2. Home
  3. Domestic appliances
  4. Climate control
  5. Fireplaces
  6. Archgard
  7. 37-DVTE30LN-1

Archgard 37-DVTE30LN-1, 41-DVTE36LN-1 Installation, Operation and Maintenance Manual

  • Hello! I am an AI chatbot trained to assist you with the Archgard 37-DVTE30LN-1 Installation, Operation and Maintenance Manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
MODEL: 37-DVTE30LN-1
GAS FIRED DIRECT VENT FIREPLACE
S/N 370000 AND UP
ARCHGARD FIREPLACE PRODUCTS
7116 Beatty Drive
Mission, BC V2V 6B4 Canada 200-3900-02
March 26, 2018
English and French Installation Manuals available through your
local dealer or visit our website at: www.archgard.com
Les manuels d'installation en anglais et en français son
disponibles chez votre détaillant local ou en visitant notre site
web: www.archgard.com
INSTALLER:
LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER:
RETAIN THIS MANUAL FOR FUTURE REFERENCE.
This appliance may be installed in an aftermarket
permanently located, manufactured home (USA only) or
mobile home where not prohibited by local codes.
This appliance is only for use with the type of gas indicated
on the rating plate. This appliance is not convertible for use
with other gases, unless a certied kit is used.
INSTALLATION, OPERATION, AND
MAINTENANCE MANUAL
- Do not store or use gasoline or other ammable vapors or
liquids in the vicinity of this or any other appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance
• Do not touch any electrical switch; do not use any
phone in your building
• Leave the building immediately
• Immediately call your gas supplier from a neighbor's
phone. Follow the gas suppliers instructions
• If you can not reach your gas supplier, call the re
department
- Installation and service must be performed by a qualied
installer, service agency or the gas supplier.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result in
serious injury, death, or property damage.
Gas Fireplace Energy Eciency Rating
70.21%
Based on CSA P.4.1-15
2
TABLE OF CONTENTS
1.0 Introduction 3
2.0 Safety Information 4
3.0 Technical Information 5
 5
 5
 5
 5
4.0 Rating Plate 6
5.0 Installation Checklist 7
6.0 Appliance Overview 8
6.1 Appliance Overview 8
6.2 Unpacking 8
6.3 Barrier Screen 9
 10
 11
 12
7.0 Electrical Connections 13
8.0 Fireplace Dimensions 14
9.0 Prepare The Fireplace 15
 15
 15
10.0 Venting Instructions 17
 19
 20
 21
 23
 25
11.0 Framing 26
 26
 27
 28
12.0 Clearances to Combustibles 29
12.1 Mantel Clearances 29
12.2 Hearth Clearances 30
 31
12.4 Finishing 32
 33
13.0 Gas Connections 34
 34
 35
14.0 Conversion Kit Instructions 36
14.1 Prepare the Fireplace 36
 36
 37
 37
15.0 Firebox Liner Installation 38
 38
 40
16.0 Log Set Installation 42
 43
 46
17.0 Operation 50
 50
17.2 First Fire 50
 51
 52
18.0 Maintenance 59
 59
 60
 60
 60
 61
18.6 Replacing Batteries 62
18.7 Replacing Fuse 62
 63
 63
 64
 65
 66
 67
18.14 Replacing the Burner 68
18.15 Replacing the Fan 68
 69
18.17 Replacing the Light Bases 70
 71
19.0 Frequently Asked Questions 72
20.0 Replacement Parts List 73
Archgard Limited Warranty 74
3
General Information
1.0 Introduction

The 37-DVTE30LN-1

service.
37-DVTE30LN-1 are:
•  

•  

•  
•  

•  

•  

•  

• 



CPI vs IPI:
Continuous Pilot Ignition (CPI):

Intermittent Pilot Ignition (IPI):


• Very Cold Conditions

• Excessive Condensation on Glass

• Cold Glass or Fireplace Front
• Insect Control -

Section 18.8.
 37-DVTE30LN-1  

 • Natural Gas • 





4
General Information
2.0 Safety Information
Caution
FOR YOUR SAFETY37-DVTE30LN-1

• 
• 
• 
• 
• 

• 
• 
Safety
• 
• 
• 

• 



• 
• 
• WARNING:

• 
• 


clean
• 
• 
• 



Section 5.0

Any alteration to the product that causes carbon or soot deposits that results in any damage or requires cleaning is not the
responsibility of the manufacturer.
5
General Information
3.0 Technical Information
3.1 Appliance Certication





Section 4.0.
Commonwealth of Massachusetts

Archgard Industries Ltd
3.2 Installation Codes




We recommend that our gas hearth products be installed and serviced by professionals who are certied in the U.S. by the
National Fireplace Institute® (NFI) as NFI Gas Specialists.
3.3 Specications
Natural Gas (NG) Propane (LP)
Manifold Pressure  
Min. Supply Pressure
Max Supply Pressure




Orice Size  
Input Rating  
P.4 Fireplace Eciency
(FE) 70.21%
P.4 Steady State Eciency 77.99%
Electrical Rating 
Gas Control 
Altitude 
Primary Air Opening  100% Open
3.4 High Altitude Installation



6
General Information
4.0 Rating Plate
SAMPLE
Figure 4.0.01:
9-1/4”
12” SHEET
SHEET
SHEET
SHEET
Feb 22, 2018
37-DVTE30LN-1 RATING PLATE
Material - Class III
Black Letters on silver Mylar background
MODEL: 37-DVTE30LN-1 (SIT 885 Proame)
DO NOT REMOVE THIS LABEL
LISTED VENTED GAS FIREPLACE HEATER and GAS-FIRED APPLIANCES FOR USE AT HIGH ALTITUDES. Tested to: ANSI
Z21.88-2017 / CSA 2.33-2017, CSA 2.17-2017, and CSA P.4.1-15. This vented gas replace heater is not for use with air lters.
Certied for use in both CANADA and USA.
VENTED GAS FIREPLACE HEATER-NOT FOR USE WITH SOLID FUEL.
Manufactured as Natural Gas.
NG LPG
Input rating 16,500 - 30,000 BTU/h
(4.84 - 8.79 kWh)
16,000 - 30,000 BTU/h
(4.69 - 8.79 kWh)
Manifold Pressure 1.1 - 3.8 in. W.C.
(0.27 - 0.95 kPa)
2.9 - 11 in. W.C.
(0.72 - 2.74 kPa)
Orice size #35 DMS (2.79 mm dia.) #51 DMS (1.70 mm dia.)
Minimum supply pressure for purpose of input
adjustment.
5 - 14.0 in. W.C.
(1.2 - 3.5 kPa)
12.0 - 14.0 in. W.C.
(2.9 - 3.5 kPa)
Burner Primary Air Setting 1/16” (1.6 mm) Open 100% Open
Altitude 0 - 4500 ft (0 - 1372 m) 0 - 4500 ft (0 - 1372 m)
Electrical rating 120 VAC, 60 Hz, less than 2 A.
P.4.1 Fireplace Eciency (FE) 70.21%
Replacement fan Part # RF-305-4224 fan / blower assembly must be used
Keep burner and control compartment clean. See
Instructions accompanying the heater.
Optional fuel conversion kit : See Manual
Minimum clearances to Combustibles:
Chase sides, back & top from replace standos: 0” (0 cm).
Interior sidewall from replace opening: 7.25” (18.42 cm).
Mantle: 8” (20.32 cm) mantle at min 20.625” (52.39 cm) from top
of the replace opening.
Vent pipe: Sides & Bottom: 1” (2.54 cm), Top: 2” (5.08 mm).
Ceiling: 60” (152.4 cm) from replace opening.
See Manual for additional dimensions and clearances
This appliance must be installed in accordance with local codes, if any; if none, follow the National Fuel Gas Code, ANSI
Z223.1/NFPA 54, or Natural Gas and Propane Installation Codes, CSA B149.1. Electrical connections and grounding must
be in accordance with local codes, if any; if none, follow the current CAN/CSA C22.1 in Canada and ANSI/NFPA 70 in the
US. This appliance is certied for installation in a bedroom or a bed sitting room. This appliance is only for use with the gas
indicated on the rating plate and may be installed in an aftermarket, permanently located, manufactured (mobile) home where
not prohibited by local codes. See owner’s manual for details. This appliance is not convertible with other gases, unless a
certied kit is used.
WARNING: Improper installation, adjustment, alteration, service, or maintenance can cause injury or property damage. Refer
to the owner’s information manual provided with this appliance. For assistance or additional information consult a
qualied installer, service agency, or the gas supplier. This appliance must be properly connected to a Direct Vent
venting system in accordance with the manufacturer’s installation instructions.
WARNING: Failure to install this appliance per the manufacturer’s instructions or failure to use only parts specically
approved with this appliance may result in property damage or personal injury.
WARNING: Do not operate the appliance until all sections have been assembled and installed in accordance with the
manufacturer’s instructions.
WARNING: Operation of this appliance when not connected to a properly installed and maintained venting system can result
in carbon monoxide (CO) poisoning and possible death.
Only doors certied with the appliance shall be used.
For use only with barrier part # 37-BS. Follow installation instructions.
Made in Canada by:
Archgard Industries Ltd.
7116 Beatty Dr., Mission, B.C.
February 2018 303-6180-01
NE PAS ENLEVER CETTE ÉTIQUETTE
RADIATEUR VENTILE, CIRCULATEUR DU TYPE VENTILATEUR. Testée selon les normes : ANSI Z21.88-2017 / CSA 2.33-2017
CSA 2.17-2017 et CSA P.4.1-15. Ne pas utiliser de ltre à air avec ce foyer au gaz à évacuation.
Certié pour utilisation dans le Canada et les ÉTATS-UNIS.
FOYER AU GAZ À ÉVACUATION. NE PAS UTILISER AVEC DU COMBUSTIBLE SOLIDE.
Fabriqué comme gaz naturel.
NG LPG
Entrée assignée 16 500 - 30 000 BTU/h
(4,84 - 8,79 kWh)
16 000 - 30 000 BTU/h
(4,69 - 8,79 kWh)
Pression d’admission 1,1 - 3,8 po W.C.
(0,27 - 0,95 kPa)
2,9 - 11 po W.C.
(0,72 - 2,74 kPa)
Dimension de l’orice #35 DMS (2,79 mm dia.) #51 DMS (1,70 mm dia.)
Pression minimale d’alimentation pour le but
d’ajustement de contribution.
5 - 14,0 po W.C.
(1,2 - 3,5 kPa)
12,0 - 14,0 po W.C.
(2,9 - 3,5 kPa)
Réglage de l’air primaire du brûleur 1/16 po (1,6 mm) Ouvrir 100% Ouvrir
Elevation 0 - 4 500 pieds (0 - 1 372 m) 0 - 4 500 pieds (0 - 1 372 m)
Tension électrique 120 V, 60 Hz, Moins que 2 A.
P.4.1 Ecacité du foyer (FE) 70,21%
Ventilateur de remplacement Le ventilateur / l’ensemble RF-305-4224 doit être utilisé
Maintenir propres le brûleur et le compartiment
de commande. Voir les instructions relatives
à l’installation et au fonctionnement qui
accompagnent le radiateur.
Trousse de conversion de combustible
optionnel : Voir le manuel
Dégagement minimum des matériaux combustibles:
Encadrement aux côtés, dos et dessus, a partir des pièces d’écartement:
0 po (0 cm).
Du mur adjacent à l’ouverture du foyer: 7,25 po (18,42 cm).
Manteau: 8 po (20,32 cm) manteau à min 20,625 po (52,39 mm) a partir du
dessus de l’ouverture du foyer
Évacuation des tuyaux: 1 po (2,54 cm) en dessous et sur les côtés, au
dessus: 2 po (5,08 cm)
Plafond: 60 po (152,4 cm) de l’ouverture du foyer
Voir le manuel pour les dimensions et les dégagements supplémentaires
Il faut que cet appareil soit installé selon les codes locaux, s’il y en a; sinon, suivre le CSA-B149.1 actuel au Canada et ANSI
Z223.1 aux É.-U. Il faut que le raccordement électrique et la mise à la masse soient en conformité avec les codes locaux, s’il
y en a; sinon, suivre le CAN/CSA C22.1 actuel au Canada et ANSI/NFPA 70 aux É.-U. Cet appareil est certié pour l’installation
dans une chambre à coucher ou une pièce qui sert de chambre. Cet appareil doit être utilisé uniquement avec le type de gaz
indiqué sur la plaque signalétique. Cet appareil peut être installé dans une maison préfabriquée ou mobile (É.-U. seulement)
installée à demeure si les règlements locaux le permettent. Voir la notice de l’utilisateur pour plus de renseignements. Cet
appareil ne peut pas être utilisé avec d’’autres gaz sauf si une trousse de conversion certiée est fournie.
AVERTISSEMENT: Une installation, un réglage, une modication, une réparation ou un entretien mal eectué peut causer des
dommages atériels ou des blessures. Voir la notice de l’utilisateur qui accompgne l’appareil. Pour de l’aide
ou des renseignements supplémentaires, consultez un installateur, un technicien agréé ou le fournisseur
de gaz. Cet appareil doit être corectement raccordé à un système d’évacuation direct, conformément aux
instructions du fabricant.
AVERTISSEMENT : Risque de dommages ou de blessures si l’appareil n’est pas installé selon les instructions du fabricant ou
si des pièces autres que celles spéciquement approuvées avec cet appareil sont utilisées.
AVERTISSEMENT : Ne pas utiliser l’appareil tant que toutes les sections n’ont pas été assemblées et installées selon les
instructions du fabricant.
AVERTISSEMENT : Si cet appareil fonctionne sans être raccordé à un système d’évacuation correctement installé et entretenu,
ou si le système d’évacuation es modié, il peut en résulter un empoisonnement au monoxyde de carbone et
la mort.
SEULES DES PORTES CERTIFIÉES POUR CET APPAREIL DOIVENT ÊTRE UTILISÉES.
Utiliser uniquement avec l’écran no 37-BS. Suivre les instructions d’installation.
Fabrique au Canada par:
Archgard Industries Ltd.
7116 Beatty Dr., Mission, B.C.
février 2018 303-6180F-01
MODÈLE: 37-DVTE30LN-1 (SIT 885 Proame)
MANUFACTURE DATE: 2018 2019 2020 JAN FEB MAR APR MAY JUN JUL AUG SEP OCT NOV DEC
date de fabrication: 2018 2019 2020 jan fév mar avr mai jun jul août sep oct nov dec
7
Installation
5.0 Installation Checklist
This standard installation checklist is to be used by the installer in conjunction with, not instead of, the instructions contained
within this installation manual.
Customer: Date Installed:
Install Address: Location of Fireplace:
Installer:
Appliance Install: (Section 9.0) YES IF NO, WHY NOT?



Venting: (Section 10.0) YES IF NO, WHY NOT?


Maintained 1/4" rise for every 1 ft. on horizontal run.


Wiring / Electrical: (Section 7.0) YES IF NO, WHY NOT?


Gas: (Section 13.0) YES IF NO, WHY NOT?




Finishing (Section 12.0): YES IF NO, WHY NOT?



Appliance Setup: YES IF NO, WHY NOT?




Comments:
8
Installation
6.0 Appliance Overview
6.1 Appliance Overview
 






Section 6.6


plate.
Note:


Figure
6.1.01.
Figure 6.1.01:
6.2 Unpacking


Figure 6.2.01.



Section 6.3
Section 6.4
each screw. See Figure 6.2.02.
Figure 6.2.01: Figure 6.2.02:
 





Warning:


Figure 6.2.03:
9
Installation
6.3 Barrier Screen
37-BS
WARNING
DO NOT INSTALL THE BARRIER SCREEN WITH THE
GLASS DOOR REMOVED.
Removal



Figure 6.3.01: Screen retainer tabs
Figure 6.3.02:
Installation




Figure 6.3.05:
Figure 6.3.06:
Figure 6.3.04: Screen pin
10
Installation
6.4 Glass Door Installation
WARNING:



Figure 6.4.01: Figure 6.4.02:
Step 1: 

Step 2: 

Step 3: 

Step 4: 

Figure 6.4.03: Figure 6.4.04:
If Your Glass Breaks




Section 6.3

NOTE:




Warning:





11
Installation
6.5 Accessing The Controls
Figure 6.5.01: Figure 6.5.02:

1. Section 6.3
2. Figure 6.5.01.
3. 
Figure 6.5.02Figure 6.5.03.
4. Figure 6.5.04.


Figure 6.5.03: Figure 6.5.04:
 
 
Note:
12
Installation
6.6 Rating Plate Location



1. Section 6.3
2. Figure 6.5.01.
3. 
Figure 6.6.01.


Note:


Figure 6.6.01:
13
Installation
7.0 Electrical Connections
The 37-DVTE30LN-1

CAUTION:
NOTE:


• Section 6.3
• Section 6.4
• Section 6.5

Step 1:

Figure 7.0.01:
Step 2:

Figure 7.0.02:
Step 3: Step 4:

Figure 7.0.03: Figure 7.0.04:
14
Installation
8.0 Fireplace Dimensions
WARNING

Figure 8.0.01:
13.73cm
5.406in
34.44cm
13.560in
100.94cm
39.738in
93.23cm
36.703in
9.84cm
3.875in
17.46cm
6.875in
7.70cm
3.031in
5.87cm
2.310in
25.25cm
9.942in
1:16
SIZE
DWG. NO.
A
REV.
SHEET 3 OF 3
WEIGHT:
37DVTE30LN-1
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
RK
DATE
NAME
A
3/21/2018
37-DVTE30LN-1
PROPRIETARY AND CONFIDENTIAL
U:\ENGINEERING\PRODUCT\UNITS\GAS\DV FIREPLACE\37-DVTE30LN-1\37DVTE30LN-1
Wednesday, March 21, 2018 1:18:32 PM
SCALE
Left Side View
13.73cm
5.406in
34.44cm
13.560in
100.94cm
39.738in
93.23cm
36.703in
9.84cm
3.875in
17.46cm
6.875in
7.70cm
3.031in
5.87cm
2.310in
25.25cm
9.942in
1:16
SIZE
DWG. NO.
A
REV.
SHEET 3 OF 3
WEIGHT:
37DVTE30LN-1
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
RK
DATE
NAME
A
3/21/2018
37-DVTE30LN-1
PROPRIETARY AND CONFIDENTIAL
U:\ENGINEERING\PRODUCT\UNITS\GAS\DV FIREPLACE\37-DVTE30LN-1\37DVTE30LN-1
Wednesday, March 21, 2018 1:18:32 PM
SCALE
Right Side View
2.54cm
1.000in
121.35cm
47.776in
105.89cm
41.689in
83.82cm
33.000in
76.64cm
30.174in
54.39cm
21.413in
67.82cm
26.702in
48.89cm
19.247in
1.35cm
.531in
22.09cm
8.695in
47.44cm
18.676in
1:16
SIZE
DWG. NO.
A
REV.
SHEET 2 OF 3
WEIGHT:
37DVTE30LN-1
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
RK
DATE
NAME
A
3/21/2018
37-DVTE30LN-1
PROPRIETARY AND CONFIDENTIAL
U:\ENGINEERING\PRODUCT\UNITS\GAS\DV FIREPLACE\37-DVTE30LN-1\37DVTE30LN-1
Wednesday, March 21, 2018 1:18:32 PM
SCALE
Top View
Front View
2.54cm
1.000in
121.35cm
47.776in
105.89cm
41.689in
83.82cm
33.000in
76.64cm
30.174in
54.39cm
21.413in
67.82cm
26.702in
48.89cm
19.247in
1.35cm
.531in
22.09cm
8.695in
47.44cm
18.676in
1:16
SIZE
DWG. NO.
A
REV.
SHEET 2 OF 3
WEIGHT:
37DVTE30LN-1
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
RK
DATE
NAME
A
3/21/2018
37-DVTE30LN-1
PROPRIETARY AND CONFIDENTIAL
U:\ENGINEERING\PRODUCT\UNITS\GAS\DV FIREPLACE\37-DVTE30LN-1\37DVTE30LN-1
Wednesday, March 21, 2018 1:18:32 PM
SCALE
15
Installation
NOTE


1. 
2. 
3. 
4. 
5. 
6. 
7. 
8. 
9. Section 12
10. 
11. 
12. 
PLACEMENT CLEARANCE REQUIREMENTS
• 
• 

• Section 12
• 
• 
• 
9.1 Installation Overview
9.0 Prepare The Fireplace
9.2 Nailing Flange Installation
CAUTION
Always install nailing anges regardless of installation variances.
1:50
SIZE
DWG. NO.
A
REV.
SHEET 9 OF 10
WEIGHT:
41-DVT Framing
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\41-DVT Prototype\41-DVT Framing
Thursday, August 24, 2017 3:07:49 PM
SCALE
Wall Board Thickness
(Nailing Flange Setting)




Side Nailing Flanges






Figure 9.2.01
Figure 9.2.01:

Flange
O
O
O
O
16
Installation
Nailing Flange Extension
A
DETAIL A
SCALE 1 : 10
1:50
SIZE
DWG. NO.
A
REV.
SHEET 8 OF 10
WEIGHT:
41-DVT Framing
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\41-DVT Prototype\41-DVT Framing
Thursday, August 24, 2017 3:07:49 PM
SCALE

Figure 9.3.01:
F
G
VIEW F
SCALE 1 : 10
DETAIL G
SCALE 1 : 2
A A
B B
C C
D D
4
4
3
3
2
2
1
1
DO NOT SCALE DRAWING
41-DVT Framing
SHEET 12 OF 12
vn
UNLESS OTHERWISE SPECIFIED:
SCALE: 1:50
WEIGHT:
REV
DWG. NO.
C
SIZE
TITLE:
NAME
DATE
COMMENTS:
Q.A.
MFG APPR.
ENG APPR.
CHECKED
DRAWN
FINISH
MATERIAL
INTERPRET GEOMETRIC
TOLERANCING PER:
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
ANGULAR: MACH
BEND
TWO PLACE DECIMAL
THREE PLACE DECIMAL
APPLICATION
USED ON
NEXT ASSY
PROPRIETARY AND CONFIDENTIAL
THE INFORMATION CONTAINED IN THIS
DRAWING IS THE SOLE PROPERTY OF
<INSERT COMPANY NAME HERE>. ANY
REPRODUCTION IN PART OR AS A WHOLE
WITHOUT THE WRITTEN PERMISSION OF
<INSERT COMPANY NAME HERE> IS
PROHIBITED.
F
G
VIEW F
SCALE 1 : 10
DETAIL G
SCALE 1 : 2
A A
B B
C C
D D
4
4
3
3
2
2
1
1
DO NOT SCALE DRAWING
41-DVT Framing
SHEET 12 OF 12
vn
UNLESS OTHERWISE SPECIFIED:
SCALE: 1:50
WEIGHT:
REV
DWG. NO.
C
SIZE
TITLE:
NAME
DATE
COMMENTS:
Q.A.
MFG APPR.
ENG APPR.
CHECKED
DRAWN
FINISH
MATERIAL
INTERPRET GEOMETRIC
TOLERANCING PER:
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
ANGULAR: MACH
BEND
TWO PLACE DECIMAL
THREE PLACE DECIMAL
APPLICATION
USED ON
NEXT ASSY
PROPRIETARY AND CONFIDENTIAL
THE INFORMATION CONTAINED IN THIS
DRAWING IS THE SOLE PROPERTY OF
<INSERT COMPANY NAME HERE>. ANY
REPRODUCTION IN PART OR AS A WHOLE
WITHOUT THE WRITTEN PERMISSION OF
<INSERT COMPANY NAME HERE> IS
PROHIBITED.
Attaching The Nailing Flange Extension


Adjusting The Top Nailing Flange


tightening the tek screws again.
Figure 9.3.02:
Figure 9.3.03:
17
Installation
10.0 Venting Instructions
WARNING: Operation of this heater when not connected to a properly installed and maintained venting system can result
in carbon monoxide (CO) poisoning and possible death. The appliance must not be connected to a chimney ue serving a
separate solid fuel burning appliance.
WARNING







in the vent run.

IF INSTALLING FLEX PIPE SYSTEMS:
• 
• 
• 



See Section 10.3.
Figure 10.0.01:



wall.
18
Installation
Figure 10.0.02:
Figure 10.0.03: Firestop Framing Figure 10.0.04: Flashing Installation
Typical Venting Conguration

Attic





 

Flashing
Combination to Rooine
Flex
Venting

Venting

Attic







Flashing

Flex to Rooine
Flex
Venting
 

Flashing



Rigid to Rooine

Attic



Venting
19
Installation
10.1 Vent Run Guide
Horizontal Vent Sections rise 1/4"/ft (21mm/m)



















1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:20
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
DVA 48in Pipe
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\DVA 48in Pipe
Thursday, August 24, 2017 9:05:20 AM
SCALE
1:50
SIZE
DWG. NO.
A
REV.
SHEET 10 OF 10
WEIGHT:
41-DVT Framing
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/24/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\41-DVT Prototype\41-DVT Framing
Thursday, August 24, 2017 10:16:52 AM
SCALE
































NOT ALLOWED
Restrictor open
Restrictor closed


• 

• 

• 
• See Section 10.5
1:5
SIZE
DWG. NO.
A
REV.
SHEET 1 OF 1
WEIGHT:
46DVA-VCH
FINISH
MATERIAL
DIMENSIONS ARE IN INCHES
TOLERANCES:
FRACTIONAL
1/32"
TWO PLACE DECIMAL
.015"
THREE PLACE DECIMAL
.005"
ALL BENDS ARE ASSUMED
TO BE 90
UNLESS NOTED
OTHERWISE.
CHECKED
DRAWN
DATE
NAME
8/25/2017
PROPRIETARY AND CONFIDENTIAL
U:\R&D\Prototype CADD\Duravent Pipe\46DVA-VCH
Friday, August 25, 2017 8:46:07 AM
SCALE
Figure 10.1.01:
0" - 11.9" vertical, one 90⁰ elbow can
be used.
1' - 1'11.9" vertical, two 90⁰ elbows
can be used.
2' - 2'11.9" vertical, three 90⁰ elbows
can be used.
3' vertical and above, four 90⁰ elbows
can be used.
20
Installation
Section 10.1



Before installation:
• Disconnect gas and electrical supply to the replace (including backup batteries)
• Section 6.3
• Section 6.4
10.2 Vent Restrictor
Step 1:Step 2:
Figure 10.2.01: Figure 10.2.02:
Step 3:

Figure 10.2.03:
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
/