Valve ........................................................................ 5

Blue Tube Connection TO Faucet Supply Hose ................................................................................... 5

Mount the Filtration System .................................................................................................................. 6

Connect the Blue Tube to the Filtration System ................................................................................... 6

Start-up Instructions ............................................................................................................................. 6

Changing The Filter Cartridge .............................................................................................................. 7

Performance Data Sheet ...................................................................................................................... 8

Warranty Registration ...................................................................................................................... 9-10

Removing chlorine from your shower ...................................................................................................11

Limited Warranty ................................................................................................................................ 12

Filter Replacement Date

System Information

Blue

Tubing

COLD

Counter Top

UC1-HC

√ 1 UC1-HC Unit √ 1 Parts Bag

Contents of Under Counter System

Installation must comply with state and local plumbing regulations.

Operational Parameters

If any of the items are missing, please contact Premier prior to installing.

Operating Temperatures:

Maximum 100°F (37.8°C) Minimum 40°F (4.4°C)

Operating Pressure:

Maximum 100 psi (689 kpa) Minimum 25 psi (172 kpa)

Flow Rate:

1.5 GPM @ 60 psi

Water supply line to the system must be from the cold water supply line.

Item Part # Description

1 231026 3/8” BRASS INSERT

2 231020 3/8” DELRIN SLEEVE

3 231002 3/8” BRASS NUT

4 140012 3/8” BLUE TUBING

5 125159 3/8” QC UNION

6 225008 3/8” QC STEM ADAPTER

7 137084 SYSTEM BRACKET

8 304132 SYSTEM LID

9 500168 15” HC CARBON FILTER

Part Number List / Flow Diagram

Tools Recommended For Installation

√ Phillips bit for electric drill √ Sharp Knife or Scisors

√ 1/2" Open End Wrench √ Electric Drill

Blue

Tubing

Step 3 Locate the blue 3/8” tube in the parts bag. Remove a brass

nut, plastic delrin sleeve and brass insert from the parts bag.

To assemble, place the brass nut on the blue tube rst (Open

end out), then the sleeve and then push the brass insert all

the way into the end of the tube. (See Picture)

Blue Tube Connection To Cold Water Angle Stop Valve

Do not use Teon tape.WARNING:

Caution:

Water supply line to the system must be from the cold water supply line only.

Hot water will severely damage your system.

Verify contents prior to installation:

( 1 ) - Brass Nut ( 1 ) - Plastic Delrin Sleeve ( 1 ) - 3/8” x 3/8” QC Union

( 1 ) - Brass Insert ( 1 ) - 3/8” Blue Tube ( 1 ) - 3/8” QC Stem Adapter

Step 4

Insert the assembled blue tube into the open tting of the

cold water angle stop valve and use an adjustable wrench

to tighten the brass nut securely.

Turn off the cold water supply to the faucet by turning the angle stop valve completely off.

Open cold water sink faucet to relieve pressure.

Step 1

Place a small container under the cold water angle stop valve to catch any runoff water.

Disconnect the cold water faucet supply hose from the cold water angle stop valve.

Step 2

Blue Tube Connection To Faucet Supply Hose

Step 5 Locate the threaded 3/8” male stem adapter tting in the parts

bag. Thread the stem adapter on to the supply hose attached

to the faucet and tighten with an adjustable wrench.

Step 6

Locate the 3/8”x3/8” Quick Connect union in the parts bag.

Push the union on to the 3/8” stem adapter tting attached

to the faucet hose until fully seated.

Step 7 Connect the open end of the 3/8” blue tube to the open end

of the 3/8”x3/8” Quick connect union tting by pushing the

tube into the adapter until fully seated.

Faucet Supply

Hose

3/8” Adapter

3/8” Union

3/8” Blue Tube

Start up Instructions

Congratulations!

You have completed the installation of your new water ltration system.

Please Follow the Startup Instructions.

Turn on water supply at cold water angle stop. Turn cold water faucet handle to the open

position to start the ow of water through the unit. Run 5 gallons of water through the unit in

order to ush out the normal black carbon nes (it will “sputter” until the air is purged out) from

the unit. Initially, the water may appear cloudy which is due to tiny air bubbles and it will clear

up shortly. Close the faucet when nished.

(Check frequently over the next 24 hours to ensure no leaks are present)

Step 1

Step 2

Check for leaks. If you have any leaks, shut off the water supply to your system, tighten

any ttings and restart unit.

Connect the Blue Tube to the Filtration System

Step 9

After mounting the system, determine where and cut the 3/8” blue

tubing into two parts in order to connect it to the ltration system.

Step 10

Connect the 3/8” blue tube coming from the angle stop valve into

the left side of the ltration system (IN), by pushing the tubing rmly

into the quick connect tting. Connect the 3/8” blue tube coming

from the faucet supply hose into the right side of the ltration system

(OUT), by pushing the tubing rmly into the quick connect tting.

Mount the Filtration System

Step 8 Determine best location for the ltration system to be mounted and

spliced into the 3/8” blue tubing. Using the mounting holes on the

bracket, mark the location for the mounting screws on the cabinet

wall under the sink (Make sure to leave enough room to remove

the lter during lter changes, approximately 2” below lter). In the

parts bag, locate the two self tapping screws. Using an electric

drill with a Phillips bit, screw them into the cabinet at the marked

location. Hang the system on the screws using the mounting holes

in the bracket

IN OUT

Premier recommends changing the lter element once every 1 year. However lter life may

vary depending on local water conditions and water use.

Use Premier’s replacement cartridge only. Other lters may look the same, but only lters

by Premier are manufactured to t your UC1-HC lter unit in order to ensure proper reduction

of water contaminants.

Carbon Block Cyst Filter:

Part# 500168

(A) Turn off incoming water supply to the ltration unit.

(B) Open the cold water faucet handle to relieve the

water pressure.

(B) Remove lter from lid by turning it to the left, then pulling

the lter down out of the lid. Discard of old lter.

(D) To install new lter cartridge, with the lter label facing

approximately 45 degrees to the left, push the lter into

the lid and twist it to the right until the lter locks in and

the label on lter is facing the front.

(H) Follow start-up procedure on page 6.

Filter Change

To Loosen To Tighten

Performance Data Sheet

Premier Inc.

8716 W Ludlow Drive Suite #1

Peoria, AZ 85381

UC1-HC

GENERAL USE CONDITIONS:

1: System to be used with municipal or well water sources treated and tested on regular basis to insure

bacteriological safe quality. DO NOT use with water that is micro biologically unsafe or of unknown quality

without adequate disinfection before or after the system. Systems certied for cyst reduction may be used on

disinfected waters that may contain lterable cysts.

2: Operating Temperature: Maximum 100

F (38

C) Minimum 40

F (4.4

3: Operating Water Pressure: Maximum 100-psi (689kpa) Minimum 25-psi (172kpa)

4: Maximum ow Rate: 1.5 gpm (5.7 lpm)

5: Rated Capacity (Chlorine): 10000 Gallons (37,854 liters)

RECOMMENDED REPLACEMENT PARTS AND CHANGE INTERVAL:

Note: Depending on incoming feed water conditions replacement time frame may vary.

Description Part Number Change time Frame

UC1-HC 303016 12 Months or 10000 gallons of water

California Proposition 65 Warning

WARNING: this product contains chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. (Installer:

California law requires that this warning be given to the consumer). For more information: www.wattsind.com/prop65

4 Ways to Register

1. On-line at www.PremierH2o.com

2. Call in your information 1-800-752-5582

3. Fax in your information 623-866-5666

First Name:_________________________ Last Name:____________________________

Address: ________________________________________ City: ____________________

State: _______________________________________ Zip Code: ___________________

Country: USA CANADA MEXICO OTHER ____________

Phone # ______-__________ -__________ Email Address: ______________________

Date of Purchase: ___________________ Date of Install: _______________________

Installed By: SELF Plumbing Professional Where Purchased: ____________

Model Number: _______________________ Serial Number: ____ - __________

Premier, Inc. 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381

Phone: 800-752-5582 www.PremierH2o.com Fax: 623-866-5666

4. Mail in the information.

Please complete the form below. Mail to: Premier

8716 W Ludlow Drive Suite #1

Peoria, AZ 85381

Fax this form directly to us.

Call and we will enter your registration information for you.

XXXXX

XXXXXX

Premier Inc. is concerned for the safety of your personal information. Premier collects personal information when you register with Premier.

This information is stored in our data base and we do not rent, sell, or share personal information with other people or nonafliated compa-

nies. We reserve the right to send you certain types of communications such as direct mail, email, or by telephone relating to our products

or products that you have purchased. We limit access to your personal information to those employees who will directly provide you with

services or products in order to do their jobs. We want to offer you four ways to communicate with us. 1.Online, 2.Fax, 3.Telephone, and

4. Mail the form below. By registering your product you will receive the full benet of our warranty. Premier will also send you a semiannual

lter change reminder beginning six months from date of installation. To insure the highest quality of your water, lters should be replaced

every 6 months. If you have any questions or comments please give us a call at 1-800-752-5582 M-F 8:00am -5:00pm MST.

Registering will

insure you

receive Premier

FREE

Filter

Reminder

Notice

Thank you for selecting Premier for your water ltration needs.

WARRANTY REGISTRATION

Please Fill out and keep for your Records

Insert into envelope and return to Premier

First Name:_________________________ Last Name:____________________________

Address: ________________________________________ City: ____________________

State: _______________________________________ Zip Code: ___________________

Country: USA CANADA MEXICO OTHER ____________

Phone # ______-__________ -__________ Email Address: ______________________

Date of Purchase: ___________________ Date of Install: _______________________

Installed By: SELF Plumbing Professional Where Purchased: ____________

Model Number: _______________________ Serial Number: ____ - __________

Iowa Department of Public Health - Sales in Iowa require this to be completed, signed and returned.

These signatures will be retained on le for two years.

XXXXX

XXXXXX

Premier

8716 W Ludlow Drive Suite #1

Peoria, AZ 85381

Removing chlorine from your shower

Deluxe Shower Handle with Built in Filter Replacement lters 2PK

5-Way Massaging Spray

72” Reinforced Hose

High Strength Bracket

Triple Plated Finish

Reversible Filter Cartridge (Model HHC)

Cartridge Life Rating: 3 months

Part No. 107070 WHITE *$38.95

Part No. 107091 CHROME *$44.95

Part No. 107092 GOLD *$44.95

Shower Falls Deluxe Shower Handle with Built in Filter

Curved Ergonomic Shower Handle Replacement lters 2PK

Filter Handle Extension

Dual Swivel Adjustment

Ultra Deluxe 5 Way Massaging Spray

72” Reinforced Hose

Chrome Plated Brass Bracket & Swivel Ball Extension

Triple Plated Finish

Reversible Filter Cartridge (Model HHC)

Cartridge Life Rating: 3 months

Part No. 107095 CHROME *$55.95

All-In-One reversible High-Flow Filter Replacement lter

Deluxe 5-Way Massaging Spray

Soft-Touch Adjustment Pads

Anti-Scaling Spray Nozzle

High Strength Housing

Triple Plated Finish

Cartridge Life Rating: 6 months

Part No. 107098 White/Chrome *$39.95 Part No. 107080 *$13.95/ea

*All prices subject to change without notice.

√ Free Chlorine (CL-)

√ Combined Chlorine (Sodium Hypochlorite)

√ Hydrogen Sulde (Rotten egg smell)

√ Plus, its pH balanced.

Special Chlorgon & KDF media – More effective then carbon medias with

hot water applications in the removal of the following.

√ Iron oxide (rust water)

√ Dirt, sediment

√ Odors

Part No. 107075 *$15.95/pk

8716 W Ludlow Drive Suite #1 Peoria, AZ 85381

Limited Warranty

What your Warranty Covers:

If any part of your Premier UC1-HC is defective in workmanship (excluding replaceable lters ), return unit after obtaining

a return authorization (see below), within 3 years of original retail purchase, Premier will repair or, at Premier’s option,

replace the system at no charge.

How to obtain Warranty Service:

For warranty service, call 1-800-752-5582 for a return authorization number. Then, ship your unit to our factory, freight and

insurance prepaid, with proof of date of original purchase. Please include a note stating the problem. Premier will repair it,

or replace it, and ship it back to you prepaid.

What this warranty does not cover:

This warranty does not cover defects resulting from improper installation, (contrary to Premier’S printed instructions),

from abuse, misuse, misapplication, improper maintenance, neglect, alteration, accidents, casualties, re, ood, freezing,

environmental factors, water pressure spikes or other such acts of God.

This warranty will be void if defects occur due to failure to observe the following conditions:

1. The UC1-HC System must be hooked up to a potable municipal or well cold water supply.

2. The pH of the water must not be lower than 5 or higher than 10.

3. The incoming water pressure must be between 25 and 100 pounds per square inch.

4. Incoming water to the Counter Top cannot exceed 100 degrees F (38 degrees C.)

This warranty does not cover any equipment that is relocated from the site of its original installation.

This warranty doe not cover any charges incurred due to professional installation.

This warranty does not cover any equipment that is installed or used outside the United States of America and Canada.

LIMITATIONS AND EXCLUSIONS:

Premier WILL NOT BE RESPONSIBLE FOR ANY IMPLIED WARRANTIES, INCLUDING THOSE OF MERCHANTABILITY AND

FITNESS FOR A PARTICULAR PURPOSE. Premier WILL NOT BE RESPONSIBLE FOR ANY INCIDENTAL OR CONSEQUENTIAL

DAMAGES, INCLUDING TRAVEL EXPENSE, TELEPHONE CHARGES, LOSS OF REVENUE, LOSS OF TIME, INCONVENIENCE,

LOSS OF USE OF THE EQUIPMENT, AND DAMAGE CAUSED BY THIS EQUIPMENT AND ITS FAILURE TO FUNCTION PROPERLY.

THIS WARRANTY SETS FORTH ALL OF PREMIER’S RESPONSIBILITIES REGARDING THIS EQUIPMENT.

OTHER CONDITIONS:

If Premier PREMIER chooses to replace the equipment, Premier may replace it with reconditioned equipment. Parts used in repairing or

replacing the equipment will be warranted for 90 days from the date the equipment is returned to you or for the remainder of the original

warranty period, whichever is longer. This warranty is not assignable or transferable.

YOUR RIGHTS UNDER STATE LAW:

Some states do not allow limitations on how long an implied warranty lasts, and some states do not allow the exclusion or limitation of

incidental or consequential damages, so the above limitations or exclusions may not apply. This warranty gives you specic legal rights,

and you may have other legal rights which vary from state to state.

Premier UC1-HC Installation, Operation and Maintenance Manual

Brand: Premier

Model: UC1-HC

Category: Water dispensers

Type: Installation, Operation and Maintenance Manual

Download PDF

report

Premier UC1-HC Installation, Operation and Maintenance Manual

Premier UC1-HC Installation, Operation and Maintenance Manual

Related papers

Other documents