Idatalink maestro Rr ADS-RR-FOR01-DS-IG-EN Install Manual

Revision Date

20121011

Document numbeR

notice The manufacturer will accept no responsability for any electrical

damage resulting from improper installation of this product, be that either

damage to the vehicle itself or to the installed device. This device must be

installed by a certiﬁed technician. This guide has been written for properly

trained technicians; a certain level of skill & knowledge is therefore assumed.

Please review the Installation Guide carefully before beginning any work.

beFoRe instaLLation

1- Connect the module to computer

2- Login to Weblink account

3- Flash ﬁrmware to module (module is not preloaded with ﬁrmware)

4- Use needed accessories

instaLL guiDe

ADSRRSRFOR01DSIGEN

haRDwaRe

ADSMRR

accessoRies

ADSHRNSXALL01 REQUIRED

ADSHRNSRFOR01 OPTIONAL

FiRmwaRe

ADSRRSRFOR01DSEN

01

RANGEHOLD

OFF

V

Hz

~~

~

V

mV Ω

Ω

)))))

mA

A

MIN MAX

400

mA

10A COM

FUSED

V

!600V CAT IV

1000V CAT III

V

DC

02

03

04

05

SUGGESTED TOOLS

Multimeter

Soldering iron and solder

Wire cutter

Wire stripper

Electrical tape

Page 2 oF 37

• 20121011

7

9

3

10

8

11

13

14

12

15

17

18

16

6

4

1

2

5

A

4

3

2

1

B

7

9

3

10

8

6

4

1

2

5

C

E1

2

3

4

1

2

3

4

2

8

1

3

5

7

10 9

6

G

USB

H

D

F01 ORANGE - PARKING LIGHT (+) OUTPUT

03 PURPLE/WHITE - REVERSE LIGHT (+) OUTPUT

02 EMPTY

06 LTGREEN - E-BRAKE (-) OUTPUT

05 PINK - VEHICLE SPEED (-) OUTPUT

07 BLACK/PINK - AMP. TURN ON (+) OUTPUT

08 BLUE/WHITE - AMP. TURN ON (+) INPUT

10 EMPTY

02 RED - RADIO ACCESSORY (+) OUTPUT

03 YELLOW - 12V (+) INPUT

01 BLACK - GROUND

WEBLINK UPDATER CABLE OR SXI HARNESS (NOT INCLUDED)

USB CABLE - FLASH MODULE

04 BROWN - MUTE (-) OUTPUT

09 BLACK/YELLOW

01 BLUE/YELLOW - RADIO CONTROL 1 OUTPUT

02 RED

04 WHITE

03 BLACK

01 TAN/RED - MONO AUDIO (+) INPUT

02 TAN/BROWN - MONO AUDIO (-) INPUT

03 WHITE/RED - LEFT 1 AUDIO (+) INPUT

04 WHITE/BROWN - LEFT 1 AUDIO (-) INPUT

01 LTBLUE/BLACK - LEFT FRONT SPEAKER (-) OUTPUT

02 LTBLUE - LEFT FRONT SPEAKER (+) OUTPUT

03 WHITE/BLACK - LEFT FRONT SPEAKER (-) INPUT

04 WHITE - LEFT FRONT SPEAKER (+) INPUT

05 GRAY/RED - RIGHT 1 AUDIO (+) INPUT

06 GRAY/BROWN - RIGHT 1 AUDIO (-) INPUT

07 GREEN/RED - LEFT 2 AUDIO (+) INPUT

08 GREEN/BROWN - LEFT 2 AUDIO (-) INPUT

09 PURPLE/RED - RIGHT 2 AUDIO (+) INPUT

10 PURPLE/BROWN - RIGHT 2 AUDIO (-) INPUT

BLACK/WHITE -

18 BLACK/WHITE - SWI GROUND FEED (-) OUTPUT

ORANGE/RED -

17 ORANGE/RED - SWI CIRCUIT 3 INPUT

LTGREEN/YELLOW -

16 LTGREEN/YELLOW - AVC LANL

LTGREEN/RED -

15 LTGREEN/RED - AVC LANH

GRAY/YELLOW - FOOT

14 GRAY/YELLOW - FOOT BRAKE (+) OUTPUT

GRAY/RED -

13 GRAY/RED - SUPER DATA CIRCUIT 1

YELLOW/BROWN -

12 YELLOW/BROWN - CAN2L

RED/BROWN -

11 RED/BROWN - CAN2H

01 PURPLE/RED -

01 PURPLE/RED - SWI CIRCUIT 1 INPUT

02 PURPLE/YELLOW - SWI CIRCUIT 1 OUTPUT/ANALOG 1 INPUT

03 PINK/RED - SWI CIRCUIT 2 INPUT

04 PINK/YELLOW - SWI CIRCUIT 2 OUTPUT/ANALOG 2 INPUT

WHITE/ORANGE -

05 WHITE/ORANGE - FAULT TOLERANT CANH

WHITE/YELLOW -

06 WHITE/YELLOW - FAULT TOLERANT CANL

BROWN/RED -

07 BROWN/RED - CAN1H

BROWN/YELLOW -

08 BROWN/YELLOW - CAN1L

YELLOW/RED -

09 YELLOW/RED - CAN1 TERMINATION

GREEN/WHITE -

10 GREEN/WHITE - SWC

MODULE

BACK VIEW

PROGRAMMING

BUTTON

USB

H

G

F

E

D

Expansion connector

(NOT IN USE)

A

B

C

AFTERMARKET RADIO

VEHICLE

WEB

RADIO CONTROL 2 OUTPUT

AUDIO OUTPUT: SXI HARNESS 3.5mm JACK (NOT INCLUDED)

MODULE OVERVIEW

Page 3 oF 37

• 20121011

vehicLe List

MAKE

MODEL

YEAR

INSTALL TYPE

FEATURES

STEERING WHEEL CONTROLS*

EXTRA SW CONTROLS

SYNC RETETION*

SAT RADIO RETENTION*

SUB AMP TURN ON*

THX AMP TURN ON*

REVERSE LIGHTS OUTPUT

ILLUMINATION OUTPUT

PARKING BRAKE OUTPUT

RAP ACCESSORY 15A OUTPUT

RCA INPUT FOR SUB*

RCA INPUT FOR CENTER*

RCA OUTPUTS FOR 3.5MM JACK*

FORD

Econoline (without Navigation) 08-10 1 • • • • • • • • • ◊ ◊ ◊

Econoline (with Navigation) 08-10 1 • • • • • • • • ◊ ◊ ◊

Econoline 11-12 1 • • • • • • • • ◊ ◊ ◊

Edge 07-09 1 • • • • • • • • • ◊ ◊ ◊

Edge (without Navigation) 10 1 • • • • • • • • • ◊ ◊ ◊

Edge (with Navigation) 10 1 • • • • • • • • ◊ ◊ ◊

Escape 08-12 1 • • • • • • • • ◊ ◊ ◊

Expedition 07-09 1 • • • • • • • • • ◊ ◊ ◊

Expedition (without Navigation) 10 1 • • • • • • • • • ◊ ◊ ◊

Expedition (with Navigation) 10 1 • • • • • • • • ◊ ◊ ◊

Expedition 11-12 1 • • • • • • • • ◊ ◊ ◊

Explorer/Sport Trac 06-09 1 • • • • • • • • • ◊ ◊ ◊

Explorer/Sport Trac (without Navigation) 10 1 • • • • • • • • • ◊ ◊ ◊

Explorer/Sport Trac (with Navigation) 10 1 • • • • • • • • ◊ ◊ ◊

F-150 09-12 1 • • • • • • • • ◊ ◊ ◊

F-Series Super Duty 08-09 1 • • • • • • • • • ◊ ◊ ◊

F-Series Super Duty (without Navigation) 10 1 • • • • • • • • • ◊ ◊ ◊

F-Series Super Duty (with Navigation) 10 1 • • • • • • • • ◊ ◊ ◊

F-Series Super Duty 11-12 1 • • • • • • • • ◊ ◊ ◊

Five Hundred 06-07 1 • • • • • • • ◊ ◊ ◊

Flex 09-12 1 • • • • • • • • ◊ ◊ ◊

Focus 08-09 1 • • • • • • • • • ◊ ◊ ◊

Focus 10-11 1 • • • • • • • • ◊ ◊ ◊

Fusion 06-09 1 • • • • • • • • • ◊ ◊ ◊

Fusion 10-12 1 • • • • • • • • ◊ ◊ ◊

Mustang 10-13 1 • • • • • • • • ◊ ◊ ◊

* If equipped.

LEGEND

Available •

Available w/T-Harness ◊

Page 4 oF 37

• 20121011

vehicLe List

MAKE

MODEL

YEAR

INSTALL TYPE

FEATURES

STEERING WHEEL CONTROLS*

EXTRA SW CONTROLS

SYNC RETETION*

SAT RADIO RETENTION*

SUB AMP TURN ON*

THX AMP TURN ON*

REVERSE LIGHTS OUTPUT

ILLUMINATION OUTPUT

PARKING BRAKE OUTPUT

RAP ACCESSORY 15A OUTPUT

RCA INPUT FOR SUB*

RCA INPUT FOR CENTER*

RCA OUTPUTS FOR 3.5MM JACK*

FORD

Taurus 08-09 1 • • • • • • • • • ◊ ◊ ◊

Taurus 10-12 1 • • • • • • • • ◊ ◊ ◊

Taurus X 08-09 1 • • • • • • • • • ◊ ◊ ◊

LINCOLN

MKS 09-12 1 • • • • • • • • • ◊ ◊ ◊

MKT 10-12 1 • • • • • • • • • ◊ ◊ ◊

MKX 07-09 1 • • • • • • • • • • ◊ ◊ ◊

MKX (without Navigation) 10 1 • • • • • • • • • • ◊ ◊ ◊

MKX (with Navigation) 10 1 • • • • • • • • • ◊ ◊ ◊

MKZ 07-08 1 • • • • • • • • • • ◊ ◊ ◊

MKZ 09-12 1 • • • • • • • • • ◊ ◊ ◊

Navigator 07-09 1 • • • • • • • • • • ◊ ◊ ◊

Navigator (without Navigation) 10 1 • • • • • • • • • • ◊ ◊ ◊

Navigator (with Navigation) 10 1 • • • • • • • • • ◊ ◊ ◊

Navigator 11-12 1 • • • • • • • • • ◊ ◊ ◊

Zephyr 06 1 • • • • • • • • • ◊ ◊ ◊

MAZDA

Tribute 08-11 1 • • • • • • • ◊ ◊ ◊

MERCURY

Mariner 08-11 1 • • • • • • • • ◊ ◊ ◊

Milan 06-09 1 • • • • • • • • • ◊ ◊ ◊

Milan 10-11 1 • • • • • • • • ◊ ◊ ◊

Montego 05-07 1 • • • • • • • ◊ ◊ ◊

Mountaineer 06-09 1 • • • • • • • • • ◊ ◊ ◊

Mountaineer (without Navigation) 10 1 • • • • • • • • • ◊ ◊ ◊

Mountaineer (with Navigation) 10 1 • • • • • • • • ◊ ◊ ◊

Sable 08-09 1 • • • • • • • • • ◊ ◊ ◊

* If equipped.

LEGEND

Available •

Available w/T-Harness ◊

Page 5 oF 37

• 20121011

y

I

z

y

A

x

A

B

C

D

E

F

G

H

I

J

K

L

M

N

O

P

Q

R

S

T

U

x

z

01

AA

BB

CC

DD

EE

FF

GG

HH

II

JJ

KK

LL

MM

NN

OO

02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45

01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45

x

z

A

AA

BB

CC

DD

EE

FF

GG

HH

II

JJ

KK

LL

MM

NN

OO

B C D EF G H I JK L M N OP Q R S TU

y

II

III

V

VI

IV

COMPONENT LOCATOR

TOP VIEW

SIDE VIEWREAR VIEW (CUT A-A)

Page 6 oF 37

• 20121011

WIRE CHART

MAKE

MODEL

YEAR

WIRE

DESCRIPTION

CONNECTOR

POSITION

WIRE

COLOR

POLARITY

MODULE

LOCATION

COMPONENT

LOCATOR

NAME

COLOR

TYPE

FORD

Econoline 08-12

12V Power FRD24 White 24 pin 01 White/Red (+) Radio 17-K-JJ

Ground FRD24 White 24 pin 13 Black/Blue (-) Radio 17-K-JJ

CanH FRD16 White 16 pin 15 Gray/Orange (DATA) Radio 17-K-JJ

CanL FRD16 White 16 pin 16 Violet/Orange (DATA) Radio 17-K-JJ

Signal SWI 1 FRD24 White 24 pin 18 Gray/Yellow (MUX) Radio 17-K-JJ

Signal SWI 2 (w/ Nav) FRD24 White 24 pin 17 Blue/Orange (MUX) Radio 17-K-JJ

Signal SWI 2 (w/o Nav, w/ Sync) ~ ~ ~ ~ Blue/Orange (MUX) Center dash, under the radio. 17-K-JJ

Feed SWI 1 FRD24 White 24 pin 19 Blue/White (-) Radio 17-K-JJ

Feed SWI 2 (w/ Nav) FRD24 White 24 pin 16 Violet/White (-) Radio 17-K-JJ

Feed SWI 2 (w/o Nav, w/ Sync) ~ ~ ~ ~ ~ ~ Do not connect. ~

Amp Activation (5V) FRD24 White 24 pin 07 Blue/Green (+) Radio 17-K-JJ

Sub Amp Activation (5V) FRD8 White 08 pin 04 Pink (+) Radio 17-K-JJ

Ampliﬁ ed Antenna (12V) FRD24 White 24 pin 05 Yellow/Green (+) Radio 17-K-JJ

LF Speaker (High Level) FRD24 White 24 pin 08 White (+) Radio 17-K-JJ

LF Speaker (High Level) FRD24 White 24 pin 21 White/Brown (-) Radio 17-K-JJ

RF Speaker (High Level) FRD24 White 24 pin 11 White/Violet (+) Radio 17-K-JJ

RF Speaker (High Level) FRD24 White 24 pin 12 White/Orange (-) Radio 17-K-JJ

LR Speaker (High Level) FRD24 White 24 pin 09 White/Green (+) Radio 17-K-JJ

LR Speaker (High Level) FRD24 White 24 pin 22 Brown/Yellow (-) Radio 17-K-JJ

RR Speaker (High Level) FRD24 White 24 pin 10 Brown/White (+) Radio 17-K-JJ

RR Speaker (High Level) FRD24 White 24 pin 23 Brown/Blue (-) Radio 17-K-JJ

Mono Input (Low Level) FRD16 White 16 pin 04 White/Violet (+) Radio 17-K-JJ

Mono Input (Low Level) FRD16 White 16 pin 05 Gray/Brown (-) Radio 17-K-JJ

Left Input (Low Level) FRD16 White 16 pin 01 Blue/Green (+) Radio 17-K-JJ

Left Input (Low Level) FRD16 White 16 pin 02 Green/Blue (-) Radio 17-K-JJ

Right Input (Low Level) FRD16 White 16 pin 09 Blue/Gray (+) Radio 17-K-JJ

Right Input (Low Level) FRD16 White 16 pin 10 Yellow/Blue (-) Radio 17-K-JJ

Page 7 oF 37

• 20121011

WIRE CHART

MAKE

MODEL

YEAR

WIRE

DESCRIPTION

CONNECTOR

POSITION

WIRE

COLOR

POLARITY

MODULE

LOCATION

COMPONENT

LOCATOR

NAME

COLOR

TYPE

FORD

Edge 07-10

12V Power FRD24 White 24 pin 01 White/Red (+) Radio 17-K-JJ

Ground FRD24 White 24 pin 13 Black/Blue (-) Radio 17-K-JJ

CanH FRD16 White 16 pin 15 Gray/Orange (DATA) Radio 17-K-JJ

CanL FRD16 White 16 pin 16 Violet/Orange (DATA) Radio 17-K-JJ

Signal SWI 1 FRD24 White 24 pin 18 Gray/Yellow (MUX) Radio 17-K-JJ

Signal SWI 2 (w/ Nav) FRD24 White 24 pin 17 Blue/Orange (MUX) Radio 17-K-JJ

Signal SWI 2 (w/o Nav, w/ Sync) ~ ~ ~ ~ Blue/Orange (MUX) Center console, right side, harness going to the back. 18-L-FF