REED R5600 User manual

REED
Brand
REED
Model
R5600
Category
Multimeters
Type
User manual
reedinstruments
www com
Model R5600
Digital Insulation Tester
Instruction
Manual
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
2
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Table of Contents
Safety ............................................................................................ 3
Specications .............................................................................4-5
General ....................................................................................... 4
Electrical ..................................................................................... 5
Meter Description .......................................................................... 6
Operating Instructions ................................................................6-7
How to connect the test leads .................................................... 6
How to check the test leads ........................................................ 7
Battery replacement .................................................................... 7
Measurements ............................................................................7-8
Insulation Resistance Measurements .......................................... 7
Low Resistance Measurements .................................................. 8
AC/DC Voltage Measurements ................................................... 8
Power Tool & Small Appliances ................................................9-10
Motors ........................................................................................ 9
Cables ...................................................................................... 10
For service on this or any other REED product, contact REED Instruments
at info@reedinstruments.com.
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
3
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Safety
• Readthefollowingsafetyinformationcarefullybeforeattemptingto
operate or service the meter.
• Toavoiddamagestotheinstrumentdonotapplythesignalswhich
exceedthemaximumlimitsshowninthetechnicalspecicationstables.
• Donotusethemeterortestleadsiftheylookdamaged.Useextreme
cautionwhenworkingaroundbareconductorsorbusbars.
• Accidentalcontactwiththeconductorcouldresultinelectricshock.
• Usethemeteronlyasspeciedinthismanual;otherwise,theprotection
providedbythemetermaybeimpaired.
• ReadtheoperatinginstructionsbeforeuseandfollowallsafetyInformation.
• Cautionwhenworkingwithvoltagesabove60VDCor30VACRMS.
Suchvoltagesposeashockhazard.
• Beforetakingresistancemeasurementsortestingacousticcontinuity,
disconnect circuit from main power supply and all loads from the circuit.
Safety Symbols:
Caution
Refertothismanualbeforeusingthemeter.
Dangerous voltages.
Meterisprotectedthroughoutbydoubleinsulationorrein-
forced insulation.
When servicing, use only specied replacement parts.
CEComplywithEN-61010-1
For service on this or any other REED product, contact REED Instruments
at info@reedinstruments.com.
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
4
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Specifications
General Specifications
Environment conditions
• InstallationCategoriesII
• PollutionDegree2
• Altitudeupto2000meters
• Indooruseonly
• Relativelyhumidity80%max.
• OperationAmbient0~40ºC
Maintenance & Cleaning
• Repairsorservicingnotcoveredinthismanualshouldonlybe
performedbyqualiedpersonnel.
• Periodicallywipethecasewithadrycloth.Donotuseabrasivesor
solvents on this instruments.
Display: LargeLCDwithdualdisplay
MeasurementRange: 200Ω,200kΩ,200MΩ/250V,200MΩ/500V,
 2000MΩ/1000V,750V/ACV,1000V/DCV.
SamplingRate: 2.5timespersecond.
Zero Adjustment: Automatic adjustment.
OverRangeIndicator: Number1ofhighestdigitisdisplayed.
LowBatteryIndication: The isdisplayedwhenthebatteryvoltage
 dropsbelowtheoperatingvoltage.
OperatingTemperature: 0ºCto40ºC(32ºFto104ºF)
 andHumiditybelow80%RH
StorageTemperature: -10ºCto60ºC(14ºFto140ºF)
 andHumiditybelow70%RH
Powersource: DC9V(6x1.5VSize“AA”batteryorequivalent)
Dimensions: 200(L)x92(W)x50(H)mm
Weight: Approx700gincludingthebatteries
Contents: Testleads,6batteries,
carrying case and manual
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
5
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Electrical Specifications
Accuraciesarespeciedby:
±(…%ofreading+…digits)at23ºC±5ºC,below80%RH.
OHMS
Range Resolution Accuracy Max. open
Circuit Voltage
Overload
Protection
200Ω 0.1Ω +(1%+2) 4.5V 250Vrms
200kΩ 0.1kΩ 3.0V
Continuity Beeper
Range Resolution Operation
Resistance
Max.open
Circuit Voltage
Overload
Protection
•))) 0.1Ω Resistance≤40Ω 4.5V 250Vrms
Short circuit current: ≤200mA
DC Voltage
Range Resolution Accuracy Input
Impedance
Overload
Protection
1000V 1V +(0.8%+3) 10MΩ 1000Vrms
AC Voltage (40Hz~400Hz)
Range Resolution Accuracy Input
Impedance
Overload
Protection
750V 1V +(1.2%+10) 10MΩ 750Vrms
Meg OHMS
Range Resolution Accuracy Terminal Voltage
200MΩ/250V 0.1MΩ
+(3%+5)
250V+10%~-0%
200MΩ/500V 0.1MΩ 500V+10%~-0%
0~1000MΩ/1000V 1MΩ 1000V+10%~-0%
1000~2000MΩ/1000V +(5%+5)
Range Test Current Short circuit current
200MΩ/250V
1mA
250KΩ(load)
≤1mA
200MΩ/500V 500KΩ(load)
0~1000MΩ/1000V 1MΩ
1000~2000MΩ/1000V
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
6
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Meter
Description
1—DigitalDisplay 2—DataHoldButton
3—LockButton 4—BacklightButton
5—TestButton 6—RotaryFunctionswitch
7—VΩJack 8—COMinputjack
9—Pothook 10—BatteryCover
Operating Instructions
How to connect test leads
1.OnMΩRange:Connecttheredtestleadintothe“VΩ”terminal
andtheblackleadintothe“COM”terminal.
2.On200ΩandACVRange:Connecttheredtestleadintothe“VΩ”
terminalandtheblackleadintoterminal“COM”
How to check the test leads
Settherangeselectswitchtothe200Ωrange.Withthetipandalligator
clipofthetestleadsconnected,theindicatorshouldread00.0Ω.When
theleadsarenotconnectedthedisplaywillreadinnityindicatedby“1”.
Thiswillensurethattestleadareunderworkingcondition.
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
7
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Battery Replacement
1.WhenthebatterypowerisnotsufcienttheLCDwilldisplay .
2.Replacementof6newbatteries,type1.5Vsize“AA”isrequired.
3.Oncereplacedbesuretoreinstallthebatterycoverandthefour
screwsbeforeoperating.
Measurements
Insulation Resistance Measurements
Measurements at 200MΩ/250V
This is the voltage used for the majority of insulation resistance tests on
normalinstallationrequirements.Tomeasureinsulationresistance,press
thetestbuttontoturnonthetester.
TheLCDwilldisplaytheinsulationresistance.SectionVIIindicatedthat
subdivisionoflargeinstallationsmightbenecessarybecauseofthelarge
numberofparallelinsulationresistance.Insuchacase,aninstallation
maybedividedintosections,eachbeingseparatelytested.Eachsection
musthaveatleastftyoutlets,anoutletbeingaswitch,socket,lighting
pointetc.Aswitchedsocketcountsasoneoutlet.Theminimumaccept-
ableinsulationresistanceis1MΩ.
Foralargeinstallation,thecapacitanceoftheinsulationwillbehigh,and
itwilltakelongerforittobecomechargedbythedirecttestingvoltage.
Becarefulnottotakeareadinguntilthereisasteadyreading,indicating
that the charging process is complete.
Note:Thechargestoredintheinsulationwillbedischargedautomatically
whenthetestbuttonisreleased.Becarefulnottoturntherangeswitch
knobwhilethetestbuttonispressed,ortheinstrumentwillbedamaged.
Measurements at 2000MΩ/1000V
Somespecicationsrequiretestingat1000V.Thisvoltagemustalsobe
selectedwherethesupplyvoltageoftheinstallationisbetween500Vand
1000V.First,settherangeswitchto1000Vandthenproceedasindicated
inabovefor500Vtesting.
Theabovenotealsoappliestotestingat1000V.In addition the following
applies.
continued ...
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
8
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Note: Makesurethatthecircuitunderdoesnotincludecomponents
Whichwillbedamagedbythe1000Vapplied.Manynormalcomponents
ofaninstallationarelikelytobedamagediftestedat1000V.Examplesare
powerfactorcorrectioncapacitors,lowvoltagemineralinsulatedcables,
electroniclightdimmers,electronicballastsandstartersforuorescent
lampsetc…
Lock Power on Feature
Forhandsfreeoperationalockpoweronfeatureisincorporatedinthe
presstotestbutton.SettheLOCKbuttontolocktestvoltage,pressingit
again will turn the tester off.
Low Resistance (Continuity) Measurements
1.Settherangeswitchto200Ω•)))Position
2.ConnecttheredtestleadtotheVΩterminalandbacktothe
COMterminal.
3.Connectthetipsofthetestleadstobothendsofthecircuitundertest.
ReadresistanceinΩontheLCD.
4.Whentheimpedanceoncircuitisbelowapproximately40Ω.
Itwillindicatebyacontinuousbeeper.
AC/DC Voltage Measurements
1.SettherangeswitchtoACVorDCVposition
2.Connectredtestleadto“VΩ”terminalandblacktestlead
toterminal“COM”.
3.ConnecttestprodsoftestleadsINPARALLELtothecircuit
beingmeasured.
4.ReadthevoltagevalueonLCD.
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
9
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Power Tools & Small Appliances
This test would also apply to
othersimilarequipmentthat
hasalinecord.Fordouble
insulated power tools, the
megohmmeter lead shown
(Seegraphiconpage8)
connected to the housing
wouldbeconnectedto
some metal part of the tool
(ie:chuck,blade).
Note:Theswitchofthe
devicemustbeinthe“ON”
position and the main power
shouldbedisconnected.
Motors
AC-Disconnectthemotorfromthelinebydisconnectingthewiresatthe
motorterminalsorbyopeningthemainswitch.Ifthemainswitchisused
andthemotoralsohasastarterthenthestartermustbeheld,bysome
means,inthe“ON”position.Inthelattercase,themeasuredresistance
willincludetheresistanceofthemotor,wireandallothercomponentsbe-
tweenthemotorandthemainswitch.Ifaweaknessisindicated,themo-
torandothercomponentsshouldbecheckedindividually.Ifthemotoris
disconnected at the motor terminals, connect one megohmmeter lead to
the grounded motor housing and the other lead to One of the motor leads.
DC-Disconnectthemotorfromtheline.Totestthebrushrigging,eld
coils and armature connect one megohmmeter lead to the grounded
motorhousingandtheotherleadtothebrushonthecommutator.Ifthe
resistancemeasurementindicatesaweakness,raisethebrushesoffthe
commutatorandseparatelytestthearmature,eldcoilsandbrushrigging
byconnectingonemegohmmeterleadtoeachofthemindividually,leav-
ingtheotherconnectedtothegroundedmotorhousing.Theabovealso
appliestoDCGemerators.
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
10
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Cables
Disconnectthecablefromtheline.Alsodisconnectoppositeendtoavoid
errorsduetoleakagefromotherequipment.Checkeachconductorto
groundand/orleadsheathbyconnectingonemegohmmeterleadtoa
groundand/orleadsheatherandtheothermegohmmeterleadtoeachof
theconductorsinturn.Checkinsulationresistancebetweenconductors
byconnectingmegohmmeterleadstoconductorsinpairs.
For service on this or any other REED product, contact REED Instruments
at info@reedinstruments.com.
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
11
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
Notes _________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
www. .com information@itm.com1.800.561.8187
reedinstruments
www com
12
Pantone 534 Blue
Pantone 123 Yellow
Pantone 485 Red
Pantone 123 Yellow
Pantone 534 Blue
Black Rich Black -
20/20/20/100
Blue - 100/80/30/5
Yellow - 0/27/100/0
Red - 10/100/100/5
Yellow - 0/27/100/0
Blue - 100/80/30/5
Only if you REALLY need them:
Pantone 534 Blue - 100/80/30/5
Pantone 485 Red - 10/100/100/5
Pantone 123 Yellow - 0/27/100/
INSTRUMENTS
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
________________________________________________
www. .com information@itm.com1.800.561.8187
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12

REED R5600 User manual

REED
Brand
REED
Model
R5600
Category
Multimeters
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents