MacDon MD #215267 A M1 Installation guide

Brand: MacDon

Model: MD #215267 A M1

Type: Installation guide

This manual is also suitable for

MD #215267 A M1 master controller service kit

M1SeriesWindrower

MASTERCONTROLLERMODULE(MD#306320)

INSTALLATIONINSTRUCTIONS



215267 RevisionA Page1of5

TheMasterControllerModulekit(MD#306320)containsapreprogrammedmastercontrollermodule.

Thisdocumentexplainshowtoinstallthemastercontrollermodule.Alistofpartsincludedinthekitisprovided.

NOTE:ThisinstructionisavailableinEnglishonly.

InstallationTime

Replacing

themastercontrollermoduleandupdatingsoftware(ifneeded)shouldtakeapproximately30minutes.

Conventions

Thefollowingconventionsareusedinthisdocument:

 Rightandleftaredeterminedfromtheoperator’sposition,facingforwardwiththewindrowerincab‐

forwardposition.

 Unlessotherwisenoted,usethestandardtorque

valuesprovidedinthewindroweroperator’smanual

andtechnicalmanual.

NOTE:KeepyourMacDonpublicationsup‐to‐date.Themostcurrentversionofthisinstructioncanbedownloaded

fromourDealer‐onlysite(https://portal.macdon.com)(loginrequired).



M1SeriesWindrower

MASTERCONTROLLERMODULE(MD#306320)

INSTALLATIONINSTRUCTIONS



215267 RevisionA Page2of5

PartsList

Thiskitincludesthefollowingparts:



Ref

Part

Number Description Quantity

1

NSS



MODULE–MASTERCONTROLLER 1



NSS SOFTWARE

–

MASTERMODULE

1





Notsoldseparately.

Themastercontrollermodulecomespreprogrammed.Thesoftwareisup‐to‐dateatthetimeofpackaging.

M1SeriesWindrower

MASTERCONTROLLERMODULE(MD#306320)

INSTALLATIONINSTRUCTIONS



215267 RevisionA Page3of5

InstallationInstructions

ToinstalltheMasterControllerModulekit,followthesesteps:



WARNING

Toavoidbodilyinjuryordeathfromunexpectedstart‐upofmachine,alwaysstopengineandremovekeyfrom

ignitionbeforeleavingoperator’sseatforanyreason.

1. Shutdowntheengine,andremovethekeyfromtheignition.

2. Openthehood.Forinstructions,refertothewindroweroperator’smanual

ortechnicalmanual.

3. Openthebatterycover,anddisconnectthenegativebatteryterminals.Forinstructions,refertothe

windrowertechnicalmanual.

4. Locatethemastercontrollermodule(A).

Figure1:MasterControllerLocation



5. Disconnectfourconnectors(A)(P231,P232,P233,

andP234)onthebackofthemaster

controller

moduleasfollows:

a) Pullbacktheconnectorcover,andpressand

holdbothsidelatches(B).

b) Worktheconnectorside‐to‐sidewhilepulling

awayfromthemodulereceptacle.

NOTE:PulltheconnectorandNOTtheharness.

6. Removehexheadboltsandnuts(C),andremove

master

controllermodule.

Figure2:ConnectorsonMasterController



M1SeriesWindrower

MASTERCONTROLLERMODULE(MD#306320)

INSTALLATIONINSTRUCTIONS



215267 RevisionA Page4of5

Important:DoNOTforceconnectorsintothe

wrongreceptacle.Eachconnectorhasakey(A)

thatfitsacorrespondingreceptacle.

Figure3:KeyFeatureonConnector



7. Installmastercontrollermodule(providedinkit)on

themodulesupportusingtwoboltsandtwo

nuts

(C).Torqueboltsto12Nm(9lbf∙ft).

8. Followthetablebelowandreconnectthefour

harnessconnectorstothereceptacles(A)onthe

mastercontroller.

HarnessConnector  ControllerReceptacle

P231



P232



P233



P234





9. Ensurebothouterlatches(B)areengagedoneach

oftheconnectors.

Figure4:ConnectorsonMasterController

10. Slidetheweathercoveringbackontoeachconnector.

11. Reconnectthenegativebatteryterminals,andclosethebatterycover.Forinstructions,refertothe

windroweroperator’smanualortechnicalmanual.

12. Closethehood.Forinstructions,refertothewindroweroperator’smanualortechnicalmanual.

UpdatingtheHarvestPerformanceTrackerSoftware

Thenewmastercontrollermodulecomespreprogrammedwiththelatestsoftwareavailableatthetimeof

packaging;however,anewsoftwareversionmaybeavailablewhenyoureadthisinstruction.



ThelatestsoftwareversioncanbedownloadedfromourDealer‐onlysite(https://portal.macdon.com)(login

required).Refertothewindrowertechnicalmanualforsoftwaredownloadingandinstallationinstructions.



M1SeriesWindrower

MASTERCONTROLLERMODULE(MD#306320)

INSTALLATIONINSTRUCTIONS



215267 RevisionA Page5of5



Theinformationinthispublicationisbasedontheinformationavailableandineffectatthetimeofprinting.

MacDonIndustries,Ltd.makesnorepresentationorwarrantyofanykind,whetherexpressedorimplied,with

respecttothe

informationinthispublication.MacDonIndustries,Ltd.reservestherighttomakechangesatany

timewithoutnotice.

MacDon MD #215267 A M1 Installation guide

Brand: MacDon

Model: MD #215267 A M1

Type: Installation guide

This manual is also suitable for

MD #215267 A M1 master controller service kit

Download PDF

report

MacDon MD #215267 A M1 Installation guide

This manual is also suitable for

MacDon MD #215267 A M1 Installation guide

Related papers

Other documents