Summers Heat 50-SHSSW02 User manual

15‐SSW02,50‐SHSSW02,

50‐TRSSW02



INSTALLATION&OPERATION

MANUAL



CAUTION



Pleasereadthisentiremanualbeforeinstallationanduseofthiswood

fuel‐

burning

appliance. Keepchildren,furniture,fixturesandallcombustibles

away

from

anyheating

appliance.



SAVETHESEINSTRUCTIONS

SAFETY

NOTICE



Failuretofollowtheseinstructionscanresultinpropertydamage,bodily

injury



orevendeath. Foryoursafetyandprotection,followthe

installation

instructionsoutlined

inthismanual. Contactyourlocalbuildingorfire

officials

aboutrestrictionsand

installationinspectionrequirements(including

permits)

inyour

area.



Rev.

10/13/2015



THISWOODHEATERNEEDSPERIODICINSPECTIONANDREPAIRFORPROPEROPERATION.

CONSULTTHEOWNER’SMANUALFORFURTHERINFORMATION.ITISAGAINSTFEDERAL

REGULATIONSTOOPERATETHISWOODHEATERINAMANNERINCONSISTENTWITHTHE

OPERATINGINSTRUCTIONSINTHEOWNER’SMANUAL.



Manufactured

By:

England’sStoveWorks,

Inc.

POBox

206

Monroe,VA

24574



Page | 2

IMPORTANT:IFYOUHAVEAPROBLEMWITHTHISUNIT,DO

NOTRETURNITTOTHEDEALER. CONTACTTECHNICAL

SUPPORT@1‐800‐245‐6489



MobileHomeUse(ApprovedforUSAonly):



Thisfreestandingwoodunitisapprovedformobilehomeor



doublewideinstallationwiththeoutsidecombustionairhook‐

up. Seethe“Installation”sectionofthismanualfordetails

pertainingtomobilehomeinstallations. Mobilehome

installationmustbeinaccordancewiththeManufactured

HomeandSafetyStandard(HUD),CFR3280,Part24.



Retainforyour

files



Model

Number

Date

of

Purchase

Date

ofManufacture

Serial

Number

*Thisinformationcanbefoundonthesafetytagattachedtotherearoftheunit.

Havethisinformationonhandifyouphonethefactoryoryourdealerregardingthis

product.



•

Keepchildrenaway.

CAUTION



•

 Supervisechildreninthesameroomasthisappliance.

•

 Alertchildrenandadultstothehazardsofhightemperatures.

•

 DoNOToperatewithprotectivebarriersopenorremoved.

•

 Hotwhileinoperation!Keepclothing,furniture,draperiesandother

combustiblesaway. Contactmaycauseskinburns!

 DoNOTover‐fireyourunit.

•

 InstallationMUSTcomplywithlocal,regional,stateandnationalcodesand

regulations.

•

 Consultlocalbuilding,fireofficialsorauthoritieshavingjurisdictionabout

restrictions,installationinspection,andpermits.



Page | 3

TABLEOF

CONTENTS



Introduction

•

Introduction.................................4 



Specifications

•

HeatingSpecifications..................5

•

Dimensions...................................5 

•

EPACompliance...........................5



Installation

•

Installation

Overview

...................6

•

ClearancestoCombustibles.........7

•

VentingIntroduction....................8

•

VentingGuidelines.......................8

•

AdditionalVenting

Information

...9

•

Wall

Pass

‐Throughs.....................10

•

ApprovedVentingMethods

o ThroughtheWall...........11

o ThroughtheCeiling........12

o MasonryChimney...........13

o MasonryFireplace..........14

•

MobileHomeInstallation...........15

•

OutsideAir

Hook‐Up

...................15

•

FloorProtection..........................16



Operation

•

Break‐InFires.............................17

•

ContinuousOperation...........17‐18

•

Safety

Notes

...............................19



Maintenance

•

StoveMaintenance....................21

•

Inspecting

Gaskets

......................22

•

Finish..........................................22



Replacing Components

•

Glass...........................................23

•

BurnerTubes..............................24

•

CeramicFiberboard....................24

•

HeatShield&BackPanel...........24

•

OtherComponents.....................25



Optional Accessories

•

AC‐16/AC‐30

Blower

..................25



ImportantInformation

 EPAandSafetyInfo………………26



Troubleshooting Guide

•

Troubleshooting.........................31



Illustrated Parts Detail

•

PartsList.....................................32

•

ExplodedPartsDiagram.............33

•

BrickLayout................................34



Warranty

•

SampleTag..................................35

•

Warranty

Details

.........................36

•

ImportantNo

tice

.........................37

•

WarrantyregistrationForm........38



IMPORTANTNOTES:CLEARANCESMAYONLYBEREDUCEDBYMEANSAPPROVEDBYTHE

REGULATORYAUTHORITYHAVINGJURISDICTION

DONOTCONNECTTOANYAIRDISTRIBUTIONDUCTORSYSTEM.

DONOTBURNGARBAGEORFLAMMABLEFLUIDSSUCHASGASOLINE,NAPHTHAORENGINEOIL.

DONOTUSECHEMICALSORFLUIDSTOSTARTTHEFIRE.

Page | 4

INTRODUCTION



ThankyouforpurchasingthisfineproductfromEngland’sStoveWorks!

England’sStoveWorkswasstarted,andisstillownedby,afamilythat

believesstronglyina“DoItYourself”spirit;that’sonereasonyou



foundthisproductatyourfavorite“DoItYourself”store.



Weintentionallydesignandbuildourstovessothatanyhomeowner

canmaintaintheirunitwithbasictools,andwe’realwaysmorethan

happytoshowyouhowtodothejobaseasilyandasinexpensivelyas

possible. However,whileremainingsimple,ourstovesaredesignedto

performextremelyefficiently,

helpingdelivermoreheatfromlessfuel.



PleaselookatourvastHelpsectiononourwebsiteandcallour

TechnicalSupportDepartmentat(800)245‐6489ifyouneedanyhelp

withyourunit. Wearenearlyalwaysableto“walkyouthrough”any

installationissues,repairs,problemsorotherquestionsthatyoumay

have.



Wishingyouyearsofefficient,qualityand“comfy”heating,



EVERYONEATENGLAND’SSTOVEWORKS



Please Note:Whileinformationobtainedfromourwebsiteand

throughourTechnicalSupportlineisalwaysfreeofcharge,therewill

beaservicechargeincurredwithany“on‐site”repairsormaintenance

thatwemayarrange.

Thismanualencompassesallversionsofthe15‐SSW02,includingthe50‐SHSSW02and

the50‐TRSSW02.However,forsimplicityofdescription,thestovewillbereferredtoby

thegeneric15‐SSW02designation.

Page | 5

SPECIFICATIONS



Heating Sp ecifications



•

MaximumBurnTime**

.............................................................................Upto14

hours

•

ApproximateSquareFootageHeated***

...............................................

2,400sq.ft.

•

Firebox

Capacity........................................................................................23

lbs.

•

FlueCollar

.................................................................................................

6.0in.round



Dimensions(Inches)



EPA and Safety Compliance Specifications

•

EPA

Compliance

......................................................................... ............Certified

•

 Particulate

Emissions............................................................................3.472

grams/hr

 COEmissions……………………………………………………………………..………….146.09grams/hr

•



Efficiency*

...........................................................................................70.32%HHV

•

 Tested

To..................................................................

UL‐1482‐2011,ULC‐S627‐00,

ASTME2515‐11,ASTME2780‐10,EPATestMe thod 28R‐15,CSAB415.1‐10



**‐Maximumburntimesareheavilydependentonthetypeofwoodburnedinthestove;assuch,thesenumbers

mayvary.

***‐Themaximumheatingcapacityofthisunitcanvarygreatlybasedonclimate,constructionstyle,insulation

andamyriadofotherfactors.Usethisinformationinconjunctionwith

aBTUlosscalculationforyourhometo

determineifthisunitwillbesufficientforyourneeds.



“U.S.ENVIRONMENTALPROTECTIONAGENCYCertifiedtocomplywith2015particulate

emissionstandardsforwoodheaters.NotapprovedaftersaleafterMay15,2020.



TAMPERWARNING:“Thiswoodheaterhasamanufacturer‐setminimumlowburnratethat

mustnotbealtered.Itisagainstfederalregulationstoalterthissettingorotherwise

operatethiswoodheaterinamannerinconsistentwithoperatinginstructionsinthis

manual.”

“Thiswoodheaterneedsperiodicinspectionandrepairforproperoperation.Itisagainst

federalregulationstooperatethiswoodheaterinamannerinconsistentwithoperating

instructionsinthismanual.”



34



12



35



27

 23



Page | 6

INSTALLATION



Installation Overview



Whenchoosingalocationforyournewstove,thereareamultitudeoffactorsthat

shouldbetakenintoaccountbeforebeginningtheinstallation.



1.TrafficPatterns–Tohelppreventaccidents,thestoveshouldbeplacedinalocation

whereitisoutofthewayofnormaltravelthroughthe home.



2.HeatFlowandEfficiency–Whendecidingonalocationforthestove,considerthe

wayheatmovesthroughout yourhome.Installthestovewhereyouneedtheheat;

basementinstallationsoftendonotallowsufficientheattoflowtotheupperfloors

andatopfloorinstallationwillnotallowanyheattoreachthefloorsbelow. Always

considerthatheatrisesandwilltakethepathofleastresistancewhileitisstillhot.



3.ExhaustLocation–Theenginewhichdrivesawoodstoveisthechimneysystem,so

itisimportanttoconsiderpreciselyhowthechimneysystemwillbeintegratedinto

thestoveinstallation. Ideally,awoodstovechimneywillruncompletelyvertical

fromthefluecollaroftheunitallthewaytotheterminationpointabovetheroof

line. Keepingtheentirechimneysysteminsidetheheatedenvelopeofthehome

willensureastrong,easytoinitiatedraftinthechimney. Althoughexteriorchimney

systemsoftenfunctionproperly,theyaremorelikelytosufferfromcolddowndrafts

atstartuporprovideweakdrafttotheunit. Also,considerthecross‐sectionalarea

ofthechimney;althoughexistingmasonrychimneyscanoftenbe used,alarge

externalmasonrychimneywillresultinaunitthatisdifficultorimpossibleto

operateproperly. Inthatcase,aninsulatedchimneylinerwilloftenberequiredto

supplythenecessarydraft.



4.WallConstruction–Locatingthestovesothattheexhaustsystemcanpassbetween

studswill simplifytheinstallationandeliminatetheneedtoreframeanysectionsof

thewallorceilingtoaccommodatethewallthimbleorceilingbox.



WARNING



•

Donotstoreorusegasolineorotherflammablevaporsandliquidsinthe

vicinityofthisoranyotherappliance.

•

DoNotOver‐fire–Ifanyexternalpartstartstoglow,youareover‐firing.

Reduceintakeairsupply. Over‐firingwillvoidyourwarranty.



•

Complywithallminimumclearancestocombustiblesasspecified.

Failuretocomplymayresultinahousefire.



•

Testedandapprovedforcordwoodonly. Burninganyotherfuelwill

voidyourwarranty.

Page | 7

INSTALLATION



Clearances to Combustibles



Parallel



Wall

Installation



CornerInstallation



Unitto

Side



Wall

Chimney

Connector

to

Side

Wall

Chimney

Connector

to

Rear

Wall

Unit



Rear

Wall

Unitto

Corner

Chimney

Connector

to

Corner

in.(mm.) in.(mm.) in.(mm.) in.(mm.) in.(mm.) in.(mm.)

SingleWall

Chimney

Connector

Unprotected

Surfacewithside

shields



16(406.4)



26.5(673.1)



15(381)



9(228.6)



13(330.2)



13(330.2)



DoubleWall

Chimney

Connector

Unprotected

Surfacewithside

shields



12(304.8)



22(558.8)



12(304.8)



7(177.8)



10(254)



10(254)

Page | 8

Venting Introduction

INSTALLATION

Venting Guidelines



Thiswoodstoveoperatesona

naturaldraftsystem,inwhichthechimney

systempullsairthroughthestove. Thisunit

mustbeinstalledinaccordancewiththe

followingdetaileddescriptionsofventing

techniques;notinstallingthestovein

accordancewiththedetailslistedherecan

resultinpoorstoveperformance,property 

damage,bodilyinjuryordeath. Avoid

make‐shiftcompromiseswheninstallingthe

ventingsystem. England’sStoveWorksis

notresponsibleforanydamageincurred

duetoapoororunsafeinstallation.

Becertainthatallaspectsofthe

ventingsystemareinstalledtotheventing

manufacturer’sinstructions,particularlythe

requiredclearancestocombustibles. Also,

becertaintouseanatticradiationshieldto

preventinsulationfromcontactinga

chimneywhichpassesthroughanattic.

Thechimneysystemisthe“engine”

whichdrivesawoodstove,soitis

imperativeforproperunitfunctionthatthe

ventingsystembeinstalledexactlyas

describedinthefollowingsection.

Ifquestionsarisepertainingtothe

safeinstallationofthestove,ourTechnical

Supportline(800‐245‐6489)isavailable.

Contactyourlocalcodeofficialtobecertain

yourinstallationmeetslocalandnational

firecodes,andifyou’reuncertainabout

howto safelyinstallthestove,westrongly

recommendcontactingalocalNFIcertified

installertoperformtheinstallation.



•

ALWAYSinstallventpipeinstrict

adherencetotheinstructionsand

clearancesincludedwithyour

ventingsystem.

•

DONOTconnectthiswoodstoveto

achimneyfluewhichalsoserves

anotherappliance.

•

DONOTinstallafluepipedamper

oranyotherrestrictivedeviceinthe

exhaustventingsystemofthisunit.

•

USEanapprovedwallthimblewhen

passingandaceilingsupport/fire

stopwhenpassingthroughaceiling.

•

INSTALLthreesheetmetalscrewsat

everychimneyconnectorjoint.

•

AVOIDexcessivehorizontalruns and

elbows,asbothwillreducethedraft

of theventing systemand will result

inpoorstoveperformance.

•

INSPECTyour ventingsystemoften,

tobecertainitisclearofcreosote,

fly‐ashandotherrestrictions.

•

CLEANtheventingsystemas

detailedinthemaintenancesection

ofthismanual.

•

ADHEREtothe10‐3‐2rule regarding

chimneyterminations.

•

INSTALLsinglewallchimney

connectorwiththemaleenddown

topreventcreosoteleakage. Follow

doublewallchimneyconnector

manufacturer’sinstructions

regardingproperpipeinstallation.



WARNING:VentingsystemsurfacesgetHOT,andcancauseburnsif

touched. Noncombustibleshieldingorguardsmayberequired.

Where passage through a wall or partition of combustible construction is desired, the

installation shall conform with CAN/CSA-B365.

Page | 9

FlueGasDirection



Additional Venting Information

INSTALLATION

•

Donotmixandmatchcomponentsfromdifferentpipemanufacturerswhenassembling

yourventingsystem(i.e.DoNOTuseventingpipefromonemanufacturerandathimble

fromanother).



•

Werequireaminimumchimneyheightof15.0ft. Chimneysystemsshorterthanthis

maynotcreatethe amountofdraftwhichisrequiredtooperatethiswoodburningunit.



•

Donotusemakeshiftcompromiseswheninstallingtheventingsystem;haveexisting

chimneysystemsinspectedbeforeuseandbecertainallnewchimneysystemsare

installedtothemanufacturer’sspecificationsandwithonlyULlistedcomponents(ULCif

Canada).



•

PrefabricatedventingsystemsusedforthisstovemustbelistedtoULCS629(Canada)

andUL103HT(US).



•

Neverinstalladraftinduceroranyothersystemwhichincreasesthenaturaldraftofthe

chimney;similarly,donotinstallabarometricorstovepipedamperwiththisunit.



•

Neverusesinglewallordoublechimneyconnectorasachimneysystem;neverpass

eithertypeofchimneyconnectorthroughacombustiblewallwithoutcarefullyfollowing

themanufacturer’sinstructions andthoselistedinthefollowingpageonWallPass‐

Throughs.NEVERpasschimneyconnectorthroughanattic,floor,closetorroof.

•

Onlyuse24gaugeMSGblacksinglewallchimneyconnectororULListed(ULCifCanada)

doublewallchimneyconnector.



Single Wall Chimney Connector Installation



Themaleendofsinglewall

chimneyconnectoris

installedfacingdownsothat

anyliquidcreosoteinthe

fluewillrunintotheunit

insteadofontotheoutside

ofthepipe(thenaturaldraft

inthechimneysystemwill 

preventsmoke leakageat

thejoints).



Crimpedormaleendof

singlewallchimney

connectormustfacedown.



Fasteneachsinglewall

chimneyconnectorjoint

withthreesheetmetal

screws.



WARNING



•

INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.

•

HOT!Donottouch! Severeburnsorclothingignitionmayresult.

•

Glassandothersurfacesarehotduringoperation.

INSTALLATION

Wall

Pass-Throughs

Canada

, the

installation

must

conform

to CAN/CSA-8365 when passing through

combustible

construction.

Page



Page | 11

18.0in.



2.0ft.



3.0ft.



INSTALLATION



Approved Venting Method 1:ThroughtheWallFactoryBuiltChimney



10

ft.



TerminationCap



StormCollar



RoofFlashing

The 10‐3‐2 Rule:Thechimneysystem

mustterminate3.0ft.abovethepoint

whereitscenterlinepassesthroughthe

roofANDthechimneymustterminate

2.0ft.aboveanypartofthedwelling



withina10ft.radiusofthechimney.



WallThimble

ClassAChimneySystem



ChimneyConnector

(SingleorDoubleWall)

TeeandTeeSupport



•

PrefabricatedchimneysystemsmustconformtoUL‐103HT(2100°F)fortheU.S.andULC‐S629(650°C)for

Canada.

•

Thiswoodburningunitisonlylistedforinstallationwith 6.0”diameterchimneyconnectorandchimneysystems.

Installingthisunitonprefabricatedchimneyslargerthan6.0”diameterwillresultindecreaseddraftandthe



potentialforpoorunitperformance.

•

Followallventingsystemmanufacturer’sinstallationrequir ementsandrequiredclearances.

•

Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s

recommendationswhendoublewallchimneyconnectorisused).

•

Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal

screws(holesshouldbepre‐drilledinfluecollarfromfactory).

•

Properlyattachtheprefabricatedchimneysystemtothehomeinstrictaccordancewiththeprefabricated

chimneysystemmanufacturer’sinstructions.

•

Avoidnumerouselbowsandexcessivehorizontalruns asbothwillleadtopoordraftandincreasedcreosote

accumulation. Horizontalrunsofchimneyconnectormustneverexceed4.0ft. andtheoveralllengthofthe

chimneyconnectormustnotexceed8.0ft.

•

Specialadaptersandslipconnectorsareavailabletoeliminatetheneedtocutsinglewallchimneyconnector.

Doublewallchimneyconnectormustbeusedwiththeseslipconnectors,asitcannotbetrimmedtolength.



Please Note:Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplans

foreachindividualinstallation. Pleasefollowallventingsystemrequirements,maintaintherequiredclearancesto

combustibles,andfollowalllocalcodes.

Page | 12

2.0ft.



3.0ft.



INSTALLATION



Approved Venting Method 2:ThroughtheCeiling



10

ft.



TerminationCap



StormCollar

The 10‐3‐2 Rule:Thechimneysystem

mustterminate3.0ft.abovethepoint

whereitscenterlinepassesthroughthe

roofANDthechimneymustterminate

2.0ft.aboveanypartofthedwelling



withina10ft.radiusofthechimney.



RoofFlashing

ClassAChimneySystem



CeilingSupportBox



ChimneyConnector

(SingleorDoubleWall)



•

PrefabricatedchimneysystemsmustconformtoUL‐103HT(2100°F)fortheU.S.andULC‐S629(650°C)for

Canada.

•

Thiswoodburningunitisonlylistedforinstallationwith 6.0”diameterchimneyconnectorandchimneysystems.

Installingthisunitonprefabricatedchimneyslargerthan6.0”diameterwillresultindecreaseddraftandthe

potentialforpoorunitperformance.

•

Followallventingsystemmanufacturer’sinstallationrequire mentsandrequiredclearances.

•

Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s

recommendationswhendoublewallchimneyconnectorisused).

•

Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal

screws(holesshouldbepre‐drilledinfluecollarfromfactory).

•

Properlyattachtheprefabricatedchimneysystemtothehomeinstrictaccordancewiththeprefabricated

chimneysystemmanufacturer’sinstructions.

•

Theoveralllengthofthechimneyconnectormustnotexceed8.0ft. Inthecaseofcathedralceilings,the

prefabricatedchimneysystemshouldextendto8.0ft.fromthetopoftheunit.

•

Specialadaptersandslipconnectorsareavailabletoeliminatetheneedtocutsinglewallchimneyconnector.

Doublewallchimneyconnectormustbeusedwiththeseslipconnectors,asitcannotbetrimmedtolength.



Please Note:Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplans

foreachindividualinstallation. Pleasefollowallventingsystemrequirements,maintaintherequiredclearancesto

combustibles,andfollowalllocalcodes

Page | 13

2.0ft.



18.0in.



3.0ft.



INSTALLATION



Approved Venting Method 3:InternalorExternalMasonryChimneySystem



10

ft.



Chimneylinercross‐sectional

area(LengthxWidth)must

be

nolargerthantwicethecross‐

sectionalareaofthefluecollar

(2x28.27in

2

=56.55in

). If

chimneylinerislargerthan

56.55in

,reliningwitha5.5”

or6.0”linerisrequired

The10‐3‐2Rule:Thechimneysystem

mustterminate3.0ft.abovethepoint

whereitscenterlinepassesthroughthe

roofANDthechimneymustterminate

2.0ft.aboveanypartofthedwelling

withina10ft.radiusofthechimney.



ChimneyConnector

(SingleorDoubleWall)



MasonryThimblewith

properclearanceto

combustibles



AshCleanoutsmust

haveanairtightsealto

preventweakdraft.



•

Followtheruleslistedaboveconcerningmaximumpermissiblefluelinersize;installingthisunitonmasonry

chimneysexceeding56.55

2

incross‐sectionalareawillresultindecreaseddraftandthepotentialforpoorunit

performance.

•

Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s

recommendationswhendoublewallchimneyconnectorisused).

•

Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal

screws(holesshouldbepre‐drilledinfluecollarfromfactory).

•

Avoidnumerouselbowsandexcessivehorizontalruns asbothwillleadtopoordraftandincreasedcreosote

accumulation. Horizontalrunsofchimneyconnectormustneverexceed4.0ft. andtheoveralllengthofthe

chimneyconnectormustnotexceed8.0ft.

•

Atightsealatthethimbleiscrucialforproperunitperformanceandtocreateasafeinstallation. Usetheproper

adapterdesignedforconnectingsingle ordoublewallchimneyconnectortoamasonrythimble.

•

Haveexistingmasonrychimneysinspectedforsafetyandproperclearancestocombustiblesbeforeputtingthem

intoservice;aqualifiedchimneysweepcanperformthisinspection.

•

Externalmasonrychimney s oftensuffercolddowndraftsandpoordraftperformanceevenwhentheymeetthe

cross‐sectionalarearules. Inthiscase,a6.0”insulatedlinermaybenecessary.



Please Note:Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplans

foreachindividualinstallation. Pleasefollowallventingsystemrequirements,maintaintherequiredclearancesto

combustibles,andfollowalllocalcodes.

Page | 14

INSTALLATION



INSTALLATION INTO A MASONRY FIREPLACE

Preparation

Measure your hearth to ensure it is large enough to accept the unit.

Unit must have a 36” clearance from the top of the stove to a mantel in accordance with NFPA 211

For the USA: Hearth must extend at least 16 in. from the front of the fuel opening.

For Canada: Hearth must extend at least 18 in (450.0 mm) from the front of the fuel opening.

Keep in mind that this type of a installation will make it difficult to change speeds on the

blower frequently. We recommend picking a blower speed and sticking with it, since

adjusting the blower will be difficult because of the tight installation.

WARNING: DO NOT ATTEMPT TO ADJUST BLOWER DURING OPERATION. SKIN BURNS

MAY OCCUR WHEN MAKING CONTACT WITH THE UNIT. WAIT FOR UNIT TO COMPLETELY

COOL BEFORE ATTEMPTING TO ADJUST BLOWER.

Inspect your hearth to be sure it is constructed of a noncombustible material such as brick or

stone. Do not install this stove on a hearth that is constructed of wood framework that is covered

by brick or stone and do not install this unit in a zero (0) clearance fireplace. The manufacturer will

not be held responsible for an accident resulting from this stove being installed on a hearth

constructed of a combustible material.

Inspect your fireplace to ensure it is in proper working order and free of any obstructions.

Prior to installation, remove the existing damper or wire it to fasten it open.

Venting Your Stove - Direct Connect

When this unit is direct connected it will require six inch (6”) diameter 24 gauge pipe from the stove

through the damper opening. (NOTE: The chimney connector must be attached to the appliance

with a minimum of three (3) screws, and 3 screws should be used to attach each adjoining

section.)

We highly recommend having the chimney fully lined with a 6 inch liner to ensure proper draft. This

will make it necessary to block off the open area on both sides of the pipe that passes through the

damper opening, which can be done with sheet metal or by packing flame retardant fiberglass

insulation in the open areas (no paper or combustibles). You must be sure the draft from the

chimney is being pulled through the stove, and not around the connector pipe. .

We highly recommend you have this done by a professional. You should also contact your local

authorities to be sure you are following all codes.

Page | 15

INSTALLATION



WARNING



DONOTINSTALLINASLEEPINGROOM.

CAUTION



THESTRUCTURALINTEGRITYOFTHE

MANUFACTUREDHOMEFLOOR,WALL

AND

CEILING/ROOFMUSTBE

MAINTAINE

Caution



NEVERdrawoutsidecombustionair

from:

Wall,floororceilingcavity



enclosedspacesuchasanattic,garageor

crawl

space.

Mobile Home Installation(USAONLY,NOTAPPROVEDFORCANADIANMOBILEHOMEINSTALLATION)



•

ThewoodstoveMUSTbesecuredtothefloorofthemobilehomeusinglagboltsandtheholes

providedinthebottomoftheunitforthis

purpose.Usea#8copperwiretoground

stovetoframeofmobilehome.



•

Thewoodstovemustbeconnectedtothe

chimneysystemwithdoublewallchimney

connectorwhichisULlistedforusein

mobileandmanufacturedhomes.



•

Carefullyfollowallclearanceslistedinthe

appropriatesectionofthismanualANDfollow

theventingmanufacturer’s

minimum

clearance

requirements. Similarly,becertain

theventingsystemusedisapproved

formobile



homeuse.



•

Installationmustbeinaccordancewith 

ManufacturersHome&SafetyStandard



ChimneyCap/SparkArrestor



ClassAChimneySystem



RoofFlashingandStormCollar



JoistShield/Firestop



MobileHomeApprovedDouble

WallChimney

Connector



Usesiliconetocreateavapor

barrierwherethechimneypasses

throughtoexterior.

(HUD)CFR3280,Part24aswellasanyapplicablelocalcodes.

Outside Combustion Air

•

Theuseofoutsidecombustionairismandatorywheninstalling thiswoodstoveinamobileor

manufacturedhome. 



•

Theoutsideairconnectionpipe protrudesfromthebottomcenterofthestove;akitisavailable

fromEngland’ sStoveWorks,Inc.designedfor connecti ngthis unittooutsidecombustionair.[Part

No.AC‐OAK3]



•

IfitisnotfeasibletousetheAC‐OAK3outsideairhookupkitinyourstoveinstallation,other

materialsmaybeused,providedthefollowingrulesarefollowed:



o Thepipeusedforoutsideairhookupmustbemetal,withaminimumthicknessof.0209in.

(25gaugemildsteel)orgreaterandaninsidediameterofapproximately2.75in.



o Keeppiperunsshortanduseamechanicalfastenerateachpipejoint.



o Ascreenorotherprotectiondevicemustbefittedovertheoutsideairterminationpointto

preventrain,debrisandnuisanceanimalsfromenteringthepipingsystem. Inspectthe

outsidecombustionairinletforblockanddebrismonthly.

Page | 16

FLOORPROTECTION



•

ThiswoodstoverequiresaULlistedtype1sparkandemberfloorprotectorifthestoveistobe

installedonacombustiblefloor. Ifthefloorthestoveistobeinstalledonisalready

non‐combustible(i.e.aconcretefloorinabasement),nofloorprotectionis

needed(althougha

decorativefloorprotectorcanstillbeusedforaestheticreasons).



•

WhenusinganyULlistedtype1sp ar k andemberfloorprotector,co nsiderthatthisstoveisnotonly

heavybutwillinduceheatingandcoolingcyclesonthefloorprotectorwhichcandamagetileand

loosenmortarandgroutjointslocatednearthestove.



•

Thespar kandem berfloorprotectorshouldbeULapprovedorequivalent(ULCifCanada)andmust

benoncombustible. Sincethemajorityoftheheatfromthisunitisradiant,thefloorprotectoronly

servestokeepashesandsparksfromlandingoncombustibleflooringneartheunit. Ahearth

rugis

NOTanapprovedsubstituteforaproperhearthpad.NoRValueisnecessary.



•

FortheUS:Thefloorprotectormustextendatleast16in.fromthefrontofthefuelopening,8in.

fromthesidesofthedooropeningand8in.fromtherearoftheunit.



•

ForCanada:Thefloorprotectormustextendatleast450.0mmfromthefrontofthefuel

opening,



200.0mmfromthesidesofthedooropeningand200.0mmfromtherearoftheunit.



•

Thesparkandemberfloorprotectormustextend2in.(50.8mm.)oneithersideofanyhorizontal

ventingrunsandextenddirectlyunderneathanyverticalventingpipe.



CAUTION



NEVERUSEGASOLINE,GASOLINE‐TYPELANTERNFUEL,KEROSENE,CHARCOALLIGHTER

FLUID,

ORSIMILARLIQUIDSTOSTARTOR“FRESHENUP”AFIREINTHISHEATER. KEEPALL

SUCH

LIQUIDSWELLAWAYFROMTHEHEATERWHILEINUSE. ADDITIONALLY,NEVERAPPLY

FIRE‐

STARTERTOANYHOTSURFACEOREMBERSINTHE

STOVE.



38½in

47in

43

in

49¾in

Page | 17

OPERATION



Break‐In Fires

•

Thiswoodburningunitisconstructedofheavygaugesteelandcastironand isbuilttolastalong

time. However,inordertoensurenoexcessivethermalstressesareinducedonthe

metal

during

thefirstfire,threebreak‐infiresshouldbeburned,eachoneslightlyhotterthanthelast.

Thesebreak‐infireswillnotonlyhelpthestovebodyacclimatetothehightemperaturesofthe

fire,butwillalsoslowlycurethehightemperaturestovepaint,whichwillensurethe

high

qualityfinishlastsforyears.



•

Thisstovehasasingleaircontrolrodwhichregulatesthewoodburnrate;whentheprimaryair

controlslideispulledallthewayoutoftheunit,thestovewillburnmoreslowlyandputout

heatoveralongertimeperiod. Conversely,whentheaircontrolslide

ispushedallthewayin,

theunitwillburnmorequicklyandputoutalargeramountofheatoverarelativelyshorter

time



period. Donotattempttomodifytherangeofaircontroladjustmentforanyreason.



•

Thefirstbreak‐infireshouldbejustalargekindlingfire,gettingthestovetoabout300°Fas

measuredbyamagneticthermometerontherightorleftsideofthestove,abovethe

door.

Once

thistemperatur ehasbeenreached,allowthefiretodieoutwiththeaircontrolopen.The

secondandthirdbreak‐infiresshouldbeabitlarger,withsomesmalldrysplitsaddedtothe

kindlingload. Thetemperaturegoal duringthesefiresisabout35 0°F–450°

F;don’tletthefire

gethotterthanthat.



Continuous Operation

•

Afterthebreak‐infiresarecomplete,thisunitisreadyforcontinuousoperation. Whenburning

thestovecontinuously,donotallowashandcoalstoaccum ulatehigherthantheairholeinthe

dogbox. Excessivecoalingisoftenaresultofburningwoodattoohighaburn

rate,andthecoal

bedshouldbeallowedtoburndownbeforereloadingthestovewithfreshwood.



•

Combustionairisdeliveredtothestoveattwolocations:Themajorityoftheprimarycombustion

airentersthefireboxviatheair‐washsystemwhichkeepstheglasscleanandfeedstheprimary

combustionflamesonthetopsurfacesofthewood;someprimarycombustionairisfedinto

the

coalbedviathedogboxholeinthebottom,frontboxofthestove. (Thisairissuppliedfrom

undertheunit.)Everyeffortmustbetakentomaintaintheareainfrontofthisholefreeofash.



•

Whenloadingthestoveforalongtermburn,itismostusefultorakea“v”inthecenterofthe

coalbed,toallowtheprimaryairbleedholetopushairallthewaytotherearoftheunit.



•

Afterloadingthestovewithafullfireboxoffreshwood,itisimportanttooperatetheunitwith

theaircontrolinthefullopenpositiontoproperlycharthewoodloadanddriveofftheinitial

moistureinthefreshwood. Oncethewoodhasbeenproperlycharred

andiscompletely

ignited,theaircontrolcanthenbesettothedesiredheatoutputlevel.

o AirControlrange:Iftheaircontrolispulledfullyout,thestoveisintheLowBurnsetting.

Pushedapproximately½wayinistheMediumsetting,andwiththeair con trol

pushedall

thewayin,thestoveisintheHighsetting.



•

Thisunitalsooffersanewfeature. Whenloadingthestoveforalonglowburn,youcansetthe

aircontroldampertoallowtheunittoheatupandgetagoodburngoingbeforetheairis

closed



offtotheLowposition. SimplypulltherodouttoLowandturnitcounter‐clockwiseuntil

youhearaslight “click”(aboutaquarterofaturn). Whenitisreadythedamperwillshutitself.

Thiswillworkforlowandmediumlowsettings.Thisensuresgood

combustionattheLowest

burnrate(oreventheMediumburnrate,ifsettoMedium).

age | 18

OPERATION



•

England’sStoveWorks,Inc.alwaysrecommendstheuseofamagneticstovethermometer,so

thatthetemperatureoftheunitcanbemonitored. Whenusingamagneticstovethermometer,

locatethethermometerabovethedooroneithertheleftorrightsideofthestoveandusethe

followingtemperatures

asroughguidelinestodeterminetheburnrateandheatoutputlevelof

thestove:

o Normalwoodstoveoperationshouldoccurbetween350°F(177°C)and550°F(288°C),

with350°F(177°C) to450°F(232°C)beingalowtomediumheatoutputleveland450°F

(232°C)to550°F(288°C)beingamedium

tohighheatoutputlevel. Operatingthestove

at600°F(316°C)wouldbeconsideredthemaximumcontinuousoperatingtemperature

permissibleandunitdamagemayresultfromoperatingatthathighofaburnratefor

extendedtimeperiods. Allowingtheunittoreach750°F(398°C)orhigherisdefinedas

over

‐firingandwillresultinunitdamage.



•

Theoptionalroomairconvectionblowerwasdesignedtoextractthemaximumamountofheat

fromthestove,forthehighestpossibleheattransferintotheroom. Sincetheblowerisso

efficientatremovingheatfromtheunit,itisveryimportanttoonlyoperatetheroomairblower

afterafreshwoodloadhasbeenallowedtoburnforatleastthirty(30)minutes. Allowingafresh

loadofwoodtoburnwithoutthebloweronensuresthattheentireunitreachesproper

operationtemperaturesandthatthesecondarycombustionsystemisfunctioningproperly.

Additionally,followtheguidelinesbelow

foracceptableblowerspeeds.



•

Whenusingtheoptionalroomairconvectionblower(PartNo.AC‐16,oryoucanupgradetothe

AC‐30),theblowershouldbeoperatedasfollowsdependingonheatoutputlevel:



Burn

Rate

High MediumHigh Medium MediumLow Low

BlowerSpeedAC‐16 High

High

Low

BlowerSpeedAC‐30 High MediumHigh Medium MediumLow Low

Creosote – Formation and Need for

Removal



Whenwoodisburnedslowly,itproducestarandotherorganicvapors,

which



combinewithexpelledmoisture toformcreosote. Thecreosote

vapors

condenseintherelativelycoolchimneyflueofaslow‐burningfire. Asa

result,

creosoteresidueaccumulatesonthefluelining. Whenignited,this

creosote

makesanextremelyhotfire. Thechimneyandchimneyconnectorshould

be

inspectedatleastonceeverytwomonthsduringtheheatingseason

to

determineifacreosotebuilduphasoccurred. Ifcreosotehasaccumulated,

it

shouldberemovedtoreducetheriskofchimney

fire.

DONOTUSEGRATESORANDIRONSOROTHERWISEELEVATEFIRE–BUILD

WOODFIREDIRECTLYON

HEARTH



DONOTOPERATEWITHTHEMAINDOOROPEN–OPERATINGTHESTOVEWITHTHE

MAIN

DOOROPENWILLCREATEANOVER‐

FIRE

Intheeventofacreosoteorsootfire(chimneyfire),closetheaircontrolonthe

stove,

contactthelocalfiredepartmentandgetout! Donotthrowwateronthefire!

Contact

yourlocalfireauthorityformoreinformationonhowtohandleachimneyfire

and



developasafeevacuationplanforyouandyourfamilyintheeventofachimneyfire.

Page | 19

OPERATION



Additional Safety Guidelines



CAUTION:Whenaddingfueltothestove,theblowermustbeturnedOFF.



•

Theinstallationofsmokedetectorsishighlyrecommendedwheninstallingthisoranyother

solidfuelburningappliance. Smokedetectorsshouldbelocatednearorineveryroomofthe

home,particularlysleepingrooms.



•

Asmokedetectorcanbeinstalledinthesameroomasthiscordwoodburningunit;installingthe

smokedetectortooclosetotheunitcanleadtonuisancealarms duetoslightwispsofsmoke

emittedduringthefirestartingorreloadingprocess. Duetothis,thesmokedetectorin

the

sameroomastheunitwillbemostusefulifitislocatedas farfromtheunitastheroomwill

permit.



•

Thisstoveisdesignedtoburnnaturalwoodonly.Higherefficienciesandloweremissions

generallyresultwhenburningairdried,seasonedhardwoods,ascomparedtosoftwoodsorto

greenorfreshly‐cuthardwoods.DONOTBURNgarbage,lawnclippingsoryardwaste,

materialscontainingrubber,includingtires;Materialscontaining

plastic:Wasterpetroleum

products,paintsor paintthinners,orasphaltprodu c ts;Material scontainingasbestos;

Constructionordemolitiondebris;Railroadtiesorpressure‐treatedwood;Manureor

animalremains;Saltwater driftwoodorpreviouslysaltwatersaturatedmaterials;Paper

products,cardboard,plywood,orparticleboard.Theprohibi tionagainstburningthese

materialsdoesnot

prohibittheuseoffirestartersmadefrompaper,cardboard,sawdust,

waxandsimilarsubstancesforthe purposeofstartingafireinanaffectedwoodheater.

Burningthesematerialsmayresultinreleaseof toxicfumesorrendertheheaterineffective

andcausesmoke.



•

Burningfuelsotherthancordwood,particularlycoalandcharcoal,canresultinhazardous

concentrationsofcarbonmonoxidebeingemittedintothedwelling. Forthesereasons,NEVER

burncoalorcharcoalinthiscordwoodstove.Installingacarbonmonoxidedetectorandbeing

awareofthesymptomsofcarbonmonoxidepoisoningcan

helpreducetheriskofcarbon

monoxiderelatedissues. 



•

Thisunitwasdesignedforoperationonlywiththeloadingdoorclosedandtightlylatched. 

Operatingthisunitwiththeloadingdoorlatchedlooselyoropenwillallowexcessivecombustion

airtoreachthefireandwillresultindangerouslyhighunittemperatures. Highunit

temperaturescan damagetheunit,

voidthewarrantyorignitecreosotedepositedinthe

chimneysystembyprevious,slowburningfires.



•

Thenaturaldraftthatpullsairthroughthis unitandallowsthefiretoburnusestheindoorairof

thedwellingforcombustion,unless theunitisconnectedtoanoutsidecombustionairsource.

Kitchenrangeventhoods,furnacesandotherairmovementappliancesinthehomeareoften

alsoremovingairfromthedwelling;iftheamountofairfiltrationorleakagebackintothehome

isexceededbytheairbeingremoved,negativepressuremaybecreatedinthehome.



•

Sincethisisanaturaldraftappliance,itwilloftenbethefirstappliancetohaveproblemsrelated

tonegativepressure. Ifsmokeisforcedoutthechimneyconnectorjointsoroutoftheair

inductionsystemoftheunit,theunitislikelyfightingnegativepressureinthedwelling.

Crackingawindowordoorneartheappliancecanhelpequalizethenegativepressure;

DONOTSTOREFUELCLOSERTHANSPECIFIEDCLEARANCESTOCOMBUSTIBLESOR

WITHINTHESPACENEEDEDFORLOADINGTHESTO

EANDFORASHREMO

AL.

Page | 20

ultimately,anunrestrictedsourceofoutsidecombustionmaybenecessaryforproperunit

function.



•

Iftheunitisconnectedtooutsideair,becertaintomonitortheexteriorinlettothecombustion

systemforicingorsnowaccumulation. Allowingtheoutsideairconnectionto

becomerestricted



willresultinairstarvationtotheunit.



SafeWood‐BurningPractices



Onceyourwood‐burningapplianceisproperlyinstalled,followtheseguidelinesfor

safeoperation:



 Keepallflammablehousehoulditems‐drapes,furniture,newspapers,andbooks‐

farawayfromtheappliance.



Startfiresonlywithnewspaper,drykindlingandallnaturalororganicfire

starters.Neverstart

afirewithgasoline,kerosene,orcharcoalstarter.



 Donotburnwetorgreen(unseasoned)logs.



Donotuselogsmadefromwaxandsawdustinyourwoodstove‐theyaremadeforopen

hearthfireplaces.Ifyouusemanufacturedlogs,choosefromthosemadefrom100

percentcompressed

sawdust.



Buildhotfires.Formostappliances,asmolderingfireisnotasafeorefficientfire.



Keepthedoorstoyourwood‐burningapplianceclosesunlessloadingorstokingthelive

fire.Harmfulchemicals,likecarbonmonoxide,canbereleasedintoyourhome.



Regularlyremoveashesfromyourwood

‐burningapplianceintoametalcontainerwitha

cover.Storethecontainerofashesoutdoorsonacementorbrickslab (notonawood

deckornearwood).Seeashremovalinstructionsinyourowner’smanual.

Keepafireextinguisherhandy.

Remembertocheckyourlocalairqualityforecast

beforeyouburn.



Page is loading ...

Summers Heat 50-SHSSW02 User manual

Related papers

Other documents