WMF 9000F VB Owner's manual

Brand: WMF

Model: 9000F VB

Category: Coffee makers

Type: Owner's manual

Series 8900 33 4243 0900 07.2019

User Manual

01.01.001

Coffee machine North America - English

2User Manual WMF 9000 FGV

Safety instructions

Warning

Risk of ﬁre or electric shock.

Do not open.

WARNING, to reduce the risk of ﬁre or electric shock,

do not remove cover (or back),

no user-serviceable parts inside,

repair should be done by authorized service personnel only.

(33 1453 5000)

The lightning ﬂash with arrowhead symbol, within an

equilateral triangle, is intended to alert the user to the

presence of uninsulated “dangerous voltage” within the

product’s enclosure that may be of sufﬁcient magnitude

to constitute arisk of ﬁre or electric shock to persons.

The exclamation point within an equilateral triangle is

intended to alert the user to the presence of important

operating and maintenance (servicing) instructions in this

User Manual.

Do not use the machine if it is not working properly or if it

is damaged.

Never alter built-in safety devices.

Ensure that there is always areceptacle under the outlet

when dispensing hot beverages to avoid scalding.

User Manual WMF 9000 FGV

Do not touch hot machine components.

Never reach into the ground coffee hopper.

Before cleaning the operating panel, switch off the coffee

machine or use the CleanLock function in order to prevent

abeverage from being dispensing accidentally.

Never reach under the spouts while system cleaning.

Do not reach into the ground coffee hoppers or the brewer

funnel or the ground coffee dischargeopening when the

Coffee Machine is switched on to avoid bruising or crushing

when handling moving parts.

4User Manual WMF 9000 FGV

Congratulations on the purchase of your

WMFcoffee machine.

The WMF9000 FGV coffee machine is afully

automatic machine for preparing ﬁlter coffee and hot

water in large volumes.

Follow the User Manual

> Read the User Manual carefully prior to use.

> Please refer to the User Manual, paying

special attention to the safety instructions

and Safety chapter.

> Follow the warning instructions on the coffee

machine.

> Ensure that the staff and all users have access

to the User Manual.

Hazard to life due

to electrical shock

• The voltage inside the coffee machine is

ahazard to life.

> Never open the housing.

> Never loosen the screws, and do not remove

any housing parts.

Conditions for use and installation

> In the event of failure to comply with

maintenance information and the speciﬁ-

cations in the Technical Data chapter, no

liability is accepted for any resultant damage.

> Follow the User Manual.

> Maintenance and repair work may be

performed only by the WMFService-Center,

using original spare parts.

CAUTION

Follow the User Manual signs

andsymbols

w page 22

Follow the Safety chapter

w starting on page 5

WARNING

Follow the Safety chapter

w starting on page 5

IMPORTANT

Technical data

w starting on page 81

Maintenance

w starting on page 71

Introduction and general information

User Manual WMF 9000 FGV

Safety

1 Safety

Misuse

• Failure to follow the safety

instructions can result in death or

serious injury.

> Follow all the safety instructions.

1.1 General safety instructions

Hazards to the operator

At WMF, safety is one of the most essential

product features. The effectiveness of the

safety devices can only be ensured if the

following points are observed:

> Read the User Manual carefully

prior to use.

> Do not touch hot machine

components.

> Do not use the coffee machine if

it is not working properly or if it is

damaged.

> Use the coffee machine only when

it is completely assembled.

WARNING

CAUTION

6User Manual WMF 9000 FGV

Safety

> Built-in safety devices must never

be altered.

> This device can be used by children

of age 8years or older while under

continuous supervision, as well as

by persons with reduced physical,

sensory, or mental capabilities or

lack of experience or knowledge,

once they have been instructed in

the safe use of the machine and the

risks associated with it.

> Children must not play with the

device.

> Cleaning and user maintenance

must not be performed by children.

Despite the safety devices, every coffee

machine poses potential hazards if

incorrectly used. Please observe the

following instructions when using the

coffee machine so as to prevent injury and

health hazards:

CAUTION

User Manual WMF 9000 FGV

Safety

Hazard to life due

to electrical shock

• The voltage inside the coffee

machine is ahazard to life.

> Never open the housing.

> Never loosen the screws, and do not

remove any housing parts.

> Avoid damage to the power cord.

Do not kink or crush it.

> Never use adamaged power cord.

Adamaged power cord must be

replaced by the manufacturer or

aservice representative in order to

prevent ahazard.

> Never immerse the mains plug in

water or other liquids. Never pour

water or other liquids over the

mains plug. Always keeps the mains

plug dry.

> The coffee machine must be

disconnected from the power supply

prior to maintenance and repair

work. Pull out the plug to do so.

The person performing the

maintenance or repair must always

be able to check, with aclear line

of sight, that the power supply has

been disconnected.

WARNING

8User Manual WMF 9000 FGV

Safety

Burn hazard/scalding hazard

• When dispensing beverages, hot

liquid comes out of the spouts.

The adjacent surfaces and spouts

become hot.

> When dispensing beverages, do not

reach beneath the spouts.

> Do not touch the spouts

immediately after dispensing.

> Always place an appropriate cup

under the spout before dispensing

abeverage.

CAUTION

User Manual WMF 9000 FGV

Safety

Bruising or crushing hazard/

risk of injury

• The coffee machine contains

moving parts that can cause ﬁnger

or hand injury.

• Closing the operating panel can

cause acrushing hazard.

> Never reach into the ground coffee

hopper, the brewer funnel, or the

ground coffee discharge when the

machine is switched on.

> Always switch off the coffee

machine and unplug the mains plug

before reaching into the opening of

the brewing unit.

> Carefully and gently close the

operating panel.

Health hazard

> Only use products that are suitable

for consumption and for use with

the coffee machine.

> The ground coffee hoppers, and the

manual insert may only be ﬁlled

with materials for the use intended.

CAUTION

10 User Manual WMF 9000 FGV

Safety

Health hazard

• The cleaner and cleaning granulate

are caustic.

> Follow the protective measures

on the packaging of the cleaning

agent.

> Load the cleaning granulate only

when the cleaning granulate

dosing mechanism is blocked and

amessage appears on the display.

Health hazard/

irritation and scalding hazard

• Cleaning ﬂuid runs out of the

ﬂexible line when cleaning. This

must be safely disposed of.

• Hot liquids can irritate the skin, and

the heat poses ascalding hazard.

• The drip tray may contain hot

liquids.

> Never reach under the spouts while

cleaning.

> Ensure that no one ever drinks the

cleaning solution.

CAUTION

User Manual WMF 9000 FGV

Safety

Slipping hazard

• Fluids can be discharged from the

coffee machine if used improperly

or if errors occur. These ﬂuids can

cause aslipping hazard.

> Regularly check the coffee machine

for leaks, and make sure no water is

coming out.

CAUTION

12 User Manual WMF 9000 FGV

Safety

1.2 Intended use

Misuse

• If the machine is used other than as

intended, this could lead to arisk of

injury.

> The coffee machine must only be

used as intended.

• The WMF9000 FGV is designed for dispensing coffee or hot

water.

• The ground coffee used must be suitable for processing in the

coffee machine. The products must not be processed after their

expiration date.

• This device is intended for industrial and commercial use and

should be operated by experts or trained users in stores, ofﬁces,

restaurants, hotels, or similar places.

• This machine is intended for large-scale service in hotels,

restaurants, and similar locations. The machine is not intended

for self-service. The machine may be operated only by specialist

personnel.

WARNING

User Manual WMF 9000 FGV

Safety

Installation location

• The machine must be set up so as to allow good visual access.

• The device must be placed and leveled on ahorizontal, sturdy,

water-resistant, and heatproof base.

• The device must not be cleaned using awater jet. The device

must be installed where it is protected against water spray.

• The device must not be located on asurface that is sprayed or

cleaned with awater hose, steam jets, steam cleaner, or similar

devices.

Water supply

On site:

• ½" (TW12) with main shutoff valve and dirt ﬁlter (250µm)

• At least 52.2psi (0.36MPa / 3.6bar) supply pressure at

1.6gal / min (6 l/ min) (1

• maximum inlet temperature 95°F (35°C).

Machine:

• Boiler feed ½" (TW12)

• Rinsing line ⅜" (TW8)

• The set of hoses provided with the new coffee machine and/or

the new water ﬁlter must be used. Do not use the old set of

hoses.

(1 This takes the normal pressure losses via water supply set and

water ﬁlter into account. As aresult, the ﬂow pressure of 29.0psi

(0.2MPa / 2bar) at 1.6gal / min (6l / min) required by the machine for

maximum hourly output will be ensured.

14 User Manual WMF 9000 FGV

Safety

Ambient temperature

• Ambient temperature 41°F to 95°F (+5°C to +35°C)

Usage

• The use of the device is subject to this User Manual. Any other

use or use that goes beyond the aforementioned is considered

incorrect use. The manufacturer shall not be liable for any

damage resulting from this.

• Under no circumstances may the WMF9000 FGV be used

to dispense and heat liquids other than coffee, hot water.

Hygiene

• The coffee machine must be set up by the operator such that

care and maintenance can be performed without hindrance.

User Manual WMF 9000 FGV

Safety

1.3 Conditions for use

andinstallation

Risk of ﬁre and accidents

> The conditions for use and

installation listed in the “Technical

Data” chapter must be met.

> Before inserting the device plug,

ensure that the information on

the rating plate matches the mains

voltage for the installation.

Any necessary on-site preparatory work for

electricity, water, and drainage connections

at the customer‘s premises is to be

arranged by the machine owner/operator.

The work must be carried out by authorized

installation technicians in compliance

with general, country-speciﬁc and local

regulations. The WMFService engineers

must only connect the coffee machine

to existing prepared connection points.

WMFService is neither authorized nor

responsible for carrying out any on-site

installation work prior to connection.

The device must only be connected and

commissioned by WMFService.

WARNING

Technical data

w page 81

NOTE

The device is to be installed to

comply with applicable federal,

state or local plumbing codes.

This includes sufﬁcient backﬂow

preventers.

16 User Manual WMF 9000 FGV

Table of Contents

Safety instructions 2

1 Safety 5

1.1 General safety instructions 5

1.2 Intended use 12

1.3 Conditions for use andinstallation 15

Table of Contents 16

2 Introduction 20

2.1 Parts of the coffee machine 20

“Ready to operate” display. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Glossary .........................................................................23

3 Operation 24

3.1 Operation safety instructions 24

3.2 Switch on the coffee machine 25

3.3 Beverage dispensing 25

Cancel beverage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

3.3.1 Pot brewing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

3.3.2 Quantity brewing arm ..............................................................26

3.4 Hot water dispensing 27

3.4.1 Single cups/pot dispensing .........................................................27

3.4.2 Large-scale dispensing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

3.5 Pre-selection pads (optional) 28

3.6 Special buttons (optional) 28

3.7 Ground coffee dispensers 29

3.8 Manual insert 30

3.9 Coffee grounds disposal (optional) 31

3.10 Switch off the coffee machine 32

4 Software 34

4.1 Overview 34

Ready to operate ..................................................................34

Function bar “Ready to operate” display. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

Main menu functions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

Menu control pads .................................................................35

Messages on the display ............................................................35

4.2 “Ready to operate” display 36

4.2.1 Beverage buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

4.2.2 Function bar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

Pre-selection pad coffee ............................................................36

Pre-selection pad hot water .........................................................36

4.3 Care 37

System cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

CleanLock ........................................................................37

Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

Grounds separator .................................................................37

Thermo container . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

4.4 Beverages 38

General information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

Filling volume and dispensing option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

Change recipes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40

Text and picture . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Change buttons ...................................................................42

Table of Contents

User Manual WMF 9000 FGV

Table of Contents

4.5 Operating options 43

Operating elements ................................................................43

Button layout .....................................................................44

Cancel beverage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

Logo ............................................................................45

4.6 Information 46

Last brewing cycle .................................................................46

Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Service. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Care .............................................................................46

Water ﬁlter and descaling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Journal ..........................................................................46

4.7 Accounting 47

Counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

Vending machines .................................................................47

External accounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

Free of charge settings. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48

4.8 PIN rights 48

Cleaning PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

Settings PIN ......................................................................49

Accounting PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

Re-enter PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

4.9 Timer 50

Time/date .......................................................................50

Timer state .......................................................................50

Timer overview and setting the timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50

Delete timer ......................................................................51

Detail view of current day . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51

Set timer switching times ...........................................................51

Timer-controlled system cleaning .....................................................51

Button layout state ................................................................52

Button layout overview .............................................................52

Eco mode overview .................................................................52

Eco mode state . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52

4.10 System 53

Progress indicator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

Display and illumination ............................................................53

Display brightness .................................................................54

Reduce brightness automatically .....................................................54

Touch calibration ..................................................................54

Display background ................................................................54

Beverages: Font + color .............................................................54

Water ﬁlter. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55

Eco mode ........................................................................56

Temperature ......................................................................56

Switch-off rinsing .................................................................56

Portioner .........................................................................56

Thermo container . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57

Warm-up rinsing ..................................................................58

Grounds separator .................................................................58

18 User Manual WMF 9000 FGV

Table of Contents

4.11 Language 58

4.12 Eco mode 58

Eco mode display ..................................................................59

4.13 USB 59

Load recipes ......................................................................59

Load beverage symbols .............................................................59

Save recipes ......................................................................60

Export counters ...................................................................60

HACCP export .....................................................................60

Data back-up .....................................................................60

Load data ........................................................................60

Load language ....................................................................60

Firmware update ..................................................................60

5 Care 61

5.1 Care safety instructions 61

5.2 Cleaning intervals overview 62

5.3 Daily cleaning 63

5.3.1 System cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63

5.3.2 Clean the hot water spout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64

5.4 Manual cleaning 65

5.4.1 Clean the drip tray .................................................................65

5.4.2 Clean the housing .................................................................65

5.4.3 Clean the operating panel (CleanLock) .................................................66

5.4.4 Clean the ground coffee dispensers ...................................................67

5.4.5 Clean the grounds separator .........................................................68

5.4.6 Clean the thermo container. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68

6 HACCP cleaning schedule 69

7 Maintenance and descaling 71

7.1 Maintenance 71

7.2 WMFService 71

8 Messages and instructions 72

8.1 Messages for operation 72

8.2 Error messages and malfunctions 73

9 Safety and warranty 75

9.1 Hazards to the coffee machine 75

9.2 Directives 76

9.3 Duties of the owner/operator 78

9.4 Warranty claims 79