England's Stove Works 55TRPAH User manual

Brand: England's Stove Works

Model: 55TRPAH

Category: Stoves

Type: User manual

This manual is also suitable for

PELLETAUXILIARYHEATER



INSTALLATION&OPERATIONMANUAL

25‐PAH/55‐SHPAH/55‐TRPAH







 

REV.12/2011



CAUTION

Pleasereadthisentiremanualbeforeinstallationanduseofthispelletfuel‐

burningappliance.Keepchildren,furniture,fixturesandallcombustiblesaway

fromanyheatingappliance.

SAFETYNOTICE

Failuretofollowtheseinstructionscanresultinpropertydamage,bodilyinjury

orevendeath.Foryoursafetyandprotection,followtheinstallation

instructionsoutlinedinthismanual.Contactyourlocalbuildingorfireofficials

aboutrestrictionsandinstallationinspectionrequirements(includingpermits)

inyourarea.

SAVETHESEINSTRUCTIO NS

ManufacturedBy:

England’sStoveWorks,Inc.

POBox206

Monroe

VA24574

Page | 2



WARNING:

 Useofoutsidecombustionairismandatorywiththisunit.

 Donotoperatewiththehopperopen;lidmustbeshut

andtightlylatchedduringoperation.

Retainforyourfiles



ModelNumber________________________

DateofPurchase_______________________

DateofManufacture____________________

SerialNumber_________________________



*Thisinformationcanbefoundonthesafetytagattachedtotheundersideofthe

hopperlid.Havethisinformationonhandifyouphone thefactoryoryourdealer

regardingthisproduct.

IMPORTANT:IFYOUHAVEAPROBLEMWITHTHISUNIT,DO

NOTRETURNITTOTHEDEALER.CONTACTTECHNICAL

SUPPORT@1‐800‐245‐6489

Note:England’sStoveWorksdoesnotrecommendusinga

pelletstoveasyouronlysourceofheat.

MobileHomeUse:

Thisfreestandingpelletunitisapprovedformobilehomeor

doublewideinstallationwiththeoutsidecombustionairhook‐

up.Seethe“Installation”sectionofthismanualfordetails

pertainingtomobilehomeinstallations.Mobilehome

installationmustbeinaccordancewiththeManufactured

HomeandSafet

Standard

(

HUD

)

,CFR3280,Part24.

Page | 3

TABLEOFCONTENTS



Introduction

 Introduction.................................4

Specifications

 HeatingSpecifications..................5

 Dimensions...................................5

 EPACompliance...........................5

Installation

 InstallationOverview...................6

 ClearancestoCombustibles.........7

 VentingIntroduction....................8

 VentingGuidelines.......................8

 AdditionalVentingInformation...9

 ApprovedVentingMethods

o ThroughtheWall...........10

o ThroughtheCeiling........11

o ExistingChimney............12

 MobileHomeInstallation..........13

 OutsideAirHook‐Up..................14

 FloorProtection.........................15

DailyOperation

 GettingStarted...........................16

 LightingaFire........................16‐17

 ControlBoardSettings...............18

 ErrorCodes................................19

 PowerFailure.............................20

 ThermostatInstallation..............21

 ThermostatOperation...............22

 OptionalAccessories..................22

Maintenance

 Daily

o ImportantNotes.............23

o DailyAshRemoval.....23‐24

o CleaningtheBurnpot.....24

 Monthly

o ImportantNotes.............25

o ExhaustChamber......25‐26

o VentingPipe...................26

 Yearly

o ImportantNotes.............27

o ExhaustBlower..............28

o ConvectionBlower.........29

o HopperFines..................29

o CheckingGaskets...........29

TroubleshootingGuide

 Troubleshooting....................30‐31

ReplacingComponents

 AugerMotor...............................32

 ConvectionBlower.....................33

 CombustionBlower...................33

 VacuumSensor..........................34

 Igniter.........................................34

 Gaskets.......................................35

 Finish..........................................35

 Glass...........................................36

 ControlBoard.............................37



WiringDiagram..........................38

IllustratedPartsDetail



 ExplodedPartsDiagram.............39

 PartsList.....................................40

Warranty

 WarrantyDetails...................41‐42

 WarrantyReg.Form..............43‐44



Page | 4

INTRODUCTION



ThankyouforpurchasingthisfineproductfromEngland’sStoveWorks!



England’sStoveWorkswasstarted,andisstillownedby,afamilythat

believesstronglyina“DoItYourself”spirit;that’sonereasonyou

foundthisproductatyourfavorite“DoItYourself”store.



Weintentionallydesign

andbuildourstovessothatanyhomeowner

canmaintaintheirunitwithbasictools,andwe’realwaysmorethan

happytoshowyouhowtodothejobaseasilyandasinexpensivelyas

possible.However,whileremainingsimple,ourstovesaredesignedto

performextremelyefficiently,helpingdelivermore

heatfromlessfuel.



PleaselookatourvastHelpsectiononourwebsiteandcallour

TechnicalSupportDepartmentat(800)245‐6489ifyouneedanyhelp

withyourunit.Wearenearlyalwaysableto“walkyouthrough”any

installationissues,repairs,problemsorotherquestionsthat

youmay

have.



Wishingyouyearsofefficient,qualityand“comfy”heating,



EVERYONEATENGLAND’SSTOVEWORKS



PleaseNote

:Whileinformationobtainedfromourwebsiteand

throughourTechnicalSupportlineisalwaysfreeofcharge,therewill

beaservicechargeincurredwithany“on‐site”repairsormaintenance

thatwemayarrange.



Thismanualencompassesallversionsofthe25‐PAH,includingthe55‐SHPAH,55‐

SPAHLand55‐TRPAH.However,forsimplicityofdescription,thestovewillbe

referredtobythegeneric25‐PAHdesignation.

Page | 5

SPECIFICATIONS



HeatingSpecifications



 HeatOutputRange**............................................11,000BTU/hr–25,000BTU/hr

 ApproximatePelletBurnRate**...............................................1.6lb/hr–4.0lb/hr

 MaximumBurnTime**..............................................................................72hours

 ApproximateSquareFootageHeated***.....................................800‐2000sq.ft.

 HopperCapacity.....................................................................................120pounds



Dimensions



EPAandSafetyComplianceSpecifications



 EPACompliance...........................................................................................Certified

 ParticulateEmissions..........................................................................1.55grams/hr

 Efficiency*...........................................................................................................78%

 TestedTo........................... ASTME1509,ULC/ORD‐C1482‐M1990&ULCS627‐00

*‐Thisunitwasnottestedforefficiency;theefficiencyshownisadefaultvaluenormallyattainedbysimilar,certifiedpelletburningappliances.

**‐Heatoutput,burnrateandmaximumburntimeareheavilydependentonthetypeofpelletsburnedinthestove;assuch,thesenumbers

mayvary.

***

‐Themaximumheatingcapacityofthisunitcanvarygreatlybasedonclimate,constructionstyle,insulationandamyriadofotherfactors.

UsethisinformationinconjunctionwithaBTUlosscalculationforyourhometodetermineifthisunitwillbesufficientforyourneeds.

12.125in.

5.5in.

24.25in.

24.25in.

31.3125in.

8.4375in.

7.00in.

Page | 6

INSTALLATION



InstallationOverview



Whenchoosingalocationforyournewstove,thereareamultitudeof

factorsthatshouldbetakenintoaccountbeforebeginningtheinstallation.



1. TrafficPatterns–Tohelppreventaccidents,thestoveshouldbeplaced

inalocationwhereitisoutofthewayofnormaltravel

throughthe

home.



2. HeatFlow–Whendecidingonalocationforthestove,considertheway

heatmovesthroughoutyourhome.Installthestovewhereyouneed

theheat;basementinstallationsoftendonotallowsuffic ient heatto

flowtotheupperfloorsandatopfloorinstallation

willnotallowany

heattoreachthefloorsbelow.Alwaysconsiderthatheatrisesandwill

takethepathofleastresistancewhileitisstillhot.



3. ExhaustLocation–Outsidewallsaregenerallythebestplacetoinstalla 

stove,sincetheyalloweasyexhaustandintakeair

installation(usingour

DuraVentAC‐3000Kit).Ifthereisnotafeasiblewaytoinstallthestove

onanoutsidewall,therearemethodsforventingthestoveupthrough

theroof,buttheytendtobemorecostlybecausetheyinvolvetheuse

ofmorepelletventpipe

andcanoftenmakeoutsideairinstallation

moredifficult.



4. WallConstruction–Locatingthestovesothattheexhaustsystemcan

passbetweenstudswillsimplifytheinstallationandeliminatetheneed

toreframeanysectionsofthewalltoaccommodatethewallthimble.



WARNING

 Donotstoreorusegasolineorotherflammablevaporsandliquidsinthevicinityof

thisoranyotherappliance.

 DoNotOverfire–Ifanyexternalpartstartstoglow,youareoverfiring.Reducefeed

rate.Overfiringwillvoidyourwarranty.

 Complywithallminimum

clearancestocombustiblesasspecified.Failuretocomply

mayresultinahousefire.

 Testedandapprovedforwoodpelletsonly.Burninganyotherfuelwillvoidyour

warranty.

Page | 7

INSTALLATION



ClearancestoCombustibles







UnittoSide

Wall

UnittoRear

Wall

Unitto

Corner



UnitTopto

Ceiling



Min.Ceiling

Height

Min.Alcove

Width

Max.Alcove

Depth

A B C D E F Notshown

12in. 6in. 6in. 28.5in. 60in. 48.25in. 24in.

304.8mm. 152.4mm. 152.4mm. 723.9mm. 1524mm. 1225.6mm. 609.6mm.

CAUTION

 Keepchildrenaway.

 Supervisechildreninthesameroomasthisappliance.

 Alertchildrenandadultstothehazardsofhightemperatures.

 DoNOToperatewithprotectivebarriersopenorremoved.

 Keepclothing,furniture,draperiesandothercombustiblesaway.

 InstallationMUSTcomplywithlocal,regional,stateandnationalcodesand

regulations.

 Consultlocalbuilding,fireofficialsorauthoritieshavingjurisdictionabout

restrictions,installationinspection,andpermits.

A

B

C

D

F

DONOTCONNECTTOANYAIRDISTRIBUTIONDUCTORSYSTEM

Page | 8

INSTALLATION

VentingIntroduction

 Thispelletstoveoperatesonanegativedraftsystem,whichpullscombustionair

throughtheburnpotandpushestheexhaustairthroughtheventpipeandoutofthebuilding.

Thisunitmustbeinstalledinaccordancewiththefollowingdetaileddescriptionsofventing

techniques;notinstallingthestoveinaccordancewiththedetailslistedherecanresultinpoor

stoveperformance,propertydamage,bodilyinjuryordeath.England’sStoveWorksisnot

responsibleforanydamageincurredduetoapoororunsafeinstallation.

 Ifquestionsarisepertainingtothesafeinstallationofthestove,ourTechnicalSupport

line(800‐245‐6489)isavailable.Contactyourlocalcodeofficialtobecertainyourinstallation

meetslocalandnationalfirecodesandifyou’reuncertainabouthowtosafelyinstallthestove,

westronglyrecommendcontactingalocalNFIcertifiedinstallertoperformtheinstallation.

VentingGuidelines

 ALWAYSinstallventpipeinstrictadherencewiththeinstructionsandclearanc es

includedwithyourventingsystem.

 DONOTconnectthispelletstovetoachimneyfluewhichalsoservesanotherappliance.

 DONOTinstallafluepipedamperoranyotherrestrictivedeviceintheexhaustventing

systemofthisunit.

 USEanapprovedwallthimblewhenpassingthroughawallandaceilingsupport/fire

stopwhenpassingthroughaceiling.

 ONLYuse3.0”or4.0”TypeLorTypePLpipeapprovedforpelletstoveventing;DONOT

usegalvanizedorB‐Ventpipe.

 SEALeachjointofpelletventwithhightemperaturesilicone(Part#AC‐RTV3)to

preventsmokespillageintothehome.

 AVOIDexcessivehorizontalrunsandelbows,asbothwillreducethedraftoftheventing

systemandwillresultinpoorstoveperformance.

 INCLUDEasmuchverticalpipeaspossibletopreventsmokefromtheunitfromentering

yourhomeintheeventofapoweroutage.

 INSPECTyourventingsystemoften,tobecertainitisclearoffly‐ashandother

restrictions.

 CLEANtheventingsystemasdetailedinthemaintenancesectionof

thismanual.

WARNING:VentingsystemsurfacesgetHOT,andcancauseburnsiftouched.

Noncombustibleshieldingorguardsmayberequired.

WARNING

 INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.

 HOT!Donottouch!Severeburnsorclothingignitionmayresult.

 Glassandothersurfacesarehotduringoperation.

Page | 9

INSTALLATION



AdditionalVentingInformation

 Donotmixandmatchcomponentsfromdifferentpipemanufacturerswhenassembling

yourventingsystem(i.e.DoNOTuseventingpipefromonemanufacturerandathimble

fromanother).



 Werequireaminimumverticalriseof36in.(3ft.)ofpipetocreatenaturaldraftinthe

system,whichhelpsevacuatesmokefromthestoveintheeventofapowerfailureor

combustionblowerfailure.

 Ventingsystems15.0ft.orshortermaybecomposedentirelyof3.0in.pelletpipe;to

reducefrictionallosses,ventingsystemslongerthan15.0ft.shouldbecomposedof4.0

in.pelletpipe.



 Donotterminatetheventingsystemdirectlybeneathanycombustiblestructuresuchas

aporchordeck.



 FollowNFPA211ruleslistedbelowforventingsystemterminationlocationrelativeto

windowsandotheropeningsinthedwelling.

o NFPA211(2003ed.)Section10.4Termination:10.4.5

(1)Theexitterminalofamechanicaldraftsystemotherthandirectvent

appliances(sealedcombustionsystemappliances)shallbelocatedinaccordance

withthefollowing:

 (a)Notlessthan3ft.(.91m)aboveanyforcedairinletlocatedwithin10

ft.(3.0m).

 (b)Notlessthan4ft.(1.2m)below,4ft.(1.2m)horizontallyfromor1ft.

(305mm)aboveanydoor,windoworgravityairinletintoanybuilding.

 (c)Notlessthan2ft.(0.61m)fromanadjacentbuildingandnotlessthan

7ft.(2.1m)above

gradewhenlocatedadjacenttopublicwalkways.



 Distancebetweentheterminationopeningandgradeshouldbeaminimumof24in.

contingentonthegradesurfacebelowthetermination.Whendeterminingthe

terminationheightabovegrade,considersnowdriftlinesandcombustiblessuchas

grassorleafaccumulation.Inareaswheresignificantsnowfallispossible,the

terminationheightmustbesufficientlyhightokeeptheterminationfreeofsnow

accumulation.

 Donotusemakeshiftcompromisesduringinstallationorinstallanycomponentofthe

unitorventingsystemwhichcouldresultinahazardousinstallation.

 Achimneyconnectorshallnotpassthroughanatticorroofspace,closetorsimilar

concealedspace,orafloor,orceiling.

 Wherepassagethroughawall,orpartitionofcombustiblematerialisdesired,the

installationshallconformtoCAN/CSA‐B365.

Page | 10

INSTALLATION



ApprovedVentingMethod1

:ThroughtheWall



 Generallythesimplestinstallationmethod,

ventingthroughthewallusingourAC‐3000

kit(orsimilarventingsystem)isalsothe

preferredventingmethod.Itminimizes

horizontalpipe,allowsthestovetobe

installedclosetothewallandkeepsthe

clean‐outteeontheoutsideofthe

house,

foreaseofcleaning.

 Wheninstallinganyventingsystem,TypeL

orTypePLpipemustbeusedandall

clearancestocombustibles(listedbythe

pipemanufacturer)mustbestrictly

adheredto.

 Usethepipemanufacturer’sapproved

thimbleforpassingthroughacombustible

wall,andmaintainatleasttheminimumclearancestocombustibles.

 Useanappliancecollarwherethepelletventconnectstotheexhaustoutputofthepellet

stoveandattachtheappliancecollartotheexhaustbloweroutputusingthreesheetmetal

screws.

 Securethepelletventtotheoutsideofthehouseusingawallstrapjustbelowthe90

degreeelbow.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemis

leakfree(Checkwiththespecificventingsystemmanufacturer’sinstructionsbeforedoing

so).

 Ifthepelletventpipebeingusedisnota“Twist

Lock”system,three(3)sheetmetalscrews

arerequiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyourstoveor

usinganalternativemethod,asdescribedinthe“OutsideAir”section,onpage14.

 Thisinstallationtypecanbe

modifiedforbasement(Basementinstallationsshouldalways

beperformedbyaprofessionalinstaller)orotherinstallationswhereintheteeandvertical

sectionofthepipewouldbeinsidethehomeandtheventingsystemwouldsimplypass

horizontallythroughthethimbleandthenterminate.

Please Note:

Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each individual

installation. Please follow all venting system requirements, maintain the required clearances to combustibles, and follow all local

codes.

For high altitude installations (above 4,000 ft.), the vent pipe should be

increased from 3-inch

(

3”

)

to four-inch

(

4”

)

Page | 11

INSTALLATION



ApprovedVentingMethod2

:ThroughtheCeiling



 Ventingthroughtheceiling/roofmaybetheonly

feasibleventingoptioninsomecasesandisafactory

recommendedinstallation.

 Wheninstallinganyventingsystem,TypeLorType

PLpipemustbeusedandallclearancesto

combustibleslistedbythepipemanufacturermust

bestrictlyadheredto.



 Usethepipemanufacturer’sapprovedceiling

supportforpassingthroughacombustibleceiling,as

wellastherequiredfirestops,radiationshields,

flashingandstormcollar.

 Becertaintofollowthemanufacturer’srequired

heightofterminationabovetheroofline,and

maintainatleasttheminimumclearancesto

combustibles.

 Useanappliancecollarwherethepelletvent

connectstotheexhaustoutputofthepelletstove

andattachtheappliancecollartotheexhaustbloweroutputusingthreesheetmetal

screws.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemis

leakfree(Checkwiththespecificpipemanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingusedisnota“TwistLock”system,three(3)sheetmetalscrews

arerequiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyour

stoveor

usinganalternativemethod,asdescribedinthe“OutsideAir”section,onpage14.

 Thisventingmethodcanalsobemodifiedsothattheventingsystemrunshorizontally

throughthewallfromthestove,thentransitionstoverticalandterminatesabovethe

roofline.Whenusingthismodifiedversionofthisinstallationbecertaintocarefullyfollow

theventingsystemmanufacturer’sinstructionsdiligently.



Please Note:

Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each individual

installation. Please follow all venting system requirements, maintain the required clearances to combustibles, and follow all local

codes.

For high altitude installations (above 4,000 ft.), the vent pipe should be

increased from 3-inch

(

3”

)

to four-inch

(

4”

)

Page | 12

INSTALLATION



ApprovedVentingMethod3

:ExistingChimneySystem

 Usinganexistingmasonryorfactorybuiltchimneyfor

ventingistheonlyotheracceptablemethodfor

ventingthispelletunit.

 UseTypeLorTypePLventingpipeuntilenteringthe

existingchimney.Usetheappropriatelysizedadapter

whentransitioningfromthepelletventpipetothe

masonryorfactorybuiltthimbleandbecertainthat

theadapterissealedtightlytoboththepelletventing

systemandtheexistingchimney.

 Beforeusinganexistingchimney,becertainitisin

goodcondition(Achimneysweepinspectionishighly

recommended).Also,makesurethechimneymeets

theminimumstandardslistedinNFPA211(A

chimneyprofessionalcanconfirmthisupon

inspection).

 Ifconnectingthisstovetoafactorybuiltchimney,it

mayONLYbea6”flue,UL103HTventingsystem.

Connectiontoanyotherfactorybuiltchimneymay

resultinapoorlyoperatingordangerousstove

installation.

 Whenconnectingtoanexistingmasonrychimney,thecross‐sectionalareaofthefluemust

beconsidered.Achimneywithafluelargerthan6”round(28.27sq.in.)mayrequire

reliningwithanapprovedpelletstovechimneyliningsystem.

 Useanappliancecollarwherethepellet

ventconnectstotheexhaustoutputofthepellet

stoveandattachtheappliancecollartotheexhaustbloweroutputusingthreesheetmetal

screws.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemis

leakfree(Checkwiththespecificpipemanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingusedisnota“TwistLock”system,three(3)sheetmetalscrews

arerequiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyourstoveor

usinganalternativemethod,asdescribedinthe“OutsideAir”section,onpage14.



Please Note:

Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each individual

installation. Please follow all venting system requirements, maintain the required clearances to combustibles, and follow all local

codes.

For high altitude installations (above 4,000 ft.), the vent pipe should be

increased from 3-inch

(

3”

)

to four-inch

(

4”

)

Page | 13

INSTALLATION

MobileHomeInstallation

 TheEngland’sStoveWorks,Inc.outsideairkitMUSTbeusedforinstallationofthisunitina

mobilehome.Pleaseseethe“OutsideAir”sectiononpage14formoreinformation

regardingoutsideairconnections.

 Theoutsideairinletmustbekeptclearofleaves,iceandotherdebris.Keepingtheoutside

airinletfreeofrestrictioniscrucialtopreventingairstarvationandsmokespillage.

 ThepelletstoveMUSTbesecuredtothefloorofthemobilehomeusinglagboltsandthe

holesprovidedinthebottomofthebaseforthispurpose.Outdoor‐aired

spaceheaters

mustbeattachedtothestructure.

 ThepelletstoveMUSTbegroundedwith#8solidcoppergroundingwire(orequivalent),

terminatedateachendwithanNECapprovedgroundeddevice.

 CarefullyfollowallclearanceslistedintheappropriatesectionofthismanualANDfollow

theventing

manufacturer’sminimumclearancerequirements.Similarly,becertainthe

ventingsystemusedisapprovedformobilehomeuse.

 InstallationmustbeinaccordancewithManufacturersHome&SafetyStandard(HUD)CFR

3280,Part24aswellasanyapplicablelocalcodes.

 Usesiliconetocreateaneffectivevaporbarrieratthelocationwherethechimneyor

outsideairductingpassesthroughtotheexteriorofthestructure.



WARNING:DONOTINSTALLINASLEEPINGROOM.

CAUTION

THESTRUCTURALINTEGRITYOFTHEMANUFACTUREDHOMEFLOOR,WALL

ANDCEILING/ROOFMUSTBEMAINTAINED.

DONOTCUTTHROUGHFLOORJOISTS,WALLSTUDS,CEILINGTRUSSESORANY

OTHERSUPPORTINGMATERIALWHICHCOULDBEDETRIMENTALTOTHE

STRUCTURALINTEGRITYOFTHEHOME.

JoistShield/Firestop

MobileHome

ApprovedTypePorPL

PelletVentPipe

RoofFlashingand

StormCollar

ChimneyCap/SparkArrestor

For high altitude installations (above 4,000 ft.), the vent pipe should be

increased from 3-inch

(

3”

)

to four-inch

(

4”

)

Page | 14

OUTSIDEAIRHOOK‐UP



 Theuseofoutsidecombustionairismandatoryonthispelletstove.

 Theoutsideairconnectionpipeprotrudesfromthelowerrearcenterofthestove;usethe

includedoutsideairkittoattachyourstovetooutsidecombustionair.Instructionsandall

thepartsneededtomakethe

outsideairconnectiontoyourpelletstoveareincludedwith

theoutsideairkit.

 Ifitisnotfeasibletousetheincludedoutsideairhookupkitinyourstoveinstallation,other

materialsmaybeused,providedthefollowingrulesarefollowed:

o Thepipeusedforoutsideairhookupmustbemetal,withaminimumthicknessof

.0209in.(25gaugemildsteel)orgreaterandaninsidediameterofapproximately

2.0in.

o Allpipejointsandconnectionsshouldbesealedwithpipeclampsorother

mechanicalmeans,toinsurealeakfreeoutsideairconnection.

o Longrunsofpipeandexcessiveelbowsforoutsideairshouldbeavoided.Dueto

frictionalresistanceinpipe,anyexcessiveoutsideairpipingcanresultinpoorstove

performance.

o Ascreenorotherprotectiondevicemustbefittedovertheoutsideairtermination

pointtopreventrain,debrisandnuisanceanimalsfromenteringthepipingsystem.

o Increasetheoutsideairpipesizeto3.0in.diameterpipeiftheoutsideair

connectionismorethan6ft.inlength,morethantwo(2)elbowsareusedorifthe

stoveisinstalledinabasement.



 Theoutsideairconnectionsystemshouldbeinspectedatleastannuallytobecertainitis

freefromblockage.



Caution

NEVERdrawoutsidecombustionairfrom:

 Wall,floororceilingcavity.

 Enclosedspacesuchasanattic,garageorcrawlspace.

Page | 15

FLOORPROTECTION



 Thispelletstoverequiresanon‐combustiblefloorprotectorifthestoveistobeinstalledon

acombustiblefloor.Ifthefloorthestoveistobeinstalledonisalreadynon‐combustible

(i.e.aconcretefloorinabasement)andhasanRvalueequaltoor

higherthan.2,nofloor

protectionisneeded(althoughadecorativefloorprotectorcanstillbeusedforaesthetic

reasons).

 PrefabricatedfloorprotectorswhichareULlistedorequivalentcanbepurchasedorafloor

protectorcanbebuiltfromstandardmaterials;twosheetsof.5”thickcementboard

covered

withceramictilewouldbeasuitablefloorprotectorwhichmeetsthe.2R‐value

requirement.

 Whenusinganyfloorprotector,considerthatthisstoveisnotonlyheavybutwillinduce

heatingandcoolingcyclesonthefloorprotectorwhichcandamagetileandloosenmortar

andgroutjoints.AhearthrugisNOTanapprovedsubstituteforaproperhearthpad.

 FortheUS:Thefloorprotectormustextendatleast6in.(152.4mm)fromthefront&sides

and4in.(101.6mm)fromtherear.

 ForCanada:Thefloorprotectormustextendatleast18.0in.(457.2mm)fromthefrontof

theunit,8.0in.(203.2mm)fromthesidesoftheunitand4.0in.(101.6mm)fromtherear.



 InCanada,itisrequiredthatthenon‐combustiblefloorprotectorisunderneathand

extends2in.(50.8mm.)oneithersideofanyhorizontalventingrunsAND/ORisdirectly

underneathanyverticalventingpipe.

US:6.0in.

Canada:



8.0



in.



US:6.0in.

ada

:

in.

US:4.0in.

ada

:4.

in.

US:6.0in.

ada

:1

in.

Page | 16

DAILYOPERATION



GettingStarted

 Checktoseethatthehopperiscleanandfreefromforeignmaterials.Besuretoconnect

thisunittoaworkingoutlet;werecommendusingasurgeprotectortohelpprotectthe

electroniccomponentsfromdamage.

 BEFOREyourfirstfire,dryrunyourunit(nopelletfuelinthehopper)fortwentyminutes;

pressingthe“ON”buttonwiththeunitpluggedinwillinitiatethedryrun.

o Oncethe“ON”buttonispressed,youshouldimmediatelyheartheexhaustblower

startandoperatecontinuously.

o Afteraboutthreetofiveminutes,lookfortheredglowoftheigniterintheigniter

portoftheburnpottobecertainitisoperatingnormally.

o Holdthehopperlidswitch(See“IllustratedPartsDiagram”pg.38)downwithyour

fingerandchecktoseethattheaugeristurning.Releasethehopperlidswitchand

becertainthattheaugerstopsturning.DONOTPUTYOURFINGERSINTHE

HOPPERORNEARTHEROTATINGAUGER.

 Afterabouttwentyminutes,thecontrolboardshoulddisplay“E‐2”inthetwodisplay

windows(MoreinformationonErrorCodescanbefoundintheErrorCodesectionofthis

manual).

 Atthispoint,thedryruniscompleteandyourpelletheatingapplianceisreadyfornormal

operation.

LightingaFire



 Inorderforthisstovetooperate,thehoppermustfirstbefilledwithpelletfuel.Liftthe

hopperlidusingtheflush‐mounthandleandpourthepelletfueldirectlyintothehopper.

 WerecommendusingonlypelletsmanufacturedbyPFICertifiedfacilities,since

pelletsbearingthePFIstampofapprovalwillbelowinashandmoisture,highin

BTU’s,anduniforminsizeandquality.



 Thispelletstovewillperformequallywellusingsoftwoodandhardwoodpellets,and

althoughtheashmaydifferslightlyinappearanceortexture,bothtypesofpelletswillburn

cleanlyandefficientlyinthisstove.

 Thispelletstoveisequippedwithanautomaticpelletignitionsystem;theonlyuserinput

requiredtolightthestoveisasimplepressofthe“On”button.

Page | 17

 Shortlyafterpressingthe“On”button,theletters“SU”willappearintheheatrangeand

blowerspeedwindowsofthecontrolboard.Thisindicatesthestovehasenteredthestart‐

upsequenceandisoperatingnormally.

 Thefuelfeedrateandcombustionairduringstart

‐upisdeterminedbythecontrolboard,so

thestovemaybestartedonanyheatrange.

 Afterapproximatelyfifteenminutes,thefireshouldbeburningbrightlyandthe“SU”

shoulddisappearfromthecontrolboard.Atthispoint,thestovehasbegunnormal

operationandthedisplaywindowsonthecontrolboardwillremainempty,unlesstheHeat

RangeorBlowerSpeedisadjusted.

DailyOperationNotes

 Onlyhighquality,¼”(.25in.)diameterwoodpellets,shouldbeusedinthisstove.Usinglow

gradewoodpelletswithhighashcontentORwoodpelletswithahighmoisturecontent

cancausetheburnpottofillwithashatamorerapidpaceandcancauseintervalsbetween

periodicmaintenancetobecomesignificantlyshorter.Pleasereadthe“Maintenance”

sectionofthismanualthoroughlytounderstandhowfuelselectionaffectsstoveoperation,

maintenanceandcleaning.

 Variationintheflameheightisnormal;notallwoodpelletfuelisuniforminsize,whichcan

affectthewaypelletsarefedintotheburnpot.Althoughtheflameheightmayincreaseand

decreaseduringoperation,thereisnolossofefficiency.

 Alwaysstorewoodpelletfuelinadrylocation;storingwoodpelletfuelinadrylocation

ensuresthefuelwillremainpelletizedandlowinmoisturecontent.Also,becertainthatall

woodpelletfuelisstoredatasafedistancefromthepelletheater;storingfuelinclose

proximitytothestovecanresultinafire.

 Thispelletburningroomheaterisequippedwithaspeciallydesignedburnpotwhichcomes

preinstalledfromthefactory.Thisburnpot

elevatestheburningpelletsanddeliversairat

thepreciserequiredlocations.Pelletsmustonlybeburnedinthefactoryburnpot;no

modificationsshouldbemadetothisburnpotandnoadditionalgratesorotherfire

elevatorsshouldbeadded.

CAUTION

NEVERUSEGASOLINE,GASOLINE‐TYPELANTERNFUEL,KEROSENE,CHARCOALLIGHTER

FLUID,ORSIMILARLIQUIDSTOSTARTOR“FRESHENUP”AFIREINTHISHEATER.KEEPALL

SUCHLIQUIDSWELLAWAYFROMTHEHEATERWHILEINUSE.ADDITIONALLY,NEVER

APPLY FIRE

‐

STARTER TO ANY HOT SURFACE OR EMBERS IN THE STOVE.

DONOTUSECHEMICALSORFLUIDSTOSTARTTHEFIRE.

DONOTBURNGARBAGEORFLAMMABLEFLUIDSSUCHASGASOLINE,NAPHTHAOR

ENGINEOIL.

Page | 18

CONTROLBOARDSETTINGS

Thecontrolboardonthisstoveallowstheusertoadjusttheheatoutputandconvection

blowerspeed,turntheunitonandoff,andtestcomponentsforfunction(moreondiagnostic

modelater).

 Thelowerbuttonsonthecontrolboard(LowFuelFeed,LowBurnAir,andAiron

Temp)are

notmeanttobeadjustedduringnormaloperationoftheunit.Thesebuttonsarefactory

presetandcannotbeadjustedbytheuser.

 Toenergizetheunitandinitiateafire,pressthe“On”button.TheLEDabovethebutton

shouldturngreenandthecontrol

boardshoulddisplay“SU”shortlyafterpressingthe

button.

 Toshuttheunitdown,pressthe“Off”button.TheLEDabovethebuttonshouldturnred

andtheboardshoulddisplay“Sd”shortlyafterpressingthebutton.Thisinitiatestheshut 

downsequence,andthestovewillremaininshutdownmodeuntilithascooleddown.

 Toincreasetheheatoutputofthestove,pressthe“Up”heatrangebutton.Thenumberin

theheatrangedisplaywindowwillincrease,signifyingthatthecontrolboardisnow

adjustingtheheatoutputtoyourdesiredlevel.Theblowerspeedwillincreasethesame

amountastheheatrange,becausethestoveisdesignedtooperatewiththeblowerspeed

greaterthanorequaltotheheatrange.Pressingthe“Down”arrowwilldecreasetheheat

rangeandblowerspeed.

 Toincreasetheblowerspeedwithoutincreasingtheheatrange,presstheBlowerSpeed

“Up”arrowuntilthedesiredblowerspeedisshowninthedisplaywindow.Pressingthe

“Down”arrowwilldecreasetheblowerspeed;however,thecontrolboardwillnotallow

theblowerspeedtobesetlowerthantheheatrange.

Caution

Thisunitismeanttooperateonlywiththeashpanandmainviewing

doorclosed.Smokespillageandaninefficient,lazyburnwillresult

fromattemptingtooperatethestovewitheitherdooropen.

Inaddition,usingfuelotherthanwoodpelletscancreateanunsafe

situationandcanalso

generateexcesscarbonmonoxide.Carbon

monoxideisanodorless,colorlessgaswhichcanbedeadly.Pleaseburn

onlywoodpellets.

Page | 19

ERRORCODES

Errorcodes,or“E‐Codes,”arealphanumericcodesthatwillappearintheHeatRangeand

BlowerSpeedwindowsoftheControlBoardiftheunitexperiencesanabnormalcondition.

Errorcodesarethecontrolboard’swayoftellingtheuserthatsomethingisn’toperating

correctlywithinthestove,andthattheunitshouldbecarefullyinspectedbeforereigniting.See

the“Trouble‐ShootingGuide,”page30,foradditionalinformationonerrorcodes.

 E‐0

 Whenthisisdisplayedinthecontrolboardwindows(typicallywhenrestartingafter

an“E‐Code”shutdown),itmeanstherearecurrentlynoerrorsandthestovewill

beginnormaloperation.

 E‐1



 Thiserrorcodeisnotusedonthisstove.Ifitisdisplayedinthecontrolboard

windows,pleasecontactTechnicalSupportandtheywilldiagnosethecauseofthe

falsecode.

 E‐2



 Whenthiscodeisdisplayedinthecontrolboardwindowitindicatesafailureto

light.Althoughthestovemayhaveignitedthepellets,thecontrolboarddidnot

ignited,waitfortheunittocool,cleantheburnpotandrestarttheunit.

 E‐3

 Thiserrorcodeindicatesthepresetmaximumallowableexhausttemperaturewas

exceeded.Commonlyreferredtoas“Over‐Firing,”theE‐3codemeanssomethingin

thestoveiscausingtheexhaustgastobehotterthanexpected.

 E‐4

 Thiscodeisdisplayedbasedonadropintheexhausttemperature.Thiscodemeans

thefireor“proofofflame”hasbeenlost.Itusuallyresultsfromthehopperbeing

empty.



If an error code continues to display, if the error code

seems unexplainable, or if you have any other

questions about error codes and what they mean,

please contact Technical Support at (800)245-6489.

Page | 20

POWERFAILURE

Ifthepowertotheunitisinterruptedforapproximatelythreeminutesorless,theunitwill

resumeoperationwhenpowerisrestoredaccordingtothefollowingtable:



Unit’sStateBeforePowerLoss StateWhenPowerReturns

ON Start‐Up

Start‐Up Start‐Up

Shut‐Down Shut‐Down

OFF OFF



 Ifthepowerisinterruptedformorethan(approximately)threeminutes,theunit

willbe“OFF”whenpowerreturns.

 IMPORTANT–DoNOTopenthehopperlidorthedoortotheunitduringpower

outage.Opentheclosestoutsidedoorandawindowtoreducethechanceofany

combustionbyproductsenteringthehomefromthestove.

 Waitforthepowertoberestoredandthenpressthe“ON”buttontorestartthe

unit,ifnecessary.

Caution

–

ShockHazard

Pressthe“Off”buttonandlettheappliancecompletelycoolBEFORE

unpluggingtheapplianceandbeginninganymaintenanceorcomponent

replacement.

Riskofshockifapplianceisnotunpluggedbeforeservice.

SmokeDetectors

England’sStoveWorks,Inc.highlyrecommendstheuseofsmokedetectorsin

everyroomofthehouse.However,locatingasmokedetect ordirectlyabove

thisunitcanresultinnuisance alarms.

Page is loading ...

England's Stove Works 55TRPAH User manual

Brand: England's Stove Works

Model: 55TRPAH

Category: Stoves

Type: User manual

This manual is also suitable for

Download PDF

report

England's Stove Works 55TRPAH User manual

This manual is also suitable for

England's Stove Works 55TRPAH User manual

Related papers

Other documents