GE ZV800SJSS Installation guide

Brand: GE

Model: ZV800SJSS

Type: Installation guide

INSTALLATION

INSTRUCTIONS

30” Chimney Vent Hood

ZV800

MONOGRAM.COM

2 49-80267 Rev. 4

Safety Information

READ AND SAVE THESE INSTRUCTIONS

BEFORE YOU BEGIN

Read these instructions completely and carefully.

IMPORTANT — Save these instructions

for local inspector’s use.

IMPORTANT — Observe all governing

codes and ordinances.

ŶNote to Installer — Be sure to leave these

instructions with the Consumer.

ŶNote to Consumer — Keep these instructions with

your Owner’s Manual for future reference.

ŶSkill Level — Installation of this appliance requires

basic mechanical and electrical skills.

ŶCompletion Time — 1 to 3 Hours.

Ŷ3URSHULQVWDOODWLRQLVWKHUHVSRQVLELOLW\RIWKH

LQVWDOOHU3URGXFWIDLOXUHGXHWRLPSURSHULQVWDOODWLRQ

is not covered under the warranty.

Ŷ)RU0RQRJUDPORFDOVHUYLFHLQ\RXUDUHDYLVLW

monogram.com.

Ŷ)RU0RQRJUDPVHUYLFHLQ&DQDGDYLVLWmonogram.ca

Ŷ)RU0RQRJUDP3DUWVDQG$FFHVVRULHVYLVLW

monogram.com/use-and-care/parts.

CAUTION

Due to the weight and size of these

vent hoods and to reduce the risk of personal injury

RUGDPDJHWRWKHSURGXFW TWO PEOPLE ARE

REQUIRED FOR PROPER INSTALLATION.

ATTENTION

À cause du poids et de la taille de

ces hottes et pour reduire le risque de blessures et de

GRPPDJHV IL FAUT DEUX PERSONNES POUR FAIRE

L’INSTALLATION CORRECTEMENT.

WARNING

To reduce the risk of fire or electrical

VKRFNGRQRWXVHWKLVUDQJHKRRGZLWKDQ\H[WHUQDO

VROLGVWDWHVSHHGFRQWUROGHYLFH$Q\VXFKDOWHUDWLRQ

from original factory wiring could result in damage to

the unit and/or create an electrical safety hazard.

AVERTISSEMENT

3RXUUpGXLUHOHULVTXHG¶LQFHQGLH

RXGHFKRFpOHFWULTXHLOQHIDXWSDVXWLOLVHUFHWWHKRWWH

DYHFXQUpJXODWHXUGHYLWHVVHpOHFWURQLTXHH[WHUQH7RXWH

modification de ce type du branchement d’usine peute

HQGRPPDJHUO¶DSSDUHLORXFUpHUXQULVTXHGHFKRFpOHFWULTXH

TO REDUCE THE RISK OF FIRE, USE ONLY

METAL DUCTWORK.

WARNING

725('8&(7+(5,6.2)),5(

(/(&75,&$/6+2&.25,1-85<723(56216

2%6(59(7+()2//2:,1*

$8VHWKLVXQLWRQO\LQWKHPDQQHULQWHQGHGE\WKH

PDQXIDFWXUHU,I\RXKDYHDQ\TXHVWLRQVFRQWDFW

the manufacturer.

%%HIRUHVHUYLFLQJRUFOHDQLQJWKHXQLWVZLWFKWKH

power off at the service panel and lock the service

disconnecting means to prevent the power from

EHLQJVZLWFKHGRQDFFLGHQWDOO\:KHQWKHVHUYLFH

GLVFRQQHFWLQJPHDQVFDQQRWEHORFNHGVHFXUHO\

IDVWHQDSURPLQHQWZDUQLQJGHYLFHVXFKDVDWDJ

to the service panel.

AVERTISSEMENT

32855e'8,5(/(5,648(

'¶,1&(1',('(&+2&e/(&75,48(28'(%/(6685(6

,/)$872%6(59(5/(65(*/(668,9$17(6

$ 

8WLOLVH]FHWDSSDUHLOXQLTXHPHQWGHODPDQLpUpSUpYXHSDU

OHIDEULFDQW(QFDVGHTXHVWLRQFRQVXOWH]OHIDEULFDQW

% $YDQWWRXWHLQWHUYHQWLRQRXQHWWR\DJHFRXSH]

O¶DOLPHQWDWLRQpOHFWULTXHDXGLVMRQFWHXUHWYHUURXLOOH]OH

SDQQHDXGXGLVMRQFWHXUSRXUpYLWHUODPLVHVRXVWHQVLRQ

accidentelle. S’il n’est pas possible de verrouiller le

SDQQHDXGXGLVFRQFWHXUDWWDFKH]XQSODFDUGRXXQH

pWLTXHWWHWUqVYLVLEOHDXSDQQHDX

Ŷ)RUJHQHUDOYHQWLODWLQJXVHRQO\'RQRWXVHWR

H[KDXVWKD]DUGRXVRUH[SORVLYHPDWHULDOVRUYDSRUV

Ŷ6WUXFWXUDOIUDPLQJLQVWDOODWLRQZRUNDQGHOHFWULFDO

wiring must be done by qualified person(s). In

accordance with all applicable codes and standards

including fire-rated construction.

Ŷ6XIILFLHQWDLULVQHHGHGIRUSURSHUFRPEXVWLRQDQG

H[KDXVWLQJRIJDVHVWKURXJKWKHIOXHFKLPQH\RIIXHO

EXUQLQJHTXLSPHQWWRSUHYHQWEDFNGUDIWLQJ)ROORZ

the heating equipment manufacturer’s guidelines

DQGVDIHW\VWDQGDUGVVXFKDVWKRVHSXEOLVKHGE\

WKH1DWLRQDO)LUH3URWHFWLRQ$VVRFLDWLRQ1)3$WKH

$PHULFDQ6RFLHW\IRU+HDWLQJ5HIULJHUDWLRQDQG$LU

&RQGLWLRQLQJ(QJLQHHUV$6+5$(DQGWKHORFDOFRGH

DXWKRULWLHV:KHQDSSOLFDEOHLQVWDOODQ\PDNHXS

(replacement) air system in accordance with local

building code requirements.

Ŷ/RFDOFRGHVYDU\,QVWDOODWLRQRIHOHFWULFDO

connections and grounding must comply with

DSSOLFDEOHFRGHV,QWKHDEVHQFHRIORFDOFRGHVWKH

YHQWVKRXOGEHLQVWDOOHGLQDFFRUGDQFHZLWK1DWLRQDO

(OHFWULFDO&RGH$16,1)3$RUODWHVWHGLWLRQ

CAUTION

To reduce risk of fire and to properly

H[KDXVWDLUEHVXUHWRGXFWDLURXWVLGH²GRQRWYHQW

H[KDXVWDLULQWRVSDFHVZLWKLQZDOOVRUFHLOLQJVRULQWR

DWWLFVFUDZOVSDFHVRUJDUDJHV

ATTENTION

Il faut prendre soin d’installer un conduit

YHUVO¶H[WpULHXUSRXUUpGXLUHOHULVTXHG¶LQFHQGLHHWSRXYRLU

pYDFXHUO¶DLUFRUUHFWHPHQW,OQHIDXWSDVpYDFXHUO¶DLUGDQV

O¶HVSDFHHQWUHOHVSDURLVG¶XQPXUXQSODIRQGRXXQJUHQLHU

un espace sanitaire ou un garage.

49-80267 Rev. 4 3

Design Information

PRODUCT DIMENSIONS AND

CLEARANCES

7KHYHQWKRRGPXVWEHLQVWDOOHG´PLQDQG´PD[

above the cooking surface. The telescopic duct cover

conceals the ductwork running from the top of the hood

to the ceiling. The duct cover is sized to reach 8 ft. to

IWFHLOLQJKHLJKWV

7KHKRRGLQVWDOODWLRQKHLJKWIURPWKHFRRNLQJVXUIDFH

WRWKHERWWRPRIWKHKRRGGHSHQGVXSRQFHLOLQJKHLJKW

INSTALLATION OPTIONS

WALL-MOUNTED INSTALLATIONS

This hood may be installed

onto a wall and vented to

WKHRXWGRRUVRULWFDQEH

installed for recirculating

RSHUDWLRQ$OOQHFHVVDU\

parts for a recirculating

operation are shipped with

WKHKRRG1RNLWVUHTXLUHG

UNDER-CABINET

INSTALLATIONS

The hood may be installed beneath a cabinet. The

FDELQHWPXVWPHDVXUHDWOHDVW´IURPWKHERWWRP

IUDPHWRWKHLQVLGHWRS6HHSDJH

Ŷ Both vented and

recirculating operation can

be accomplished in an

under-cabinet installation.

(Custom cabinet

modification is required for

recirculating operation.)

CONTENTS

Safety Information ....................................................... 2

Design Information

3URGXFW'LPHQVLRQVDQG&OHDUDQFHV ............................ 3

Installation Options ........................................................ 3

$GYDQFH3ODQQLQJ'XFWZRUN)UDPLQJ ......................... 4

3RZHU6XSSO\ ................................................................ 4

'XFW)LWWLQJV .................................................................. 5

Installation Preparation

Tools and Materials Required ....................................... 6

5HPRYHWKH3DFNDJLQJ ................................................. 6

:DOO0RXQW,QVWDOODWLRQV ................................................ 

,QVWDOODWLRQ%HORZD:DOO&DELQHW .................................. 

Check Installation Hardware ......................................... 8

'XFWZRUN:LULQJ/RFDWLRQV ........................................... 

Installation—Vented to the Outside

6WHS,QVWDOO)UDPLQJIRU+RRG6XSSRUW...................... 

6WHS,QVWDOO0RXQWLQJ%UDFNHW ................................. 

6WHS,QVWDOO'XFW%UDFNHW ......................................... 

6WHS3UHSDUHWKH+RRG ........................................... 11

6WHS0RXQWWKH+RRG .............................................. 11

6WHS&RQQHFW'XFWZRUN .......................................... 12

6WHS&RQQHFW(OHFWULFDO ........................................... 12

6WHS,QVWDOO'XFW&RYHUV.......................................... 13

6WHS,QVWDOO)LOWHUV .................................................... 13

6WHS)LQDOL]H,QVWDOODWLRQ ....................................... 13

Wall-Mounted Installation—Recirculating

'XFWZRUN:LULQJ/RFDWLRQV ......................................... 14

6WHS,QVWDOO)UDPLQJIRU+RRG6XSSRUW.................... 14

6WHS,QVWDOO0RXQWLQJ%UDFNHW ................................. 15

6WHS3UHSDUHWKH+RRG ........................................... 15

6WHS0RXQWWKH+RRG .............................................. 16

6WHS6L]HDQG&XW'XFW3LHFH................................. 16

6WHS&RQQHFW(OHFWULFDO ........................................... 

6WHS,QVWDOO'XFW&RYHUV.......................................... 

6WHS,QVWDOO)LOWHUV .................................................... 18

6WHS)LQDOL]H,QVWDOODWLRQ ......................................... 18

Wall-Mounted Installation—Recirculating

Cabinet Requirements ................................................. 

'XFWZRUN:LULQJ ......................................................... 

6WHS,QVWDOO)UDPLQJIRU+RRG6XSSRUW.................... 

6WHS3UHSDUHWKH+RRG ........................................... 

6WHS&XWWKH2SHQLQJ.............................................. 21

6WHS,QVWDOO6LGH³/´%UDFNHWV .................................. 21

6WHS5HPRYH6LGH6FUHZ ....................................... 21

6WHS0RXQWWKH+RRG .............................................. 22

6WHSComplete Installation and Connect Ductwork.... 22

6WHS&RQQHFW(OHFWULFDO ........................................... 23

6WHS,QVWDOO5HDU0RXQWLQJ6FUHZV ......................... 23

6WHS,QVWDOO)LOWHUV .................................................. 23

12" at Sides,

12 7/8

-1/2"

Height to

Ceiling

35-7/8"

The Supplied Duct Co

* Height to

Ceiling

1-1/2”

´DW6LGHV

13-11/16” at Center

´

* The Supplied Duct Cover

)LWVIWWRIW&HLOLQJ+HLJKWV

NOTE: The

vent hood

FDQRS\H[WHQGV

IRUZDUG´

24” Min.

´0D[

*24” Min.

*Depending on Cabinet Height

4 49-80267 Rev. 4

Installation Preparation

ADVANCE PLANNING

Ŷ'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG

Ŷ3ODQWKHURXWHIRUYHQWLQJH[KDXVWWRWKHRXWGRRUV

Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH)RU

VDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOGQRWH[FHHG

IWHTXLYDOHQWOHQJWKIRUDQ\GXFWFRQILJXUDWLRQV

Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWRQSDJHWRFRPSXWH

WKHPD[LPXPSHUPLVVLEOHOHQJWKIRUGXFWUXQVWRWKH

outdoors.

Ŷ:KHQDSSOLFDEOHLQVWDOODQ\PDNHXSUHSODFHPHQW

air system in accordance with local building code

requirements. Visit Monogram.com for available

makeup air solutions.

CAUTION

To reduce risk of fire and to properly

H[KDXVWDLUEHVXUHWRGXFWDLURXWVLGH²GRQRWYHQW

H[KDXVWDLULQWRVSDFHVZLWKLQZDOOVRUFHLOLQJVRULQWR

DWWLFVFUDZOVSDFHVRUJDUDJHV

ATTENTION

Il faut prendre soin d’installer un conduit

YHUVO¶H[WpULHXUSRXUUpGXLUHOHULVTXHG¶LQFHQGLHHWSRXYRLU

pYDFXHUO¶DLUFRUUHFWHPHQW,OQHIDXWSDVpYDFXHUO¶DLU

FRUUHFWHPHQW,OQHIDXWSDVpYDFXHUO¶DLUGDQVO¶HVSDFHHQWUH

OHVSDURLVG¶XQPXUXQSODIRQGRXXQJUHQLHUXQHVSDFH

sanitaire ou un garage.

Ŷ8VHPHWDOGXFWZRUNRQO\7KHVHKRRGVPXVWXVH

´URXQGGXFW,WFDQWUDQVLWLRQWR´[´UHGXFLQJ

WKHPD[LPXPHTXLYDOHQWGXFWOHQJWKWR

IHHW

Ŷ,QVWDOODZDOOFDSZLWKGDPSHURUURRIFDSDWWKH

H[WHULRURSHQLQJ2UGHUWKHZDOORUURRIFDSDQGDQ\

transition needed in advance.

Wall Framing for Adequate Support

Ŷ7KLVYHQWKRRGLVKHDY\$GHTXDWHVWUXFWXUDOVXSSRUW

must be provided in all types of installations. The hood

PXVWEHVHFXUHGWRYHUWLFDOVWXGVLQWKHZDOORUWRD

KRUL]RQWDOVXSSRUW)RUZDOOPRXQWLQJLQVWDOODWLRQVVHH

SDJHVDQG)RUXQGHUFDELQHWLQVWDOODWLRQVVHH

SDJH

Ŷ7KHYHQWKRRGDQGZDOOFDELQHWLIXVHGVKRXOGEH

on site before final framing and wall finishing. This

will also help to accurately locate the duct work and

electrical service.

POWER SUPPLY

IMPORTANT – (Please read carefully)

WARNING

)253(5621$/6$)(7<7+,6

$33/,$1&(0867%(3523(5/<*5281'('

AVERTISSEMENT

3285'(65$,6216'(

6e&85,7e&(7$33$5(,/'2,7Ç75(&255(&7(0(17

0,6¬/$7(55(

Remove house fuse or open circuit breaker before

beginning installation.

'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJZLWKWKLV

DSSOLDQFH)ROORZ1DWLRQDOHOHFWULFDOFRGHVRUSUHYDLOLQJ

local codes and ordinances.

Electrical supply

7KHVHYHQWKRRGVPXVWEHVXSSOLHGZLWK9+]

DQGFRQQHFWHGWRDQLQGLYLGXDOSURSHUO\JURXQGHG

EUDQFKFLUFXLWDQGSURWHFWHGE\DRUDPSFLUFXLW

breaker or time delay fuse.

Ŷ:LULQJPXVWEHZLUHZLWKJURXQG

Ŷ,IWKHHOHFWULFDOVXSSO\GRHVQRWPHHWWKHDERYH

UHTXLUHPHQWVFDOODOLFHQVHGHOHFWULFLDQEHIRUH

proceeding.

Ŷ5RXWHKRXVHZLULQJWKURXJKFRQGXLWDVFORVHWRWKH

LQVWDOODWLRQORFDWLRQDVSRVVLEOHLQWKHFHLOLQJRUEDFN

wall.

Ŷ8VHDFRQGXLWFRQQHFWRUWRVHFXUHWKHFRQGXLWWRWKH

MXQFWLRQER[

Ŷ&RQQHFWWKHKRRGZLULQJWRWKHKRXVHZLULQJLQ

accordance with local codes.

Grounding instructions

The grounding conductor must be connected to a

JURXQGHGPHWDOSHUPDQHQWZLULQJV\VWHPRUDQ

equipment-grounding terminal or lead on the hood.

WARNING

The improper connection of the

equipment-grounding conductor can result in a risk

of electric shock. Check with a qualified electrician or

service representative if you are in doubt whether the

appliance is properly grounded.

AVERTISSEMENT

Le mauvais branchement du fil

GHPLVHjODWHUUHSHXWFDXVHUXQFKRFpOHFWULTXH(QFDVGH

GRXWHFRQVXOWHUXQpOHFWULFLHQTXDOLILpRXXQWHFKQLFLHQSRXU

GpWHUPLQHUVLO¶DSSDUHLOHVWjODWHUUH

49-80267 Rev. 4 5

DUCT FITTINGS

This Hood Must Use an

6” Round Duct.

It Can Transition to a

3-1/4” x 12” Duct.

8VHWKLVFKDUWWRFRPSXWHPD[LPXP

permissible lengths for duct runs to

outdoors.

NOTE:'RQRWH[FHHGPD[LPXP

permissible equivalent lengths!

Maximum duct length:

100 foot for 6” round duct

75 foot for 3-1/4” x 12” duct

Flexible ducting:

,IIOH[LEOHPHWDOGXFWLQJLVXVHG

all the equivalent feet values in

the table should be doubled. The

IOH[LEOHPHWDOGXFWVKRXOGEHVWUDLJKW

DQGVPRRWKDQGH[WHQGHGDVPXFK

as possible.

'2127XVHIOH[LEOHSODVWLFGXFWLQJ

NOTE:$Q\KRPHYHQWLODWLRQ

V\VWHPVXFKDVDYHQWLODWLRQKRRG

may interrupt the proper flow of

FRPEXVWLRQDLUDQGH[KDXVWUHTXLUHG

E\ILUHSODFHVJDVIXUQDFHVJDV

water heaters and other naturally

vented systems. To minimize the

chance of interruption of such

QDWXUDOO\YHQWHGV\VWHPVIROORZWKH

heating equipment manufacturer’s

guidelines and safety standards

VXFKDVWKRVHSXEOLVKHGE\1)3$

DQG$6+5$(:KHQDSSOLFDEOH

install any makeup (replacement)

air system in accordance with

local building code requirements.

Visit Monogram.com for available

makeup air solutions.

Installation Preparation

Equivalent

Duct Piece Dimensions

Equivalent

Length*

Quantity

Used

Total

Equivalent

Length

5RXQGVWUDLJKW 1 ft.

(per foot length)

´[´´[´

straight

1 ft.

(per foot length)

6” Round

HOERZ

15 ft.

6” Round

HOERZ

8 ft.

»´[´

HOERZ

11 ft.

´[´RU

HOERZ

6 ft.

´[´

IODWHOERZ

24 ft.

6” round to

´[´WUDQVLWLRQRU

´[´WUDQVLWLRQ

1 ft.

´[´WR´

round transition

8 ft.

´URXQGWR´[´RU

WUDQVLWLRQHOERZ

16 ft.

´[´WR´

URXQGWUDQVLWLRQHOERZ

IW

6” Round wall cap

with damper

IW

´[´ZDOOFDS

with damper

IW

6” Round roof cap 26 ft

6” Round roof vent 26 ft

$FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFWILWWLQJHTXLYDOHQW(TXLYDOHQW

length of duct pieces are based on actual tests conducted by

*($SSOLDQFHV(YDOXDWLRQ(QJLQHHULQJDQGUHIOHFWUHTXLUHPHQWVIRU

good venting performance with any ventilation hood.

Total Duct Run

6 49-80267 Rev. 4

Installation Preparation

TOOLS AND MATERIALS REQUIRED

(NOT SUPPLIED)

Ŷ7DSHPHDVXUH

Ŷ.QLIH

Ŷ6SLULWOHYHO

Ŷ:LUHFXWWHUVWULSSHU

Ŷ:LUHQXWV

Ŷ(OHFWULFGULOOZLWKDQGELWV

Ŷ3KLOOLSVDQGIODWEODGHVFUHZGULYHUV

Ŷ+DPPHU

Ŷ3OLHUV

Ŷ6DIHW\JODVVHV

Ŷ'XFWWDSH

Ŷ7DSHWRPRXQWWHPSODWH

Ŷ*ORYHVWRSURWHFWDJDLQVWVKDUS

edges

Ŷ9+]RU$PSZLUH

ZLWKJURXQG3URSHUO\JURXQGHG

branch circuit

Ŷ6WUDLQUHOLHIIRUMXQFWLRQFRYHU

ŶURXQGPHWDOGXFWOHQJWKWRVXLW

installation

Ŷ6DZRUMLJVDZ

Ŷ&RQGXLWIRUKRXVHZLULQJ

and conduit connector

REMOVE THE PACKAGING

Ŷ5HPRYHWKHGXFWFRYHUSDUWVER[DQGRWKHU

packaging.

Ŷ/LIWWKHKRRGRXWRIWKHER[

Ŷ5HPRYHDQGSURSHUO\GLVFDUGWKHSODVWLFZUDSSLQJ

Ŷ5HPRYHMXQFWLRQER[FRYHU

Measuring tape

Electric drill with

1/8” and 3/8” Bits

´ORQJ3KLOOLSV

head screwdriver

Safety glasses

*ORYHV

Spirit level

Knife

:LUHFXWWHUVWULSSHU

)ODWEODGHVFUHZGULYHU

Hammer

3OLHUV

Duct tape

Masking tape

:LUHQXWV

Strain relief for

MXQFWLRQER[

Saw or jig saw

Conduit

2-piece duct

cover

49-80267 Rev. 4 

Installation Preparation

WALL MOUNT INSTALLATIONS

These hoods may be installed onto a wall or below a

wall cabinet.

Ŷ7HOHVFRSLFGXFWFRYHUVDUHSURYLGHGWRFRQFHDOWKH

GXFWZRUNUXQQLQJWRWKHFHLOLQJ

Ŷ7KLVKRRGFDQEHLQVWDOOHGIRUUHFLUFXODWLQJ

RSHUDWLRQ1RNLWVUHTXLUHG

7KHYHQWKRRGPXVWEHLQVWDOOHGPLQDQG

PD[DERYHWKHFRRNLQJVXUIDFH7KHKRRGLQVWDOODWLRQ

KHLJKWIURPWKHFRRNLQJVXUIDFHWRWKHERWWRPRIWKH

KRRGGHSHQGVXSRQFHLOLQJKHLJKW

INSTALLATION BELOW A CABINET

7KHFDELQHWPXVWPHDVXUHDWOHDVW´IURPWKH

bottom frame to the inside top. The hood housing will

occupy the interior cabinet space.

Wall Mount ZV830

Installation Heights

Actual Ceiling

Height

*Possible VENTED

Installation Height

*Possible

RECIRCULATING

Installation Height

¶´ ´WR´ 

¶´ 24” to 28” 24” to 25”

8’-1” ´WR´ 24” to 26”

8’-2” ´WR´ ´WR´

8’-3” ´WR´ 24” to 28”

8’-4” ´WR´ ´WR´

8’-5” ´WR´ ´WR´

8’-6” ´WR´ ´WR´

¶´ ´WR´ ´WR´

8’-8” ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

8’-11” ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

¶´ ´WR´ ´WR´

 WR WR

 WR WR

 WR WR

 WR WR

 WR WR

  WR

* Based on 36” countertop height.

36” Min.

24” Min.

´0D[

24” Min.

´0LQ

INSTALLATION BELOW A WALL

CABINET

2UGHUDFDELQHWWKDWLVDWOHDVW´KLJKIURPWKH

bottom frame to the inside top. The cabinet must be

at least 12” deep.

Ŷ7KHKRRGLQVWDOODWLRQKHLJKWLVGHWHUPLQHGE\WKH

ceiling height.

Ŷ7KHKRRGLQVWDOODWLRQKHLJKWPXVWEH´0LQDERYH

the cooking surface.

8 49-80267 Rev. 4

Installation Preparation

CHECK INSTALLATION HARDWARE

/RFDWHWKHKDUGZDUHDFFHVVRU\ER[SDFNHGZLWKWKHKRRGDQGFKHFNFRQWHQWV

29-7/8"

11-1/2"

12"

27-3/4"

4 wood

screws

Mounting bracket

2 stainless steel filters

3KLOOLSVKHDG

screws to secure

HOHFWULFDOER[WR

top of motor

compartment

1 charcoal filter for

recirculating installations

2-piece decorative duct

cover (dimension shown

for reference only)

$LUGHIOHFWRUIRU

recirculating

installations only

Duct bracket

³/´%UDFNHWVZLWKKDUGZDUH

package for cabinet-mounted

installations.

&RQWDLQV3KLOOLSVKHDGVFUHZV

to secure the brackets to the

FDELQHWUHTXLUHGH[WUD

Cabinet installation template

REAR WALL TEMPLATE

49-80271 07-04 JR

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

ALIGN BOTTOM EDGE WITH

PENCIL LINE INDICATING

BOTTOM OF THE HOOD.

5-1/16"

9-5/8"

8-1/8"

2-1/16"

13-3/4"

12-3/4"

043021

:DOOPRXQWWHPSODWH

4 wall

fasteners

3KLOOLSVKHDGGHFRUDWLYH

screws to secure duct cover

to ceiling bracket

49-80267 Rev. 4 

Installation Instructions

WALL-MOUNTED INSTALLATION—VENTED TO THE OUTSIDE

DUCTWORK, WIRING LOCATIONS

'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG

Ŷ/RFDWHWKHWHPSODWHSDFNHGZLWKWKHOLWHUDWXUH

0HDVXUHIURPWKHIORRUWRWKHWRSRIWKH

FRRNLQJVXUIDFH$GGKRRGLQVWDOODWLRQKHLJKW

GHWHUPLQHGRQSDJH0DUNWKDWORFDWLRQ

Use a level to draw a straight pencil line on the wall.

Tape the template in position along the penciled line.

&+(&.72%(685(7+(7(03/$7(,6/(9(/

Ceiling ducting:

,IGXFWZRUNZLOOYHQWVWUDLJKWXSWRWKHFHLOLQJ

Ŷ8VHDOHYHOWRGUDZDOLQHVWUDLJKWXSIURPWKH

centerline on the template to the ceiling.

Ŷ0HDVXUH´IURPWKHEDFNZDOOWRWKHFHQWHUOLQH

of a 6-1/2” hole on the ceiling.

NOTE:,IGU\ZDOOLVQRWSUHVHQWDGGGU\ZDOOWKLFNQHVV

to the 3-3/4” dimension.

Wall Ducting:

,IGXFWZRUNZLOOYHQWWRWKHUHDU

Ŷ8VHDOHYHOWRGUDZDOLQHVWUDLJKWXSIURPWKH

centerline on the template.

Ŷ0HDVXUHDWOHDVW´DERYHWKHWRSPRXQWLQJ

bracket holes shown on the template to the

centerline of a 6-1/2” dia. duct hole. (Hole may be

elongated for duct elbow.)

HOUSE WIRING LOCATION:

Ŷ7KHMXQFWLRQER[LVORFDWHGRQWKHWRSOHIWVLGHRI

the hood.

Ŷ:LULQJVKRXOGHQWHUWKHEDFNZDOO´WR´DERYH

WKHERWWRPRIWKHKRRGDQGZLWKLQ´RIWKHULJKW

VLGHRIWKHFHQWHUOLQH:LULQJVKRXOGHQWHUDWOHDVW´

above the bracket on the right side.

INSTALL FRAMING FOR HOOD

SUPPORT

IMPORTANT: Framing must be capable of

supporting 100 lbs.

,IGU\ZDOOLVSUHVHQWPDUNWKHVFUHZKROHORFDWLRQVIRU

the top mounting brackets. Remove the template.

Ŷ&XWDZD\HQRXJKGU\ZDOOWRH[SRVHYHUWLFDOVWXGV

at the bracket location indicated on the template.

Ŷ,QVWDOODKRUL]RQWDOVXSSRUWDWOHDVW[EHWZHHQ

two wall studs at the mounting screw location. The

horizontal support must be flush with the room

side of the studs. Use cleats behind both sides of

the support to secure to wall studs.

Ŷ5HLQVWDOOGU\ZDOO

REAR WALL TEMPLATE

49-80271 JR 07-04

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

ALIGN BOTTOM EDGE WITH

PENCIL LINE INDICATING

BOTTOM OF THE HOOD.

5-1/16"

9-5/8"

8-1/8"

2-1/16"

13-3/4"

12-3/4"

Ceiling

3-3/4” c enterline to wall

6-1/2” dia. hole

)RUFHLOLQJYHQWGXFWLQJ

Centerline

3-3/4” min.

above top

mounting

bracket holes

)25:$//9(17'8&7

Centerline of

Installation

Space

8" Min. Opening for Ductwork

View From Rear

Cleats

1" x 6" Min.

Mounting

Support

6” min. opening for ductwork

Centerline of

installation

space

View from rear

cleats

´[´PLQ

mounting

support

 49-80267 Rev. 4

Installation Instructions

WALL-MOUNTED INSTALLATION—VENTED TO THE OUTSIDE

INSTALL MOUNTING BRACKET

This vent hood must be secured to the horizontal

support or wall studs.

Ŷ:LWKWKHWHPSODWHWDSHGLQSODFHXVHDSXQFKWR

mark all mounting screw locations.

Ŷ'ULOO´SLORWKROHVDWWKHSXQFKHGORFDWLRQV

Ŷ5HPRYHWKHWHPSODWH

Ŷ7KHKROHVLQWKHVXSSRUWEUDFNHWKROHVPXVWHQWHU

studs or the horizontal support.

Ŷ8VHZRRGVFUHZVWRVHFXUHWKHPRXQWLQJEUDFNHWWR

the wall. The screws must engage wall studs or the

installed horizontal mounting support.

Ŷ&KHFNWREHVXUHWKDWWKHEUDFNHWLVOHYHO7KHUHLV

no way to level the hood after hanging it from this

bracket.

INSTALL DUCT BRACKET

The duct bracket must be intalled against the ceiling.

This bracket will hold the duct cover in place at the

top.

Secure the bracket to the ceiling and wall:

Ŷ$OLJQWKHPDUNHGFHQWHUOLQHRQWKHEUDFNHWZLWKWKH

centerline on the wall.

Ŷ0DUNWKHVFUHZKROHORFDWLRQVLQWKHFHLOLQJ

Ŷ'ULOO´SORWKROHVLQWKHPDUNHGORFDWLRQV

Ŷ,ISLORWKROHVGRQRWHQWHUVWXGVHQODUJHWKHKROHVWR

3/8” and install wall fastener anchors.

Ŷ'ULYHVFUHZVE\KDQGLQWRWKHIDVWHQHUVWRDOORZ

DQFKRUVWRH[SDQG5HPRYHWKHVFUHZV

Ŷ6HFXUHWKHEUDFNHWWRWKHFHLOLQJDQGZDOOZLWKZRRG

screws and/or fasteners.

49-80267 Rev. 4 11

Installation Instructions

WALL-MOUNTED INSTALLATION—VENTED TO THE OUTSIDE

PREPARE THE HOOD

Ŷ5HPRYHWKHKRRGIURPWKHER[5HPRYHSDFNDJLQJ

and tape.

Ŷ5HPRYHRQHVFUHZRQHDFKVLGHRIWKHFRYHURQ

the electrical panel. Lift off the cover and set aside

with screws.

Ŷ6WDQGWKHHOHFWULFDOSDQHOXSULJKW

Ŷ$OLJQWKHVFUHZKROHVLQWKHERWWRPRIWKHSDQHO

with the holes on the base of

the hood at the front side.

Ŷ,QVWDOOVFUHZVSURYLGHG

MOUNT THE HOOD

Ŷ/LIWWKHKRRGRQWRWKHPRXQWLQJEUDFNHW

Ŷ&KHFNWREHVXUHLWLVOHYHO

Ŷ,QVWDOOZRRGVFUHZVWKURXJKWKHKRRGDQGLQWRWKH

wall on each side of the mounting bracket.

Ŷ([WHQGWKHFDQRS\IRUZDUGIRUEHWWHUDFFHVVWRWKH

rear mounting screw holes.

Ŷ,QVWDOOZRRGVFUHZVRUIDVWHQHUVWKURXJKWKH

bottom of the hood into the wall.

Remove 2 side

cover screws

Electrical

panel

Secure electrical

panel with 3

screws

-XQFWLRQER[

Inside screw

Install a wood

screw on each

side of the

mounting frame

Mounting

bracket

Install bottom

mounting screws

12 49-80267 Rev. 4

Installation Instructions

WALL-MOUNTED INSTALLATION—VENTED TO THE OUTSIDE

CONNECT DUCTWORK

Ŷ,QVWDOOGXFWZRUNPDNLQJFRQQHFWLRQVLQGLUHFWLRQRI

airflow as illustrated.

Ŷ3XVKGXFWRYHUWKHH[KDXVWRXWOHWDQGGDPSHU

Ŷ6HFXUHMRLQWVLQGXFWZRUNZLWKVKHHWPHWDOVFUHZV

Ŷ:UDSDOOGXFWMRLQWVZLWKGXFWWDSHIRUDQDLUWLJKW

seal.

Ŷ8VHGXFWWDSHWRVHDOWKHIODQJHFRQQHFWLRQV

CAUTION

Do not use sheet metal screws at

the hood flange connection. Doing so will prevent

proper damper operations. Seal connection with tape

only.

ATTENTION

Il ne faut pas utiliser de vis

DXWRUDXUGHXVHVjODFRQQH[LRQGXFROOHWGHODKRWWH&HFL

HPSrFKHUDLWOHERQIRQFWLRQQHPHQWGXUHJLVWUH1¶XWLOLVHU

TXHGXUXEDQDGKpVLISRXUDVVXUHUO¶pWDQFKpLWpGXUDFFRUG

CONNECT ELECTRICAL

Verify that power is turned off at the source.

WARNING

If house wiring is not 2-wire with

DJURXQGZLUHDJURXQGPXVWEHSURYLGHGE\WKH

LQVWDOOHU:KHQKRXVHZLULQJLVDOXPLQXPEHVXUH

WRXVH8/DSSURYHGDQWLR[LGDQWFRPSRXQGDQG

aluminum-to-copper connectors.

AVERTISSEMENT

Si la maison n’est pas câblee avec

GHX[ILOVHWXQILOGHWHUUHO¶LQVWDOODWHXUGRLWLQVWDOOHUXQILOGH

WHUUH4XDQGOHVILOVVRQWHQDOXPLQLXPLOIDXWSUHQGUHVRLQ

d’utiliser des connecteurs aluminium à cuivre avec une pâte

DQWLR[\GDQWHDSSURXYpHSDU8/

Ŷ5HPRYHMXQFWLRQER[FRYHUDQGNQRFNRXW

Ŷ8VHDFRQGXLWFRQQHFWRUWRVHFXUHWKHFRQGXLWWR

WKHMXQFWLRQER[

Ŷ&RQQHFWZKLWHOHDGVWREUDQFKFLUFXLWZKLWHOHDG

Ŷ&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG

Ŷ&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQ

lead or bare ground lead.

Ŷ6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFK

electrical connector.

Ŷ3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU

Be sure wires are not pinched.

Ŷ6HFXUHHOHFWULFDOSDQHOFRYHUZLWKRULJLQDOVFUHZV

Duct tape

over seam

and screw

Screw

$LUIORZ

49-80267 Rev. 4 13

Installation Instructions

WALL-MOUNTED INSTALLATION—VENTED TO THE OUTSIDE

INSTALL DUCT COVERS

Ŷ3ODFHWKHGHFRUDWLYHGXFW

covers on top of the hood.

NOTE: The inside (upper)

duct piece has holes on one

end. The holes are intended

for use when the hood is

installed for recirculating

purposes. Slide the vented

HQGLQWRWKHRXWHUSLHFHWKH

vent holes should not be

visible in this installation.

The inside duct piece must slip into the folded ends of

the outer section.

Ŷ([WHQGWKHLQQHUGXFWXSZDUGVWRWKHFHLOLQJ

bracket.

Ŷ6HFXUHGXFWFRYHUWRFHLOLQJEUDFNHWZLWKVFUHZV

Ŷ6HFXUHWKHORZHUGXFWFRYHUWRWKHKRRGE\

installing 2 screws from the bottom of the hood into

the duct cover.

INSTALL FILTERS

Ŷ5HPRYHSURWHFWLYHILOPRQWKHILOWHUV

Ŷ7LSWKHILOWHULQWRWKHVORWVDWWKHUHDURIWKHRSHQLQJ

Lift the filter lock and pull forward until the filter rests

in the slots.

Ŷ,QVWDOOERWKPHWDOJUHDVHILOWHUV

Ŷ7RUHPRYHWKHILOWHUVSUHVVLQZDUGVRQWKHKDQGOH

and pull the filter downwards.

FINALIZE INSTALLATION

Ŷ5HPRYHDOOSDFNDJLQJPDWHULDOV

Ŷ5HIHUWRWKH2ZQHU¶V0DQXDOIRURSHUDWLQJ

instructions.

Mounting

screws

,QVWDOOVFUHZV

duct cover and into

ceiling bracket

Install

2 bottom

duct cover

screws

)LOWHU/RFNV

NOTE: The charcoal filter is not required for this installation.

14 49-80267 Rev. 4

Installation Instructions

WALL-MOUNTED INSTALLATION—RECIRCULATING

INSTALL FRAMING FOR HOOD

SUPPORT

IMPORTANT:)UDPLQJPXVWEHFDSDEOHRIVXSSRUWLQJ

OEV

,IGU\ZDOOLVSUHVHQWPDUNWKHVFUHZKROHORFDWLRQVIRU

the top mounting brackets. Remove the template.

Ŷ&XWDZD\HQRXJKGU\ZDOOWRH[SRVHYHUWLFDOVWXGV

at the bracket location indicated on the template.

Ŷ,QVWDOODKRUL]RQWDOVXSSRUWDWOHDVW´[´EHWZHHQ

two wall studs at the mounting screw location. The

horizontal support must be flush with the room side

of the studs. Use cleats behind both sides of the

support to secure to wall studs.

IMPORTANT: Reinstall drywall for an even mounting

surface.

DUCTWORK, WIRING LOCATIONS

Ŷ'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG

Ŷ/RFDWHWKHWHPSODWHSDFNHGZLWKWKHOLWHUDWXUH

Ŷ0HDVXUHIURPWKHIORRUWRWKHWRSRIWKHFRRNLQJ

VXUIDFH$GGKRRGLQVWDOODWLRQKHLJKWGHWHUPLQHGRQ

SDJH0DUNWKDWORFDWLRQ

Ŷ7DSHWKHWHPSODWHLQSRVLWLRQDORQJWKHSHQFLOHGOLQH

&+(&.72%(685(7+(7(03/$7(,6/(9(/

Ŷ8VHDOHYHOWRGUDZDOLQHVWUDLJKWXSIURPWKH

centerline on the template to the ceiling.

HOUSE WIRING LOCATION:

Ŷ7KHMXQFWLRQER[LVORFDWHGRQWKHWRSOHIWVLGHRI

the hood.

Ŷ:LULQJVKRXOGHQWHUWKHEDFNZDOO´WR´DERYH

WKHERWWRPRIWKHKRRGDQGZLWKLQ´RIWKHULJKW

side of the centerline.

REAR WALL TEMPLATE

49-80271 JR 07-04

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

ALIGN BOTTOM EDGE WITH

PENCIL LINE INDICATING

BOTTOM OF THE HOOD.

5-1/16"

9-5/8"

8-1/8"

2-1/16"

13-3/4"

12-3/4"

Ceiling

Centerline of

Installation

Space

View From Rear

Cleats

1" x 6" Min.

Mounting

Support

Centerline of

installation

space

View from rear

cleats

´[´PLQ

mounting

support

49-80267 Rev. 4 15

Installation Instructions

WALL-MOUNTED INSTALLATION—RECIRCULATING

PREPARE THE HOOD

Ŷ5HPRYHWKHKRRGIURPWKHER[5HPRYHSDFNDJLQJ

and tape.

Ŷ5HPRYHRQHVFUHZRQHDFKVLGHRIWKHFRYHURQ

the electrical panel. Lift off the cover and set aside

with screws.

Ŷ6WDQGWKHHOHFWULFDOSDQHOXSULJKW

Ŷ$OLJQWKHVFUHZKROHVLQWKH

bottom of the panel with the

holes on the base of the

hood at the front side.

Ŷ,QVWDOOVFUHZVSURYLGHG

INSTALL MOUNTING BRACKET

This vent hood must be secured to the horizontal

support or wall studs.

Ŷ:LWKWKHWHPSODWHWDSHGLQSODFHXVHDSXQFKWR

mark all mounting screw locations.

Ŷ'ULOO´SLORWKROHVDWWKHSXQFKHGORFDWLRQV

Ŷ5HPRYHWKHWHPSODWH

Ŷ7KHKROHVLQWKHVXSSRUWEUDFNHWKROHVPXVWHQWHU

studs or the horizontal support.

Ŷ8VHZRRGVFUHZVWRVHFXUHWKHPRXQWLQJEUDFNHWWR

the wall. The screws must engage wall studs or the

installed horizontal mounting support.

Ŷ&KHFNWREHVXUHWKDWWKHEUDFNHWLVOHYHO7KHUHLV

no way to level the hood after hanging it from this

bracket.

Remove 2 side

cover screws

Electrical

panel

Secure electrical

panel with 3

screws

-XQFWLRQER[

Inside screw

16 49-80267 Rev. 4

Installation Instructions

WALL-MOUNTED INSTALLATION—RECIRCULATING

SIZE AND CUT DUCT PIECE

(cont.)

Ŷ&XWWKHGXFWSLHFHWRVL]HDQG

slip onto the bottom of the duct

connector.

Ŷ8VHGXFWWDSHWRVHDODQGVHFXUH

the duct piece to the connector.

Ŷ3ODFHWKHDVVHPEO\RYHUWKHKRRG

outlet.

Ŷ+ROGWKHDVVHPEO\DJDLQVW

the ceiling. The penciled

centerline should show

through the slot in the

deflector. Mark the screw

holes on the sides of the

assembly.

Ŷ5HPRYHWKHDVVHPEO\DQG

drill 1/8” pilot holes into the

wall studs.

Ŷ(QODUJHKROHVWKDWGLGQRW

enter studs to 3/8” and tap

SODVWLFRUPHWDODQFKRUVLQWRWKHKROHVIOXVKZLWK

the wall.

Ŷ0RXQWWKHDVVHPEO\RQWRWKHKRRGRXWOHWSXVKXS

against the ceiling and install the screws provided.

CAUTION

Do not use sheet metal screws at

the hood flange connection. Doing so will prevent

proper damper operations. Seal connection with tape

only.

ATTENTION

1¶XWLOLVH]SDVGHYLVDXWRWDUDXGHXVHV

pour connecter le rabat de la hotte. En utilisant des

YLVYRXVHPSrFKH]OHERQIRQFWLRQQHPHQWGXYROHWGH

fermeture. cellez la connection uniquement avec du ruban

DGKpVLI

SIZE AND CUT DUCT PIECE

Ŷ+ROGXSSHUDLUGHIOHFWRUZLWKGXFWFRQQHFWRUDJDLQVW

the ceiling.

Ŷ0HDVXUHIURPWKHERWWRPRIWKHDLUGHIOHFWRUWRWKH

top of the hood as shown.

Reduce that dimension by

1” to facilitate installation.

The duct will cover and

overlap the deflector and

the hood outlets.

MOUNT THE HOOD

Ŷ/LIWWKHKRRGRQWRWKHPRXQWLQJEUDFNHW

Ŷ&KHFNWREHVXUHLWLVOHYHO

Ŷ,QVWDOOZRRGVFUHZVWKURXJKWKHKRRGDQGLQWRWKH

wall on each side of the mounting bracket.

Ŷ([WHQGWKHFDQRS\IRUZDUGIRUEHWWHUDFFHVVWRWKH

rear mounting screw holes.

Ŷ,QVWDOOZRRGVFUHZVRUIDVWHQHUVWKURXJKWKH

bottom of the hood into the wall.

Install a wood screw

on each side of the

mounting frame

Mounting

bracket

Install bottom

mounting screws

Duct length

Measure

length

49-80267 Rev. 4 

Installation Instructions

WALL-MOUNTED INSTALLATION—RECIRCULATING

CONNECT ELECTRICAL

Verify that power is turned off at the source.

WARNING

If house wiring is not 2-wire with

DJURXQGZLUHDJURXQGPXVWEHSURYLGHGE\WKH

LQVWDOOHU:KHQKRXVHZLULQJLVDOXPLQXPEHVXUH

WRXVH8/DSSURYHGDQWLR[LGDQWFRPSRXQGDQG

aluminum-to-copper connectors.

AVERTISSEMENT

Si la maison n’est pas câblee avec

GHX[ILOVHWXQILOGHWHUUHO¶LQVWDOODWHXUGRLWLQVWDOOHUXQILOGH

WHUUH4XDQGOHVILOVVRQWHQDOXPLQLXPLOIDXWSUHQGUHVRLQ

d’utiliser des connecteurs aluminium à cuivre avec une pâte

DQWLR[\GDQWHDSSURXYpHSDU8/

Ŷ5HPRYHMXQFWLRQER[FRYHUDQGNQRFNRXW

Ŷ8VHDFRQGXLWFRQQHFWRUWRVHFXUHWKHFRQGXLWWR

WKHMXQFWLRQER[

Ŷ&RQQHFWZKLWHOHDGVWREUDQFKFLUFXLWZKLWHOHDG

Ŷ&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG

Ŷ&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQ

lead or bare ground lead.

Ŷ6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFK

electrical connector.

Ŷ3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU%H

sure wires are not pinched.

Ŷ6HFXUHHOHFWULFDOSDQHOFRYHUZLWKRULJLQDOVFUHZV

INSTALL DUCT COVERS

Ŷ3ODFHWKHGHFRUDWLYHGXFW

covers on top of the hood.

NOTE: The inside piece has vent

holes on one end intended for

use when the hood is installed for

recirculating purposes. Be sure

the vented end is at the top; the

vent holes will be visible in this

installation.

The inside duct piece must slip

into the folded ends on the outer

section.

Ŷ([WHQGWKHLQQHUGXFWSLHFHXSZDUGVWRWKHFHLOLQJ

mounted air deflector.

Ŷ6HFXUHWKHGXFWFRYHUWRWKHDLUGHIOHFWRUGULYLQJ

one screw on each side.

Ŷ/RFDWHWKHVFUHZKROHVRQWKHERWWRPRXWVLGHHGJH

of the hood.

Ŷ6HFXUHWKHORZHUGXFWFRYHUWRWKHKRRGE\

installing 2 screws from the bottom of the hood into

the duct cover.

Mounting

screws

Vent

holes

Install

2 bottom

duct cover screws

,QVWDOOVFUHZV

duct cover and into

ceiling bracket

18 49-80267 Rev. 4

Installation Instructions

WALL-MOUNTED INSTALLATION—RECIRCULATING

INSTALL FILTERS

Charcoal filter

Ŷ5HPRYHSURWHFWLYHILOPVRQWKHILOWHUV

Ŷ,QVHUWWKHEODFNFKDUFRDOILOWHULQWRWKHFHQWHU

opening.

Metal grease filters

Ŷ7LSILOWHUVLQWRWKHVORWVDWWKHUHDURIWKHRSHQLQJ

Lift the filter lock and pull forward until the filter rests

in the slots.

Ŷ,QVWDOOERWKPHWDOJUHDVHILOWHUV

Ŷ7RUHPRYHWKHILOWHUVSUHVVLQZDUGVRQWKHKDQGOH

and pull the filter downwards.

FINALIZE INSTALLATION

Ŷ5HPRYHDOOSDFNLQJPDWHULDO

Ŷ5HIHUWRWKH2ZQHU¶V0DQXDOIRURSHUDWLQJ

instructions.

)LOWHU/RFNV

49-80267 Rev. 4 

UNDER-CABINET INSTALLATION

Installation Instructions

CABINET REQUIREMENTS

This hood may be installed beneath a wall-mounted

cabinet.

Ŷ/RFDWHWKHWHPSODWHSDFNHGZLWKWKHOLWHUDWXUH

Ŷ,IWKHFDELQHWKDVEHHQLQVWDOOHGLWPXVWEH

removed so that wall framing supports can be

added.

7KHFDELQHWPXVWEHDWOHDVW´KLJKEHWZHHQWKH

bottom frame and the inside top. If the cabinet is not

´IURPERWWRPWRLQVLGHWRSDFXVWRPFDELQHWRU

modifications to a different size cabinet and/or soffit

may be required to accommodate the hood housing.

Ŷ7KHFDELQHWPXVWEH´ZLGHDQGDWOHDVW´GHHS

Ŷ7KHFDELQHWPXVWEHILUPO\VHFXUHGWRZDOOVWXGV

or the added framing support and capable of

VXSSRUWLQJSRXQGV

DUCTWORK, WIRING LOCATIONS

Ŷ'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG

Ŷ/RFDWHWKH5HDU:DOO7HPSODWHSDFNHGZLWKWKH

literature.

Ŷ0HDVXUHIURPWKHIORRUWRWKHWRSRIWKHFRRNLQJ

VXUIDFH$GGWKHSUHGHWHUPLQHGKRRGLQVWDOODWLRQ

height. Mark that location.

Ŷ8VHDOHYHOWRGUDZDVWUDLJKWSHQFLOOLQHRQWKHZDOO

Ŷ7DSHWKHWHPSODWHLQSRVLWLRQDORQJWKHSHQFLOHGOLQH

Check to be sure the template is level.

Ŷ8VHWKHOHYHOWRGUDZDOLQHVWUDLJKWXSIURPWKH

centerline on the template to the ceiling.

Ŷ0HDVXUH´IURPWKHEDFNZDOOWRWKHFHQWHUOLQH

of a 6-1/2” hole on the ceiling.

NOTE: ,IGU\ZDOOLVQRWSUHVHQWDGGGU\ZDOOWKLFNQHVV

to the 3-3/4” dimension.

HOUSE WIRING LOCATION:

Ŷ7KHMXQFWLRQER[LVORFDWHGRQWKHWRSOHIWVLGHRI

the hood.

Ŷ:LULQJVKRXOGHQWHUWKHEDFNZDOO´WR´DERYH

WKHERWWRPRIWKHKRRGDQGZLWKLQ´RIWKHULJKW

VLGHRIWKHFHQWHUOLQH:LULQJVKRXOGHQWHUDWOHDVW´

above the bracket on the right side.

24” Min.

´0LQ

19-1/2"

11-3/4"

11"

´

11-3/4”

´

REAR WALL TEMPLATE

49-80271 JR 07-04

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

Drill 1/8"

Pilot Holes

ALIGN BOTTOM EDGE WITH

PENCIL LINE INDICATING

BOTTOM OF THE HOOD.

5-1/16"

9-5/8"

8-1/8"

2-1/16"

13-3/4"

12-3/4"

Ceiling

3-3/4” centerline

to wall

Top frame mounting

screw locations

 49-80267 Rev. 4

Installation Instructions

UNDER-CABINET INSTALLATION

INSTALL FRAMING FOR HOOD

SUPPORT

IMPORTANT:)UDPLQJPXVWEHFDSDEOHRIVXSSRUWLQJ

OEV

,IGU\ZDOOLVSUHVHQWPDUNWKHVFUHZKROHORFDWLRQVIRU

the top mounting brackets. Remove the template.

Ŷ&XWDZD\HQRXJKGU\ZDOOWRH[SRVHYHUWLFDOVWXGV

at the bracket location indicated on the template.

Ŷ,QVWDOODKRUL]RQWDOVXSSRUWDWOHDVW´[´EHWZHHQ

two wall studs at the mounting screw location. The

horizontal support must be flush with the room side

of the studs. Use cleats behind both sides of the

support to secure to wall studs.

Ŷ5HLQVWDOOGU\ZDOO

Centerline of

Installation

Space

View From Rear

Cleats

1" x 6" Min.

Mounting

Support

Centerline of

installation

space

View from rear

cleats

´[´PLQ

mounting

support

PREPARE THE HOOD

Ŷ5HPRYHWKHKRRGIURPWKHER[5HPRYHSDFNDJLQJ

and tape.

Ŷ5HPRYHRQHVFUHZRQHDFKVLGHRIWKHFRYHURQ

the electrical panel. Lift off the cover and set aside

with screws.

Ŷ6WDQGWKHHOHFWULFDOSDQHOXSULJKW

Ŷ$OLJQWKHVFUHZKROHVLQWKH

bottom of the panel with the

holes on the base of the

hood at the front side.

Ŷ,QVWDOOVFUHZVSURYLGHG

Remove 2 side

cover screws

Electrical

panel

Secure electrical

panel with 3

screws

-XQFWLRQER[

Inside screw

Page is loading ...

GE ZV800SJSS Installation guide

GE ZV800SJSS Installation guide

GE ZV800SJSS Installation guide

Related papers

Other documents