Aqua Free FLUSH 2.0 Operating instructions

Brand: Aqua Free

Model: FLUSH 2.0

Type: Operating instructions

Contents Page

1 Safety information 2

2 Instructionsforttingandinitialoperation 2

3 Generalinstructions 2

4 Productdescription 3

5 Technicaldata 4

6 Itemssupplied 4

7 Handling 4

8 Programmingtheushingsystem 8

9 Correctingmalfunctions 11

10 Manufacturer 12

FLUSH 2.0

Operating and

installation instructions

1 Safety instructions

2 Instructionsforttingandinitialoperation

Onlysuitablyqualiedtechniciansusingappropriatetools

shouldinstallandset-uptheFLUSH2.0ushingsystem.

3 Generalinstructions

3.1 Backowprotection

3.2 Storage

Dryalloftheindividualcomponentsbeforestorageand

disconnectthebattery.Storethecomponentsoftheushing

systeminthecaseprovided.

3.3 Disposal

Pleasedisposeofthepackagingforthisproductinan

environmentallyfriendlyway.Donotdisposeofbatteries

withdomesticrefuse.Takethemtospecialbatterycollection

points.

4 Productdescription

Aqua freehasdevelopedtheFLUSH2.0ushingsystem

toautomaticallyandindividuallyushwateroutletsthatare

rarelyusedorleftunusedforperiodsoftime.Itprevents

waterstagnationandthethreatofmicrobialcontaminationin

thepipes.

FLUSH2.0canbeeasilyinstalledonanytaps,showers

orotherwateroutletsinprivatehomes,publicbuildingsor

commercialestablishments.

Recommendations for ushing cycles and ushing

duration:

If drinking water pipes are ushed daily Aquafree recom-

mends a ushing duration of 5 minutes.

Howevertheprecisedurationdependsonthecrosssection

andlengthofthepipeandthewaterpressurealthough

referenceshouldalwaysbemadetonationalguidelinesfor

ushing.

IMPORTANT! Beforetheushingsystemisusedwitha

mixertaporsimilaritisimportanttomakesurenon-return

valvesaretted.

NOTE

IMPORTANT!Pleasereadtheseinstructionscarefully.

Themanufactureracceptsnoliabilityforanydamagethat

occursbecausetheseinstructionsarenotfollowed.

Forfuturereferencekeeptheseinstructionsinthecase

withtheushingsystem.

CAUTION

Iftheushingsystemisconnectedtoalow-pressure

systemsuchasaboilerthereisariskofpressurebuild

up,causingleakage.

Beforeinstallingtheushingsystemcheckthewater

outletandassociatedpipework.Ifgasketsorjoints

aredamagedorunsecure,theadditionalweightofthe

ushingsystemcancauseleakage.

Thebatteryoftheushingsystemlastsforoneyear.

Thedateofthenextbatterychangecanberecorded

onthedeviceitselfusingthestickerssupplied.

Intheeventofbatteryfailurethevalvefailsafeposition

isCLOSEDandthe“DELAY”,“FREQUENCY”and

“RUNTIME”LEDsonthedisplaywillashrepeatedly.

Whenthebatteryischangedtheushingprogramwill

returntoitsdefaultsettings.Therequiredprogramme

shouldbere-enteredandthenre-activatedbypressing

theSETkeyforatleastveseconds.

WARNING

Iftheushingsystemisusedwithoutnon-returnvalves

beingttedorworking,anybackpressurefromthe

hotwatersupplyriskscontaminatingthewholeofthe

drinkingwatersupplysystem.

Non-returnvalvesshouldbettedonboththehotwater

andcoldwatersupplypipestothetap.

Theushingsystemshouldnotbeusedwithout

functioningnon-returnvalvesinplace.

5 Technicaldata

Couplingoptionsprovided M24×1; M22×1; G½"

Operatingvoltage: 9VoltDC

Operatingpressure: 0.2-10bar

Watertemperature:

5°-60°C

(withoutlimitation)

60°-90°C(lifetimereduced

by40%)

Flowrate: 20l/min

IPrating: IP68

Batteriesused: 1×9voltPP3(alkaline)

Flushingdurations:

30 sec; 1 min; 2 min; 3 min;

4 min; 5 min; 10 min

Flushingintervals:

every1h;2h;4h;8h;12h;

24 h; 48 h; 72 h

Medium: drinkingwater

6 Itemssupplied

1×FLUSH2.0ushing

system

2×9-voltPP3battery

1×M24adapter

(includingsealinggasket

andU-clamp)

1×spanner

(22mmund24mm)

1×M22adapter

(includingsealinggasket

and.U-clamp)

2×hygienicow

straightener

1×G½"-adapter

(includingsealinggasket

andU-clamp)

1×replacementsealing

gasket

5×replacementO-rings

(forattachmentpiece)

1×operatinginstructions

1x short instructions 5xbatterychangesticker

7 Handling

Installation:

■

 Checkwhethernon-returnvalvesarettedinthepipes

supplyingthetap.

■

 Removetheaerator(fromtaps)orunscrewtheshower

hose(fromshowers)

■

 Toinsertthebattery,rstunscrewthetransparentcover

oftheushingsystemandremovetheblackbattery

coverbelowtheoperatingpanel.

■ Thenttheappropriatequick-tadapterwithsealing

gasket(thesetincludesthreedifferentadapters).

CAUTION

Ensurethattheadapteristtedtoaxedwateroutletsuch

asawall-mountedshowerorfree-standingtap.

Fittingattheendofaexibleshowerhoseisnotpermitted

becauseoftheuncontrolledoutowofushingwaterand

possibleresultantwaterdamage.

Whenthetransparentcoverisremovedtheunit

electronicscanbedamagedbywateringress.

Forthisreasonalwaysdetachtheushingsystem

beforeprogrammingitorchangingthebattery.

Ensurethatyoualwaysprogrammetheushing

systemandchangethebatteryinadryenvironment.

WARNING

Iftheushingsystemisusedwithoutnon-returnvalves

beingttedorworking,anybackpressurefromthe

hotwatersupplyriskscontaminatingthewholeofthe

drinkingwatersupplysystem.

Non-returnvalvesshouldbettedonboththehotwater

andcoldwatersupplypipestothetap.

Theushingsystemshouldnotbeusedwithout

functioningnon-returnvalvesinplace.

■

Connectthesnapcontactoftheushingsystemto

thebattery.Removetheprotectivelmfromthebatteryif

necessary.Oncethebatteryisinstalledthesystemperforms

asystemcheckinwhicheachoftheLEDsashesoncein

turn.

■

 Programtheushingdevice,ifnecessaryrefertosection

8.3.

■

 Replacetheblackcoveronthebatterycompartmentand

screwthetransparentcoverbackintoplace.

■

 Emptythewashbasinandcheckthatthewatercanow

awayfreely.Fixthewaterlevelswitchtotheinneredge

ofthewashbasinwiththeoatpointingverticallydown-

wards.

■

 Wetthesuctioncupwithwatersothatitholdsrmlyto

thesideofthebasin.Ensurethatthecableisnothan-

gingdownandpullingonthesuctioncup.

■

 MoistentheO-ringoftheFLUSHcouplingwithwater(for

easierandsaferinstallation);thenpushthecouplinginto

theadaptorwithaslightturningmovementandlockthe

FLUSH2.0inplacewiththeU-clamp.Checkthatthe

ushingsystemisseatedsecurely.

■

 Turnonthetapandnowatershouldow.

■

 Carryoutatestush(seesection8.3)

Regularchecks:

■

Every4weeks:

 • Checkforpotentialblockingofthewashbasin.

 • Checkthatthewatercanowawayfreely.

 • Checkthatthelevelswitchiscorrectlypositioned,

securelyxedandtheoatabletomovefreely.

 • Ifnecessarypositionthelevelswitchandsuctioncup

correctly.Replacedamagedsuctioncupifrequired.

■

Every6months:

 • Checkthefunctionoftheushingsystem:testthema-

nualmodeofdrawingwaterandcarryoutatestush,

seesection8.3.

■

Yearly:

 • Replacethebattery,renewthebatterychangesticker

NOTE

CAUTION

Theushingprogramcannotbeactivatedifthebattery

voltageistoolow.Inthiscasethe“DELAY”,

“FREQUENCY”and“RUNTIME”LEDsashandthe

batterymustbereplaced.

Ifthedrainisblockedorthelevelswitchwronglytted,

watercannotrunawaycreatingariskofoverow.

Makesurethatnoobjectscanobstructtheowofwater

andthatthewatercandrainawayfreely.

Ensurethatthesuctioncupiscorrectlyttedandsecurely

xed.

Checkthatthelevelswitchiscorrectlyoriented;theoatmustbeableto

movefreelyandmustpointdownwards.

988

Afteruse:

■

 Turnoffthetap,removetheU-clampanddisconnectthe

FLUSHunit.

■

 Todeactivatetheushingelectronicsunscrewthe

transparentcoverandremovetheblackbatterycover.

 ThendisconnectthebatteryfromtheFLUSHunit.

■

 Releasethelevelswitch.

■

 Drytheushingsystemandstorethecomponentsinthe

caseprovided.

■

 Replacethetapaeratororshowerhoseasappropriate.

8 Programmingtheushingsystem

8.1 Operatingprinciple

DELAY:Preselectionofstartingtime/delaybeforethe

rstush

Example:DELAY=2h

Therstushbeginsin2hours.

FREQUENCY:Pausebetweenushes

Example:FREQUENCY=24h

Flushesarerepeatedevery24hours.

Theushingsystemiscontrolledwiththethreekeyslabelled

“SET”,“+”and“-“atthebottomoftheoperatingpanel.

8.2 Defaultsettings

Thedefaultsettingsoftheushingsystemareasfollows:

■

 DELAY:  0minutes

■

 FREQUENCY: 24hours

■

 RUNTIME:  5minutes

Toactivatetheushingsystempressthe“SET”key

andholditdownforatleastveseconds.Successful

programmingisindicatedbytheashingofoneLED

fromtheleft-handrow.

TheLEDsareturnedoffafteroneminuteofinactivity.Ifone

ofthethreekeysispressedforthreesecondsthedisplayis

turnedonagain.

8.3 Examples

Thefunctiontobechangedcanbeselectedbypressingthe

“SET”keyrepeatedly.Therequiredtimescanthenbeset

withthe“+”and“-“keys.

Thefollowingillustratedexamplesprovideexplanationofthe

differentfunctionsavailable:

NOTE

Afterthebatteryhasbeenconnectedtheushing

programdoesnotstartuntilyouholdthe“SET”key

downforatleast5seconds!

Afterthe“+”and“-“keyshavebeenreleasedthe

mostrecentvaluesarestored.Thesenewtimeswill

beusedforthenextushingcycle.

1110

RUNTIME:Durationofushing

Thevalveisopenedbypressingthe“+”key.

Thevalveisclosedbypressingthe“-“key.

9 TroubleShooting

Thefollowingtableprovidestypicalerrormodesansesolu-

tionfortheFLUSH2.0unit.Ifyourerrorisnotlistedplease

contactyourlocalAquafreerepresentative.

Error Cause Procedure

Flushing

programme

doesnotrun

Watersupply

faulty

Checkthatthetap

andanyisolation

valvesareopen

Theushing

programhasnot

beensaved

PressSETkeyfor

5seconds

Thebatteryisat

(the“DELAY”,

“FREQUENCY”

and“RUNTIME”

LEDsare

ashing)

Changethebattery

Levelswitch

incorrectlytted

Checkthatthe

levelswitchcan

movefreelyand

theoatispointing

downwards

Levelswitch

comesaway

fromsideof

washbasin

Washbasinisnot

clean

Checkthatthe

surface of the

washbasinis

clean,dryandfree

ofgrease

Suctioncupisnot

clean

Checkthatthe

surface of the

suctioncupis

clean,dryandfree

ofgrease

Leakage

betweenwater

outletand

FLUSHunit

Faultysealing

gasket

Checkthesealing

gasketsand

replaceanythat

aredamaged

MANUAL:Modefordrawingwatermanuallyand

checkingthefunctioningoftheushingsystem

(testush)

Example:RUNTIME=5‘:Flushingcontinuesfor5minutes.

Timescanbeincreasedwiththe“+”key.

Timescanbereducedwiththe“-“key.

GEBR-ANWFLUSH-GB-03/2018-V002

10 Manufacturer

Aqua freeSolutionsLtd.

TheMediaCentre,7NorthumberlandStreet

Hudderseld,HD11RL

Great Britain

E-Mail: [email protected]

Phone: +44(0)1484483045

Headquarters:

Aqua freeGmbH

Winsbergring31

22525Hamburg

Germany

Phone: +49(0)40468999702

Fax:  +49(0)4046899999

[email protected]

www.aqua-free.com

Aqua Free FLUSH 2.0 Operating instructions

Brand: Aqua Free

Model: FLUSH 2.0

Type: Operating instructions

Download PDF

report

Aqua Free FLUSH 2.0 Operating instructions

Aqua Free FLUSH 2.0 Operating instructions

Related papers

Other documents