Astria Fireplaces WRE60 Instruction Sheet

Brand: Astria Fireplaces

Model: WRE60

Type: Instruction Sheet

This manual is also suitable for

REQUIRED TOOLS AND SUPPLIES

1/8" Shims

Phillips Screwdriver

GENERAL INFORMATION

Bi-Fold glass doors are available in ebony, pewter and oiled bronze

ﬁ nishes.

READ ALL THE STEPS BEFORE STARTING THE INSTALLATION

THE FIREPLACE MUST BE OFF AND COLD BEFORE BEGINNING.

ALL WARNINGS, PRECAUTIONS AND INSTRUCTIONS IN THE

INSTALLATION AND OPERATION MANUAL PROVIDED WITH THE

APPLIANCE APPLY TO THESE INSTRUCTIONS.

If you encounter any problems, need clariﬁ cation of these instructions

or are not qualiﬁ ed to properly install this kit, contact you local

distributor or dealer.

If any of these parts are missing or damaged, contact your dealer or

IHP.us.com for referral information.

INSTALLING DOOR FRAMES

1. Remove screws from smoke shelf (see Figure 1).

2. Mount top door frame and secure with screws provided (see Figure 1).

3. Place bottom door frame on top of ash lip at front of ﬁ replace (see

Figure 2).

4. Secure bottom door frame to brick with two hex screws provided as

shown in Figure 3 using a 7/16" open end or adjustable wrench.

Figure 1 - Installing Top Door Frame

Top Door

Frame

Smoke

Shelf

Figure 2 - Installing Bottom Door Frame

Hex Screw

Bottom Door

Frame

Ash Lip

BDM SERIES GLASS BI-FOLD DOOR KITS

[FOR USE WITH MODELS: RAPTURE36/42/50, ORACLE36/42/50, GEORGIAN36/42/50, WRT6036/42/50, WRE6036/42/50, WRT6842/50]

GLASS DOOR KITS

36/42/50 FIREPLACES

P/N 127144-01

Rev. B, 03/2017

HEARTH PRODUCTS

KITS AND ACCESSORIES

127144-01B 1

IHP.us.com

KIT CONTENTS

1 ea. Glass Bi-Fold Doors

1 ea. Instruction Sheet

Cat. No. Model Description

F1011 BDMO36E 36" Mosaic Masonry Bi-Fold Door, Ebony

F1012 BDMO36G 36" Mosaic Masonry Bi-Fold Door, Pewter

F1013 BDMO36C 36" Mosaic Masonry Bi-Fold Door, Oiled Bronze

F1014 BDMO42E 42" Mosaic Masonry Bi-Fold Door, Ebony

F1015 BDMO42G 42" Mosaic Masonry Bi-Fold Door, Pewter

F1016 BDMO42C 42" Mosaic Masonry Bi-Fold Door, Oiled Bronze

F1020 BDMO50E 50" Mosaic Masonry Bi-Fold Door, Ebony

F1021 BDMO50G 50" Mosaic Masonry Bi-Fold Door, Pewter

F1022 BDMO50C 50" Mosaic Masonry Bi-Fold Door, Oiled Bronze

IHP.us.com 127144-01B2

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.

P/N 127144-01 Rev. B 03/2017

IHP reserves the right to make changes at any time, without notice, in design, materials, speciﬁ ca-

tions, prices and also to discontinue colors, styles and products. Consult your local distributor

for ﬁ replace code information.

1508 Elm Hill Pike, Suite 108 • Nashville, TN 37210

INSTALLING GLASS DOORS

Spring clips have been installed but minor adjustments may still be needed.

Install the doors using the following steps:

1. With bi-fold door completely folded, insert bottom pivot pin into hole

located at bottom corner of bottom door frame as shown in Figure 3.

2. Swing door to vertical position and make sure top pins slide into door

track. Door pin should snap onto the clip when vertical.

3. Repeat for other door.

DOOR ADJUSTMENT

Remove doors and slightly loosen upper spring clips. Replace and fully close

doors. Use 1/8" shims (any material) to level doors. Once proper setting is

achieved, carefully open doors enough to access pivot and spring clips with

a phillips head screwdriver. Tighten screws (see Figure 4).

Figure 3 - Installing Bi-Fold Doors

Spring Clip

Insert Pin into

Spring Clip

Pivot Hole

Insert Bottom

Pivot Pin into Hole

and Swing Door to

Vertical Position

Fold Door and

Slide Top Pins

Into Track

Partially

Opened

Doors

Side Front

Face Spring Clip

Figure 4 - Adjusting Door

Astria Fireplaces WRE60 Instruction Sheet

Brand: Astria Fireplaces

Model: WRE60

Type: Instruction Sheet

This manual is also suitable for

Download PDF

report

Astria Fireplaces WRE60 Instruction Sheet

This manual is also suitable for

Astria Fireplaces WRE60 Instruction Sheet

Related papers

Other documents