GE ZV925SLSS Installation guide

Brand: GE

Model: ZV925SLSS

Type: Installation guide

INSTALLATION

INSTRUCTIONS

36” Island Chimney Vent Hood

ZV925

MONOGRAM.COM

2 49-80329 Rev. 5

Safety Information

READ AND SAVE THESE INSTRUCTIONS

BEFORE YOU BEGIN

Read these instructions completely and carefully.

Ŷ IMPORTANT — Save these instructions

for local inspector’s use.

Ŷ IMPORTANT — Observe all governing

codes and ordinances.

ŶNote to Installer — Be sure to leave these

instructions with the Consumer.

ŶNote to Consumer — Keep these instructions with

your Owner’s Manual for future reference.

ŶSkill Level — Installation of this appliance requires

basic mechanical and electrical skills.

ŶCompletion Time — 1 to 3 Hours.

Ŷ3URSHULQVWDOODWLRQLVWKHUHVSRQVLELOLW\RIWKHLQVWDOOHU

3URGXFWIDLOXUHGXHWRLPSURSHULQVWDOODWLRQLVQRW

covered under the warranty.

Ŷ)RU0RQRJUDPORFDOVHUYLFHLQ\RXUDUHDYLVLW

monogram.com.

Ŷ)RU0RQRJUDPVHUYLFHLQ&DQDGDYLVLWmonogram.ca

Ŷ)RU0RQRJUDP3DUWVDQG$FFHVVRULHVYLVLW

monogram.com/use-and-care/parts.

CAUTION

Due to the weight and size of these

vent hoods and to reduce the risk of personal injury

RUGDPDJHWRWKHSURGXFW TWO PEOPLE ARE

REQUIRED FOR PROPER INSTALLATION.

ATTENTION

À cause du poids et de la taille de

ces hottes et pour reduire le risque de blessures et

GHGRPPDJHVIL FAUT DEUX PERSONNES POUR

FAIRE L’INSTALLATION CORRECTEMENT.

WARNING

To reduce the risk of fire or electrical

VKRFNGRQRWXVHWKLVUDQJHKRRGZLWKDQ\H[WHUQDO

VROLGVWDWHVSHHGFRQWUROGHYLFH$Q\VXFKDOWHUDWLRQ

from original factory wiring could result in damage to

the unit and/or create an electrical safety hazard.

AVERTISSEMENT

3RXUUpGXLUHOHULVTXH

G¶LQFHQGLHRXGHFKRFpOHFWULTXHLOQHIDXWSDV

XWLOLVHUFHWWHKRWWHDYHFXQUpJXODWHXUGHYLWHVVH

pOHFWURQLTXHH[WHUQH7RXWHPRGLILFDWLRQGHFHW\SHGX

branchement d’usine peute endommager l’appareil ou

FUpHUXQULVTXHGHFKRFpOHFWULTXH

TO REDUCE THE RISK OF FIRE, USE ONLY

METAL DUCTWORK.

WARNING

725('8&(7+(5,6.2)),5(

(/(&75,&$/6+2&.25,1-85<723(56216

2%6(59(7+()2//2:,1*

$8VHWKLVXQLWRQO\LQWKHPDQQHULQWHQGHGE\WKH

PDQXIDFWXUHU,I\RXKDYHDQ\TXHVWLRQVFRQWDFW

the manufacturer.

%%HIRUHVHUYLFLQJRUFOHDQLQJWKHXQLWVZLWFKWKH

power off at the service panel and lock the service

disconnecting means to prevent the power from

EHLQJVZLWFKHGRQDFFLGHQWDOO\:KHQWKHVHUYLFH

GLVFRQQHFWLQJPHDQVFDQQRWEHORFNHGVHFXUHO\

IDVWHQDSURPLQHQWZDUQLQJGHYLFHVXFKDVDWDJ

to the service panel.

AVERTISSEMENT

32855e'8,5(/(5,648(

'¶,1&(1',('(&+2&e/(&75,48(28'(

%/(6685(6,/)$872%6(59(5/(65(*/(6

68,9$17(6

$8WLOLVHUFHWDSSDUHLOXQLTXHPHQWGHODPDQLpUH

SUpYXHSDUOHIDEULFDQW(QFDVGHTXHVWLRQ

consulter le fabricant.

%$YDQWWRXWHLQWHUYHQWLRQRXQHWWR\DJHFRXSHU

O¶DOLPHQWDWLRQpOHFWULTXHDXGLVMRQFWHXUHWYHUURXLOOHU

OHSDQQHDXGXGLVMRQFWHXUSRXUpYLWHUODPLVHVRXV

tension accidentelle. S’il n’est pas possible de

YHUURXLOOHUOHSDQQHDXGXGLVFRQFWHXUDWWDFKHUXQ

SODFDUGRXXQHpWLTXHWWHWUpVYLVLEOHDXSDQQHDX

Ŷ)RUJHQHUDOYHQWLODWLQJXVHRQO\'RQRWXVHWRH[KDXVW

KD]DUGRXVRUH[SORVLYHPDWHULDOVRUYDSRUV

Ŷ6WUXFWXUDOIUDPLQJLQVWDOODWLRQZRUNDQGHOHFWULFDO

wiring must be done by qualified person(s) in

accordance with all applicable codes and standards

including fire-rated construction.

Ŷ6XIILFLHQWDLULVQHHGHGIRUSURSHUFRPEXVWLRQDQG

H[KDXVWLQJRIJDVHVWKURXJKWKHIOXHFKLPQH\RIIXHO

EXUQLQJHTXLSPHQWWRSUHYHQWEDFNGUDIWLQJ)ROORZ

the heating equipment manufacturer’s guidelines

and safety standards such as those published by

WKH1DWLRQDO)LUH3URWHFWLRQ$VVRFLDWLRQ1)3$DQG

WKH$PHULFDQ6RFLHW\IRU+HDWLQJ5HIULJHUDWLRQDQG

$LU&RQGLWLRQLQJ(QJLQHHUV$6+5$(DQGWKHORFDO

FRGHDXWKRULWLHV:KHQDSSOLFDEOHLQVWDOODQ\PDNHXS

(replacement) air system in accordance with local

EXLOGLQJFRGHUHTXLUHPHQWV9LVLW*($SSOLDQFHVFRP

for available makeup air solutions.

Ŷ/RFDOFRGHVYDU\,QVWDOODWLRQRIHOHFWULFDOFRQQHFWLRQV

and grounding must comply with applicable codes.

,QWKHDEVHQFHRIORFDOFRGHVWKHYHQWVKRXOGEH

LQVWDOOHGLQDFFRUGDQFHZLWK1DWLRQDO(OHFWULFDO&RGH

$16,1)3$RUODWHVWHGLWLRQ

CAUTION

To reduce risk of fire and to properly

H[KDXVWDLUEHVXUHWRGXFWDLURXWVLGH²GRQRWYHQW

H[KDXVWDLULQWRVSDFHVZLWKLQZDOOVRUFHLOLQJVRULQWR

DWWLFVFUDZOVSDFHVRUJDUDJHV

ATTENTION

Il faut prendre soin d’installer

XQFRQGXLWYHUVO¶H[WpULHXUSRXUUpGXLUHOHULVTXH

G¶LQFHQGLHHWSRXYRLUpYDFXHUO¶DLUFRUUHFWHPHQW,O

QHIDXWSDVpYDFXHUO¶DLUFRUUHFWHPHQW,OQHIDXWSDV

pYDFXHUO¶DLUGDQVO¶HVSDFHHQWUHOHVSDURLVG¶XQPXU

XQSODIRQGRXXQJUHQLHUXQHVSDFHVDQLWDLUHRXXQ

garage.

49-80329 Rev. 5 3

Design Information

CONTENTS

Design Information

3URGXFW'LPHQVLRQV ...................................................... 3

Advance Planning

$GYDQFH3ODQQLQJ ........................................................ 4

3RZHU6XSSO\ ...............................................................4

'XFW)LWWLQJV ................................................................ 5

Installation Preparation

Tools and Materials Required ....................................... 6

5HPRYHWKH3DFNDJLQJ ................................................ 6

Installation Height ......................................................... 

3DUWV3URYLGHG .............................................................. 8

Installation Preparation

Construct Ceiling Support ............................................. 

Installation Instructions—Vented to the Outside

6WHS0RXQW7HPSODWH .............................................. 12

6WHS$GMXVW)UDPH+HLJKW ....................................... 12

6WHS&XW'XFWWR/HQJWKIRU9HQWHG,QVWDOODWLRQ...... 13

6WHS,QVWDOOWKH6XSSRUW)UDPH ............................... 13

6WHS,QVWDOO+RRG$WWDFKPHQW6FUHZV ..................... 13

6WHS0RXQWWKH+RRGRQWRWKH6XSSRUW .................. 14

6WHS&RQQHFW&DEOHV .............................................. 14

6WHS&RQQHFW(OHFWULFDO ........................................... 15

6WHS3UHSDUHWKH'XFW&RYHUV ................................ 16

6WHS,QVWDOO8SSHU'XFW&RYHU .............................. 16

6WHS,QVWDOO/RZHU'XFW&RYHU .............................. 

6WHS,QVWDOO'XFW&RYHU7ULP ................................. 

6WHS,QVWDOO0HWDO)LOWHU.......................................... 

6WHS)LQDOL]H,QVWDOODWLRQ ....................................... 

Installation Instructions—Recirculating

6WHS0RXQW7HPSODWH .............................................. 18

6WHS$GMXVW)UDPH+HLJKW ....................................... 18

6WHS,QVWDOO$LU'HIOHFWRU&XW'XFW

for Recirculating Operation ............................. 

6WHS,QVWDOO8SSHU6XSSRUW)UDPH .......................... 

6WHS,QVWDOO/RZHU6WUXFWXUHWR8SSHU6WUXFWXUH ..... 

6WHS,QVWDOO%ORZHU0RWRU ........................................ 

6WHS,QVWDOO+RRG$WWDFKPHQW6FUHZV ..................... 

6WHS0RXQWWKH+RRGRQWRWKH6XSSRUW .................. 

6WHS&RQQHFW&DEOHV .............................................. 21

6WHS&RQQHFW(OHFWULFDO ......................................... 21

6WHS3UHSDUHWKH'XFW&RYHUV .............................. 22

6WHS,QVWDOO8SSHU'XFW&RYHU .............................. 22

6WHS,QVWDOO/RZHU'XFW&RYHU .............................. 22

6WHS,QVWDOO'XFW&RYHU7ULP ................................. 23

6WHS,QVWDOO)LOWHUV .................................................. 23

6WHS)LQDOL]H,QVWDOODWLRQ ....................................... 23

PRODUCT DIMENSIONS

These vent hoods are supplied with a support frame for

FHLOLQJKHLJKWVRI¶´WR¶´

Decorative duct covers conceal the ductwork running

from the top of the hood to the ceiling.

=;DFFHVVRU\LVDYDLODEOHIRUFHLOLQJKHLJKWVRI

¶´WR¶´

NOTE: Installation height should be measured from the

cooking surface to the bottom of the outer glass portion

of the hood.

7KLVKRRGPXVWEHLQVWDOOHG´PLQDQG´PD[

above the cooking surface. The cooking surface should

EHDWOHDVW´DERYHWKHIORRU

7KLVKRRGPD\EHYHQWHGWRWKHRXWGRRUVRULWFDQEH

installed for recirculating operation.

This hood can be installed over any Monogram electric

or gas cooktop. It cannot be installed over a Monogram

3URIHVVLRQDOFRRNWRSRUUDQJH

 7KHVXSSOLHGGXFWFRYHUILWV¶´WR¶FHLOLQJKHLJKWV

)RU¶´WR¶´FHLOLQJVRUGHU=;

27 9/16"

3 1/4"

35 7/8"

*Height

Ceiling

2 3/4"

*Height to

ceiling





24" min.*

PD[

36" min.

([DFWLQVWDOODWLRQ

height depends on

ceiling height.

4 49-80329 Rev. 5

Installation Preparation

ADVANCE PLANNING

Ductwork Planning

Ŷ7KHVHYHQWKRRGVDUHHTXLSSHGIRU´URXQG

ductwork.

Ŷ'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG

Ŷ3ODQWKHURXWHIRUYHQWLQJH[KDXVWWRWKHRXWGRRUV

Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH

)RUVDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOG

QRWH[FHHGIWHTXLYDOHQWOHQJWKIRUDQ\GXFW

configurations.

Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWWRFRPSXWHWKH

PD[LPXPSHUPLVVLEOHOHQJWKIRUGXFWUXQVWRWKH

outdoors.

Ŷ8VHULJLGPHWDOGXFWZRUNRQO\

Ŷ,QVWDOODURRIFDSZLWKGDPSHUDWWKHH[WHULRU

opening. Order the cap and any transitions needed

in advance.

Ŷ:KHQDSSOLFDEOHLQVWDOODQ\PDNHXSUHSODFHPHQW

air system in accordance with local building code

UHTXLUHPHQWV9LVLW*($SSOLDQFHVFRPIRUDYDLODEOH

makeup air solutions.

Ductwork Planning

Ŷ7KHVHYHQWKRRGVDUHKHDY\$GHTXDWHVWUXFWXUDO

support must be provided. The ceiling structure

must be capable of supporting the weight of the

hood and any inadvertent user contact loads

DSSUR[LPDWHO\SRXQGV7KHKRRGVXSSRUW

IUDPHZLOOEHVXSSRUWHGE\[FURVVIUDPLQJ

Ŷ,QVWDOODWLRQZLOOEHHDVLHULIWKHYHQWKRRGLVLQVWDOOHG

before the cooktop or countertop below is installed.

Accessory Duct Cover

Ŷ$OOPRGHOVDUHVKLSSHGZLWKDGXFWFRYHUIRUFHLOLQJ

KHLJKWVRI¶´WR¶

POWER SUPPLY

IMPORTANT - (Please read carefully)

WARNING

)253(5621$/6$)(7<7+,6

$33/,$1&(0867%(3523(5/<*5281'('

AVERTISSEMENT

3285'(65$,6216

'(6e&85,7e&(7$33$5(,/'2,7Ç75(

&255(&7(0(170,6¬/$7(55(

Remove house fuse or open circuit breaker before

beginning installation.

'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJZLWK

WKLVDSSOLDQFH)ROORZ1DWLRQDOHOHFWULFDOFRGHVRU

prevailing local codes and ordinances.

Electrical supply

7KHVHYHQWKRRGVPXVWEHVXSSOLHGZLWK9+]

DQGFRQQHFWHGWRDQLQGLYLGXDOSURSHUO\JURXQGHG

EUDQFKFLUFXLWDQGSURWHFWHGE\DRUDPSFLUFXLW

breaker or time delay fuse.

Ŷ:LULQJPXVWEHZLUHZLWKJURXQG

Ŷ,IWKHHOHFWULFDOVXSSO\GRHVQRWPHHWWKHDERYH

UHTXLUHPHQWVFDOODOLFHQVHGHOHFWULFLDQEHIRUH

proceeding.

Ŷ5RXWHKRXVHZLULQJLQWKHFHLOLQJDVFORVHWRWKH

LQVWDOODWLRQORFDWLRQDVSRVVLEOH$OORZDGGLWLRQDO

OHQJWKIURPFHLOLQJMRLVWVWRUHDFKWKHMXQFWLRQER[

on the bottom of the hood support frame.

Ŷ&RQQHFWWKHZLULQJWRWKHKRXVHZLULQJLQ

accordance with local codes.

Grounding instructions

The grounding conductor must be connected to

DJURXQGPHWDOSHUPDQHQWZLULQJV\VWHPRUDQ

equipment-grounding terminal or lead on the hood.

WARNING

The improper connection of the

equipment-grounding conductor can result in a risk

of electric shock. Check with a qualified electrician or

service representative if you are in doubt whether the

appliance is properly grounded.

AVERTISSEMENT

Le mauvais branchement du fil

GHPLVHjODWHUUHSHXWFDXVHUXQFKRFpOHFWULTXH(Q

FDVGHGRXWHFRQVXOWHUXQpOHFWULFLHQTXDOLILpRXXQ

WHFKQLFLHQSRXUGpWHUPLQHUVLO¶DSSDUHLOHVWjODWHUUH

=;DFFHVVRU\ duct cover is available

WRUHDFK1" WR1" ceiling heights. The

accessory should be ordered with the hood and be

on site before final framing and wall finishing.

49-80329 Rev. 5 5

Installation Preparation

DUCT FITTINGS

This Hood Must Use an 8” Round

Duct. It Can Transition to a

3-1/4” x 12” Duct.

8VHWKLVFKDUWWRFRPSXWHPD[LPXPSHUPLVVLEOHOHQJWKV

for duct runs to outdoors.

NOTE:'RQRWH[FHHGPD[LPXPSHUPLVVLEOHHTXLYDOHQW

lengths!

Maximum duct length: 100 foot for range hoods.

Flexible ducting

,IIOH[LEOHPHWDOGXFWLQJLVXVHGDOOWKHHTXLYDOHQWIHHW

YDOXHVLQWKHWDEOHVKRXOGEHGRXEOHG7KHIOH[LEOHPHWDO

GXFWVKRXOGEHVWUDLJKWDQGVPRRWKDQGH[WHQGHGDV

much as possible.

DO NOTXVHIOH[LEOHSODVWLFGXFWLQJ

NOTE: $Q\KRPHYHQWLODWLRQV\VWHPVXFKDVD

YHQWLODWLRQKRRGPD\LQWHUUXSWWKHSURSHUIORZRI

FRPEXVWLRQDLUDQGH[KDXVWUHTXLUHGE\ILUHSODFHVJDV

IXUQDFHVJDVZDWHUKHDWHUVDQGRWKHUQDWXUDOO\YHQWHG

systems. To minimize the chance of interruption of such

QDWXUDOO\YHQWHGV\VWHPVIROORZWKHKHDWLQJHTXLSPHQW

manufacturer’s guidelines and safety standards such

DVWKRVHSXEOLVKHGE\1)3$DQG$6+5$(:KHQ

DSSOLFDEOHLQVWDOODQ\PDNHXSUHSODFHPHQWDLUV\VWHP

in accordance with local building code requirements. Visit

GEAppliances.com for available makeup air solutions.

Duct Piece Dimensions

Equivalent

Length*

Quantity

Used

Total

Equivalent

Length

5RXQG

straight

1 ft. (per foot

length)

´[´

straight

1 ft. (per foot

length)

HOERZ IW

HOERZ IW

´[´

HOERZ

43 ft.

´[´

HOERZ

26 ft.

´[´

IODW

elbow

IW

´URXQGWR

´[´

transition

2 ft.

´[´

WR´URXQG

transition

5 ft.

´URXQGWR

´[´

WUDQVLWLRQ

elbow

6 ft.

´[´

WR´URXQG

WUDQVLWLRQ

elbow

13 ft.

Round wall

cap with

damper

32 ft.

´[´

wall cap with

damper

IW

Round roof

cap

44 ft.

$FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFWILWWLQJ

equivalent. Equivalent length of duct pieces

DUHEDVHGRQDFWXDOWHVWVFRQGXFWHGE\*(

$SSOLDQFHV(YDOXDWLRQ(QJLQHHULQJDQGUHIOHFW

requirements for good venting performance

with any ventilation hood.

Total Duct Run

6 49-80329 Rev. 5

Installation Preparation

TOOLS AND MATERIALS REQUIRED

(NOT SUPPLIED)

REMOVE THE PACKAGING

CAUTION

/,)77+(+22'2872)7+(%2;

%<7+(&(17(50(7$/3257,21'2127/,)7%<

7+(*/$666,'(6

ATTENTION

/(9(=/$+277(¬/¶(;7e5,(85

'(/$%2Ì7(3$5/$3257,210e7$/&(175$/

1(/(9(=3$63$5/(6&Ð7e6'(9(55(

CAUTION

:HDUJORYHVWRSURWHFWDJDLQVW

sharp edges.

ATTENTION

3RUWH]GHVJDQWVSRXUpYLWHUOHV

EOHVVXUHVFDXVpHVSDUOHVWUDQFKDQWV

Ŷ*UDVSWKHKRRGE\WKHPHWDOLQVHUWLQWKHFHQWHUDQG

OLIWVWUDLJKWXSDQGRXWRIWKHER[

Ŷ5HPRYHDQGSURSHUO\GLVFDUGWKHSODVWLFZUDSSLQJ

Ŷ5HPRYHSDUWVER[GXFWFRYHUVDQGRWKHUSDFNDJLQJ

3HQFLODQGWDSHPHDVXUH

3OLHUV

9+]RU$PS

2-wire with ground. properly

grounded branch circuit.

Key hole saw

:LUHFXWWHUVWULSSHU

Step ladder

Metal snips

Saber saw

or sawsall

:LUHQXWV

3KLOOLSVDQG

flat blade

screwdrivers

Strain relief for

junction cover.

Spirit level

)ODVKOLJKW

Safety glasses

8" round metal

GXFWOHQJWKWR

suit installation.

Duct tape

3/8" swivel

socket or pivoting

KH[VRFNHWZLWK

H[WHQVLRQV

Carpenter’s square

Hammer

Electric or battery-operated drill

DQGELWV3KLOOLSVDQGIODW

blade screwdriver bits.

49-80329 Rev. 5 

Installation Preparation

DETERMINE INSTALLATION HEIGHT

Ŷ'HFRUDWLYHGXFWFRYHUVDUHSURYLGHGWRFRQFHDOWKH

ductwork running to the ceiling.

Ŷ7KLVKRRGFDQEHLQVWDOOHGIRUUHFLUFXODWLQJ

RSHUDWLRQ1RNLWVUHTXLUHG

7KHKRRGLQVWDOODWLRQKHLJKWIURPWKHFRRNLQJVXUIDFH

WRWKHERWWRPRIWKHKRRGGHSHQGVXSRQFHLOLQJ

height.

)RURSWLPXPSHUIRUPDQFHWKHKRRGPXVWEH´PLQ

DQG´PD[DERYHWKHFRRNLQJVXUIDFH

Use the chart on this page to accurately determine

LQVWDOODWLRQKHLJKWDQGVXSSRUWIUDPHDGMXVWPHQWDQG

WRVHOHFWWKHFRUUHFWVL]HWRSWULPSLHFH$%&RU'

=;$FFHVVRU\'XFWFRYHULQFOXGHVD´

long duct cover and 3 sets of duct cover top trim

SLHFHVODEHOHG()*

Ceiling

Height

Possible Hood

Installation

Height (inches)

Mounting Frame

Height (inches)

Trim

Needed

 26  $

8’   $

 24 34 1/2 B

 28  $

 25 34 1/2 B

   $

3" 26 34 1/2 B

   $

  34 1/2 B

 24 38 1/2 C

 28 34 1/2 B

 25 38 1/2 C

  34 1/2 B

 26 38 1/2 C

  34 1/2 B

  38 1/2 C

 24 42 1/2 D

 28 38 1/2 C

 25 42 1/2 D

  38 1/2 C

 26 42 1/2 D

  38 1/2 C

  42 1/2 D

ZX92510 Accessory Duct Cover

 24 46 1/2 E

 28 42 1/2 D

 25 46 1/2 E

  42 1/2 D

 26 46 1/2 E

3"  42 1/2 D

  46 1/2 E

 24  )

 28 46 1/2 E

 25  )

  46 1/2 E

 26  )

  46 1/2 E

   )

 24 54 1/2 *

 28  )

 25 54 1/2 *

   )

 26 54 1/2 *

   )

  54 1/2 *

 28 54 1/2 *

8 49-80329 Rev. 5

Installation Preparation

PARTS PROVIDED

Locate the parts packed with the hood.

HARDWARE PACKAGE

Locate and check

contents. Screws

shown actual size.

$LUGHIOHFWRUIRU

recirculating installation

49-80406

Printed in Italy 04-06 JR

36≤ Hood

Template

8-1/2

≤ Dia.

Cut a 1≤Dia.

Wire Access

Hole

Cut a 1≤Dia.

Wire Access

Hole

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

10-1/16≤ to

Centerline

of Holes

7-1/16≤ to

Centerline

of Holes

FRONT OF HOOD

7-1/16≤ to

Centerline

of Holes

Template

6 ceiling

mounting

screws

VFUHZVWRWDO

• 24 support frame screws

KRRGDWWDFKPHQW

screws

• 2 upper duct cover

attachment screws

• 4 recirculating

deflector screws

• 2 duct cover bracket

attachment screws

12 sheet

metal

screws

Decorative duct covers

(14"ZLGHGHHSZKHQDVVHPEOHG

12 cage

nuts

Telescoping support

frame

Upper duct cover trim pieces

2 each of 4 sizes

1 charcoal filter for

recirculating installation

Stainless steel filter

24-3/4"

23-1/4"

2 Duct cover

brackets

2 thumb

screws

Lower duct cover trim pieces

Note: Some additional hardware/screws included.

49-80329 Rev. 5 

Installation Preparation

CONSTRUCT CEILING SUPPORT

Plan the Location of the Hood and Ductwork

ŶUse a plumb bob to check the location. The

countertop/cooktop below the hood must be

centered with the hood.

Ŷ7KHKRRGVKRXOGH[WHQGEH\RQGWKHIURQW

and rear edge of the cooking appliance.

ŶThe duct in the ceiling must be centered

over the cooktop.

Ceiling Support Structure

Ŷ$WWKHKRRGORFDWLRQLQVWDOO[FURVVIUDPLQJ

EHWZHHQFHLOLQJMRLVWVDVVKRZQ[¶VDUHUHTXLUHGWR

support the weight of the hood.)

Ŷ$UUDQJHFURVVIUDPLQJLQWKHFHLOLQJWRVXLWWKHH[LVWLQJ

structure.

Ŷ<RXUFHLOLQJMRLVWVZLOOEHOLNHRQHRIWKHIROORZLQJ

H[DPSOHV

Ceiling

Hood ducting

centerline

Cooktop

Countertop

)URQW



13-3/4"

Side view

$OLJQZLWKFHQWHU

of cooktop

Top view – ceiling joists parallel to front of hood



Install cross-framing

symmetrically over duct/

cooktop centerline

16" joist

spacing



´GXFW

)URQW

hood

[FURVV

framing

Cooktop

outline

$OLJQGXFWWR

center of cooktop

(;$03/($

 49-80329 Rev. 5

Installation Preparation

CONSTRUCT CEILING SUPPORT (Cont.)

Top view – ceiling joists run perpendicular to front of hood

Top view – ceiling joists at angle to front of hood

LQVWDOO

cross-framing

symmetrically over

duct/cooktop

centerline

16" joist

spacing



8" duct

)URQW

hood

[FURVV

framing

Cooktop

outline

$OLJQGXFW

to center of

cooktop

LQVWDOOFURVV

framing symmetrically over

duct/cooktop centerline

16" joist

spacing



8" duct

)URQW

hood

[FURVV

framing

Cooktop

outline

$OLJQGXFW

to center of

cooktop

(;$03/(%

(;$03/(&

49-80329 Rev. 5 11

Installation Preparation

CONSTRUCT CEILING SUPPORT (Cont.(

Ŷ6HFXUHHDFK[EORFNZLWKDWOHDVWIRXU

ZRRGVFUHZV´ORQJQRWVXSSOLHG8VHZRRG

screws total for the two supports.

ŶThe cross framing must be accurately aligned to

assure correct positioning of the hood.

ŶThe cross framing must be level in all directions.

Check with a spirit level and adjust if necessary.

IMPORTANT: The ceiling structure must be capable of

VXSSRUWLQJWKHZHLJKWRIWKHKRRGDSSUR[LPDWHO\

pounds) and any inadvertent user contact loads. The

KRRGVXSSRUWIUDPHZLOOEHVXSSRUWHGE\WKH[FURVV

framing.

Ductwork for Installations Vented to the Outdoors

Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH

)RUVDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOGQRW

H[FHHGIHHWHTXLYDOHQWOHQJWKIRUDQ\GXFW

configuration.

Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWWRFRPSXWHWKH

PD[LPXPSHUPLVVLEOHOHQJWKIRUGXFWUXQVWRWKH

outdoors.

Ŷ7KLVYHQWKRRGPXVWXVH´URXQGULJLGGXFW

Ŷ,QVWDOOWKHKRXVHGXFWZRUNWRUXQKRUL]RQWDOO\EHWZHHQ

ceiling joists or straight up through the roof.

Finish the Ceiling

Ŷ)LQLVKWKHFHLOLQJVXUIDFH%HVXUHWRPDUNORFDWLRQRI

the ceiling joists and cross framing. Check to be sure

the ceiling is level; use shims if necessary.

Ceiling Joint

2x4

10"

Duct

Vent Straight Up

Through The Ceiling

8" Duct

Ceiling joist

[

Vent straight up through

the ceiling

Ceiling

Joist

10-3/4

2x 4

Cross Framing

Height

Adjustment

Screw Holes

7-1/16"

[PLQFURVVIUDPLQJ

Ceiling

joist





Height

adjustment

screws

12 49-80329 Rev. 5

Installation Instructions

MOUNT TEMPLATE

Ŷ$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQG

tape in place.

– Be sure the template is oriented correctly with the

front of the hood.

Ŷ8VHDSOXPEEREWREHVXUHWKHPRXQWLQJKROHV

will provide parallel alignment with the countertop

below.

Ŷ&HQWHUSXQFKDOOKROHORFDWLRQV

Ŷ'ULOOSLORWKROHVLQWKHVFUHZORFDWLRQV8VHD´

ELWDQGGULOODSSUR[LPDWHO\´GHHS

Ŷ'ULYHKH[KHDGZRRGVFUHZVLQWRWKHFHQWHURIWKH

FHLOLQJMRLVWVDQGFURVVIUDPLQJ/HDYHD´JDSWR

allow the screw head to engage the keyhole slots on

the support frames.

Ŷ&XWWKH´GXFWRSHQLQJWKURXJKWKHVKHHWURFN

ADJUST FRAME HEIGHT

Ŷ0HDVXUHH[DFWFHLOLQJKHLJKW

Ŷ)LQGWKHH[DFWIUDPHKHLJKWUHTXLUHG

RQWKHFKDUWRQSDJH

Ŷ5HPRYHVFUHZVRQHDFKRIWKH

sides of the frame to loosen the upper

VWUXFWXUHORZHUVWUXFWXUHDQGEORZHU

motor.

Ŷ$GMXVWWKHKHLJKW³;´DFFRUGLQJWR

WKHFKDUWRQSDJH8VHDWRWDORI

32 screws (8 screws on each side)

WRVHFXUHWKHXSSHUVWUXFWXUHORZHU

structure and blower/motor together.

INSTALLATION—VENTED TO THE OUTSIDE

1/4" Gap

49-80406

Printed in Italy 04-06 JR

36≤ Hood

Template

8-1/2

≤

Dia.

Cut a 1≤Dia.

Wire Access

Hole

Cut a 1≤Dia.

Wire Access

Hole

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

10-1/16≤ to

Centerline

of Holes

7-1/16≤ to

Centerline

of Holes

FRONT OF HOOD

7-1/16≤ to

Centerline

of Holes

24"min.

PD[

36"min.

)UDPH

height

2-3/4"

Ceiling

height

49-80329 Rev. 5 13

Installation Instructions

CUT DUCT TO LENGTH FOR

VENTED

Ŷ0HDVXUHIURPKRXVH

GXFWWRH[KDXVW

opening.

Ŷ&XWWKH´GXFWOHQJWK

to size.

Ŷ6OLSGXFWRYHUWKH

H[KDXVWRSHQLQJ

Ŷ6HDOWKHFRQQHFWLRQ

with duct tape.

INSTALL HOOD ATTACHMENT

SCREWS

Ŷ,QVWDOOKRRGDWWDFKPHQWVFUHZVLQWKHERWWRPRI

WKHVXSSRUWDVVKRZQ/HDYH´JDSEHWZHHQ

screw head and support flange.

INSTALL THE SUPPORT FRAME

Ŷ5DLVHWKHVXSSRUWWRZDUG

the ceiling.

Ŷ7KUHDGWKHKRXVHZLULQJ

through one of the large

KROHVSUHIHUDEO\RQWKHOHIW

side.

Ŷ&DUHIXOO\HQJDJHWKH

ceiling mounting screws to

WKHNH\KROHVORWV$1'WKH

house duct in the top of the

frame.

Ŷ7LJKWHQWKHPRXQWLQJ

screws against the frame.

Ŷ,QVWDOOVDIHW\VFUHZV

Ŷ8VHGXFWWDSHWRVHDOWKH

duct connection at the top.

INSTALLATION—VENTED TO THE OUTSIDE

Duct

House

duct

)UDPH

height

Duct

length

Duct

Safety screws

Keyhole

slots

House wiring

Keyhole

slots

Install 4

attachment

screws

14 49-80329 Rev. 5

Installation Instructions

INSTALLATION—VENTED TO THE OUTSIDE

CONNECT CABLES

Ŷ-RLQWKHWZRFDEOHFRQQHFWRUVDWWKHIURQWRIWKH

hood. Secure the cables behind the retainer clip.

MOUNT THE HOOD ONTO THE

SUPPORT

WARNING

2 people are required to lift and

position the hood onto the mounting bracket.

AVERTISSEMENT

,IIDXWGHX[SHUVRQQHVSRXU

lever et mettre en place la hotte sur le support de

montage.

Ŷ/LIWWKHKRRGWRWKHERWWRPRIWKHVXSSRUWHQJDJLQJ

the keyhole slots to the 4 mounting screws.

Ŷ7LJKWHQWKHPRXQWLQJVFUHZV

Ŷ,QVWDOODGGLWLRQDOVFUHZVDVVKRZQ

Install

6 screws

Retainer clip

To lights

To control

panel

49-80329 Rev. 5 15

Installation Instructions

CONNECT ELECTRICAL

Verify that power is turned off at the source.

WARNING

If house wiring is not 2-wire with a

JURXQGZLUHDJURXQGPXVWEHSURYLGHGE\WKHLQVWDOOHU

:KHQKRXVHZLULQJLVDOXPLQXPEHVXUHWRXVH8/

DSSURYHGDQWLR[LGDQWFRPSRXQGDQGDOXPLQXPWR

copper connectors.

AVERTISSEMENT

Si le câblage de la maison n’est

SDVGXW\SHjGHX[ILOVDYHFXQILOGHWHUUHO¶LQVWDOODWHXU

GRLWIRXUQLUXQFLUFXLWGHWHUUH4XDQGOHVILOVGHOD

PDLVRQVRQWHQDOXPLQLXPLOSUHQGUHVRLQG¶XWLOLVHUGHOD

SkWHDQWLR[LGDWLRQDSSURXYpHSDU8/HWGHVFRQQHFWHXUV

pour l’aluminium-cuivre.

Ŷ5HPRYHMXQFWLRQER[FRYHUDQGNQRFNRXWRQWKH

left side.

Ŷ6HFXUHWKHKRXVHZLULQJWRWKHMXQFWLRQER[ZLWK

a strain relief.

Ŷ

Connect white leads to branch circuit white lead.

Ŷ&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG

Ŷ&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQ

lead or bare ground lead.

Ŷ6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFK

electrical connector.

Ŷ3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU

Be sure wires are not pinched.

Ŷ6HFXUH-%R[FRYHUZLWKRULJLQDOVFUHZ

Knockout

-%R[FRYHU

INSTALLATION—VENTED TO THE OUTSIDE

-%R[FRYHU

House wiring

16 49-80329 Rev. 5

Installation Instructions

PREPARE THE DUCT COVERS

Ŷ5HPRYHWKHSODVWLFSURWHFWLYHFRYHULQJRQDOOGXFW

pieces.

Ŷ,QVWDOOFDJHQXWVRQHDFKLQVLGHVHFWLRQRIWKHWRS

duct cover. The cage nuts fit into the rectangular

VORWVFOLSVIDFLQJRXWZDUG

Ŷ,QVWDOOFDJHQXWVRQHDFKVLGHRIWKHORZHUGXFW

covers.

INSTALL UPPER DUCT COVER

Ŷ3ODFHWKHWDOOGXFWFRYHUVRQWRWKHWRSRIWKHKRRG

This section has venting holes on one end.

NOTE: If you are installing this hood for

UHFLUFXODWLQJRSHUDWLRQSODFHWKHGXFWFRYHUVRQWR

the hood with the venting slots at the top.

,IWKHKRRGLVYHQWHGWRWKHRXWVLGHWKHKROHV

should be positioned on the bottom.

Ŷ6HFXUHWKHVLGHVZLWKVFUHZVLQVWDOOHGWKURXJKWKH

cage nuts.

Ŷ5DLVHWKHDVVHPEOHGGXFWFRYHUVWRWKHWRSDJDLQVW

the ceiling.

Ŷ0DWFKPRXQWLQJKROHVRQHRQHDFKVLGH,QVWDOO

screws through the duct and into the support.

INSTALLATION—VENTED TO THE OUTSIDE

Support

frame

3ODQ

diagram

Rectangular slots

1XW

Top

sections

Top

sections

49-80329 Rev. 5 

Installation Instructions

INSTALL LOWER DUCT

Ŷ3ODFHUHDUGXFWFRYHURQWRWKHKRRG

Ŷ3ODFHIURQWGXFWFRYHURQWRWKHKRRG

Ŷ6HFXUHWKHGXFWFRYHUVZLWKVFUHZV

INSTALL DUCT COVER TRIM

Ŷ,QVWDOOVLGHEUDFNHWVWRVHFXUHWKHORZHUGXFWWLJKWO\

against the upper duct.

Ŷ+ROGORZHUWULPVWULSVQDUURZSLHFHVZLWKKRRNV

IDFLQJGRZQ3ODFHWKHKRRNVLQVLGHWKHVORWVDQG

slide downward.

Ŷ6HOHFWWKHFRUUHFWVL]HXSSHUWULPVWULSVDQGSUHVV

into place.

INSTALL METAL FILTER

IMPORTANT:&KHFNWREHVXUHWKDWWKHPDLQ21

2))VZLWFKQH[WWRWKHPRWRULVLQWKH21SRVLWLRQ

Ŷ7LSWKHILOWHULQWRWKHOHIWRUULJKWVLGHRIWKHRSHQLQJ

Lift the filter to the opposite side and into the filter

lock.

Ŷ7RUHPRYHWKHILOWHUSXOOWKHILOWHUORFNGRZQZDUG

FINALIZE INSTALLATION

Ŷ5HPRYHDOOWDSHDQGSDFNLQJPDWHULDO

Ŷ5HIHUWRWKH2ZQHU¶V0DQXDOIRURSHUDWLQJ

instructions.

INSTALLATION—VENTED TO THE OUTSIDE

)URQWERWWRPGXFWFRYHUVHFWLRQ

(snap into place and secure

with 6 screws – 3 per side)

3ODQGLDJUDPWRS

view

)URQWERWWRPGXFW

cover sections

Upper

trim

strip

Lower

trim strip

Lower

trim

strip

Upper

trim

strip

Side

bracket

)LOWHUORFN

18 49-80329 Rev. 5

Installation Instructions

MOUNT TEMPLATE

Ŷ$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQG

tape in place.

– Be sure the template is oriented correctly with the

front of the hood.

Ŷ8VHDSOXPEEREWREHVXUHWKHPRXQWLQJKROHV

will provide parallel alignment with the countertop

below.

Ŷ&HQWHUSXQFKDOOKROHORFDWLRQV

Ŷ'ULOOSLORWKROHVLQWKHVFUHZORFDWLRQV8VHD´

ELWDQGGULOODSSUR[LPDWHO\´GHHS

Ŷ'ULYHKH[KHDGZRRGVFUHZVLQWRWKHFHQWHURIWKH

FHLOLQJMRLVWVDQGFURVVIUDPLQJ/HDYHD´JDSWR

allow the screw head to engage the keyhole slots on

the support frames.

Ŷ&XWWKH´GXFWRSHQLQJWKURXJKWKHVKHHWURFN

ADJUST FRAME HEIGHT

Ŷ0HDVXUHH[DFWFHLOLQJKHLJKW

Ŷ)LQGWKHH[DFWIUDPHKHLJKWUHTXLUHG

RQWKHFKDUWRQSDJH

Ŷ5HPRYHVFUHZVRQHDFKRIWKH

sides of the frame to loosen the upper

VWUXFWXUHORZHUVWUXFWXUHDQGEORZHU

motor.

Ŷ$GMXVWWKHKHLJKW³;´DFFRUGLQJWR

WKHFKDUWRQSDJH8VHDWRWDORI

32 screws (8 screws on each side)

WRVHFXUHWKHXSSHUVWUXFWXUHORZHU

structure and blower/motor together.

INSTALLATION—VENTED TO THE OUTSIDE

1/4" Gap

49-80406

Printed in Italy 04-06 JR

36≤ Hood

Template

8-1/2

≤

Dia.

Cut a 1≤Dia.

Wire Access

Hole

Cut a 1≤Dia.

Wire Access

Hole

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

10-1/16≤ to

Centerline

of Holes

7-1/16≤ to

Centerline

of Holes

FRONT OF HOOD

7-1/16≤ to

Centerline

of Holes

24"min.

PD[

36"min.

)UDPH

height

2-3/4"

Ceiling

height

Mark

each

piece to

indicate

where

screw

holes

align.

NOTE: Low ceilings may require that the

lower portion of the support frame be removed.

The upper support frame may be secured

directly to the blower/motor. Refer to the

FKDUWRQSDJHIRU\RXUFHLOLQJKHLJKWDQG

to be sure the duct cover trim piece will fit.

49-80329 Rev. 5 

INSTALL AIR DEFLECTOR,

CUT DUCT FOR RECIRCULATING

OPERATION

Ŷ7HPSRUDULO\VOLGHWKHDLUGHIOHFWRU

into the support frame.

Ŷ0HDVXUHGXFWOHQJWKEHWZHHQ

the deflector and over the

H[KDXVWRSHQLQJ

Ŷ&XWGXFWSLHFHWROHQJWKDQG

set aside.

INSTALL UPPER SUPPORT

FRAME

Ŷ5DLVHWKHXSSHUVXSSRUW

toward the ceiling.

Ŷ7KUHDGWKHKRXVHZLULQJ

through one of the large

KROHVSUHIHUDEO\RQWKHOHIW

side.

Ŷ&DUHIXOO\HQJDJHWKHFHLOLQJ

mounting screws to the

keyhole slots in the top of

the frame.

Ŷ7LJKWHQWKHPRXQWLQJVFUHZVDJDLQVWWKHIUDPH

Ŷ,QVWDOOVDIHW\VFUHZV

Ŷ6OLGHDLUGHIOHFWRU

into the support

frame.

Ŷ6HFXUHWKHGHIOHFWRU

to the support with

4 screws.

Ŷ,QVWDOOWKHGXFW

piece to the bottom

of the deflector

and seal the

connection with

duct tape.

Installation Instructions

INSTALLATION—RECIRCULATING

)5217

Duct

length

Safety

screws

Keyhole

slots

House wiring

Keyhole

slots

 49-80329 Rev. 5

Installation Instructions

INSTALLATION—RECIRCULATING

INSTALL LOWER STRUCTURE TO

UPPER STRUCTURE

Ŷ6OLGHORZHUIUDPHLQWRWKH

upper frame. Match the

marked alignment holes.

Ŷ6HFXUHWKHXSSHUDQGORZHU

IUDPHZLWKVFUHZVRQ

each side of the frame.

INSTALL HOOD ATTACHMENT

SCREWS

Ŷ,QVWDOOKRRGDWWDFKPHQWVFUHZVLQWKHERWWRPRI

WKHVXSSRUWDVVKRZQ/HDYH´JDSEHWZHHQ

screw head and support flange.

MOUNT THE HOOD ONTO THE

SUPPORT

WARNING

2 people are required to lift and

position the hood onto the mounting bracket.

AVERTISSEMENT

,IIDXWGHX[SHUVRQQHVSRXU

lever et mettre en place la hotte sur le support de

montage.

Ŷ/LIWWKHKRRGWRWKHERWWRP

RIWKHVXSSRUWHQJDJLQJ

the keyhole slots to the 4

mounting screws.

Ŷ7LJKWHQWKHPRXQWLQJ

screws.

Ŷ,QVWDOO

additional

screws as

shown.

INSTALL BLOWER/MOTOR

Ŷ5DLVHWKHEORZHU

motor piece toward the

assembled frame.

Ŷ&DUHIXOO\UDLVHWKHPRWRUWR

the marked reference point

while making sure the duct

piece slips over the blower

outlet flange.

Ŷ6HFXUHWKHEORZHUPRWRUWR

WKHIUDPHXVLQJVFUHZV

4 on each side.

Ŷ8VHWDSHWRVHDOWKHGXFW

connection.

Install 4

attachment

screws

Install 6 screws

Page is loading ...

GE ZV925SLSS Installation guide

GE ZV925SLSS Installation guide

GE ZV925SLSS Installation guide

Related papers

Other documents