Sealey AK4564D.V2 User manual

Brand: Sealey

Model: AK4564D.V2

Type: User manual

OIL HOSE END GUN

MODEL NO: AK4564D.V2

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,

and properly maintained, give you years of trouble free performance.

IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE

THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR

PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.

1. SAFETY

 WARNING! Ensure health & safety, local authority, and general workshop practice regulations are strictly adhered to when using this

equipment.

9 Familiariseyourselfwithproductapplicationandlimitations,aswellasthespecicpotentialhazardspeculiartothisproduct.

9 Maintainthepumpstationingoodcondition(useanauthorisedserviceagent).

9 Replaceorrepairdamagedparts.Use genuine parts only. Non authorised parts will invalidate the warranty.

9 UseonlytodispenselubricantsuptoSAE150viscosity.

9 Ensuresafetyeyeprotectionandprotectiveclothingarewornwhenusingthisproduct.

9 Keeptheworkareaclean,unclutteredandensurethereisadequatelighting.

9 Maintaincorrectbalanceandfooting.Ensuretheoorisnotslipperyandwearnonslipshoes.

9 Keepchildrenandunauthorisedpersonsawayfromtheworkingarea.

9 Afteruse,drainanyuidsfromtheequipmentbeforestorage.

9 Disposeofwasteliquidsinaccordancewithlocalauthorityregulations.

9 Disconnectairpressurefromequipmentwhennotinuse.

8 DO NOT exceedthemaximumworkingpressureof1500psi.

8 DO NOT pointthenozzleatpeopleoranimals.

8 DO NOT usetheequipmentnearopenames.

8 DO NOT smokewhilstusingthisequipment.

8 DO NOT usetoextractcorrosiveuids.

8 DO NOTdismantle,tamperwithoradaptthegunforanypurposeotherthanforwhichitisdesigned.

8 DO NOT usetheunitifithasbeendroppedormishandled,checktheunittoensurethereisnodamage.

9 Keepthegunandnozzlecleanandstoreinasafedry,childprooflocation.

 WARNING! DO NOT allow uncontrolled discharge of uids thus polluting the environment. All liquids must be disposed of according to

local authority regulations.

2. INTRODUCTION

Robustoildispensinggunincorporatingmanualshuto.Fittedwithrigidextension,handlelockandnon-dripnozzle.

Pleasenotethatthisgunisnotapprovedforresaleofoil.

3. SPECIFICATION

Model no............................................................AK4564D.V2

Max.owrate............................................................ 35L/min

Inletsize....................................................................1/2”BSP

Max.outputpressure.................................................1450psi

4. ASSEMBLY

4.1.  Attachthenozzleassemblytothegun.

4.2.  Insertthelterintotheinletconnectionandthenattach

 thesupplyhose.

NOTE: DO NOT over tighten the inlet swivel connection or

 damagemayresult.

Refer to

instruction

manual

Wear

protective

gloves

Wear eye

protection

Wear

protective

clothing

Original Language Version

fig.1

Original Language Version

5. OPERATION

5.1.  Openthenozzlevalve(g.1).

5.2.  Presstriggertodispenseliquid,thetriggercanbelockedopenforlongperiodsofdispensingusingtheclip.

 WARNING! DO NOTleavethegundispensingunattended.

5.3.  Releasethetriggertostopdispensing.

5.4.  Closethenozzlevalve.

5.5.

5.6.

.

AK4564D.V2Issue:115/06/21

Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR

01284 757500 01284 703534 sales@sealey.co.uk www.sealey.co.uk

ENVIRONMENT PROTECTION

Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento

arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely

unserviceable and requires disposal, drain any fluids (if applicable) into approved containers and dispose of the product and fluids

accordingtolocalregulations.

Note: It is our policy to continually improve products and as such we reserve the right to alter data, specifications and component parts without prior

notice.Pleasenotethatotherversionsofthisproductareavailable.Ifyourequiredocumentationforalternativeversions,pleaseemailorcallour

technicalteamontechnical@sealey.co.ukor01284757505.

Important:NoLiabilityisacceptedforincorrectuseofthisproduct.

Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.

Sealey AK4564D.V2 User manual

Sealey AK4564D.V2 User manual

Sealey AK4564D.V2 User manual

Related papers

Other documents