FIELD CONTROLS AN-127 Water Hammer Arrester Installation guide

Type
Installation guide
ULTRA-ZONE HUMIDIFIERS
Water Hammer Arrester
Parts List:
* Water Hammer Arrester #WH 100
* 2 - 1/4” brass compression nuts
* 2 - 1/4” brass ferrules
* 2 - 1/4” plastic ferrules
INSTALLATION INSTRUCTIONS & OWNER'S MANUAL
Water Hammer Arrester
Required tools and materials:
* Adjustable wrenches
* Tubing cutter
EWC Controls Inc. 385 Highway 33 Englishtown, NJ 07726 800-446-3110 FAX 732-446-5362 E-Mail- [email protected]
Water Hammer is the term used to define the pounding noise or vibration
that occurs in a water line, due to the fast closing action of electric solenoid
valves or similar water flow control devices.
Installation of a water hammer arrester will cure this problem and allow your
humidifier to work quietly and efficiently.
1. Identify a suitable location to install the arrester.
2. The preferred location of the arrester is on a horizontal or vertical
section of the ¼” water line close to the humidifier. Approximately 6-12
inches from the connection to the humidifier.
3. Unplug the humidifier, and turn off the water supply to the humidifier.
4. Cut the water line, 1/4” copper or plastic tubing.
5. Slide the 1/4” brass nuts and ferrules onto each end of the water
line.
6. Use the plastic ferrules if installing the arrester onto plastic
tubing.
7. CAUTION: provide support for plastic water lines which cannot
handle the weight of the water hammer arrester.
8. Install the water hammer arrester and tighten the connections.
DO NOT OVER TIGHTEN.
9. Turn on water supply, and plug the humidifier back in.
10. Inspect for water leaks and observe humidifier operation.
11. Congratulations ! You have successfully installed the water hammer
arrester.
WATER HAMMER
ARRESTER
1/4” WATER LINE
WATER VALVE
(SADDLE VALVE)
HUMIDIFIER
AN-127
P/N 090376A0127 REV. B Copyright 2002-2006 © EWC Controls Inc., All Rights Reserved
Field Controls Inc. 2630 Airport Road Kinston, NC 28504 PH: 252.522.3031 FAX: 252.522.0214
P/N 090376A0127 REV. C 10/2011 Copyright © 2011, Field Controls Inc., All Rights Reserved
Field Controls Humidifiers
  • Page 1 1

FIELD CONTROLS AN-127 Water Hammer Arrester Installation guide

Type
Installation guide

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI