Stratasys CleanStation CSIIP Installation guide

Brand: Stratasys

Model: CleanStation CSIIP

Type: Installation guide

DOC-03204 Rev. B



CLEANSTATION™ CSIIP

INSTALLATION GUIDE



CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 2

ThisdocumentationcontainsproprietaryinformationofStratasysLtd.This

informationissuppliedsolelytoassistauthorizedusersofthiscleaningsystem.

Nopartofthisdocumentmaybeusedforotherpurposes,anditmaynotbe

disclosedtootherparties.

Thespecificationsonwhichthisdocumentisbasedaresubjecttochangewithout

notice.

Nopartofthisbookmaybereproducedinanyformorbyanymeans,norstored

inadatabaseorretrievalsystem,withoutpriorpermissioninwritingfrom

StratasysLtd.

IfthisdocumentisdistributedasaPDFfile,youmayprintitforinternaluse.

February2016

DOC-03204Rev.B

Trademarks

StratasysisaregisteredtrademarkofStratasysLtd.

Allnamesofproductsandservicescitedinthisbookaretrademarksorregistered

trademarksoftheirrespectivecompanies.

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 3

Contents

1 Introduction 4

1.1 About this Guide 4

2 Safety Guidelines 5

3 Installation 6

3.1 Required Items 6

3.2 Unpacking the CleanStation™ CSIIP 6

3.3 Connecting the Water Supply and Drainage Hoses 11

3.4 Attaching a Plug to the Power Cable (for 220 V Units) 12

3.5 Plugging the Power Cable into the Power Outlet 13

3.6 Leveling the CleanStation™ CSIIP 14

4 Post-Installation 15

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 4

1 Introduction

TheCleanStation™CSIIPusesagitationandanalkalinecleaningsolutionto

rapidlydissolvesolubleSupportmaterialfromprintedpartsandmodels.

1.1 About this Guide

Theinformationandrequirementsprovidedinthisdocumentensureproper

installationoftheCleanStation™CSIIP.InstalltheCleanStation™CSIIPas

describedinthisdocument.

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 5

2 Safety Guidelines

Thefollowinggeneralguidelines,togetherwiththeinstructionsprovided

throughoutthisguide,ensureusersafetywhileoperatingandmaintainingthe

CleanStation™CSIIP.If the system is not installed and operated as

specified, the user's safety might be compromised.

• MakesurethatthesitehasbeenpreparedasspecifiedintheSitePreparation

Guide.

• Allelectricalworkistobeperformedbypersonnelqualifiedbylocal

authorities.

• Thepowercableshouldbeconnectedtoaneasilyaccessibleelectricsocket

neartheCleanStation™CSIIPlocation.

• MakesurethataResidualCurrentDevice(RCD)hasbeeninstalled.

• NevermovetheCleanStation™CSIIPwhenthereisliquidinthetank.



CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 6

3 Installation

3.1 Required Items

Prepare the following:

• protectiveglasses

• utilityknife

• strapcutter

• scissors

• Phillipsscrewdriver

• 14-mmsocketwrench

• 3.2-mmhex(Allen

)key

3.2 Unpacking the CleanStation™ CSIIP

To unpack the unit:

1. Checktheshockdetectorlabeltoensurethatthepackagehasnotbeen

damaged.

2. Makesurethatthepackagehasbeenmovedascloseaspossibletoitsfinal

location.

3. Usingstrapcutters,carefullycutthestrapsaroundthepackage.

Warning: Impact hazard.

The straps are tightly wrapped around the package and can cause injury

when suddenly released. Stand clear of the straps while cutting them.

Figure 1 Cutting the straps

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 7

4. UsingaPhillipsscrewdriver,removethescrewsthatsecurethepackagetoits

platforms.

Figure 2 Removing the package screws

5. Removethepackagingfromtheunit.

Figure 3 Removing the packaging

6. Removetherampandpositionitbehindtheunit.

The ramp is packed between the back of the unit and the foam supports.

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 8

7. Removethestart-upkit.

Figure 4 Unit with start-up kit and ramp lowered

8. Usingscissors,removethewrappingfromtheunit.

Figure 5 Removing the wrapping

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 9

9. Turnthelevelingfeetadjustmentgearstoraisethelegsuntiltheunitrestson

itsfourwheels.

Figure 6 Lowering the unit onto its wheels

10.Rolltheunitoffoftheplatformtoitsfinallocation.

11.Usinga3.2mmhexkey,removethethreescrewsshownbelow,butdonot

discardthem.

Figure 7 Removing the screws

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 10

12.Installtheventcoverwiththethreescrewsremovedinstep11.

Figure 8 Installing the vent cover

13.Usinga3.2-mmhexkey,removetheprotectivecovershownbelow.

Figure 9 Removing the protective cover

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 11

3.3 Connecting the Water Supply and Drainage Hoses

To connect the water supply hose:

1. AttachthesupplyhosetotheSUPPLYinlet.

2. Attachtheotherendofthehosetothefacilitiestap.

To connect the drainage hose:

3. AttachthedrainhosetotheDRAINoutlet.

4. Attachtheotherendofthehosetoadrain,accordingtolocalwastedisposal

regulations.

Caution:

When the selector switch (on the operator panel) is set to DRAIN TANK

and the CONTROL VALVE is set to DRAIN TANK, high pressure can

cause the drain hose to be freed from the drain if it is not properly secured.

Make sure that the drain hose is securely attached to the drain.

Figure 10 Water connection diagram

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 12

3.4 Attaching a Plug to the Power Cable (for 220 V Units)

It is the customer’s responsibility to ensure that the power connector is prepared by personnel

qualified by local authorities.

TheCleanStation™CSIIPunitisshippedwithoneofthefollowing:

• for 90-120 VAC:apowercable,includingaNEMA5-15(TypeB)plug

suitablefortheUSA.Forregionswiththisvoltagethatuseadifferenttypeof

plug,thecustomermustprovideaplugthatmeetslocalrequirementsand

haveitinstalledbypersonnelqualifiedbylocalauthorities.

• for 220-240 VAC:a14AWGpowercable,withnoplugattached.Forthese

areas,thecustomermustprovideaplugthatmeetslocalrequirementsand

haveitinstalledbypersonnelqualifiedbylocalauthorities.

Ifnecessary,attachthepowerplugrequiredbylocalauthorities.

Figure 11 Schematic diagram of 220 V power cable

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 13

3.5 Plugging the Power Cable into the Power Outlet

To power-on the CleanStation™ CSIIP:

1. Opentheoperatorpaneldoor.

2. MakesurethattheselectorswitchissettoOFF.

3. PlugtheCleanStation™CSIIPintothepoweroutletatthesite.

Figure 12 Plugging in the unit

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 14

3.6 Leveling the CleanStation™ CSIIP

1. Turnthelevelingfeetadjustmentgearsuntiltheunitrestsonitslevelingfeet.

2. Placeaspiritlevelonthetopcoverorientedfrombacktofront.

3. Adjustthelevelingfeetasshownbelowuntilthebubbleindicatesthattheunit

islevel.

Figure 13 Leveling the unit—front to back

4. Orientspiritlevelfromlefttorightandrepeatstep3.

Figure 14 Leveling the unit—left to right

5. Aftertheunitislevel,makesurethatitisnotrestingonanyofitswheels.

CleanStation™ CSIIP Installation Guide

DOC-03204 Rev. B 15

4 Post-Installation

Performthefollowing,asdescribedintheCleanStation™CSIIPUserGuideor

theServiceManual:

1. Openthefacilitieswatersupplytapandfillthetank.

There is no automatic shutoff valve. You need to shut the water tap when

the tank is full.

2. Drainthetankwithoutactivatingthepump.

3. Whilethetankisstillbeingdrained,activatethepumpandmakesurethatthe

flowincreases.

4. Fillthetankwithwater.

5. Verifythatthecontrollerissettothedesiredtemperatureunits.

6. Setthecontrollertotwominutes,recordthetime,andactivatethesystem

fromthecontroller.

7. WhiletheCleanStation™CSIIPisactive:

• Increaseanddecreasethewateragitationandmakesurethattheagitation

changesaccordingly.

• Makesurethatthejetsarefunctional.

8. MakesurethattheCleanStation™CSIIPturnsoffaftertwominutes.

9. TrainthecustomeronproperuseoftheCleanStation™CSIIP,usingtheUser

Guideasareference.

Stratasys CleanStation CSIIP Installation guide

Stratasys CleanStation CSIIP Installation guide

Stratasys CleanStation CSIIP Installation guide

Related papers

Other documents