Heat & Glo TIARAI-BR-IPI Installation guide

Brand: Heat & Glo

Model: TIARAI-BR-IPI

Category: Fireplaces

Type: Installation guide

This manual is also suitable for

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/141

Installation Manual

Installation and Appliance Setup

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

NOTICE: DO NOT discard this manual!

This appliance may be installed as an OEM installation

in manufactured home (USA only) or mobile home and

must be installed in accordance with the manufacturer’s

instructions and the manufactured home construction

and safety standard, Title 24 CFR, Part 3280 or Standard

for Installation in Mobile Homes, CAN/CSA Z240MH, in

Canada.

This appliance is only for use with the type(s) of gas

indicated on the rating plate.

In the Commonwealth of Massachusetts installation must be



See Table of Contents for location of additional Commonwealth



WARNING: If the information in these

instructions is not followed exactly, a re

or explosion may result causing property

damage, personal injury, or death.

 DO NOT store or use gasoline or other





• What to do if you smell gas

- DO NOT

- DO NOT     DO

NOT

- Immediately call your gas supplier from a





- If you cannot reach your gas supplier, call



 





Models:

TIARAI-BK-IPI

TIARAI-BR-IPI

TIARAI-CES-IPI

TIARAI-BK-IPIL

TIARAI-BR-IPIL

TIARAI-CES-IPIL

HOT GLASS WILL CAUSE



DO NOT TOUCH GLASS UNTIL



NEVER ALLOW CHILDREN TO



WARNING

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/142

Safety Alert Key:

• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.

• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.

• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

• NOTICE: Used to address practices not related to personal injury.

Installation Standard Work Checklist3

1 Product Specic and Important Safety Information

 4

 4

 4

 4

 4

  4

4

   5

2 Getting Started

 6

 6

 6

3 Framing and Clearances

 7

  8

 8

4 Termination Location and Vent Information

 9

 10

  11

  12

 12

 13

13

5 Vent Clearances and Framing

  30

 30

 31

  31

6 Appliance Preparation

32

 35

7 Venting and Chimneys

36

  37

  38

  38

 40

  42

8 Electrical Information

 44

  45

9 Gas Information

 48

 48

 48

 48

  49

10 Appliance Setup

  50

  50

 50

  51

  52

11 Reference Materials

  53

 58



Table of Contents



Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/143

Installation Standard Work Checklist

Customer:

Lot/Address:

Model (circle one): TIARAI-BK-IPI TIARAI-BK-IPIL

TIARAI-BR-IPI TIARAI-BR-IPIL

TIARAI-CES-IPI TIARAI-CES-IPIL

Date Installed:

Location of Stove:

Installer:

Dealer/Distributor Phone #

Serial #:

Comments: Further description of the issues, who is responsible (Installer/ Builder/ Other Trades, etc) and corrective

action needed _____________________________________________________________________________________

_________________________________________________________________________________________________

Comments Communicated to party responsible ____________________ by ______________________on ___________

(Builder / Gen. Contractor/) (Installer) (Date)

Appliance Install YES IF NO, WHY?

Veri ed combustible or non-combustible clearances to walls. (Pg. 8) ___________________________

Stove is installed level. (Pg. 35) ___________________________

Venting/Chimney Section 7 (Pg 36-43)

Venting con guration complies with allowable vent requirements. ___________________________

Venting installed, locked and secured in place with proper clearance. ___________________________

Interior/Exterior  restops installed and sealed. ___________________________

Attic insulation shield installed. ___________________________

Exterior wall/Roof  ashing installed and sealed. ___________________________

Terminations/Roof  ashing installed and sealed. ___________________________

Electrical Section 8 (Pg 44-47)

Unswitched power (110-120 VAC) provided for the appliance. ___________________________

Switch wires properly installed. ___________________________

Gas Section 9 (Pg 48-49)

Appliance con guration matches fuel type. ___________________________

Was a conversion performed? ___________________________

Leak check performed and inlet/outlet pressure veri ed. ___________________________

Set air shutter for optimal  ame appearance. ___________________________

Appliance Setup Section 10 (Pg 50-52)

All packaging and protective materials are from removed inside/under/on

the appliance). ___________________________

Refractories, logs, and embers installed correctly. ___________________________

Glass assembly installed and secured. ___________________________

Accessories installed properly. ___________________________

Mesh, doors, or decorative front properly installed. ___________________________

Manual bag and all of its contents are removed from inside/under

the appliance and given to party responsible for use and operation. ___________________________

Started appliance and veri ed no gas leaks exist. ___________________________

2342-982 Rev. B 2/14

 = Contains updated information.

Hearth & Home Technologies recommends the following:

• Photographing the installation and copying this checklist for your  le.

• That this checklist remain visible at all times on the appliance until the installation is complete.

This standard work checklist is to be used by the installer in conjunction with, not instead of, the instructions contained in

this

installation manual.

WARNING! Risk of Fire or Explosion! Failure to install appliance according to these instructions can

lead to a  re or explosion.

ATTENTION INSTALLER:

Follow this Standard Work Checklist

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/144

B. Glass Specications

        





C. BTU Specications

        

      

Burning Heating Appliances for Manufactured Homes and





NOTICE: This installation must conform with local codes. In

the absence of local codes you must comply with the National

Fuel Gas Code, ANSI Z223.1-latest edition in the U.S.A. and

the CAN/CGA B149 Installation Codes in Canada.

A. Appliance Certication

NOT INTENDED FOR USE AS A PRIMARY HEAT SOURCE.



           



1 Product Specic and Important Safety Information

MODELS: TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI

LABORATORY: Underwriters Laboratories, Inc. (UL)

TYPE: Direct Vent Heater

STANDARD: ANSI Z21.88-2009/CSA 2.33-2009

D. High Altitude Installations

NOTICE: If the heating value of the gas has been reduced,

these rules do not apply. Check with your local gas utility or

authorities having jurisdiction.



 









      







E. Non-Combustible Materials Specication



those consisting entirely of steel, iron, brick, tile, concrete,



Materials that are reported as passing ASTM E 136,

Standard Test Method for Behavior of Materials in a

Vertical Tube Furnace at 750 ºC shall be considered non-



F. Combustible Materials Specication

Materials made of or surfaced with wood, compressed paper,



        



G. Electrical Codes

NOTICE: This appliance must be electrically wired and

grounded in accordance with local codes or, in the absence

of local codes, with National Electric Code ANSI/NFPA

70-latest edition or the Canadian Electric Code CSA

C22.1.

 

with ground-fault circuit-interrupter protection, in

compliance with the applicable electrical codes, when

it is installed in locations such as in bathrooms or near



Models

(U.S. or Canada)

Maximum

Input

BTU/h

Minimum

Input

BTU/h

Orice

Size

(DMS)







(NG)

(0-2000 FT) 25,000 19,500 42









(0-2000 FT) 22,500 16,500 54

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/145

H. Requirements for the Commonwealth of

Massachusetts

 

        

whole or in part for residential purposes, including those

owned or operated by the Commonwealth and where

         

          

including but not limited to decks and porches, the following



Installation of Carbon Monoxide Detectors



        



with an alarm and battery back-up is installed on the

          

        

        



         











equipment is installed in a crawl space or an attic, the hard

       





be met at the time of completion of installation, the owner

           

      





Approved Carbon Monoxide Detectors







Signage











“GAS VENT DIRECTLY

BELOW. KEEP CLEAR OF ALL OBSTRUCTIONS”.

Note:     

Massachusetts and national codes not contained in this



Inspection



       



      

       



Exemptions





   





 

equipment installed in a room or structure separate from

the dwelling, building or structure used in whole or in part



MANUFACTURER REQUIREMENTS

Gas Equipment Venting System Provided

       

      

       

      

        



        



          



Gas Equipment Venting System NOT Provided

       



 

      



 

be included with the appliance or equipment installation



 

by the Board, and the instructions for that system shall





       

       





See Gas Connection section for additional

Commonwealth of Massachusetts requirements.

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/146

2 Getting Started

A. Design and Installation Considerations

         

operate with all combustion air siphoned from outside of the





Installation MUST comply with local, regional, state and

    

       

     



Before

 

 

 

 

 



C. Inspect Appliance and Components

 



       



 

         



 Read all of the instructions before starting the

installation. Follow these instructions carefully during

the installation to ensure maximum safety and benet.

WARNING! Risk of Fire or Explosion! Damaged parts

could impair safe operation. DO NOT install damaged,

incomplete or substitute components. Keep appliance dry.

B. Tools and Supplies Needed

Before beginning the installation be sure that the following



 

 

 

 

 

 

 







     

rating)



Hearth & Home Technologies disclaims any responsibility for,



 



 

         



 

 



Any such action may cause a re hazard.

WARNING! Risk of Fire, Explosion or Electric Shock! DO

NOT use this appliance if any part has been under water.

Call a qualied service technician to inspect the appliance

and to replace any part of the control system and/or gas

control which has been under water.

     

       







      







Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/147

3 Framing and Clearances

A. Appliance Dimension Diagram



Figure 3.1 Appliance Dimensions

Location Inches Millimeter Location Inches Millimeter

A 590 D  514

B 237 E  298

C 27 686 20 506

NOTE: Diagrams show gas appliance equipped without optional Blower, Part #GFK-160A.

FRONT SIDE

BACK

GAS LINE

ELECTRICAL

CORD

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/148

B. Clearances to Combustibles

When selecting a location for the appliance it is important to



WARNING! Risk of Fire or Burns! Provide adequate

clearance around air openings and for service access. Due

to high temperatures, the appliance should be located out of

trafc and away from furniture and draperies.

NOTICE: Illustrations reect typical installations and are FOR

DESIGN PURPOSES ONLY. Illustrations/diagrams are not

drawn to scale. Actual installation may vary due to individual

design preference.

NOTICE: Some carpet materials may be sensitive to radiant

heat from the appliance causing discoloration or odor.

Figure 3.2 Appliance Locations

Model A B C D E F G

Top of

pipe

Side of

pipe

Inside Outside

corner wall



TIARAI-IPI

Inches    54 36  27 3 1 9

Millimeters 216 6 10 1372 914 1022 686 76 25 229

"A"

measurement is from

stove top, not side

C. Hearth Extension/Floor Protection

CAUTION! Risk of Fire or Injury! Install appliance on

a stable, level, platform or oor strong enough to support

appliance without tipping.

        



strong enough to support the appliance without a tipping



NOTE:

      





Note:



Alcove Installation

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/149

A. Vent Termination Minimum Clearances

Roof Pitch H (Min.) Ft.











 

 

 



Figure 4.1 Minimum Height From Roof To Lowest Discharge Opening

HORIZONTAL

OVERHANG

VERTICAL

WALL

GAS DIRECT VENT

TERMINATION CAP

ROOF PITCH

IS X/ 12

LOWEST

DISCHARGE

OPENING

2 FT.

MIN.

20 INCHES MIN.

H (MIN.) - MINIMUM HEIGHT FROM ROOF

TO LOWEST DISCHARGE OPENING

4 Termination Location and Vent Information



     



 DO NOT pack air space with insulation or other







Figure 4.2 Staggered Termination Caps

Gas, Wood or Fuel Oil

Termination Cap

Gas

Termination

Cap **

A *

*If using decorative cap cover(s), this distance may need to be

increased. Refer to the installation instructions supplied with the

decorative cap cover.

A B

6 in. (minimum) up to 20 in.

152 mm/508 mm

18 in. minimum

457 mm

20 in. and over 0 in. minimum

In a staggered installation with both gas and wood or fuel oil

terminations, the wood or fuel oil termination cap must be

higher than the gas termination cap.

WARNING

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1410

B. Chimney Diagram

Figure 4.3 Minimum Clearances for Termination

A = 12 inches   

porch, deck or balcony

B = clearance to window or door that may

be opened, or to permanently closed

window

C = 18 inches

18 inches

30 inches    



D = 9 inchesclearance to outside corner

E = 6 inchesclearance to inside corner

        



   

regulator

G = 3 ft

outlet

H = 12 clearance to non-mechanical

(unpowered) air supply inlet,

    

termination

  

  clearance to a mechanical (powered)

air supply inlet

All mechanical air intakes within 10 feet of a termination cap must



   On public



          





H or i

X= AIR SUPPLY INLET

V= VENT TERMINAL

= AREA WHERE TERMINAL IS NOT PERMITTED

Electrical

Service

V K

QMIN RMAX

1 cap 3 feet ACTUAL

2 caps 6 feet ACTUAL

3 caps 9 feet ACTUAL

4 caps 12 feet ACTUAL

QMIN = # termination caps x 3 RMAX = (2 / # termination caps) x QACTUAL

Covered Alcove Applications



N = 6 inches  

12 inches  

O = 18 inches  

42 inches  

  





CAUTION! Risk of Burns! Termination caps are HOT, consider

proximity to doors, trafc areas or where people may pass or

gather (sidewalk, deck, patio, etc.). Listed cap shields available.

Contact your dealer.

 

 NOT

 



 





 

M = 18 inches     



42 inches 





K = 6 inches clearance from sides of electrical



L = 12 inches





Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1411

C. Approved Pipe

         





DO NOT 





        



WARNING! Risk of Fire or Asphyxiation. This appliance

requires a separate vent. DO NOT vent to a pipe serving a

separate solid fuel burning appliance.

DO NOT USE FIELD-FABRICATED VENTING

COMPONENTS

        

















  is required



       is required when the



 



 



Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1412

D. Use of Elbows



         









         







Figure 4.4

HORIZONTAL

VERTICAL

RUN

RISE

EFFECTIVE

LENGTH

Vent Type X

Inches Millimeters

  286

Vent

Type

X Y

Inches Millimeters Inches Millimeters

 5 127  298

SLP

Pipe

Effective Length Rise/Run

Inches Millimeters Inches Millimeters

 4 102  70

 6 152  108

 12 305  216

 24 610 17 432

 36 914  648

 48 1219 34 864

 3 to 6 76 to 152  54-108

 3 to 12 76 to 305  54-216

Figure 4.5 Vertical and Horizontal Offset for SLP Elbows

E. Measuring Standards

       



 





       





       



 

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1413

G. Vent Diagrams



     





 



 



 





 



 





       



4 ft min.

(1.22 m)

Figure 4.7

Figure 4.6

F. Venting Guidelines for Horizontal Runs

Snorkel Kit







Snorkel kit and derating





 

is 10 ft (3m)



o

Elbow (No Rise)



Snorkel kit and derating







Rise



must be used prior to any

-













one -



Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1414

Figure 4.8

One Elbow

Top Vent - Horizontal Termination

V1H1 Maximum

 305 mm  356 mm

 610 mm  

   

   

   

   

   

   

   

   

   

   

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1415

Two Elbows

INSTALLED

HORIZONTALLY

2 Elbows to Max. Horizontal

V1 Minimum H1 + H2 Maximum

 610 mm  

   

   

   

   

   

   

   

   

   787 mm

   533 mm

Figure 4.9

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1416

Figure 4.10

Top Vent - Horizontal Termination - (continued)

Three Elbows

3 Elbows to Max. Horizontal

V1 Minimum H1 + H2 Maximum

 610 mm  914 mm

   

   

   

   

   

   

   

   457 mm

   279 mm

   279 mm

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1417

Top Vent - Vertical Termination

No Elbow

Figure 4.11

V1 = 30 ft. Max. (9.1 m)

V1 = 6 ft. Min. (1.8 m)

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1418

Figure 4.12

Two Elbows

2 Elbows to Max. Horizontal

V1 Minimum V1 + V2 Maximum H1 Maximum

 610 mm    

     

     

     

     

     

     

     

     

     787 mm

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1419

Figure 4.13

Top Vent - Vertical Termination - (continued)

Three Elbows

INSTALLED

HORIZONTALLY

H2V1

3 Elbows to Max. Horizontal

V1 Minimum V1 + V2 Maximum H1 + H2 Maximum

 610 mm    

     

     

     

     

     

     

     

     457 mm

Heat & Glo • TIARAI-BK-IPI, TIARAI-BR-IPI, TIARAI-CES-IPI Installation Manual • 2342-980_R8 • 11/1420

Rear Vent - Horizontal Termination

Figure 4.14

Figure 4.15

No Elbow

H1 = 14 in. (356 mm) Maximum

Note:      



Note:      



Note:



Note:



NOTICE: An SLK-SNKD is required for this

vent conguration.

NOTICE: An SLK-SNKD is required for this

vent conguration.

One 45º Elbow

Rear Vent - Horizontal Termination

Page is loading ...

Heat & Glo TIARAI-BR-IPI Installation guide

Brand: Heat & Glo

Model: TIARAI-BR-IPI

Category: Fireplaces

Type: Installation guide

This manual is also suitable for

Download PDF

report

Heat & Glo TIARAI-BR-IPI Installation guide

This manual is also suitable for

Heat & Glo TIARAI-BR-IPI Installation guide

Related papers

Other documents