GE ZV850SPSS Installation guide

INSTALLATION

INSTRUCTIONS

36” Island Vent Hood

ZV850, ZV855

ENGLISH/FRANÇAIS/ESPAÑOL

MONOGRAM.COM

2 31-10725 Rev. 6

Safety Information

READ AND SAVE THESE INSTRUCTIONS

BEFORE YOU BEGIN

Read these instructions completely and carefully.

Ŷ

IMPORTANT — Save these instructions

for local inspector’s use.

Ŷ

IMPORTANT — Observe all governing

codes and ordinances.

ŶNote to Installer — Be sure to leave these

instructions with the Consumer.

ŶNote to Consumer — Keep these instructions with

your Owner’s Manual for future reference.

ŶSkill Level — Installation of this appliance requires

basic mechanical and electrical skills.

ŶCompletion Time — 1 to 3 Hours.

Ŷ3URSHULQVWDOODWLRQLVWKHUHVSRQVLELOLW\RIWKH

LQVWDOOHU3URGXFWIDLOXUHGXHWRLPSURSHULQVWDOODWLRQ

is not covered under the warranty.

Ŷ)RU0RQRJUDPORFDOVHUYLFHLQ\RXUDUHDYLVLW

monogram.com.

Ŷ)RU0RQRJUDPVHUYLFHLQ&DQDGDYLVLW

monogram.ca.

Ŷ)RU0RQRJUDP3DUWVDQG$FFHVVRULHVYLVLW

monogram.com/use-and-care/parts.

CAUTION

Due to the weight and size of these

vent hoods and to reduce the risk of personal injury

RUGDPDJHWRWKHSURGXFW TWO PEOPLE ARE

REQUIRED FOR PROPER INSTALLATION.

WARNING

To reduce the risk of fire or electrical

VKRFNGRQRWXVHWKLVUDQJHKRRGZLWKDQ\H[WHUQDO

VROLGVWDWHVSHHGFRQWUROGHYLFH$Q\VXFKDOWHUDWLRQ

from original factory wiring could result in damage to

the unit and/or create an electrical safety hazard.

TO REDUCE THE RISK OF FIRE, USE ONLY

METAL DUCTWORK.

WARNING

725('8&(7+(5,6.2)),5(

(/(&75,&$/6+2&.25,1-85<723(56216

2%6(59(7+()2//2:,1*

$8VHWKLVXQLWRQO\LQWKHPDQQHULQWHQGHGE\WKH

PDQXIDFWXUHU,I\RXKDYHDQ\TXHVWLRQVFRQWDFW

the manufacturer.

%%HIRUHVHUYLFLQJRUFOHDQLQJWKHXQLWVZLWFKWKH

power off at the service panel and lock the service

disconnecting means to prevent the power from

EHLQJVZLWFKHGRQDFFLGHQWDOO\:KHQWKHVHUYLFH

GLVFRQQHFWLQJPHDQVFDQQRWEHORFNHGVHFXUHO\

IDVWHQDSURPLQHQWZDUQLQJGHYLFHVXFKDVDWDJ

to the service panel.

CAUTION

)25*(1(5$/9(17,/$7,1*86(

21/<'212786(72(;+$867+$=$5'286

0$7(5,$/6(;3/26,9(0$7(5,$/6259$3256

WARNING

725('8&(7+(5,6.2)),5(

(/(&75,&$/6+2&.25,1-85<723(56216

2%6(59(7+()2//2:,1*

Ŷ,QVWDOODWLRQZRUNDQGHOHFWULFDOZLULQJPXVWEHGRQHE\

qualified person(s) in accordance with all applicable

FRGHVDQGVWDQGDUGVLQFOXGLQJILUHUDWHGFRQVWUXFWLRQ

Ŷ6XIILFLHQWDLULVQHHGHGIRUSURSHUFRPEXVWLRQDQG

H[KDXVWLQJRIJDVHVWKURXJKWKHIOXHFKLPQH\RIIXHO

EXUQLQJHTXLSPHQWWRSUHYHQWEDFNGUDIWLQJ)ROORZ

the heating equipment manufacturer’s guidelines

DQGVDIHW\VWDQGDUGVVXFKDVWKRVHSXEOLVKHGE\

WKH1DWLRQDO)LUH3URWHFWLRQ$VVRFLDWLRQ1)3$WKH

$PHULFDQ6RFLHW\IRU+HDWLQJ5HIULJHUDWLRQDQG$LU

&RQGLWLRQLQJ(QJLQHHUV$6+5$(DQGWKHORFDOFRGH

DXWKRULWLHV:KHQDSSOLFDEOHLQVWDOODQ\PDNHXS

(replacement) air system in accordance with local

building code requirements.

Ŷ:KHQFXWWLQJRUGULOOLQJLQWRZDOOVRUFHLOLQJVGRQRW

damage electrical wiring and other hidden utilities.

Ŷ'XFWHGV\VWHPVPXVWDOZD\VEHYHQWHGWRWKH

outdoors.

Ŷ/RFDOFRGHVYDU\,QVWDOODWLRQRIHOHFWULFDO

connections and grounding must comply with

DSSOLFDEOHFRGHV,QWKHDEVHQFHRIORFDOFRGHVWKH

YHQWVKRXOGEHLQVWDOOHGLQDFFRUGDQFHZLWK1DWLRQDO

(OHFWULFDO&RGH$16,1)3$RUODWHVWHGLWLRQ

CAUTION

To reduce risk of fire and to properly

H[KDXVWDLUEHVXUHWRGXFWDLURXWVLGH²GRQRWYHQW

H[KDXVWDLULQWRVSDFHVZLWKLQZDOOVRUFHLOLQJVRULQWR

DWWLFVFUDZOVSDFHVRUJDUDJHV

31-10725 Rev. 6 3

Design Information

PRODUCT DIMENSIONS AND CLEARANCES

The vent hood must be

installed 24” minimum

DQG´PD[LPXPDERYH

the cooking surface.

NOTE: Installation height

should be measured from

the cooking surface to the

lowest part of the hood.

ZX8510SPSS Duct Cover Accessory

This accessory is available for installation with ceiling

KHLJKWVRIƍ´WRRYHUIHHW6HHWKHWDEOHRQSDJH

The duct cover accessory must be on-site with the hood

at the time of installation.

MODELS AVAILABLE

0RGHO=90RGHO=9

7KHVHKRRGVPD\EHLQVWDOOHGWRYHQWWRWKHRXWGRRUV

RUWKH\PD\EHLQVWDOOHGIRUUHFLUFXODWLQJRSHUDWLRQ$OO

necessary parts for recirculating operation are supplied

ZLWKWKHKRRG1RNLWVUHTXLUHG

Ŷ7KHVHYHQWKRRGVFDQEHLQVWDOOHGRYHUDQ\´RU´

0RQRJUDPHOHFWULFRUJDVFRRNWRSH[FHSW0RQRJUDP

3URIHVVLRQDOFRRNWRSVRUUDQJHVODUJHUWKDQ´

Ŷ Reversible duct covers accommodate recirculating

operation.

Ŷ The telescopic duct covers conceal the ductwork

running from the top of the hood to the ceiling.

Ŷ The supplied duct cover is sized to reach ceiling heights

over 8 feet. See the table on page 8.

CONTENTS

Safety Information ....................................................... 2

Design Information

0RGHOV$YDLODEOH ........................................................... 3

3URGXFW'LPHQVLRQV ...................................................... 3

Advance Planning

'XFWZRUN3ODQQLQJ ....................................................... 4

&HLOLQJ)UDPLQJIRU$GHTXDWH6XSSRUW ......................... 4

Installation Preparation

'XFW)LWWLQJV .................................................................. 

3RZHU6XSSO\ ................................................................ 

Tools and Materials Required ....................................... 

5HPRYHWKH3DFNDJLQJ ................................................ 

Check Installation Hardware ........................................ 

Determine Installation Height ........................................ 8

Install Ceiling Support Structure .............................. ±

Installation Instructions

,QVWDOODWLRQ±9HQWHGWRWKH2XWVLGH ...................... ±

6WHS0RXQW7HPSODWH .............................................. 12

6WHS,QVWDOO8SSHU6XSSRUW)UDPH .......................... 12

6WHS,QVWDOO/RZHU6XSSRUW)UDPH .......................... 12

6WHS6HFXUH:LULQJ ................................................. 13

6WHS6L]HDQG,QVWDOO'XFWZRUN ............................... 13

6WHS,QVWDOO'HFRUDWLYH'XFW&RYHUV ....................... 14

6WHS,QVWDOO+RRG ..................................................... 

6WHS&RQQHFW(OHFWULFDO ........................................... 

6WHS6OLGH'XFW&RYHU

'RZQ,QVWDOO6LGH8WHQVLO5RGV .................................. 

6WHS,QVWDOO)LOWHUV .................................................. 

6WHS)LQDOL]H,QVWDOODWLRQ ....................................... 

Installation Instructions

,QVWDOODWLRQ±5HFLUFXODWLQJ .................................... ±

6WHS0RXQW7HPSODWH .............................................. 

6WHS,QVWDOO8SSHU6XSSRUW)UDPH .......................... 

6WHS,QVWDOO/RZHU6XSSRUW)UDPH .......................... 18

6WHS6HFXUH:LULQJ ................................................. 18

6WHS6L]HDQG,QVWDOO'XFWZRUN ............................... 18

6WHS,QVWDOO'HFRUDWLYH'XFW&RYHUV ....................... 

6WHS,QVWDOO+RRG ..................................................... 

6WHS&RQQHFW(OHFWULFDO ........................................... 

6WHS6OLGH'XFW&RYHU

'RZQ,QVWDOO6LGH8WHQVLO5RGV .................................. 

6WHS,QVWDOO)LOWHUV .................................................. 21

6WHS)LQDOL]H,QVWDOODWLRQ ....................................... 21

24” Minimum

30” Maximum

36" Minimum

*Height

to Ceiling

8-1/4"

27-1/2”

35-3/8ļ (excluding utensil rods)

36-1/2ļ (including utensil rods)

4 31-10725 Rev. 6

Advance Planning

DUCTWORK PLANNING

Ŷ7KHKRRGLVGHVLJQHGWREHYHQWHGYHUWLFDOO\

through the ceiling. Use locally supplied elbows to

vent horizontally through the rear wall.

Ŷ'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG

Ŷ3ODQWKHURXWHIRUYHQWLQJH[KDXVWWRWKHRXWGRRUV

Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH

)RUVDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOG

QRWH[FHHGƍHTXLYDOHQWOHQJWKIRUDQ\GXFW

configurations.

Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWWRFRPSXWHWKH

PD[LPXPSHUPLVVLEOHOHQJWKIRUGXFWUXQVWRWKH

outdoors.

Ŷ8VHULJLGPHWDOGXFWZRUNRQO\

Ŷ7KLVYHQWKRRGPXVWXVH´URXQGGXFW7KH´

URXQGGXFWFDQWUDQVLWLRQWR´[´RU´[

12”.

Ŷ,QVWDOOWKHKRXVHGXFWWRUXQKRUL]RQWDOO\EHWZHHQ

ceiling joists or straight up through the roof.

Ŷ,QVWDOODZDOORUURRIFDSZLWKGDPSHUDWWKHH[WHULRU

opening. Order the wall or roof cap and any

transition and length of duct needed in advance.

Ŷ:KHQDSSOLFDEOHLQVWDOODQ\PDNHXSUHSODFHPHQW

air system in accordance with local building code

requirements. Visit Monogram.com for available

makeup air solutions.

WARNING

725('8&(7+(5,6.2)),5(

86(21/<0(7$/'8&7:25.

CEILING FRAMING FOR ADEQUATE

SUPPORT

Ŷ7KHVHYHQWKRRGVDUHKHDY\$GHTXDWHVWUXFWXUDO

support must be provided. The ceiling structure

must be capable of supporting the weight of the

hood and any inadvertent user contact loads

DSSUR[LPDWHO\SRXQGV7KHKRRGVXSSRUW

IUDPHZLOOEHVXSSRUWHGE\[PLQLPXPFURVV

framing.

Ŷ,QVWDOODWLRQZLOOEHHDVLHULIWKHYHQWKRRGLVLQVWDOOHG

before the cooktop or countertop below

is installed.

Accessory Duct Cover

$GXFWFRYHUDFFHVVRU\PD\EHUHTXLUHGIRU\RXU

LQVWDOODWLRQGHSHQGLQJRQFHLOLQJKHLJKW

31-10725 Rev. 6 

DUCT FITTINGS

This Hood Must Use an

6” Round Duct. It Can

Transition to 3-1/4” x 10”

or 3-1/4” x 12” Duct.

8VHWKLVFKDUWWRFRPSXWHPD[LPXP

permissible lengths for duct runs to

outdoors.

NOTE: 'RQRWH[FHHGPD[LPXP

permissible equivalent lengths!

0D[LPXPGXFWOHQJWK

IRRWIRUUDQJHKRRGV

)OH[LEOHGXFWLQJ

,IIOH[LEOHPHWDOGXFWLQJLVXVHGDOO

the equivalent feet values in the

WDEOHVKRXOGEHGRXEOHG7KHIOH[LEOH

metal duct should be straight and

VPRRWKDQGH[WHQGHGDVPXFKDV

possible.

'2127XVHIOH[LEOHSODVWLFGXFWLQJ

NOTE: $Q\KRPHYHQWLODWLRQ

V\VWHPVXFKDVDYHQWLODWLRQKRRG

may interrupt the proper flow of

FRPEXVWLRQDLUDQGH[KDXVWUHTXLUHG

E\ILUHSODFHVJDVIXUQDFHVJDV

water heaters and other naturally

vented systems.

To minimize the chance of

interruption of such naturally

YHQWHGV\VWHPVIROORZWKHKHDWLQJ

equipment manufacturer’s guidelines

and safety standards such as those

SXEOLVKHGE\1)3$DQG$6+5$(

:KHQDSSOLFDEOHLQVWDOODQ\

makeup (replacement) air system in

accordance with local building code

requirements.

Visit Monogram.com for available

makeup air solutions.

Installation Preparation

Duct Piece Dimensions

Equivalent

Length*

Quantity

Used

Total

Equivalent

Length

5RXQGVWUDLJKW 1 ft.

(per foot length)

´[´VWUDLJKW 1 ft.

(per foot length)

HOERZ 12 ft.

HOERZ IW

´[´

»´[´

HOERZ

14 ft.

IW

´[´

´[´

HOERZ

8 ft.

IW

´[´

´[´

IODWHOERZ

33 ft.

24 ft.

´URXQGWR

rectangular

2 ft.

Rectangular to 8”

round

2 ft.

´URXQGWR´[´

WUDQVLWLRQHOERZ

4 ft.

´[´

»´[´

UHFWDQJXODUWR´URXQG

WUDQVLWLRQHOERZ

4 ft.

Round wall cap

with damper

24 ft.

´[´

»´[´

rectangular wall cap

with damper

24 ft.

18 ft.

Round roof cap 33 ft

$FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFWILWWLQJHTXLYDOHQW(TXLYDOHQW

length of duct pieces are based on actual tests conducted by

*($SSOLDQFHV(YDOXDWLRQ(QJLQHHULQJDQGUHIOHFWUHTXLUHPHQWVIRU

good venting performance with any ventilation hood.

Total Duct Run

 31-10725 Rev. 6

Installation Preparation

TOOLS AND MATERIALS REQUIRED

(NOT SUPPLIED)

POWER SUPPLY

IMPORTANT – (Please read carefully)

WARNING

)253(5621$/6$)(7<7+,6

$33/,$1&(0867%(3523(5/<*5281'('

Remove house fuse or open circuit breaker before

beginning installation.

'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJZLWK

WKLVDSSOLDQFH)ROORZ1DWLRQDOHOHFWULFDOFRGHVRU

prevailing local codes and ordinances.

Electrical supply

7KLVYHQWKRRGPXVWEHVXSSOLHGZLWK9+]

DQGFRQQHFWHGWRDQLQGLYLGXDOSURSHUO\JURXQGHG

EUDQFKFLUFXLWDQGSURWHFWHGE\DRUDPSFLUFXLW

breaker or time delay fuse.

Ŷ:LULQJPXVWEHZLUHZLWKJURXQG

Ŷ,IWKHHOHFWULFDOVXSSO\GRHVQRWPHHWWKHDERYH

UHTXLUHPHQWVFDOODOLFHQVHGHOHFWULFLDQEHIRUH

proceeding.

Ŷ5RXWHKRXVHZLULQJDVFORVHWRWKHLQVWDOODWLRQ

ORFDWLRQDVSRVVLEOHLQWKHFHLOLQJRUEDFNZDOO

5HIHUWR:LULQJ/RFDWLRQVRQSDJH

Ŷ&RQQHFWWKHKRRGZLULQJWRWKHKRXVHZLULQJLQ

accordance with local codes.

Grounding instructions

The grounding conductor must be connected to a

JURXQGHGPHWDOSHUPDQHQWZLULQJV\VWHPRUDQ

equipment-grounding terminal or lead on the hood.

WARNING

The improper connection of the

equipment-grounding conductor can result in a risk

of electric shock. Check with a qualified electrician or

service representative if you are in doubt whether the

appliance is properly grounded.

Masking

tape

*ORYHV

Utility knife

3OLHUV

:LUHFXWWHUVWULSSHU

Metal snips

Spirit level

$OXPLQL]HG

duct tape

Safety glasses

9+]RU$PS

ZLUHZLWKJURXQGSURSHUO\

grounded branch circuit

Stepladder

Saber saw or keyhole saw

3KLOOLSVVFUHZGULYHU

Strain relief for

MXQFWLRQER[

” round metal

GXFWOHQJWKWR

suit installation

Hammer

)ODVKOLJKW

UL-listed wire nuts

3HQFLODQGWDSHPHDVXUH

(OHFWULFGULOOZLWK”ELWV

3KLOOLSVDQG” socket

PPZUHQFK

3OXPE

31-10725 Rev. 6 

Installation Preparation

REMOVE THE PACKAGING

CAUTION

:HDUJORYHVWRSURWHFWDJDLQVWVKDUS

edges.

The vent hood is packed with the duct cover and

support frames.

Ŷ5HPRYHWKHKRRGSDUWVDQGSDFNDJLQJ

Ŷ5HPRYHMXQFWLRQER[FRYHU

Ŷ,QVWDOOVWUDLQUHOLHIRQWRMXQFWLRQER[FRYHU

(not supplied).

NOTE: $GGLWLRQDOWRROVPDWHULDOVDQGKDUGZDUHDUH

required to construct your ceiling support.

Check Installation Hardware

Locate the hardware accessory bag packed with the

hood and check contents.

Front of Hood

Template

+H[KHDG

wood lag

screws

PP[

´RU[

2-1/2”)

2 Stop screws

(One is in the service

manual envelope.

Leave that screw in the

envelope.)

)ODW

washers

3 Stainless

steel grease filters

Decorative

duct covers

3KLOOLSVKHDG

duct cover

screws

2 Utensil rods with 4 machine screws

PP1XWV

and lock

washers

Support

frames with 8

screws and 8

washers

)UDPH

attachment screws

with washers

(attached to

accessory support

frames)

Mounting screw holes

$GGLWLRQDO3DUWVIRU5HFLUFXODWLQJ2SHUDWLRQ

3 Charcoal filters

$LUGHIOHFWRUZLWKXSSHU

duct connector and 4

small flat-head screws

8 31-10725 Rev. 6

Installation Preparation

DETERMINE INSTALLATION HEIGHT

Ŷ7HOHVFRSLFGXFWFRYHUVDUHSURYLGHGWRFRQFHDO

the ductwork running to the ceiling.

Ŷ7KLVKRRGFDQEHLQVWDOOHGIRUYHQWHGRU

UHFLUFXODWLQJRSHUDWLRQ$OOQHFHVVDU\SDUWVDUH

shipped with the hood.

NOTE: Installation height should be measured from

the cooking surface to the lowest part of the hood.

7KHYHQWKRRGPXVWEHLQVWDOOHGPLQDQG

PD[DERYHWKHFRRNLQJVXUIDFH7KHKRRGLQVWDOODWLRQ

KHLJKWIURPWKHFRRNLQJVXUIDFHWRWKHERWWRPRIWKH

KRRGGHSHQGVXSRQFHLOLQJKHLJKWDQGGXFWFRYHU

limitations.

DUCT COVER DIMENSIONS

ZX8510SPSS Duct Cover

Accessory

The accessory is available for

LQVWDOODWLRQZLWKFHLOLQJKHLJKWVRIƍ

´WRRYHUIHHW7KLVDFFHVVRU\

FRQVLVWVRIWZR´GXFWFRYHUV

and one 31” upper support frame

piece.

ZV850/ZV855

Installation Heights

Lower Frame 20.75”

Frame 20.75”

Lower Duct 18”

Upper Duct 18”

Upper Frame 31”

Supplied Lower Frame

Lower Duct 26.25”

Upper Duct 26.25”

Actual

Ceiling

Height

*Possible

VENTED

Installation

Height

*Possible

RECIRCULATING

Installation Height

¶´ 24” 24”

SUPPLIED FRAME

SUPPLIED DUCT COVERS

¶´ ´WR´ ´WR´

8’-1” WR´ ´WR´

8’-2” ´WR´ ´WR´

8’-3” ´WR´ 24” to 28”

8’-4” ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´ ´WR´

8’-8” ´WR´

¶´ ´WR´

ZX8510SPSS - ACCESSORY UPPER FRAME

¶´ ´WR´

8’-11” ´

¶´ 24” 24”

ZX8510SPSS - ACCESSORY UPPER FRAME

8’-8” ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

8’-11” ´WR´ 24” to 28”

¶ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶ ´ ´WR´

¶´ ´WR´

¶´ ´WR´

¶´ ´WR´

´ ´

%DVHGRQ´FRXQWHUWRSKHLJKW

24” Minimum

30” Maximum

36" Minimum

”

”

31-10725 Rev. 6 

Installation Preparation

CONSTRUCT CEILING SUPPORT

Plan the Location of the Hood and Ductwork

ŶUse a plumb bob to check the location. The countertop/

cooktop below the hood must be centered with the hood.

Ŷ7KHKRRGVKRXOGH[WHQGEH\RQGWKHIURQWDQGUHDUHGJH

of the cooking appliance.

ŶThe duct in the ceiling must be centered over the

cooktop.

Ceiling Support Structure

Ŷ$WWKHKRRGORFDWLRQLQVWDOO[FURVVIUDPLQJ

EHWZHHQFHLOLQJMRLVWVDVVKRZQ[¶VDUHUHTXLUHGWR

support the weight of the hood.)

Ŷ$UUDQJHFURVVIUDPLQJLQWKHFHLOLQJWRVXLWWKHH[LVWLQJ

structure.

Ŷ<RXUFHLOLQJMRLVWVZLOOEHOLNHRQHRIWKHIROORZLQJ

H[DPSOHV

7RSYLHZ±FHLOLQJMRLVWVSDUDOOHOWRIURQWRIKRRG

´-RLVW

spacing

8-3/4”

´'XFW

)URQW

of hood

[&URVVIUDPLQJZRRG

supports

Cooktop

outline

$OLJQGXFW

to center

of cooktop

(;$03/($

Install cross-framing symmetrically over duct/

cooktop centerline

´

 31-10725 Rev. 6

Installation Preparation

CONSTRUCT CEILING SUPPORT (cont.)

7RSYLHZ±FHLOLQJMRLVWVUXQSHUSHQGLFXODUWRIURQWRIKRRG

7RSYLHZ±FHLOLQJMRLVWVDWDQJOHWRIURQWRIKRRG

´-RLVW

spacing

8-3/4”

´'XFW

)URQW

of

hood

[&URVVIUDPLQJ

wood supports

Cooktop

outline

$OLJQGXFW

to center

of cooktop

´-RLVW

spacing

´'XFW

Cooktop

outline

$OLJQGXFW

to center

of cooktop

(;$03/(%

(;$03/(&

)URQW

of

hood

´

[&URVVIUDPLQJ

wood supports

Install cross-framing symmetrically

over duct/cooktop centerline

´

8-3/4”

Install cross-framing

symmetrically over duct/

cooktop centerline

31-10725 Rev. 6 11

Installation Preparation

CONSTRUCT CEILING SUPPORT (Cont.)

Ŷ6HFXUHHDFK[EORFNZLWKDWOHDVWIRXU

ZRRGVFUHZV´ORQJQRWVXSSOLHG8VHZRRG

screws total for the two supports.

Ŷ7KHFURVVIUDPLQJPXVWEHDFFXUDWHO\DOLJQHG

to assure correct positioning of the hood.

Ŷ7KHFURVVIUDPLQJPXVWEHOHYHOLQDOOGLUHFWLRQV

Check with a spirit level and adjust if necessary.

IMPORTANT: The ceiling structure must be capable of

VXSSRUWLQJWKHZHLJKWRIWKHKRRGDSSUR[LPDWHO\

pounds) and any inadvertent user contact loads. The

hood support frame will be supported by the

[FURVVIUDPLQJ

Ductwork for Installations Vented to the

Outdoors

Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH

)RUVDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOGQRW

H[FHHGIHHWHTXLYDOHQWOHQJWKIRUDQ\GXFW

configuration.

Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWWRFRPSXWHWKHPD[LPXP

permissible length for duct runs to the outdoors.

Ŷ7KLVYHQWKRRGPXVWXVH´URXQGULJLGGXFW

WARNING

725('8&(7+(5,6.2)),5(

86(21/<0(7$/'8&7:25.

Ŷ,QVWDOOWKHKRXVHGXFWZRUNWRUXQKRUL]RQWDOO\EHWZHHQ

ceiling joists or straight up through the roof.

Finish the Ceiling

Ŷ)LQLVKWKHFHLOLQJVXUIDFH%HVXUHWRPDUNORFDWLRQRI

the ceiling joists and cross framing. Check to be sure

the ceiling is level; use shims if necessary.

´

Duct

Ceiling joist

[

Vent straight up

through the ceiling

12 31-10725 Rev. 6

Installation Instructions

INSTALLATION—VENTED TO THE OUTSIDE

3

INSTALL LOWER SUPPORT

FRAME

Ŷ,QVHUWORZHUVXSSRUWIUDPHLQWRWKHXSSHUVXSSRUW

frame and loosely secure with 8 screws and

washers (4 on the front and 4 on the back sides).

Ŷ$GMXVWWKHORZHUVXSSRUWIUDPHXSRUGRZQWR

the desired height above the countertop. Tighten

screws.

IMPORTANT:$JDLQFKHFNWREHVXUHWKHVXSSRUWLV

level in both directions. There is no way to level the

hood after the hood is secured to the frame.

1

MOUNT TEMPLATE

Ŷ$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQG

tape in place.

±%HVXUHWKHWHPSODWHLVRULHQWHGFRUUHFWO\ZLWKWKH

front of the hood.

Ŷ8VHDSOXPEWREHVXUHWKHPRXQWLQJKROHVZLOO

provide parallel alignment with the countertop

below.

Ŷ&HQWHUSXQFKDOOKROHORFDWLRQV

Ŷ'ULOOSLORWKROHVLQWKHVFUHZ

ORFDWLRQV8VHD´ELWDQGGULOO

DSSUR[LPDWHO\´GHHS

Ŷ&XWZLUHDFFHVVKROH

DSSUR[LPDWHO\´GLD

Ŷ&XWWKH´GXFWRSHQLQJ

through the ceiling.

2

INSTALL UPPER SUPPORT

FRAME

Ŷ6HFXUHWKHXSSHUVXSSRUWIUDPHWRWKHFHLOLQJ

joists and/or cross framing with the 4 screws

SURYLGHG)RUPD[LPXPULJLGLW\DQGVWUHQJWKWKH

screws must be driven into the center of the joists

and/or cross-framing.

Ŷ&KHFNWREHVXUHWKHVXSSRUWIUDPHLVOHYHO

vertically and horizontally.

Wire Access Hole

Front of Hood



”

24” Minimum

”0D[LPXP

31-10725 Rev. 6 13

Installation Instructions

INSTALLATION—VENTED TO THE OUTSIDE

5

SIZE AND INSTALL DUCTWORK

Ŷ0HDVXUHIURPKRXVHGXFW'LP$WRERWWRPRI

support frame.

±$GGDWOHDVW´IRUGXFWRYHUODSDWWKHWRS

±6XEWUDFW´IRUKRRGLQVHUWLRQLQWRWKHERWWRPRI

the frame.

Ŷ&XWWKH´GLDGXFWWRWKHUHTXLUHGOHQJWK

NOTE: The bottom end of the duct must be flared

VOLJKWO\WRIDFLOLWDWHLQVWDOODWLRQRIWKHKRRG

Ŷ,QVWDOOGXFWXSWKURXJKVXSSRUWIUDPHVRQWRWKH

KRXVHGXFW3XVKGXFWXSXQWLOLWLV´IURPWKH

bottom of the support frame flange.

Ŷ6HFXUHWKHGXFWWRKRXVHGXFWFRQQHFWLRQZLWK

screws and seal with duct tape.

Ŷ6HDOGXFWFRQQHFWLRQZLWKGXFWWDSHPDNLQJVXUH

connection is secured in place.

4

SECURE WIRING

Ŷ5RXWHKRXVHZLULQJWKURXJKWKHFHLOLQJKROHDQGSXOO

DOHQJWKWRUHDFKWKHKRRGMXQFWLRQER[

Ŷ7DSHWKHZLUHWRWKHIURQWRIWKHIUDPHVXSSRUWWR

prevent damage during installation and service.

Ceiling

Support

Frames

Tape

House

Wiring

Front Side

14 31-10725 Rev. 6

Installation Instructions

INSTALLATION—VENTED TO THE OUTSIDE

6

INSTALL DECORATIVE DUCT COVERS

Ŷ3UHWDSRUGULYHGHFRUDWLYHVFUHZLQWRWKHVFUHZKROHV

on the support frame. This will make screw installation

easier.

Ŷ6HSDUDWHWKHWZRGHFRUDWLYHGXFWFRYHUV

Ŷ6HOHFWWKHLQVLGHRUWRSFRYHUZLWKWKHYHQWKROH

pattern on one end.

For this vented installation to the outside, the hole

pattern should be located at the bottom.

Ŷ/RFDWHWKHVXSSOLHGGXFWFRYHUVFUHZV

Ŷ6OLGHWKHGHFRUDWLYHGXFWFRYHURYHUWKHVXSSRUWIUDPH

and push to the ceiling.

Ŷ$WWDFKWKHLQVLGHGXFWFRYHUWRWKHKRRGVXSSRUWDWWKH

top with 2 supplied duct cover screws.

Ŷ/RFDWHWKHVWRSVFUHZLQWKHKDUGZDUHEDJ

Ŷ,QVWDOOWKHVWRSVFUHZLQWRRQHRIWKHWZRKROHVDQG

tighten against the frame to allow the second duct

cover to slide up and pass over.

Ŷ6OLGHWKHORZHUGXFWFRYHURYHUWKHLQVWDOOHGXSSHU

duct cover and push up past the stop screw location.

Ŷ%DFNRXWWKHVWRSVFUHZIDUHQRXJKWRVXSSRUWWKH

bottom duct cover and prevent it from sliding down

onto the top of the hood.

CAUTION

The stop screw must be installed.

)DLOXUHWRGRVRFRXOGUHVXOWLQSHUVRQDOLQMXU\RUGDPDJH

to the duct cover.

31-10725 Rev. 6 

7

INSTALL HOOD

NOTE: TWO PEOPLE ARE REQUIRED TO

COMPLETE THIS INSTALLATION!

Ŷ/LIWWKHKRRGXSWRWKHVXSSRUWIUDPH&DUHIXOO\DOLJQ

WKHKRRGPRXQWLQJVWXGVLQWRWKHVXSSRUWIUDPHKROHV

DQGDWWKHVDPHWLPHJXLGHWKHKRRGGXFWFRQQHFWRU

into the duct.

Ŷ,QVWDOOQXWVDQGORFNZDVKHUV7LJKWHQZLWKDPP

wrench.

Ŷ&KHFNKRRGOHYHOLQERWKGLUHFWLRQV

Ŷ6HDOWKHGXFWFRQQHFWLRQZLWKGXFWWDSH

NOTE: Do not drive screws through this duct

connection. Doing so will prevent proper damper

operation.

Installation Instructions

INSTALLATION—VENTED TO THE OUTSIDE

8

CONNECT ELECTRICAL

Verify that power is turned off at the source.

WARNING

If house wiring is not 2-wire with

DJURXQGZLUHDJURXQGPXVWEHSURYLGHGE\WKH

LQVWDOOHU:KHQKRXVHZLULQJLVDOXPLQXPEHVXUH

WRXVH8/DSSURYHGDQWLR[LGDQWFRPSRXQGDQG

aluminum-to-copper connectors.

Ŷ,QVWDOOVWUDLQUHOLHIRQWRWKHNQRFNRXWRIWKHMXQFWLRQ

ER[FRYHU

Ŷ,QVHUWKRXVHZLULQJWKURXJKVWUDLQUHOLHIDQGWLJKWHQ

Ŷ&RQQHFWZKLWHOHDGVWREUDQFKFLUFXLWZKLWHOHDG

Ŷ&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG

Ŷ&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQ

or bare ground lead.

Ŷ6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFK

electrical connector.

Ŷ3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU%H

sure wires are not pinched.

9

SLIDE DUCT COVER DOWN,

INSTALL SIDE UTENSIL RODS

Ŷ

Slide the lower duct cover up and above the stop screw.

Ŷ'ULYHWKHVWRSVFUHZLQFORVHWRWKHIUDPH

Ŷ6OLGHWKHORZHUGXFWFRYHUGRZQDJDLQVWWKHWRSRI

the hood. The duct cover should be seated into the

pocket on top of the hood.

Ŷ,QVWDOOWKHVLGHXWHQVLOURGVZLWKVFUHZVDVVKRZQ

 31-10725 Rev. 6

Installation Instructions

INSTALLATION—VENTED TO THE OUTSIDE

10

INSTALL FILTERS

Ŷ5HPRYHSURWHFWLYHILOPVRQWKHJUHDVHILOWHUVDQGILOWHU

cover panel.

Ŷ7LSWKHILOWHULQWRWKHORZHUFKDQQHODWWKHUHDURIWKH

RSHQLQJ3XVKEDFNOLIWDQGSXOOWKHNQREIRUZDUGXQWLO

the filter rests on the channel.

Ŷ,QVWDOODOOWKUHHPHWDOJUHDVHILOWHUV

Ŷ7XUQSRZHURQ,IWKHILOWHUOLJKWRQWKHFRQWUROSDQHO

JORZVDGMXVWWKHULJKWVLGHILOWHULQWKHFKDQQHOWR

engage the switch arm.

9

FINALIZE INSTALLATION

Ŷ5HPRYHWKHSURWHFWLYHILOPFRYHULQJWKHFRQWUROSDQHO

on the front face of the hood and any other packaging

materials.

Ŷ0DNHVXUHWKHILOWHUVDUHVHDWHGSURSHUO\ZKHQ

installed and the filter light is not on.

Ŷ%HVXUHIDQDQGOLJKWVRSHUDWHFRUUHFWO\5HIHUWRWKH

Owner’s Manual for operating instructions and the

3UREOHP6ROYHU

Lower Filter

Channels

Lower

filter channel

31-10725 Rev. 6 

Installation Instructions

INSTALLATION—RECIRCULATING

1

MOUNT TEMPLATE

Ŷ$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQG

tape in place.

±%HVXUHWKHWHPSODWHLVRULHQWHGFRUUHFWO\ZLWKWKH

front of the hood.

Ŷ8VHDSOXPEWREHVXUHWKHPRXQWLQJKROHVZLOO

provide parallel alignment with the countertop

below.

Ŷ&HQWHUSXQFKDOOKROHORFDWLRQV

Ŷ'ULOOSLORWKROHVLQWKHVFUHZ

ORFDWLRQV8VHD´ELWDQGGULOO

DSSUR[LPDWHO\´GHHS

Ŷ&XWZLUHDFFHVVKROH

DSSUR[LPDWHO\´GLD

2

INSTALL AIR DEFLECTOR AND

UPPER SUPPORT FRAME

The duct connector is shipped

inside the deflector.

Ŷ6QDSWKHSODVWLFFRQQHFWRURXWRI

the deflector and remove. Turn it

RYHU)URPWKHERWWRPVQDSWKH

connector over the opening.

Ŷ6OLGHWKHDVVHPEOHGGHIOHFWRU

into the upper support frame and

secure with 4 small screws.

Ŷ6HFXUHWKHXSSHUVXSSRUWIUDPHWRWKHFHLOLQJMRLVWV

and/or cross framing with the 4 screws provided.

)RUPD[LPXPULJLGLW\DQGVWUHQJWKWKHVFUHZVPXVW

be driven into the center of the joists and/or cross

framing.

Ŷ&KHFNWREHVXUHWKHVXSSRUWIUDPHLVOHYHO

vertically and horizontally.

Wire Access Hole

Front of Hood

127(%HVXUH

plastic connector

is installed on

the bottom of the

deflector as shown.

18 31-10725 Rev. 6

Installation Instructions

INSTALLATION—RECIRCULATING

4

SECURE WIRING

Ŷ5RXWHKRXVHZLULQJWKURXJKWKHFHLOLQJKROHDQGSXOO

DOHQJWKWRUHDFKWKHKRRGMXQFWLRQER[

Ŷ7DSHWKHZLUHWRWKHIURQWRIWKHIUDPHVXSSRUWWR

prevent damage during installation and service.

5

SIZE AND INSTALL DUCTWORK

Ŷ0HDVXUHIURPWRSGXFWFRQQHFWRU'LP$WRERWWRP

of support frame.

±6XEWUDFW´IRUKRRGLQVHUWLRQLQWRWKHERWWRPRI

the frame.

Ŷ&XWWKH´GLDGXFWWRWKHUHTXLUHGOHQJWK

NOTE: The bottom end of the duct must be flared

VOLJKWO\WRIDFLOLWDWHLQVWDOODWLRQRIWKHKRRG

Ŷ,QVWDOOGXFWXSWKURXJKVXSSRUWIUDPHVRQWRWKH

GXFWFRQQHFWRU3XVKGXFWXSXQWLOLWLV´IURPWKH

bottom of the support frame flange. See illustration.

Ŷ6HDOGXFWFRQQHFWLRQZLWKGXFWWDSHPDNLQJVXUH

the connection is secured in place.

3

INSTALL LOWER SUPPORT FRAME

Ŷ,QVHUWORZHUVXSSRUWIUDPHLQWRWKHXSSHUVXSSRUW

frame and loosely secure with 8 screws and washers

(4 on the front and 4 on the back sides).

Ŷ$GMXVWWKHORZHUVXSSRUWIUDPHXSRUGRZQWRWKH

desired height above the countertop. Tighten screws.

IMPORTANT:$JDLQFKHFNWREHVXUHWKHVXSSRUWLV

level in both directions. There is no way to level the

hood after the hood is secured to the frame.



”

Ceiling

Support

Frames

Tape

House

Wiring

Front Side

31-10725 Rev. 6 

Installation Instructions

INSTALLATION—RECIRCULATING

6

INSTALL DECORATIVE DUCT COVERS

Ŷ3UHWDSRUGULYHGHFRUDWLYHVFUHZLQWRWKHVFUHZKROHV

on the support frame. This will make screw installation

easier.

Ŷ6HSDUDWHWKHWZRGHFRUDWLYHGXFWFRYHUV

Ŷ6HOHFWWKHLQVLGHRUWRSFRYHUZLWKWKHYHQWKROH

pattern on one end.

For this recirculating installation, the hole pattern

should be located at the top.

Ŷ/RFDWHWKHVXSSOLHGGXFWFRYHUVFUHZV

Ŷ6OLGHWKHGHFRUDWLYHGXFWFRYHURYHUWKHVXSSRUWIUDPH

and push to the ceiling.

Ŷ$WWDFKWKHLQVLGHGXFWFRYHUWRWKHKRRGVXSSRUWDWWKH

top with 2 supplied duct cover screws.

Ŷ/RFDWHWKHVWRSVFUHZLQWKHKDUGZDUHEDJ

Ŷ,QVWDOOWKHVWRSVFUHZLQWRRQHRIWKHWZRKROHVDQG

tighten against the frame to allow the second duct

cover to slide up and pass over.

Ŷ6OLGHWKHORZHUGXFWFRYHURYHUWKHLQVWDOOHGXSSHU

duct cover and push up past the stop screw location.

Ŷ%DFNRXWWKHVWRSVFUHZIDUHQRXJKWRVXSSRUWWKH

bottom duct cover and prevent it from sliding down

onto the top of the hood.

CAUTION

The stop screw must be installed.

)DLOXUHWRGRVRFRXOGUHVXOWLQSHUVRQDOLQMXU\RUGDPDJH

to the duct cover.

 31-10725 Rev. 6

Installation Instructions

INSTALLATION—RECIRCULATING

7

INSTALL HOOD

NOTE: Before installing the hood, the metal damper

flaps on top of the hood exhaust outlet may be

removed. Do not remove the duct transition.

The damper is not required for this recirculating

operation.

NOTE: TWO PEOPLE ARE REQUIRED TO

COMPLETE THIS INSTALLATION!

Ŷ/LIWWKHKRRGXSWRWKHVXSSRUWIUDPH&DUHIXOO\DOLJQ

WKHKRRGPRXQWLQJVWXGVLQWRWKHVXSSRUWIUDPHKROHV

DQGDWWKHVDPHWLPHJXLGHWKHKRRGGXFWFRQQHFWRU

into the duct.

Ŷ,QVWDOOQXWVDQGORFNZDVKHUV7LJKWHQZLWKDPP

wrench.

Ŷ&KHFNKRRGOHYHOLQERWKGLUHFWLRQV

Ŷ6HDOWKHGXFWFRQQHFWLRQZLWKGXFWWDSH

NOTE: Do not drive screws through this duct

connection. Doing so will prevent proper damper

operation (if present).

8

CONNECT ELECTRICAL

Verify that power is turned off at the source.

WARNING

If house wiring is not 2-wire with

DJURXQGZLUHDJURXQGPXVWEHSURYLGHGE\WKH

LQVWDOOHU:KHQKRXVHZLULQJLVDOXPLQXPEHVXUH

WRXVH8/DSSURYHGDQWLR[LGDQWFRPSRXQGDQG

aluminum-to-copper connectors.

Ŷ,QVWDOOVWUDLQUHOLHIRQWRWKHNQRFNRXWRIWKHMXQFWLRQ

ER[FRYHU

Ŷ,QVHUWKRXVHZLULQJWKURXJKVWUDLQUHOLHIDQGWLJKWHQ

Ŷ&RQQHFWZKLWHOHDGVWREUDQFKFLUFXLWZKLWHOHDG

Ŷ&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG

Ŷ&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQ

or bare ground lead.

Ŷ6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFK

electrical connector.

Ŷ3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU%H

sure wires are not pinched.

9

SLIDE DUCT COVER DOWN,

INSTALL SIDE UTENSIL RODS

Ŷ

Slide the lower duct cover up and above the stop screw.

Ŷ'ULYHWKHVWRSVFUHZLQFORVHWRWKHIUDPH

Ŷ6OLGHWKHORZHUGXFWFRYHUGRZQDJDLQVWWKHWRSRI

the hood. The duct cover should be seated into the

pocket on top of the hood.

Ŷ,QVWDOOWKHVLGHXWHQVLOURGVZLWKVFUHZVDVVKRZQ

Page is loading ...

GE ZV850SPSS Installation guide

This manual is also suitable for

GE ZV850SPSS Installation guide

in other languages

Related papers

Other documents