GE ZV1050SFSS Installation guide

INSTALLATION

INSTRUCTIONS

42” Island Vent Hood

ZV1050

MONOGRAM.COM

2 31-14899 Rev. 3

Safety Information

READ AND SAVE THESE INSTRUCTIONS

BEFORE YOU BEGIN

Read these instructions completely and carefully.

IMPORTANT — Save these instructions

for local inspector’s use.

IMPORTANT — Observe all governing

codes and ordinances.

ŶNote to Installer — Be sure to leave these

instructions with the Consumer.

ŶNote to Consumer — Keep these instructions with

your Owner’s Manual for future reference.

ŶSkill Level — Installation of this appliance requires

basic mechanical and electrical skills.

ŶCompletion Time — 1 to 3 Hours.

Ŷ3URSHULQVWDOODWLRQLVWKHUHVSRQVLELOLW\RIWKH

LQVWDOOHU3URGXFWIDLOXUHGXHWRLPSURSHULQVWDOODWLRQ

is not covered under the warranty.

Ŷ)RU0RQRJUDPORFDOVHUYLFHLQ\RXUDUHDYLVLW

monogram.com.

Ŷ)RU0RQRJUDPVHUYLFHLQ&DQDGDYLVLWmonogram.ca

Ŷ)RU0RQRJUDP3DUWVDQG$FFHVVRULHVYLVLW

monogram.com/use-and-care/parts.

CAUTION

Due to the weight and size of this

vent hood and to reduce the risk of personal injury

RUGDPDJHWRWKHSURGXFWwe recommend at least

three people install this hood.

ATTENTION

À cause du poids et de la taille de

la hotte et pour réduire les risques de blessures ou de

GRPPDJHVGHO¶pTXLSHPHQWnous recommandons

que trois personnes installent cette hotte.

WARNING

To reduce the risk of fire or electrical

VKRFNGRQRWXVHWKLVUDQJHKRRGZLWKDQ\H[WHUQDO

VROLGVWDWHVSHHGFRQWUROGHYLFH$Q\VXFKDOWHUDWLRQ

from original factory wiring could result in damage to

the unit and/or create an electrical safety hazard.

AVERTISSEMENT

3RXUUpGXLUHOHULVTXH

G¶LQFHQGLHRXGHFKRFpOHFWULTXHLOQHIDXWSDVXWLOLVHU

cette hotte avec un régulateur de vitesse électronique

H[WHUQH7RXWHPRGLILFDWLRQGHFHW\SHGXEUDQFKHPHQW

d’usine peute endommager l’appareil ou créer un

risque de choc électrique.

TO REDUCE THE RISK OF FIRE, USE ONLY

METAL DUCTWORK.

WARNING

725('8&(7+(5,6.2)),5(

(/(&75,&$/6+2&.25,1-85<723(56216

2%6(59(7+()2//2:,1*

$8VHWKLVXQLWRQO\LQWKHPDQQHULQWHQGHGE\WKH

PDQXIDFWXUHU,I\RXKDYHDQ\TXHVWLRQVFRQWDFW

the manufacturer.

%%HIRUHVHUYLFLQJRUFOHDQLQJXQLWVZLWFKSRZHURIIDW

the service panel and lock service panel to prevent

power from being switched on accidentally. If the

VHUYLFHSDQHOFDQQRWEHORFNHGIDVWHQDWDJRU

prominent warning label to the panel.

AVERTISSEMENT

32855e'8,5(/(5,648(

'¶,1&(1',('(&+2&e/(&75,48(28'(%/(6685(6

,/)$872%6(59(5/(65(*/(668,9$17(6

$

Utilisez cet appareil uniquement de la maniéré prévue par

OHIDEULFDQW(QFDVGHTXHVWLRQFRQVXOWH]OHIDEULFDQW

B. $YDQWWRXWHLQWHUYHQWLRQRXQHWWR\DJHFRXSH]

l’alimentation électrique au disjoncteur et verrouillez le

panneau du disjoncteur pour éviter la mise sous tension

accidentelle. S’il n’est pas possible de verrouiller le

SDQQHDXGXGLVFRQFWHXUDWWDFKH]XQSODFDUGRXXQH

étiquette très visible au panneau.

Ŷ)RUJHQHUDOYHQWLODWLQJXVHRQO\'RQRWXVHWRH[KDXVW

KD]DUGRXVRUH[SORVLYHPDWHULDOVRUYDSRUV

Ŷ6WUXFWXUDOIUDPLQJLQVWDOODWLRQZRUNDQGHOHFWULFDO

wiring must be done by qualified person(s) in

accordance with all applicable codes and standards

including fire-rated construction.

ŶSufficient air is needed for proper combustion and

H[KDXVWLQJRIJDVHVWKURXJKWKHIOXHFKLPQH\RIIXHO

EXUQLQJHTXLSPHQWWRSUHYHQWEDFNGUDIWLQJ)ROORZWKH

heating equipment manufacturer’s guideline and safety

VWDQGDUGVVXFKDVWKRVHSXEOLVKHGE\WKH1DWLRQDO)LUH

3URWHFWLRQ$VVRFLDWLRQ1)3$WKH$PHULFDQ6RFLHW\IRU

+HDWLQJ5HIULJHUDWLRQDQG$LU&RQGLWLRQLQJ(QJLQHHUV

$6+5$(DQGWKHORFDOFRGHDXWKRULWLHV:KHQ

DSSOLFDEOHLQVWDOODQ\PDNHXSUHSODFHPHQWDLUV\VWHP

in accordance with local building code requirements. Visit

GEAppliances.com for available makeup air solutions.

Ŷ/RFDOFRGHVYDU\,QVWDOODWLRQHOHFWULFDOFRQQHFWLRQV

and grounding must comply with applicable codes.

,QWKHDEVHQFHRIORFDOFRGHVWKHYHQWVKRXOGEH

LQVWDOOHGLQDFFRUGDQFHZLWK1DWLRQDO(OHFWULFDO&RGH

$16,1)3$RUODWHVWHGLWLRQ

CAUTION

To reduce risk of fire and to properly

H[KDXVWDLUEHVXUHWRGXFWDLURXWVLGH²GRQRWYHQW

H[KDXVWDLULQWRVSDFHVZLWKLQZDOOVRUFHLOLQJVRULQWR

DWWLFVFUDZOVSDFHVRUJDUDJHV

ATTENTION

Il faut prendre soin d’installer un

FRQGXLWYHUVO¶H[WpULHXUSRXUUpGXLUHOHULVTXHG¶LQFHQGLH

et pouvoir évacuer l’air correctement. Il ne faut pas

évacuer l’air correctement. Il ne faut pas évacuer l’air

GDQVO¶HVSDFHHQWUHOHVSDURLVG¶XQPXUXQSODIRQGRXXQ

JUHQLHUXQHVSDFHVDQLWDLUHRXXQJDUDJH

31-14899 Rev. 3 3

Design Information

CONTENTS

Design Information

3URGXFW'LPHQVLRQV ...................................................... 3

'XFW&RYHU$FFHVVRULHV ............................................

Determine Installation Height ....................................... 

$GYDQFH3ODQQLQJ

Tools and Materials Required ....................................... 5

3RZHU6XSSO\ ................................................................ 5

'XFW)LWWLQJV .................................................................. 6

Installation Instructions

6WHS&RQVWUXFW&HLOLQJ6XSSRUW .............................  ±  

6WHS5HPRYH3DFNDJLQJ ......................................... 

6WHS&KHFN,QVWDOODWLRQ+DUGZDUH ........................... 

6WHS0RXQW7HPSODWH .............................................. 11

6WHS,QVWDOO6XSSRUW)UDPH ..................................... 11

6WHS6HFXUH:LULQJ ................................................. 12

6WHS6L]HDQG,QVWDOO'XFWZRUN ............................... 12

6WHS,QVWDOO'HFRUDWLYH'XFW&RYHUV ....................... 13

6WHS,QVWDOO+RRG ..................................................... 13

6WHS&RQQHFW(OHFWULFDO ......................................... 

6WHS6OLGH'XFW&RYHU'RZQ ................................ 

6WHS,QVWDOO)LOWHUV)LQDOL]H,QVWDOODWLRQ ................. 15

PRODUCT DIMENSIONS

This vent hood is designed to be used in vented ceiling-

mounted installations. It can be installed over any

0RQRJUDPFRRNWRSRUUDQJHLQFOXGLQJ3URIHVVLRQDO

models.

DUCT COVER ACCESSORIES

$'XFW&RYHU$FFHVVRU\PD\EHUHTXLUHGIRU\RXUKRRG

LQVWDOODWLRQKHLJKW2UGHUDFFHVVRU\GXFWFRYHUVIRUIW

DQGIWFHLOLQJV

ZX1059SFSS –)RUIWFHLOLQJKHLJKW

This kit includes a decorative duct cover and support

IUDPHWRUHDFKDIWFHLOLQJKHLJKW

ZX10510SFSS – )RUIWFHLOLQJKHLJKW

This kit includes a decorative duct cover and support

IUDPHWRUHDFKDIWFHLOLQJKHLJKW

´WRDQIWFHLOLQJXVLQJVXSSOLHGGXFWFRYHU

´IRUIWFHLOLQJXVLQJ=;6)66$FFHVVRU\

´IRUIWFHLOLQJXVLQJ=;6)66$FFHVVRU\

This vent hood is supplied with a decorative duct cover

WRUHDFKIWFHLOLQJKHLJKWRUEHWZHHQ¶´DQG¶´

10"

*Height

to Ceiling

42"

31-1/2"

 31-14899 Rev. 3

DUCT COVER ACCESSORIES

Order the accessory at the same time as the vent

hood and have on-site before installation begins.

Use this chart to accurately determine the need for a

'XFW&RYHU$FFHVVRU\

Design Information

DETERMINE INSTALLATION HEIGHT

The distance between the cooking surface and the

ERWWRPRIWKHKRRGPXVWEHDWOHDVW´7KH´

UHFRPPHQGHGLQVWDOODWLRQKHLJKWDERYHWKHVWDQGDUG

´FRXQWHUWRSZLOOHQVXUHGXFWFRYHUILWWRWKHFHLOLQJ

)RUIWDQGIWFHLOLQJKHLJKWVWKHKRRGPD\EH

ORZHUHGWR´RYHUWKHFRRNLQJVXUIDFH

Ŷ:KHQLQVWDOOLQJWKH,VODQG+RRGDERYHD0RQRJUDP

3URIHVVLRQDO5DQJHRU5DQJHWRSLQVWDOODWLRQ

FOHDUDQFHPXVWEHDWOHDVW´

IMPORTANT: Clearances may vary due to type of

cooking product and local codes. Check with local

inspectors to be sure standard is applicable.

DUCT COVER DIMENSIONS

Installation Heights

Actual

Ceiling

Height

Possible

VENTED

Installation

Height

Duct Cover

7'11" 29" Supplied

8'0" 30" Supplied

8'1" 30" Supplied

8'2" 25-1/2" to 30" ZX1059SFSS

8'3" 25-1/2" to 30" ZX1059SFSS

8'4" 25-1/2" to 30" ZX1059SFSS

8'5" 25-1/2" to 30" ZX1059SFSS

8'6" 25-1/2" to 30" ZX1059SFSS

8'7" 25-1/2" to 30" ZX1059SFSS

8'8" 25-1/2" to 30" ZX1059SFSS

8'9" 25-1/2" to 30" ZX1059SFSS

8'10" 25-1/2" to 30" ZX1059SFSS

8'11" 25-1/2" to 30" ZX1059SFSS

9'0" 25-1/2" to 30" ZX1059SFSS

9'1" 25-1/2" to 30" ZX10510SFSS

9'2" 25-1/2" to 30" ZX10510SFSS

9'3" 25-1/2" to 30" ZX10510SFSS

9'4" 25-1/2" to 30" ZX10510SFSS

9'5" 25-1/2" to 30" ZX10510SFSS

9'6" 25-1/2" to 30" ZX10510SFSS

9'7" 25-1/2" to 30" ZX10510SFSS

9'8" 25-1/2" to 30" ZX10510SFSS

9'9" 25-1/2" to 30" ZX10510SFSS

9'10" 25-1/2" to 30" ZX10510SFSS

9'11" 25-1/2" to 30" ZX10510SFSS

10'0" 25-1/2" to 30" ZX10510SFSS

*30"

Recommended

36" Min.

IWWRIWFHLOLQJVPD\EH´WR´FOHDUDQFH

ZV1050 Duct Cover

Dimensions

Model A B

=9 11-1/2" 12"

=;  

=; 25" 26"

31-14899 Rev. 3 5

TOOLS AND MATERIALS REQUIRED

(not supplied)

• Tape measure

• Knife

• Spirit level

:LUHFXWWHU

:LUHVWULSSHU

:LUHQXWV

(OHFWULFGULOODQG´ELW

3KLOOLSVVFUHZGULYHU

)ODWEODGHVFUHZGULYHU

• Hammer

3OLHUV

• Safety glasses

• Tape to mount template

*ORYHVWRSURWHFWDJDLQVWVKDUSHGJHV

9+]RU$PSZLUHZLWKJURXQG

properly grounded branch circuit

• Strain relief for junction cover

3OXPEERE

• Center punch

Advance Planning

POWER SUPPLY

IMPORTANT - (Please read carefully)

WARNING

)253(5621$/6$)(7<7+,6

$33/,$1&(0867%(3523(5/<*5281'('

AVERTISSEMENT

3285'(65$,6216

'(6e&85,7e&(7$33$5(,/'2,7Ç75(

&255(&7(0(170,6¬/$7(55(

Remove house fuse or open circuit breaker before

beginning installation.

'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJZLWK

WKLVDSSOLDQFH)ROORZ1DWLRQDOHOHFWULFDOFRGHVRU

prevailing local codes and ordinances.

Electrical supply

7KLVYHQWKRRGPXVWEHVXSSOLHGZLWK9+]

FRQQHFWHGWRDQLQGLYLGXDOSURSHUO\JURXQGHGEUDQFK

FLUFXLWDQGSURWHFWHGE\DRUDPSFLUFXLW

breaker or time-delay fuse.

Ŷ:LULQJPXVWEHZLUHZLWKJURXQG

Ŷ,IWKHHOHFWULFDOVXSSO\GRHVQRWPHHWWKHDERYH

UHTXLUHPHQWVFDOODOLFHQVHGHOHFWULFLDQEHIRUH

proceeding.

Ŷ5RXWHKRXVHZLULQJLQWKHFHLOLQJDVFORVHWRWKH

LQVWDOODWLRQORFDWLRQDVSRVVLEOH$OORZDQDGGLWLRQDO

3-feet length from ceiling joists to reach the junction

ER[RQWKHKRRG

Ŷ&RQQHFWWKHZLULQJWRWKHKRXVHZLULQJLQ

accordance with local codes.

Grounding instructions

The grounding conductor must be connected to

DJURXQGPHWDOSHUPDQHQWZLULQJV\VWHPRUDQ

equipment-grounding terminal or lead on the hood.

WARNING

The improper connection of the

equipment-grounding conductor can result in a risk

of electric shock. Check with a qualified electrician or

service representative if you are in doubt whether the

appliance is properly grounded.

AVERTISSEMENT

Le mauvais branchement du fil

de mise à la terre peut causer un choc électrique. En

FDVGHGRXWHFRQVXOWHUXQpOHFWULFLHQTXDOLILpRXXQ

technicien pour déterminer si l’appareil est à la terre.

6 31-14899 Rev. 3

Advance Planning

DUCT FITTINGS

This Hood Must Use an 8” Round

Duct. It Can Transition to a

3-1/4” x 12” Duct.

8VHWKLVFKDUWWRFRPSXWHPD[LPXPSHUPLVVLEOHOHQJWKV

for duct runs to outdoors.

NOTE:'RQRWH[FHHGPD[LPXPSHUPLVVLEOHHTXLYDOHQW

lengths!

Maximum duct length: 100 foot for range hoods.

Flexible ducting

,IIOH[LEOHPHWDOGXFWLQJLVXVHGDOOWKHHTXLYDOHQWIHHW

YDOXHVLQWKHWDEOHVKRXOGEHGRXEOHG7KHIOH[LEOHPHWDO

GXFWVKRXOGEHVWUDLJKWDQGVPRRWKDQGH[WHQGHGDV

much as possible.

'R127XVHIOH[LEOHSODVWLFGXFWLQJ

NOTE:$Q\KRPHYHQWLODWLRQV\VWHPVXFKDVD

YHQWLODWLRQKRRGPD\LQWHUUXSWWKHSURSHUIORZRI

FRPEXVWLRQDLUDQGH[KDXVWUHTXLUHGE\ILUHSODFHVJDV

IXUQDFHVJDVZDWHUKHDWHUVDQGRWKHUQDWXUDOO\YHQWHG

systems. To minimize the chance of interruption of such

QDWXUDOO\YHQWHGV\VWHPVIROORZWKHKHDWLQJHTXLSPHQW

manufacturer’s guidelines and safety standards such

DVWKRVHSXEOLVKHGE\1)3$DQG$6+5$(:KHQ

DSSOLFDEOHLQVWDOODQ\PDNHXSUHSODFHPHQWDLUV\VWHP

in accordance with local building code requirements. Visit

GEAppliances.com for available makeup air solutions.

Duct Piece Dimensions

Equivalent

Length*

Quantity

Used

Total

Equivalent

Length

5RXQG

straight

1 ft. (per foot

length)

´[´

straight

1 ft. (per foot

length)

HOERZ IW

HOERZ IW

´[´

HOERZ

IW

´[´

HOERZ

26 ft.

´[´

IODW

elbow

IW

´URXQGWR

´[´

transition

2 ft.

´[´

WR´URXQG

transition

5 ft.

´URXQGWR

´[´

WUDQVLWLRQ

elbow

6 ft.

´[´

WR´URXQG

WUDQVLWLRQ

elbow

13 ft.

Round wall

cap with

damper

32 ft.

´[´

wall cap with

damper

IW

Round roof

cap

IW

$FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFWILWWLQJ

equivalent. Equivalent length of duct pieces

DUHEDVHGRQDFWXDOWHVWVFRQGXFWHGE\*(

$SSOLDQFHV(YDOXDWLRQ(QJLQHHULQJDQGUHIOHFW

requirements for good venting performance

with any ventilation hood.

Total Duct Run

31-14899 Rev. 3 

Installation Preparation

CONSTRUCT CEILING SUPPORT

Plan the location

'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG

Ŷ Use a plumb bob to check location to be sure

countertop/cooktop location below the hood will align

H[DFWO\

Ŷ7KHKRRGVKRXOGSURMHFWIRUZDUG´EH\RQGWKH

front edge of the cooking appliance. See illustration.

Ŷ2EVHUYHWKHUHFRPPHQGHGVSDFH´EHWZHHQWKH

cooking surface and bottom of hood.

Ceiling support structure

Ŷ$WWKHKRRGORFDWLRQLQVWDOO

[FURVVIUDPLQJEHWZHHQ

ceiling joists as shown.

[VDUHUHTXLUHGWRVXSSRUW

the weight of the hood.)

Ŷ$UUDQJHFURVVIUDPLQJLQWKH

FHLOLQJWRVXLWWKHH[LVWLQJ

structure.

Ŷ<RXUFHLOLQJMRLVWVZLOOEHOLNH

RQHRIWKHIROORZLQJH[DPSOHV

Ceiling

Hood

Ducting

Centerline

Side View

Approx. 1-1/2"

Beyond Cooking

Surface

Cooktop

Countertop

31-1/2"

Hood

Front

15-3/4"

,QVWDOO&URVV)UDPLQJ

6\PPHWULFDOO\$ERXW

Duct/Cooktop Centerline



-RLVW

Spacing

[&URVV

)UDPLQJ

8" Duct

$OLJQ'XFWWR

Center of Cooktop

Cooktop Outline

7RS9LHZ²&HLOLQJ-RLVWV3DUDOOHOWR)URQWRI+RRG

Front

of Hood

EXAMPLE A

8 31-14899 Rev. 3

Installation Preparation

CONSTRUCT CEILING SUPPORT (cont.)

EXAMPLE B

$OLJQ'XFWWR

Center of Cooktop

Cooktop

Outline

7RS9LHZ²&HLOLQJ-RLVWV5XQ3HUSHQGLFXODUWR)URQWRI+RRG

Front

of Hood

,QVWDOO&URVV)UDPLQJ

6\PPHWULFDOO\$ERXW

Duct/Cooktop Centerline

-RLVW

Spacing

[&URVV

)UDPLQJ



8" Duct

EXAMPLE C



[&URVV

)UDPLQJ

,QVWDOO

&URVV)UDPLQJ

6\PPHWULFDOO\$ERXW

Duct/Cooktop Centerline

8" Duct

-RLVW

Spacing

$OLJQ'XFWWR

Center of Cooktop Cooktop

Outline

7RS9LHZ²&HLOLQJ-RLVWVDW$QJOHZLWK)URQWRI+RRG

Front

of Hood

31-14899 Rev. 3 

Installation Instructions

CONSTRUCT CEILING SUPPORT (cont.)

Ŷ$UUDQJHFURVVIUDPLQJLQWKHFHLOLQJWRVXLWWKHH[LVWLQJ

VWUXFWXUH6HHH[DPSOHV

±6HFXUHHDFK[EORFNZLWKDWOHDVWIRXU

ZRRGVFUHZV´ORQJQRWVXSSOLHG8VHZRRG

screws total for the two supports.

Ŷ7KHFURVVIUDPLQJPXVWEHDFFXUDWHO\DOLJQHGWR

ensure correct positioning of the hood.

Ŷ7KHFURVVIUDPLQJPXVWEHOHYHOLQDOOGLUHFWLRQV

Check with a spirit level and adjust if necessary.

IMPORTANT: The ceiling structure must be capable

of supporting the weight of the hood (approximately

300 pounds) and any inadvertent user contact loads.

The hood support frame will be supported by the 2 x

4 min. cross-framing.

Ductwork

Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH

)RUVDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOGQRW

H[FHHGIHHWHTXLYDOHQWOHQJWKIRUDQ\GXFW

configuration.

Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWWRFRPSXWHWKHPD[LPXP

permissible length for duct runs to the outdoors.

Ŷ7KLVYHQWKRRGPXVWXVH´URXQGGXFW7KH´URXQG

GXFWFDQWUDQVLWLRQWR´[´

Ŷ,QVWDOOWKHKRXVHGXFWZRUNWRUXQKRUL]RQWDOO\EHWZHHQ

ceiling joists or straight up through the roof.

Finish the Ceiling

Ŷ)LQLVKWKHFHLOLQJVXUIDFH%HVXUHWRPDUNORFDWLRQRI

the ceiling joists and cross-framing. Check to be sure

WKHFHLOLQJLVOHYHOXVHVKLPVLIQHFHVVDU\

*Depending on available space.

 31-14899 Rev. 3

Installation Instructions

REMOVE THE PACKAGING

The vent hood is packed separately from the decorative

GXFWFRYHURUDFFHVVRU\FRYHUV=;6)66RU

=;6)66

Ŷ5HPRYHWKHIUDPHFRYHUSDUWVER[DQGSDFNDJLQJ

Ŷ5HPRYHMXQFWLRQER[FRYHU

Ŷ,QVWDOOVWUDLQUHOLHIRQWRMXQFWLRQER[FRYHU

CHECK INSTALLATION HARDWARE AND ACCESSORIES

Locate the hardware accessory pack shipped with the hood and check contents.

11-1/4”

TO CENTER LINE

OF HOLES

7-1/4” TO

CENTER LINE

OF HOLES

WIRE

HOLE

ACCESS

WIRE

HOLE

ACCESS

Mounting Screw Holes

2 Phillips-Head

Decorative Screws

4 Filters

4 Lock Washers

Template

Installation/

Service Stop

Screw

4 Machine Screws

Support Frames

with 8 Screws

and 8 Washers

4 Hex-Head

Lag Screws

Decorative Duct Covers

31-14899 Rev. 3 11

MOUNT TEMPLATE

Ŷ$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQG

tape in place.

±%HVXUHWKHWHPSODWHLVRULHQWHGFRUUHFWO\ZLWKWKH

front of the hood.

Ŷ Use a plumb bob to be sure the mounting holes will

provide parallel alignment with the countertop below.

Ŷ Center-punch all hole locations.

Ŷ'ULOOSLORWKROHVLQWKHVFUHZORFDWLRQV8VHD´

ELWDQGGULOODSSUR[LPDWHO\´GHHS

Ŷ&XWWKH´GXFWRSHQLQJDQGDSSUR[LPDWHO\´ZLUH

access hole.

INSTALL SUPPORT FRAME

Install upper support frame

Ŷ6HFXUHWKHXSSHUVXSSRUWIUDPHWRWKHFHLOLQJMRLVWV

DQGFURVVIUDPLQJZLWKWKHODJVFUHZVSURYLGHG

)RUPD[LPXPULJLGLW\DQGVWUHQJWKWKHVFUHZVPXVW

be driven into the center of the joists and/or cross-

framing.

Check to be sure the support frame is level,

vertically and horizontally.

Install lower support frame

Ŷ,QVHUWORZHUVXSSRUWIUDPHRUDFFHVVRU\VXSSRUW

IUDPH=;6)66RU=;6)66LQWRWKHXSSHU

support frame and loosely secure with 8 screws and

ZDVKHUVRQWKHIURQWDQGRQWKHEDFNVLGHV

Ŷ$GMXVWWKHORZHUVXSSRUWIUDPHXSRUGRZQWRWKH

desired height above the countertop. Tighten screws.

,03257$17$JDLQFKHFNWREHVXUHWKHVXSSRUWLV

level in both directions. There is no way to level the

hood after the hood is secured to the frame.

Installation Instructions

Wire Access Holes

30" Recommended

10"

40"

Countertop

Hood

Mounting

Flange

Lower Support

76"

12 31-14899 Rev. 3

Installation Instructions

SECURE WIRING

Ŷ5RXWHKRXVHZLULQJWKURXJKWKHFHLOLQJKROHDQG

SXOODOHQJWKWRUHDFKWKHKRRGMXQFWLRQER[

DSSUR[LPDWHO\´EHORZWKHVXSSRUW

Ŷ7DSHWKHZLUHWRWKHOHIWVLGHRIWKHIUDPHVXSSRUWWR

prevent damage during installation and service.

SIZE AND INSTALL DUCTWORK

Ŷ0HDVXUHIURPKRXVHGXFWIODQJHWRERWWRPRI

VXSSRUWIUDPH'LP$

 ±$GGDWOHDVW´IRUGXFWRYHUODSDWWKHWRS

±6XEWUDFW´IRUKRRGLQVHUWLRQLQWRWKHERWWRP

of the frame to determine required duct length.

Ŷ&XWWKH´GXFWOHQJWKUHTXLUHG

NOTE:7KHERWWRPRIWKHGXFWPXVWEHH[WHUQDO

(female) connection to the top of the hood. The

ERWWRPHQGVKRXOGEHIODUHGVOLJKWO\WRIDFLOLWDWH

installation of the hood.

Ŷ,QVWDOOGXFWXSWKURXJKVXSSRUWIUDPHVDQGDWWDFKWR

house ducting with sheet metal screws.

Ŷ6HDOWKHFRQQHFWLRQZLWKGXFWWDSH

Ceiling

Support

Frames

Tape

House

Wiring

Left Side

View

31-14899 Rev. 3 13

Installation Instructions

INSTALL DECORATIVE DUCT COVERS

Ŷ3UHWDSRUGULYHGHFRUDWLYHVFUHZLQWRWKHVFUHZKROHV

on the support frame. This will make screw installation

easier.

Ŷ6HSDUDWHWKHWZRGHFRUDWLYHGXFWFRYHUV

Ŷ6HOHFWWKHLQVLGHFRYHUWRSZKLFKKDVWZRVFUHZ

holes in the top.

Ŷ6OLGHWKHGHFRUDWLYHGXFWFRYHURYHUWKHVXSSRUWIUDPH

and push to the ceiling.

Ŷ$WWDFKWRWKHKRRGVXSSRUWDWWKHWRSZLWKVXSSOLHG

decorative screws.

Ŷ/RFDWHWKHWKLUGGHFRUDWLYHVFUHZLQWKHKDUGZDUH

package. Set aside.

Ŷ6OLGHWKHORZHUGHFRUDWLYHGXFWRYHUWKHLQVWDOOHG

upper duct and push to the top.

Ŷ,QVWDOOWKHGHFRUDWLYHVWRSVFUHZLQWKHFHQWHUKROHRI

the upper (inner) duct cover. The decorative screw will

act as a stop screw and prevent the lower decorative

duct cover from sliding down.

CAUTION

The stop screw must be installed.

)DLOXUHWRGRVRFRXOGUHVXOWLQSHUVRQDOLQMXU\RU

damage to the duct cover.

ATTENTION

/DYLVVXSpULHXUHGRLWrWUHHQSODFH

afin d’éviter les blessures ou d’endommager le capot

antipoussière.

INSTALL HOOD

NOTE: AT LEAST THREE PEOPLE ARE REQUIRED

TO COMPLETE THIS INSTALLATION!

Ŷ/LIWWKHKRRGXSWRWKHVXSSRUWIUDPH&DUHIXOO\DOLJQ

the hood mounting holes to the support frame holes

DQGDWWKHVDPHWLPHWKHKRRGGXFWFRQQHFWRULQWR

the duct.

Ŷ,QVWDOOVFUHZVWKURXJKWKHKRRGDQGKRRGVXSSRUW

Ŷ&KHFNKRRGOHYHOLQERWKGLUHFWLRQV

Ŷ&KHFNWREHVXUHWKDWWKHGXFWLVSRVLWLRQHGRYHUWKH

hood connector.

Ŷ6HDOWKHGXFWFRQQHFWLRQZLWKGXFWWDSH

NOTE: Do not drive screws through this duct connection.

Doing so will prevent proper damper operation.

Right

Side

Front

Stop Screw

Apply Duct Tape

to Seal Duct

Connection

Install

4 Lock Washers

and 4 Machine Bolts

Bottom

Duct

Cover

 31-14899 Rev. 3

Installation Instructions

CONNECT ELECTRICAL

Verify that power is turned off at the source.

WARNING

If house wiring is not 2-wire with

DJURXQGZLUHDJURXQGPXVWEHSURYLGHGE\WKH

LQVWDOOHU:KHQKRXVHZLULQJLVDOXPLQXPEHVXUH

WRXVH8/DSSURYHGDQWLR[LGDQWFRPSRXQGDQG

aluminum-to-copper connectors.

AVERTISSEMENT

Si le câblage de la maison

Q¶HVWSDVGXW\SHjGHX[ILOVDYHFXQILOGHWHUUH

O¶LQVWDOODWHXUGRLWIRXUQLUXQFLUFXLWGHWHUUH4XDQGOHV

ILOVGHODPDLVRQVRQWHQDOXPLQLXPLOSUHQGUHVRLQ

G¶XWLOLVHUGHODSkWHDQWLR[LGDWLRQDSSURXYpHSDU8/HW

des connecteurs pour l’aluminium-cuivre.

Ŷ,QVWDOOVWUDLQUHOLHIRQWRWKHNQRFNRXWRIWKHMXQFWLRQ

ER[FRYHU

Ŷ,QVHUWKRXVHZLULQJWKURXJKVWUDLQUHOLHIDQGWLJKWHQ

Ŷ&RQQHFWZKLWHOHDGVWREUDQFKFLUFXLWZKLWHOHDG

Ŷ&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG

Ŷ&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQ

or bare ground lead.

Ŷ6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFK

electrical connector.

Ŷ3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU%H

sure wires are not pinched.

SLIDE DUCT COVER DOWN

Ŷ+ROGWKHGHFRUDWLYHGXFWFRYHUDQGUHPRYHWKH

decorative stop screw from the support frame.

Dress all wire harnesses out of the path of the duct

cover seating.

Ŷ6OLGHWKHORZHUGXFWFRYHUGRZQRQWRWKHKRRG

31-14899 Rev. 3 15

Installation Instructions

INSTALL FILTERS, FINALIZE INSTALLATION

Ŷ7LSWKHILOWHULQWRWKHORZHUVORWVDWWKHUHDURIWKH

opening. Lift the filter and pull the knob forward until

the filter rests on the slots.

Ŷ0DNHVXUH\RXKDYHHQJDJHGWKH³&OHDQ)LOWHU

5HPLQGHU6ZLWFK´ZLWKWKHULJKWVLGHJUHDVHILOWHU

by checking to see if the red light is glowing in the

GLVSOD\,IWKHUHGOLJKWLVJORZLQJSOHDVHDGMXVWWKH

filter until the red indicator light turns off.

Ŷ&OHDQWKHKRRGZLWKDQDSSURYHGVWDLQOHVVVWHHO

cleaner.

Ŷ

&KHFNKRRGRSHUDWLRQ,IWKHKRRGGRHVQRWRSHUDWH

check that house wires have been connected securely

and that no wires have been damaged during installation.

Check the breaker or house fuse is turned on.

Filter Slots

NOTE::KLOHSHUIRUPLQJLQVWDOODWLRQVGHVFULEHGLQWKLVERRN

safety glasses or goggles should be worn.

)RU0RQRJUDP

ORFDOVHUYLFHLQ\RXUDUHDYLVLW

monogram.com.

NOTE:3URGXFWLPSURYHPHQWLVDFRQWLQXLQJHQGHDYRUDW

0RQRJUDP$SSOLDQFHV7KHUHIRUHPDWHULDOVDSSHDUDQFH

and specifications are subject to change without notice.

31-14899 Rev. 3

10-19 GEA

Printed in Italy

GE ZV1050SFSS Installation guide

Related papers

Other documents