Englander 25-CBPAH User manual

Brand: Englander

Model: 25-CBPAH

Category: Stoves

Type: User manual

This manual is also suitable for

55-SHPCBPAH







CAUTION

PLEASEREADTHISENTIREMANUALBEFOREINSTALLATIONANDUSEOFTHISPELLETFUEL‐BURNING

APPLIANCE.KEEPCHILDREN,FURNITURE,ANDALLCOMBUSTIBLESAWAYFROMANYHEATINGAPPLIANCE.



SAFETYNOTICE

FAILURETOFOLLOWTHESEINSTRUCTIONSCANRESULTINPROPERTYDAMAGE,BODILYINJURYOREVEN

DEATH.FORYOURSAFETYANDPROTECTION,FOLLOWTHEINSTALLATIONINSTRUCTIONSOUTLINEDIN

THISMANUAL.CONTACTYOURLOCALBUILDINGORFIREOFFICIALSABOUTRESTRICTIONSAND

INSTALLATIONINSPECTIONREQUIREMENTS(INCLUDINGPERMITS)INYOURAREA.



ManufacturedBy:

England’sStoveWorks,Inc.

POBox206

Monroe,VA24574

Rev.03/2019

SAVETHESEINSTRU CTIONS

INSTALLATION&OPERATION

MANUAL

25‐CBPAH

55‐SHPCBPAH

55‐TRPCBPAH



THISWOODHEATERNEEDSPERIODICINSPECTIONANDREPAIRFORPROPEROPERATION.CONSULTTHE

OWNER’SMANUALFORFURTHERINFORMATION.ITISAGAINSTFEDERALREGULATIONSTOOPERATETHIS

WOODHEATERINAMANNERINCONSISTENTWITHTHEOPERATINGINSTRUCTIONSINTHEOWNER’S

MANUAL.

www.heatredefined.com

Parts:(800)516‐3636

Support:(800)245‐6489

2

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.

IMPORTANT:IFYOUHAVEAPROBLEMWITHTHISUNIT,DONOTRETURNITTO

THEDEALER.CONTACTTECHNICALSUPPORT@1‐800‐245‐6489



TamperWarning:

Thiswoodheaterhasamanufacturer‐setminimumlowburnratethatmustnotbe

altered.Itisagainstfederalregulationstoalterthissettingorotherwiseoperate

thiswoodheaterinamannerinconsistentwithoperatinginstructionsinthis

manual.



MobileHomeUse:

Thisfreestandingpelletunitisapprovedformobilehomeordoublewide

installationwiththeoutsidecombustionairhook‐upSeethe“Installation”section

ofthismanualfordetailspertainingtomobilehomeinstallations.Mobilehome

installationmustbeinaccordancewiththeManufacturedHomeandSafety

Standard(HUD),CFR3280,Part24.



WARNING:

USEOFOUTSIDECOMBUSTIONAIRISMANDATORYWITHTHISUNIT.

DONOTOPERATEWITHTHEHOPPEROPEN;LIDMUSTBESHUTANDTIGHTLY

LATCHEDDURINGOPERATION.DONOTOVER‐FIREYOURUNIT.



Note:England’sStoveWorksdoesnotrecommendusingapelletstoveasyour

onlysourceofheat.

Retainforyourfiles

ModelNumber



DateofPurchase



DateofManufacture



SerialNumber





3

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.

Welcome!

Introduction

 ThankYou.........................................5

Specifications

 HeatingSpecifications.......................6

 Dimensions........................................6

 EPACompliance.................................6

Installation

 InstallationOverview...................7

 ClearancestoCombustibles.........8

 VentingIntroduction...................9

 VentingGuidelines.......................9

 AdditionalVentingInformation...10

 ApprovedVentingMethods

 ThroughtheWall...........11

 ThroughtheCeiling........12

 ExistingChimney............13

 MobileHomeInstallation............14

 VentTerminationClearances......15

 OutsideAirHookup.....................16

 FloorProtection...........................17

DailyOperation

 GettingStarted............................18

 LightingaFire..............................18

 DailyOperationNotes………………19

ControlBoard

 ControlBoardSettings................20

 ErrorCodes..................................21

 PowerFailure……..……………………22



Maintenance

 Daily

 ImportantNotes..............23

 DailyAshRemoval...........23

 CleaningtheBurnPot......24



 Weekly

 BaffleRemoval...........25

 Clean‐OutCovers.............25

 Monthly

 ImportantNotes…………….26

 VentingPipeCleaning…….27

 Yearly

 ImportantNotes..............28

 ExhaustBlower................29

 ConvectionBlower...........29

 HopperFines....................30

 CheckingGaskets.............30



 BasicTroubleshooting.......................31

ReplacingComponents

 AugerMotor.......................................33

 ConvectionBlower.............................34

 CombustionBlower............................35

 VacuumSwitch...................................36

 Igniter.................................................37

 Gaskets...............................................38

 Glass...................................................39

 ControlBoard.....................................40

 WiringDiagram..................................41

 HopperLidHinges..............................42 

 HopperLidHandle..............................42

 Panels………………………………………………43

 Finish……………………………………………….43

IllustratedPartsDetail

 ExplodedPartsDiagram……………………44

 PartsList……………………………………..…..45



Warranty

 SerialTagSample…………………….………..47

 WarrantyDetails……………………………....48

 ImportantNotice………….…….....…………50

 WarrantyReg.Form………………………….51

AIR WASH BAR PLACEMENT

CAUTION:TheAirWashBarmaybecomejarredlooseduringshipping.

BESUREthattheAirWashBarisinstalledproperlybeforeeachfire,

includingaftercleaningandmaintenance.



TheAirWashBarshouldfitintothetwoinstallationholesand‘lean

forward’onthefrontwallofthestove.



Thebendinthebarshouldbendtowardthefrontdooropening,andnot

backwardtowardtheburnpot.



InstallationHoles

AirWashChannels

FireBox

InstalltheAirWashBartabsintotheholes

andnotintotheairwashchannels

Thebendoftheairwashbar

shouldfaceTOWARDthefront

door

FrontDoorO

enin



AirWashBar

(installed)

AirWashBar

5

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INTRODUCTION

ThankyouforpurchasingthisfineproductfromEngland’sStoveWorks!

England’sStoveWorkswasstarted,andisstillownedby,afamilythatbelieves

stronglyina“DoItYourself”spirit;that’sonereasonyoufoundthisproductat

yourfavorite“DoItYourself”store.

Weintentionallydesignandbuild

ourstovessothatanyhomeownercanmaintain

theirstovewithbasictools,andwe’realwaysmorethanhappytohelpyoudothe

jobaseasilyandasinexpensivelyaspossible.However,whileremainingsimple,

ourstovesaredesignedtoperformextremelyefficiently,helpingdelivermore

heatfromless

fuel.

PleaselookattheextensiveHelpsectiononourwebsiteandcallourTechnical

SupportDepartmentat(800)245‐6489ifyouneedanyhelpwithyourstove.We

arenearlyalwaysableto“walkyouthrough”anyinstallationissues,repairs,

problemsorotherquestionsthatyoumayhave.



Wishingyouyearsofefficient,qualityand“comfy”heating,

EveryoneatEngland’sStoveWorks



PleaseNote:Whileinformationobtainedfromourwebsiteandthroughour

TechnicalSupportlineisalwaysfreeofcharge,therewillbeaservicecharge

incurredwithany“on‐site”repairsormaintenancethatwemayarrange.

Thismanualencompassesallversionsofthe25‐CBPAH,includingthe55‐SHPCBPAHandthe55‐TRPCBPAH.

However,forsimplicityofdescription,thestovewillbereferredtobythegeneric25‐CBPAHdesignation.





This manual is available for free download on the manufacturer’s web site. It is a copyrighted document and resale

is strictly prohibited. The manufacturer may update this manual occasionally and cannot be responsible for

problems including injuries or damages resulting from the use of information found in any manual from

unauthorized sources.

CAUTION:Stoveisheavy.

Inaddition,whenhandlinganysheetmetalproducts,beawarethattheremaybesharpedgesorburrs.

Althoughwemakeeveryefforttoeliminateanysharpedges,pleaseusecautionwhenhandlinganymetalparts.

Remembertodisconnect(unplug)thestovefromthepowersourceand

allowittocompletelycooldown

beforeperforminganymaintenance.

6

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



SPECIFICATIONS

HeatingSpecifications



 ApproximatePelletBurnRate**………….…………0.7to1.7kg/hr(1.5to3.8lbs/hr)

 MaximumBurnTime**………………………………………………………………………..76hours

 HeatOutput**…………………………………………………………13,429‐21,807BTU/hr

 ApproximateSquareFootageHeated***…….………………………….upto2,200sq.ft.

 HopperCapacity………………………………………………………………………….…..120pounds

Dimensions



EPAandSafetyComplianceSpecifications

 EPAComplianceStatus…….........................................Certifiedtocomplywith2020particulate

emissionstandardsusingpelletfuel.

 U.S.TestStandard:USEPA40CFRPart60,Subpart60.536

 ParticulateEmissions …………………………………………………………………0.763grams/hr

 COEmissions………………………………………………………………………….0.013grams/min

 Efficiency………………………………………………………………………………………77.6%(HHV)

 TestedToUL1482‐00,ASTME1509,ULC/ORD‐C1482‐M1990&ULCS627‐00

Notesforthisunit:Productmayvaryslightlyfromdiagram.Clearancesaretheminimumforthisunit

andmayneedtobeincreasedinthereartohaveproperventclearances.Followallventingmanufacturer

clearancesandlocalcodes.

*‐AstestedperASTM2779‐10

**‐Heatoutput,burnrateandmaximumburntimeareheavilydependentonthetypeofpelletsburnedinthestove;assuch,thesenumbersmayvary.

***‐Themaximumheatingcapacityofthisunitcanvarygreatlybasedonclimate,constructionstyle,insulation

andamyriadofotherfactors.Usethisinformation

inconjunctionwithaBTUlosscalculationforyourhometodetermineifthisunitwillbesufficientforyourneeds.

7

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

InstallationOverview

Whenchoosingalocationforyournewstove,thereareamultitudeoffactorsthat

shouldbetakenintoaccountbeforebeginningtheinstallation.

1. TrafficPatterns–Tohelppreventaccidents,thestoveshouldbeplacedinalocation

whereitisout ofthewayofnormaltravelthrough

thehome.

2. HeatFlowandEfficiency–Whendecidingonalocationforthestove,considertheway

heatmovesthroughoutyourhome.Installthestovewhereyouneedtheheat;

basementinstallationsoftendonotallowsufficientheattoflowtotheupperfloorsand

atopfloor

installationwillnotallowanyheattoreachthefloorsbelow. Always 

considerthatheatrisesandwilltakethepathofleastresistancewhileitisstillhot.

3. ExhaustLocation–Outsidewallsaregenerallythebestplacetoinstalla stove,since

theyalloweasyexhaustandintake

airinstallation(usingourDuraVentAC‐3000Kit,AC‐

33000ifCanada).Ifthereisnotafeasiblewaytoinstallthestoveonanoutsidewall,

therearemethodsforventingthestoveupthroughtheroof,buttheytendtobemore

costlybecausetheyinvolvethe

useofmorepelletventpipeandcanoftenmakeoutside

airinstallationmoredifficult.

4. WallConstruction–Locatingthestovesothattheexhaustsystemcanpassbetween

studswillsimplifytheinstallationandeliminatetheneedtoreframeanysectionsofthe

walltoaccommodatethewallthimble.



Warning

 Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any

other appliance.

 Do Not Over fire – If any external part starts to glow, you are over firing. Reduce feed rate.

Over firing will void your warranty.

 Comply with all minimum clearances to combustibles as specified. Failure to comply may

result in a house fire.

 Tested and approved for wood pellets only. Burning any other fuel will void your warranty.

 For use with Premium grade wood pellets only.

8

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

ClearancestoCombustibles



 



CAUTION

 UnitcanbeveryHOTwhileinoperation.Keepchildrenaway.

 Supervisechildreninthesameroomasthisappliance.

 Alertchildrenandadultstothehazardsofhightemperatures.

 DoNOToperatewithprotectivebarriersopenorremoved.

 Keepclothing,furniture,draperiesandothercombustiblesaway.

 InstallationMUSTcomplywithlocal,regional,stateandnationalcodesandregulations.

 Consultlocalbuilding,fireofficialsorauthoritieshavingjurisdictio n about restrictions,install a tioninspection,and

permits.

DONOTCONNECTTOANYAIRDISTRIBUTIONDUCTORSYSTEM

UnittoRear

Wall(A)

UnittoSide

Wall(B)

UnittoCorner

(C)

0in. 8in. 6in.

0mm 203mm 152mm

9

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

VentingIntroduction

 Thispelletstoveoperatesonanegativedraftsystem,whichpullscombustionairthroughthe

burnpotandpushestheexhaustairthroughtheventpipeandoutofthebuilding.Thisunitmustbe

installedinaccordancewiththefollowingdetaileddescriptionsofventingtechniques;notinstalling

thestovein

accordancewiththedetailslistedherecanresultinpoorstoveperformance,property

damage,bodilyinjuryordeath.England’sStoveWorksisnotresponsibleforanydamageincurred

duetoapoororunsafeinstallation.

 Ifquestionsarisepertainingtothesafeinstallationofthestove,ourTechnicalSupportline



(800‐245‐6489)isavailable.Contactyourlocalcodeofficialtobecertainyourinstallationmeetslocal

andnationalfirecodesandifyou’reuncertainabouthowtosafelyinstallthestove,westrongly

recommendcontactingalocalNFIcertifiedinstallertoperformtheinstallation.

VentingGuidelines

 WARNING‐INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.

 ALWAYSinstallventpipeinstrictadherencewiththeinstructionsandclearancesincludedwith

yourventingsystem.

 DONOTconnectthispelletstovetoachimneyfluewhichalsoservesanotherappliance.

 DONOTinstalla

fluepipedamperoranyotherrestrictivedeviceintheexhaustventingsystem

ofthisunit.

 USEanapprovedwallthimblewhenpassingthroughawallandaceilingsupport/firestop

whenpassingthroughaceiling.

 ONLYuse3.0”or4.0”TypeLorTypePLpipeapproved

forpelletstoveventing;DONOTuse

galvanizedorB‐Ventpipe.

 SEALeachjointofpelletventwithhightemperaturesilicone(Part#AC‐RTV3)toprevent

smokespillageintothehome.

 AVOIDexcessivehorizontalrunsandelbows,asbothwillreducethedraftoftheventing

system

andwillresultinpoorstoveperformance.

 INCLUDEasmuchverticalpipeaspossibletopreventsmokefromtheunitfromenteringyour

homeintheeventofapoweroutage.

 INSPECTyourventingsystemoften,tobecertainitisclearoffly‐ashandotherrestrictions.

 CLEANtheventingsystemasdetailedinthemaintenancesectionofthismanual.



WARNING

 INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.

 HOT!Donottouch!Severeburnsorclothingignitionmayresult.

 Glassandothersurfacesarehotduringoperation.

 Donotattempttotouchoropenthefrontorsidepanelsduringoperation.Thiscouldresultinsevere



burnsorin

.

10

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

AdditionalVentingInformation

 Donotmixandmatchcomponentsfromdifferentpipemanufacturerswhenassemblingyour

ventingsystem(i.e.DoNOTuseventingpipefromonemanufacturerandathimblefrom

another).

 Werequireaminimumverticalriseof36in.(3ft.)ofpipetocreatenaturaldraftinthesystem.



Thishelpsevacuatesmokefromthestoveintheeventofapowerfailureorcombustion

blowerfailure.

 Ventingsystems15.0ft.orshortermaybecomposedentirelyof3.0in.pelletpipe;toreduce

frictionallosses,ventingsystemslongerthan15.0ft.shouldbecomposedof4.0in.

pelletpipe.

 Donotterminatetheventingsystemdirectlybeneathanycombustiblestructuresuchasa

porchordeck.

 FollowNFPA211ruleslistedbelowforventingsystemterminationlocationrelativeto

windowsandotheropeningsinthedwelling.

o NFPA211(2006ed.)Section10.4Termination:10.4.5

(1)

Theexitterminalofamechanicaldraftsystemotherthandirectventappliances

(sealedcombustionsystemappliances)shallbelocatedinaccordancewiththe

following:

 (a)Notlessthan3ft.(.91m)aboveanyforcedairinletlocatedwithin10ft.

(3.0m).

 (b)Notlessthan4

ft.(1.2m)below,4ft.(1.2m)horizontallyfromor1ft.(305

mm)aboveanydoor,windoworgravityairinletintoanybuilding.

 (c)Notlessthan2ft.(0.61m)fromanadjacentbuildingandnotlessthan7ft.

(2.1m)abovegradewhenlocated

adjacenttopublicwalkways.

 Distancebetweentheterminationopeningandgradeshouldbeaminimumof2ft.(24in.)

contingentonthegradesurfacebelowthetermination.Whendeterminingthetermination

heightabovegrade,considersnowdriftlinesandcombustiblessuchasgrassorleaf

accumulation.Inareas

wheresignificantsnowfallispossible,theterminationheightmustbe

sufficientlyhightokeeptheterminationfreeofsnowaccumulation.

 Donotusemakeshiftcompromisesduringinstallationorinstallanycomponentoftheunitor

ventingsysteminsuchamannerthatcouldresultinahazardousinstallation.

 A

chimneyconnectorshallnotpassthroughanatticorroofspace,closetorsimilarconcealed

space,orafloor,orceiling.

 Wherepassagethroughawallorpartitionofcombustiblematerialisdesired,theinstallation

shallconformtoCAN/CSA‐B365.

WARNING:

VentingsystemsurfacesgetHOT,andcancauseburnsiftouched.

Noncombustibleshieldingorguardsmayberequired.

11

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

ApprovedVentingMethod1:ThroughtheWall



 Generallythesimplestinstallationmethod,venting

throughthewallusingourAC‐3000kit,AC‐33000ifCanada

(orsimilarventingsystem)isalsothepreferredventing

method.Itminimizeshorizontalpipe,allowsthestoveto

beinstalledclosetothewallandkeepstheclean‐outtee

onthe

outsideofthehouse,foreaseofcleaning.

 Wheninstallinganyventingsystem,TypeLorTypePL

pipemustbeusedandallclearancestocombustibles

(listedbythepipemanufacturer)mustbestrictlyadhered

to.

 Usethepipemanufacturer’sapprovedthimblefor

passingthroughacombustible

wall,andmaintainatleast

theminimumclearancestocombustibles.

 Useanappliancecollarwherethepelletventconnects

totheexhaustoutputofthepelletstoveandattachthe

appliancecollartotheexhaustbloweroutputusingthree

sheetmetalscrews.

 Securethepelletventtotheoutside

ofthehouseusingawallstrapjustbelowthe90degree

elbow.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemisleak

free(Checkwiththespecificventingsystemmanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingused

isnota“TwistLock”system,three(3)sheetmetalscrewsare

requiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyourstoveorusing

analternativemethod,asdescribedinthe“OutsideAir”section,onpage16.

Thisinstallationtype

canbemodifiedforbasement(Basementinstallationsshouldalwaysbe

performedbyaprofessionalinstaller)orotherinstallationswhereintheteeandverticalsectionof

thepipewouldbeinsidethehomeandtheventingsystemwouldsimplypasshorizontallythrough

thethimbleandthenterminate.



PleaseNote:

Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplansforeach

individualinstallation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancestocombustibles,

andfollowalllocalcodes.

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(3”)tofour‐inch(4”).

12

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

ApprovedVentingMethod2:ThroughtheCeiling



 Ventingthroughtheceiling/roofmaybetheonlyfeasible

ventingoptioninsomecasesandisafactoryrecommended

installation.

 Wheninstallinganyventingsystem,TypeLorTypePLpipe

mustbeusedandallclearancestocombustibleslistedbythe

pipemanufacturermustbestrictlyadheredto.



 Usethepipemanufacturer’sapprovedceilingsupportfor

passingthroughacombustibleceiling,aswellastherequired

firestops,radiationshields,flashingandstormcollar.

 Becertaintofollowthemanufacturer’srequiredheightof

terminationabovetheroofline,andmaintainatleastthe

minimumclearancesto

combustibles.

 Useanappliancecollarwherethepelletventconnectstothe

exhaustoutputofthepelletstoveandattachtheappliance

collartotheexhaustbloweroutputusingthreesheetmetal

screws.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemisleak



free(Checkwiththespecificpipemanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingusedisnota“TwistLock”system,three(3)sheetmetalscrewsare

requiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwith

yourstoveorusing

analternativemethod,asdescribedinthe“OutsideAir”section,onpage16.

 Thisventingmethodcanalsobemodifiedsothattheventingsystemrunshorizontallythroughthe

wallfromthestove,thentransitionstoverticalandterminatesabovetheroofline.Whenusing

thismodified

versionofthisinstallationbecertaintocarefullyfollowtheventingsystem

manufacturer’sinstructionsdiligently.



PleaseNote:

Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplansforeach

individualinstallation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancestocombustibles,and

followalllocalcodes.



Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(3”)tofour‐inch(4”).

13

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

ApprovedVentingMethod3:ExistingChimneySystem

 Usinganexistingmasonryorfactorybuiltchimneyforventingistheonlyotheracceptablemethod

forventingthispelletunit.

 UseTypeLorTypePLventingpipeuntilenteringthe

existingchimney.Usetheappropriatelysizedadapterwhen

transitioningfromthepelletventpipetothemasonry

or

factorybuiltthimbleandbecertainthattheadapteris

sealedtightlytoboththepelletventingsystemandthe

existingchimney.

 Beforeusinganexistingchimney,becertainitisingood

condition(Achimneysweepinspectionishighly

recommended).Also,makesurethechimneymeetsthe

minimumstandardslistedinNFPA211(Achimney

professionalcanconfirmthisuponinspection).

 Ifconnectingthisstovetoafactorybuiltchimney,itmay

ONLYbea6”flue,UL103HTventingsystem(ULCS629if

Canada).Connectiontoanyotherfactorybuiltchimneymay

resultinapoorly

operatingordangerousstoveinstallation.

 Whenconnectingtoanexistingmasonrychimney,thecross‐sectionalareaofthefluemustbe

considered.Achimneywithafluelargerthan6”round(28.27sq.in.)mayrequirereliningwithan

approvedpelletstovechimneyliningsystem.

 Useanappliance

collarwherethepelletventconnectstotheexhaustoutputofthepelletstove

andattachtheappliancecollartotheexhaustbloweroutputusingthreesheetmetalscrews.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemisleak

free(Checkwiththespecific

pipemanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingusedisnota“TwistLock”system,three(3)sheetmetalscrewsare

requiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyourstoveorusing

an

alternativemethod,asdescribedinthe“OutsideAir”section,onpage16.



PleaseNote:

Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplansforeachindividual

installation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancestocombustibles,andfollowalllocal

codes.

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(3”)tofour‐inch(4”).

14

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

MobileHomeInstallation

 TheEngland’sStoveWorks,Inc.outsideairkitMUSTbeusedforinstallationofthisunitina

mobilehome.Pleaseseethe“OutsideAir”sectiononpage16formoreinformationregarding

outsideairconnections.

 Theoutsideairinletmustbekeptclearofleaves,iceandother

debris.Keepingtheoutsideair

inletfreeofrestrictioniscrucialtopreventingairstarvationandsmokespillage.

 ThepelletstoveMUSTbesecuredtothefloorofthemobilehomeusinglagboltsandtheholes

providedinthebottomofthebaseforthispurpose.Outdoor‐aired

spaceheatersmustbe

attachedtothestructure.

 ThepelletstoveMUSTbegroundedwith#8solidcoppergroundingwire(orequivalent),

terminatedateachendwithanNECapprovedgroundeddevice.

 CarefullyfollowallclearanceslistedintheappropriatesectionofthismanualANDfollowthe

ventingmanufacturer’s

minimumclearancerequirements.Similarly,becertaintheventing

systemusedisapprovedformobilehomeuse.

 InstallationmustbeinaccordancewithManufacturersHome&SafetyStandard(HUD)CFR3280,

Part24aswellasanyapplicablelocalcodes.

 Usesiliconetocreateaneffectivevaporbarrierat

thelocationwherethechimneyoroutsideair

ductingpassesthroughtotheexteriorofthestructure.



CAUTION

THESTRUCTURALINTEGRITYOFTHEMANUFACTUREDHOMEFLOOR,WALLANDCEILING/ROOFMUSTBE

MAINTAINED.DONOTCUTTHROUGHFLOORJOISTS,WALLSTUDS,CEILINGTRUSSESORANYOTHER

SUPPORTINGMATERIALWHICHCOULDBEDETRIMENTALTOTHESTRUCTURALINTEGRITYOFTHEHOME.

WARNING:DONOTINSTALLINASLEEPINGROOM.

JoistShield/Firestop MobileHomeApproved

TypeLorTypePLPellet

VentPipe

ChimneyCap/SparkArrestor RoofFlashingandStorm

Collar

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(3”)tofour‐inch(4”).

15

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



VENTTERMINATIONCLEARANCES

A)Min.4‐ftclearancebeloworbesideanydoororwindow that opens.

B)Min.1‐ftclearanceaboveanydoororwindowthatopens.

C)Min.2‐ftclearancefromanyadjacentbuilding.

D)Min.7‐ftclearancefromanygradewhenadjacenttopublicwalkways.

E)Min.2

‐ftclearanceaboveanygrass,plants,orothercombustiblematerials.

F)Min.3‐ftclearancefromaforcedairintakeofanyappliance.

G)Min.2‐ftclearancebeloweavesoroverhang.

H)Min.1‐ftclearancehorizontallyfromcombustiblewall.

I)Ventsinstalledwithmechanicalexhaustersshallterminatenot

lessthan12in.(305mm)abovethe

highestpointwheretheypassthroughtheroofsurface.





NotesonterminationofPelletVentPipefromNFPA211(2006ed.)Section10.4Termination:10.4.5

(Seealso“INSTALLATION”sectionofmanualANDadditionalnotesabove):

 Notlessthanthree(3)feetaboveanyforcedairinletlocatedwithinten(10)feet.

 Notlessthanfour(4)feetbelow,four(4)feethorizontallyfrom,orone(1)footaboveanydoor,

windoworgravityairinletintoanybuilding.

 Notlessthantwo(2)feetfromanadjacentbuilding,andnotlessthanseven(7)feetabovegrade

wherelocatedadjacenttopublicwalkways.

Theexhaustexitshallbea rrangedsothatthefluegases arenotdirectedsothatitwillaffectpeople,overheat

combustiblestructures,orenterbuildings.Forceddraftsystemsandallpartsofinduceddraftsystemsunderpositive

pressureduringoperationshallbeinstalledgastightortopreventleakageofcombustion

productsintoa building.

Through‐the‐wallventsshallnotterminateoverpublicwalkways,orwherecondensateorvaporcouldcreatehazards

oranuisance.

Besuretofollowlocalcodesandallmanufacturer’sinstructions(includingexhaustpipe).

Consultaprofessional installerand/orcallTechnicalSupportifyouhaveany

questions.

16

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



OUTSIDEAIRHOOK‐UP

 Theuseofoutsidecombustionairismandatoryonthispelletstove.

 Theoutsideairconnectionpipeprotrudesfromthelowerrearcenterofthe

stove;usetheincludedoutsideairkittoattachyourstovetooutside

combustionair.Instructionsandallthepartsneededtomakethe

outsideair

connectiontoyourpelletstoveareincludedwiththeoutsideairkit.

 Ifitisnotfeasibletousetheincludedoutsideairhookupkitinyour stove

installation,othermaterialsmaybeused,providedthefollowingrulesare

followed:

 Thepipeusedforoutsideair

hookupmustbemetal,withaminimum

thicknessof.0209in.(25gaugemildsteel)orgreaterandaninside

diameterofapproximately2.0in.

 Allpipejointsandconnectionsshouldbesealedwithpipeclampsorother

mechanicalmeans,toinsurealeakfreeoutsideairconnection.

 Long

runsofpipeandexcessiveelbowsforoutsideairshouldbeavoided.

Duetofrictionalresistanceinpipe,anyexcessiveoutsideairpipingcan

resultinpoorstoveperformance.

 Ascreenorotherprotectiondevicemustbefittedovertheoutsideair

terminationpointtopreventrain,debrisand

nuisanceanimalsfrom

enteringthepipingsystem.

 Increasetheoutsideairpipesizeto3.0in.diameterpipeiftheoutsideair

connectionismorethan6ft.inlength,morethantwo(2)elbowsareused

orifthestoveisinstalledinabasement.

 Theoutsideair

connectionsystemshouldbeinspectedatleastannuallytobe

certainitisfreefromblockage.



Caution

NEVERdrawoutsidecombustionairfrom:

1.Wall,floororceilingcavity.

2.Enclosedspacesuchasanattic,garageorcrawlspace.

17

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



FLOORPROTECTION

 Thispelletstoverequiresanon‐combustiblefloorprotectorifthestoveistobeinstalledonacombustible

floor.Ifthefloorthestoveistobeinstalledonisalreadynon‐combustible(i.e.aconcretefloorina

basement)andhasanRvalueequaltoorhigher

than.2,nofloorprotectionisneeded(althougha

decorativefloorprotectorcanstillbeusedforaestheticreasons).

 PrefabricatedfloorprotectorswhichareULlisted(ULCifCanada)orequivalentcanbepurchasedorafloor

protectorcanbebuiltfromstandardmaterials:twosheetsof.5”thick

cementboardcoveredwithceramic

tilewouldbeasuitablefloorprotectorwhichmeetsthe.2R‐valuerequirement.

 Whenusinganyfloorprotector,considerthatthisstoveisnotonlyheavybutwillinduceheatingand

coolingcyclesonthefloorprotectorwhichcandamagetileandloosenmortarandgroutjoints.Ahearth

rugisNOTanapprovedsubstituteforaproperhearthpad.

 FortheUSandCanada:Thefloorprotectormustextendatleast6in.(152mm)fromthefront&sides.

 InCanada,itisrequiredthatthenon‐combustiblefloorprotectorisunderneathandextends2in.(50.8

mm.)oneithersideofanyhorizontalventingrunsAND/ORisdirectlyunderneathanyverticalventing

pipe.





18

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



DAILYOPERATION

GettingStarted

 Checktoseethatthehopperiscleanandfreefromforeignmaterials.Besuretoconnectthisunittoa

workingoutlet;werecommendusingasurgeprotectortohelpprotecttheelectroniccomponentsfrom

damage.

 BEFOREyourfirstfire,dryrunyourunit(nopelletfuelinthehopper)fortwentyminutes;pressingthe

“ON”buttonwiththeunitpluggedinwillinitiatethedryrun.

 Oncethe“ON”buttonispressed,youshouldimmediatelyheartheexhaustblowerstartand

operatecontinuously.

 Afteraboutthreetofiveminutes,lookfortheredglowoftheigniterintheigniterportoftheburn

pottobecertainitisoperatingnormally.

 Holdthehopperlidswitch(See“IllustratedPartsDiagram”pg.44)downwithyourfingerandcheck

toseethattheaugeristurning.Releasethehopperlidswitchandbecertainthattheaugerstops

turning.DONOTPUTYOURFINGERSINTHEHOPPERORNEARTHEROTATINGAUGER.

 Afterabouttwentyminutes,thecontrolboardshoulddisplay“E‐2”inthetwodisplaywindows(More

informationonErrorCodescanbefoundintheErrorCodesectionofthismanual).

 Atthispoint,thedryruniscompleteandyourpelletheatingapplianceisreadyfornormaloperation.

LightingaFire

 Inorderforthisstovetooperate,thehoppermustfirstbefilledwithpelletfuel.Liftthehopperlidusing

theflush‐mounthandleandpourthepelletfueldirectlyintothehopper.

 WerecommendusingonlypelletsmanufacturedbyPFICertifiedfacilities,sincepelletsbearing

thePFIstampofapprovalwillbelowinashandmoisture,highinBTU’s,anduniforminsizeand

quality.

 Thispelletstovewillperformequallywellusingsoftwoodandhardwoodpellets,andalthoughtheashmay

differslightlyinappearanceortexture,bothtypesofpelletswillburncleanlyandefficientlyinthisstove.

 Thispelletstoveisequippedwithanautomaticpelletignitionsystem;theonlyuserinputrequiredtolight

thestoveisasimplepressofthe“On”button.

 Shortlyafterpressingthe“On”button,theletters“SU”willappearintheheatrangeandblowerspeed

windowsofthecontrolboard.Thisindicatesthestovehasenteredthestart‐upsequenceandisoperating

normally.

 Thefuelfeedrateandcombustionairduringstart‐upisdeterminedbythecontrolboard,sothestovemay

bestartedonanyheatrange.

 Afterapproximatelyfifteenminutes,thefireshouldbeburningbrightlyandthe“SU”shoulddisappear

fromthecontrolboard.Atthispoint,thestovehasbegunnormaloperationandthedisplaywindowson

thecontrolboardwillremainempty,unlesstheHeatRangeorBlowerSpeedisadjusted.

19

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



 Itisnormalfortheunittosmokeduringthefirstfire,aspaintsandoilscure.Thisshoulddissipatewithin

thefirsthour.Openadoorand/orwindowduringthefirstfiretoventilatethearea.



DailyOperationNotes

 Onlyhighquality,PremiumGrade¼”(.25in.)diameterwoodpelletsshouldbeusedinthisstove.Using

lowgradewoodpelletswithhighashcontentORwoodpelletswithahighmoisturecontentcancausethe

burnpottofillwithashatamorerapidpaceandcancauseintervalsbetweenperiodicmaintenanceto

becomesignificantlyshorter.Pleasereadthe“Maintenance”sectionofthismanualthoroughlyto

understandhowfuelselectionaffectsstoveoperation,maintenanceandcleaning.

 Variationintheflameheightisnormal;notallwoodpelletfuelisuniforminsize,whichcanaffecttheway

pelletsarefedintotheburnpot.Althoughtheflameheightmayincreaseanddecreaseduringoperation,

thereisnolossofefficiency.

 Alwaysstorewoodpelletfuelinadrylocation;storingwoodpelletfuelinadrylocationensuresthefuel

willremainpelletizedandlowinmoisturecontent.Also,becertainthatallwoodpelletfuelisstoredata

safedistancefromthepelletheater;storingfuelincloseproximitytothestovecanresultinafire.Donot

installoroperatethisunitoutside,inagreenhouse,orinanyareathatishighinmoisture.

 Thispelletburningroomheaterisequippedwithaspeciallydesignedburnpotwhichcomespreinstalled

fromthefactory.Thisburnpotelevatestheburningpelletsanddeliversairattheprecisely‐required

locations.Pelletsmustonlybeburnedinthefactoryburnpot;nomodificationsshouldbemadetothis

burnpotandnoadditionalgratesorotherfireelevatorsshouldbeused.



CAUTION

NEVERUSEGASOLINE,GASOLINE‐TYPELANTERNFUEL,KEROSENE,CHARCOALLIGHTERFLUID,OR

SIMILARLIQUIDSTOSTARTOR“FRESHENUP”AFIREINTHISHEATER.KEEPALLSUCHLIQUIDS

WELLAWAYFROMTHEHEATERWHILEINUSE.ADDITIONALLY,NEVERAPPLYFIRE‐STARTERTO

ANYHOTSURFACEOREMBERSINTHESTOVE.DONOTUSECHEMICALSORFLUIDS

TOSTARTTHEFIRE.

DONOTBURNFLAMMABLEFLUIDSSUCHASGASOLINE,NAPHTHAORENGINEOIL.

DONOTBURNGARBAGE;LAWNCLIPPINGSORYARDWASTE;MATERIALSCONTAININGRUBBER,

INCLUDINGTIRES;MATERIALSCONTAININGPLASTIC;WASTEPETROLEUMPRODUCTS,PAINTOR

PAINTTHINNERS,ORASPHALTPRODUCTS;MATERIALSCONTAININGASBESTOS;CONSTRUCTION

ORDEMOLITIONDEBRIS;RAILROADTIESORPRESSURE‐TREATEDWOOD;MANUREORANIMAL

REMAINS;PAPERPRODUCTS,CARDBOARD,PLYWOODORPARTICLEBOARD.THEPROHIBITION

AGAINSTBURNINGTHESEMATERIALSDOESNOTPROHIBITTHEUSEOFFIRESTARTERSMADEFROM

PAPER,CARDBOARD,SAWDUST,WAXANDSIMILARSUBSTANCESFORTHEPURPOSEOFSTARTING

AFIREINANAFFECTEDWOODHEATER.BURNINGTHESEMATERIALSMAYRESULTINRELEASEOF

TOXICFUMESORRENDERTHEHEATERINEFFECTIVEANDCAUSESMOKE.

20

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



 CONTROLBOARDSETTINGS

Thecontrolboardonthisstoveallowstheusertoadjusttheheatoutputandconvectionblowerspeed,turn

theunitonandoff,andtestcomponentsforfunction(moreondiagnosticmodelater).

 Thelowerbuttonsonthecontrolboard(LowFuelFeed,LowBurnAir,andAironTemp)arenotmeantto

beadjustedduringnormaloperationoftheunit.Thesebuttonsarefactorypresetandcannotbeadjusted

bytheuser.

 Toenergizetheunitandinitiateafire,pressthe“On”button.TheLEDabovethebuttonshouldturngreen

andthecontrolboardshoulddisplay“SU”shortlyafterpressingthebutton.

 Toshuttheunitdown,pressthe“Off”button.TheLEDabovethebuttonshouldturnredandtheboard

shoulddisplay“Sd”shortlyafterpressingthebutton.Thisinitiatestheshutdownsequence,andthe

stovewillremaininshutdownmodeuntilithascooleddown.

 Toincreasetheheatoutputofthestove,pressthe“Up”heatrangebutton.Thenumberintheheatrange

displaywindowwillincrease,signifyingthatthecontrolboardisnowadjustingtheheatoutputtoyour

desiredlevel.Theblowerspeedwillincreasethesameamountastheheatrange,becausethestoveis

designedtooperatewiththeblowerspeedgreaterthanorequaltotheheatrange.Pressingthe“Down”

arrowwilldecreasetheheatrangeandblowerspeed.

 Toincreasetheblowerspeedwithoutincreasingtheheatrange,presstheBlowerSpeed“Up”arrowuntil

thedesiredblowerspeedisshowninthedisplaywindow.Pressingthe“Down”arrowwilldecreasethe

blowerspeed;however,thecontrolboardwillnotallowtheblowerspeedtobesetlowerthantheheat

range.

Caution

Thisunitismeanttooperateonlywiththemainviewingdoorclosed.Smoke

spillageandaninefficient,lazyburnwillresultfromattemptingtooperatethe

stovewiththedooropen.

Inaddition,usingfuelotherthanwoodpelletscancreateanunsafesituationand

canalsogenerateexcesscarbon

monoxide.Carbonmonoxideisanodorless,

colorlessgaswhichcanbedeadly.

BurnONLYwoodpellets.

CarbonMonoxideDetector

England’sStoveWorks,Inc.highlyrecommendstheuseofacarbonmonoxide

detectorintheproximityofthestoveandoneperfloorofthehome.

Acertainamountofcarbonmonoxideisproducedwithinthestoveasaby‐productofcombustion.

AllexhaustventconnectionsmustbesealedwithRTVSiliconetoassureatightseal.Anyleaksinto

aconfinedareacausedbyfaultyinstallationorimproperoperationofthestovecouldproduce

dizziness,nauseaandinextremecases,death.TheCOconcentrationduringtestingwasfoundto

be0.013g/min.

Page is loading ...

Englander 25-CBPAH User manual

Brand: Englander

Model: 25-CBPAH

Category: Stoves

Type: User manual

This manual is also suitable for

55-SHPCBPAH

Download PDF

report

in other languages

français: Englander 25-CBPAH Manuel utilisateur

Englander 25-CBPAH User manual

This manual is also suitable for

Englander 25-CBPAH User manual

in other languages

Related papers

Other documents