Summers Heat 55-SHPCAB80S User guide





CAUTION

PLEASEREADTHISENTIREMANUALBEFOREINSTALLATIONANDUSEOFTHISPELLETFUEL‐BURNING

APPLIANCE.KEEPCHILDREN,FURNITURE,ANDALLCOMBUSTIBLES AWAYFROMANYHEATINGAPPLIANCE.



SAFETYNOTICE

FAILURETOFOLLOWTHESEINSTRUCTIONSCANRESULTINPROPERTYDAMAGE,BODILYINJURYOREVEN

DEATH.FORYOURSAFETYANDPROTECTION,FOLLOWTHEINSTALLATIONINSTRUCTIONSOUTLINEDIN

THISMANUAL.CONTACTYOURLOCALBUILDINGORFIREOFFICIALSABOUTRESTRICTIONSAND

INSTALLATIONINSPECTIONREQUIREMENTS(INCLUDINGPERMITS)INYOURAREA.



ManufacturedBy:

England’sStoveWorks,Inc.

POBox206

Monroe,VA24574

Rev.08/2018

SAVETHESEINSTRUCTIO NS

INSTALLATION&OPERATION

MANUAL

25‐CAB80

55‐SHPCAB80

55‐TRPCAB80

25‐CAB80S

55‐SHPCAB80S

55‐TRPCAB80S



THISWOODHEATERNEEDSPERIODICINSPECTIONANDREPAIRFORPROPEROPERATION.CONSULTTHE

OWNER’SMANUALFORFURTHERINFORMATION.ITISAGAINSTFEDERALREGULATIONSTOOPERATETHIS

WOODHEATERINAMANNERINCONSISTENTWITHTHEOPERATINGINSTRUCTIONSINTHEOWNER’S

MANUAL.

www.heatredefined.com

Parts:(800)516‐3636

Support:(800)245‐6489

2

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.

IMPORTANT:IFYOUHAVEAPROBLEMWITHTHISUNIT,DONOTRETURNITTO

THEDEALER.CONTACTTECHNICALSUPPORT@1‐800‐245‐6489



TamperWarning:

Thiswoodheaterhasamanufacturer‐setminimumlowburnratethatmustnotbe

altered.Itisagainstfederalregulationstoalterthissettingorotherwiseoperate

thiswoodheaterinamannerinconsistentwithoperatinginstructionsinthis

manual.



MobileHomeUse:

Thisfreestandingpelletunitisapprovedformobilehomeordoublewide

installationwiththeoutsidecombustionairhook‐upSeethe“Installation”section

ofthismanualfordetailspertainingtomobilehomeinstallations.Mobilehome

installationmustbeinaccordancewiththeManufacturedHomeandSafety

Standard(HUD),CFR3280,Part24.



WARNING:

USEOFOUTSIDECOMBUSTIONAIRISMANDATORYWITHTHISUNIT.

DONOTOPERATEWITHTHEHOPPEROPEN;LIDMUSTBESHUTANDTIGHTLY

LATCHEDDURINGOPERATION.DONOTOVER‐FIREYOURUNIT.



Note:England’sStoveWorksdoesnotrecommendusingapelletstoveasyour

onlysourceofheat.

Retainforyourfiles

ModelNumber



DateofPurchase



DateofManufacture



SerialNumber





3

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.

Welcome!

Introduction

 ThankYou.........................................4

Specifications

 HeatingSpecifications.......................5

 Dimensions........................................5

 EPACompliance.................................5

Installation

 InstallationOverview...................6

 ClearancestoCombustibles.........7

 VentingIntroduction...................8

 VentingGuidelines.......................8

 AdditionalVentingInformation....9

 ApprovedVentingMethods

 ThroughtheWall...........10

 ThroughtheCeiling........11

 ExistingChimney............12

 MobileHomeInstallation............13

 VentTerminationClearances......14

 OutsideAirHookup.....................15

 FloorProtection...........................16

DailyOperation

 ControlBoardTypes…………………17

 GettingStarted............................18

 LightingaFire..............................18

 DailyOperationNotes………………19

ControlBoard

 TopMountBoardSettings...........21

 ErrorCodes(TopMount)............23

 DiagnosticMode(TopMount)....29

 SideMountBoardSettings...........31

 SideMountErrorCodes...............32

 PowerFailure...............................33

Maintenance

 Daily

 ImportantNotes..............34

 DailyAshRemoval............34

 CleaningtheBurnPot…...35



 Weekly

 BaffleRemoval.................36

 Monthly

 VentingPipeCleaning…..37

 Yearly

 ImportantNotes..............38

 BurnPot………..................39

 ExhaustBlower……………..39

 ConvectionBlower...........40

 Finish…………....................40

 Gaskets…………………………40



 BasicTroubleshooting.......................41

ReplacingComponents

 ConvectionBlower............................43

 AugerMotor……….............................44

 CombustionBlower............................45

 VacuumSwitch...................................46

 Igniter.................................................48

 Gaskets...............................................49

 Glass...................................................50

 ControlBoard(TopMount)...............51

 ControlBoard(SideMount)...............53

 HopperLidLatch….............................55



IllustratedPartsDetail

 ExplodedPartsDiagram……………………56

 PartsList……………………………………..…..57



Warranty

 SerialTagSample…………………….………..59

 WarrantyDetails……………………………....60

 ImportantNotice………….…….....…………62

 WarrantyReg.Form………………………….63



INTRODUCTION

ThankyouforpurchasingthisfineproductfromEngland’sStoveWorks!

England’sStoveWorkswasstarted,andisstillownedby,afamilythatbelieves

stronglyina“DoItYourself”spirit;that’sonereasonyoufoundthisproductat

yourfavorite“DoItYourself”store.



Weintentionallydesignand

buildourstovessothatanyhomeownercanmaintain

theirstovewithbasictools,andwe’realwaysmorethanhappytohelpyoudothe

jobaseasilyandasinexpensivelyaspossible.However,whileremainingsimple,

ourstovesaredesignedtoperformextremelyefficiently,helpingdelivermore

heatfromless

fuel.



PleaselookattheextensiveHelpsectiononourwebsiteandcallourTechnical

SupportDepartmentat(800)245‐6489ifyouneedanyhelpwithyourstove.We

arenearlyalwaysableto“walkyouthrough”anyinstallationissues,repairs,

problemsorotherquestionsthatyoumayhave.



Wishingyouyearsofefficient,qualityand“comfy”heating,

EveryoneatEngland’sStoveWorks



PleaseNote:Whileinformationobtainedfromourwebsiteandthroughour

TechnicalSupportlineisalwaysfreeofcharge,therewillbeaservicecharge

incurredwithany“on‐site”repairsormaintenancethatwemayarrange.





This manual is available for free download on the manufacturer’s web site. It is a copyrighted document and resale

is strictly prohibited. The manufacturer may update this manual occasionally and cannot be responsible for

problems including injuries or damages resulting from the use of information found in any manual from

unauthorized sources.

CAUTION:Stoveisheavy.

Inaddition,whenhandlinganysheetmetalproducts,beawarethattheremaybesharpedgesorburrs.

Althoughwemakeeveryefforttoeliminateanysharpedges,pleaseusecautionwhenhandlinganymetalparts.

Remembertodisconnect(unplug)thestovefromthepowersourceand

allowittocompletelycooldown

beforeperforminganymaintenance.

5

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



SPECIFICATIONS

HeatingSpecifications



 ApproximatePelletBurnRate**……….…………1.0to1.8kg/hr(2.2to3.8lbs/hr)

 MaximumBurnTime**………………………………………………………………………..36hours

 ApproximateSquareFootageHeated***………...………………………….up2,000sq.ft.

 HopperCapacity(fuel)…………………………………….…………………………….…..80pounds

Dimensions



EPAandSafetyComplianceSpecifications

 EPAComplianceStatus………………….Certifiedtocomplywith2020particulateemissionstandards

usingpelletfuel.

 U.S.TestStandard:USEPA40CFRPart60,Subpart60.536

 ParticulateEmissions …………………………………………………………………1.130grams/hr

 COEmissions…………………………………………………………………………….0.029grams/hr

 Efficiency………………………………………………………………………………………64.1%(HHV)

 BTUrating…………………………………………………………………………………….20,511BTU/hr

 TestedToUL1482‐00,ASTME1509,ULC/ORD‐C1482‐M1990&ULCS627‐00

Notesforthisunit:Productmayvaryslightlyfromdiagram.Clearancesaretheminimumforthisunit

andmayneedtobeincreasedinthereartohaveproperventclearances.Followallventingmanufacturer

clearancesandlocalcodes.

*‐AstestedperASTM2779‐10

**‐Heatoutput,burnrateandmaximumburntimeareheavilydependentonthetypeofpelletsburnedinthestove;assuch,thesenumbersmayvary.

***‐Themaximumheatingcapacityofthisunitcanvarygreatlybasedonclimate,constructionstyle,insulation

andamyriadofotherfactors.Usethisinformation

inconjunctionwithaBTUlosscalculationforyourhometodetermineifthisunitwillbesufficientforyourneeds.



6

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

InstallationOverview

Whenchoosingalocationforyournewstove,thereareamultitudeoffactorsthat

shouldbetakenintoaccountbeforebeginningtheinstallation.

1. TrafficPatterns–Tohelppreventaccidents,thestoveshouldbeplacedinalocation

whereitisout ofthewayofnormaltravelthrough

thehome.

2. HeatFlowandEfficiency–Whendecidingonalocationforthestove,considertheway

heatmovesthroughoutyourhome.Installthestovewhereyouneedtheheat;

basementinstallationsoftendonotallowsufficientheattoflowtotheupperfloorsand

atopfloor

installationwillnotallowanyheattoreachthefloorsbelow.Always

considerthatheatrisesandwilltakethepathofleastresistancewhileitisstillhot.

3. ExhaustLocation–Outsidewallsaregenerallythebestplacetoinstalla stove,since

theyalloweasyexhaustandintake

airinstallation(usingourDuraVentAC‐3000Kit,AC‐

33000ifCanada).Ifthereisnotafeasiblewaytoinstallthestoveonanoutsidewall,

therearemethodsforventingthestoveupthroughtheroof,buttheytendtobemore

costlybecausetheyinvolvethe

useofmorepelletventpipeandcanoftenmakeoutside

airinstallationmoredifficult.

4. WallConstruction–Locatingthestovesothattheexhaustsystemcanpassbetween

studswillsimplifytheinstallationandeliminatetheneedtoreframeanysectionsofthe

walltoaccommodatethewallthimble.



Warning

 Donotstoreorusegasolineorotherflammablevaporsandliquidsinthevicinityofthisorany

otherappliance.

 DoNotOverfire–Ifanyexternalpartstartstoglow,youareoverfiring.Reducefeedrate.

Overfiringwillvoidyourwarranty.

 Complywithallminimumclearancestocombustiblesasspecified.Failuretocomplymay

resultinahousefire.

 Testedandapprovedforwoodpelletsonly.Burninganyotherfuelwillvoidyourwarranty.

 ForusewithPremiumgradewoodpelletsonly.

7

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

ClearancestoCombustibles



 



CAUTION

 UnitcanbeveryHOTwhileinoperation.Keepchildrenaway.

 Supervisechildreninthesameroomasthisappliance.

 Alertchildrenandadultstothehazardsofhighte mperatures.

 DoNOToperatewithprotectivebarriersopenorremoved.

 Keepclothing,furniture,draperiesandothercombustiblesaway.

 InstallationMUSTcomplywithlocal,regional,stateandnationalcodesandregulations.

 Consultlocalbuilding,fireofficialsorauthoritieshavingjurisdictionaboutrestrictions,installationinspection,and

permits.

DONOTCONNECTTOANYAIRDISTRIBUTIONDUCTORSYSTEM



UnittoSide

Wall(A)

UnittoRear

Wall(B)

UnittoCorner

(C)

7in. 0in. 5in.

178mm 0mm 127mm

8

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

VentingIntroduction

 Thispelletstoveoperatesonanegativedraftsystem,whichpullscombustionairthroughthe

burnpotandpushestheexhaustairthroughtheventpipeandoutofthebuilding.Thisunitmustbe

installedinaccordancewiththefollowingdetaileddescriptionsofventingtechniques;notinstalling

thestovein

accordancewiththedetailslistedherecanresultinpoorstoveperformance,property

damage,bodilyinjuryordeath.England’sStoveWorksisnotresponsibleforanydamageincurred

duetoapoororunsafeinstallation.

 Ifquestionsarisepertainingtothesafeinstallationofthestove,ourTechnicalSupportline



(800‐245‐6489)isavailable.Contactyourlocalcodeofficialtobecertainyourinstallationmeetslocal

andnationalfirecodesandifyou’reuncertainabouthowtosafelyinstallthestove,westrongly

recommendcontactingalocalNFIcertifiedinstallertoperformtheinstallation.

VentingGuidelines

 WARNING‐INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.

 ALWAYSinstallventpipeinstrictadherencewiththeinstructionsandclearancesincludedwith

yourventingsystem.

 DONOTconnectthispelletstovetoachimneyfluewhichalsoservesanotherappliance.

 DONOTinstalla

fluepipedamperoranyotherrestrictivedeviceintheexhaustventingsystem

ofthisunit.

 USEanapprovedwallthimblewhenpassingthroughawallandaceilingsupport/firestop

whenpassingthroughaceiling.

 ONLYuse3.0”or4.0”TypeLorTypePLpipeapproved

forpelletstoveventing;DONOTuse

galvanizedorB‐Ventpipe.

 SEALeachjointofpelletventwithhightemperaturesilicone(Part#AC‐RTV3)toprevent

smokespillageintothehome.

 AVOIDexcessivehorizontalrunsandelbows,asbothwillreducethedraftoftheventing

system

andwillresultinpoorstoveperformance.

 INCLUDEasmuchverticalpipeaspossibletopreventsmokefromtheunitfromenteringyour

homeintheeventofapoweroutage.

 INSPECTyourventingsystemoften,tobecertainitisclearoffly‐ashandotherrestrictions.

 CLEANtheventingsystemasdetailedinthemaintenancesectionofthismanual.



WARNING

 INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.

 HOT!Donottouch!Severeburnsorclothingignitionmayresult.

 Glassandothersurfacesarehotduringoperation.

 Donotattempttotouchoropenthefront,sideorbackpanelsduringoperation.Thiscouldresultin



severeburnsorin

.

9

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

AdditionalVentingInformation

 Donotmixandmatchcomponentsfromdifferentpipemanufacturerswhenassemblingyour

ventingsystem(i.e.DoNOTuseventingpipefromonemanufacturerandathimblefrom

another).

 Werequireaminimumverticalriseof36in.(3ft.)ofpipetocreatenaturaldraftinthesystem.



Thishelpsevacuatesmokefromthestoveintheeventofapowerfailureorcombustion

blowerfailure.

 Ventingsystems15.0ft.orshortermaybecomposedentirelyof3.0in.pelletpipe;toreduce

frictionallosses,ventingsystemslongerthan15.0ft.shouldbecomposedof4.0in.

pelletpipe.

 Donotterminatetheventingsystemdirectlybeneathanycombustiblestructuresuchasa

porchordeck.

 FollowNFPA211ruleslistedbelowforventingsystemterminationlocationrelativeto

windowsandotheropeningsinthedwelling.

o NFPA211(2006ed.)Section10.4Termination:10.4.5

(1)

Theexitterminalofamechanicaldraftsystemotherthandirectventappliances 

(sealedcombustionsystemappliances)shallbelocatedinaccordancewiththe

following:

 (a)Notlessthan3ft.(.91m)aboveanyforcedairinletlocatedwithin10ft.

(3.0m).

 (b)Notlessthan4

ft.(1.2m)below,4ft.(1.2m)horizontallyfromor1ft.(305

mm)aboveanydoor,windoworgravityairinletintoanybuilding.

 (c)Notlessthan2ft.(0.61m)fromanadjacentbuildingandnotlessthan7ft.

(2.1m)abovegradewhenlocated

adjacenttopublicwalkways.

 Distancebetweentheterminationopeningandgradeshouldbeaminimumof2ft.(24in.)

contingentonthegradesurfacebelowthetermination.Whendeterminingthetermination

heightabovegrade,considersnowdriftlinesandcombustiblessuchasgrassorleaf

accumulation.Inareas

wheresignificantsnowfallis possible,theterminationheightmustbe

sufficientlyhightokeeptheterminationfreeofsnowaccumulation.

 Donotusemakeshiftcompromisesduringinstallationorinstallanycomponentoftheunitor

ventingsysteminsuchamannerthatcouldresultinahazardousinstallation.

 A

chimneyconnectorshallnotpassthroughanatticorroofspace,closetorsimilarconcealed

space,orafloor,orceiling.

 Wherepassagethroughawallorpartitionofcombustiblematerialisdesired,theinstallation

shallconformtoCAN/CSA‐B365.

WARNING:

VentingsystemsurfacesgetHOT,andcancauseburnsiftouched.

Noncombustibleshieldingorguardsmayberequired.

10

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

ApprovedVentingMethod1:ThroughtheWall



 Generallythesimplestinstallationmethod,venting

throughthewallusingourAC‐3000kit,AC‐33000ifCanada

(orsimilarventingsystem)isalsothepreferredventing

method.Itminimizeshorizontalpipe,allowsthestoveto

beinstalledclosetothewallandkeepstheclean‐outtee

onthe

outsideofthehouse,foreaseofcleaning.

 Wheninstallinganyventingsystem,TypeLorTypePL

pipemustbeusedandallclearancestocombustibles

(listedbythepipemanufacturer)mustbestrictlyadhered

to.

 Usethepipemanufacturer’sapprovedthimblefor

passingthroughacombustible

wall,andmaintainatleast

theminimumclearancestocombustibles.

 Useanappliancecollarwherethepelletventconnects

totheexhaustoutputofthepelletstoveandattachthe

appliancecollartotheexhaustbloweroutputusingthree

sheetmetalscrews.

 Securethepelletventtotheoutside

ofthehouseusingawallstrapjustbelowthe90degree

elbow.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemisleak

free(Checkwiththespecificventingsystemmanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingused

isnota“TwistLock”system,three(3)sheetmetalscrewsare

requiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyourstoveorusing

analternativemethod,asdescribedinthe“OutsideAir”section,onpage15.

Thisinstallationtype

canbemodifiedforbasement(Basementinstallationsshouldalwaysbe

performedbyaprofessionalinstaller)orotherinstallationswhereintheteeandverticalsectionof

thepipewouldbeinsidethehomeandtheventingsystemwouldsimplypasshorizontallythrough

thethimbleandthenterminate.



PleaseNote:

Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplansforeach

individualinstallation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancestocombustibles,

andfollowalllocalcodes.

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(3”)tofour‐inch(4”).

11

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

ApprovedVentingMethod2:ThroughtheCeiling



 Ventingthroughtheceiling/roofmaybetheonlyfeasible

ventingoptioninsomecasesandisafactoryrecommended

installation.

 Wheninstallinganyventingsystem,TypeLorTypePLpipe

mustbeusedandallclearancestocombustibleslistedbythe

pipemanufacturermustbestrictlyadheredto.



 Usethepipemanufacturer’sapprovedceilingsupportfor

passingthroughacombustibleceiling,aswellastherequired

firestops,radiationshields,flashingandstormcollar.

 Becertaintofollowthemanufacturer’srequiredheightof

terminationabovetheroofline,andmaintainatleastthe

minimumclearancesto

combustibles.

 Useanappliancecollarwherethepelletventconnectstothe

exhaustoutputofthepelletstoveandattachtheappliance

collartotheexhaustbloweroutputusingthreesheetmetal

screws.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemisleak



free(Checkwiththespecificpipemanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingusedisnota“TwistLock”system,three(3)sheetmetalscrewsare

requiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwith

yourstoveorusing

analternativemethod,asdescribedinthe“OutsideAir”section,onpage15.

 Thisventingmethodcanalsobemodifiedsothattheventingsystemrunshorizontallythroughthe

wallfromthestove,thentransitionstoverticalandterminatesabovetheroofline.Whenusing

thismodified

versionofthisinstallationbecertaintocarefullyfollowtheventingsystem

manufacturer’sinstructionsdiligently.



PleaseNote:

Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplansforeach

individualinstallation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancestocombustibles,and

followalllocalcodes.



Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(3”)tofour‐inch(4”).

12

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

ApprovedVentingMethod3:ExistingChimneySystem

 Usinganexistingmasonryorfactorybuiltchimneyforventingistheonlyotheracceptablemethod

forventingthispelletunit.

 UseTypeLorTypePLventingpipeuntilenteringthe

existingchimney.Usetheappropriatelysizedadapterwhen

transitioningfromthepelletventpipetothemasonry

or

factorybuiltthimbleandbecertainthattheadapteris

sealedtightlytoboththepelletventingsystemandthe

existingchimney.

 Beforeusinganexistingchimney,becertainitisingood

condition(Achimneysweepinspectionishighly

recommended).Also,makesurethechimneymeetsthe

minimumstandardslistedinNFPA211(Achimney

professionalcanconfirmthisuponinspection).

 Ifconnectingthisstovetoafactorybuiltchimney,itmay

ONLYbea6”flue,UL103HTventingsystem(ULCS629if

Canada).Connectiontoanyotherfactorybuiltchimneymay

resultinapoorly

operatingordangerousstoveinstallation.

 Whenconnectingtoanexistingmasonrychimney,thecross‐sectionalareaofthefluemustbe

considered.Achimneywithafluelargerthan6”round(28.27sq.in.)mayrequirereliningwithan

approvedpelletstovechimneyliningsystem.

 Useanappliance

collarwherethepelletventconnectstotheexhaustoutputofthepelletstove

andattachtheappliancecollartotheexhaustbloweroutputusingthreesheetmetalscrews.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemisleak

free(Checkwiththespecific

pipemanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingusedisnota“TwistLock”system,three(3)sheetmetalscrewsare

requiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyourstoveorusing

an

alternativemethod,asdescribedinthe“OutsideAir”section,onpage15.



PleaseNote:

Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplansforeachindividual

installation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancestocombustibles,andfollowalllocal

codes.

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(3”)tofour‐inch(4”).

13

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



INSTALLATION

MobileHomeInstallation

 TheEngland’sStoveWorks,Inc.outsideairkitMUSTbeusedforinstallationofthisunitina

mobilehome.Pleaseseethe“Outside Air”sectiononpage15formoreinformationregarding

outsideairconnections.

 Theoutsideairinletmustbekeptclearofleaves,iceandother

debris.Keepingtheoutsideair

inletfreeofrestrictioniscrucialtopreventingairstarvationand smokespillage.

 ThepelletstoveMUSTbesecuredtothefloorofthemobilehomeusinglagboltsandtheholes

providedinthebottomofthebaseforthispurpose.Outdoor‐aired

spaceheatersmustbe

attachedtothestructure.

 ThepelletstoveMUSTbegroundedwith#8solidcoppergroundingwire(orequivalent),

terminatedateachendwithanNECapprovedgroundeddevice.

 CarefullyfollowallclearanceslistedintheappropriatesectionofthismanualANDfollowthe

ventingmanufacturer’s

minimumclearancerequirements.Similarly,becertaintheventing

systemusedisapprovedformobilehomeuse.

 InstallationmustbeinaccordancewithManufacturersHome&SafetyStandard(HUD)CFR3280,

Part24aswellasanyapplicablelocalcodes.

 Usesiliconetocreateaneffectivevaporbarrierat

thelocationwherethechimneyoroutsideair

ductingpassesthroughtotheexteriorofthestructure.



CAUTION

THESTRUCTURALINTEGRITYOFTHEMANUFACTUREDHOMEFLOOR,WALLANDCEILING/ROOFMUSTBE

MAINTAINED.DONOTCUTTHROUGHFLOORJOISTS,WALLSTUDS,CEILINGTRUSSESORANYOTHER

SUPPORTINGMATERIALWHICHCOULDBEDETRIMENTALTOTHESTRUCTURALINTEGRITYOFTHEHOME.

WARNING:DONOTINSTALLINASLEEPINGROOM.

JoistShield/Firestop MobileHomeApproved

TypeLorTypePLPellet

VentPipe

ChimneyCap/SparkArrestor RoofFlashingandStorm

Collar

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3 ‐inch

(3”)tofour‐inch(4”).

14

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



VENTTERMINATIONCLEARANCES

A)Min.4‐ftclearancebeloworbesideanydoororwindowthatopens.

B)Min.1‐ftclearanceaboveanydoororwindowthatopens.

C)Min.2‐ftclearancefromanyadjacentbuilding.

D)Min.7‐ftclearancefromanygradewhenadjacenttopublicwalkways.

E)Min.2

‐ftclearanceaboveanygrass,plants,orothercombustiblematerials.

F)Min.3‐ftclearancefromaforcedairintakeofanyappliance.

G)Min.2‐ftclearancebeloweavesoroverhang.

H)Min.1‐ftclearancehorizontallyfromcombustiblewall.

I)Ventsinstalledwithmechanicalexhaustersshallterminatenot

lessthan12in.(305mm)abovethe

highestpointwheretheypassthroughtheroofsurface.





NotesonterminationofPelletVentPipefromNFPA211(2006ed.)Section10.4Termination:10.4.5

(Seealso“INSTALLATION”sectionofmanualANDadditionalnotesabove):

 Notlessthanthree(3)feetaboveanyforcedairinletlocatedwithinten(10)feet.

 Notlessthanfour(4)feetbelow,four(4)feethorizontallyfrom,orone(1)footaboveanydoor,

windoworgravityairinletintoanybuilding.

 Notlessthantwo(2)feetfromanadjacentbuilding,andnotlessthanseven(7)feetabovegrade

wherelocatedadjacenttopublicwalkways.

Theexhaustexitshallbea rrangedsothatthefluegases arenotdirectedsothatitwillaffectpeople,overheat

combustiblestructures,orenterbuildings.Forceddraftsystemsandallpartsofinduceddraftsystemsunderpositive

pressureduringoperationshallbeinstalledgastightortopreventleakageofcombustion

productsintoa building.

Through‐the‐wallventsshallnotterminateoverpublicwalkways,orwherecondensateorvaporcouldcreatehazards

oranuisance.

Besuretofollowlocalcodesandallmanufacturer’sinstructions(includingexhaustpipe).

Consultaprofessional installerand/orcallTechnicalSupportifyouhaveany

questions.

15

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



OUTSIDEAIRHOOK‐UP

 Theuseofoutsidecombustionairismandatoryonthispelletstove.

 Theoutsideairconnectionpipeprotrudesfromthelowerrearcenterofthe

stove;usetheincludedoutsideairkittoattachyourstovetooutside

combustionair.Instructionsandallthepartsneededtomakethe

outsideair

connectiontoyourpelletstoveareincludedwiththeoutsideairkit.

 Ifitisnotfeasibletousetheincludedoutsideairhookupkitinyour stove

installation,othermaterialsmaybeused,providedthefollowingrulesare

followed:

 Thepipeusedforoutsideair

hookupmustbemetal,withaminimum

thicknessof.0209in.(25gaugemildsteel)orgreaterandaninside

diameterofapproximately2.0in.

 Allpipejointsandconnectionsshouldbesealedwithpipeclampsorother

mechanicalmeans,toinsurealeakfreeoutsideairconnection.

 Long

runsofpipeandexcessiveelbowsforoutsideairshouldbeavoided.

Duetofrictionalresistanceinpipe,anyexcessiveoutsideairpipingcan

resultinpoorstoveperformance.

 Ascreenorotherprotectiondevicemustbefittedovertheoutsideair

terminationpointtopreventrain,debrisand

nuisanceanimalsfrom

enteringthepipingsystem.

 Increasetheoutsideairpipesizeto3.0in.diameterpipeiftheoutsideair

connectionismorethan6ft.inlength,morethantwo(2)elbowsareused

orifthestoveisinstalledinabasement.

 Theoutsideair

connectionsystemshouldbeinspectedatleastannuallytobe

certainitisfreefromblockage.



Caution

NEVERdrawoutsidecombustionairfrom:

1.Wall,floororceilingcavity.

2.Enclosedspacesuchasanattic,garageorcrawlspace.

16

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



FLOORPROTECTION

 Thispelletstoverequiresanon‐combustiblefloorprotectorifthestoveistobeinstalledonacombustible

floor.Ifthefloorthestoveistobeinstalledonisalreadynon‐combustible(i.e.aconcretefloorina

basement)andhasanRvalueequaltoorhigher

than.2,nofloorprotectionisneeded(althougha

decorativefloorprotectorcanstillbeusedforaestheticreasons).

 PrefabricatedfloorprotectorswhichareULlisted(ULCifCanada)orequivalentcanbepurchasedorafloor

protectorcanbebuiltfromstandardmaterials:twosheetsof.5”thick

cementboardcoveredwithceramic

tilewouldbeasuitablefloorprotectorwhichmeetsthe.2R‐valuerequirement.

 Whenusinganyfloorprotector,considerthatthisstoveisnotonlyheavybutwillinduceheatingand

coolingcyclesonthefloorprotectorwhichcandamagetileandloosenmortarandgroutjoints.Ahearth

rugisNOTanapprovedsubstituteforaproperhearthpad.

 FortheUS:Thefloorprotectormustextendatleast6in.(152.4mm)fromthefront&sidesand4in.

(101.6mm)fromtherear.

 ForCanada:Thefloorprotectormustextendatleast18.0in.(457.2mm)fromthefrontoftheunit,8.0in.

(203.2mm)fromthesidesoftheunitand4.0in.(101.6mm)fromtherear.

 InCanada,itisrequiredthatthenon‐combustiblefloorprotectorisunderneathandextends2in.(50.8

mm.)oneithersideofanyhorizontalventingrunsAND/ORisdirectlyunderneathanyverticalventing

pipe.







6”

(8”Can)

6”

(8”Can)

4”

(Xmm

Can)

6”

(18”Can)

17

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



CONTROLBOARDTYPES

ControlBoardTypes

Yourstovemaycomeequippedwithacontrolboardthatismountedonthetopof

thestove,behindthehopper(“TopMount”),oritmaycomeequippedwitha

controlboardthatismountedonthesidewalloftheunit(“SideMount”).



Forreference,aTopMountcontrolboardlookslikethis:



AndasidemountcontrolboardhasseparatewindowsforHeatRangeandBlower

Speed,likethis:



PLEASE NOTE that some instructions in this manual apply to the TOP MOUNT

board,andotherinstructionsapplytotheSIDEMOUNTboard.

Differenceswillbecalledoutsothatyoumayknowwhatinstructionsapplytoyour

particularstove.



18

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



DAILYOPERATION

GettingStarted

 Checktoseethatthehopperiscleanandfreefromforeignmaterials.Besuretoconnectthisunittoaworking

outlet;werecommendusingasurgeprotectortohelpprotecttheelectroniccomponentsfromdamage.

 BEFOREyourfirstfire,dryrunyourunit(nopelletfuel

inthehopper)fortwentyminutes;pressingthe“ON”button

withtheunitpluggedinwillinitiatethedryrun.

 Whenthe“ON”buttonispressed:

 TopMountcontrolboards:theboardwillscrollthemessage“DIDYOUCLEANBURNPOTBEFORE

STARTING?HOLDONTOCONFIRM”.Pressandholdthe“ON”buttonfor3secondstostartthe

unit.

 SideMountboards:Afterafewseconds,theletters“SU”willappearinthedisplaywindows.

 Oncetheunitstarts,youshouldimmediatelyheartheexhaustblowerstartandoperatecontinuously.The

boardwilldisplaythelastsettingitwassettoforthedurationof

itsoperation,oruntilthesettingis

adjusted.(SideMountcont rol boards willcontinuetoshow“SU”).

 Afteraboutthreetofiveminutes,lookfortheredglowoftheigniterintheigniterportoftheburnpottobe

certainitisoperatingnormally.

 Holdthe

hopperlidswitch(See“IllustratedPartsDiagram”atrearofthismanual)downwithyourfingerand

checktoseethattheauge r is turning.Releasethehopperlidswitchandbecertainthattheaugerstops

turning.DONOTPUTYOURFINGERSINTHEHOPPERORNEARTHEROTATING

AUGER.

 TopMountboardsPleaseNote:Ifthelidswitchisleftdisengaged(notpresseddown)for60seconds,the

unitwillshutdownwithanerrormessageof“HOPPERLEFTOPEN.SHUTTINGDOWN–ifthishappens,the

unitmustbeallowedtoshutdownandthedry

runwouldthenneedtoberepeatedfromthebeginning.

 Notethatthefrontdoormustbeclosedfortheaugertocycle(theboardwillnotgiveavacuumlosserror,

astheboarddoesnotlookforthisuntilproofoffireismet,buttheaugerwill

notcycleifthedoorisopen).

 TopMountboards:Afterapproximatelytwentyminu tes,thecontrolboardshoulddisplay“FAILEDTOSTART

SHUTTINGDOWN”severaltimes,andthenitwillcontinuetodisplay“FAILEDTOSTART”.Tocleartheerror

messagesimplypressthe“OFF”button.

 SideMount

boardswilldisplay“E‐2”inthetwodisplaywindows(moreinformationonErrorCodes

canbefoundintheErrorCodesectionofthismanual).

 Atthispoint,thedryruniscompleteandyourpelletheatingapplianceisreadyfornormaloperation.

LightingaFire

 Inorderforthisstovetooperate,thehoppermustfirstbefilledwithpelletfuel.Liftthehopperlidandpourthe

pelletfueldirectlyintothehopper.Ofcourse,yourstoveshouldbeconnectedtoyourventingsystematthispoint.

 WerecommendusingonlypelletsmanufacturedbyPFICertifiedfacilities,sincepelletsbearingthePFI

stampofapprovalwillbelowinashandmoisture,highinBTU’s,anduniforminsizeandquality.

 Thispelletstovewillperformequallywellusingsoftwoodandhardwoodpellets,andalthoughthe

ashmaydiffer

slightlyinappearanceortexture,bothtypesofpelletswillburncleanlyandefficientlyinthisstove.

 Thispelletstoveisequippedwithanautomatic pelletignitionsystem.Simplypressthe“ON”button

19

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



 TopMountboards:whenthe“ON”buttonispressed,theboardwillscrollthemessage“DIDYOUCLEAN

BURNPOTBEFORESTARTING?HOLDONTOCONFIRM”.Pressandholdthe“ON” buttonfor3secondsto

starttheunit.

 SideMountboards:Shortlyafterpressingthe“ON”button,

theletters“SU”willappearinthedisplay

windowsoftheboard.Thisindicatesthestovehasenteredthestart‐upsequenceandisoperatingnormally.

 Afterinitiatingthestart‐upasdescribedabove,themostrecentsettingwillappearinthewindowofthecontrol

board(Side

Mountboardswillcontinuetoshow“SU”).Thisindicatesthestovehasenteredthestart‐upsequence

andisoperatingnormally.

 Thefuelfeedrateandcombustionairduringstart‐upisdeterminedbythecon t rolboard, sothestovemaybe

startedonanyheatrange.

 Afterapproximatelyfifteenminutes,thefireshouldbeburningbrightly.Atthispoint,thestovehasbegun

normaloperationandthedisplaywindowsonthecontrolboardwilldisplayyoursetting,unlesstheboard

isadjusted.

 Itisnormalfortheunittosmokeduringthefirstfire,aspaintsandoilscure.Thisshoulddissipatewithin

thefirsthour.Openadoorand/orwindowduringthefirstfiretoventilatethearea.



DailyOperationNotes

 Onlyhighquality,PremiumGrade¼”(.25in.)diameterwoodpelletsshouldbeusedinthisstove.

UsinglowgradewoodpelletswithhighashcontentORwoodpelletswithahighmoisturecontent

cancausetheburnpottofillwithashatamorerapidpaceandcan

causeintervalsbetween

periodicmaintenancetobecomesignificantlyshorter.Pleasereadthe“Maintenance”sectionof

thismanualthoroughlytounderstandhowfuelselectionaffectsstoveoperation,maintenance

andcleaning.

 Variationintheflameheightisnormal;notallwoodpelletfuelisuniforminsize,whichcanaffect

the

waypelletsarefedintotheburnpot.Althoughtheflameheightmayincreaseanddecrease

duringoperation,thereisnolossofefficiency.

 Alwaysstorewoodpelletfuelinadrylocation;storingwoodpelletfuelinadrylocationensures

thefuelwillremainpelletizedandlowin

moisturecontent.Also,becertainthatallwoodpellet

fuelisstoredatasafedistancefromthepelletheater;storingfuelincloseproximitytothestove

canresultinafire.Donotinstalloroperatethisunitoutside,inagreenhouse,orin anyarea

thatis

highinmoisture.

 Thispelletburningroomheaterisequippedwithaspeciallydesignedburnpotwhichcomes

preinstalledfromthefactory.Thisburnpotelevatestheburningpelletsanddeliversairatthe

precisely‐requiredlocations.Pelletsmustonlybeburnedinthefactoryburnpot;nomodifications

should

bemadetothisburnpotandnoadditionalgratesorotherfireelevatorsshouldbeused.



20

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



 TopMountboard:Thecircuitboardisequippedwith“ReminderMessages”whichwillpopupand

scrollonthedisplayatvarioustimes.



 ThefollowingapplytotheTopMountboardonly:



 Asnotedabove,thecontrolboardwillasktheuseriftheyhavecleanedouttheburnpotpriorto

everystartwith“HOLDONTOCONFIRM”.



 “Dailycleaningreminder”‐Aftertheunithasrunfor46consecutivehoursofburntime,theboard

willdisplayareminder

toshuttheunitdownandperformdailycleaningwith“PLEASESHUT

DOWNANDCLEANBURNPOT“.ThisremindercodedoesNOTshuttheunitdown,butWILLscroll

untiltheunitiscompletelyshutdownbytheuser.Controlofthestoveisnotaffectedbythe

scrollingmessage;

theusercanadjustthecontrolboardanditwilldisplaytheadjustmentand

thenrevertbacktothescrollingmessageuntiltheusershutstheunitdown.



 “Weeklymaintenancereminder”‐After7daysofcumulativeruntime,thecontrolboardwill

displayascrollingremindermessagetoconfirm

theuserhasperformedtheweeklymaintenance

requiredwith“DIDYOUPERFORMWEEKLYMAINTENANCE?HOLDONBUTTONTOCONFIRM”.

Again,themessagedoesnotaffecttheunit’soperation,andinthiscasecanbeclearedbyholding

the“ON”buttonfor3seconds,atwhichtimetheboardstatuswill

returntoitspreviousstate.

CAUTION

NEVERUSEGASOLINE,GASOLINE‐TYPELANTERNFUEL,KEROSENE,CHARCOALLIGHTERFLUID,OR

SIMILARLIQUIDSTOSTARTOR“FRESHENUP”AFIREINTHISHEATER.KEEPALLSUCHLIQUIDS

WELLAWAYFROMTHEHEATERWHILEINUSE.ADDITIONALLY,NEVERAPPLYFIRE‐STARTERTO

ANYHOTSURFACEOREMBERSINTHESTOVE.DONOTUSECHEMICALSORFLUIDS

TOSTARTTHEFIRE.

DONOTBURNFLAMMABLEFLUIDSSUCHASGASOLINE,NAPHTHAORENGINEOIL.

DONOTBURNGARBAGE;LAWNCLIPPINGSORYARDWASTE;MATERIALSCONTAININGRUBBER,

INCLUDINGTIRES;MATERIALSCONTAININGPLASTIC;WASTEPETROLEUMPRODUCTS,PAINTOR

PAINTTHINNERS,ORASPHALTPRODUCTS;MATERIALSCONTAININGASBESTOS;CONSTRUCTION

ORDEMOLITIONDEBRIS;RAILROADTIESORPRESSURE‐TREATEDWOOD;MANUREORANIMAL

REMAINS;PAPERPRODUCTS,CARDBOARD,PLYWOODORPARTICLEBOARD.THEPROHIBITION

AGAINSTBURNINGTHESEMATERIALSDOESNOTPROHIBITTHEUSEOFFIRESTARTERSMADEFROM

PAPER,CARDBOARD,SAWDUST,WAXANDSIMILA RSUBSTANCESFORTHEPURPOSEOFSTARTING

AFIREINANAFFECTEDWOODHEATER.BURNINGTHESEMATERIALSMAYRESULTINRELEASEOF

TOXICFUMESORRENDERTHEHEATERINEFFECTIVEANDCAUSESMOKE.

 

Summers Heat 55-SHPCAB80S User guide

Related papers

Other documents