IEI Technology KINO-DH810 User manual

KINO-DH810

Page I

User Manual

KINO-DH810

MODEL:

Mini-ITX SBC supports 22nm LGA1150 socket Intel® Core™ i7/i5/i3

and Celeron® processor, DDR3, DVI-D / VGA / DP, Dual Intel®

PCIe GbE, USB 3.0, SATA 6Gb/s, HD Audio and RoHS

Rev. 1.00 - 17 December, 2013

KINO-DH810 CPU Card

KINO-DH810

Page II

Revision

Date Version Changes

17 December, 2013 1.00 Initial release

KINO-DH810

Page III

Copyright

COPYRIGHT NOTICE

The information in this document is subject to change without prior notice in order to

improve reliability, design and function and does not represent a commitment on the part

of the manufacturer.

In no event will the manufacturer be liable for direct, indirect, special, incidental, or

consequential damages arising out of the use or inability to use the product or

documentation, even if advised of the possibility of such damages.

This document contains proprietary information protected by copyright. All rights are

reserved. No part of this manual may be reproduced by any mechanical, electronic, or

other means in any form without prior written permission of the manufacturer.

TRADEMARKS

All registered trademarks and product names mentioned herein are used for identification

purposes only and may be trademarks and/or registered trademarks of their respective

owners.

KINO-DH810

Page IV

Table of Contents

1 INTRODUCTION .......................................................................................................... 1

1.1 INTRODUCTION ........................................................................................................... 2

1.2 FEATURES ................................................................................................................... 3

1.3 CONNECTORS ............................................................................................................. 4

1.4 DIMENSIONS ............................................................................................................... 5

1.5 DATA FLOW ................................................................................................................ 6

1.6 TECHNICAL SPECIFICATIONS ...................................................................................... 7

2 UNPACKING ................................................................................................................. 9

2.1 ANTI-STATIC PRECAUTIONS ...................................................................................... 10

2.2 UNPACKING PRECAUTIONS ....................................................................................... 10

2.3 PACKING LIST ............................................................................................................ 11

2.4 OPTIONAL ITEMS ...................................................................................................... 12

3 CONNECTORS ........................................................................................................... 14

3.1 PERIPHERAL INTERFACE CONNECTORS ..................................................................... 15

3.1.1 KINO-DH810 Layout ....................................................................................... 15

3.1.2 Peripheral Interface Connectors ..................................................................... 16

3.1.3 External Interface Panel Connectors ............................................................... 17

3.2 INTERNAL PERIPHERAL CONNECTORS ...................................................................... 17

3.2.1 AT/ATX Mode Select Switch ............................................................................. 17

3.2.2 Battery Connector ............................................................................................ 18

3.2.3 Clear CMOS Button ......................................................................................... 19

3.2.4 12V DC-IN Power Connector .......................................................................... 20

3.2.5 DDR3 SO-DIMM Slots .................................................................................... 21

3.2.6 Digital I/O Connector ...................................................................................... 22

3.2.7 Display Port Connector ................................................................................... 23

3.2.8 Fan Connector (CPU) ...................................................................................... 24

3.2.9 Fan Connector (System) .................................................................................. 25

3.2.10 Front Audio Connector .................................................................................. 26

3.2.11 Front Panel Connector ................................................................................... 26

KINO-DH810

Page V

3.2.12 Keyboard/Mouse Connector .......................................................................... 27

3.2.13 LAN LED Connector ...................................................................................... 28

3.2.14 PCIe x1 Slot ................................................................................................... 29

3.2.15 PCIe Mini Card Slot ...................................................................................... 30

3.2.16 Power Button ................................................................................................. 31

3.2.17 SATA 6Gb/s Drive Connectors ....................................................................... 31

3.2.18 SATA Power Connectors ................................................................................ 32

3.2.19 Serial Port Connector, RS-422/485 ................................................................ 33

3.2.20 Serial Port Connectors, RS-232 ..................................................................... 34

3.2.21 SMBUS Connector ......................................................................................... 34

3.2.22 TPM Connector .............................................................................................. 35

3.2.23 USB Connectors ............................................................................................. 36

3.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 37

3.3.1 Audio Connector .............................................................................................. 38

3.3.2 Ethernet and USB Connectors ......................................................................... 38

3.3.3 12V DC- IN Power Connector ......................................................................... 40

3.3.4 RS-232 Serial Port Connectors ........................................................................ 41

3.3.5 VGA and DVI Connector ................................................................................. 42

4 INSTALLATION ......................................................................................................... 44

4.1 ANTI-STATIC PRECAUTIONS ...................................................................................... 45

4.2 INSTALLATION CONSIDERATIONS .............................................................................. 46

4.3 BASIC INSTALLATION ............................................................................................... 47

4.3.1 Socket LGA1150 CPU Installation .................................................................. 47

4.3.2 Cooling Kit Installation ................................................................................... 50

4.3.3 SO-DIMM Installation ..................................................................................... 51

4.4 INTERNAL PERIPHERAL DEVICE CONNECTIONS ........................................................ 53

4.4.1 SATA Drive Connection ................................................................................... 53

4.5 EXTERNAL PERIPHERAL INTERFACE CONNECTION ................................................... 54

4.5.1 Audio Connection ............................................................................................. 54

4.5.2 DVI Display Device Connection ...................................................................... 55

4.5.3 LAN Connection ............................................................................................... 56

4.5.4 Serial Device Connection ................................................................................ 57

4.5.5 USB Connection ............................................................................................... 58

4.5.6 VGA Monitor Connection ................................................................................ 59

KINO-DH810

Page VI

5 BIOS .............................................................................................................................. 61

5.1 INTRODUCTION ......................................................................................................... 62

5.1.1 Starting Setup ................................................................................................... 62

5.1.2 Using Setup ...................................................................................................... 62

5.1.3 Getting Help ..................................................................................................... 63

5.1.4 Unable to Reboot after Configuration Changes .............................................. 63

5.1.5 BIOS Menu Bar ................................................................................................ 63

5.2 MAIN ........................................................................................................................ 64

5.3 ADVANCED ............................................................................................................... 65

5.3.1 ACPI Configuration ......................................................................................... 66

5.3.2 Trusted Computing ........................................................................................... 67

5.3.3 CPU Configuration .......................................................................................... 69

5.3.4 SATA Configuration ......................................................................................... 71

5.3.5 USB Configuration ........................................................................................... 72

5.3.6 F81866 Super IO Configuration ...................................................................... 73

5.3.6.1 Serial Port n Configuration ....................................................................... 74

5.3.7 F81866 H/W Monitor ....................................................................................... 79

5.3.7.1 Smart Fan Mode Configuration ................................................................ 80

5.3.8 Serial Port Console Redirection ...................................................................... 83

5.3.8.1 Console Redirection Settings .................................................................... 84

5.3.9 IEI Feature ....................................................................................................... 87

5.4 CHIPSET ................................................................................................................... 88

5.4.1 PCH-IO Configuration .................................................................................... 89

5.4.1.1 PCH Azalia Configuration ........................................................................ 90

5.4.2 System Agent (SA) Configuration .................................................................... 91

5.4.2.1 Graphics Configuration ............................................................................. 91

5.4.2.2 Memory Configuration ............................................................................. 93

5.5 BOOT ........................................................................................................................ 94

5.6 SECURITY ................................................................................................................. 96

5.7 EXIT ......................................................................................................................... 97

A BIOS MENU OPTIONS ............................................................................................. 99

B ONE KEY RECOVERY ........................................................................................... 102

B.1 ONE KEY RECOVERY INTRODUCTION .................................................................... 103

KINO-DH810

Page VII

B.1.1 System Requirement ....................................................................................... 104

B.1.2 Supported Operating System ......................................................................... 105

B.2 SETUP PROCEDURE FOR WINDOWS ........................................................................ 106

B.2.1 Hardware and BIOS Setup ............................................................................ 107

B.2.2 Create Partitions ........................................................................................... 107

B.2.3 Install Operating System, Drivers and Applications ...................................... 111

B.2.4 Building the Recovery Partition ..................................................................... 112

B.2.5 Create Factory Default Image ........................................................................ 114

B.3 AUTO RECOVERY SETUP PROCEDURE ..................................................................... 119

B.4 SETUP PROCEDURE FOR LINUX .............................................................................. 123

B.5 RECOVERY TOOL FUNCTIONS ................................................................................ 127

B.5.1 Factory Restore ............................................................................................. 128

B.5.2 Backup System ............................................................................................... 129

B.5.3 Restore Your Last Backup .............................................................................. 130

B.5.4 Manual ........................................................................................................... 131

B.6 RESTORE SYSTEMS FROM A LINUX SERVER THROUGH LAN .................................. 132

B.6.1 Configure DHCP Server Settings .................................................................. 133

B.6.2 Configure TFTP Settings ............................................................................... 134

B.6.3 Configure One Key Recovery Server Settings ............................................... 135

B.6.4 Start the DHCP, TFTP and HTTP ................................................................. 136

B.6.5 Create Shared Directory ................................................................................ 136

B.6.6 Setup a Client System for Auto Recovery ...................................................... 137

B.7 OTHER INFORMATION ............................................................................................ 140

B.7.1 Using AHCI Mode or ALi M5283 / VIA VT6421A Controller ....................... 140

B.7.2 System Memory Requirement ........................................................................ 142

C TERMINOLOGY ..................................................................................................... 143

D WATCHDOG TIMER .............................................................................................. 148

E HAZARDOUS MATERIALS DISCLOSURE ....................................................... 151

E.1 HAZARDOUS MATERIAL DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS

ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY ..................................... 152

KINO-DH810

Page VIII

List of Figures

Figure 1-1: KINO-DH810 ................................................................................................................. 2

Figure 1-2: Connectors

.................................................................................................................. 4

Figure 1-3: KINO-DH810 Dimensions (mm)

................................................................................. 5

Figure 1-4: Data Flow Diagram

...................................................................................................... 6

Figure 3-1: Connector and Jumper Locations

...........................................................................15

Figure 3-2: AT/ATX Mode Select Switch Location

....................................................................18

Figure 3-3: Battery Connector Location

.....................................................................................19

Figure 3-4: Clear CMOS Button Location

...................................................................................20

Figure 3-5: 12V DC-IN Power Connector Location

....................................................................21

Figure 3-6: DDR3 SO-DIMM Slot Locations

...............................................................................22

Figure 3-7: Digital I/O Connector Location

................................................................................22

Figure 3-8: Display Port Connector Location

............................................................................23

Figure 3-9: CPU Fan Connector Locations

................................................................................24

Figure 3-10: System Fan Connector Location

...........................................................................25

Figure 3-11: Front Audio Connector Location

...........................................................................26

Figure 3-12: Front Panel Connector Location

...........................................................................27

Figure 3-13: Keyboard/Mouse Connector Location

..................................................................28

Figure 3-14: LAN LED Connector Location

...............................................................................29

Figure 3-15: PCIe x1 Slot Location

.............................................................................................30

Figure 3-16: PCIe Mini Card Slot Location

.................................................................................30

Figure 3-17: Power Button Location

...........................................................................................31

Figure 3-18: SATA 6Gb/s Drive Connector Locations

..............................................................32

Figure 3-19: SATA Power Connector Locations

.......................................................................32

Figure 3-20: RS-422/485 Connector Location

............................................................................33

Figure 3-21: Serial Port Connector Location

.............................................................................34

Figure 3-22: SMBus Connector Location

...................................................................................35

Figure 3-23: TPM Connector Location

........................................................................................36

Figure 3-24: USB Connector Locations

......................................................................................37

Figure 3-25: KINO-DH810 External Peripheral Interface Connector

........................................38

Figure 3-26: Audio Connector

.....................................................................................................38

Figure 3-27: LAN Connector

........................................................................................................39

KINO-DH810

Page IX

Figure 3-28: 12V DC-IN Power Connector ..................................................................................41

Figure 3-29: RS-232 Serial Port Connector

................................................................................41

Figure 3-30: VGA Connector

.......................................................................................................42

Figure 4-1: Disengage the CPU Socket Load Lever

..................................................................48

Figure 4-2: Remove Protective Cover

.........................................................................................48

Figure 4-3: Insert the Socket LGA1150 CPU

..............................................................................49

Figure 4-4: Close the Socket LGA1150

.......................................................................................50

Figure 4-5: Cooling Kit Support Bracket

....................................................................................51

Figure 4-6: SO-DIMM Installation

................................................................................................52

Figure 4-7: SATA Drive Cable Connection

.................................................................................53

Figure 4-8: Audio Connector

.......................................................................................................55

Figure 4-9: DVI Connector

...........................................................................................................56

Figure 4-10: LAN Connection

......................................................................................................57

Figure 4-11: Serial Device Connector

.........................................................................................58

Figure 4-12: USB Connector

........................................................................................................59

Figure 4-13: VGA Connector

.......................................................................................................60

Figure B-1: IEI One Key Recovery Tool Menu

.........................................................................103

Figure B-2: Launching the Recovery Tool

...............................................................................108

Figure B-3: Recovery Tool Setup Menu

...................................................................................108

Figure B-4: Command Prompt

..................................................................................................109

Figure B-5: Partition Creation Commands

...............................................................................110

Figure B-6: Launching the Recovery Tool

...............................................................................112

Figure B-7: Manual Recovery Environment for Windows ......................................................112

Figure B-8: Building the Recovery Partition

............................................................................113

Figure B-9: Press Any Key to Continue

...................................................................................113

Figure B-10: Press F3 to Boot into Recovery Mode

................................................................114

Figure B-11: Recovery Tool Menu

............................................................................................114

Figure B-12: About Symantec Ghost Window

.........................................................................115

Figure B-13: Symantec Ghost Path

..........................................................................................115

Figure B-14: Select a Local Source Drive

................................................................................116

Figure B-15: Select a Source Partition from Basic Drive

.......................................................116

Figure B-16: File Name to Copy Image to

................................................................................117

Figure B-17: Compress Image

...................................................................................................117

Figure B-18: Image Creation Confirmation

..............................................................................118

Figure B-19: Image Creation Complete

....................................................................................118

KINO-DH810

Page X

Figure B-20: Image Creation Complete ....................................................................................118

Figure B-21: Press Any Key to Continue

.................................................................................119

Figure B-22: Auto Recovery Utility

...........................................................................................120

Figure B-23: Launching the Recovery Tool

.............................................................................120

Figure B-24: Auto Recovery Environment for Windows

........................................................120

Figure B-25: Building the Auto Recovery Partition

.................................................................121

Figure B-26: Factory Default Image Confirmation

..................................................................121

Figure B-27: Image Creation Complete

....................................................................................122

Figure B-28: Press any key to continue

...................................................................................122

Figure B-29: Partitions for Linux

...............................................................................................124

Figure B-30: Manual Recovery Environment for Linux

..........................................................125

Figure B-31: Access menu.lst in Linux (Text Mode)

...............................................................126

Figure B-32: Recovery Tool Menu

............................................................................................126

Figure B-33: Recovery Tool Main Menu

...................................................................................127

Figure B-34: Restore Factory Default

.......................................................................................128

Figure B-35: Recovery Complete Window

...............................................................................129

Figure B-36: Backup System

.....................................................................................................129

Figure B-37: System Backup Complete Window

....................................................................130

Figure B-38: Restore Backup

....................................................................................................130

Figure B-39: Restore System Backup Complete Window

......................................................131

Figure B-40: Symantec Ghost Window

....................................................................................131

KINO-DH810

Page XI

List of Tables

Table 1-1: Technical Specifications .............................................................................................. 8

Table 3-1: Peripheral Interface Connectors

...............................................................................17

Table 3-2: Rear Panel Connectors

..............................................................................................17

Table 3-3: AT/ATX Mode Select Switch Settings

.......................................................................18

Table 3-4: Battery Connector Pinouts

........................................................................................19

Table 3-5: Clear CMOS Button Settings

.....................................................................................19

Table 3-6: 12V DC-IN Power Connector Pinouts

.......................................................................21

Table 3-7: Digital I/O Connector Pinouts

....................................................................................23

Table 3-8: Display Port Connector Pinouts

...............................................................................24

Table 3-9: CPU Fan Connector Pinouts

.....................................................................................25

Table 3-10: System Fan Connector Pinouts

..............................................................................25

Table 3-11: Front Audio Connector Pinouts

..............................................................................26

Table 3-12: Front Panel Connector Pinouts

...............................................................................27

Table 3-13: Keyboard/Mouse Connector Pinouts

.....................................................................28

Table 3-14: LAN LED Connector Pinouts

...................................................................................29

Table 3-15: SATA Power Connector Pinouts

.............................................................................33

Table 3-16: RS-422/485Connector Pinouts

................................................................................33

Table 3-17: Serial Port Connector Pinouts

................................................................................34

Table 3-18: SMBus Connector Pinouts

......................................................................................35

Table 3-19: TPM Connector Pinouts

...........................................................................................36

Table 3-20: USB 2.0 Connector Pinouts (USB1, USB2)

............................................................37

Table 3-21: LAN2_USB1 Connector Pinouts

.............................................................................39

Table 3-22: LAN1_USB1 Connector Pinouts .............................................................................40

Table 3-23: 12V DC-IN Power Connector Pinouts

.....................................................................41

Table 3-24: RS-232 Serial Port Connector Pinouts (COM1, COM2)

.........................................42

Table 3-25: VGA Connector Pinouts

...........................................................................................42

Table 3-26: DVI Connector Pinouts

.............................................................................................43

Table 5-1: BIOS Navigation Keys

................................................................................................63

KINO-DH810

Page XII

List of BIOS Menus

BIOS Menu 1: Main .......................................................................................................................65

BIOS Menu 2: Advanced

..............................................................................................................66

BIOS Menu 3: ACPI Configuration

..............................................................................................66

BIOS Menu 4: Trusted Computing

..............................................................................................68

BIOS Menu 5: CPU Configuration

...............................................................................................69

BIOS Menu 6: SATA

Configuration .............................................................................................71

BIOS Menu 7: USB Configuration

...............................................................................................72

BIOS Menu 8: Super IO Configuration

........................................................................................73

BIOS Menu 9: Serial Port n Configuration Menu

.......................................................................74

BIOS Menu 10: Hardware Health Configuration

........................................................................79

BIOS Menu 11: FAN 1 Configuration

..........................................................................................80

BIOS Menu 12: Serial Port Console Redirection

.......................................................................84

BIOS Menu 13: Console Redirection Settings

...........................................................................85

BIOS Menu 14: IEI Feature

...........................................................................................................87

BIOS Menu 15: Chipset

................................................................................................................88

BIOS Menu 16:PCH-IO Configuration

.........................................................................................89

BIOS Menu 17:PCH-IO Configuration

.........................................................................................90

BIOS Menu 18: System Agent (SA) Configuration

....................................................................91

BIOS Menu 19: Graphics Configuration

.....................................................................................92

BIOS Menu 20: Memory Configuration

.......................................................................................94

BIOS Menu 21: Boot

.....................................................................................................................94

BIOS Menu 22: Security

...............................................................................................................96

BIOS Menu 23:Exit

........................................................................................................................97

BIOS Menu 24: IEI Feature .........................................................................................................123

KINO-DH810

Page 1

1 Introduction

Chapter

1

KINO-DH810

Page 2

1.1 Introduction

Figure 1-1: KINO-DH810

The KINO-DH810 is a Mini-ITX motherboard. It accepts a LGA1150 Intel® Core™ i7/i5/i3

and Celeron® processor and supports two 204-pin 1066/1333/1600 MHz dual-channel

DDR3 SDRAM unbuffered SO-DIMM modules up to 16 GB.

The integrated Intel® H81 system chipset supports two GbE LAN ports through dual

Intel® I211AT PCIe GbE controllers.

The KINO-DH810 includes one external VGA connector, one external DVI-D connector

and one internal display port connector. Expansion and I/O include one PCIe x1 slot, one

mini PCIe card slot, two USB 3.0 connectors on rear panel, two USB 2.0 connectors on

rear panel, four USB 2.0 connectors by pin header and two SATA 6Gb/s connectors.

Serial device connectivity is provided by one internal RS-422/485 connector, three internal

RS-232 connectors and two external RS-232 connectors.

KINO-DH810

Page 3

1.2 Features

Some of the KINO-DH810 motherboard features are listed below:

 LGA1150 Intel® Core™ i7/i5/i3 and Celeron® processor supported

 DDR3 1066/1333/1600 MHz dual channel SDRAM

 3D micro-architecture enhancements supports for DX11.1, OCL 1.2 and

OGL3.2

 Rich media acceleration for hardware decode and encode acceleration

 High speed I/O interface for USB 3.0, SATA 6Gb/s and mSATA supported

 IEI jumper-less function

KINO-DH810

Page 4

1.3 Connectors

The connectors on the KINO-DH810 are shown in the figure below.

Figure 1-2: Connectors

KINO-DH810

Page 5

1.4 Dimensions

The dimensions of the board are listed below:

 Length: 170 mm

 Width: 170 mm

Figure 1-3: KINO-DH810 Dimensions (mm)

KINO-DH810

Page 6

1.5 Data Flow

Figure 1-4 shows the data flow between the system chipset, the CPU and other

components installed on the motherboard.

Figure 1-4: Data Flow Diagram

KINO-DH810

Page 7

1.6 Technical Specifications

KINO-DH810 technical specifications are listed below.

Specification KINO-DH810

CPU

22nm LGA1150 socket supports Intel® Core™ i7/i5/i3 and

Celeron® processor

PCH

Intel® H81

Memory

Two 240-pin 1066/1333/1600 MHz dual-channel DDR3

SRAM unbuffered SO-DIMM supported (system max. 16GB)

BIOS

UEFI BIOS

Ethernet

Dual Intel I211AT PCIe GbE controller

Graphic Engine

Support for DX11.1 and OpenGL3.2

Full MPEG2, VC1, AVC Decode

Display Output

DVI-D integrated in the CPU

VGA integrated in the Intel® H81

DisplayPort integrated in the CPU (pin header for changing to

HDMI, LVDS, VGA, DVI, DisplayPort)

Super I/O

Fintek F81866

EC

ITE 8519

Audio

Realtek ALC662 HD Audio codec

Digital I/O

8-bit digital I/O (4-bit input, 4-bit output)

Watchdog Timer

Software programmable supports 1~255 sec. system reset

Expansions

PCIe

1 x PCIex1 slot (with x1 signal)

1 x Mini PCIe card slot (colay mSATA)

I/O Interface Connectors

Audio Connector

Two external audio jacks (Line-out, Mic)

Ethernet

Two RJ-45 ports

Keyboard/Mouse

1 x 6-pin wafer for PS/2 KB/MS

KINO-DH810

Page 8

Specification KINO-DH810

TPM 1 x 20-pin (2x10) header

SMBus 1 x 4-pin (1x4) wafer

Fan 1 x 4-pin (1x4) CPU fan connector

1 x 4-pin (1x4) system fan connector

Serial Ports

5 x RS-232 (2 on Rear I/O, 3 by pin header)

1 x RS-422/485 by 4-pin wafer

USB Ports

2 x USB 3.0 (on Rear I/O)

6 x USB 2.0 (2 on Rear I/O, 4 by pin header)

Front Panel

1 x Front Panel (Power LED, HDD LED, Speaker, Power

Button, Reset Button)

LAN LED 2 x 2-pin (1x2) header for LAN1 LED, LAN2 LED

Storage

Serial ATA

2 x SATA 6Gb/s without raid support

Environmental and Power Specifications

Power Supply

DC input (12V only)

Operating Temperature

-20ºC ~ 60ºC

Humidity

5% ~ 95% (non-condensing)

Physical Specifications

Dimensions

170 mm x 170 mm

Weight GW/NW

900 g / 450 g

Table 1-1: Technical Specifications

Page is loading ...

IEI Technology KINO-DH810 User manual

IEI Technology KINO-DH810 User manual

Related papers

Other documents