ECHOGEAR EGCM2 Full Motion TV Wall Mount User manual

ECHOGEAR
Brand
ECHOGEAR
Model
EGCM2 Full Motion TV Wall Mount
Category
Flat panel wall mounts
Type
User manual
#YourGearUpgraded
INSTRUCTION MANUAL
Full Motion
TV Wall Mount
Model EGCM2
LANGUAGES
Visit: echogear.com
ES FR DE NL SV JA ZH RU
CAUTION: DO NOT exceed
the maximum weight indicated. This
mounting system is intended for
use only with the maximum weights
indicated. Use with products
heavier than the maximum weights
indicated may result in collapse
of the mount and its accessories,
causing possible injury.
2
90 lbs.
(40.8 kg)
If your TV weighs more, this mount is NOT compatible.
Visit echogear.com to find a compatible mount.
Your TV (including accessories)
CANNOT EXCEED 90 lbs.
(40.8 kg) for this mount.
“You can think about it ...
but doooon’t do it.”
IMPORTANT SAFETY INSTRUCTIONS. READ ENTIRE MANUAL PRIOR TO USE. SAVE These INSTRUCTIONS.
Yea, the boring stuff ... but read it so you don’t jack things up!
Weight Restrictions
Please read through these instructions completely to be sure you’re comfortable with this easy install process.
Also check your TV owner’s manual to see if there are any special requirements for mounting your TV.
If you do not understand these instructions or have doubts about the safety of the installation, assembly
or use of this product, contact The Echogear Pros (See Back Page)
CAUTION: Avoid potential personal injuries and property damage!
►This product is designed for use in wood stud, solid concrete and concrete block walls
- DO NOT install into drywall alone.
►The wall must be capable of supporting five times the weight of the TV and mount combined.
►Do not use this product for any purpose not explicitly specified by manufacturer.
►Manufacturer is not responsible for damage or injury caused by incorrect assembly or use.
“Apologies to
all the Jacks
in the world”
3
Grab Your Tools
Verify Your Wall Construction
Hex Wrench
Cable Wrap
Toy Toy SurpriseSurprise
Inside Every Box
4mm
HK C
CAUTION:
DO NOT install into
drywall alone
Drywall will not hold the weight
and motion of your TV.
... unless you WANT to watch your
TV fall and crash onto the floor.
wood stud Solid Concrete or
Concrete Block?
Perfect!
Good to Go
Perfect!
Good to Go
Unsure?
Contact
The Echogear Pros
(See Back Page)
?
UUUUHH ?!?
Socket
Wrench
1/2 in.
(13 mm)
Pencil LevelPhillips
Screwdriver
Tape
Measure Electric Drill
"Give it back
to Phil when
you finish"
"collect the
whole set"
FREE
Awl
Stud
Finder
7/32 in.
(5.5 mm)
for wood
Drill Bit Hammer
Drill Bit
3/8 in.
(10 mm)
for concrete
Wood Stud Installation Concrete Installation
4
M8 x 25mm M8 x 50mm
M8 x 16mm M8 x 35mm
M6 x 12mm M6 x 35mm
M5 x 8mm
2.5mm
22mm
5mm
5/16 in.
5/16 x 2¾ in.
M6 x 12mm
M4 x 12mm M4 x 35mm
WARNING: DON'T FEED TO CHILDREN —This product contains small items that could be a choking hazard
if swallowed. Before starting assembly, verify all parts are included and undamaged. If any parts are missing or
damaged, do not return the damaged item to your dealer; contact Customer Service.
Never use damaged parts!
What’s in the Box ... what's in the boooox
NOTE: Not all hardware included in this kit will be used.
STUFF FOR STEP 1STUFF FOR STEP 1
TV Screws (qty. 4 each)
[Only one size fits your TV]
Washer
(qty. 4 each)
Spacers
[If necessary]
TV
Bracket
qty. 8
qty. 2
qty. 4
qty. 4
M6
M6/M8
M8
1
23
M4/M6/M8
4
M4
M4
5
Hardware for STEP 2B Concrete Installation
[Concrete Anchor Kit #EGHWLB is NOT INCLUDED]
M8 x 25mm M8 x 50mm
M8 x 16mm M8 x 35mm
M6 x 12mm M6 x 35mm
M5 x 8mm
2.5mm
22mm
5mm
5/16 in.
5/16 x 2¾ in.
M6 x 12mm
M4 x 12mm M4 x 35mm
STUFF FOR STEP 2STUFF FOR STEP 2
Wall Plate/
Arm Assembly
Drill
Template
Lag Screw Washer (Lag Screw)
Extension Screw
Extension
Brackets End Cap
End Cap Screw
qty. 2
9qty. 2
10
qty. 2
11
qty. 2
12
qty. 2
8
qty. 1
6
qty. 1
5
qty. 2
7
qty. 4
14
qty. 4
13
Wall Plate
Cover
Fischer UX10 x 60R
Concrete Anchor
For concrete installations ONLY
CAUTION: Do not use in drywall or wood
You can order the
Concrete Anchor Kit:
Model EGHWLB.
Sold online at
ECHOGEAR.com or
Amazon... or contact The
Echogear Pros (see back page)
C1
qty. 4
6
TV Screw Diameter
STEP 1.1
Only one screw size fits your TV.
M6
M4
M8
"Suggested uses for the extra screws:
board game pieces, industrial jewelry, sweet corn
holders, musical instruments– like maracas or
'monsoon' sticks, stocking stuers, currency
(not most countries) ..."
NOTE: If your
TV included inset
spacers or adapters,
use them UNDER
the mount hardware.
CAUTION: Verify adequate thread engagement with
your screw 01 , washer 02, spacer 03 combination AND TV
bracket 04 .
Too short will not
hold your TV.
Too long will
damage your TV.
STEP 1 Attach the TV BRACKETS TO YOUR TV
7
SPACER NEEDED
b
NO SPACER
a
TV Screw Length
STEP 1.2
For Flat Back TVs
[TV brackets 04
lay flat on your TV]
For Flat Back TVs with
Extra Space Needed
[for deep inset holes or cable interference]
For Rounded or
Irregular Back TVs
[TV brackets 04
NOT resting flat on your TV]
Long Screw
Short Screw
Washer
Washer
Spacer
TV Bracket
TV Bracket
01 02
03
04
04 02
EXTRA
SPACE
01
8
Secure the TV Brackets to Your TV
1.3
TV BRACKETS MUST BE LEVEL
INSTALL UP/DOWN
IF NEEDED
LOW
MOUNTING
HOLES
HIGH
MOUNTING
HOLES
04
04
04
9
With Spacer
b
No Spacer
Alternate
Spacer setups
a
01 01
02
02
03
04
10
Standard
(Diagonal)
TV Size *
MIN
Minimum Distance
from Corner
MAX
Maximum Distance
from Corner
55 in. (140 cm)
and under 1.5 in. (3.5 cm) 30 in. (76 cm)
60 in. (152 cm) 5.5 in. (14 cm) 29.5 in. (75 cm)
65 in. (165 cm) 9.5 in. (24 cm) 29 in. (73.5 cm)
STEP 2 Install the Wall Plate
Determine Your Mount Location to Center Your TV in the Corner
STUD
MIN
MAX
STUD
STUD
STUD
* MIN/MAX shown are for typical (diagonal) TV sizes.
If you're the type that needs a more precise
measurement to locate your TV, see PAGE 19.
2.1
ForafkAFK
For Wood Stud Installs:
fvYour stud CENTER must be located
at or between the MIN and MAX.
“Let's put this baby
in the corner!”
11
SOLID WALL BLOCK WALL
CAUTION: Avoid potential personal injuries and property damage!
Mount wall plate/arm
06 directly onto the concrete surface
(no surface covering).
Min.
8 in.
(203 mm)
Min.
8 in.
(203 mm)
Min.
8 in.
(203 mm)
Min.
16 in.
(406 mm)
For
WOOD STUD INSTALLATIONS, follow STEP 2.2-A on PAGE 12
For
CONCRETE INSTALLATIONS, follow STEP 2.2-B on PAGE 14
CAUTION: Avoid potential personal injuries and property damage!
Drywall covering the wall must not exceed 5/8 in. (16 mm).
Minimum wood stud size:
nominal 2 x 4 in. (51 x 102 mm) actual 1 ½ x 3 ½ in. (38 x 89 mm).
Max. Drywall:
5/8 in. (16 mm)
Min. Wood Stud Width:
nominal 2 in. (51 mm)
actual 1 ½ in. (38 mm)
Min. Wood Stud Depth:
nominal 4 in. (102 mm)
actual 3 ½ in. (89 mm)
DO NOT Install in drywall alone.
Drywall will not hold the weight and motion of your TV.
CAUTION: Avoid potential personal injuries and property damage!
12
Mark
2.3-A
5
Use a stud
finder ...
... and/or verify
the edges with
an awl or a
small drill bit.
X-Ray
Specs
sold
separately
Find a Stud
2.2-A
"favorite
pokey device"
For Wood Stud INSTALLATION
13
Drill
2.4-A
7/32 in.
(5.5 mm)
2 ¾ in. (7 cm)
Bit
Secure Wall Plate
2.5-A
CAUTION: Avoid potential personal injury or
property damage! Lag screws 7 MUST BE firmly
tightened to prevent unwanted movement of the wall
plate/arm 6.
8 67
For Wood Stud INSTALLATION
Go to STEP 2.6 on PAGE 16
14
For CONCRETE INSTALLATION
Mark
2.2-B Drill
2.3-B
5
002862.eps
3/8 in.
(10 mm)
3 in. (7.5 cm)
Bit
15
For CONCRETE INSTALLATION
Insert Concrete Anchors
2.4-B Secure Wall Plate
2.5-B
CAUTION: Avoid potential personal injury or
property damage! Lag screws 7 MUST BE firmly
tightened to prevent unwanted movement of the wall
plate/arm 6.
8 67
"whichever way
your mind works"
FLUSH
Go to STEP 2.6 on PAGE 16
C1
Concrete Anchor Kit
Model EGHWLB is
NOT INCLUDED,
Sold online at
ECHOGEAR.com or
Amazon... or contact
The Echogear Pros
(see back page)
**
16
Assemble Extensions
2.7
Attach Covers
2.6
10
11
9
9
6
13
HK
2X
17
Assemble End Caps
2.8
14
12
12 14
12
4X
18
Open the Safety Locks
3.1
4
4
IMPORTANT:
Save the screws
S
for STEP 3.3
2X
S
STEP 3 Hang Your TV
19
HEAVY! You may need
assistance with this step.
Hang Your TV
3.2
4
6
4
6
"SPAN THE FACEPLATE ...
that's a good name for a band!"
"Ask that friend of
yours that yammers
on about CrossFit"
IMPORTANT:
TV brackets
4
MUST
be centered
AND span the faceplate of arm
6
.
10
4
11
20
Secure Your TV
3.3
4
2X
CAUTION: Avoid potential personal injury or property damage!
Bracket clips and screws
S
MUST be installed to the secure the
TV in place. DO NOT OVERTIGHTEN.
S
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24

ECHOGEAR EGCM2 Full Motion TV Wall Mount User manual

ECHOGEAR
Brand
ECHOGEAR
Model
EGCM2 Full Motion TV Wall Mount
Category
Flat panel wall mounts
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents