RAIS Rina Instructions For Installation, Use And Maintenance Manual

ENGLISH RAISmanualforRaisRina&RaisViva

1

INSTRUCTIONSFORINSTALLATION,

USEANDMAINTENANCE

RAISRINA&RAISVIVA

IMPORTANTINFORMATION

Onfirstlightingthestove youmustbecarefulnottotouchthepainted

surfacesanditisMOSTIMPORTANTthat thedooriskeptslightly‘ajar’in

orderforthedoorseal andsealanttocure.

Thiswillpreventthedoorsealstickingtothe paintedbodyandbecoming

damaged.

ENGLISH RAISmanualforRaisRina&RaisViva

3

Revision:

Date :2011

INTRODUCTION ………………………………………………………….. 4

WARRANTY …………………………………………………….………….. 4

SPECIFICATIONS………………………………………………………….. 5

CONVECTION………………………………………………………………. 6

INSTALLATIONINSTRUCTIONS ………………………………….……… 7

CHIMNEY…………………………………………………….…………. 89

HEARTH………………………………………………………………… 9

INSTALLATION………………………………………………..……... 11

COMMISSIONINGANDHANDOVER……………………………… 11

MANUFACTURERSPLATE………………………………………………. 1213

CHANGINGTHECHIMNEYCONNECTION…………………………….. 14

INSTALLATIONDISTANCETOCOMBUSTIBLEWALL…………....... 1520

INSTALLATIONDISTANCETONONCOMBUSTIBLEWALL……… 21

FORTHEINSTALLER……………………………………………………… 21

OPERATINGINSTRUCTIONS…………………………………………….. 26

FUEL…………………………………………………………………………... 26

DRYINGANDSTORAGE…………………………………………………… 27

REGULATIONOFCOMBUSTIONAIR…………………………………… 27

ROOMVENTILATIONANDSTOVES…………………………………….. 27

USINGTHEWOODBURNINGSTOVE…………………………………… 28

FIRSTUSAGE………………………………………………………………… 29

LIGHTINGANDFUELLING………………………………………………… 3031

CLEANINGANDCARE…………………………………………………….. 32

CLEANINGOFTHEFLUEWAYS………………………………………… 33

PROBLEMSOLVING……………………………………………………….. 34

ACCESSORIESANDSPAREPARTS……………………………………. 35

SPAREPARTDIAGRAM…….………..……………………………………. 3645

CERTIFICATEOFCONFORMITY..………………………………………… 46

ENGLISH RAISmanualforRaisRina&RaisViva

4

ARaiswoodburningstoveismorethanjustaheatsource:italsoshowsthatyou

careaboutdesignandqualityinyourhome.

Tomakethemostofyourwoodburningstoveitisimportantthatyoureadthemanual

thoroughlybeforeinstallingandusingit.

Inthecaseofwarrantycoverage,andforgeneralqueriesregardingyourwood

burningstove,itisimportantthatyouknowthestove’sproductionnumber.

Wethereforerecommendthatyounotedownthenumberinthetablebelow.

Theproductionnumberislocatedatthebackofthestoveatthebottom.

Warranty

YourRaiswoodburningstovecomeswitha5yearwarranty.

Thewarranty,however,doesnotcoverheatinsulatingmaterials,glassandseals.

TheseareavailabletoorderfromyourlocalRaisdealer/stockist.

Anyalterationsmadetothestovewillvoidthewarranty.

Introduction

ThankyouforpurchasingaRaiswoodburningstove.

TheseapplianceshavebeenapprovedbySCA/HETASas

intermittentoperatingappliancesforburningwoodl ogsonly.

TheseapplianceshavebeenapprovedforuseinSmokelessZones

ENGLISH RAISmanualforRaisRina&RaisViva

5

Rina90

Nominaloutput(kW): 4.6

Heatingarea(m

2

): Ca.3090

Size,widt h/depth/height(mm): 461/410/900

Combustionchamberwidth/depth/height(mm). 295/225/393

Recommendedamountofwoodwhenfuelling(kg)

(Basedon2  3logsofwoodapprox.25cm)

1.2

Min.uptake/Min.draught(Pascal): 12

Weight(kg): (SteelDoo r/GlassDoor) 105

Efficiency(%) 79

ParticlesafterNS3058/3059(g/kg) 1.39

DustmeasuredaccordingtoDin+(mg/Nm

3

) 11

Smokegasmassflow(g/s): 4

Smokegastemperature(°C): 271

Intermittentoperation: Fuellingshould

beundertaken

within3hours

Viva98

Viva98G

4.6

Ca.3090

Ø440/980

295/225/393

320/225/393

1.2

12

98

79

1.39

11

4

271

Fuellingshould

beundertaken

within3hours

Viva120

Viva120G

4.6

Ca.3090

Ø440/1200

295/225/393

320/225/393

1.2

12

104

79

1.39

11

4

271

Fuellingshould

beundertaken

within3hours

Specifications

PleaseNote,thisappliancehasbeentestedbythemanufacturersandworksona3mstraightflue.

ENGLISH RAISmanualforRaisRina&RaisViva

6

Convection

Raisstovesareconvectionstoves.Thismeansthatthestove’sbackandsidepanelsare

notoverheated.Convectionmeansthatthereisacirculationofair,whichensuresthat

theheatisdistributedmoreevenlythroughouttheentireroom.Thecoldairissuckedin

atthebaseofthestoveand upthroughtheconvectionchannel,whichrunsalongthe

stove’scombustionchamber.Theheatedaircomesoutatthetopofthestove,which

ensuresacirculationofwarmairthroughouttheroom.

Thestovesareequippedwithcooldoorhandles  aRaisspecialfeature which

meansyoucouldalmostdoawaywithgloves.Beaware,however,thatallexterior

surfacesbecomehotduringuse  sotakeextremecare.

ENGLISH RAISmanualforRaisRina&RaisViva

7

PleasenotethatitisalegalrequirementunderEnglandandWalesBuilding

RegulationsthattheinstallationofthestoveiseithercarriedoutunderLocal

AuthorityBuildingControlapprovalorisinstalledbyaCompetentPerson

registeredwithaGovernmentapprovedCompetentPersonsScheme.HETASLtd

operatesuchaSchemeandalistingoftheirRegisteredCompetentPersonsca n

befoundontheirwebsiteatwww.hetas.co.uk.

COAlarms:

Buildingregulationsrequirethatwheneveraneworreplacementfixedsolidfuel

orwood/biomassapplianceisinstalledinadwellingacarbonmonoxidealarm

mustbefittedinthesameroomastheappliance.Furtherguidanceonthe

installationofthecarbonmonoxidealarmisavailableinBSEN50292:2002and

fromthealarmmanufacturer’sinstructions.

Provisionofanalarmmustnotbeconsideredasubstituteforeitherinstallingthe

appliancecorrectlyorensuringregularservicingandmaintenanceoftheappli

anceandchimneysystem.

HEALTHANDSAFETYPRECAUTIONS

Specialcaremustbetakenwheninstallingthestovesuchthattherequirementsofthe

HealthandSafetyatWorkActaremet.

Handling

Adequatefacilitiesmustbeavailableforloading,unloadingandsitehandling.

FireCement

Sometypesoffirecementarecausticandshould notbeallowedtocomeintocontact

withtheskin.Incaseofcontactwashimmediatelywithplentyofwater.

Asbestos

Thisstovecontainsnoasbestos.Ifthereisapossibilityofdisturbinganyasbestosin

thecourseofinstallationthenpleaseseek specialistguidanceanduseappropriate

protectiveequipment.

MetalParts

Wheninstallingorservicingthisstovecareshouldbetakentoavoidthepossibilityof

personalinjury.

Theseinstructions togetherwiththoseintheinstructionbookletcover

thebasicprinciplestoensurethesatisfactoryinstallationofthestove,

althoughdetailmayneedslightmodificationtosuitparticularlocalsite

conditions.

InallcasestheinstallationmustcomplywithcurrentBuildingRegulations,

LocalAuthorityByelawsandotherspecificationsorregulationsastheyaffect

theinstallationofthestove.

ItshouldbenotedthattheBuildingRegulationsrequirementsmaybemetby

adoptingtherelevantrecommendationsgiveninBritishStandardsBS8303,

BSEN152871:2007asanalternativemeanstoachieveanequivalentlevelof

performancetothatobtainedfollowingtheguidancegiveninApproved

DocumentJ.

ENGLISH RAISmanualforRaisRina&RaisViva

8

STOVEPERFORMANCE

IntheUKthestovehasbeenapprovedbyHETASLtdasanintermittentoperating

applianceforburningwoodlogsonly.

Itshouldbenotedthatitisanoffencetoburnwoodlogsinthisstoveifitisinstalledwithin

aSmokeControlAreaintheUK,unlessithasbeenaccreditedasaSm okeControl

Exemptappliance(Checkwithyoursupplier/installer).

PREPARATORYWORKANDSAFETYCHECKS

IMPORTANTWARNING

Thisstovemustnotbeinstalledintoachimneythatservesanyotherheatingappliance.

Theremustnotbeanextractorfanfittedinthesameroomasthestoveasthiscancause

thestovetoemitfumesintotheroom.

Chimney

Inorderforthestovetoperformsatisfactorilythechimneyheightmustbesufficientto

ensureanadequatedraughtofapproximately15Pasoastocleartheproductsof

combustionandpreventsmokeproblemsintotheroom.

NOTE:Achimneyheightofnotlessthan4.5metresmeasuredverticallyfromtheoutletof

thestovetothetopofthechimneyshouldbesatisfactory.Alternativelythecalculation

proceduregiveninEN133841maybeusedasthebasisfordecidingwhetheraparticular

chimneydesignwillprovidesufficientdraught.

PleaseNote,thisappliancehasbeentestedbythemanufacturersandworksona3m

straightflue.

Theoutletfromthechimneyshouldbeabovetheroofofthebuildinginaccordancewith

theprovisionsofBuildingRegulationsApprovedDocumentJ.

Ifinstallationisintoanexistingchimneythenitmustbesoundandhavenocracksorother

faultswhichmightallowfumesintothehouse.Olderproperties,especially,mayhave

chimneyfaultsorthecrosssectionmaybetoolargei.e.morethan230mmx230mm.

Remedialactionshouldbetaken,ifrequired,seekingexpertadvice,ifnecessary.Ifitis

foundnecessarytolinethechimneythenafluelinersuitableforsolidfuelmustbeusedin

accordancewithBuildingRegulationsApprovedDocumentJ.

Anyexistingchimneymustbeclearofobstructionandhavebeenswe ptcleanimmediately

beforeinstallationofthestove.Ifthestoveisfittedinplaceofanopenfirethenthe

chimneyshouldbesweptonemonthafterinstallationtoclearanysootfallswhichmay

haveoccurredduetothedifferenceincombustionbetweenthestoveandtheopenfire.

Ifthereisnoexistingchimneytheneitheraprefabricatedblockchimneyinaccordance

withBuildingRegulationsApprovedDocumentJoratwi nwall edinsulatedstainlesssteel

fluetoBS4543canbeused.Thesechimneysmustbefittedinaccordancewiththe

manufacturer’sinstructionsandBuildingRegulations.

ENGLISH RAISmanualforRaisRina&RaisViva

9

Asinglewallmetalfluepipeissuitableforconnectingthestovetothec himneybutisnot

suitableforusingforthecompletechimney.Thechimneyandconnectingfluepipemust

haveaminimumdiameterof150mmanditsdimensionshouldbenotlessthanthesizeof

theoutletsocketofthestove.

Anybendinthechimneyorconnectingfluepipeshouldnotexceed45°.90°bendsshould

notbeused.

Combustiblematerialshouldnotbelocatedwheretheheatdissipatingthroughthewallsof

fireplacesorfluescouldigniteit.Thereforewheninstallingthestoveinthepresenceof

combustiblematerialsdueaccountmustbetakenoftheguidanceontheseparationof

combustiblematerialgiveninBuildingRegulationsApprovedDocumentJandalsoin

thesestoveinstructions.

Ifitisfoundthatthereisexcessivedraughti nthechimneythenadraughtstabilisershould

befitted.Fittingofadraughtstabiliserwillaffecttherequirementforthepermanentair

supplyintotheroominwhichthestoveisfittedinaccordancewithApprovedDocumentJ

(seealsocombustionairsupply).

Adequateprovisione.g.easilyaccessiblesootdoorordoorsmustbeprovidedfor

sweepingthechimneyandconnectingfluepipewhereitisnotintendedforthechimneyto

besweptthroughtheappliance,alsotopermitvisualchecksontheintegrityoftheflue

whentheapplianceisserviced.

Hearth

Thehearthshouldbeabletoaccommodatetheweightofthestoveanditschimneyifthe

chimneyisnotindependentlysupported.Theweightofthestoveisindicatedinthe

brochure.

Thestoveshouldalwaysbeinstalledonanoncombustiblehearthofasi zeand

constructionthatisinaccordancewiththeprovisionsofthecurrentBuildingRegulations

ApprovedDocumentJ.

Theclearancedistancestocombustiblematerialbeneath,surroundingoruponthehearth

andwallsadjacenttothehearthshouldcomplywiththeguidanceontheseparationof

combustiblematerialgiveninBuildingRegulationsApprovedDocumentJandalsoin

thesestoveinstructions.

If the stove is to be installed on a combustible floor surface, it must be covered with a

noncombustible material at l east 12mm thick, in accordance with Buildi ng Regulations

ApprovedDocumentJ,toadistanceof30cminfrontofthestoveand15cmtoeachside

measuringfromthedoorofthecombustionchamber.

ENGLISH RAISmanualforRaisRina&RaisViva

10

Combustionairsupply

Inorderforthestovetoperformefficientlyandsafelythereshouldbeanadequateair

supplyintotheroominwhichthestoveisinstalledtoprovidecombustionair.Thisis

particularlynecessaryiftheroomisdoubleglazedorafluedraughtstabiliseris

operatinginthesameroomastheappliance.Itmaybenecessarytoincreasetheair

ventsizeinpropertywithlowairpermeability(<5.0m

3

/(h.m

2

).

Theprovisionofairsupplytothestovemustbei naccordancewithcurrentBuilding

RegulationsApprovedDocumentJ.Anopeni ngwindowisnotappropriateforthis

purpose.

IMPORTANTNOTE:Ifapplicableandtheapplianceisbeingfittedwithinanexisting

fireplacerecess,specialistadviceshouldbesoughtbeforefittingany permanent

ventilationwithinthisarea.

Connectiontochimney

Stovesmayhaveachoiceofeitherarearortopfl uegasconnectorthatallows

connectiontoeitheramasonrychimneyoraprefabricatedfactorymadeinsulatedmetal

chimneyinaccordancewiththeirinstructions.Insomecasesitmaybenecessarytofit

anadaptortoincreasethediameterofthefluetotheminimumrequired150mmsection

ofthechimneyorliner.

ElectricalServices

Theinstallationofanyelectricalservicesduringtheinstallationofthisappliancemustbe

carriedoutbyaregisteredcompetentelectricianandinaccordancewiththe

requirementsofthelatestissueofBS7671

CarbonMonoxideAlarm

AcarbonmonoxidealarmcomplyingwithBSEN50292mustbefittedinthesameroom

astheappliance.Itshouldbepositionedontheceilingatleast300mmfromanywallor,

ifitislocatedonawall,ashighupaspossible(aboveanydoorsandwindows)butnot

within150mmoftheceiling.Thealarmshouldalsobebetween1mand3mhorizontally

fromtheappliance.

ENGLISH RAISmanualforRaisRina&RaisViva

11

Installation

Itisprohibitedtocarryoutunauthorisedalterationstothestove.

Theremustbeplentyoffreshairintheroomwherethestoveisbeinginstalled,i n

ordertoensurepropercombustion.Notethatanymechanicalexhaustventilation

e.g.anextractionhoodmayreducethea irsupply.Anyairgrillesmustbeplaced

insuchamanner,thattheairsupplyisnotblocked.

BuildingRegulationsApprovedDocumentJgivesspecificguidanceontherequired

permanentventilationintotheroomforcombustionai rofsolidfuelappliances.

Thefloorstructuremustbeabletocarrytheweightofthewoodburningstove,as

wellastheweightofachimney,ifnecessary.

WhenyouchoosewheretosetupyourRAISwoodburningstove,yo ushould

considertheheatdistributiontotheotherrooms.Thiswillenableyoutogetthebest

useoutofyourstove.

Thestoveshouldbesetupatasafedistancefrominflammablematerials.

Seethemanufacturer'splateonthewoodburningstove.

Commissioningandhandover

Ensureloosepartsarefittedinaccordancewitht heinstructionsgiveninthe

instructionbooklet.

Oncompletionoftheinstallationallowasuitableperiodoftimeforanyfirecement

andmortartodryout,whenasmallfiremaybelitandcheckedtoensurethe

smokeandfumesaretakenfromthestoveupt hechimneyandemittedsafelyto

atmosphere.Donotrunatfulloutputforatleast24hours.

Oncompletionoftheinstallationandcommissioningensurethattheoperating

instructionsforthestoveareleftwiththecustomer.Ens uretoadvisethecustomer

onthecorrectuseoftheappliancewithth efuelslikelytobeusedonthestoveand

warnthemtouseonlytherecommendedfuelsforthestove.

Advisetheuserwhattodoshouldsmokeorfumesbeemittedfromthestove.The

customershouldbewarnedtouseafireguardtoBS8423:2002(ReplacesBS

6539)inthepresenceofchildren,agedand/orinfirmpersons.

ENGLISH RAISmanualforRaisRina&RaisViva

14

Removethecasingknockout.

Removetheprotectivecover/sealandplaceoverthe

holeinthetopmakesurethatthesealispositioned

properly.TightentheassemblyusingthethreeM6 nuts.

Theflueoutletspigot,whichcanbefoundinthestoveina

bag,andtheholderfortheupperfluediverterare

assembledwith3M6x20nutsandbolts.

Theupperfluediverter,baffleplateandtopplateare

assembledinreverseorder.

Changingthechimneyconnection

ENGLISH RAISmanualforRaisRina&RaisViva

15

Installationdistancetocombustiblewall

Tofindoutwhetherthewallnexttowherethestoveisgoingtobeinstalledis

flammable,youshouldcontactyourbuildingcontractororthelocalbuilding

authorities.

Thehearthshouldbeabletoaccommodatetheweightofthestove.Thechimney

mustbeindependentlysupportedbywallbracketsoraceilingsupportplate.The

weightofthestoveisindicatedinthebrochure.

Thestoveshouldalwaysbeinstalledonanoncombustiblehearthofasi zeand

constructionthatisinaccordancewiththeprovisionsofthecurrentUKBuilding

RegulationsApprovedDocumentJ.

Ifthestoveistobeinstalledonawoodenfloor,itmustbecoveredwithanon

combustiblematerialatleast12mmthick,inaccordancewithUKBuilding

RegulationsApprovedDocumentJ,toadistanc eof300mminfrontofthestove

and150mmtoeachsidemeasuringfromthedoorofthecombustionchamber.

Theclearancedistancestocombustiblematerialbeneath,surroundingoruponthe

hearthandwallsadjacenttothehearthshouldcomplywiththeguidanceonthe

separationof

combustiblematerialgiveninUKBuildingRegulationsApprovedDocumentJand

alsointhesestoveinstructions.

Informtheuserthattheappliancehasbeencommissi onedandreadytouseand

give

instructiononthesafeoperationofthestove.

TheseInstructionsmustbeleftwiththeuserandt heusershouldbeinstructedto

keeptheminasafeplace.

ENGLISH RAISmanualforRaisRina&RaisViva

16

Normalsetupcornersetting

RINA

A. Distancetofurniture 700mm

Distancetoflammablematerials:

B. infront(floor) 300mm

C. totheside(floor) 150mm

D. totherear(floor) 150mm

E. tothesideofthewall 350mm

ENGLISH RAISmanualforRaisRina&RaisViva

17

Normalsetupcornersetting

VIVA VIVAG

A. Distancetofurniture 700mm 650mm

Distancetoflammablematerials:

B. infront(floor) 300mm 300mm

C. totheside(floor) 150mm 150mm

D. totherear(floor) 100mm 150mm

E. tothesideofthewall 350mm 400mm

ENGLISH RAISmanualforRaisRina&RaisViva

18

Cornersetting45°fixedsocket

RINA

A. Distancetofurniture 700mm

Distancetoflammablematerials:

B. infront(floor) 300mm

C. totheside(floor) 150mm

D. totherear(wall) 150mm

E. tothesideofthewall 350mm

ENGLISH RAISmanualforRaisRina&RaisViva

19

Cornersetting45°fixedsocket

VIVAVIVAG

Distancetofurniture700mm 650mm

Distancetoflammablematerials:

B. infront(floor) 300mm 300mm

C. totheside(floor) 150mm 150mm

D. totherear(wall) 100mm 200mm

E. tothesideofthewall 350mm 400mm

ENGLISH RAISmanualforRaisRina&RaisViva

20

360°SwivelBase

VIVAVIVAG

Distancetofurniture700mm 650mm

Distancetoflammablematerials:

C. totheside(floor) 300mm 300mm

RAIS Rina, Rina 90, VIVA, Viva 120, Viva 120 G, Viva 98, Viva 98 G Instructions For Installation, Use And Maintenance Manual

Related papers

Other documents