Sealey FOAM GUN FOR EXPANDING User manual

Brand: Sealey

Model: FOAM GUN FOR EXPANDING

Type: User manual

FOAM GUN FOR EXPANDING FOAM

CARTRIDGES

MODEL NO: FG001

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these

instructions, and properly maintained, give you years of trouble free performance.

IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE

THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR

PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.

1. SAFETY

9 Always read the foam and cleaner manufacturers’ instructions when handling and using their product in conjunction with this gun.

9 Only use the gun in adequately ventilated rooms with the correct respiratory protection equipment

9 Manyfoamproductscontainhighlyinammablechemicals,DO NOTuseintheproximityofanyopenames,cigarettesoranyother

 potentialcauseofcombustion

9 Alwayswearapprovedsafetyclothingandpersonalprotectionequipment:gloves,gogglesforeyeprotection,amaskwiththe 

 appropriateactivatedcarbonlterswhenworkingwiththefoamgun.

9 Keep the gun out of the reach of children.

9 Maintaintheguningoodcondition.Replaceorrepairdamagedparts.Userecommendedpartsonly.Unauthorisedpartsmaybe 

dangerous and will invalidate the warranty.

9 Keepchildrenandunauthorisedpersonsawayfromtheworkarea.

9 Avoid unintentional operation.

8 DO NOTholdgunorattachmentsclosetoyourface(especiallyeyes,ears,etc.)andDO NOT point gun at other persons or animals.

8 DO NOT use the gun for any purpose other than that for which it is designed.

8 DO NOT operate the gun if damaged.

9 Whennotinusestoreinasafe,dry,childproofarea.

2. INTRODUCTION

Atopqualitymetalgunforusewithgungradepolyurethaneexpandingfoams.Screwsontothecanisterforquickandeasyapplication.Easy

foamgunforexpandingfoamadjustableowcontrol.Stainlesssteelbarrelandneedle.

3. SPECIFICATION

Model No.: .................................................................. FG001

4. OPERATION

4.1. Alwaysinspectthegunbeforeusetoensureitisnotdamaged.If 

 indoubtdonotusethegunandcontactyourSealeyStockist.

4.2. Shakecanvigorouslyfor30secondspriortoinstallingontofoamgun.

4.3. Makesurethegunbasketisperfectlycleanandapplysomepetro-jelly

 orlightgreasetotheinsideofthegunbasketarea.Thishelpsprevent

 foamfromcuringtothebasketandgluingthecanontothegun.

4.4. Screw the cartridge onto the gun’s adaptor until it is tight. DO NOT over

tighten as this may cause damage to the threads.

4.5. Pullthetriggertostartthefoamow,thismayberegulatedbythebeadsizeadjusteruntilthedesiredfoambeadisachieved

4.6. Releasethetriggerandtightenthesizeadjustertolocktheneedleintheclosedposition,topreventaccidentaldischargewhen 

the gun is not in use.

4.7. Always store the gun with the can attached in the normal use position.

4.8. Replaceemptycartridgesassoonaspossibletoavoidhardeningofthefoaminthegun.

4.9. Tore-use,simplyshakethefoamcanvigorouslyfor30seconds.

4.10 Whenthecartridgeisemptiedunscrewitoutofthefoamgunsocket.Cleanpossibledirtwithcleanserandscrewnewcartridgein.

5. MAINTENANCE

5.1. Ifthegunisnottobereloadeditmustbecleanedassoonaspossibleafterthecartridgehasbeenremovedtoavoidhardeningof

the foam inside the gun.

5.2. Oncethefoamhasbecomehardsolventswillnotnecessarilydissolveallresidues.

5.3. Alwaysensureallfoamisreleasedfromthegunbeforecleaning.

8 DO NOT use water to clean the gun.

5.4. Onlycleanthegunwithrecommendedcleaningsolvents,anyothersolventsmaydamagethegun.

5.5. Leavethesolventinthegunfor2minutes.Releasethesolventbypressingthetriggerandrepeatthisprocessuntilthesolvent 

FG001Issue110/06/22

Original Language Version

©JackSealeyLimited

Refer to

instructions

g.1

Wear eye

protection

Wear protective

gloves

Wear Face

Mask

(Filtered)

BeadSizeAdjuster

 runsclearandshowsnotraceoffoam.Unscrewtheregulatingknobandremovetheneedle,cleantheneedlewithnonabrasive

cleaning solvent.

NOTE:-hardenedfoamwilldamagetheneedle.Removethefrontnozzlewithasetscrewwrenchandcheckthenozzlefor 

 hardenedfoam.Cleanasnecessarywithanappropriatesolvent.

Original Language Version

Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR

01284 757500 01284 703534 sales@sealey.co.uk www.sealey.co.uk

ENVIRONMENT PROTECTION

Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento

arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely

unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids

according to local regulations.

Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponent

parts without prior notice.

Important:NoLiabilityisacceptedforincorrectuseofthisproduct.

Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.

PURCHASE HERE

FG001Issue110/06/22

Sealey FOAM GUN FOR EXPANDING User manual

Sealey FOAM GUN FOR EXPANDING User manual

Sealey FOAM GUN FOR EXPANDING User manual

Related papers

Other documents