Andersen 9069150 Jamb Liner Dust Pad Replacement Service Instructions

Brand: Andersen

Model: 9069150 Jamb Liner Dust Pad Replacement

Type: Service Instructions

Jamb Liner Dust Pad

9069150 BA Revised 06/03/13

Jamb Liner Dust Pad Replacement

for E-Series Double-Hung Windows

Thank you for choosing Andersen.

For questions call 1-888-888-7020. For more information and/or guides visit eaglewindow.com

Please leave this guide with building owner.

▶Read guide from beginning to end before starting maintenance procedure. Read all warnings and cautions during unit maintenance.

Parts Included

(1) Jamb Liner Dust Pad

▶For information, calculating, and design pressure ratings for E-Series windows and doors go to

www.eaglewindow.com/Wintelligence/Design-Pressure-Estimator.aspx

▶Check with your local building code ofcial to identify and conrm compliance with local building code requirements.

Tools Needed

∙Safety Glasses

∙Thin Blade Putty Knife

∙Finish Nailer (for monumental units only)

∙Pliers (for monumental units only)

Supplies Needed

∙Denatured Alcohol

∙Clean Cloth

Use caution when working at elevated

heights and around unit openings. Follow

manufacturers’ instructions for ladders and/

or scaffolding. Failure to do so may result in

injury or death.

Follow manufacturers’ instructions for hand

or power tools. Always wear safety glasses.

Failure to do so may result in injury and/or

product damage.

Windows and doors can be heavy. Use safe

lifting techniques and a reasonable number of

people with enough strength to lift, carry and

install window and door products to avoid injury

and/or product damage.

9069150

Slide tilt latches inward while tilting sash in 90 degrees.Lower top sash 6”.

Tilt Latches

6 Inches

Interior

Interior Tilt

Latches

Pivot bottom sash to remove from window

frame as shown. Place sash on clean at work

surface, exterior side up.

Rotate and hold lock handles toward center

while tilting sash in 90 degrees.

Unlock window and raise bottom sash 4".

Lock

Handles

4 Inches

Lock

Handles

Interior

Bottom Sash

Pry interior side stop away from frame. Repeat on opposite side. Remove any nails from frame and

interior side stops.

Remove sash stop from the side jamb.

Thin Blade Putty Knife

Interior Side Stop

Pliers

Interior Side Stop

For Monumental Only

Single Hung and Monumental Only

▶For double hung units proceed to step 6.

Interior

▶For single and double hung units proceed to step 2.

Interior

9069150

Remove release liner and apply new dust pad.

Interior

Clean dust pad area with clean cloth and denatured alcohol.

Remove existing dust pad and dispose of properly.

Dust Pads

Dust Pad

Tilt sash up, retracting tilt latches by sliding inward. Release tilt latches to

re-engage sash in frame. Verify top sash operation. Repeat steps 12-13 if

sash does not operate correctly.

Rotate top sash to engage pivot pins into balance shoes of exterior

channel. Push down until both pivot pins are fully engaged.

Tilt

Latches

Balance

Shoes

Tilt Latches

Release Liner

Clean Cloth and

Denatured Alcohol

Interior

Pivot Pin

Putty Knife

Pivot top sash to remove from window frame as shown. Place sash on

clean at work surface, exterior side up.

Interior

Top Sash

▶For double hung units proceed to step 15.

9069150

Verify sash operation. Repeat steps 15-16 if sash does not

operate correctly.

Close and lock window.

Lock Handles

Tilt sash up, retracting tilt latches by rotating lock handles toward

center, then release lock handles to re-engage sash.

Lock Handles

▶Jamb liner dust pad replacement procedure is complete for single

and double hung units.

▶For monumental units proceed to step 19.

Rotate bottom sash to engage pivot pins into balance shoes of interior

channel. Push down until both pivot pins are fully engaged.

Balance

Shoe

Interior

Channel

Pivot Pin

Interior

Replace sash stop in the side jamb.

Interior

Sash Stop

Single Hung and Monumental Only

▶Jamb liner dust pad replacement procedure is complete for

monumental units.

Reapply interior side stop on frame. Repeat on opposite side. Fasten with

nish nailer.

Interior Side

Stop

For Monumental Only

Interior

Andersen 9069150 Jamb Liner Dust Pad Replacement Service Instructions

Andersen 9069150 Jamb Liner Dust Pad Replacement Service Instructions

Andersen 9069150 Jamb Liner Dust Pad Replacement Service Instructions

Related papers

Other documents