Bull 1100 & 1300 Cabinet Installation guide

Installation and

Service Guide

1100 AND 1300

CABINET

REFERENCE

86 A1 91EM 03

BLANK

1100 AND 1300

CABINET

Installation and Service

Guide

October 2006

BULL CEDOC

357 AVENUE PATTON

B.P.20845

49008 ANGERS CEDEX 01

FRANCE

REFERENCE

86 A1 91EM 03

Hardware

The following copyright notice protects this book under Copyright laws which prohibit such actions as, but not

limited to, copying, distributing, modifying, and making derivative works.

Copyright Bull SAS 1992, 2006

Printed in France

Suggestions and criticisms concerning the form, content, and presentation of this

book are invited. A form is provided at the end of this book for this purpose.

To order additional copies of this book or other Bull Technical Publications, you

are invited to use the Ordering Form also provided at the end of this book.

Trademarks and Acknowledgements

We acknowledge the right of proprietors of trademarks mentioned in this book.

Intel

and Itanium are registered trademarks of Intel Corporation.

Windows

and Microsoft software are registered trademarks of Microsoft Corporation.

UNIX

is a registered trademark in the United States of America and other countries licensed exclusively through

the Open Group.

Linux

is a registered trademark of Linus Torvalds.

The information in this document is subject to change without notice. Bull will not be liable for errors contained

herein, or for incidental or consequential damages in connection with the use of this material.

iii
Preface
Preface
Table of Contents
Intended Readers vii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Highlighting vii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Unpacking Label viii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Chapter 1. Overview 1-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Cabinet Models 1-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
1300H Cabinet and 1300H-E Cabinet 1-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
1100H Cabinet and 1100H-E Cabinet 1-4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
1300L Cabinet and 1300L-E Cabinet 1-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
1100L Cabinet and 1100L-E Cabinet 1-6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
PDU Models 1-7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
PDU-4-2-M-63A 1-8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
PDU-2-4-M-32A 1-9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
PDU-0-7-M-32A 1-10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
PDU-0-12-M-32A 1-11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Chapter 2. Installing and Servicing Cabinets 2-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
General Recommendations 2-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Cabinet Packing 2-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Inspecting Packing 2-4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Removing Packing 2-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Storing Packing Items 2-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Inspecting the Cabinet 2-6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Unloading the Cabinet 2-7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Service Clearance 2-7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Removing the Shipping Pallet Assembly 2-8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Moving the Cabinet 2-14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Rolling the Cabinet 2-14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Hoisting the Cabinet 2-15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Securing the Cabinet 2-16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Lowering the Jacking Screws 2-16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Installing the Stabilizer 2-17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Raising the Stabilizer 2-19. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Lowering the Stabilizer 2-19. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Removing / Installing Cabinet Doors and Covers 2-20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Removing / Installing the Front and Rear Doors 2-20. . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Removing the Door 2-20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Installing the Door 2-21. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Removing / Installing Side Covers 2-22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Removing a Side Cover 2-22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Installing a Side Cover 2-23. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Removing / Installing the 1300H/1100H Top Cover 2-24. . . . . . . . . . . . . . . . . . . . . . . 
Removing the Top Cover (1300H/1100H) 2-24. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Installing the Top Cover (1300H/1100H) 2-25. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Removing / Installing the 1300L/1100L Top Cover 2-26. . . . . . . . . . . . . . . . . . . . . . . . . 
Removing the 1300L/1100L Top Cover 2-26. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Installing the 1300L/1100L Top Cover 2-27. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

iv
Installation & Service Guide
Turning the Front and/or Rear Door 2-28. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Adding an Extension Cabinet 2-29. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Preparing the Cabinets 2-29. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Fitting Front Spacers 2-29. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Fitting Rear Spacers 2-30. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Fitting the Top Spacer 2-31. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Replacing Side Covers 2-31. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Installing Servers and/or Devices 2-32. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Checking Server / Device Compatibility 2-33. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Fitting a Short Integration Kit 2-34. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Fitting Equipment Trays 2-37. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Fitting a Short Equipment Tray 2-38. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Fitting a Medium Equipment Tray 2-39. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Fitting a Long Equipment Tray 2-40. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Mounting the Long Equipment Tray Integration Bracket 2-40. . . . . . . . . . . . . . . . . . . . . . 
Fitting the Long Equipment Tray for Non-Rackable Devices 2-41. . . . . . . . . . . . . . . . . . . 
Fitting the Long Equipment Tray for Rackable Devices 2-42. . . . . . . . . . . . . . . . . . . . . . . 
Installing a PDU 2-44. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Chapter 3. Managing Power and Data Cables 3-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Routing Data Cables 3-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Routing Inter-Cabinet Data Cables 3-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Routing and Connecting Power Cables 3-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Connecting a PDU to the Site Power Supply 3-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Safety Recommendations 3-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Mounting the PDU Power Cable Socket 3-4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Appendix A. Specifications A-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
1300H Cabinet / 1300H-E Cabinet Specifications A-2. . . . . . . . . . . . . . . . . . . . . . . . . . . 
1100H Cabinet / 1100H-E Cabinet Specifications A-4. . . . . . . . . . . . . . . . . . . . . . . . . . . 
1300L Cabinet / 1300L-E Cabinet Specifications A-6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
1100L Cabinet / 1100L-E Cabinet Specifications A-8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
PDU-4-2-M-63A Specifications A-10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
PDU-2-4-M-32A A-11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
PDU-0-7-M-32A A-12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
PDU-0-12-M-32A A-13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Appendix B. Regulatory Statements and Disclaimers B-1. . . . . . . . . . . . . . . . . . . . . . . . . . 
Declaration of the Manufacturer or Importer B-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Safety Compliance Statement B-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
European Community (EC) Council Directives B-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Federal Communications Commission (FCC) Statement B-2. . . . . . . . . . . . . . . . . . . . . . . . 
FCC Declaration of Conformity B-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Canadian Compliance Statement (Industry Canada) B-2. . . . . . . . . . . . . . . . . . . . . . . . . . 
Laser Compliance Notice B-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Appendix C. Safety Notices C-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Definition of Safety Notices C-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
General Safety Notices C-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Electrical Safety Notices C-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Index X-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

v
Preface
List of Figures
Figure 1. Unpacking label viii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 2. 1300H Cabinet / 1300H-E Cabinet features 1-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 3. 1100H Cabinet / 1100H-E Cabinet features 1-4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 4. 1300L Cabinet / 1300L-E Cabinet features 1-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 5. 1100L Cabinet  / 1100L-E Cabinet features 1-6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 6. PDU-4-2-M-63A features - vertical / horizontal installation 1-8. . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 7. PDU-2-4-M-32A features -vertical / horizontal installation 1-9. . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 8. PDU-0-7-M-32A features - vertical / horizontal installation 1-10. . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 9. PDU-0-12-M-32A features - vertical/horizontal installation 1-11. . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 10. Packing shockwatch and tiltwatch labels 2-4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 11. Removing the top, front and rear covers 2-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 12. Required unpacking area 2-7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 13. Removing shipping brackets 2-8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 14. Pallet assembly 2-9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 15. Removing pallet retaining plates 2-9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 16. Positioning the fork lift - front 2-10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 17. Removing the front half-pallet 2-10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 18. Skate-board assembly 2-11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 19. Inserting the skate-board 2-11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 20. Tightening the skate-board safety screw 2-11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 21. Postioning the fork lift - rear 2-12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 22. Removing the rear half-pallet 2-12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 23. Installing the rear jack screws 2-13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 24. Cabinet on  casters 2-13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 25. Single cabinet service clearance 2-14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 26. Dual cabinet service clearance 2-15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 27. Installing hoisting fixtures. 2-15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 28. Lowering jacking screws 2-16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 29. Stabilizer and fixtures 2-17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 30. Removing the front shipping bracket 2-17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 31. Aligning the stabilizer 2-18. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 32. Stabilizer cut-outs 2-18. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 33. Installing the stabilizer trim 2-19. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 34. Raising the stabilizer 2-19. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 35. Removing the door 2-20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 36. Installing the door 2-21. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 37. Opening side cover locks 2-22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 38. Side cover retaining lug 2-22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 39. Side cover retaining lug 2-23. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 40. Closing side cover locks 2-23. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 41. Unscrewing the top cover 2-24. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 42. Removing the top cover 2-24. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 43. Installing the top cover (1300H/1100H) 2-25. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 44. Securing the top cover (1300H/1100H) 2-25. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 45. Removing the top cover (1300L/1100L) 2-26. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 46. Installing the top cover (1300L/1100L) 2-27. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

vi
Installation & Service Guide
Figure 47. Fitting a front spacer 2-29. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 48. Fitting a rear spacer 2-30. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 49. Fitting the top spacer 2-31. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 50. Internal cabinet dimensions 2-33. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 51. Mounting flange hole size and placement 2-34. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 52. Fitting a 1U integration bracket 2-35. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 53. Fitting a 2U integration bracket 2-35. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 54. 2U and 1U integration brackets 2-36. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 55. Mounting flange hole size and placement 2-37. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 56. Fitting a short equipment tray 2-38. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 57. Fitting a medium equipment tray 2-39. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 58. Mounting the long equipment tray integration bracket 2-40. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 59. Fitting the long equipment tray for non-rackable devices 2-41. . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 60. Fitting the long equipment tray for rackable devices 2-42. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 61. Installing long equipment tray leveling pads 2-43. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 62. Installing a PDU vertically 2-44. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 63. Installing a PDU horizontally 2-45. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 64. Power plug and socket 3-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Figure 65. PDU power socket 3-4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
List of Tables
Table 1. 1300H Cabinet / 1300H-E Cabinet Specifications A-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Table 2. 1100H Cabinet / 1100H-E Cabinet A-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Table 3. 1300L Cabinet / 1300L-E Cabinet Specifications A-7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Table 4. 1100L Cabinet / 1100L-E Cabinet A-9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Table 5. PDU-4-2-M-63A specifications A-10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Table 6. PDU-2-4-M-32A specifications A-11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Table 7. PDU-0-7-M-32A specifications A-12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
Table 8. PDU-0-12-M-24A specifications A-13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

vii

Preface

Intended Readers

This guide is intended for use by qualified personnel in charge of installing and servicing Bull

1300H/L & 1100H/L Cabinets.

Important:

Detailed installation and servicing instructions for rack-mountable servers and/or devices are

provided in the documentation delivered with these servers and/or devices.

Chapter 1. Overview

describes cabinet features.

Chapter 2. Installing and Servicing Cabinets

explains how to unpack, install, and service the cabinets.

Chapter 3. Managing Power and Data Cables

explains how to route and connect power and data cables inside the cabinets.

Appendix A. Specifications

Appendix B. Regulatory Statements and Disclaimers

Appendix C. Safety Notices

DANGER

Personnel are requested to carefully read the Safety Notices set out in Appendix C. before

installing or servicing cabinets.

Highlighting

The following highlighting conventions are used in this guide:

     

     

Italics     

  

         

viii

Installation & Service Guide

Unpacking Label

Figure 1. Unpacking label

1-1

Overview

Chapter 1. Overview

This chapter presents the different cabinet and power distribution unit models. It includes the

following topics:

• 1300H Cabinet and 1300H-E Cabinet, on page 1-3

• 1100H Cabinet and 1100H-E Cabinet, on page 1-4

• 1300L Cabinet and 1300L-E Cabinet, on page 1-5

• 1100L Cabinet and 1100L-E Cabinet, on page 1-6

• PDU-4-2-M-63A, on page 1-8

• PDU-2-4-M-32A, on page 1-9

• PDU-0-7-M-32A, on page 1-10

• PDU-0-12-M-32A, on page 1-11

1-2

Installation & Service Guide

Cabinet Models

Four main cabinet models and four extension cabinet models are available:

Main Cabinet Models Extension Cabinet Models

1300H Cabinet 1300H-E Cabinet

1100H Cabinet 1100H-E Cabinet

1300L Cabinet 1300L-E Cabinet

1100L Cabinet 1100L-E Cabinet

Note:

See Appendix A. Specifications for further details.

1-3

Overview

1300H Cabinet and 1300H-E Cabinet

The 1300H Cabinet and 1300H-E Cabinet are 600 mm wide, 40-U high, 1300 mm deep

cabinets.

The 1300H Cabinet and 1300H-E Cabinet allow the installation of both short and long

server and device drawers. Refer to the documentation delivered with the server and/or

device drawer for detailed installation instructions.

The 1300H Cabinet is delivered with side panels installed. The 1300H-E Cabinet is

delivered with or without side panels installed, according to required suite configuration.

Note:

• 1 U = 44.45 mm (1.75 in)

• Maximum allowable thermal dissipation: 400 W per U mean, 700 W per U peak

 

 

 

 

Figure 2. 1300H Cabinet / 1300H-E Cabinet features

1-4

Installation & Service Guide

1100H Cabinet and 1100H-E Cabinet

The 1100H Cabinet and 1100H-E Cabinet are 600 mm wide, 40-U high, 1100 mm deep

cabinets.

The 1100H Cabinet and 1100H-E Cabinet allow the installation of short server and device

drawers only. Refer to the documentation delivered with the server and/or device drawer for

detailed installation instructions.

The 1100H Cabinet is delivered with side panels installed. The 1100H-E Cabinet is

delivered with or without side panels, according to required suite configuration.

Note:

• 1 U = 44.45 mm (1.75 in)

• Maximum allowable thermal dissipation: 400 W per U mean, 700 W per U peak

 

 

 

 

Figure 3. 1100H Cabinet / 1100H-E Cabinet features

1-5

Overview

1300L Cabinet and 1300L-E Cabinet

The 1300L Cabinet and 1300L-E Cabinet are 600 mm wide, 19-U high, 1300 mm deep

cabinets.

The 1300L Cabinet and 1300L-E Cabinet allow the installation of both short and long server

and device drawers. Refer to the documentation delivered with the server and/or device

drawer for detailed installation instructions.

The 1300L Cabinet is delivered with side panels installed. The 1300L-E Cabinet is delivered

with or without side panels, according to required suite configuration.

Note:

• 1 U = 44.45 mm (1.75 in)

• Maximum allowable thermal dissipation: 400 W per U mean, 700 W per U peak

 

 

 

 

Figure 4. 1300L Cabinet / 1300L-E Cabinet features

1-6

Installation & Service Guide

1100L Cabinet and 1100L-E Cabinet

The 1100L Cabinet and 1100L-E Cabinet are 600 mm wide, 19-U high, 1100 mm deep

cabinets.

The 1100L Cabinet and 1100L-E Cabinet allow the installation of short server and device

drawers. Refer to the documentation delivered with the server and/or device drawer for

detailed installation instructions.

The 1100L Cabinet is delivered with side panels installed. The 1100L-E Cabinet is delivered

with or without side panels, according to required suite configuration.

Note:

• 1 U = 44.45 mm (1.75 in)

• Maximum allowable thermal dissipation: 400 W per U mean, 700 W per U peak

 

 

 

 

Figure 5. 1100L Cabinet / 1100L-E Cabinet features

1-7

Overview

PDU Models

Three Power Distribution Units (PDUs) are available:

• PDU-4-2-M-63A

• PDU-2-4-M-32A

• PDU-0-7-M-32A

• PDU-0-12-M-32A

According to type, the PDUs allow you to connect six, seven, or twelve servers and/or

devices to a single dedicated power supply outlet.

All PDUs can be installed both vertically and horizontally in the cabinet. Refer to the

documentation delivered with the PDU for detailed installation instructions.

Note:

See Appendix A. Specifications for further details.

1-8

Installation & Service Guide

PDU-4-2-M-63A

The PDU-4-2-M-63A allows you to connect up to six servers and/or devices. It offers the

following features:

• Phase: Single phase

• Max. Current: 63 A

• Max. Voltage: 240 VAC

• 14.5A (C19) Outlets: 4

• 9A (C13) Outlets: 2

• Mains Cable: 3xAWG06

• Mains Connectors: IEC60309-63A

CAUTION:

France:

Power sockets and plugs must be compliant with Decree 88-1056 Article 20-IV, dated 14th

November 1988.

Figure 6. PDU-4-2-M-63A features - vertical / horizontal installation

1-9

Overview

PDU-2-4-M-32A

The PDU-2-4-M-32A allows you to connect up to six servers and/or devices. It offers the

following features:

• Phase: Single phase

• Max. Current: 32 A

• Max. Voltage: 240 VAC

• 14.5A (C19) Outlets: 2

• 9A (C13) Outlets: 4

• Mains Cable: 3xAWG10

• Mains Connectors: IEC60309-32A

Figure 7. PDU-2-4-M-32A features -vertical / horizontal installation

1-10

Installation & Service Guide

PDU-0-7-M-32A

The PDU-0-7-M-32A allows you to connect up to seven servers and/or devices. It offers the

following features:

• Phase: Single phase

• Max. Current: 32 A

• Max. Voltage: 240 VAC

• 14.5A (C19) Outlets: 0

• 9A (C13) Outlets: 7

• Mains Cable: 3xAWG10

• Mains Connectors: IEC60309-32A

Figure 8. PDU-0-7-M-32A features - vertical / horizontal installation

Page is loading ...

Bull 1100 & 1300 Cabinet Installation guide

Bull 1100 & 1300 Cabinet Installation guide

Related papers

Other documents