VIA Technologies AMOS-3006 User manual

VIA Technologies
Brand
VIA Technologies
Model
AMOS-3006
Type
User manual
USER MANUAL
VIA AMOS-3006
Ultra-compact fanless system for
embedded transportaon applicaons
in demanding environments
1.00-01222020-144700
Copyright
Copyright © 2020 VIA Technologies Incorporated. All rights reserved.
No part of this document may be reproduced, transmied, transcribed, stored in a retrieval system, or translated into any language, in any
form or by any means, electronic, mechanical, magnec, opcal, chemical, manual or otherwise without the prior wrien permission of
VIA Technologies, Incorporated.
Trademarks
All trademarks are the property of their respecve holders.
Disclaimer
No license is granted, implied or otherwise, under any patent or patent rights of VIA Technologies. VIA Technologies makes no warranes,
implied or otherwise, in regard to this document and to the products described in this document. The informaon provided in this
document is believed to be accurate and reliable as of the publicaon date of this document. However, VIA Technologies assumes no
responsibility for the use or misuse of the informaon (including use or connecon of extra device/equipment/add-on card) in this
document and for any patent infringements that may arise from the use of this document. The informaon and product specicaons
within this document are subject to change at any me, without noce and without obligaon to nofy any person of such change.
VIA Technologies, Inc. reserves the right the make changes to the products described in this manual at any me without prior noce.
Regulatory Compliance
FCC-A Radio Frequency Interference Statement
This equipment has been tested and found to comply with the limits for a class A digital device, pursuant to part 15 of the FCC rules.
These limits are designed to provide reasonable protecon against harmful interference when the equipment is operated in a commercial
environment. This equipment generates, uses, and can radiate radio frequency energy and, if not installed and used in accordance with the
instrucon manual, may cause harmful interference to radio communicaons. Operaon of this equipment in a residenal area is likely to
cause harmful interference, in which case the user will be required to correct the interference at his personal expense.
Noce 1
The changes or modicaons not expressly approved by the party responsible for compliance could void the user's authority to operate
the equipment.
Noce 2
Shielded interface cables and A.C. power cord, if any, must be used in order to comply with the emission limits.
Noce 3
The product described in this document is designed for general use, VIA Technologies assumes no responsibility for the conicts or
damages arising from incompability of the product. Check compability issue with your local sales representaves before placing an
order.
Baery Recycling and Disposal
• Only use the appropriate baery specied for this product.
• Do not re-use, recharge, or reheat an old baery.
• Do not aempt to force open the baery.
• Do not discard used baeries with regular trash.
• Discard used baeries according to local regulaons.
Safety Precauons
• Always read the safety instrucons carefully.
• Keep this User’s Manual for future reference.
• All cauons and warnings on the equipment should be noted.
• Keep this equipment away from humidity.
• Put this equipment on a reliable at surface before seng it up.
• Check the voltage of the power source and adjust to 110/220V before connecng the equipment to
the power inlet.
• Do not place the power cord where people will step on it.
• Always unplug the power cord before inserng any add-on card or module.
• If any of the following situaons arise, get the equipment checked by authorized service personnel:
• The power cord or plug is damaged.
• Liquid has entered into the equipment.
• The equipment has been exposed to moisture.
• The equipment is faulty or you cannot get it work according to User’s Manual.
• The equipment has been dropped and damaged.
• The equipment has an obvious sign of breakage.
• Do not leave this equipment in extreme temperatures or in a storage temperature above 65°C (149°F). The
equipment may be damaged.
• Do not leave this equipment in direct sunlight.
• Never pour any liquid into the opening. Liquid can cause damage or electrical shock.
• Do not place anything over the power cord.
• Do not cover the venlaon holes. The openings on the enclosure protect the equipment from
overheang.
Box Contents
• 1 x VIA AMOS-3006 system
• 1 x 4-pole Phoenix plug connector
• 1 x Screw pack for miniPCIe and mSATA modules
• 2 x Thermal pads for mSATA module and heatsink
• 1 x Screw pack for mounng
• 1 x Rubber feet pack
Ordering Informaon
Oponal Accessories
VIA AMOS-3006 User Manual
Part Number Descripon
AMOS-3006-1Q12A1 1.2GHz VIA Eden® X4 CPU with fanless cooling and HDMI, VGA, 2 USB 3.0,
2 Lockable USB 2.0, 4 COM, 2 CAN, DIO, 2 Gigabit Ethernet, 2 miniPCIe, 9~30V
DC-in power
Wireless Accessories
Part Number Descripon
EMIO- 1542-00A1 DAUK-W8812 IEEE 802.11ac/a/b/g/n dual-band USB Wi-Fi module with
assembly kit and antenna
EMIO-2531-00A1 VAB-820-W-M IEEE 802.11b/g/n miniPCIe Wi-Fi & Bluetooth module with
assembly kit and antenna
EMIO-2550-00A1 3.75G HSPA/UMTS mobile broadband full size miniPCIe module with GPS, SIM
card slot, assembly kit and antenna
EMIO-2551-02A0 3.75G HSPA/UMTS mobile broadband full size miniPCIe module (Europe only)
EMIO-2551-03A0 3.75G HSPA/UMTS mobile broadband full size miniPCIe module with GPS
(Europe only)
EMIO-2573-00A0 4G LTE mobile broadband full size miniPCIe module with assembly kit and
antenna pack (USA only)
EMIO-2573-01A0 4G LTE mobile broadband full size miniPCIe module with assembly kit and
antenna pack (Europe only)
EMIO-2573-02A0 4G LTE mobile broadband full size miniPCIe module with assembly kit and
antenna pack (Japan only)
iv
VIA AMOS-3006 User Manual
Table of Contents
1. Product Overview .............................................................................................................. 1
1.1 Key Features ......................................................................................................................................... 1
1.1.1 High-Performance .......................................................................................................................... 1
1.1.2 Fanless and Ruggedized Chassis .................................................................................................... 1
1.1.3 OpmizedIntegraonwithMulpleI/OAccess ............................................................................ 1
1.1.4 Storage Expansion ................................................... ....................................................................... 1
1.1.5 Networking Support....................................................................................................................... 1
1.1.6 Support for a Wide Range of Power Sources ................................................................................. 1
1.1.7 WideRangeofOperangTemperatures ........................................................................................ 1
1.1.8 ShockandVibraonResistant ....................................................................................................... 2
1.1.9 MounngSoluon ......................................................................................................................... 2
1.1.10 EmbeddedOperangSystemReady .............................................................................................. 2
1.2 ProductSpecicaons .......................................................................................................................... 3
1.3 Layout Diagram .................................................................................................................................... 6
1.4 Product Dimensions ............................................................................................................................. 7
2. ExternalI/OPinDescriponsandFunconality ................................................................ 8
2.1 HDMI
®
Port ........................................................................................................................................... 8
2.2 USB 3.0 Ports ........................................................................................................................................ 8
2.3 Lockable USB 2.0 Ports ......................................................................................................................... 9
2.4 Gigabit Ethernet Ports .......................................................................................................................... 9
2.5 AudioJacks ......................................................................................................................................... 10
2.6 LEDIndicators ..................................................................................................................................... 10
2.7 VGAPort ............................................................................................................................................. 10
2.8 COMPorts .......................................................................................................................................... 11
2.9 DIOPort .............................................................................................................................................. 11
2.10 CANBusPorts ..................................................................................................................................... 12
2.11 DC-inJack ........................................................................................................................................... 12
3. OnboardI/O ..................................................................................................................... 13
3.1 MiniPCIeSlots ..................................................................................................................................... 13
3.2 SIMCardSlots .................................................................................................................................... 13
3.3 USB Wi-Fi Connectors ......................................................................................................................... 14
3.4 mSATASlot .......................................................................................................................................... 14
3.5 DDR3SODIMMSlot ............................................................................................................................ 15
4. OnboardJumper .............................................................................................................. 16
4.1 USB2.0PowerTypeJumper ............................................................................................................... 17
5. HardwareInstallaon ...................................................................................................... 18
5.1 InstallingtheDDR3SODIMMMemory ............................................................................................... 18
5.2 InstallingthemSATAFlashDriveModule ........................................................................................... 23
5.3 Installingthe4GSIMCard .................................................................................................................. 26
5.4 InstallingtheRubberFeet .................................................................................................................. 27
6. BIOSSetup ....................................................................................................................... 28
6.1 EnteringtheBIOSSetupUlity ........................................................................................................... 28
6.2 Control Keys ........................................................................................................................................ 28
6.3 GengHelp ....................................................................................................................................... 28
6.4 MainMenu ......................................................................................................................................... 29
6.4.1 BIOSInformaon ......................................................................................................................... 29
6.4.2 MemoryInformaon ................................................................................................................... 29
6.4.3 System Language ......................................................................................................................... 29
6.4.4 System Date ................................................................................................................................. 29
6.4.5 System Time ................................................................................................................................. 29
6.5 AdvancedSengs .............................................................................................................................. 30
v
VIA AMOS-3006 User Manual
vi
6.5.1 ACPISengs ................................................................................................................................ 31
6.5.1.1 EnableHibernaon ............................................................................................................ 31
6.5.1.2 ACPISleepState ................................................................................................................ 31
6.5.2 S5RTCWakeSengs ................................................................................................................... 32
6.5.2.1 Wake system with Fixed Time ........................................................................................... 32
6.5.2.2 Wake system with Dynamic Time ...................................................................................... 32
6.5.3 CPUConguraon ................................................... ..................................................................... 33
6.5.4 SATAConguraon ................................................... .................................................................... 34
6.5.4.1 SATAMode ........................................................................................................................ 34
6.5.5 USBConguraon ........................................................................................................................ 35
6.5.5.1 Legacy USB Support .......................................................................................................... 35
6.5.5.2 USB 3.0 Support ................................................................................................................ 35
6.5.5.3 XHCIHand-o .................................................................................................................... 35
6.5.5.4 EHCIHand-o .................................................................................................................... 36
6.5.5.5 USBMassStorageDriverSupport ..................................................................................... 36
6.5.6 F81865SuperIOConguraon ................................................... ................................................. 37
6.5.6.1 SerialPort1Conguraon ................................................................................................ 37
6.5.6.1.1 Serial Port .................................................................................................................... 37
6.5.6.1.2 UartTransmissionMode ............................................................................................. 37
6.5.6.2 SerialPort2Conguraon ................................................................................................ 37
6.5.6.2.1 Serial Port .................................................................................................................... 37
6.5.6.2.2 UartTransmissionMode ............................................................................................. 37
6.5.6.3 SerialPort3Conguraon ................................................................................................ 37
6.5.6.3.1 Serial Port .................................................................................................................... 37
6.5.6.4 SerialPort4Conguraon ................................................................................................ 38
6.5.6.4.1 Serial Port .................................................................................................................... 38
6.5.6.5 SerialPort5Conguraon ................................................................................................ 38
6.5.6.5.1 Serial Port .................................................................................................................... 38
6.5.7 F81865H/WMonitor ................................................................................................................... 39
6.5.8 ClockGeneratorConguraon .................................................................................................... 40
6.5.8.1 CPU Spread Spectrum ....................................................................................................... 40
6.5.8.2 PCIeSpreadSpectrum ....................................................................................................... 40
6.6 ChipsetSengs .................................................................................................................................. 41
6.6.1 DRAMConguraon .................................................................................................................... 42
6.6.1.1 DRAMClock ....................................................................................................................... 42
6.6.1.2 VGAShareMemory(FrameBuer) ................................................................................... 42
6.6.2 VideoConguraon ..................................................................................................................... 43
6.6.2.1 Select Display Device Control ............................................................................................ 43
6.6.2.2 Select Display Device 1 and 2 ............................................................................................ 43
6.6.3 PMU_ACPIConguraon ............................................................................................................. 44
6.6.3.1 USB S4 WakeUp ................................................................................................................. 44
6.6.4 HDACConguraon ..................................................................................................................... 45
6.6.4.1 OnChipHDACDevice ......................................................................................................... 45
6.6.5 OtherConguraon ..................................................................................................................... 46
6.6.5.1 WATCHDOGTimerEnable ................................................................................................. 46
6.6.5.2 WATCHDOGTimerRUN/STOP ........................................................................................... 46
6.6.5.3 WATCHDOGTimerACTION ............................................................................................... 46
6.6.5.4 WATCHDOGTimerCOUNT ................................................................................................ 46
6.7 BootSengs ...................................................................................................................................... 47
6.7.1 BootConguraon ................................................... .................................................................... 47
6.7.2 Setup Prompt Timeout ................................................................................................................ 47
6.7.3 BootupNumLock State ................................................................................................................. 47
6.7.4 Display Logo ................................................................................................................................. 47
6.7.5 BootOponPriories .................................................................................................................. 47
6.7.6 LaunchPXEOpROMpolicy ........................................................................................................... 47
6.8 SecuritySengs ................................................................................................................................. 48
6.8.1 AdministratorPassword ............................................................................................................... 48
6.8.2 User Password ............................................................................................................................. 48
VIA AMOS-3006 User Manual
vii
6.9 Save & Exit .......................................................................................................................................... 49
6.9.1 Save Changes and Exit ................................................................................................................. 49
6.9.2 Discard Changes and Exit ............................................................................................................. 49
6.9.3 Save Changes and Reset .............................................................................................................. 49
6.9.4 Discard Changes and Reset .......................................................................................................... 49
6.9.5 Save Changes ............................................................................................................................... 49
6.9.6 Discard Changes ................................................... ........................................................................ 49
6.9.7 Restore Default ............................................................................................................................ 50
6.9.8 Save as User Defaults ................................................................................................................... 50
6.9.9 Restore User Defaults .................................................................................................................. 50
6.9.10 LaunchEFIShellfromlesystemdevice ...................................................................................... 50
7. SowareandTechnicalSupport ...................................................................................... 51
7.1 MicrosoWindowsandLinux Support .............................................................................................. 51
7.2 VIASmartETK ..................................................................................................................................... 51
7.3 TechnicalSupportandAssistance....................................................................................................... 51
AppendixA.InstallingWirelessAccessories ............................................................................ 52
A.1. InstallingtheVIAEMIO-1542USBWi-FiModule ............................................................................... 52
A.2. InstallingtheVIAEMIO-2531MiniPCIeWi-Fi&BTModule ............................................................... 55
A.3. InstallingtheVIAEMIO-2550MiniPCIeMobileBroadbandModule .................................................. 58
A.4. InstallingtheVIAEMIO-2551MiniPCIeMobileBroadbandModule .................................................. 62
A.5. InstallingtheVIAEMIO-2573MiniPCIeMobileBroadbandModule .................................................. 65
VIA AMOS-3006 User Manual
List of Figures
Figure1: FrontpanelI/Olayout .......................................................................................................................... 6
Figure2: BackpanelI/Olayout ........................................................................................................................... 6
Figure3: DimensionsoftheVIAAMOS-3006(frontview) .................................................................................. 7
Figure4: DimensionsoftheVIAAMOS-3006(sideview) ................................................................................... 7
Figure5: HDMIportdiagram ............................................................................................................................. 8
Figure 6: USB 3.0 port diagram .......................................................................................................................... 8
Figure 7: Lockable USB 2.0 port diagram ............................................................................................................ 9
Figure 8: Gigabit Ethernet port diagram ............................................................................................................. 9
Figure9: Audiojacksdiagram ........................................................................................................................... 10
Figure 10: LED indicators diagram ....................................................................................................................... 10
Figure11: VGAportdiagram ............................................................................................................................... 10
Figure12: COMportdiagram ............................................................................................................................. 11
Figure13: DIOportdiagram ............................................................................................................................... 11
Figure15: DC-injackdiagram ............................................................................................................................. 12
Figure14: CANbusportdiagram ........................................................................................................................ 12
Figure16: MiniPCIeslotsdiagram ...................................................................................................................... 13
Figure17: SIMcardslotsdiagram ....................................................................................................................... 13
Figure 18: USB Wi-Fi connectors diagram ........................................................................................................... 14
Figure19: mSATAslotdiagram ............................................................................................................................ 14
Figure20: DDR3SODIMMslotdiagram .............................................................................................................. 15
Figure21: Jumpersengsexample ................................................................................................................... 16
Figure22: USB2.0powertypejumperdiagram ................................................................................................. 17
Figure23: Removingtheboomplatecover ...................................................................................................... 18
Figure 24: Unscrewing the front and back panel plates ...................................................................................... 19
Figure25: RemovingallthehexstandoscrewsoftheVGA,DIO,CANbusandCOMports ............................ 19
Figure 26: Removing the front and back panel plates......................................................................................... 20
Figure27: UnscrewingtheVIAEMIO-3006daughterboard ................................................................................ 20
Figure28: Removingthean-vibraonbracketandtwohexstandoscrews ................................................... 21
Figure29: RemovingtheVIAEMIO-3006daughterboard ................................................................................... 21
Figure30: InstallingtheDDR3SODIMMmemorymodule ................................................................................. 22
Figure31: InstallingthemSATAthermalpad ...................................................................................................... 23
Figure32: PeelingotheprotecveplasccoverofmSATAthermalpad......................................................... 23
Figure33: InserngthemSATAmodule .............................................................................................................. 24
Figure34: SecuringthemSATAmodule ............................................................................................................. 24
Figure35: InstallingthethermalpadonmSATAheatsink ................................................................................... 25
Figure36: Installingthe4GSIMcard .................................................................................................................. 26
Figure37: Installingtherubberfeet ................................................................................................................... 27
Figure38: IllustraonoftheMainMenuscreen................................................................................................. 29
Figure39: IllustraonoftheAdvancedSengsscreen ...................................................................................... 30
Figure40: IllustraonoftheACPISengsscreen .............................................................................................. 31
Figure41: IllustraonoftheS5RTCWakeSengsscreen ................................................................................. 32
Figure42: IllustraonoftheCPUConguraonscreen ...................................................................................... 33
Figure43: IllustraonoftheSATAConguraonscreen ..................................................................................... 34
Figure44: IllustraonoftheUSBConguraonscreen ...................................................................................... 35
Figure45: IllustraonoftheF81865Conguraonscreen ................................................................................. 37
Figure46: IllustraonoftheF81865H/WMonitorscreen ................................................................................. 39
Figure47: IllustraonoftheClockGeneratorConguraonscreen ................................................................... 40
Figure48: IllustraonoftheChipsetSengsscreen .......................................................................................... 41
Figure49: IllustraonoftheDRAMConguraonscreen .................................................................................. 42
Figure50: IllustraonoftheVideoConguraonscreen ................................................................................... 43
Figure51: IllustraonofthePMU_ACPIConguraonscreen ........................................................................... 44
Figure52: IllustraonoftheHDACConguraonscreen ................................................................................... 45
Figure53: IllustraonoftheOtherConguraonscreen ................................................................................... 46
Figure54: IllustraonoftheBootSengsscreen .............................................................................................. 47
Figure55: IllustraonoftheSecuritySengsscreen ......................................................................................... 48
viii
VIA AMOS-3006 User Manual
ix
Figure56: IllustraonoftheSave&ExitSengsscreen .................................................................................... 49
Figure57: InstallingtheVIAEMIO-1542module ................................................................................................ 52
Figure 58: Removing the two Wi-Fi antenna holes covers .................................................................................. 52
Figure59: InstallingtheWi-Fiantennacablesandantennas .............................................................................. 53
Figure60: ConnecngtheWi-FiantennacablestoVIAEMIO-1542module...................................................... 54
Figure61: InserngtheVIAEMIO-2531module ................................................................................................ 55
Figure62: SecuringtheVIAEMIO-2531module ................................................................................................. 55
Figure 63: Removing the Wi-Fi & BT antenna hole cover .................................................................................... 56
Figure64: InstallingtheWi-Fi&BTantennacableandantenna ........................................................................ 56
Figure65: ConnecngtheWi-Fi&BTantennacabletoVIAEMIO-2531module ............................................... 57
Figure 66: Removing the 4G and GPS antenna holes covers ............................................................................... 58
Figure67: Installingthe4GandGPSantennacablesandantennas ................................................................... 58
Figure 68: Reinstalling the front panel plate ....................................................................................................... 59
Figure69: Installingthe4GSIMcardontheVIAEMIO-2550module ................................................................ 59
Figure70: ConnecngtheGPSantennacabletoVIAEMIO-2550module ......................................................... 60
Figure71: InserngtheVIAEMIO-2550module ................................................................................................ 60
Figure72: SecuringtheVIAEMIO-2550module ................................................................................................. 61
Figure73: Connecngthe4GantennacabletoVIAEMIO-2550module ........................................................... 61
Figure74: InserngtheVIAEMIO-2551module ................................................................................................ 62
Figure75: SecuringtheVIAEMIO-2551module ................................................................................................. 62
Figure 76: Removing the 4G and GPS antenna holes covers ............................................................................... 63
Figure77: Installingthe4GandGPSantennacablesandantennas ................................................................... 63
Figure78: Connecngthe4GandGPSantennacablestoVIAEMIO-2551module ........................................... 64
Figure79: InserngtheVIAEMIO-2573module ................................................................................................ 65
Figure80: SecuringtheVIAEMIO-2573module ................................................................................................. 65
Figure 81: Removing the 4G antenna hole cover ................................................................................................ 66
Figure82: Installingthe4Gantennacableandantenna ..................................................................................... 66
Figure83: Connecngthe4GantennacabletoVIAEMIO-2573module ........................................................... 67
VIA AMOS-3006 User Manual
List of Tables
Table1: HDMIportpinouts .............................................................................................................................. 8
Table 2: USB 3.0 ports pinouts .......................................................................................................................... 8
Table 3: Lockable USB 2.0 ports pinouts ............................................................................................................ 9
Table 4: Gigabit Ethernet ports pinouts ............................................................................................................. 9
Table5: GigabitEthernetportLEDcolordenion ........................................................................................... 9
Table6: VGAportpinouts ................................................................................................................................ 10
Table7: COMportspinouts ............................................................................................................................. 11
Table8: DIOportpinouts ................................................................................................................................ 11
Table9: CANbusportspinouts ....................................................................................................................... 12
Table10: DC-injackpinouts .............................................................................................................................. 12
Table11: USB2.0powertypejumpersengs .................................................................................................. 17
x
VIA AMOS-3006 User Manual
1
1. Product Overview
SpeedupyourcommercialandindustrialIoTandedgeintelligenceinstallaonswiththeVIAAMOS-3006.
Thisruggedized,fanlesssystemisdesignedtooergreatperformanceandarichI/Ogeaturesetinthemost
demandingembeddedin-vehicleapplicaonsthatinvolveharshestenvironments.
Inaddiontosupporngawideoperangtemperaturerangefrom-20°Cto60°Candawidevoltageinput
from9~30V,theVIAAMOS-3006alsooersricharrayofnetworking,connecvity,andI/Ofeatures,including
dualGigabitEthernet,fourCOMports,twoCANbusports,andWi-Fianddual4GSIMcardsupport.
FullycompablewithawiderangeofMicroso®Windows®operangsystems,includingWindows10IoT,as
wellasthepopularLinuxdistribuons.
TheVIAAMOS-3006ispoweredbyhighperformance1.2GHzVIAEden®X4processor,anditshousingismade
of a heavy-duty steel body chassis and a robust aluminum alloy top cover that provides high stability which can
withstandshockandvibraon.
1.1 Key Features
1.1.1 High-Performance
TheVIAAMOS-3006systemispoweredbyaVIAEdenX4processorthatprovidesafullrangeofrichfeatures
includingsuperbmul-taskingperformanceandconsistentperformanceinahostofconnecteddevice
applicaons.
1.1.2 Fanless and Ruggedized Chassis
TheVIAAMOS-3006deliversfanlessoperaoninasealedaluminumalloychassisthatalsoactasathermal
soluon.Theruggedizedchassisdesignmakesitsuitableforinstallaonsinaspace-cricalenvironments,while
also ensuring maximum reliability.
1.1.3 OpmizedIntegraonwithMulpleI/OAccess
WithfrontandbackpanelI/Oaccess,theVIAAMOS-3006canbeeasilyconguredtosupportawidevarietyof
applicaonswitheasyintegraon,andquicksetup.
1.1.4 Storage Expansion
TheVIAAMOS-3006comeswithanmSATAslotthatenablestohaveexiblestorageofmSATAashdrive.
1.1.5 Networking Support
TheVIAAMOS-3006isequippedwithtwoRJ-45portsthatsupportshigh-speeddataGigabitEthernet.It
alsohasawirelessconnecvityoponthatgivesthesystemthefreedomofWi-Fi,Bluetooth,4G,andGPS
connecvitythroughonboardUSBWi-FiconnectorsandminiPCIeslots.
1.1.6 Support for a Wide Range of Power Sources
TheVIAAMOS-3006supportsawiderangeofinputpowerfrom9~30VDC.Theexibilityofpowerinput
enablestheVIAAMOS-3006tobedeployableinabroadvarietyofautomaonenvironments.
1.1.7 WideRangeofOperangTemperatures
TheVIAAMOS-3006carriesaqualiedthermalperformancedesignwhichallowsawiderangeofoperang
temperature-from-20°Cto60°C,suitableforcricalapplicaons.
VIA AMOS-3006 User Manual
2
1.1.8 ShockandVibraonResistant
TheVIAAMOS-3006isshockresistantformaximumreliability.
1.1.9 MounngSoluon
TheVIAAMOS-3006supportsmulplemethodsformounngthechassissecurely.Incanbemountedtoany
atsurface,oreventoVESAmountablesurfaceswiththeVESAmounngkit.
1.1.10 EmbeddedOperangSystemReady
TheVIAAMOS-3006isfullycompablewithMicroso®Windows10,Windows8.1,Windows8,Windows7,
Windows10IoT,WindowsEmbeddedStandard7,andLinux.
VIA AMOS-3006 User Manual
3
1.2 ProductSpecicaons
Processor
• 1.2GHzVIAEden®X4
Chipset
• VIAVX11MediaSystemProcessor
BIOS
• AMIBIOS,32MbitFlashmemory
System Memory
• 1DDR31333SDRAMslot
Storage
• 1xmSATAslot
Graphics
• IntegratedC-640DX113D/2DgraphicswithMPEG-2,WMV9,VC-1andH.264videodecoding
accelerator
Audio
• VIAVT2021HighDenionAudoCodec
Display I/O
• 1xHDMIport
• 1xVGAportsupporngVGAresoluonsupto2048x1536pixel
• DualindependentVGA+HDMIdisplayatdierentresoluons,pixeldepths,andrefreshrates
USB
• 2 x USB 3.0 ports
• 2xUSB2.0ports(lockableUSBportsforsecureconnecons)
LAN
• 2xRealtekRTL8111GPCIeGigabitEhternetcontrollers
COM
• Fintek F81865
CAN
• 2xMCP2518
Expansion I/O
• 2xMiniPCIeslots(1withPCIe+USB2.0signal,1withUSB2.0signalonly)
• 2xSIMcardslots
VIA AMOS-3006 User Manual
4
Front Panel I/O
• 2 x Lockable USB 2.0 ports
• 2xCOMportsforRS-232/422/485
• 2xCOMportsforRS-232
• 1xRedLEDforHDDacvity
• 1 x Green LED for power status
• 5xAntennaholesfor4G,GPS,andWi-Fi
Back Panel I/O
• 1xHDMIport
• 1xVGAport
• 2 x USB 3.0 ports
• 2 x Gigabit Ethernet ports
• 1xDIOportfor8-bitGPIO
• 2xCANbusports(9-pinD-subconnectors)
• 2xAudiojacks:Line-outandMic-in
• 5xAntennaholesfor4G,GPS,andWi-Fi
• 1x4-polePhoenixDCjack
Power Supply
• 9~30VDC-in(typical:19W)
Operang System
• Windows10/8.1/8/7,Windows10IoT,WindowsEmbeddedStandard7,Linux
VIA Smart ETK
• BIOSashtool,Wake-onLAN,Keyboardpower-on,Timerpower-on,PowerManagement,
Watchdogmer,GPIO
Operang Temperature
• -20°C~60°CwithqualiedindustrialgrademSATAandDRAM
Operang Humidity
• 0%~95%(relavehumidity;non-condensing)
Storage Temperature
• -20°C~65°C
Vibraon Loading During Operaon
• WithmSATAFlashDrive:3Grms,IEC60068-2-64,random,5~500Hz,1hr/axis
Shock During Operaon
• WithmSATAFlashDrive:50G,IEC60068-2-27,halfsine,11msduraon
Mechanical Construcon
• Aluminumtopchassishousing
• Metalchassishousing
• Dual removable front & rear metal face plates
Mounng
• Wall/DINRail/VESAmountable
VIA AMOS-3006 User Manual
5
Dimensions
• 250mm(W)x54.1mm(H)x109.8mm(D)(9.8”x2.1”x4.3”)
Weight
• 1.3kg(2.87lbs)
Compliance
• CE,FCC,E-Mark
Note:
Astheoperangtemperatureprovidedinthespecicaonsisaresultoftesngperformedinatesngchamber,a
numberofvariablescaninuencethisresult.Pleasenotethattheworkingtemperaturemayvarydependingonthe
actualsituaonandenvironment.Itishighlyrecommendedtoexecuteasolidtesngprogramandtakeallvariables
intoconsideraonwhenbuildingthesystem.Pleaseensurethatthesystemisstableattherequiredoperang
temperatureintermsofapplicaon.
VIA AMOS-3006 User Manual
6
1.3 Layout Diagram
Figure 1: FrontpanelI/Olayout
Figure 2: BackpanelI/Olayout
VIA AMOS-3006 User Manual
7
1.4 Product Dimensions
Figure 3: DimensionsoftheVIAAMOS-3006(frontview)
Figure 4: DimensionsoftheVIAAMOS-3006(sideview)
VIA AMOS-3006 User Manual
8
2. External I/O Pin Descripons and Funconality
TheVIAAMOS-3006hasawideseleconofinterfaces,andincludesaseleconoffrequently-usedportsas
partoftheexternalI/Ocoastline.
2.1 HDMI
®
Port
TheVIAAMOS-3006isequippedwithoneHDMIportonthebackpanel.AHDMIportTypeAreceptacle
connectorprovidesconnecontoHighDenionvideoanddigitalaudiousingasinglecable.Thepinoutsof
theHDMIportareshownbelow.
Table 1: HDMIportpinouts
2.2 USB 3.0 Ports
TheVIAAMOS-3006isequippedwithtwoUSB3.0portsonthebackpanel.EachUSB3.0porthasamaximum
datatransferrateofupto5GbpsandisbackwardscompablewiththeUSB2.0specicaon.TheUSBports
providescompletePlugandPlayandhotswapcapabiliesforexternaldevices.ThepinoutsoftheUSB3.0ports
are shown below.
Table 2: USB 3.0 ports pinouts
Figure 5: HDMIportdiagram
Figure 6: USB 3.0 port diagram
Pin Signal Pin Signal
1 TX2+ 2 GND
3 TX2- 4 TX1+
5 GND 6 TX1-
7 TX0+ 8 GND
9 TX0- 10 TXC+
11 GND 12 TXC-
13 NC 14 NC
15 DDCSCL 16 DDCSDA
17 GND 18 +5V
19 Hot Plug Detect
USB 3.0 Port 1
Pin Signal
1 +5V
2 Data1-
3 Data1+
4 GND
5 RX1-
6 RX1+
7 GND
8 TX1-
9 TX1+
USB 3.0 Port 2
Pin Signal
1 +5V
2 Data2-
3 Data2+
4 GND
5 RX2-
6 RX2+
7 GND
8 TX2-
9 TX2+
VIA AMOS-3006 User Manual
9
2.3 Lockable USB 2.0 Ports
TheVIAAMOS-3006isequippedwithtwolockableUSB2.0portsonthefrontpanelwhichgivescompletePlug
andPlayandhotswapcapabilityforexternaldevices.TheUSB2.0interfacecomplieswithUSBUHCI,Rev.2.0.
The pinouts of the USB 2.0 ports are shown below.
Table 3: Lockable USB 2.0 ports pinouts
Note:
TounlocktheUSBdevicefromthelockableUSB2.0port,pushthetabonthelockableportthenpulltheUSBdevice.
Ifnecessary,useapofthescrewdrivertooloranythinrodtopushthetab.
2.4 Gigabit Ethernet Ports
TheVIAAMOS-3006comeswithtwoGigabitEthernetportsonthebackpanelwhichusesan8Posionand
8Contact(8P8C)receptacleconnectorcommonlyknownasRJ-45.EachportisfullycompliantwiththeIEEE
802.3(10BASE-T),802.3u(100BASE-TX),and802.3ab(1000BASE-T)standards.ThepinoutsoftheGigabit
Ethernet port are shown below.
Table 4: Gigabit Ethernet ports pinouts
EachGigabitEthernetport(RJ-45)isequippedwithtwoLEDindicatorsonthefrontsidetoshowitsAcve/Link
status and Speed status.
Table 5: GigabitEthernetportLEDcolordenion
USB1 Port
Pin Signal
1 VUSB0
2 USBDT3-
3 USBDT3+
4 GND
Figure 7: Lockable USB 2.0 port diagram
Ethernet Port 1
Pin Signal
1 LAN1_TD0+
2 LAN1_TD0-
3 LAN1_TD1+
4 LAN1_TD1-
5 LAN1_TD2+
6 LAN1_TD2-
7 LAN1_TD3+
8 LAN1_TD3-
Acve LED
(Le LED on RJ-45 port)
Link LED
(Right LED on RJ-45 port)
Linko LEDiso LEDiso
Speed_10Mbit Orangeash LEDiso
Speed_100Mbit Orangeash LED is on in Red color
Speed_1000Mbit Orangeash LED is on in Green color
Figure 8: Gigabit Ethernet port diagram
USB2 Port
Pin Signal
1 VUSB0
2 USBDT2-
3 USBDT2+
4 GND
Ethernet Port 2
Pin Signal
1 LAN2_TD0+
2 LAN2_TD0-
3 LAN2_TD1+
4 LAN2_TD1-
5 LAN2_TD2+
6 LAN2_TD2-
7 LAN2_TD3+
8 LAN2_TD3-
VIA AMOS-3006 User Manual
10
2.5 AudioJacks
TheVIAAMOS-3006oersHighDenionaudiothroughtwo3.5mmTRSjacksonthebackpanel:Line-outand
Mic-in.TheLine-outjackisusedforconnecngtoexternalspeakersorheadphones.TheMic-injackisusedfor
connecngtoamicrophone..Thediagramoftheaudiojacksisshownbelow.
2.6 LEDIndicators
TherearetwoLEDsonthefrontpaneloftheVIAAMOS-3006thatindicatesthestatusofthesystem.
●PowerLED(PWR)isgreenandindicatesthestatusofthesystem'spower.
●HDDLED(DISK)isredandindicatesthestorageacvity.
2.7 VGAPort
TheVIAAMOS-3006providesahighresoluonVGAinterfacethroughDE-15femaleconnectorontheback
panel.Itsupportsresoluonsupto2048x1536pixels.ThepinoutsoftheVGAportareshownbelow.
Table 6: VGAportpinouts
Figure 9: Audiojacksdiagram
Figure 10: LED indicators diagram
Figure 11: VGAportdiagram
Pin Signal Pin Signal
1 Red 9 +5V
2 Green 10 GND
3 Blue 11 NC
4 NC 12 DDC_SPD
5 GND 13 HSync
6 GND 14 VSync
7 GND 15 DDC_SCL
8 GND
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40
  • Page 41 41
  • Page 42 42
  • Page 43 43
  • Page 44 44
  • Page 45 45
  • Page 46 46
  • Page 47 47
  • Page 48 48
  • Page 49 49
  • Page 50 50
  • Page 51 51
  • Page 52 52
  • Page 53 53
  • Page 54 54
  • Page 55 55
  • Page 56 56
  • Page 57 57
  • Page 58 58
  • Page 59 59
  • Page 60 60
  • Page 61 61
  • Page 62 62
  • Page 63 63
  • Page 64 64
  • Page 65 65
  • Page 66 66
  • Page 67 67
  • Page 68 68
  • Page 69 69
  • Page 70 70
  • Page 71 71
  • Page 72 72
  • Page 73 73
  • Page 74 74
  • Page 75 75
  • Page 76 76
  • Page 77 77
  • Page 78 78

VIA Technologies AMOS-3006 User manual

VIA Technologies
Brand
VIA Technologies
Model
AMOS-3006
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents