LRP 83020 User manual

Brand: LRP

Model: 83020

Category: Toy parts

Type: User manual

This manual is also suitable for

AI Runner Reverse V2.0

Speciﬁcations

USER MANUAL

Connections & Explanations

Installation Guide

Setup Procedure

Motor Suppression

Special Features

Troubleshooting Guide

Repair Procedures / Limited Warranty

• Positionthespeedowhereisprotectedintheeventofacrashandgivesyoueasyaccesstotheconnectors.

• Mountthespeedousingthesuppliedthick/blackdoubled-sidedtape

• Makesurethereisenough clearancebetweenthespeed-control,power-wires,antenna andreceiver.Avoid

anydirectcontactbetweenpowercomponents,thereceiverortheantennaasthiscancauseinterference.If

interferenceoccurs,positionthecomponentsatadifferentplaceinthemodel.

• Theaerialshouldberunverticallyupandawayfromthereceiver.Avoidcontactwithanypartsmadeofcarbon

fibreormetal.Iftheaerialistoolong,don’tcoiluptheexcesslength.Seealsotheinstructionssuppliedwith

yourradiocontrolsystem.

Receiver & Switch Connecting Wires:TheAI Runner V2

isequippedwiththeLRPMulticonreceiverwireandwill

easilyfitinallordinaryreceivers.Makesureyouconnect

ittoreceiverwithcorrectpolarityandusechannel2.

Heatsink: Thesuppliedheatsinkisimportantandimpro-

Forward/Brake/Reverse yes Rec.MotorLimit** Over16Turns

Footprint 26x26mm BEC 6.0V/1.0A

Height 15.7mm Fullywaterproof yes

Weight(excl.wires) 19.0g Fail-Safe-System yes

VoltageInput 4.8-7.4V Multi-Protection-System yes

Typ.VoltageDrop*@20A 0.152V Connectors StdTamiya

RatedCurrent* 92A SetupProcedure Automatic

Connections:

 •Connectthespeedotothereceiver(position:Channel2).

 •Connectthespeedotothemotor(blue=minus/yellow=plus).

 Doublecheckallconnectionsbeforeconnectingthespeed-controltoabattery.

 Caution: Ifbatteryisconnectedwithreversedpolarityitwilldestroyyourspeed-control!

 •Connectspeedotobattery-->yourspeed-controlisnowreadytobeused!

RA00321

Version: 28.7.11

LRP electronic GmbH

Wilhelm-Enssle-Str. 132-134

73630 Remshalden, Germany

info@LRP.cc - www.LRP.cc

AI Runner V2

#83020

Brushed Speed Control

Over 16 Turns Motorlimit

ThankyouforyourtrustinthisLRPproduct.BypurchasingaLRP AI Runner V2 speed-control,youhavechosena

high-performancespeed-controlfullofnewdesignfeatures,suchas:

•Fullywaterproofandshock-resistant •Multi-ProtectionSystem

•LRPA.I.AutomaticSetup  •FailSafeSystem

Pleaseread the followinginstructionscarefullybeforeyoustart using yourspeedcontrol. Thisuser guide contains

importantnotesforthesafety,theuseandthemaintenanceofthisproduct.Thusprotectingyourselfandavoiddamages

oftheproduct.

Proceedaccordingtotheuserguideinordertounderstandyourspeedcontrolbetter.Pleasetakeyourtimeasyouwill

havemuchmorejoywithyourproductifyouknowitexactly.

Thisusermanualshallbekeptinasafeplace.Ifanothercustomerisusingthisproduct,thismanualhastobehanded

outtogetherwithit.

* Transistorsratingat25°Cjunctiontemperature.Specificationssubjecttochangewithoutnotice.

** @6cells(7.2V).usingsinglemotor

TamiyaConnector(Battery)

MotorConnector

(yellow=plus)(blue=minus)

ReceiverLead

Switch

CAUTION:NeveruseSchottkydiodesinconjunc-

tion with a forward/reverse speed-control, e.g.

theLRPA.I.Runnerseriesspeed-controls.

Motors with no capacitors or not enough capa-

citors may interfere with the speed-control. To

avoidthis,solderthesuppliedcapacitorstoyour

motor(seepicture).

Afterwiringupthespeed-control,itisreadytooperate.Nosetupisrequired.Thespeed-control„learns“theneu-

tral,full-speedforwardandfull-speedreversepointswhilethecarisrunning.Pleasenote:Beforeyoupluginthe

drivebattery,setthetransmittertoneutralpositionandthenstartthemodelintheforwarddirection.

SWITCHONTHETRANSMITTER

CONNECTTHESPEED-CONTROLTOTHEBATTERY

AND...GO!

• Ifyouhavemadeamistakesofar,don’tworry:Unplugthebatteryforabout10secondsandstartoveragain.

• Aftertherun,firstunplugthebatteryandthenswitchoffthetransmitter.Whenyoustartagain,firstswitchon

thetransmitterandthenpluginthebattery.

AUTOMATIC SETUP: thereisnoneedforamanualsetupofthespeed-controlbypushbuttons.Allyouneedtodois

simplypluginthespeed-controlandyou’rereadytogo!Thespeed-control“learns”theneutral,full-speedforward

andfull-speedreversepointsofyourradiosystemwhilethecarisrunning.Thisway,thespeed-controlhasthe

optimizedsetupforeveryrun-automaticly.Incorrectorunperfectsetupsareathingofthepast!

FAIL-SAFE SYSTEM: Digitalprotectionagainstradiointerference,“Theguardianangel“.Thesafetyelectroniccan

detectreceptionofa“false”orincompleteradiosignal,e.gduetoalowtransmitterbatteryorenvironmentalradio

interferencewhichreachthemodel,orifthemodelisoutofthetransmitterrange.Forprotectionagainstdamage,

thespeed-controlswitchestotheneutralposition,andthemodelcomestoastop.

REVERSE OPERATION: Noreversetimelimit!

MULTI-PROTECTION SYSTEM,3-wayProtection

Thisuniquemonitoringsoftwareistheperfectprotectionforthespeed-controlagainstshort-circuits(motor),over-

loadandoverheating.Ifyourspeed-controliseverfacedwithoverload,themotorfunctionisswitchedoffforpro-

tection,althoughthesteeringfunctionismaintained.Waitafewminutestoallowthespeed-controltocooldown.

Ifthespeed-controlswitchesofffrequently,eitherthemotorusedistoostrong,themotorpinionistoobigoryou

areusingfullbraketoooften.Youcanimprovethisifyoumakeadditionalcoolingslotsinthebody.

vestheperformanceofyourspeed-controlwhenusedclosetoitsspecifiedlimits.UseonlygenuineLRPheatsinks

andneverallowtheFettabstotouchotherFets,shortcircuitwouldoccurwhichresultsindamageofthespeed-

control!

Connectors & Power Wires: FormaximumconviencestandardTamiya/Bullet typeconnectors,incombination

withhighqualitysiliconewires,areused.

Waterproof:Due to latestproductiontechnologiesand useofHighTech materials,itwaspossibletomakethis

speed-controlfullywaterproof!Thismaterialalsomakesthespeed-controlsmoreshockresistantthenothersi-

milarproducts.

It‘snolongerneededtosealyourspeed-controlwhenyouaredrivingintherain/snow!Butpleasemakesureyou

stillsealyourotherelectroniccomponents(receiverandservo)sincethesearenormallynotwaterproof.

TURNONTHESWITCH

SympTOm CAUSe Remedy

Insufficientperformance.

E.g.poorpower,topspeed,

reversespeedorbrake

WrongGearratio Adjustgearratio

Transmittersettingschangedafterset-up Repeatset-upprocedure

Motorwornout Maintainmotor

Motordefective Replacemotor

Speed-controldefective Sendinproductforrepair

Servoisworking,nomotor

function

Speedopluggedinincorrectly PlugspeedotoreceiverasCh.2

MultiprotectionSystemactivated Checksettingsforyourapplication

Wiringproblem Checkwiresandconnectors

Motorbrushesjammed Checkwhetherbrushesaremovingfreely

Motordefective Replacemotor

Speedodefective Sendinproductforrepair

Noservoandnomotor

function

Speedoconnectedtoreceiverwithwrongpolarity Connectspeedowithcorrectpolarity

Wiringproblem Checkwiresandconnectors

Batterydefective Replacewithdifferentbatterypack

Crystal,receiverortransmitterdefective Replacecomponentsonebyone

Speedodefective Sendinproductforrepair

Motorstutterswhile

accelerating

Radiointerference Changelocationofcomponents

Servodamagedortoostrong(BECoverload) Replaceservo

Speedodefective Sendinproductforrepair

Motorrunsinreversewhen

acceleratingforwardonradio

Motorconnectedincorrectly Connectmotorcorrectly

Throttle stick polarity at transmitter changed

whiledriving

Repeatstartupprocedure

Speed-controlswitchesoff

frequently

Modelusedtoooftenwithoutcool-downperiods Letcooldownaftereveryrun

Motorstrongerthanmotorlimitorinputvoltage

toohigh

Useonlymotorsandbatterieswhicharewithin

thespecificationsofthespeed-control

Stuckdrivetrainorball-bearing Maintainmodel

Motordefective Replacemotor

Motorneverstops,runsat

constantslowspeed

Transmittersettingschangedafterset-up Repeatset-upprocedure

Speedodefective Sendinproductforrepair

Radiointerference Receiverorantennatooclosetopowerwires,

motor,batteryorspeedo.Receiveraerialtooshort

orcoiledup

See„InstallationTips“and„Installation“

Receiverdefective,toosensitive;

Transmitterdefective,transmitteroutputpower

toolow,servoproblem

Replacecomponentsonebyone

Onlyuseoriginalmanufacturerscrystals

Motorsuppressioninsufficient Addcapacitorstothemotor

Poorbatteryconnection Checkplugsandconnectingwires

Transmitterbatteriesempty Replace/rechargetransmitterbatteries

Toeliminate allotherpossibilities or improperhandling,firstcheck allothercomponentsin your model andthe

troubleshootingguidebeforeyousendinthisproductforrepair.Ifproductsaresentinforrepair,whichdooperate

perfectly,wehavetochargeaservicefeeaccordingtoourpricelist.

Thecrossed-outwheeledbinmeansthatwithintheEuropeanUniontheproductmustbetaken

toseperatecollectionattheproductend-of-life.Donotdisposeoftheseproductsasunsorted

municipalwaste.

AllproductsfromLRPelectronicGmbH(hereinaftercalled“LRP”)aremanufacturedaccordingtothehighestqualitystan-

dards.LRPguaranteesthisproducttobefreefromdefectsinmaterialsorworkmanshipfor90days(non-europeancountris

only)fromtheoriginaldateofpurchaseverifiedbysalesreceipt.Thislimitedwarrantydoesn’tcoverdefects,whicharea

resultofmisuse,impropermaintenance,outsideinterferenceormechanicaldamage.

„Thisappliesamongotherthingson:

• Cutofforiginalpowerplugornotusingreversepolarityprotectedplugs

• Receiverwireand/orswitchwiredamaged

• Mechanicaldamageofthecase

• Mechanicaldamageofelectronicalcomponents/PCB

• SolderedonthePCB(exceptonsolderpads)

• Connectedspeed-controlwithreversedpolarity“

Toeliminateallotherpossibilitiesorimproperhandling,firstcheckallothercomponentsinyourmodelandthetroubleshoo-

tingguide,ifavailable,beforeyousendinthisproductforrepair.Ifproductsaresentinforrepair,whichdooperateperfectly,

wehavetochargeaservicefeeaccordingtoourpricelist.

Withsending inthisproduct, the customerhas toadviseLRPif theproductshould be repairedin eithercase. Ifthereis

neithera warrantynorguaranteeclaim,theinspectionoftheproduct andthe repairs,ifnecessary,ineither case will be

chargedwithafeeatthecustomersexpenseaccordingtoourpricelist.Aproofofpurchaseincludingdateofpurchaseneeds

tobeincluded.Otherwise,nowarrantycanbegranted.Forquickrepair-andreturnservice,addyouraddressanddetailed

descriptionofthemalfunction.

If LRP no longermanufacturesareturneddefectiveproductandweareunableto service it, weshall provide youwith a

productthathasatleastthesamevaluefromoneofthesuccessorseries.

Thespecificationslikeweight,sizeandothersshouldbeseenasguidevalues.Duetoongoingtechnicalimprovements,which

aredoneintheinterestoftheproduct,LRPdoesnottakeanyresponsibilityfortheaccuracyofthesespecs.

With LRP 25-Years Warranty products, the warranty terms on the LRP25-Years Warranty card do also apply. Thelegal

warrantyclaims,whicharoseoriginallywhentheproductwaspurchased,shallremainunaffected.

LRP-Distributor-Service: 

• Packageyourproductcarefullyandincludesalesreceiptanddetaileddescriptionofmalfunction.

• SendparceltoyournationalLRPdistributor.

• Distributorrepairsorexchangestheproduct.

• ShipmentbacktoyouusuallybyCOD(cashondelivery),butthisissubjecttoyournationalLRPdistributor‘s

generalpolicy.

LRP 83020 User manual

Brand: LRP

Model: 83020

Category: Toy parts

Type: User manual

This manual is also suitable for

AI Runner Reverse V2.0

Download PDF

report

LRP 83020 User manual

This manual is also suitable for

LRP 83020 User manual

Related papers

Other documents