Monogram ZV1050SFSS Installation guide

Installation

Instructions

monogram.com

42" Island

Vent Hood

ZV1050

Safety Information

WARNING:

TO REDUCE THE RISK OF FIRE, ELECTRICAL SHOCK OR

INJURY TO PERSONS, OBSERVE THE FOLLOWING:

A. Use this unit only in the manner intended by the

manufacturer. If you have any questions, contact the

manufacturer.

B.%HIRUHVHUYLFLQJRUFOHDQLQJXQLWVZLWFKSRZHURȺDW

the service panel and lock service panel to prevent

power from being switched on accidentally. If the

service panel cannot be locked, fasten a tag or

prominent warning label to the panel.

AVERTISSEMENT :

POUR RÉDUIRE LE RISQUE D’INCENDIE, DE CHOC

ÉLECTRIQUE OU DE BLESSURES, IL FAUT OBSERVER LES

REGLES SUIVANTES :

A. Utiliser cet appareil uniquement de la maniére

prévue par le fabricant. En cas de question, consulter

le fabricant.

B. Avant toute intervention ou nettoyage, couper

l’alimentation électrique au disjoncteur et verrouiller

le panneau du disjoncteur pour éviter la mise

sous tension accidentelle. S’il n’est pas possible de

verrouiller le panneau du disconcteur, attacher un

placard ou une étiquette trés visible au panneau.

)RUJHQHUDOYHQWLODWLQJXVHRQO\'RQRWXVHWRH[KDXVW

KD]DUGRXVRUH[SORVLYHPDWHULDOVRUYDSRUV

6WUXFWXUDOIUDPLQJLQVWDOODWLRQZRUNDQGHOHFWULFDO

ZLULQJPXVWEHGRQHE\TXDOL¿HGSHUVRQVLQ

accordance with all applicable codes and standards

LQFOXGLQJ¿UHUDWHGFRQVWUXFWLRQ



6XȻFLHQWDLULVQHHGHGIRUSURSHUFRPEXVWLRQDQG

H[KDXVWLQJRIJDVHVWKURXJKWKHÀXHFKLPQH\RIIXHO

EXUQLQJHTXLSPHQWWRSUHYHQWEDFNGUDIWLQJ)ROORZ

the heating equipment manufacturer’s guideline

and safety standards such as those published by the

1DWLRQDO)LUH3URWHFWLRQ$VVRFLDWLRQ1)3$WKH$PHULFDQ

Society for Heating, Refrigeration and Air Conditioning

(QJLQHHUV$6+5$(DQGWKHORFDOFRGHDXWKRULWLHVWhen

DSSOLFDEOHLQVWDOODQ\PDNHXSUHSODFHPHQWDLUV\VWHP

in accordance with local building code requirements. Visit

GEAppliances.com for available makeup air solutions.

/RFDOFRGHVYDU\,QVWDOODWLRQHOHFWULFDOFRQQHFWLRQVDQG

grounding must comply with applicable codes. In the

absence of local codes, the vent should be installed in

DFFRUGDQFHZLWK1DWLRQDO(OHFWULFDO&RGH$16,1)3$

RUODWHVWHGLWLRQ

CAUTION: 7RUHGXFHULVNRI¿UHDQGWR

SURSHUO\H[KDXVWDLUEHVXUHWRGXFWDLURXWVLGH³GRQRW

YHQWH[KDXVWDLULQWRVSDFHVZLWKLQZDOOVRUFHLOLQJVRULQWR

attics, crawl spaces or garages.

PRUDENCE : Il faut prendre soin

G·LQVWDOOHUXQFRQGXLWYHUVO·H[WpULHXUSRXUUpGXLUHOHULVTXH

d’incendie et pouvoir évacuer l’air correctement. Il ne faut

pas évacuer l’air correctement. Il ne faut pas évacuer l’air

dans l’espace entre les parois d’un mur, un plafond

ou un grenier, un espace sanitaire ou un garage.

BEFORE YOU BEGIN

Read these instructions completely and carefully.

,03257$17 – Save these instructions for local

inspector’s use.

,03257$17 – Observe all governing codes and

ordinances.

 1RWHWR,QVWDOOHU – Be sure to leave these instructions

with the Consumer.

 1RWHWR&RQVXPHU² Keep these instructions for

future reference.

 6NLOO/HYHO – Installation of this vent hood requires basic

mechanical and electrical skills.

 &RPSOHWLRQWLPH –WRKRXUV

 3URSHULQVWDOODWLRQLVWKHUHVSRQVLELOLW\RIWKHLQVWDOOHU

 3URGXFWIDLOXUHGXHWRLPSURSHULQVWDOODWLRQLVQRW

covered under the Warranty.

CAUTION:

'XHWRWKHZHLJKWDQGVL]HRIWKLVYHQWKRRGDQGWRUHGXFH

the risk of personal injury or damage to the product, we

recommend at least three people install

this hood.

PRUDENCE :

À cause du poids et de la taille de la hotte et pour

réduire les risques de blessures ou de dommages de

l’équipement, nous recommandons que trois personnes

installent cette hotte.

WARNING:

7RUHGXFHWKHULVNRI¿UHRUHOHFWULFDOVKRFNGRQRWXVH

WKLVUDQJHKRRGZLWKDQ\H[WHUQDOVROLGVWDWHVSHHG

control device. Any such alteration from original factory

wiring could result in damage to the unit and/or create an

electrical safety hazard.

AVERTISSEMENT :

3RXUUpGXLUHOHULVTXHG·LQFHQGLHRXGHFKRFpOHFWULTXH

il ne faut pas utiliser cette hotte avec un régulateur

GHYLWHVVHpOHFWURQLTXHH[WHUQH7RXWHPRGL¿FDWLRQGH

ce type du branchement d’usine peute endommager

l’appareil ou créer un risque de choc électrique.

TO REDUCE THE RISK OF FIRE, USE ONLY METAL

DUCTWORK.

Design Information

PRODUCT DIMENSIONS

7KLVYHQWKRRGLVGHVLJQHGWREHXVHGLQYHQWHGFHLOLQJ

mounted installations. It can be installed over any Mono

JUDPFRRNWRSRUUDQJHLQFOXGLQJ3URIHVVLRQDOPRGHOV

CONTENTS

Design Information

3URGXFW'LPHQVLRQV .............................................................................. 

'XFW&RYHU$FFHVVRULHV .................................................................. 

'HWHUPLQH,QVWDOODWLRQ+HLJKW .........................................................

$GYDQFH3ODQQLQJ

Tools and Materials Required ...........................................................5

3RZHU6XSSO\ ............................................................................................5

'XFW)LWWLQJV ..............................................................................................6

Installation Instructions

6WHS&RQVWUXFW&HLOLQJ6XSSRUW .............................................. ²

6WHS5HPRYH3DFNDJLQJ.............................................................. 

6WHS&KHFN,QVWDOODWLRQ+DUGZDUH .......................................... 

6WHS0RXQW7HPSODWH.................................................................... 

6WHS,QVWDOO6XSSRUW)UDPH ........................................................ 

Step 6, Secure Wiring ......................................................................... 

6WHS6L]HDQG,QVWDOO'XFWZRUN ................................................. 

6WHS,QVWDOO'HFRUDWLYH'XFW&RYHUV ...................................... 

6WHS,QVWDOO+RRG ............................................................................. 

6WHS&RQQHFW(OHFWULFDO ............................................................. 

6WHS6OLGH'XFW&RYHU'RZQ ................................................... 

6WHS,QVWDOO)LOWHUV)LQDOL]H,QVWDOODWLRQ .............................. 

10"

*Height

to Ceiling

42"

31-1/2"

WRDQIWFHLOLQJXVLQJVXSSOLHGGXFWFRYHU

32" for 9-ft. ceiling using ZX1059SFSS Accessory

44" for 10-ft. ceiling using ZX10510SFSS Accessory

This vent hood is supplied with a decorative duct cover

WRUHDFKIWFHLOLQJKHLJKWRUEHWZHHQDQG

DUCT COVER ACCESSORIES

$'XFW&RYHU$FFHVVRU\PD\EHUHTXLUHGIRU\RXUKRRG

LQVWDOODWLRQKHLJKW2UGHUDFFHVVRU\GXFWFRYHUVIRUIW

DQGIWFHLOLQJV

ZX1059SFSS –)RUIWFHLOLQJKHLJKW

This kit includes a decorative duct cover and support

IUDPHWRUHDFKDIWFHLOLQJKHLJKW

ZX10510SFSS –)RUIWFHLOLQJKHLJKW

This kit includes a decorative duct cover and support

IUDPHWRUHDFKDIWFHLOLQJKHLJKW

=9'XFW&RYHU'LPHQVLRQV

A B

ZV1050 11-1/2" 12"

ZX1059 19" 20"

ZX10510 25" 26"

Design Information

DUCT COVER ACCESSORIES

Order the accessory at the same time as the vent hood

DQGKDYHRQVLWHEHIRUHLQVWDOODWLRQEHJLQV

8VHWKLVFKDUWWRDFFXUDWHO\GHWHUPLQHWKHQHHGIRUD'XFW

Cover Accessory.

Installation Heights

Actual *Possible Hood

&HLOLQJ+HLJKW ,QVWDOODWLRQ+HLJKW 'XFW&RYHU

7'11" 29" Supplied

8'0" 30" Supplied

8'1" 30" Supplied

8'2" 25-1/2" to 30" ZX1059SFSS

8'3" 25-1/2" to 30" ZX1059SFSS

8'4" 25-1/2" to 30" ZX1059SFSS

8'5" 25-1/2" to 30" ZX1059SFSS

8'6" 25-1/2" to 30" ZX1059SFSS

8'7" 25-1/2" to 30" ZX1059SFSS

8'8" 25-1/2" to 30" ZX1059SFSS

8'9" 25-1/2" to 30" ZX1059SFSS

8'10" 25-1/2" to 30" ZX1059SFSS

8'11" 25-1/2" to 30" ZX1059SFSS

9'0" 25-1/2" to 30" ZX1059SFSS

9'1" 25-1/2" to 30" ZX10510SFSS

9'2" 25-1/2" to 30" ZX10510SFSS

9'3" 25-1/2" to 30" ZX10510SFSS

9'4" 25-1/2" to 30" ZX10510SFSS

9'5" 25-1/2" to 30" ZX10510SFSS

9'6" 25-1/2" to 30" ZX10510SFSS

9'7" 25-1/2" to 30" ZX10510SFSS

9'8" 25-1/2" to 30" ZX10510SFSS

9'9" 25-1/2" to 30" ZX10510SFSS

9'10" 25-1/2" to 30" ZX10510SFSS

9'11" 25-1/2" to 30" ZX10510SFSS

10'0" 25-1/2" to 30" ZX10510SFSS

DETERMINE INSTALLATION HEIGHT

*30"

Recommended

36" Min.

*9-ft. to 10-ft. ceilings may be 25-1/2" to 30" clearance.

7KHGLVWDQFHEHWZHHQWKHFRRNLQJVXUIDFHDQGWKHERWWRP

of the hood must be at least 25-1/2". The 30" recommended

LQVWDOODWLRQKHLJKWDERYHWKHVWDQGDUGµFRXQWHUWRSZLOO

HQVXUHGXFWFRYHU¿WWRWKHFHLOLQJ)RUIWDQGIWFHLO-

LQJKHLJKWVWKHKRRGPD\EHORZHUHGWRRYHUWKH

FRRNLQJVXUIDFH

:KHQLQVWDOOLQJWKH,VODQG+RRGDERYHD0RQRJUDP3URIHV-

sional Range or Rangetop, installation clearance must be

at least 30".

,03257$17&OHDUDQFHVPD\YDU\GXHWRW\SHRIFRRNLQJ

SURGXFWDQGORFDOFRGHV&KHFNZLWKORFDOLQVSHFWRUVWREH

sure standard is applicable.

DUCT COVER DIMENSIONS

$GYDQFH3ODQQLQJ

TOOLS AND MATERIALS REQUIRED

(not supplied)

7DSHPHDVXUH

.QLIH

6SLULWOHYHO

:LUHFXWWHU

:LUHVWULSSHU

:LUHQXWV

(OHFWULFGULOODQGELW

3KLOOLSVVFUHZGULYHU

)ODWEODGHVFUHZGULYHU

+DPPHU

3OLHUV

6DIHW\JODVVHV

7DSHWRPRXQWWHPSODWH

*ORYHVWRSURWHFWDJDLQVWVKDUSHGJHV

9+]RU$PSZLUHZLWKJURXQGSURSHUO\

grounded branch circuit

6WUDLQUHOLHIIRUMXQFWLRQFRYHU

3OXPEERE

&HQWHUSXQFK

POWER SUPPLY

IMPORTANT – Please read carefully.

WARNING: FOR PERSONAL SAFETY, THIS

APPLIANCE MUST BE PROPERLY GROUNDED.

AVERTISSEMENT :

POUR DES RAISONS DE SÉCURITÉ, CET APPAREIL DOIT

ÊTRE CORRECTEMENT MIS À LA TERRE.

Remove house fuse or open circuit breaker before

beginning installation.

'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJZLWKWKLV

DSSOLDQFH)ROORZ1DWLRQDO(OHFWULFDO&RGHRUSUHYDLOLQJ

local codes and ordinances.

Electrical supply

7KLVYHQWKRRGPXVWEHVXSSOLHGZLWK9+]

connected to an individual, properly grounded branch

FLUFXLWDQGSURWHFWHGE\DRUDPSFLUFXLWEUHDNHU

RUWLPHGHOD\IXVH

:LULQJPXVWEHZLUHZLWKJURXQG

,IWKHHOHFWULFDOVXSSO\GRHVQRWPHHWWKHDERYH

requirements, call a licensed electrician before

proceeding.

5RXWHKRXVHZLULQJLQWKHFHLOLQJDVFORVHWRWKH

installation location as possible. Allow an additional

IHHWOHQJWKIURPFHLOLQJMRLVWVWRUHDFKWKHMXQFWLRQ

ER[RQWKHKRRG

&RQQHFWWKHZLULQJWRWKHKRXVHZLULQJLQDFFRUGDQFH

with local codes.

Grounding instructions

The grounding conductor must be connected to

a ground metal, permanent wiring system, or an

equipPHQWJURXQGLQJWHUPLQDORUOHDGRQWKHKRRG

WARNING: The improper connection

RIHTXLSPHQWJURXQGLQJFRQGXFWRUFDQUHVXOWLQDULVN

RIHOHFWULFVKRFN&KHFNZLWKDTXDOL¿HGHOHFWULFLDQRU

service representative if you are in doubt whether the

appliance is properly grounded.

AVERTISSEMENT :

/HPDXYDLVEUDQFKHPHQWGX¿OGHPLVHjODWHUUHSHXW

causer un choc électrique. En cas de doute, consulter

XQpOHFWULFLHQTXDOL¿pRXXQWHFKQLFLHQSRXUGpWHUPLQHU

VLO·DSSDUHLOHVWjODWHUUH

$GYDQFH3ODQQLQJ

DUCT FITTINGS

Total

   (TXLYDOHQW 4XDQWLW\ (TXLYDOHQW

Duct Piece Dimensions Length* Used Length

  5RXQG IW

  VWUDLJKW SHUIRRW

   OHQJWK

   IW

  [ SHUIRRW

  VWUDLJKW OHQJWK

  HOERZ IW

  HOERZ IW

  [

  HOERZ IW

  [

  HOERZ IW

  [

  ÀDWHOERZ IW

  URXQGWR

  [WUDQVLWLRQ IW

  [

  WRURXQGWUDQVLWLRQ IW

  URXQG

  WR[

  WUDQVLWLRQHOERZ IW

  [WR

  URXQGWUDQVLWLRQHOERZ IW

Round

wall cap

  ZLWKGDPSHU IW

  [ZDOOFDS

with damper 75 ft.

Round

  URRIFDS IW

8VHWKLVFKDUWWRFRPSXWHPD[LPXP

permissible lengths for duct runs to

outdoors.

NOTE: 'RQRWH[FHHGPD[LPXPSHUPLV

sible equivalent lengths!

Maximum duct length: 100 ft. for

range hoods.

Flexible ducting:

,IÀH[LEOHPHWDOGXFWLQJLVXVHGDOO

the equivalent feet values in the table

VKRXOGEHGRXEOHG7KHÀH[LEOHPHWDO

duct should be straight and smooth and

H[WHQGHGDVPXFKDVSRVVLEOH

'RNOTXVHÀH[LEOHSODVWLFGXFWLQJ

7RWDO'XFW5XQ

NOTE: Any home ventilation system, such

as a ventilation hood, may interrupt the

SURSHUÀRZRIFRPEXVWLRQDLUDQGH[KDXVW

UHTXLUHGE\¿UHSODFHVJDVIXUQDFHV

gas water heaters and other naturally

vented systems. To minimize the chance

of interruption of such naturally vented

systems, follow the heating equipment

manufacturer’s guidelines and safety

standards such as those published by

1)3$DQG$6+5$(When applicable, install

DQ\PDNHXSUHSODFHPHQWDLUV\VWHP

in accordance with local building code

requirements. Visit GEAppliances.com

for available makeup air solutions.

$FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFW¿WWLQJHTXLYDOHQW(TXLYDOHQW

length of duct pieces are based on actual tests conducted by GE

(YDOXDWLRQ(QJLQHHULQJDQGUHÀHFWUHTXLUHPHQWVIRUJRRGYHQWLQJ

performance with any ventilation hood.

This Hood Must

Use 8" Round Duct.

It Can Transition to

3-1/4" x 12" Duct.

Installation Instructions

STEP 1 CONSTRUCT CEILING SUPPORT

Plan the location

'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG

8VHDSOXPEEREWRFKHFNORFDWLRQWREHVXUHFRXQWHUWRSFRRN

WRSORFDWLRQEHORZWKHKRRGZLOODOLJQH[DFWO\

7KHKRRGVKRXOGSURMHFWIRUZDUGEH\RQGWKHIURQWHGJHRI

the cooking appliance. See illustration.

2EVHUYHWKHUHFRPPHQGHGVSDFHEHWZHHQWKHFRRNLQJ

surface and bottom of hood.

Ceiling

Hood

Ducting

Centerline

Side View

Approx. 1-1/2"

Beyond Cooking

Surface

Cooktop

Countertop

31-1/2"

Hood

Front

15-3/4"

Ceiling support structure

$WWKHKRRGORFDWLRQLQVWDOO[FURVVIUDPLQJ

EHWZHHQFHLOLQJMRLVWVDVVKRZQ[VDUHUHTXLUHGWR

VXSSRUWWKHZHLJKWRIWKHKRRG

$UUDQJHFURVVIUDPLQJLQWKHFHLOLQJWRVXLWWKHH[LVW

ing structure.

<RXUFHLOLQJMRLVWVZLOOEHOLNHRQHRIWKHIROORZLQJ

H[DPSOHV

,QVWDOO&URVV)UDPLQJ

Symmetrically About

'XFW&RRNWRS&HQWHUOLQH



-RLVW

Spacing

[&URVV

)UDPLQJ

8" Duct

$OLJQ'XFWWR&HQ

ter of Cooktop

Cooktop

Outline

7RS9LHZ³&HLOLQJ-RLVWV3DUDOOHOWR)URQWRI+RRG

Front

of Hood

EXAMPLE A

Installation Instructions

STEP 1 CONSTRUCT CEILING SUPPORT (cont.)

$OLJQ'XFWWR

Center of Cooktop

Cooktop

Outline

7RS9LHZ³&HLOLQJ-RLVWV5XQ3HUSHQGLFXODUWR)URQWRI+RRG

Front

of Hood

EXAMPLE B

,QVWDOO&URVV)UDPLQJ

Symmetrically About

'XFW&RRNWRS&HQWHUOLQH

-RLVW

Spacing

[&URVV

)UDPLQJ



8" Duct

EXAMPLE C



[&URVV

)UDPLQJ

,QVWDOO

&URVV)UDPLQJ

Symmetrically About

'XFW&RRNWRS&HQWHUOLQH

8" Duct

-RLVW

Spacing

$OLJQ'XFWWR

Center of Cooktop

Cooktop

Outline

7RS9LHZ³&HLOLQJ-RLVWVDW$QJOHZLWK)URQWRI+RRG

Front

of Hood

Installation Instructions

STEP 1 CONTINUED

$UUDQJHFURVVIUDPLQJLQWKHFHLOLQJWRVXLWWKHH[LVWLQJ

VWUXFWXUH6HHH[DPSOHV

 ²6HFXUHHDFK[EORFNZLWKDWOHDVWIRXUZRRG

VFUHZVORQJQRWVXSSOLHG8VHZRRGVFUHZVWRWDO

for the two supports.

 The cross-framing must be accurately aligned to

ensure correct positioning of the hood.

 7KHFURVVIUDPLQJPXVWEHOHYHOLQDOOGLUHFWLRQV

Check with a spirit level and adjust if necessary.

IMPORTANT: The ceiling structure must be capable of sup-

porting the weight of the hood (approximately 300 pounds)

DQGDQ\LQDGYHUWHQWXVHUFRQWDFWORDGV7KHKRRGVXSSRUW

frame will be supported by the 2 x 4 min. cross-framing.

'XFWZRUN

8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH)RU

VDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOGQRWH[FHHG

IHHWHTXLYDOHQWOHQJWKIRUDQ\GXFWFRQ¿JXUDWLRQ

5HIHUWR´'XFW)LWWLQJVµFKDUWWRFRPSXWHWKHPD[LPXP

permissible length for duct runs to the outdoors.

7KLVYHQWKRRGPXVWXVHURXQGGXFW7KHURXQG

GXFWFDQWUDQVLWLRQWR[

,QVWDOOWKHKRXVHGXFWZRUNWRUXQKRUL]RQWDOO\EHWZHHQ

ceiling joists or straight up through the roof.

Finish the Ceiling

)LQLVKWKHFHLOLQJVXUIDFH%HVXUHWRPDUNORFDWLRQRI

WKHFHLOLQJMRLVWVDQGFURVVIUDPLQJ&KHFNWREHVXUH

the ceiling is level; use shims, if necessary.

'HSHQGLQJRQDYDLODEOHVSDFH

Installation Instructions

STEP 2 REMOVE THE PACKAGING

The vent hood is packed separately from the decorative

GXFWFRYHURUDFFHVVRU\FRYHUV=;6)66RU

=;6)66

5HPRYHWKHIUDPHFRYHUSDUWVER[DQGSDFNDJLQJ

5HPRYHMXQFWLRQER[FRYHU

,QVWDOOVWUDLQUHOLHIRQWRMXQFWLRQER[FRYHU

STEP 3 CHECK INSTALLATION HARDWARE AND ACCESSORIES

/RFDWHWKHKDUGZDUHDFFHVVRU\SDFNVKLSSHGZLWKWKH

hood and check contents.

11-1/4”

TO CENTER LINE

OF HOLES

7-1/4” TO

CENTER LINE

OF HOLES

WIRE

HOLE

ACCESS

WIRE

HOLE

ACCESS

Mounting Screw Holes

2 Phillips-Head

'HFRUDWLYH6FUHZV

4 Filters

/RFN:DVKHUV

Template

,QVWDOODWLRQ6HUYLFH

Stop Screw

4 Machine Screws

Support Frames

with 8 Screws

and 8 Washers

4 Hex-Head

Lag Screws

'HFRUDWLYH'XFW&RYHUV

STEP 4 MOUNT TEMPLATE

$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQGWDSH

in place.

– Be sure the template is oriented correctly, with the front

of the hood.

8VHDSOXPEEREWREHVXUHWKHPRXQWLQJKROHVZLOOSUR

vide parallel alignment with the countertop below.

&HQWHUSXQFKDOOKROHORFDWLRQV

'ULOOSLORWKROHVLQWKHVFUHZORFDWLRQV8VHDELW

DQGGULOODSSUR[LPDWHO\GHHS

&XWWKHGXFWRSHQLQJDQGDSSUR[LPDWHO\ZLUH

access hole.

Installation Instructions

STEP 5 INSTALL SUPPORT FRAME

Install upper support frame

6HFXUHWKHXSSHUVXSSRUWIUDPHWRWKHFHLOLQJMRLVWV

DQGFURVVIUDPLQJZLWKWKHODJVFUHZVSURYLGHG)RU

PD[LPXPULJLGLW\DQGVWUHQJWKWKHVFUHZVPXVWEH

GULYHQLQWRWKHFHQWHURIWKHMRLVWVDQGRUFURVVIUDPLQJ

&KHFNWREHVXUHWKHVXSSRUWIUDPHLVOHYHOYHUWLFDOO\

DQGKRUL]RQWDOO\

Install lower support frame

,QVHUWORZHUVXSSRUWIUDPHRUDFFHVVRU\VXSSRUWIUDPH

=;6)66RU=;6)66LQWRWKHXSSHUVXSSRUW

IUDPHDQGORRVHO\VHFXUHZLWKVFUHZVDQGZDVKHUV

RQWKHIURQWDQGRQWKHEDFNVLGHV

$GMXVWWKHORZHUVXSSRUWIUDPHXSRUGRZQWRWKH

desired height above the countertop. Tighten screws.

IMPORTANT: Again, check to be sure the support is level in

both directions. There is no way to level the hood after the

hood is secured to the frame.

30" Recommended

10"

40"

Countertop

Hood

Mounting

Flange

Lower Support

76"

Wire Access Holes

Installation Instructions

STEP 6 SECURE WIRING

5RXWHKRXVHZLULQJWKURXJKWKHFHLOLQJKROHDQGSXOOD

OHQJWKWRUHDFKWKHKRRGMXQFWLRQER[DSSUR[LPDWHO\

below the support.

STEP 7 SIZE AND INSTALL

DUCTWORK

7DSHWKHZLUHWRWKHOHIWVLGHRIWKHIUDPHVXSSRUWWR

prevent damage during installation and service.

0HDVXUHIURPKRXVHGXFWÀDQJHWRERWWRPRIVXSSRUW

frame (Dim. A).

 ²$GGDWOHDVWIRUGXFWRYHUODSDWWKHWRS

 ²6XEWUDFWIRUKRRGLQVHUWLRQLQWRWKHERWWRPRI

the frame to determine required duct length.

&XWWKHGXFWOHQJWKUHTXLUHG

NOTE:7KHERWWRPRIWKHGXFWPXVWEHH[WHUQDOIHPDOH

connection to the top of the hood. The bottom end should

EHÀDUHGVOLJKWO\WRIDFLOLWDWHLQVWDOODWLRQRIWKHKRRG

,QVWDOOGXFWXSWKURXJKVXSSRUWIUDPHVDQGDWWDFKWR

house ducting with sheet metal screws.

6HDOWKHFRQQHFWLRQZLWKGXFWWDSH

Ceiling

Support

Frames

Tape

House

Wiring

Left Side

View

Installation Instructions

STEP 8 INSTALL DECORATIVE DUCT COVERS

3UHWDSRUGULYHGHFRUDWLYHVFUHZLQWRWKHVFUHZKROHV

on the support frame. This will make screw installation

easier.

6HSDUDWHWKHWZRGHFRUDWLYHGXFWFRYHUV

6HOHFWWKHLQVLGHFRYHUWRSZKLFKKDVWZRVFUHZKROHV

in the top.

6OLGHWKHGHFRUDWLYHGXFWFRYHURYHUWKHVXSSRUWIUDPH

and push to the ceiling.

$WWDFKWRWKHKRRGVXSSRUWDWWKHWRSZLWKVXSSOLHG

decorative screws.

/RFDWHWKHWKLUGGHFRUDWLYHVFUHZLQWKHKDUGZDUH

package. Set aside.

6OLGHWKHORZHUGHFRUDWLYHGXFWRYHUWKHLQVWDOOHGXSSHU

duct and push to the top.

,QVWDOOWKHGHFRUDWLYHVWRSVFUHZLQWKHFHQWHUKROHRIWKH

XSSHULQQHUGXFWFRYHU7KHGHFRUDWLYHVFUHZZLOODFWDV

a stop screw and prevent the lower decorative duct cover

from sliding down.

CAUTION: The stop screw must be installed.

)DLOXUHWRGRVRFRXOGUHVXOWLQSHUVRQDOLQMXU\RUGDPDJH

to the duct cover.

PRUDENCE : /DYLVVXSpULHXUHGRLWrWUH

HQSODFHD¿QG·pYLWHUOHVEOHVVXUHVRXG·HQGRPPDJHUOH

capot antipoussière.

STEP 9 INSTALL HOOD

NOTE: AT LEAST THREE PEOPLE ARE REQUIRED TO

COMPLETE THIS INSTALLATION!

/LIWWKHKRRGXSWRWKHVXSSRUWIUDPH&DUHIXOO\DOLJQWKH

hood mounting holes to the support frame holes and, at

the same time, the hood duct connector into the duct.

,QVWDOOVFUHZVWKURXJKWKHKRRGDQGKRRGVXSSRUW

&KHFNKRRGOHYHOLQERWKGLUHFWLRQV

&KHFNWREHVXUHWKDWWKHGXFWLVSRVLWLRQHGRYHUWKH

hood connector.

6HDOWKHGXFWFRQQHFWLRQZLWKGXFWWDSH

NOTE:'RQRWGULYHVFUHZVWKURXJKWKLVGXFWFRQQHFWLRQ

'RLQJVRZLOOSUHYHQWSURSHUGDPSHURSHUDWLRQ

Stop Screw

Apply Duct Tape

to Seal Duct

Connection

Install

4 Lock Washers

and 4 Machine Bolts

Bottom

Duct

Cover

Right

Side

Front

Installation Instructions

STEP 10 CONNECT ELECTRICAL

9HULI\WKDWSRZHULVWXUQHGRȹDWWKHVRXUFH

WARNING: ,IKRXVHZLULQJLVQRWZLUH

with a ground wire, a ground must be provided by the

installer. When house wiring is aluminum, be sure to use

8/DSSURYHGDQWLR[LGDQWFRPSRXQGDQGDOXPLQXPWR

copper connectors.

AVERTISSEMENT : Si le câblage de

ODPDLVRQQ·HVWSDVGXW\SHjGHX[¿OVDYHFXQ¿OGHWHUUH

O·LQVWDOODWHXUGRLWIRXUQLUXQFLUFXLWGHWHUUH4XDQGOHV¿OV

de la maison sont en aluminium, il prendre soin d’utiliser

GHODSkWHDQWLR[LGDWLRQDSSURXYpHSDU8/HWGHVFRQ

QHFWHXUVSRXUO·DOXPLQLXPFXLYUH

,QVWDOOVWUDLQUHOLHIRQWRWKHNQRFNRXWRIWKHMXQFWLRQER[

cover.

,QVHUWKRXVHZLULQJWKURXJKVWUDLQUHOLHIDQGWLJKWHQ

&RQQHFWZKLWHOHDGVWREUDQFKFLUFXLWZKLWHOHDG

&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG

&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQRU

bare ground lead.

6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFKHOHFWULFDO

connector.

3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU%HVXUH

wires are not pinched.

STEP 11

SLIDE DUCT COVER DOWN

+ROGWKHGHFRUDWLYHGXFWFRYHUDQGUHPRYHWKH

GHFRUDWLYHVWRSVFUHZIURPWKHVXSSRUWIUDPH'UHVV

all wire harnesses out of the path of the duct cover

seating.

6OLGHWKHORZHUGXFWFRYHUGRZQRQWRWKHKRRG

Installation Instructions

STEP 12 INSTALL FILTERS, FINALIZE INSTALLATION

7LSWKH¿OWHULQWRWKHlower slots at the rear of the

RSHQLQJ/LIWWKH¿OWHUDQGSXOOWKHNQREIRUZDUGXQWLOWKH

¿OWHUUHVWVRQWKHVORWV

0DNHVXUH\RXKDYHHQJDJHGWKH&OHDQ)LOWHU5HPLQGHU

6ZLWFKZLWKWKHULJKWVLGHJUHDVH¿OWHUE\FKHFNLQJWR

see if the red light is glowing in the display. If the red

OLJKWLVJORZLQJSOHDVHDGMXVWWKH¿OWHUXQWLOWKHUHG

LQGLFDWRUOLJKWWXUQVRȺ

&OHDQWKHKRRGZLWKDQDSSURYHGVWDLQOHVVVWHHOFOHDQHU

&KHFNKRRGRSHUDWLRQ,IWKHKRRGGRHVQRWRSHUDWH

check that house wires have been connected securely

and that no wires have been damaged during

installation. Check the breaker or house fuse is turned

on.

Filter Slots

Note: While performing installations described in this

ERRNVDIHW\JODVVHVRUJRJJOHVVKRXOGEHZRUQ

For Monogram

local service in your area, call

1.800.444.1845.

Note: 3URGXFWLPSURYHPHQWLVDFRQWLQXLQJHQGHDYRUDW

General Electric. Therefore, materials, appearance and

VSHFL¿FDWLRQVDUHVXEMHFWWRFKDQJHZLWKRXWQRWLFH



*(

Printed in Italy

Monogram ZV1050SFSS, ZV1050SFSS Installation guide

Related papers

Other documents