Road Armor Stealth Full Width Rear Bumper Installation guide

Brand: Road Armor

Model: Stealth Full Width Rear Bumper

Type: Installation guide

This manual is also suitable for

Page(1of5)

INSTALLINSTRUCTIONS

JeepJKRearStealthBumper

Product:508R0B,508R0B‐TC

Applicaon:2007+JeepWranglerJK

(2Doorand4Door)

2007+JeepWranglerRearBumperPage(2of5)

www.ROADARMOR.com

INSTALL INSTRUCTIONS



SAFETYFIRST!

 FOLLOWALLINSTRUCTIONS,YOURSAFETYANDTHESAFETYOFOTHERSISMOSTIMPORTANT.

 WEARAPPROPRIATEEYEPROTECTIONANDEXERCISECAUTIONWHENDRILLING/CUTTING

REQUIREDTOOLS



INCLUDEDHARDWARE TIRECARRIERPARTS

IWARNING

Readtheinstruconscompletelybeforebeginninginstallaon.Beforeghteningbolts,

drillingorcungwhererequired,checktomakesuretherearenoobstruconssuchas

brake,fuelorelectricallineswhichmaybedamaged.Alsokeepinmindthisisanaer‐

marketproductandMAYrequireminorshimmingand/ortrimming,reaming,etc.for

properﬁt.RoadArmorisnotresponsibleforanydamagestovehicle.

IMPORTANT NOTICE

 Besuretoinspectandtestﬁtyourproducttoensureproperﬁtmentbeforehavingitcoated,painted,bed

lined,etc.

 RoadArmorwillnotberesponsibleforthecostofcoangyourunitifanyproblemswithﬁtorﬁnisharenot

notedandaddressedbeforehand.

MetricandSAESocketSetsandWrenches5/16HexBitSocketorAllenWrench

5/8DrillBitorStepBitSmallPryBarorLargeFlatheadScrewdriver

(6)1/2”x1.5”BoltTabs(2)BrashBushings

(6)1/2”KeeperWashers(1)Latch

(10)1/2”Grade8Washers(1)StrikerPad

(10)1/2”Grade8LockWashers(6)3/8‐16x1.25”StainlessBuonHeadBolts

(4)1/2”x1.5”Grade8Bolts(6)3/8”StainlessWasher/(6)3/8”StainlessNylocks

(2)DoubleNutPlates(4)5/16‐18x1”StainlessBuonHeadBolts

(1)StainSteelRoadArmorLogoLeersandBoltKit(3)1/2‐13x1”Grade8Bolts

(2)1/4‐20x1.25”CounterSinkSocketHeadCapScrews

(2)1/4‐20Nylocks/(2)1/4”Washers

(1)1/2‐20x1.25”BuonHeadwithNylonPatch

(3)1/2‐20WheelStuds

2007+JeepWranglerRearBumperPage(3of5)

www.ROADARMOR.com

INSTALL INSTRUCTIONS

1Usinga16mmsocket,removetheboltssecuringtheinnermounngbracketstotherearcrossmember.

2Nowremovethe2boltssecuringtherearbumperoutermounngbrackets.Setasidetheseboltsastheywillbereused.

3Removefactoryrecoveryhookifequipped.Oneboltontheboomandtwothroughtheframe.Discardthenutplate.

KEEPBOLTS

4Pulloﬀfactorybumperandsetaside.

5InstallRoadArmorLogowithincluded#10StainlessBuonHeadBoltsandKepsNuts.

6InstallLightsasthisiseasiernowthanaerRoadArmorbumperhasbeeninstalled.

7Fitupandinstallincludedframebracketstooutsideofframeasshown.Included

nutplategoesinsideframe.Re‐usefactoryboltsfromStep2wherecircled.

IFYOUDONOTHAVETHETIRECARRIERROADARMORBUMPERSKIPTOSTEP17

8Removethesparerefromtailgateandsetitaside.

9Usinga13mmsocket,removethe8boltssecuringthesparerecarriermounttothetailgateandallowtohang.

10Ontheinsideofthetailgatenearthelatch,popouttheventedplascpiecetogainaccesstowiring.

STOP

11Pressdownontheplascclipandthenunplugthe3rdbrakelightwiringharnessandremovealongwiththepass

2007+JeepWranglerRearBumperPage(4of5)

www.ROADARMOR.com

INSTALL INSTRUCTIONS

13AachStrikerPadwithtwo(2)1/4‐20CounterSunkScrewswith1/4”washerandNylocknutsontheinsideofbumper.

14AachTireCarrierarmbyﬁrstﬁngonebrassbushing(ﬂangedown)overthehingepin.Thenﬁttheopenendofthe

recarrierarmoverthebushingandbeginslidingthesecondbrassbusingdownoverthehingepin(ﬂangeup).Fitupthe

supportbracketandthreadthe1/2”BuonHeadthroughbracketintohingepin,butdonotghten.Now,usingthe3/8”

hardwareboltonthesupportbracket.Besuretogeteveryboltstartedbeforefullyghtening.

TIPThethree(3)3/8”buonheadboltsthatclampthebrassbushingsoverthehingepinadjusttheﬁrmnessoftheswing.

Donotoverghtentheseasyoucoulddamagethebushings,butghtenthemunlyouarehappywiththeresistance.

15Thethree1/2”Grade8boltstriangulateoverthewheelmountsha.Thisshaallowsforsomeinandoutadjustment.

Besuretocranktheseboltsdownandcheckthemperiodically!

16InstalltheincludedwheelstudsthroughtheholesasmarkedifyouhavestockJeepaxles.Theseholeswillneedtobe

drilledoutto5/8”usingastepbitifyouhaveone.x3

12AachLatchtoTireCarrierarmusingthefour(4)5/16”StainlessSteelBuonHeadBolts.

2007+JeepWranglerRearBumperPage(5of5)

www.ROADARMOR.com

INSTALL INSTRUCTIONS

18FitupyournewRoad

ArmorBumperandstarta

washer,lockwasherand

nutovereachbolt.

Onceallnutsareﬁnger

ght,checkﬁtmentand

ghtenthemalldown.

Checkthatallthebracket

boltsarefullyghtaswell.

IFYOUHAVEANYINTERFERENCEISSUESWITHTHEFACTORYTOWHITCHRECEIVER

Pullthewiringharnessstraightdownandoutofit’smountandzipeitoutoftheway.

Removethe4boltssecuringthetowhitchreceivertotherearcrossmemberusingan18mmsocket.

Ifthetowhitchreceiverisdiﬃculttoremove,useaprybartoassistinremoval.

NowinstallbumperasinSTEP18,thenusingaﬂoorjackandablockofwood,re‐installthetowhitch.

TIRECARRIERASSEMBLED—CONTINUEFROMHERE

17InstalltheBoltTabsthroughbumperusingtheincludedkeeperwashers.Usea3/4”deepsockettopushthewashers

overthethreads.

Road Armor Stealth Full Width Rear Bumper Installation guide

Brand: Road Armor

Model: Stealth Full Width Rear Bumper

Type: Installation guide

This manual is also suitable for

Download PDF

report

Road Armor Stealth Full Width Rear Bumper Installation guide

This manual is also suitable for

Road Armor Stealth Full Width Rear Bumper Installation guide

Related papers

Other documents