2. Sealey
  3. AK4564D.V2

Sealey AK4564D.V2 User manual

  • Hello! I am an AI chatbot trained to assist you with the Sealey AK4564D.V2 User manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
OIL HOSE END GUN
MODEL NO: AK4564D.V2
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
WARNING! Ensure health & safety, local authority, and general workshop practice regulations are strictly adhered to when using this
equipment.
9 Familiariseyourselfwithproductapplicationandlimitations,aswellasthespecicpotentialhazardspeculiartothisproduct.
9 Maintainthepumpstationingoodcondition(useanauthorisedserviceagent).
9 Replaceorrepairdamagedparts.Use genuine parts only. Non authorised parts will invalidate the warranty.
9 UseonlytodispenselubricantsuptoSAE150viscosity.
9 Ensuresafetyeyeprotectionandprotectiveclothingarewornwhenusingthisproduct.
9 Keeptheworkareaclean,unclutteredandensurethereisadequatelighting.
9 Maintaincorrectbalanceandfooting.Ensuretheoorisnotslipperyandwearnonslipshoes.
9 Keepchildrenandunauthorisedpersonsawayfromtheworkingarea.
9 Afteruse,drainanyuidsfromtheequipmentbeforestorage.
9 Disposeofwasteliquidsinaccordancewithlocalauthorityregulations.
9 Disconnectairpressurefromequipmentwhennotinuse.
8 DO NOT exceedthemaximumworkingpressureof1500psi.
8 DO NOT pointthenozzleatpeopleoranimals.
8 DO NOT usetheequipmentnearopenames.
8 DO NOT smokewhilstusingthisequipment.
8 DO NOT usetoextractcorrosiveuids.
8 DO NOTdismantle,tamperwithoradaptthegunforanypurposeotherthanforwhichitisdesigned.
8 DO NOT usetheunitifithasbeendroppedormishandled,checktheunittoensurethereisnodamage.
9 Keepthegunandnozzlecleanandstoreinasafedry,childprooflocation.
WARNING! DO NOT allow uncontrolled discharge of uids thus polluting the environment. All liquids must be disposed of according to
local authority regulations.
2. INTRODUCTION
Robustoildispensinggunincorporatingmanualshuto.Fittedwithrigidextension,handlelockandnon-dripnozzle.
Pleasenotethatthisgunisnotapprovedforresaleofoil.
3. SPECIFICATION
Model no............................................................AK4564D.V2
Max.owrate............................................................ 35L/min
Inletsize....................................................................1/2”BSP
Max.outputpressure.................................................1500psi
4. ASSEMBLY
4.1.  Attachthenozzleassemblytothegun.
4.2.  Insertthelterintotheinletconnectionandthenattach
 thesupplyhose.
NOTE: DO NOT over tighten the inlet swivel connection or
 damagemayresult.
Refer to
instruction
manual
Wear
protective
gloves
Wear eye
protection
Wear
protective
clothing
Original Language Version
© Jack Sealey Limited AK4564D.V2Issue:119/04/21
fig.1
Original Language Version
© Jack Sealey Limited
5. OPERATION
5.1.  Openthenozzlevalve(g.1).
5.2.  Presstriggertodispenseliquid,thetriggercanbelockedopenforlongperiodsofdispensingusingtheclip.
WARNING! DO NOTleavethegundispensingunattended.
5.3.  Releasethetriggertostopdispensing.
5.4.  Closethenozzlevalve.
5.5.
5.6.
.
AK4564D.V2Issue:119/04/21
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 sales@sealey.co.uk www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento
arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely
unserviceable and requires disposal, drain any fluids (if applicable) into approved containers and dispose of the product and fluids
accordingtolocalregulations.
Note: It is our policy to continually improve products and as such we reserve the right to alter data, specifications and component parts without prior
notice.Pleasenotethatotherversionsofthisproductareavailable.Ifyourequiredocumentationforalternativeversions,pleaseemailorcallour
technicalteamontechnical@sealey.co.ukor01284757505.
Important:NoLiabilityisacceptedforincorrectuseofthisproduct.
Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.
/