American Hearth DVCT50CBP Owner's manual

Brand: American Hearth

Model: DVCT50CBP

Category: Fireplaces

Type: Owner's manual

This manual is also suitable for

Page 1

INSTALLER:

Leave this manual with the appliance.

CONSUMER:

Retain this manual for future reference.

WARNING

FIRE OR EXPLOSION HAZARD

Failure to follow safety warnings exactly

could result in serious injury, death, or

property damage.

— Do not store or use gasoline or other

ammable vapors and liquids in the

vicinity of this or any other appliance.

— WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch;

do not use any phone in your building.

• Leave the building immediately.

• Immediately call your gas supplier

from a neighbor’s phone. Follow

the gas supplier’s instructions.

• If you cannot reach your gas

supplier, call the re department.

— Installation and service must be

performed by a qualied installer,

service agency or the gas supplier.

This appliance may be installed in an

aftermarket, permanently located,

manufactured home (USA only) or mobile

home, where not prohibited by local codes.

This appliance is only for use with the type

of gas indicated on the rating plate. This

appliance is not convertible for use with

other gases, unless a certied kit is used.























GAS-FIRED



HOT GLASS

DO NOT TOUCH

NEVER

WILL

CAUSE BURNS.

GLASS

UNTIL COOLED.

ALLOW CHILDREN

TO TOUCH GLASS.

DANGER

A barrier designed to reduce the risk of burns from the

hot viewing glass is provided with this appliance and shall

be installed for the protection of children and other at-risk

individuals.

(SEE HOMEOWNER MANUAL FOR OPERATING INSTRUCTIONS)

DIRECT VENT ZERO

CLEARANCE GAS FIREPLACE

HEATER MODEL SERIES:

DVCT50CBP95(N,P)-1

INSTALLATION INSTRUCTIONS

38267-3-0220

TABLE OF CONTENTS



4-5

6

7

7





9





 

15

16

16

17

 

 





 



 



















44

44

45-46

47

 

SECTION PAGE

38267-3-0220 

ATTENTION INSTALLER:

Follow This Standard Work Checklist

This standard work checklist is to be used by the installer in conjunction with, not instead of, the instruction manual.

Customer: _____________________________________

Lot/Address: ___________________________________

_______________________________________________

Model: ________________________________________

Serial # ________________________________________

Date Installed: _________________________________

Fireplace Location: _____________________________

Installer: ______________________________________

Dealer Phone #: ________________________________

______________________________________________

Empire recommends the following:

• 

• 

Comments: 

___________________________________________________________________________________________________________

 _____________________ _____________________  ______________________

DVCT50CBP95(N,P)-1

FIREPLACE INSTALLATION COMMENTS

 o ____________________

 o ____________________

VENTING / CHIMNEY

 o ____________________

 o ____________________

 o ____________________

 o ____________________

 o ____________________

 o ____________________

ELECTRICAL (pgs. 16-17)

 o

____________________

GAS (pg. 15)

 o

____________________

 oYes oNo

 o ____________________

FINISHING ( pg. 19)

 o ____________________

 o ____________________

 o ____________________





o ____________________

 o ____________________

FIREPLACE SETUP

 o ____________________

 o ____________________

 o ____________________

 o ____________________





o ____________________

 o ____________________

38267-3-0220Page 4

BEFORE YOU START

Television Considerations









         











Samples, Warnings, and Denitions:

DANGER

Indicates a hazardous situation which, if not avoided, will

result in death or serious injury.

WARNING

Indicates a hazardous situation which, if not avoided,

could result in death or serious injury.

CAUTION

Indicates a hazardous situation which, if not avoided,

could result in minor or moderate injury.

NOTICE: 

Read all instructions before starting installation and

follow them carefully to ensure safety. Failure to follow

the instructions will void the warranty and may cause

a re hazard.





• 

• 

• 

• 



• 

• 





         

(Page 7).

Unpacking The Fireplace

 

 



 

 

 



 





38267-3-0220 Page 5

BEFORE YOU START (CONT’D)

Accessories











TrueFlame Technology



        









Preparation

         









• 

• 

• 

• 

• 

• 

• 

• 

 

 

 

•  

        





• 



         





Planning the installation

         





• 

(See Pages 28-31)







•   

(Page 15)

• 

 

• 

 (Page 18)

•         



      

  (See Page 19)



38267-3-0220Page 6

CARTON CONTENTS

INDEX

NUMBER

DESCRIPTION

QUANTITY

SUPPLIED

1  1

  

  4

4  

5  5



7  1

  1





CARTON CONTENTS AND HARDWARE

Rock

wool

Rock

wool





NOTICE:

38267-3-0220 Page 7

INTRODUCTION





Instructions to Installer

 

 



 

Notes to Installer

• 

 



 

• 











• 







• 

• 



WARNING

Any change to this replace can be dangerous. Improper

installation or use can cause serious injury or death from re,

burns, explosion or carbon monoxide poisoning.

Fireplace Certication























Qualied Installing Agency





“

”



















High Altitude (USA)

















High Altitude (CANADA)











HOMEOWNER REFERENCE INFORMATION



 _____________________________   ________________________

 _____________________________   _____________________

 ______________________________   _________________________

 ______________________________________________________________________________

38267-3-0220

SPECIFICATIONS

MODEL NUMBER DVCT50NAT DVCT50LP

  

  

  

  

  

  

  

  

  

  

 56 56

  

  

NOTE: 

GAS SUPPLY PRESSURES (inches water column)

Gas Type Maximum Minimum Manifold

 14  

 14  

VENTING LIGHT BULB REPLACEMENT

 

ACCESSORIES





MODEL NUMBER DESCRIPTION

DVP50P...





 

 

 

 

 

 

 





































 

Model

Number

CONVERSION KITS

Description

 

 

LOG SETS

Model

Number

Description

 

NOTE: A liner kit and log set must be purchased and installed in order to operate

the unit.

38267-3-0220 Page 9

FIREPLACE DIMENSIONS

INDEX LETTER DIMENSION DESCRIPTION DIMENSION IN INCHES

  

B  

  

  

  51

 



  

H  

  

J  

K  

L  

  

  

  

P  14

Q  

  



Figure 1

38267-3-0220

BLOWER INSTALLATION

Bench Installation

  See Figure 2.

Figure 2

 See Figure 3.

Figure 3

  Figure 4 

 

HAND BEND

TAB INWARD

HAND BEND

TAB INWARD

Figure 4

 





See Figure 5.

TO WIRE ASSEMBLY

(MODULE)

TO WIRE ASSEMBLY

(MODULE)

Figure 5





See Figure 1.

Installation After Placement of Unit in Wall

 See Figure 6.

 (See Homeowner’s Manual, Maintenance

and Service).

 (See Homeowner’s Manual,

Maintenance and Service).

 (See separate liner instruction document).

Figure 6

 See Figure 7.

Figure 7

CAUTION

Sharp edges. Use protective gloves when installing.

38267-3-0220 Page 11

BLOWER INSTALLATION (CONT’D)

  See Figure 8.

Figure 8

 See

Figure 9.

Figure 9

 See Figure 10.



Figure 10

  Figure 11 

HAND BEND

TAB INWARD

HAND BEND

TAB INWARD

Figure 11

 

 

  

 See Figure 12.

TO WIRE ASSEMBLY

(MODULE)

TO WIRE ASSEMBLY

(MODULE)

Figure 12

 

See Figure 13.

Figure 13

 

Figure 6.

38267-3-0220

Mantel Chart

COMBUSTIBLES

ALLOWED

WALL

STUD

FIREBOX FACE

CEILING

FLOOR

OPENING OF

FIREPLACE

35”

MIN.

22”

MIN.

12”

MIN.

10”

WALL

FACING

Index

Letter

Distance From

Wall Facing

Distance From Top

of Opening

Dimensions in inches

  

B 4 

 6 

  17

  

  

Figure 16

Clearances





▼

6” (152 mm)

FIREPLACE

OPENING

35” (889mm)

FIREPLACE

OPENING

Figure 17

CLEARANCES

Clearance to Combustibles

Dimension in inches

 

 

 





 

FINISHED WALL

(COMBUSTIBLE)

NONCOMBUSTIBLE

BOARD INSTALLED

OVER APPLIANCE

SEE MANTEL CHART

FOR MAXIMUM

MANTEL DEPTH

FRAMING HEADER

FINISHED WITH

NONCOMBUSTIBLE

MATERIAL AS

DESIRED

REFER TO

MANTEL CHART

BARRIER SCREEN

AND GLASS FRONT

NAILING

FLANGES

Figure 14

NOTICE: 



MAX.

PERPENDICULAR

SIDE WALL

FRONT

FACE

(SIDE)

COMBUSTIBLE MATERIALS

ALLOWED IN SHADED AREAS

FIREPLACE

(TOP VIEW)

2”

Figure 15

38267-3-0220 



Vertical Sidewall Installations

Important!





Important!    







Information on Various Venting Routes and Components

Important:







         



Figure 18



      









ATTENTION: Vinyl Soft, Vinyl Ceiling, Vinyl Overhang

Disclaimer









VENT TERMINATION CLEARANCES

38267-3-0220Page 14

VENT TERMINATION CLEARANCES (CONT’D)

   







 





 























-

























-



 

-









-



-







 











 

-



 







 





 1





  















-



 





ATTENTION: Vinyl Soft, Vinyl Ceiling, Vinyl Overhang

Disclaimer









-













38267-3-0220 Page 15

GAS SUPPLY





See Figures 18 and

19.



CAUTION

Never use plastic pipe. Check to conrm whether your local

codes allow copper or galvanized tubing.

NOTICE:





 



 









Figure 19

Installing the Main Gas Shut-Off























WARNING

Never use an exposed ame to check for leaks. Fireplace

must be disconnected from piping at inlet of control valve and

pipe capped or plugged for pressure test. Never pressure test

with replace connected; control valve will sustain damage.

NOTICE: 























WARNING

If one of the procedures results in pressures in excess of

1/2 psig (14 inches w.c.) (3.5 kPa) on the replace gas valve,

it will result in a hazardous condition.

19 3/4”

12 1/4”

FRONT OF

FIREPLACE

GAS FLEX LINE WITH

SHUT-OFF VALVE

(PROVIDED)

Figure 20







See Figure 21. 





GAS SUPPLY PLUMBING

MANUAL

SHUT-OFF VALVE

GAS SUPPL

INLET

DRIP LEG

3” MINIMUM

CONTROL

VALVE

Figure 21

38267-3-0220Page 16

NOTICE:   



   



LOCATING FIREPLACE

CORNER

INSTALLATION

ANGLED CORNER

INSTALLATION

ISLAND

INSTALLATION

CABINET

INSTALLATION

FLUSH WALL

INSTALLATION

ROOM DIVIDER

INSTALLATION

ELECTRICAL CONSIDERATIONS

Junction Box











See Figure 23.

Interface/Battery Holder









NOTICE:

  



NOTICE:           



BLACK (HOT)

JUNCTION BOX

WHITE (NEUTRAL)

GROUND TO JUNCTION BOX

120 VOLT POWER SUPPLY

JUNCTION BOX CONNECTIONS

Figure 23

CAUTION

All wiring should be done by a qualied electrician and shall be in compliance with all local, city and state building codes.

Before making the electrical connection, make sure that the main power supply is disconnected. The appliance, when installed,

must be electrically grounded in accordance with local codes, or in the absence of local codes, with the National Electrical

Code ANSI/NFPA 70 (Latest Edition).

VERTICALL

FRAMING

MEMBER

USER INTERFACE

HARNESS

COMPONENT

ACCESS BOX

ELECTRICAL POWER TO UNIT

JUNCTION BOX / CONTROL MODULE

USER INTERFACE/BATTERY HOLDER MUST BE INSTALLED INTO WALL

JUNCTION BOX (ORANGE LOW-VOLTAGE BOX RECOMMENDED)

Figure 22

NOTICE:

     

     







  



    







Figure 24

38267-3-0220 Page 17

Figure 25

COMPONENT WIRING DIAGRAM

IF ANY OF THE ORIGINAL WIRE AS SUPPLIED

WITH THIS UNIT MUST BE REPLACED, IT MUST

BE REPLACED WITH EQUI

ALENT GAUGE AND

TEMPERATURE RATED WIRE.

SI LE FIL ORIGINAL L'UN DES COMME FOURNI

AVEC CETTE UNITÉ DOI

ÊTRE REMPLACÉ, IL

DOIT REPLCED AVEC LA MESURE ÉQUIVALENTE

ET LE FIL ÉVALUÉ PAR TEMPÉRATURE.

ORANGE

PILOT

GAS CONTROL VALVE

ORANGE

GREEN

YELLOW

WHITE

BLACK

WHITE

BLOWER

FUSE

BLACK

WHITE

GREEN

TO JUNCTION

BOX

LOOP

TO LIGHTS

SPLIT FLOW SOLENOID

SLEEVE

USER INTERFACE/

BATTERY HOLDER

INDEX NUMBER DESCRIPTION PART NUMBER

  

B  

  

  

  



Figure 26



Figure 27

38267-3-0220

INSTALLATION

INSTALLATION TABLE - MINIMUM DIMENSIONS (in inches)

MODEL A B C D E F

      

Rough Opening for Floor Level Installation

Figure 28

Rough Opening for Installing in Corner

Figure 29



 

 

 







NOTICE:



Framing Information







 INSTALLATION TABLE

 

CAUTION

Before construction begins, measure replace dimensions

and verify framing methods and wall covering details.

38267-3-0220 Page 19

INSTALLATION (CONT’D)

NAILING FLANGES

FLUSH WALL INSTALLATION

NONCOMBUSTIBLE

BOARD INSTALLED

OVER APPLIANCE

FINISHED

WALL

NAILING

FLANGES

SECURED

IN PLACE

FOR 1/2”DRYWALL

FOR 5/8”DRYWALL

FINISHED

WALL

NONCOMBUSTIBLE

BOARD INSTALLED

OVER APPLIANCE

FRAMING

HEADER

11”

Figure 30 Figure 31

Figure 32 Figure 33

WARNING

When nishing the replace never obstruct or modify the

gap around the glass frame in any manner. Provide adequate

clearances around air openings into the combustion chamber.

CAUTION

If the joints between the nished wall and the replace surround

(top and sides) are sealed, a 300°F minimum sealant material

must be used. These joints are not required to be sealed. Only

non-combustible material (using 300°F minimum adhesive if

needed) can be applied as facing to the replace surround.

11"

38267-3-0220

INSTALLATION (CONT’D)

Horizontal Vent Clearance





See Figure 35.

Vertical Vent Clearance





NOTICE:

See Figure 34.





See Figures 34 and 35.

VENT PIPE

1” MINIMUM CLEARANCE

AROUND VENT PIPE

Figure 34

TOP OF VENT

COMBUSTIBLES NOT

ALLOWED IN SHADED

AREA

3” (76 mm)

8” DIAMETER

INTAKE VENT

1” (25 mm)

5” DIAMETER FLUE

1” (25 mm)

Horizontal Vent Clearances - Figure 35

ATTENTION:



        









Vent Runs

        







 

 

 





Page is loading ...

American Hearth DVCT50CBP Owner's manual

Brand: American Hearth

Model: DVCT50CBP

Category: Fireplaces

Type: Owner's manual

This manual is also suitable for

Download PDF

report

American Hearth DVCT50CBP Owner's manual

This manual is also suitable for

American Hearth DVCT50CBP Owner's manual

Related papers

Other documents