3M ScaleGard™ HP Reverse Osmosis System Operating instructions

™

Water Filtration Products

Reverse Osmosis Cartridge Change-out Instructions

FOR ScaleGard

HP Reverse Osmosis System

WARNING

To reduce the risk associated with the ingestion of contaminants:

• Do not use with water that is microbiologically unsafe or of unknown quality without adequate disinfection before or after the system.

To reduce the risk associated with choking:

• Do notallowchildrenunder3yearsofagetohaveaccesstosmallpartsduringtheinstallationofthisproduct.

To reduce the risk of physical injury:

• Depressurizesystemasshowninmanualpriortocartridgeremoval.

To reduce the risk of injury associated with household bleach:

• Read and followmanufacturer’sdirectionsandcautions.

• Keep out of the reach of children.

• DO NOTintermixwithotherchemicals.

To reduce the risk associated with ingestion of water contaminated with sanitizer:

 •Afterinstallation,sanitizersmustbeushedfromthesystembeforerstuseasdirectedwithintheinstallationinstructions

(dilutebleachsolution).

CAUTION

To reduce the risk associated with property damage due to water leakage:

• Protect from freezing,removeltercartridgewhentemperaturesareexpectedtodropbelow40°F(4.4°C).

• Do notinstallsystemsinareaswhereambienttemperaturesmaygoabove110°F(43.3°C).

• TheROcartridgeMUSTbereplacedeverytwentyfour(24)months,orsoonerifanoticeableincreaseinTDSoccurs.

• ThedisposableltercartridgesMUSTbereplacedeverysix(6)months,attheratedcapacityorsoonerifanoticeablereductioninowrate

occurs.

IMPORTANT NOTE:

TheROcartridgeshavegreenlabelsandwillonlytintotheheadontherightsideofthemanifold(headhasagreen3Mlabel).

Shut-Off procedure:

HFRO500Cartridgeswillneedtobechangedatleasteverytwentyfour(24)months.HF90-CL-ROcartridgewillneedtobechangedeverysix(6)months.

1. Unplugsystemfromthewalloutlet,whichwillshutofffeedwatertoROsystem.

2. OpenPre-ltersamplevalveuntilowstopsandpressuregaugereaches0psitorelievepressure.

HF90-CL-RO Cartridge (blue label) Replacement:

1. Pushandholdyellowtabtoreleasecartridgelockingmechanismwhilesimultaneouslyrotatingcartridgetotheleft.

2. Usingbothhandsandholdingthecartridgefromthebottom,rotatethecartridgeaquarterturntotheleftandgentlypulldown.

NOTE:Asmallamountofwaterwilldrainfrommanifoldascartridgeisremoved.

3. Removesanitarycapfromnewcartridge.Installwithaquarterturntotherightuntilcartridgecometoacompletestop.

NOTE:Cartridgesarekeyedtotinproperlocationonly.

HFRO 500 Cartridge (green label) Replacement:

1. Takeoutrejecttubingbypushinginthecolletandpullingoutthetubing.(Seegureonreverse).

2. Pushandholdyellowtabtoreleasecartridgelockingmechanismwhilesimultaneouslyrotatingcartridgetotheleft.

3. Usingbothhandsandholdingthecartridgefromthebottom,rotatethecartridgeaquarterturntotheleftandgentlypulldown.

NOTE:Asmallamountofwaterwilldrainfrommanifoldascartridgeisremoved.

4. Removesanitarycapfromnewcartridge.Installwithaquarterturntotherightuntilcartridgecomestoacompletestop.

NOTE:Cartridgesarekeyedtotinproperlocationonly.

5. Placenewowcontrolinrejecttubing(suppliedwithcartridge).

6. Connectrejecttubingtocartridge.

System Start Up

1. TurnONthefeedwatersupplybypluggingsystemintoelectricaloutlet.

2. Pressresetbuttonontopofelectricalenclosure(seeFigure5).

3. OpenPre-ltervalvesamplevalvetoventairfromsystemandushforve(5)minutes.

4. Closesamplevalve.

5. Sanitize the Storage Tank and Filtration System as per instructions below

Sanitizingthestoragetankgenerallyrequires:

• Commonhouseholdbleach(5.25%non-scented)orsanitizingagent

• Eyedropperorplasticoralsyringe

a.) Disconnectthe1/2”linefrommarked”TankOutlet”topressuretank.

b.) Insert1tablespoonofbleachorsanitizingagentinto1/2”linetopressuretank.

c.) Reconnectthe1/2”linetopressuretank.

d.) TurnONthefeedwatersupplybypluggingsystemintoelectricaloutlet.

e.) Wait4-5hours.

f.) Openpressuretanksamplevalveandemptytanktodrain.

3Misatrademarkof3MCompany.

ScaleGardisatrademarkof3MCompany.

©20123MCompany.Allrightsreserved.

Pleaserecycle.PrintedinU.S.A.

INSTR44011012

3M Puriﬁcation Inc.

400ResearchParkway

Meriden,CT06450,U.S.A.

Tel (866)990-9785

 (203)237-5541

Fax (203)238-8977

www.cunofoodservice.com

www.3Mpurication.com

Limited Warranty

3MPuricationInc.warrantsthisdisposableltercartridgeormembraneiswarrantedfromdefectsinmaterialandmanufactureforaperiodofone(1)yearfromthedate

ofpurchase.Thiswarrantydoesnotcoverfailuresresultingfromabuse,misuse,alterationordamagenotcausedby3MPuricationInc.orfailuretofollowinstallation

anduseinstructions.Nowarrantyisgivenastotheservicelifeofanyltercartridgeormembraneasitwillvarywithlocalwaterconditionsandwaterconsumption.

3M PURIFICATION INC. MAKES NO OTHER WARRANTIES OR CONDITIONS, EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTY

OR CONDITION OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR ANY IMPLIED WARRANTY OR CONDITION ARISING OUT OF A COURSE OF

DEALING, CUSTOMER OR USAGE OF TRADE.IftheProductfailstosatisfythisLimitedWarrantyduringthewarrantyperiod,3MPuricationInc.willreplacetheProductor

refundyourProductpurchaseprice.Thiswarrantydoesnotcoverlabor.TheremedystatedinthisparagraphisCustomer’ssoleremedyand3M’sexclusiveobligation.

Thiswarrantygivesyouspeciclegalrights,andyoumayhaveotherrightswhichmayvaryfromstatetostate,orcountrytocountry.Foranywarrantyquestions,pleasecall(866)

990-9785ormailyourrequestto:WarrantyClaims,3MPuricationInc.,400ResearchParkway,Meriden,CT06450.Proofofpurchase(originalsalesreceipt)mustaccompany

thewarrantyclaim,alongwithacompletedescriptionoftheProduct,modelnumberandallegeddefect.

Limitation of Liability

3MPuricationInc.willnotbeliableforanylossordamagearisingfromtheuseoftheProduct(s),whetherdirect,indirect,special,incidental,orconsequential,regardlessofthe

legaltheoryasserted,includingwarranty,contract,negligenceorstrictliability.Somestatesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamages,sothe

abovelimitationmaynotapplytoyou.

Figure 1 (Reset Button)

Reset

Button

To Attach Tubing

To Release Tubing

Push tubing straight in as far as it

will go

Tubing is secured in. Push in collet to release tubing. Pull tubing straight out.

Thisproductisoutttedwithauserfriendly‘PushIn’connectorattheventvalve.Properuseoftheconnectorsisshowninthegurebelow.Itismost

importantthatthetubingselectedforusewiththeseconnectorsbeofhighquality,exactsizeandroundness,andwithnosurfacenicksorscratches.

Ifitisnecessarytocutthetubing,useaplastictubingcutterorsharprazorknife.Makeacleansquarecut.Shouldaleakoccurata“Push-In”

connector,thecauseisusuallyaproblemwiththetubing.

To Fix:

1.Relievepressure 2.Releasetubing  3.Cutoffatleast1/4”fromend

 4.Reattachtubing  5.Conrmconnectionisleakfree

Figure 6 (How to Use “Push-in” Connectors)

g.) Sanitizingisnowcomplete.

h) Ifthereisanyresidualchlorine/bleachtasteinthenexttank

full,draintankcompletelyasecondtime.

6. Allowtanktollagain.

Systemisnowreadyforuse.