Elite Screens 235 User manual

Rev.051811‐

www.elitesc















S

eens.com





ixed

 

info

rame

User’s

elitescreens.com

rojecti

Guide



n Scre



1

2

Rev.051811‐AS

www.elitescreens.com

 [email protected]

Pleasemakesureallpartslistedbelowareincludedbeforeproceedingwiththeinstallation.



1.FramePartsx6pcs(4Top&Bottomframepcs+2Sideframepcs)

2.TensionRodsx6pcs(4Top&Bottomframe rods +2 Siderods)

3.ScreenMaterial

x1pc

4.CenterJointsx2pcs

5.ElbowJointsx4pcs

6.WallBracketsx2‐3pcs(dependingonsize)

7.Screwsx16pcs

8.UserGuidex1pc

9.CenterSupportBarx1‐2pcs(dependingonsize)

10.SupportJoinerx

2‐4pcs(dependingonsize)

11.FixPlatesx30‐90pcs(dependingonsize)

12.BlackClothBackingx1pc(AcousticPro1080modelsonly)



AssembletheFrame

1.InserttheCenterJointConnectortothehorizonta lframepieceandsecurewithscrews.





Parts List for the Cinema235 Series

Installation Instructions

3

Rev.051811‐AS

www.elitescreens.com

 [email protected]

2.InserttheotherhorizontalframepiecetotheCenterJointconnectorandsecurewithscrews.



Note:Tomakesuretheframepieceslineupcorrectly,donottightenthescrewsuntilassemblyiscomplete.

3.InsertbothElbowJointconnectorsintothelonghorizontalframe(seefig.1).



Push

Joint

Long frame

( fig.1)

Push

Short frame

1/2Longframe

Push

4

Rev.051811‐AS

www.elitescreens.com

 [email protected]

Push

( fig.2)

Insert the exposed ends of the joint connectors

into the short (vertical) frame and align the four

corners so that they meet at perfect right angles

4.Joinallfourframepartstogetherfollowingthestepsshowedbelow(seefig.2)



5.Makesureallfourcornersjoincorrectlytoformaperfectrectangle,thenfastenthefourangles

togetherbyusingtheincludedjointscrews.(seefig.3)



Screw

( fig.3)

5

Rev.051811‐AS

www.elitescreens.com

 [email protected]

TensionRod(Horizontal)x4

TensionRod(Vertical)x2

AttachtheScreenMaterialtotheFrame

1.LayoutthematerialandTensionRodsonaclean&drysurface.InserttheTensionRodsthroughthe

sleevesaccordingtotheircorrespondinglengthsoneachedgeofthescreen(seefig.4).







2.Placethescreenmaterialonthebackoftheframeandinsertthe

tensionrodsintothegrooves

runningofeachcorneroftheframe.InserttheFixPlatestothebackoftheframetosecuretherods

intoplacecreatingtension foraflatsurface(seefig.5&6).



Push

( fig.5)

Viewing surface

(Front of screen)

Steel rod

fix plate

Steel rod

Push

( fig.4)

Steel rod

Screen

Push

6

Rev.051811‐AS

www.elitescreens.com

 [email protected]



BlackBackingforAcousticPro1080Models



ThisprocedureonlyappliestomodelswithA cousticPro1080Material.TheBlackBackingcountersthe

effectsoflightpenetrationthatwouldotherwiselightupallitemsbehindthescreenandspoilthe

picture.AttachtheBlackBackingbehindtheprojectionsurfaceandsecuretotheVelcro‐FacedFix

Plates.







Afterthematerialhasbeeninstalled,thebackingwilllieoverthebackofthewhite(AcousticPro1080)materialand

thenbeheldintoplacebythefixplatesastheyareadded(fig.1‐3).Intervalmarkingsrevealthesuggestedpoints

ofattachment(fig.1).Theprongsonthefixplates

(fig.2)straddlealiponthebackoftheframecreatingafriction

toholdthematerialinplace(fig.3‐4).



  Fig.1Fig.2

*AnalternatewaytoattachtheblackbackingtothebackoftheAcousticPro1080materialistoutilizetheVelcro

tabslocatedontheoutersurfaceofthefixplates(fig.3‐4)





Blackbacking

FixplatesecuresAcousticPro1080materialand

theblackbackingbehindit.

AcousticPro1080 Screen



Material



Cover



Blackbacking



FixPlate

Blackbackin



TensionRod(stretchesthe

AcousticPro1080material)

Fig.3

Fig.4

7

Rev.051811‐AS

www.elitescreens.com

 [email protected]

AttachtheFixPlates

1. Makesurethatthemateri alandframearebothlyingfacedownonaclean,dryandnon‐abrasive

surface.

2. Centerthematerialinsideoftheframe

Note:Thematerialwasmadesmallerthantheframeinordertobestretchedtocreateasufficientamountof

tension

.

3. StartattachingtheFixPlatesinthecenterofeachhorizontalframepiece(1),theninthecenterof

eachverticalframepiece(2).(seefig.7)

Note:Followtheseinstructionstomakesurethematerialisproperlyfixedinthecenterpositionoftheframe.

Afterattachingthefixplatesinsequence#2(verticalsides),removethefixplatesinsequence#1(horizontal

pieces)andre‐attachthemagain,andalsoremovethefixplatesfromsequence

#2,andre‐attach.

4. Followthesuggestednumbers3‐8toproperlyattachthefixplatestotheframe.



CenterSupportBar



1.InserttheSupportJoinerintoeachsideoftheCenterSupportBar.



SupportJoiner CenterSupportBar



2.InserttheCenterSupportBarintotheuppertopgrooveofthebackframe(notthefixplatesinsert)

withthebottomendneartheapproximatecenterpointoftheframeandplaceitinatanangleso

thatbothendsofthebarareinalignment

withthegroove(seefig.8).

(Fig.7)

8

Rev.051811‐AS

www.elitescreens.com

 [email protected]

3.Slidethetopendofthebarintothetopcenterpointlocationtocompletetheinstallation.Thiswill

providestabilitytotheframeandte nsiontothematerial.









Installation

1.Eliterecommends usingastudfinder (notincluded)tolocateandmarktheinstallationlocation.

2.Drillaholewiththeproperbitsizeaccordingtotheincludedwoodscrews.

3.Line‐uptheWallBracketswiththedrilledholesandscrewtheminusingaPhillipsscrewdriver.

Note:2wallbracketsareprovidedwithdiagonalsizesbelow135”,and3fordiagonalsizes135”andabove.



4.Positiontheframeontothetopwallbrackets(seefig.9)andpushdownatthecenterofthebottom

frametosecuretheinstallation.



5.Thewallbracketsprovideflexibilitybyallowingtheframetoslidetothesides.Thisfeatureallowsthe

screentobeproperlycentered.





CenterSupportBar

(Fig.8)

Wallbrackets

2pcs

(fig.9)

9

Rev.051811‐AS

www.elitescreens.com

 [email protected]



Pleasefollowtheseinstructionscarefullytoensurepropermaintenanceandsafetywithyour

Cinema235Screen.

1.Whenhangingthescreenup,pleasemakesurethatnootherobjectssuchaspowerswitches,outlets,

furniture,ladders,windows,etc.occupythespacedesignatedforyourFixed‐Framescreen.



2.Regardlessifthescreenishungonorinstalledintothewall,makesurethatthepropermounting



anchorsareusedandthattheweight is supportedappropriatelybyastrongandstructurallysound

surfacejustasanylargeandheavypictureframe should.



(Pleaseconsultahomeimprovementspecialistforthebestadviceoninstallation)



3.Framepartsaremadeofhighqualityvelour‐surfacedaluminumandshouldbehandledwithcare.

4.Whennotinuse,coveroverthescreenwithafurnituresheettoprotectitfromdirt,grime,paintor

anyotherimpurities.



5.Whencleaning,useadampsoftclothwith

warmwatertoremoveanymarksontheframeorscreen

surface.



6.Neverattempttouseanysolutions,chemicalsorabrasivecleanersonthescreensurface.



7.Inordertoavoiddamagingthescreen,avoidtouchingitdirectlywithyourfingers,toolsoranyother

sharporabrasiveobjects.



8.SparePartsshouldbeplacedoutofreachofsmallchildreninaccordancewithhouseholdsafety

guidelines.



1.Theprojectionscreenframeismadeofhigh‐qualityaluminumalloyandshouldbehandledwithcare. 



2.Useasoftclothwithwarmwatertoremoveany

spotsonthescreensurface.



3.Toavoiddamagingthescreenmaterial,neverattempttouseanysolutions,chemicalsorabrasive

cleanersonthescreenitselfandneverattempttotouchscreenwithyourfingersorsharp/abrasive

objects.





Caution

Warning

Rev.051811‐

www.elitesc



Measu



S

eens.com

rementsareinte

Cinem

dedasareferenc

info

235 D

onlyandaresu

elitescreens.com

mensi

jecttochangewi



n Tabl

thoutnotice.Not

:DataErrormay



be±1"

10



11

Rev.051811‐AS

www.elitescreens.com

 [email protected]



• Two(2)Yearpartsandlaborwarrantyfromdefectsinworkmanshipfrompurchasedateas

follows(exceptforrefurbishedunitsasspecifiedbelow).

• Three(3)YearpartsandlaborwarrantyfromdefectsinworkmanshipforGEMR(Government,

Educational,Military,&Religious)purchases ofnewproductonly.

• Refurbished

Unitscarrya90‐DAYpartsandlaborwarranty. 

• Eachpartywillberesponsibleforonewayshippingduringthewarrantyperiod.

• ARMA(ReturnMerchandiseAuthorization)numbermustbeissuedinordertoprocessa

replacementortoauthorizeareturnforwarrantyrepair.EliteScreenswill,at

itssoleoption

replaceorrepairthedefectiveunitwithareplacement*(seeexceptionsbelow)afterthe

defectiveunitorpartshavebeenreceived.Oncetheproductisreceived,EliteScreenswillsend

outareplacement*unittothecustomerbygroundservice(subjecttoinve ntoryavailability).

• DoNot

ReturnAnyUnauthorizedItemstoEliteScreens,astheywillberefusedandreturned

atyourexpense.TheRMANumbermustbeincludedontheoutsidelabelofyourshipping

box.Ourwarehouseisnotauthorizedtoacceptreturns withoutanRMAnumberonthe

shippinglabel.

• RMANumbersare

validfor45daysfromthedateissued.

• MissingPartsmustbereportedwithin7daysofreceipt.Ifreportedafter7days,thecustomer

willberesponsibleforshippingandhandlingfees.Ifreportedafter30daysofreceipt,the

customerwillberesponsibleforcostofparts

andshipping&handlingfees.



*ANeworrefurbishedreplacementwillbesendouttothecustomerdependingonthetypeof

purchase(neworrefurbished)andbasedonstockavailability.



NorthAmericaonlyU.S.andCanada



ForWarrantyandServicerequests,pleasesubmitanRMA/ServiceFormat:

www.elitescreens.com/warrantysupportform





PleasevisitthislinkforfullWarrantyinformation:

www.elitescreens.com/warranty





ForCustomerServiceandTechnicalquestions,pleasecontactEliteScreensat:

Telephone:(877)511‐1211   [email protected]



Fax:(562)926‐8433[email protected]





REMEMBERTOREGISTERYOURPRODUCTAT:

www.elitescreens.com



Warranty Policy

12

Rev.051811‐AS

www.elitescreens.com

 [email protected]

US&CanadaTechSupport&WarrantyClaim

Pleasecontactusat[email protected]

orcall+1877‐511‐1211#3orfax+1‐562‐926‐8433

EuropeTechSupport&WarrantyClaim

Pleasecontactusat[email protected]

orcall+49‐(0)40‐30392958

AsiaTechSupport&WarrantyClaim

Pleasecontactusat[email protected]

orcall+86‐(0)755‐8461‐7989

TaiwanTechSupport&WarrantyClaim 

Pleasecontactusat[email protected]

orcall+866+2+8990‐1999

America:Europe:

EliteScreensIncEliteScreensEurope

16410ManningWayLübeckerStraße1

Cerritos,CA90703USA22087Hamburg,Germany

Tel:+1‐877‐511‐1211Tel:+49‐4030392494

Fax:+1‐562‐926‐8433Fax:+49‐40‐49219200

[email protected]

[email protected]

www.elitescreens.com

www.elitescreens.eu



Asia:



EliteScreensFranceS.A.S



Elite



Screens



China



Corp.

11,AlléeWillia m Penn



Longxi



Duimianling



Industry



Zone92150Surenes,France

Longcheng



Longgang



District,Tel:+33‐1‐45064735

ShenZhen



GuangDong,



ChinaFax:+33‐1‐45064735



Tel:



+86‐(0)755‐8461‐7989[email protected]



Fax:



+86‐(0)755‐8461‐7669www.elitescreens.com/fr

[email protected]



www.elitescreens.co m.cn





Japan:

Taiwan:



EliteScreensJapanCorp.



Elite



Screens



Taiwan



Corp.

467‐2‐606Tsuru m a,Machida‐shi,



4F.,No.42‐1WuguanRd.WuguTown ship Taipei  Tokyo,194‐0004Japan 

County248,Taiwan(Wug uIndustrialPark)  Tel:0120‐07‐0008

Taiwan(R.O.C)Fax:+81(0)42‐706‐9130



Tel:



+886+2+8990‐1999[email protected]



Fax:



+886+2+8990+1366www.elitescreens.jp



[email protected].tw



www.elitscree ns.co m.tw

LatinAmericaContact:

[email protected]



EastAsiaContact:

[email protected]



IndiaContact:

[email protected]



Contact Info

Elite Screens 235 User manual

Related papers

Other documents