Bali Essentials 21306 Installation guide

EASYSHADE®

OWNER’S MANUAL

& INSTALLATION

INSTRUCTIONS

Do Not Discard,

Retain for Future Reference

Motorized

EasyShade®

WARNING:

FAILURE TO FOLLOW THESE

INSTRUCTIONS COULD RESULT

IN PERSONAL INJURY!

For Technical Support visit us at hp://ownerscorner.sunseer.com,

e-mail at contactus@sunseer.com or call Toll Free 800-670-7071 • Fax 877-224-4944

Motorized EasyShade



Owner’s Manual & Installaon Instrucon

Motorized EasyShade



Schemac View

Fabric Panel

Aluminum Housing

Cable

Guide

Hole

Guiding

Cable

Bracket







Note: The Fabric Panel width is 3” less than the



Aluminum Leading Bar

(inside Boom Fabric Pleat)

Figure 1



clearance

is needed

for the

Aluminum





the Aluminum Housing

and Cable Brackets must







included with Wall

Post and spare



12 Ft. Plug-in

Power Cord,

Le or Right

side opon.

TABLE OF CONTENTS

Motorized EasyShade Schemac View (Figure 1). . . . . . . . . . . . . . . . . . . . . . . Inside Front Cover

Tools Needed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Parts Supplied (Figure 2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Pre-Installaon Note . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Installaon. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Vercal Mounng (Figure 3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Horizontal Mounng (Figure 4) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Operang the EasyShade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Remote Transmiers are unique. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Troubleshoong - Installaon . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Troubleshoong - Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Troubleshoong - Operaon . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Troubleshoong - Operaon (Addional Motor Troubleshoong) . . . . . . . . . . . . . . . . . . . . . . 11

Appendix A - Adjusng the Up and Down Posion Limits of the EasyShade Motor . . . . . . . . . . . . 12

Appendix B - Reset All Communicaons between the Motor and Remote Transmier. . . . . . . . . . . 13

Appendix C - Programming Instrucons - Mul Channel Remote Transmier. . . . . . . . . . . . . . . . 14

5-Year Limited Manufacturer’s Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

READ ME FIRST

Congratulaons





Customer Support

Our technical experts are available from 8 am - 10 pm EST daily via email contactus@sunseer.com or

call us at 800-670-7071

hp://ownerscorner.sunseer.com 

to register your purchase by calling 800-670-7071



Factory Limit Sengs

The Up and Down stop limits





Remote Transmier

EasyShades are programmed to operate on Channel 1



Appendix C



*Helper Needed*

Tools Needed



Parts Supplied







WARNING: FAILURE TO FOLLOW THESE INSTRUCTIONS CAN RESULT IN PERSONAL INJURY! PLEASE READ

THESE INSTRUCTIONS IN ITS ENTIRETY BEFORE ATTEMPTING TO COMPLETE THIS INSTALLATION.

Figure 2 - Parts Supplied





Round Head Screw





Cable Guide Stop

with Set Screw



Flat Head Screw



Bracket







Cable Guide Bracket









Wall Mount Post Kit





Spare

CR-2430



Remote



Motorized EasyShade Assembly

PRE-INSTALLATION NOTE

Note: Prior to installing your Motorized EasyShade, please review Figure 1 (Motorized EasyShade Schemac

View) then inspect to ensure that there are no obstrucons on your wall surface, such as light xtures or

door handles, that would interfere with or block the Fabric Panel as it is extended. For proper operaon you

must ensure that the Aluminum Housing and Cable Guide Brackets are mounted on the same vercal plane

or surface.

Figure 3

or on the underside of a structure (Horizontal Surface, see Figure 4For all models, the two Mounng Brackets

should be installed no more than 10” from each end of the Aluminum Housing. For the 10’ to 12’ models, the

third Mounng Bracket should be installed at the mid point between the two End Brackets









Aluminum

Housing

for the

EasyShade

Assembly



Set Screw





Surface





Round

Head

Screw

Figure 3



Bracket

Protruding





Recessed



of the

EasyShade

Assembly

INSTALLATION

MOUNT EASYSHADE



HOUSING TO HOUSE

1







INSTALL VERTICAL MOUNTING BRACKET

2aVercal Surface



Note the orientaon of the Bracket; the end with the



See Figure 3

2b

(Horizontal Surface)

Note the orientaon

of the Bracket; the end with the Set Screw should



See Figure 4



Figure 4

Set

Screw



Round

Head

Screw



Bracket

Protruding



Top Groove

of Housing

EasyShade

Aluminum

Housing

Recessed



EasyShade

Assembly

House

INSTALL HORIZONTAL MOUNTING BRACKET

Set Screw

Recessed Area



Bracket

EasyShade

Housing

Figure 5

3

Figure 3 and 4

While maintaining upward pressure to keep the Top Groove of the EasyShade Assembly on the Tab of the



Figure 5

INSTALL EASYSHADE



INTO BRACKETS

Note: Aluminum Housing and Cable Brackets need to be mounted on the same Vercal Surface. If mounted

to siding, it may be necessary to shim the Brackets to create a at mounng surface.

4





See Figure 6

Note: The Up and Down Stop Limits on the

EasyShade Motor were set at the factory prior to

shipment. The Down Stop Limit was set for a 36

inch extension. This will allow for compleon of the

installaon process.

5



6.DOWN

Figure 7



Note: If the EasyShade does not respond when you

press the DOWN





the DOWN Figure 8

Channel Lights comes on, press the Channel Selector



See Figure 8

7.



8

each end of the Aluminum Housing Assembly, and



See Figure 9

9

end of the Aluminum Housing Assembly, through the

Guide Holes at each end of the Leading Bar, at the



See Figure 10

Figure 9

Vinyl

Coated

Guide

Cable

Figure 8



First Light on the



Use Channel 1

to operate your

EasyShade.









Figure 7









Use Channel 1

Channel Selector



Figure 10

EasyShade

Fabric Panel

Guide Hole Vinyl Coated Cable

Leading Bar

CAUTION: The installaon procedure for the

Motorized EasyShade includes the use of Cable

Guides to stabilize the extended Fabric Panel during

normal use. If your applicaon does not permit the

installaon of the necessary Cable Guides or you

do not plan to install them, you must use addional

care to prevent damage to your product. While

we do not recommend installing the Motorized

EasyShade without the supplied Cable Guides, some

customers may determine that their applicaon

does not have a vercal surface to install the

supplied Cable Guides as instructed.

Figure 6

EasyShade

Assembly



Brackets

Set Screws

Example shown is for the





wrench

10

extended (this is limited to the length of the Vinyl

Coated Cable, but you can not exceed 84” from the



Line on the wall below each end of the EasyShade

Figure 11

Figure 11

Horizontal Line

11



Figure 12

the Horizontal Line made in Step 10

Cable Guide Brackets must be mounted on the same



Figure 12

Horizontal Line



Vinyl Coated Cable

Cable Guide



12



13



as shown in Figure 13





Remove the Bracket and pre-drill both screw hole





Figure 13

Cable Guide

Bracket

14





17





Figure 16

15

Cables through the hole in the Cable Guide Bracket



Cable Guide Stops onto the Vinyl Coated Cable and





See Figure 14

16





See Figure 15

Note: Do not over ghten the Cable.

Figure 15

Adjust Cable Tension

by turning this Cable



Open End Wrench

Figure 14

Cable Guide

Bracket

Cable Guide

Stop



Wrench

Note:

The Cable Guide

Stop installs

underneath the

Cable Guide

Bracket, with threads

poinng up.

Figure 16

If trimming the

Vinyl Coated Cable,

leave one inch of

cable below the



Note: The Fabric Panel is preset to stop 36” from the

Housing. This posion can be changed to lower the

Fabric Panel as much as 84” from the Housing.

18. 

19UP







See Figure 17

20

DOWN



the EasyShade to the current

Let the EasyShade stop on its own

See Figure 17

21UP and DOWN

simultaneously



See Figure 17

Note: The EasyShade is temporarily in Programming

Mode. The UP and DOWN buons on the

Remote Transmier must be pressed and held to

reposion the EasyShade. When either buon is

released, the Fabric Panel will stop moving.

22DOWN or UP

to adjust the new Down

marked in Step 10Figure 11

CAUTION: Do not let the EasyShade extend more

than 84” from the Housing. See Figure 18.

23STOP (my) 



Down

UP and DOWN









Figure 17

Figure 18

EasyShade

Housing





Housing



Fabric Panel Extension



Cable Guide

Bracket

Leading Bar in



Operang the EasyShade



24

UP and DOWN

24a. Press and release the UP

EasyShade will roll up into the EasyShade Housing

Up stop limit should stop





Appendix A

24b. Press and release the DOWN

EasyShade will unroll from the EasyShade Housing

Down stop limit should stop







Appendix A

25

Figure 2



CAUTION: Do not leave your Motorized EasyShade

extended during windy condions, as the uncontrolled

movement of the extended EasyShade Fabric Panel

could cause damage to the product and surrounding

items. Simply retract the Motorized EasyShade by

pressing the UP Buon on the Remote Transmier.

CAUTION: Do not permit the hand-held Remote

Transmier to get wet as this can aect its proper

operaon. It is recommended to keep the Remote

Transmier indoors when the EasyShade is not in use

or if rain is expected.

CAUTION: The installaon procedure for the

Motorized EasyShade includes the use of Cable

Guides to stabilize the extended Fabric Panel during

normal use. If your applicaon does not permit the

installaon of the necessary Cable Guides or you do

not plan to install them, you must use addional care

to prevent damage to your product. While we do

not recommend installing the Motorized EasyShade

without the supplied Cable Guides, some customers

may determine that their applicaon does not have a

vercal surface to install the supplied Cable Guides as

instructed.

Note: During an electrical outage, you will not have

the ability to operate your Motorized EasyShade.

“Congratulaons, your installaon is complete.”





Appendix C

Remote Transmiers are Unique









see Figure 20

It is recommended to use Channel 1



Figure 19.



Appendix C

Figure 19







Channel 1











set to Channel 1 works

only with EasyShade 1



set to Channel 1 works

only with EasyShade 4



set to Channel 1 works

only with EasyShade 3



set to Channel 1 works

only with EasyShade 2

EasyShade 1

EasyShade 4

EasyShade 3EasyShade 2

Installaon

Problem Soluon

Can I “hard-wire” the Motorized

EasyShade motor into my

home?

The manufacturer cannot be responsible for any changes in the electrical





their website at hp://www.somfy.com

Note: Some maintenance procedures such as reseng communicaon

between the Remote Transmier and the Motor (see Appendix B)

require power to be interrupted. Therefore, hard-wiring the Motorized

EasyShade can interfere with this procedure.



my Motorized EasyShade will



 Remote Transmier on Channel 1 that came with this



For details, see Page 7

 

Press the UP

or DOWN 





Figure 19

 

 

 UP or DOWN 



 If the motor turns, the problem could be mechanical with the









 If the motor does not turn, the problem could be related to the

Step 6

 

 Press and hold the UP or DOWN 





 

a new Lithium CR2430

Page 9

 

 



 



TROUBLESHOOTING

Appearance

Problem Soluon

Fabric rolls up unevenly or

pulls to one side when the

Motorized EasyShade is



 



 

Both the Aluminum Housing and the Cable Brackets must be installed on









Short lines appear in the











Fabric appears folded or

pleated as it extends from









 



 

where the Aluminum Leading Bar is located, is just below the opening of



Operaon

Problem Soluon



to Open or Close the





be set to Channel 1



 

 Channel 1





CR2430

 

Page 11









the red light on the Remote









1. Remove and replace the Remote Transmier’s Baery with a new Lithium

CR2430

 

 Remove back cover,

 

 

 

 Remove the back cover to allow it to dry out completely,

 

Note

TROUBLESHOOTING

Operaon (connued)

Problem Soluon

My Motorized EasyShade

retracts but will not fully

close into the Aluminum



Appendix A





Appendix B, Programming the



Fabric is stuck inside the

Aluminum Housing









My Motorized EasyShade

rolls out and keeps going

and the Fabric Panel begins





Appendix A





Appendix B



Motorized EasyShades to

operate on one master







See Appendix C, Programming Instrucons - Mul Channel Remote

Transmier.

Can I use more than one



control one Motorized

EasyShade?

See Appendix C, Programming Instrucons - Mul Channel Remote

Transmier



It is recommended to always unplug all Motorized EasyShades except the one



What if I lose my Remote



damaged?



motor?



800-670-7071 to purchase a













The Motorized EasyShade

only operates while the

or DOWN 





 

 

 



 

If the problem persists, please call Customer Service for assistance at

800-670-7071

TROUBLESHOOTING

Operaon (connued)

ADDITIONAL MOTOR TROUBLESHOOTING

Problems:







EasyShade / Motor only runs while holding down the UP or DOWN

Soluon:

 

 Wait two seconds,

 Plug in Motor,

 If the Motor DOES jog, go to Group A

 If the Motor DOES NOT jog, go to Group B

GROUP A GROUP B

 Press and Hold the UP and DOWN



 

 Press and Hold the PROGRAMMING

 

 

 Press and Hold the UP and DOWN



 

 Perform Steps 9 - 18 in Appendix B

 

If GROUP A or B (above) does not x the problem, then . . .

Perform Steps 1 - 18 in Appendix B, or call Technical Support 800-670-7071

Self Test the Remote Transmier;

 Up, Down, my

 

 

 

 CR2430

Channel Indicator Lights



Figure 24



 

 

Light blinks, press the Channel



 

Figure 20







Fabric Panel Extension





To Change the Down Stop Posion:

 Figure 22

and let it stop on its own

 Figure 23



 

 



 

Adjusng the Up and Down Stop Posion

for the Motorized EasyShade



Follow these instrucons to change the

posion where the EasyShade stops. This is

for both the Up and the Down stop posions.

See Figure 20.

Note: Do Not exceed the 84” Down Stop Posion

Limit as this will cause the Fabric Panel to roll up

backwards in the housing. See Figure 20.

To Change the Up Stop Posion:

 Figure 21

let it stop on its own

 Figure 23



 

 Press and hold the (MY



 

APPENDIX A

Figure 21





Figure 22





Figure 23

Holding the





Note: Every EasyShade is programmed

to work on Channel 1 (see Figure 24) of

the specic Remote Transmier shipped

with that Motorized EasyShade. For

more informaon, see Page 7.

Channel 1

APPENDIX B

Reset All Communicaons Between the Motor and Remote Transmier

 

 Press and Hold the my 

 

 

 

 

 Press and hold the Programmingten seconds, watching for two separate jogs back

and forth, several seconds apart

Note: A single jog is a quick two-direcon movement of the motor.

 Press and Hold the UP and DOWN 

Note: The EasyShade now moves ONLY while holding down the UP or DOWN buon.

Programming

Buon

Rear View

To ADD an 

• 



• 

To DELETE

Add/Delete a Remote Transmier

 Press the DOWN 



my

Press the DOWN 

DOWN

Front View

Channel

Selector

Move the EasyShade to the desired UP 

Press and Hold the my and DOWN 



Press the my Stop the EasyShade at the desired Down

Make desired adjustments to the Down

Press and Hold the my and UP 

begins to move UpLet the EasyShade stop on its own at the UP 

Press and Hold the my

Up and

Down

17. Press and Hold the Programming buon, wait for jog

Up and Down

SET PROPER DIRECTION OF MOTOR ROTATION

PREPARE MOTOR - See Figures 25 & 26

SET THE UP AND DOWN POSITIONS

WARNING: ALL STEPS MUST BE FOLLOWED EXACTLY AND COMPLETELY







This procedure overwrites the factory set Up and DownUp and Down

Note: To ONLY change the Up and Down preset posions, follow the basic procedure in Appendix A.

Tools needed: A pen or similar poinng device is needed to press and hold the Programming Buon.

Note: If steps 8-15 fail, unplug the Power, plug back in, then begin again from step 8. If

that fails to help, go to Advanced Motor Troubleshoong on Page 11.

Figure 25

Figure 26

APPENDIX C

PROGRAMMING INSTRUCTIONS - MULTI CHANNEL REMOTE TRANSMITTER

Note: Each EasyShade operates on Channel 1 of the Remote that came with it.

Every Channel on every Remote Transmier is dierent, but you can mix and match them.

Channel

Selector



Channel

Indicator

Lights





my/STOP

Figure 27

How to use the Mul Channel Remote Transmier (see Figure 27):

• To idenfy the currently selected Channel, press and release the Channel



• To select the next Channel





How to program the EasyShade to work with any Channel (see Figures 28, 29 & 30):

One EasyShade can



See Figure 28

Add each Channel to

the EasyShade, using

STEP 1, then STEP 2 in

Figure 30

One Channel can





Figure 29

Add that Channel

to each EasyShade,

using STEP 1, then

STEP 2 in Figure 30



be removed from an

EasyShade using STEP 1,

then STEP 2 in Figure 30.

Programming



Figure 30

STEP 1

Select a Channel that

currently controls

the EasyShade being



Hold the Programming







Note: It is recommended all EasyShades be unplugged from the power source except for the

one EasyShade being programmed. This simplies the process and reduces errors.

STEP 2

Select a Channel to



the EasyShade being



Hold the Programming







Programming



Figure 28 Figure 29

A. WHO GIVES THIS WARRANTY?





B. WHO IS ENTITLED TO THIS WARRANTY?

This Warranty applies only to the original purchaser

who paid for the product and may not be assigned



applies only to products purchased and installed in



C. WHAT ARE THE RESPONSIBILITIES

OF SUNSETTER PRODUCTS UNDER THIS

WARRANTY?











D. WHAT ARE THE RESPONSIBILITIES OF

THE ORIGINAL PURCHASER UNDER THE

WARRANTY?



Warranty, the original purchaser must have paid in

full for the product covered under the Warranty,



IF THE PURCHASER

HAS FAILED TO MAKE FULL PAYMENTS ACCORDING

TO THE SPECIFIC PAY PLAN FOR THE PRODUCT,

THIS WARRANTY SHALL BE NULLIFIED AND

SUNSETTER PRODUCTS SHALL BE RELIEVED FROM

ANY RESPONSIBILITY OR LIABILITY UNDER THIS

WARRANTY. The purchaser agrees and acknowledges











ANY FAILURE TO INSTALL,

5-Year Limited Manufacturer’s Warranty

for EasyShade



MAINTAIN, OPERATE, USE AND STORE THE PRODUCT

IN ACCORDANCE WITH THE INSTRUCTIONS

CONTAINED WITH THE PRODUCT WILL NULLIFY THIS

WARRANTY AND RELIEVE SUNSETTER PRODUCTS

FROM ANY RESPONSIBILITY OR LIABILITY UNDER

THIS WARRANTY.















customer service department prior to the return







E. WHAT IS COVERED UNDER THIS

WARRANTY?



are covered under this Warranty, subject to the

These components

have up to ve (5) year limited (prorated) warranty,













listed below for each component from the date of





prorated amount based on full retail price of the





as percent of the total number of months during the



(Connued on next page.)

2. Covered Components:

STRUCTURAL COMPONENTS AND GEAR MECHANISM

OR ELECTRIC MOTOR (whichever applies to your

warranted for ve (5) years not to fail







VINYL MESH is warranted for ve (5) years against:



maintained, operated, used, and stored in accordance





the mesh itself, but may form on dirt and dust that



clean the vinyl mesh periodically with water and mild











SOLAR PANEL ASSEMBLY (solar-powered model) is

warranted for three (3) years not to fail under normal







BATTERY PACK (solar-powered model) is warranted

for three (3) years

if maintained, operated, used, and stored in





F. WHAT IS NOT COVERED UNDER THIS

WARRANTY?





the purchaser or by any other person is not covered





fasten the EasyShade to studs, joists, headers or



results from the EasyShade falling from its installed









replacement parts are not covered by this Warranty



G. GENERAL PROVISIONS AND LIMITATIONS















































long an implied warranty lasts, or do not allow the











A place for your notes:

SunSeer Products, a Massachuses Limited Partnership, 184 Charles Street, Malden, MA 02148





A place for your notes:

Bali Essentials 21306 Installation guide

Related papers

Other documents